15-PIN CONNECTOR

15/1 TRANS NEUTRAL Sw

15/2 DUAL SPEED AXLE
15/3 VSS + POWER WIRING GOVERNOR CRUISE CONTROL
15/4 VSS - CAVITY LABEL CAVITY DASH PANEL
THROTTLE PEDAL
15/5 NOT USED 21/1 BATTERY (+) CRUISE
CAVITY LABEL ENABLE
15/6 NOT USED 16/5 BATTERY (+) 20 AMP 18/6 SWITCH OFF
ON
15/7 ENGINE COOLANT LEVEL SENSOR BATTERY (+) 21/19 SENSOR SUPPLY AUTOMOTIVE
16/6 BATTERY (+) RESUME/ACCEL
15/8 NOT USED 21/11 ALSG LIMITING 18/5 SWITCH ON
OFF
15/9 AGS2 BACKUP LAMP OUTPUT/COOLANT LEVEL LOW LAMP SPEED
21/3 BATTERY (-) 21/14 SENSOR RETURN
GOVERNOR SET/COAST OFF
15/10 GRID HEATER 16/9 BATTERY (-)
18/4 SWITCH ON
15/11 OI ACTIVE LAMP BATTERY (-)
16/11 BATTERY (-) SERVICE BRAKE
15/12 STARTER LOCKOUT / OI ALARM 21/12 IVS #2
IDLE 21/15 SWITCH
IGNITION ON
15/13 MBE PROPRIETARY CAN (+) FUSE
21/13 IVS #1 VALIDATION CLUTCH OFF
15/14 MBE PROPRIETARY CAN SHIELD 16/15 SWITCHED 18/3 IVS GND (REQUIRED) 18/2 SWITCH
ON
15/15 MBE PROPRIETARY CAN (-) 21/2
IGNITION OFF
21/3 GND

18-PIN CONNECTOR MUST PROVIDE IGNITION POWER VEHICLE SPEED SENSOR

IN RUN AND CRANK MODES. 18/17 SENSOR SUPPLY VARIABLE
C 15/3 SIGNAL
18/1 VEHICLE POWER SHUTDOWN DO NOT SOURCE ANY NON-DDEC
SPEED
ACCESSORY FROM IGN CIRCUIT 18/18 VSG
18/2 CLUTCH SWITCH 1 B
GOVERNOR 15/4
21/14 SENSOR RETURN
18/3 IDLE VALIDATION GROUND A (OPTIONAL) RETURN
18/4 CRUISE CONTROL, SET/COAST
18/5 CRUISE CONTROL, RES/ACCEL 18/10 REMOTE VSG SWITCH
18/6 CRUISE CONTROL, ON/OFF REMOTE ACCELERATOR
18/7 SELECT SWITCH
18/7 REMOTE ACCELERATOR SELECT SWITCH
18/8 ENGINE BRAKE LOW 21/3 GROUND
18/9 ENGINE BRAKE HIGH
18/10 REMOTE PTO SWITCH
18/11 LIMITER 0
18/12 LIMITER 1 OEM CONNECTION TO PLD (16-PIN) INSTRUMENT PANEL ENGINE COOLANT LEVEL SENSOR - SHUTDOWN CONNECTIONS TO ENGINE HARNESS (55-PIN)
18/13 ENGINE SHUTDOWN OVERRIDE CAVITY LABEL CAVITY LABEL CAVITY LABEL
18/14 AIR CONDITION STATUS RED STOP LAMP COOLANT
15/13 CAN (HIGH) 1 16/1 15/7 COOLANT LEVEL
18/15 FAN OVERRIDE A LEVEL PIN NO COLOR
21/5 RSL
18/16 THROTTLE INHIBIT 15/15 CAN (LOW) 16/2 IGN 21/3 GND SENSOR SINGLE
2 B 55/12 BRN/RED 1
18/17 REMOTE THROTTLE +5V SUPPLY SHUTDOWN SPEED
15/14 CAN SHIELD 3 16/3
18/18 REMOTE THROTTLE SIGNAL AMBER WARNING LAMP 2 FAN
NOT USED 4 16/4 21/6 AWL CONTROL
IGN 55/43 & 55/41 BLK/WHT (OEM RESPONSIBILITY
3
12-PIN CONNECTOR BATTERY (+) 5 16/5 & RED TO WIRE FAN TO
12/6 TACH OUTPUT PIGTAIL)
12/1 ENGINE START BATTERY (+) 6 16/6
12/2 NOT USED
NOT USED 7 16/7 ENGINE BRAKE SWITCHES
12/3 OIL PRESSURE GAUGE/WARNING LAMP/FRS
12/4 OI THERMOSTAT/AGS2 CHECK TRANS LIGHT NOT USED 8 16/8 18/8 ENG. BRAKE LOW
12/5 AGS2 TRANS TEMP LIGHT BATTERY GND
DIAGNOSTIC CONNECTOR
9 16/9
ENG. BRAKE MED
12/6 TACH OUT 18/9
NOT USED CAVITY DDC CONNECTOR LABEL
12/7 NOT USED 10 16/10
12/8 OI HOOD TILT SWITCH 21/3 GND - A GND
BATTERY GND 11 16/11 - B +12/24 V
12/9 NOT USED 21/19 C J1939 DATA LINK (+)
NOT USED 12 16/12 STOP ENGINE OVERRIDE
12/10 NOT USED 21/21 D J1939 DATA LINK (-)
12/11 ENGINE STOP NOT USED 13 16/13 ENGINE SHUTDOWN 21/20 E J1939 SHIELD
18/13 OVERRIDE 21/17 F J1587 DATA LINK (+)
12/12 NOT USED NOT USED 21/18 G J1587 DATA LINK (-)
14 16/14
- H PLUG
SEO SWITCH
IGNITION 21/3 GND - J PLUG
21-PIN CONNECTOR 15 16/15

21/1 BATTERY VOLTAGE NOT USED 16 16/16

FAN CONTROL CONNECTOR CAVITY PLUG
21/2 IGNITION (+12V) DEUTSCH P/N: HD10-9-1939P DEUTSCH P/N: 114017
21/3 BATTERY GROUND 18/14 A/C STATUS
DDC P/N: 23529496 DDC P/N: 23507136
21/4 NOT USED TERMINAL CONNECTOR COVER
21/5 RED STOP LAMP 18/15 FAN CTRL OVERRIDE DEUTSCH P/N: 0460-202-16141 DEUTSCH P/N: HDC16-9
21/6 AMBER WARNING LAMP DDC P/N: 23507132 DDC P/N: 23529497

21/7 WAIT TO START LAMP 21/3 GND

21/8 NOT USED
21/9 THROTTLE PEDAL POWER +5V SUPPLY
21/10 PLUG (NOT USED, MUST BE PLUGGED)
PARKING BRAKE & VEHICLE POWER SHUTDOWN
21/11 THROTTLE PEDAL SIGNAL
21/12 VALIDATION 2 (THROTTLE ACTIVE) 21/16 PARK BRAKE
21/13 IDLE VALIDATION 1 (IDLE ACTIVE)
21/14 THROTTLE PEDAL SENSOR RETURN 21/3 GND
21/15 SERVICE BRAKE SWITCH
21/16 PARK BRAKE SWITCH VEHICLE POWER
21/17 SAE J1587 (+) 18/2 SHUTDOWN
IGN
21/18 SAE J1587 (-)
21/19
21/20
21/21
SAE J1939 (+)
J1939 SHIELD
SAE J1939 (-)
DDEC FOR MBE (MBE 900/4000)
All information subject to change without notice. (Rev. 09/05)
7SA825 0509 Copyright 2005 DETROIT DIESEL CORPORATION VEHICLE INTERFACE HARNESS 45297