Wire Description Component Identifiers (CID¹) Failure Mode Identifiers (FMI)¹ Monitoring System Service Modes

Wire Wire Wire Wire Module Identifier (MID²) Machine Codes FMI No. Failure Description Service Mode Number
Number Color Description Number Color Description RENR2092
Caterpillar Monitoring System Machine Code 0 Data valid but above normal operational range. Operator Mode Sequence 0
Power Circuits Control Circuits
(MID No. 030) D7R 35 1 Data valid but below normal operational range. Harness Code 1
November 2001
101 RD Battery (+) 709 OR Sensor Power Supply
CID Component 2 Data erratic, intermittent, or incorrect.
Numeric Readout 2 Electrical Schematic Symbols And Definitions
102 RD Engine Control Power 751 GN XMSN Reverse Clutch 0096 Fuel Level Sender 3 Voltage above normal or shorted high.
Service 3
103 RD Rear Flood Power 752 YL XMSN Forward Clutch 0248 Data Link 4 Voltage below normal or shorted low.
Digital Tattletale 4
0263 Sensor Power Supply 5 Current below normal or open circuit.
104 YL Aux Ckt 754 BU XMSN Third Gear Clutch
0271 Action Alarm 6 Current above normal or grounded circuit. Units (US/SI) 5
105 RD Key Switch Power 755 OR XMSN Second Gear Clutch
0324 Action Lamp Related Electrical Service Manuals 7 Mechanical system not responding properly. Calibration 1 (Transmission Control) 6
106 PU Product Link A700 OR Engine Control Digital Sensor Power (+8V)
0600 Hydraulic Oil Temperature Sensor Title Form Number 8 Abnormal frequency, pulse width, or period. Calibration 2 (Transmission Control) 7
108 BU Wipers A701 GY Injector #1 0819 Display Data Link 9 Abnormal update.
21 SI Alternator: 132-2156 (70A) SENR4757 Calibration 3 (Transmission Control) 8
109 RD Alternator Breaker A702 PU Injector #2 0821 Display Power Supply 10 Abnormal rate of change. T
42MT Electric Starting Motor: 6V-5227 SENR3581 Charging System Display 9
110 GN Aux Ckt A703 BR Injector #3 826 Torque Converter Oil Temperature Sensor 11 Failure mode not identifiable.
Engine Electronic Control Module Engine Control: SENR5003 12 Bad device or component.
Monitoring System Operator Modes Pressure Temperature Level Flow
111 YL Aux Ckt A704 GN Injector #4
(MID No. 036) Drive Train Control: SENR8367 13 Out of calibration. Operator Mode Number Symbol Symbol Symbol Symbol
112 PU Main Power Relay Output A705 BU Injector #5
Caterpillar Monitoring System: SENR2014 14 Parameter failures. Service Meter 1
113 OR Monitor Panel Power A706 GY Injector #6 CID Component
0001 Injector Cylinder 1 Starting and Charging: SENR2947 15 Parameter failures. Tachometer 2
114 RD Forward Horn Power A745 WH Fuel Pressure 16 Parameter not available.
0002 Injector Cylinder 2 Odometer 3
115 RD Front Flood Power A746 PK Turbo Outlet Pressure 0003 Injector Cylinder 3 17 Module not responding.
Scrolling (Diagnostic) 4
18 Sensor supply fault.
116 BR Fender Flood Power A747 GY Atmospheric Pressure 0004 Injector Cylinder 4 Event Codes
124 GN A/C and Blower Power A751 YL Fuel Temperature 0005 Injector Cylinder 5 19 Condition not met.
Number Event Description
0006 Injector Cylinder 6 20 Parameter failures.
130 GN Auxiliary Power D786 BR Engine Retarder Sol Cyl 1, 2, 5 , 6 E017 High Engine Coolant Temperature Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
0041 8 Volt DC Supply 1
The FMI is a diagnostic code that indicates what type of failure has occurred.
140 BU Powertrain Control Power D787 GN Engine Retarder Sol 3, 4 E025 High Inlet Air Temperature
0091 Throttle Switch
150 RD Engine Control Power D788 BK Engine Retarder Sol Common 0110 Engine Oil Pressure E027 High Intake Air Temperature
158 BR Remote A/C Condenser Power D789 WH Injector Common 1 & 2 0168 System Voltage E035 Loss Of Coolant Flow Warning Normally open switch that is closed due to an applied condition, and will open again with a
160 RD Winch Power D790 OR Injector Common 3 & 4 0172 Intake Manifold Air Temp
0174 Fuel Temperature
E039 Low Engine Oil Pressure specific decrease in that condition.
176 YL Seat Power D791 YL Injector Common 5 & 6 E100 Low Engine Oil Pressure
0190 Engine Speed Signal
184 BU Aux Ckt E707 GN Display +V E190 Engine Overspeed
0253 Personality Module
186 RD Power Outlet Power E708 PK SPI Clock 0261 Engine Timing E265 User Defined Shutdown
Normally closed switch that will open with an increase of a specific condition.
D7R Series II Track-Type Tractor
197 GN Aux Ckt E735 PU Cat Mon Sys Operator Switch 0262 5 Volt Sensor Supply E272 Inlet Air Restriction
198 RD Secondary Brake Power E793 BU ATA Datalink - 0264 Decel Throttle Position Signal
E794 YL ATA Datalink + 0266 Crank Without Inject Inputs
Ground Circuits

Differential Steer
0268 Check Programmable Paramaters
200 BK Main Chassis Ground E799 BR Solenoid Return Connector Location
201 BK Operator Monitor Return F700 BU Demand Fan Actuator
0273 Turbo Outlet Pressure
Machine
Normally closed switch that is open due to an applied condition, and will close again
0274 Atmospheric Pressure Connector Number Schematic Location
202 BK XMSN Ctrl F701 BR Retarder Solenoid Location with a specific decrease in that condition.

Electrical System
0275 Right Turbo Inlet Pressure
207 BK Starter Ground Diagnostic F702 GN Decelerator Pedal 0291 Engine Cooling Fan Solenoid CONN 1 G-15 C
0296 Transmission ECM CONN 2 C-14 16
229 BK Engine Control Ground F704 OR Use Shutdown
0342 Secondary Engine Speed Signal CONN 3 C-14 16
270 BK Cat Mon Sys Ident Code 0 F708 YL Flexxaire Fan Pull Solenoid
0544 Engine Cooling Fan Speed Signal CONN 4 C-14 16 The circle indicates that the component has screw terminals and a wire can be disconnected
271 BK Cat Mon Sys Ident Code 1 F710 BR Start Aid Relay
0545 Ether Start Relay CONN 5 A-14, B-15, E-15 27 from it.
272 BK Cat Mon Sys Ident Code 2 F713 OR Unused 0799 Need Service Tool Update CONN 6 B-14, C-15, E-14 26
273 BK Cat Mon Sys Ident Code 3 F714 PK Turbo Inlet Pressure 1599 Engine Fan Pull Solenoid CONN 7 F-14 25 AEC1-UP
274 BK Cat Mon Sys Ident Code 4 F715 PU Throttle Switch (Low Idle) 1600 Engine Fan Push Solenoid
Power Train Control System
CONN 8
CONN 9
F-14
A-13
24
29
AGN1-UP
275
276
BK
BK
Cat Mon Sys Ident Code 5
XMSN Ctrl Indent Code 0
F716
F717
WH
YL
Throttle Switch (Low Idle Parity)
Throttle Switch (High Idle) (MID No. 113) CONN 10 C-13 30
Component Location ABJ1-UP No circle indicates that the wire cannot be disconnected from the component.
CONN 11 D-13 30 Component Component
277 BK XMSN Ctrl Indent Code 1 F718 BU Throttle Switch (High Idle Parity) CID Component
0070 Parking Brake Switch CONN 12 D-13 16
10A Converter F-7 32 Relay - Start Aid I-2 8
278 BK XMSN Ctrl Indent Code 2 F719 BR Crank w/o Inject (N.O.) CONN 13 E-13 16
0168 Electrical System Voltage 22 38
12V Battery I-10 Relay - Main H-9
279 BK XMSN Ctrl Indent Code 3 F720 GN Crank w/o Inject (N.C.) 0177 Transmission Oil Temperature Sensor CONN 14 Datalink Service E-13 23
CONN 15 Monitor Service E-13 23 12V Battery #2 I-10 22 Relay - Prelube I-4 8
280 BK XMSN Ctrl Indent Code 4 F721 GY Start Aid Switch 0190 Engine Speed Sensor
290 BK Cat Mon Sys Service F723 PK TDC Probe + 0248 CAT Data Link CONN 16 H-13 31 12V Outlet F-13 23 Relay - Start H-9 38 This indicates that the component has a wire connected to it that is connected to ground.
0254 Electronic Control Module CONN 17 I-13 31 12V Outlet #2 F-13 23 Resistor D-9 A
291 Bk Cat Mon Clear F724 PU TDC Probe -
0269 Sensor Power Supply CONN 18 I-13 33 20A Converter 24V - 12V F-8 32 Resistor - Blower E-10 A
Basic Machine Circuits F732 PK Backup Camshaft Speed/Timing
0298 Service Brake Pedal Switch CONN 19 A-12 29
Accessory Power Connector (Switched) E-7 38 Resistor - Starter I-3 1
301 BU Starter No. 1 Solenoid F780 PK Parking Brake SW 0299 Transmission Lever Position Sensor CONN 20 A-12 B
Accessory Power Connector (Unswitched) F-7 38 Seat Suspension Motor & Switches F-12 9
302 OR Starter No. 1 Resistor to Diagnostic F781 BR Downshift SW (N.O.) 0368 Autoshift Switch CONN 21 B-12 A
A C
This indicates that the component does not have a wire connected to ground. It is grounded
0468 Service Brake Pedal Position Sensor CONN 22 D-12 34 Alarm - Action C-10 Sender - Direction H-15
304 WH Starter Relay No. 1 Output F782 OR Reverse SW (N.O.)
0490 Implement Lockout Switch Alarm - Backup C-14 15 Sender - Fuel Level D-14 26
by being fastened to the machine.
306 GN Starter Relay Coil to Neutral Start SW or Key SW F783 GN Upshift SW (N.O.) CONN 23 H-12, G-12, F-12 32
0618 Parking Brake Switch - Brake Backup CONN 24 H-12 20 Alternator I-2 11 Sensor - ATM Pressure E-1 37
307 OR Key Switch to Neutral Start Switch F784 YL Downshift SW (N.C.)
0621 Downshift Switch CONN 25 I-12 31 Aux Start I-9 14 Sensor - Backup Speed Timing G-1 4
308 YL Main Power Relay Coil F785 WH Upshift SW (N.C.) 0622 Upshift Switch CONN 26 A-11 B 38 35
Block Assy G-7 Sensor - Brake Postion B-9
310 PU Start Aid Switch to Start Aid Solenoid F786 GY Reverse SW (N.C.) 0623 Direction Switch CONN 27 D-10 A
Breaker - Alternator H-9 38 Sensor - Coolant Temperature F-1 13
321 BR Backup Alarm F788 PU Left Steer Clutch 0650 Harness Code CONN 28 I-10 22
0668 Transmission Shift Lever Breaker - Conv #1 F-7 32 Sensor - Decel Pedal Postion B-9 35
322 GY Warning Horn (Forward) F789 YL Right Steer Clutch CONN 29 A-9 B
0671 Transmission Output Speed Sensor I CONN 30 B-9 B Breaker - Conv #2 F-7 32 Sensor - ECPC XMSN Input Spd F-4 4
326 PU Key Start Switch OFF F790 BR Service Brake Pedal
0672 Torque Converter Output Speed Sensor CONN 31 E-9 A Breaker - Drivetrain I-8 38 Sensor - Engine Oil Pressure E-1 37
334 BU Implement Detent F791 BU Right Brake Solenoid 0673 Transmission Output Speed Sensor II
CONN 32 B-8 35 Breaker - ENG ECM Switched I-8 38 Sensor - Engine Spd F-4 3
337 WH Prelube Pushbutton Switch to Prelube Timer F792 WH Left Brake Solenoid 0674 Transmission Intermediate Speed Sensor I
CONN 33 A-7 B Breaker - ENG ECM Unswitched I-8 38 Sensor - Fuel Pressure G-1 37
Monitoring Circuits G730 PK EPTC II - Park Brake Sol 0675 Transmission Intermediate Speed Sensor II
CONN 34 B-7, C-7, D-7 A
0676 Left Track Steering Lever Position Sensor Buss Bar I-8 22 Sensor - Fuel Temperature E-1 37
403 GN Alternator (R) Term. G731 GY EPTC II - Secondary Serivce Brake Sol CONN 35 F-7 32
410 WH Action Alarm 851 WH Direction Sensor
0677 Right Track Steering Lever Position Sensor
CONN 36 G-7 34
Connector - Datalink Service E-13 23 Sensor - Inching Pedal Position B-9 35 © 2001 Caterpillar Printed in U.S.A.
0681 Parking Brake Solenoid
411 PK Master Action Lamp 892 BR CAT Data Link (-) CONN 37 G-7 4 Connector - Monitor Service E-13 23 Sensor - Inlet Air Temperature F-1 37 All Rights Reserved
0689 Left Brake Solenoid
CONN 38 H-7, I-7 32 Control - Blade Float A-8 B Sensor - Speed Timing F-1 8
419 YL Opr Mon Parking Brake 893 GN CAT Data Link (+) 0690 Right Brake Solenoid
CONN 39 I-7 37 Control - ECB (Drivetrain) G-13 C Sensor - Turbo Inlet Press E-4 47
426 BR Powertrain Oil Filter Differential Pressure F842 BU Implement Lockout SW 2 0691 Reverse Clutch Solenoid Valve I
CONN 40 E-6 14 Diode H-4 3 Sensor - Turbo Outlet Pressure F-1 37
442 GY Hydraulic Oil Temperature F843 YL Inching Pedal Sensor 0692 Forward Clutch Solenoid Valve II
0693 Speed 3 Clutch Solenoid Valve III CONN 41 E-5 47
Diode - Flyback H-9 38 Sensor - XMSN Inter Spd #1 I-14 17
443 YL Powertrain Oil Temperature F846 PU MSS LED CONN 42 C-4 2
0694 Speed 2 Clutch Solenoid Valve IV EEC Code Plug E-9 A Sensor - XMSN Inter Spd #2 I-14 17
447 PK Fuel Level F847 YL Aux Ckt CONN 43 C-4, D-4 4
0695 Speed 1 Clutch Solenoid Valve V
CONN 44 E-3 2 EMS II C-9 , D-9 A Sensor - XMSN Out Spd #1 H-14 17
450 YL Engine Speed F848 OR Bi Directional Mode SW (N.O.) 0697 Priority Valve Solenoid
CONN 45 E-3 36 Engine Control ADEM II D-2 , D-3 1 Sensor - XMSN Out Spd #2 H-14 17
A447 PK Engine Oil Prelube Pressure Switch F849 WH Bi Directional Mode SW (N.C.) 0698 Left Steering Clutch Solenoid
C413 YL SPI Data F850 PK Implement Lockout SW 0699 Right Steering Clutch Solenoid CONN 46 C-2 6 Flood #1 Side Sweep LH B-14 10 Sensor - XMSN Temp G-4 18 Harness And Wire Electrical Schematic Symbols
0718 Transmission System CONN 47 I-2 8 Flood #2 Side Sweep RH B-14 20 Shift Control G-15 C
C414 BU SPI Load 900 PU XMSN First Gear Clutch
0722 Secondary Brake Solenoid CONN 48 I-1 5 Flood - Cyl. #1 FRH C-1 6 Solenoid - A/C Clutch H-4 3
Accessory Circuits 973 BR CST Autoshift - Auto/Manual SW 2
1488 Implement Lever Detent The connectors shown in this chart are for harness to harness connectors. Part Numbers For 1 1
6 48
500 BR Wiper - Front (Park) 975 WH CST Autoshift - Sol Return ¹ The CID is a diagnostic code that indicates which component is faulty. Connectors that join a harness to a component are generally located at or near Flood - Cyl. #2 FRH B-1 Solenoid - ECPC Pump G-4
Connector Assembly 2 2
the component. See the Component Location Chart. Flood - Cyl. #3 FLH H-1 5 Solenoid - Ether Start Valve I-2 8
501 GN Wiper - Front (Low) 977 YL CST Auto Downshift Switch ² The MID is a diagnostic code that indicates which electronic control module Off Machine Switch Specification
502 OR Wiper - Front (HI) 993 BR Engine Control Analog Sensor Common diagnosed the fault. Flood - Cyl. #4 FLH H-1 5 Solenoid - First Gear Clutch I-14 17
Part No. Function Actuate Deactuate Contact Position AG-C4 * L-C12 * Typical representation of Typical representation of a
503 BR Wiper - Rear (Park) 994 GY Engine Control Oil Pressure (Filtered)
Flood - Cyl. STD1 FRH C-1 6 Solenoid - Forward Clutch I-14 17
3E-5464 Thermostat
-1.1 ± 0.8°C 2.2 ± 0.8°C
Normally Closed
111-7898 3E-5179 a Deutsch connector. The Sure-Seal connector. The plug
22 Flood - Cyl. STD2 FLH H-1 5 Solenoid - Injector #1 G-2 37 (30 ± 1.4°F) (36 ± 1.4°F) plug contains all sockets and receptacle contain
504 YL Wiper - Rear (Low) 995 BU Engine Control Coolant Temperature 30±7 kPa 30±7 kPa 1
505 BU Wiper - Rear (HI) 996 GN Engine Speed/Timing Sensor Power
27 Flood - Ripper C-14 31 Solenoid - Injector #2 G-2 37 105-9152 Pre Lube Oil Pressure
(39.9 to 253.8 psi) (39.9 to 253.8 psi)
Normally Closed
and the receptacle contains both pins and sockets.
506 PU Washer - Front 997 OR Engine Control Analog Sensor Power (+ 5V) 10 Flood - Sweep #1 FRH B-1 6 Solenoid - Injector #3 G-2 37
114-5333 A/C (High / Low) Pressure
275 to 1750 kPa¹ -
Normally Open²
all pins.
507 WH Washer - Rear 998 BR Engine Digital Sensor Return 25 38 Flood - Sweep #2 FRH B-1 6 Solenoid - Injector #4 F-2 37 (39.9 to 253.8 psi) -

508 PU Radio Speaker - Left 999 WH Engine Primary Camshaft Speed/Timing

34 44
Flood - Sweep #3 FLH H-1 5 Solenoid - Injector #5 F-2 37
¹ A hysteresis band exists: with increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed Plug Receptacle
32
24 C 39 8 5
5 37
condition can be maintained down to 170 kpa (25psi). Component
509 WH Radio Speaker - Left (Common) C967 BU Inlet Air Temperature Flood - Sweep #4 FLH G-1 Solenoid - Injector #6 F-2
40 1 ² Contact position at the contacts of the harness connector. Part Number 9X-1123
511 BR Radio Speaker - Right C987 RD +Battery 37 7 Flood #1 Fuel Tank RLH A-15 27 Solenoid - Left Brake H-11 49 2
512 GN Radio Speaker - Right (Common) C991 PK Fuel Filter Monitor 23 14 3 Flood #1 Fuel Tank RLH C-15 27 Solenoid - Left Steer Clutch H-11 49
31 42
513 GN A/C Compressor/Refrigerant Pressure Switch E900 WH ECPC Trans Output SPD + 26
9 19
43 Flood #1 Fuel Tank RLH E-15 27 Solenoid - Park Brake Dump I-11 49 Wire, Cable, or Harness
17 A
Pin or Socket Assembly Identification

325-L25 PK-14
515 GY Blower Motor (HI) E901 GN ECPC Trans Output SPD - 46 4 Flood #1 Rops RLH B-15 24 Solenoid - Reverse Clutch I-14 17
49
18 48 35
516 GN Blower Motor (Medium) E902 PU ECPC Trans Intermediate SPD + Flood #1 Rops STD WD RLH E-14 24 Solenoid - Right Brake H-11 49 Number
30 51 28 49
517 BU Blower Motor (Low) E903 YL ECPC Trans Intermediate SPD - 47 Flood #2 Fuel Tank RRH A-15 Solenoid - Right Steer Clutch H-11
B
521 YL A/C Switch to Refrigerant Switch E904 BR ECPC Trans Intermediate SPD Q+ 13 Flood #2 Fuel Tank RRH B-15 28 Solenoid - Second Gear Clutch I-14 17
16
11
28
* L-C12*
522 WH A/C Clutch to Thermostat Switch E905 BU ECPC Trans Intermediate SPD Q- 6 Flood #2 Fuel Tank RRH E-15 Solenoid - Service Brake Dump I-11 49
C-C4* AG-C4*
45
Flood #2 Rops RLH H-14 24 Solenoid - Third Gear Clutch I-14 17 AG-C3
523 BR Wiper - Left (Park) E906 OR ECPC Trans Output SPD Q+ 41 29
130-6795 130-6795 111-7898 3E-5179 Harness identification code
524 BU Wiper - Left (Low) E907 GY ECPC Trans Output SPD Q- 20 Flood #2 Rops STD WD RRH D-14 25 Solenoid - Winch C-15 16
525 GY Wiper - Left (HI) E908 BR ECPC Trans Input SPD + 28
Flood #3 Rops RRH A-15 25 Starter I-3 1 325-A135 PK-14 1 This example indicates wire
526 YL Wiper - Right (Park) E909 WH ECPC Trans Input SPD - 15 Flood #4 Rops RRH H-14 25 Starter - Prelube I-3 1 32 in harness "L'.
50
527 GN Wiper - Right (Low) G939 PK MAC 14 Switch Return Floods - Fender LH I-10 10 Switch - 4 Speed Blower E-11 A Pin Socket
20
528 PK Wiper - Right (HI) J992 YL Miscellaneous Switch #1 Floods - Fender RH A-10 Switch - AC D-11 A Resistor, Sender and Solenoid Specifications
529 WH Washer Left J993 PK Unused Fuse Block I-8 , H-8 38 Switch - Auto Downshift C-10 A Part No. Component Description Resistance (Ohms)¹
Single Wire
42 24 25
A
Connector
530 OR Washer Right J994 GY Unused Gage Cluster C-9 Switch - BI Directional Mode C-10 A 3E-6333 Solenoid: Start Aid Valve 6.0
567 WH A/C SW Jumper J995 PU Unused Ground - Case H-10 22 Switch - Disconnect H-10 22
2 200-L32 BK-14
3E-7842 Resistor: Starter 150 ± 7.5 * Harness identification letter(s) and a
592 BU DC/DC Converter Output +12V Switched K977 PK ECPC Trans Oil Temp Sensor Ground - Engine Block H-3 1 Switch - Downshift G-15 C
46
30 43
39 4W-9972 Sender: Hydraulic Oil Temperature
54°C (130°F) 638 ± 78
serializing code. The "C" stands for Circuit Number
593 GN Condenser Fan Relay to Motors K978 BU ECPC Pump Sol Ground - Frame H-3 Switch - Ether Start Aid D-10 A 110°C (230°F) 77 ± 5
connector and the number indicates Wire Wire
A513 PK DC/DC Converter Memory Output +12V L983 WH Injector Common 1 & 2 Ground - Ground H-2 11 Switch - Horn - Forward B-11 B 4W-9972 Sender: Powertrain Oil Temperature
54°C (130°F) 638 ± 78 which connector in the harness. Identification Color Gauge
110°C (230°F) 77 ± 5
C568 WH Blower Motor (MAX) L984 OR Injector Common 3 & 4 Ground - Headliner B-13 30 Switch - HYD Oil Temp A-13 50
116-6203 Resistor: Resistor 20 ± 1.0
Lighting Circuits L985 YL Injector Common 5 & 6 Ground - Module I-6 40 Switch - Implement Lockout A-8 B
600 BR Dash Lamp Basic N940 BU Engine Analog Sensor Power (+5V) Ground - Module #1 I-6 40 Switch - Implement Lockout #2 A-8 B 2
A-C: 2.00 ± .10
608 GN Flood Lamp - Rear N941 YL Engine Analog Sensor Return 41
45
A
Ground - Module 2 H-10 22 Switch - Key Start D-10 A
Electrical Schematic Symbols And Definitions
27 28 44 5 125-9740 Resistor: Blower B-C: 1.00 ± 0.05
34 6 7
609 YL Flood Lamp - Side N942 OR Flexxaire Fan C B Horn - FWD HI I-1 Switch - Operator Monitor C-10 A
38 14 C-D: 0.36 ± 0.02
610 OR Flood Lamp - Front N944 PU Engine Digital Sensor Return 31 26 29 Horn - FWD LOW I-1 7 Switch - Parking Brake F-15 C FUSE - A component in an electrical circuit that will open the circuit if too much
630 GY Flood Lamp - Rear Ripper
23
22 50 47 3 Lamp - Action D-9 A Switch - Power Train Oil Temp. F-4 19 134-3998 Solenoid: A/C Clutch 17.6 ± 0.6 current flows through it.
663 GY Gage Lamps - Cat Mon Sys 15 32 9 7 Light - Attach Winch B-12 B Switch - Pressure - Prelude Oil I-5 51
35 136-1679 Solenoid: ECPC Pump 31 ± 3.0
20
10 1
8 13 Light - Pipe D-9 A Switch - PTrain FLT Press A-13 29 25°C (77°F) 76.3 ± 3.8 REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet
137-9755 Solenoid: Blade Float
49
40 Light - Pipe #2 D-9 A Switch - Rear Floods and Ripper D-11 A -40°C (-40°F) 57.2 closes the contacts of a normally open reed switch; it opens the contacts of a
Full 0-3.5
Module - Lamp Gear C-9 A Switch - Refrigerant H-4 3 160-1823 Sender: Fuel Level normally closed reed switch.
37 A Empty 92-98
16 4 51 Motor - Blower #1 E-10 Switch - Reverse G-15 C
160-2456 Solenoid: Right Brake 2.2 ± 0.2
17 Motor - Blower #2 E-10 A Switch - Service Brake Pedal B-9 35 SENDER - A component that is used with a temperature or pressure gauge. The
48 160-2456 Solenoid: Left Brake 2.2 ± 0.2
39
11
Motor - Rops Cond F-15 42 Switch - Throttle A-10 , B-10 B
Forward Clutch
sender measures the temperature or pressure. Its resistance changes to give an
Motor - Rops Cond #2 E-15 42 Switch - Upshift G-15 C T
Reverse Clutch
indication to the gauge of the temperature or pressure.
Motor - Washer Front E-12 34 Switch - Winch H-8 B
160-8408 Solenoid: First Gear Clutch 8.7 ± 0.4
Motor - Washer Left E-12 34 Switch - Wiper Front C-13 30
18
Second Gear Clutch RELAY (Magnetic Switch) - A relay is an electrical component that is activated by
Motor - Washer Rear D-12 34 Switch - Wiper Left C-13 30
Motor - Washer Right D-12 34 Switch - Wiper Rear D-13 30
Third Gear Clutch electricity. It has a coil that makes an electromagnet when current flows through it.
Motor - Wiper Front C-12 43 Switch - Wiper Right C-13 30
172-2392 Solenoid: Park Brake Dump 41.9 ± 2.1 The electromagnet can open or close the switch part of the relay.
172-2392 Solenoid: Service Brake Dump 41.9 ± 2.1
Motor - Wiper Left C-12 44 Timer - Prelube H-4 8
Motor - Wiper Rear D-12 46 Thermostat E-10 A
190-6017 Solenoid: Injectors 1-6 2.2 ± 0.2 CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the
Motor - Wiper Right C-12 45 Transducer - Magnetic F-1 37
¹ At room temperature unless otherwise noted. circuit if too much current flows through it. This does not destroy the circuit breaker
and it can be reset to become part of the circuit again.
2
Receptacle As F-7 32 Winch Free Spool A-8 B Letters are stamped near terminals.

Relay - Cond F-15 41

SOLENOID - A solenoid is an electrical component that is activated by electricity.
Machine Harness Connector And Component Location
Machine locations are repeated for components located close together.
A = Located on dash. C = Located inside of left console. It has a coil that makes an electromagnet when current flows through it. The
B = Located inside of right console. D = Located around headliner. electromagnet can open or close a valve or move a piece of metal that can do work.
 15 14 13 12 11 10 9 8 7 6 5 4 3 2
CONN 18 ML-C1 MP-C3 MP-C2 M-C5 CONN 25 CONN 28 M-C7 MR-C1 MR-C2
H-4 H-4
3E5179 1552252 1130580 3E6286 106-M79 RD-18 1552269 3E3364 1552269 ETHER START AID RLY
106-ML1 PU-18 1 106-MP25 RD-18 1
H-4 609-M191 YL-14 1 609-MR1 YL-14 1 WH-18 LH FENDER FLOOD CBL-AW1 RD-00 CBL-AW1 RD-00 CBL-AW1 RD-00 3E5239
TRANSMISSION 200-ML2 BK-18 2 200-MP24 BK-18 2 200-M63 BK-14 2 200-MR2 BK-14 2 BK-18 1355549 108-C13 BU-16 87A
P-C3 3 3 200-M212 BK-18 CBL-AT2 BK-00 CBL-AT2 BK-00 CBL-AT2 BK-00 30 87
1552269 403-ML4 GN-18 4 403-MP22 GN-18 4 310-C7 PU-18 108-C13 BU-16
FORWARD CLUTCH 1 752-P10 YL-18 308-ML3 YL-18 5 308-MP23 YL-18 5 109-HF1 RD-0 109-HF1 RD-0
1608408 2 975-P16 WH-18 6 6 CONN 39 310-C12 PU-18 C-C8
9X1054
P-C4 7 7 CBL-AT1 RD-00 FUSE PANEL 310-C9 PU-18 86 85
PRODUCT LINK ML-C2 1552269 8 8 A-C4
1532304 7X6222 REVERSE CLUTCH 1 751-P9 GN-18 9 106-MP25 RD-18 9 106-M79 RD-18 P N 1642336 F710-C31 BR-18 F710-C31 BR-18
1608408 SERVICE BRAKE DUMP
+BAT 1 106-ML1 PU-18 2 975-P18 WH-18 10 200-MP24 BK-18 10 200-M212 BK-18 M-C4 1722392 CBL-AP1 RD-00 CBL-AN1 RD-00 207-A37 BK-18 101-A34 RD-18 1 200-C10 BK-18
-BAT 2 200-ML2 BK-18 893-ML6 GN-18 11 893-MP21 GN-18 308-MP23 YL-18 11 308-M169 YL-18 1552272 AUX START 302-A36 OR-18 302-A36 OR-18 2 200-M21 BK-14 200-C11 BK-18 310-C9 PU-18
P-C5
HDD INPUT 3 1552269 751-P9 GN-18 892-ML5 BR-18 12 892-MP20 BR-18 403-MP22 GN-18 12 403-M177 GN-18 G730-M35 PK-18 1 BK-18 NEG POS NEG POS 1704857 112-A32 PU-14 140-A26 BU-14 310-A39 PU-18 203-A15 BK-18 3 200-M160 BK-10 200-C10 BK-18
15A
ALTERNATOR IN 4 403-ML4 GN-18 FIRST GEAR CLUTCH 1 900-P13 PU-18 752-P10 YL-18 13 975-M23 WH-18 2 BK-18 BUSS BAR
DRIVETRAIN
207-A37 BK-18 304-A21 WH-18 4 200-M74 BK-10 200-CF6 BK-16 200-CF6 BK-16 304-C50 WH-8 200-C1 BK-14 C-C4 ETHER START VALVE

I I
KEY SW INPUT 5 308-ML3 YL-18 1608408 2 975-P17 WH-18 754-P11 BU-18 14 3 9W0742 302-A36 OR-18 203-A15 BK-18 105-A41 RD-18 5 C-C15 RESISTOR S 200-C6 BK-14 1552269 3E6333 G-C4
6T3643
6 755-P8 OR-18 15 403-M177 GN-18 4 12V BATTERY 12V BATTERY2 310-A39 PU-18 306-A40 GN-18 6 MODULE 200-M172 BK-10 1552269 3E7842 310-C12 PU-18 1 WH-18 1552269
P-C6 PRELUBE OIL PRESSSURE
9X9721 9X9721 GROUND
+BAT 7 1552269 900-P13 PU-18 NOTE E P-C1 MP-C1 CONN 17 16 101-A34 RD-18 207-A37 BK-18 7 200-M149 BK-10 CF-C3 1059152 302-C45 OR-18 1 200-C11 BK-18 2 PU-18 322-G5 GY-14 1 FWD HORN HI
-BAT 8 SECOND GEAR CLUTCH 1 755-P8 OR-18 1086177 1086259 17 105-A41 RD-18 308-A38 YL-18 8 200-M107 BK-10 1552269 301-C39 BU-18 2 200-G1 BK-14 2 1747875
1608408 PARK BRAKE DUMP
HDD GND 9 2 975-P19 WH-18 975-P16 WH-18 E901-P1 GN-18 A E901-MP1 GN-18 18 892-M161 BR-18 M-C6 1722392 112-A11 PU-14 15A
150-A29 RD-14 101-A22 RD-14 109-A9 RD-18 109-A9 RD-18 9 A447-CF7 PK-16 1 BK-18
SENSOR SUPPLY 10 975-P18 WH-18 E902-P2 PU-18 B E902-MP2 PU-18 893-MP21 GN-18 19 893-M165 GN-18 893-M165 GN-18 1552272 101-AA1 RD-0 101-A34 RD-18 112-A42 PU-18 310-A39 PU-18 10 200-M152 BK-14 200-CF5 BK-16 2 BK-18 301-CF8 BU-4 G-C5
P-C7 ENG ECM SWITCHED
CAT Data Link + 11 893-ML6 GN-18 1552269 975-P17 WH-18 975-P15 WH-18 E903-P3 YL-18 C E903-MP3 YL-18 892-MP20 BR-18 20 892-M161 BR-18 G731-M37 GY-18 1 BK-18 101-A12 RD-14 304-A21 WH-18 11 200-M178 BK-14 200-G9 BK-14 1552269
6T3643
CAT Data Link - 12 892-ML5 BR-18 THIRD GEAR CLUTCH 1 754-P11 BU-18 975-P19 WH-18 975-P14 WH-18 E904-P4 BR-18 D E904-MP4 BR-18 E900-MP12 WH-18 21 E900-M38 WH-18 975-M25 WH-18 2 BK-18 306-A40 GN-18 112-A42 PU-18 12 200-M207 BK-14 H-14 CONN 49 200-G1 BK-14 322-G6 GY-14 1 FWD HORN LO
1608408 G S 1747876
CAN Data Link + 13 2 975-P20 WH-18 975-P20 WH-18 E905-P5 BU-18 E E905-MP5 BU-18 E901-MP1 GN-18 22 E901-M39 GN-18 975-M29 WH-18 3 101-A22 RD-14 102-A33 RD-14 308-A38 YL-18 C-C2 G-C1 200-G2 BK-14 200-G2 BK-14 2

H-14
CAN Link Shield 14 NOTE E E906-P6 OR-18 F E906-MP6 OR-18 E902-MP2 PU-18 23 E902-M40 PU-18 975-M30 WH-18 4 103-A18 RD-12 201-M127 BK-18 101-CF9 RD-4 0
CBL-AW1 RD-00 1552267 3E3370 200-G8 BK-14
CAN Data Link - 15 NOTE E E907-P7 GY-18 G E907-MP7 GY-18 E903-MP3 YL-18 24 E903-M41 YL-18 106-A35 RD-18 A-C1 M-C3 MODULE 1 201-M151 BK-18 MTR BAT 101-CF9 RD-4 200-C1 BK-14 A 200-G3 BK-14
CONN 38
0

PP-C1
16 1552269 755-P8 OR-18 H 755-MP8 OR-18 E904-MP4 BR-18 25 E904-M42 BR-18 102-A33 RD-14 108-A4 BU-16 1130580 3E6286 GROUND 201-M91 BK-18 610-C2 OR-14 B 610-G7 OR-14 610-G11 OR-14 200-G9 BK-14 H-20

CBL-AM1 BK-00
15A PRELUBE RELAY
17 XMSN INTER SPD 1 BK-18 1 E903-PP3 YL-18 751-P9 GN-18 J 751-MP9 GN-18 E905-MP5 BU-18 26 E905-M43 BU-18 M-C8
ENG ECM UNSWITCHED
113-A2 OR-18 140-A26 BU-14 1 140-M5 BU-14 1790006 MOTOR STARTER 322-C3 GY-18 C 322-G4 GY-14 610-G10 OR-14 610-G11 OR-14
18 1932550 BK-18 2 E902-PP4 PU-18 752-P10 YL-18 K 752-MP10 YL-18 E906-MP6 OR-18 27 E906-M44 OR-18 751-M46 GN-18 1552269 306-A8 GN-18 2 306-M109 GN-18 6V5227
6T3643
RS-232C Tx DATA 19 PP-C2 754-P11 BU-18 L 754-MP11 BU-18 E907-MP7 GY-18 28 E907-M45 GY-18 752-M47 YL-18 F789-M116 YL-18 1 114-A6 RD-18 308-A10 YL-18 3 301-CF8 BU-4 PRELUBE STARTER 322-G5 GY-14 G-C2
CONN 48
CONN 16 NOT USED ON THIS MODEL 1552269
RS-232C GND 20 1552269 E900-P12 WH-18 M E900-MP12 WH-18 751-MP9 GN-18 29 751-M46 GN-18 754-M48 BU-18 975-M164 WH-18 2 112-A11 PU-14 FUSE BLOCK
115-A46 RD-14 184-A7 BU-14 4 1249780 322-G6 GY-14
RS-232C Rx Data 21 XMSN INTER SPD 2 BK-18 1 E905-PP5 BU-18 PP-C5 P-C2 900-P13 PU-18 N 900-MP13 PU-18 752-MP10 YL-18 30 752-M47 YL-18 755-M49 OR-18 1901030 116-A1 RD-14 114-A6 RD-18 5 114-M72 RD-18 102-M61 RD-14 207-C17 BK-18 0
200-CF6 BK-16 403-C4 GN-18 610-G10 OR-14 1 CYLINDER/SWEEP LIGHTING
22 1932550 BK-18 2 E904-PP6 BR-18 1552264 3E3388 975-P14 WH-18 P 975-MP14 WH-18 754-MP11 BU-18 31 754-M48 BU-18 900-M50 PU-18 130-A43 GN-18 111-A3 YL-14 6 103-M77 RD-14 229-C49 BK-14 0
200-G8 BK-14 2
BUSS BAR A ALTERNATOR
23 PP-C3 E901-PP1 GN-18 1 E901-P1 GN-18 975-P15 WH-18 R 975-MP15 WH-18 755-MP8 OR-18 32 755-M49 OR-18 E900-M38 WH-18 M-C11 140-A26 BU-14 103-A18 RD-12 7 103-M77 RD-14 104-M78 YL-14 CF-C2 1 CBL-AT2 BK-00 1322156
1552269 1667418 1552273

CBL-AV1 BK-00
24 1552269 E900-PP2 WH-18 2 E900-P12 WH-18 S 900-MP13 PU-18 33 900-M50 PU-18 BUSS 150-A29 RD-14 160-A28 PU-18 8 160-M201 PU-18 105-M98 RD-18 2
POINT 1
XMSN OUT SPD 1 BK-18 1 E901-PP1 GN-18 E903-PP3 YL-18 3 E903-P3 YL-18 T 975-MP14 WH-18 34 975-M30 WH-18 E901-M39 GN-18 F788-M120 PU-18 1 158-A25 BR-14 158-A25 BR-14 9 158-M192 BR-14 106-M218 RD-18 200-M107 BK-10 A447-CF7 PK-16 4 BK-16 PRESSURE SW (NC) CBL-AY1 BK-00 ALT
1932550 NOT USED ON THIS MODEL
BK-18 2 E900-PP2 WH-18 E902-PP4 PU-18 4 E902-P2 PU-18 NOTE E 975-MP15 WH-18 35 975-M29 WH-18 E902-M40 PU-18 975-M125 WH-18 2 203-AG1 BK-18 MAIN RELAY BUSS BAR B KEY FORWARD HORN 160-A28 PU-18 207-A37 BK-18 10 207-M156 BK-18 106-M79 RD-18 200-CF4 BK-16 2 GN-16 GROUND 109-HF1 RD-0 + R

PP-C4 E905-PP5 BU-18 5 E905-P5 BU-18 36 E903-M41 YL-18 1670138 105-A23 RD-18 15A 15A 114-A6 RD-18 116-A1 RD-14 11 116-M88 RD-14 106-M134 RD-18 H-13 307-CF1 OR-16 3 WH-16 KEY SWITCH (START) CYL LIGHTS (STD, WD)
1552269 E904-PP6 BR-18 6 E904-P4 BR-18 37 NOTE E E904-M42 BR-18 1667419 105-A41 RD-18 1 2 104-A31 YL-14 108-A4 BU-16 12 108-M83 BU-16 200-M172 BK-10 337-CF3 WH-16 5 YL-16 CRANKING MOTOR CTRL
LEFT BRAKE
XMSN OUT SPD 2 BK-18 1 E907-PP7 GY-18 E907-PP7 GY-18 7 E907-P7 GY-18 38 E905-M43 BU-18 M-C12 1602456 DISCONNECT SW 112-A42 PU-18 SERVICE BRAKE PRODUCT LINK 105-A23 RD-18 124-A14 GN-14 13 124-M104 GN-14 108-M83 BU-16 108-M100 BU-16 116-CF2 BR-16 1 RD-16 KEY SWITCH (RUN) 200-CE1 BK-0
1932550 BK-18 2 E906-PP8 OR-18 E906-PP8 OR-18 8 E906-P6 OR-18 39 E906-M44 OR-18 1552269 7N0718 A-C2 198-A5 RD-18 15A 15A 106-A35 RD-18 110-A45 RD-14 302-A36 OR-18 14 302-M157 OR-18 108-M65 BU-16 6
40 E907-M45 GY-18 F792-M20 WH-18 1 BK-18 3E3364 3 4 124-A14 GN-14 198-A5 RD-18 15 198-M71 RD-18 102-M61 RD-14 PRELUBE TIMER
TRANSMISSION 975-M24 WH-18 2 BK-18 BK-18 1 308-A19 YL-18 AUX 4 FRONT FLOODS 111-A3 YL-14 197-A13 RD-14 16 197-M86 RD-14 113-M135 OR-18 113-M99 OR-18 108-M65 BU-16 1403108 610-TP1 OR-14
751-M46 GN-18 BK-18 2 197-A13 RD-14 10A 15A 115-A46 RD-14 105-A41 RD-18 130-A43 GN-18 17 130-M176 GN-18 113-M75 OR-18 130-M176 GN-18 CONN 48 200-TP2 BK-14
DRIVE TRAIN CONTROL 752-M47 YL-18 A-C7 5 6 186-A44 RD-14 18 186-M208 RD-14 150-M62 RD-14
RIGHT BRAKE
CONN 24 754-M48 BU-18 1552269 176-A27 YL-14 110-A45 RD-14 114-M72 RD-18 200-M178 BK-14

CBL-AR1 BK-00
M-C14 AUX 3 FENDER FLOODS 19

BUSS BAR C
1602456
JK-C1 755-M49 OR-18 1552269 1 110-A45 RD-14 15A 15A 116-A1 RD-14 184-A7 BU-14 310-A39 PU-18 20 310-M84 PU-18 115-M205 RD-14 207-M156 BK-18 ENGINE FRAME GROUND

1667417
NOTE E 3E3382 900-M50 PU-18 F791-M19 BU-18 1 BK-18 2 7 8 186-A44 RD-14 105-A23 RD-18 21 105-M98 RD-18 116-M88 RD-14 H-8 BLOCK GROUND
276-X53 BK-18 1 E900-M38 WH-18 975-M27 WH-18 2 BK-18 24V-12V CONVERTER REAR FLOODS 197-A13 RD-14 115-A46 RD-14 22 115-M205 RD-14 124-M104 GN-14 302-M157 OR-18 CYLINDER LIGHTS (10)
140-X63 BU-18 G730-X85 PK-18 277-X54 BK-18 2 200-JK1 BK-18 186-A44 RD-14 20A 15A 103-A18 RD-12 198-A5 RD-18 113-A2 OR-18 23 113-M135 OR-18 130-M176 GN-18 304-M96 WH-8
H 202-X52 BK-18 754-X23 BU-18 278-X55 BK-18 3 200-JK2 BK-18 E901-M39 GN-18 START RELAY
1183534
9 10 24 310-M84 PU-18 H

BUSS BAR D
892-X35 BR-18 975-X50 WH-18 140-X49 BU-18 279-X56 BK-18 4 200-JK3 BK-18 E902-M40 PU-18 304-A21 WH-18 AUX 3 AUX 5 101-A12 RD-14 176-A27 YL-14 25 176-M183 YL-14 140-M58 BU-18 403-M162 GN-18 108-C13 BU-16

1698681
140-X49 BU-18 752-X22 YL-18 851-X76 WH-18 306-X33 GN-18 280-X57 BK-18 5 E903-M41 YL-18 304-A30 WH-8 184-A7 BU-14 10A 5A 130-A43 GN-18 109-A9 RD-18 26 140-M202 BU-18 892-M182 BR-18 200-C6 BK-14 610-TN4 OR-14
140-X71 BU-18 202-X41 BK-14 321-X32 BR-18 G939-X58 PK-18 6 200-JK4 BK-18 E904-M42 BR-18 A-C3 11 12 112-A42 PU-18 104-A31 YL-14 27 104-M78 YL-14 140-M6 BU-14 893-M174 GN-18 310-C7 PU-18 610-TN3 OR-14 200-TN5 BK-14
140-X70 BU-18 140-X37 BU-14 F843-X4 YL-18 334-X6 BU-18 E905-M43 BU-18 200-M212 BK-18 200-M212 BK-18 1552269 AUX 1 WINCH 304-A21 WH-18 102-A33 RD-14 28 102-M61 RD-14 140-M5 BU-14 140-M3 BU-14 610-TN1 OR-14 610-TN4 OR-14
140-X63 BU-18 975-X39 WH-18 K978-X48 BU-18 337-X34 WH-18 M-C36 CONN 23 E906-M44 OR-18 200-M114 BK-18 200-M114 BK-18 BK-18 1 306-A20 GN-18 111-A3 YL-14 10A 15A 160-A28 PU-18 304-A30 WH-8 150-A29 RD-14 29 150-M62 RD-14 103-M77 RD-14 322-C3 GY-18 200-TN2 BK-14 200-TN5 BK-14
1030213 CONN 48
140-X64 BU-18 G731-X30 GY-18 334-X6 BU-18 450-X45 YL-18 E907-M45 GY-18 202-M76 BK-18 BK-18 2 200-A16 BK-18 13 14 106-A35 RD-18 30 106-M218 RD-18 150-M62 RD-14 105-M98 RD-18 403-C4 GN-18 200-TN6 BK-14
893-X36 GN-18 709-X46 OR-18 E900-X13 WH-18 1 E900-M38 WH-18 202-M148 BK-14 200-CL1 BK-6 AUX 2 AC CONDENSOR 306-A8 GN-18 200-A17 BK-18 31 108-M100 BU-16 610-C2 OR-14 610-TN3 OR-14
751-X21 GN-18 K977-X47 PK-18 754-X23 BU-18 E901-X14 GN-18 2 E901-M39 GN-18 140-M3 BU-14 104-A31 YL-14 15A 20A 158-A25 BR-14 32 158-M192 BR-14 158-M144 BR-14 113-M99 OR-18 F710-C31 BR-18 200-TN6 BK-14
755-X24 OR-18 F790-X31 BR-18 E902-X15 PU-18 3 E902-M40 PU-18 140-M6 BU-14 202-M198 BK-18 202-M148 BK-14 101-A12 RD-14 15 16 306-A20 GN-18 33 N931-M133 GY-18 158-M185 BR-14 113-M75 OR-18
306-X33 GN-18 F788-X28 PU-18 709-X46 OR-18 F791-X26 BU-18 E903-X16 YL-18 4 E903-M41 YL-18 176-M115 YL-18 202-M198 BK-18 BLOWERS WIPERS 34 201-M145 BK-18 114-M72 RD-18 REFRIGERANT SWITCH CH-C2
337-X34 WH-18 F780-X65 PK-18 F791-X26 BU-18 F792-X27 WH-18 E904-X17 BR-18 5 E904-M42 BR-18 200-M114 BK-18 202-M76 BK-18 124-A14 GN-14 20A 10A 108-A4 BU-16 306-A40 GN-18 35 160-M201 PU-18 115-M205 RD-14 1145333 1552269
419-X66 YL-18 280-X57 BK-18 E901-X14 GN-18 E905-X18 BU-18 6 E905-M43 BU-18 202-M76 BK-18 MODULE 2 CASE
135A
109-A9 RD-18 17 18 308-A10 YL-18 36 116-M88 RD-14 2 3
BK-18 1 521-CH1 YL-14 SWEEP LIGHTING (08)
F780-X65 PK-18 G939-X59 PK-18 G730-X86 PK-18 E906-X19 OR-18 7 E906-M44 OR-18 202-M148 BK-14 GROUND GND RPR PIN/SEAT/WINCH EMS II 37 176-M115 YL-18 124-M104 GN-14 1 BK-18 2 513-CH3 OR-14
F781-X75 BR-18 G939-X60 PK-18 G730-X85 PK-18 E907-X20 GY-18 8 E907-M45 GY-18 ALT BRKR 176-A27 YL-14 15A 10A 113-A2 OR-18 101-A12 RD-14 38 176-M183 YL-14 176-M112 YL-14 140-M58 BU-18

101-AA1 RD-0
F782-X68 OR-18 900-X25 PU-18 G730-X42 PK-18 751-X21 GN-18 9 751-M46 GN-18 202-M198 BK-18 1712213 19 20 308-A19 YL-18 39 176-M184 YL-18 140-M202 BU-18 521-C15 YL-14
BUSS A/C CLUTCH
F783-X1 GN-18 F789-X29 YL-18 F790-X31 BR-18 752-X22 YL-18 10 752-M47 YL-18 POINT 2
40 158-M185 BR-14 1343998 CH-C3 522-C16 WH-14 610-TM4 OR-14
F784-X67 YL-18 419-X66 YL-18 F792-X27 WH-18 754-X23 BU-18 11 754-M48 BU-18 BUSS BAR A BUSS BAR B 308-A38 YL-18 CONN 37 186-M92 RD-14 160-M201 PU-18 1552269 610-TM3 OR-14 200-TM5 BK-14

109-HF1 RD-0
140-X70 BU-18 F785-X62 WH-18 F781-X75 BR-18 E900-X13 WH-18 851-X76 WH-18 755-X24 OR-18 12 755-M49 OR-18 306-M109 GN-18 186-M208 RD-14 186-M85 RD-14 176-M184 YL-18 GN-18 1 513-CH4 OR-14 610-TM1 OR-14 610-TM4 OR-14
G939-X83 PK-18 F786-X72 GY-18 F848-X10 OR-18 900-X25 PU-18 13 900-M50 PU-18 321-M7 BR-18 1667418 1667419 200-A16 BK-18 A-C5 M-C15 198-M71 RD-18 GN-18 2 522-CH5 WH-14 200-TM2 BK-14 200-TM5 BK-14
1275486 1275485 H-9 CONN 48
851-X76 WH-18 G730-X86 PK-18 F842-X3 BU-18 973-X7 BR-18 14 176-M115 YL-18 334-M200 BU-18 321-M7 BR-18 197-M86 RD-14 200-M74 BK-10 200-TM6 BK-14
851-X76 WH-18 F782-X68 OR-18 E909-X44 WH-18 F843-X4 YL-18 15 200-M114 BK-18 337-M136 WH-18 304-A30 WH-8 1 304-M96 WH-8 198-M71 RD-18 200-M149 BK-10 610-TM3 OR-14
CONN 1 F783-X1 GN-18 E902-X15 PU-18 F846-X8 PU-18 F842-X3 BU-18 16 F842-M199 BU-18 450-M175 YL-18 975-M29 WH-18 200-M152 BK-14 522-CH2 WH-14 CH-C1 C-C3 200-TM6 BK-14
276-X53 BK-18 E906-X19 OR-18 F847-X51 YL-18 F843-X4 YL-18 17 F843-M214 YL-18 709-M15 OR-18 200-A17 BK-18 200-M172 BK-10 200-M207 BK-14 1552269 3E3364
277-X54 BK-18 G848-X9 GN-18 977-X5 YL-18 18 977-M113 YL-18 F788-M120 PU-18 975-M30 WH-18 BUSS BAR E BUSS BAR E
BLOCK ASSY 200-M131 BK-14 201-M91 BK-18 DIODE CH-C4 1 521-C15 YL-14
F786-RT1 GY-18 F786-X72 GY-18 J994-X77 GY-18 973-X7 BR-18 334-X6 BU-18 19 334-M200 BU-18 F789-M116 YL-18 1724863 200-M97 BK-14 201-M127 BK-18 1068704 1552269 2 522-C16 WH-14
1698680 1698680 2

F782-RT2 OR-18 F782-X68 OR-18 G939-X73 PK-18 G848-X9 GN-18 975-X50 WH-18 973-X7 BR-18 20 F790-M57 BR-18 975-M110 WH-18 109-HF2 RD-0 201-M145 BK-18 1 513-CH6 OR-14
1

G939-RT3 PK-18 G939-X74 PK-18 G939-X74 PK-18 F784-X67 YL-18 E908-X43 BR-18 E900-X13 WH-18 F846-X8 PU-18 21 F791-M19 BU-18 101-AA2 RD-0 200-M107 BK-10 201-M151 BK-18 2 522-CH7 WH-14 ENGINE ENGINE

2
G939-X58 PK-18 F785-X62 WH-18 E905-X18 BU-18 E901-X14 GN-18 G848-X9 GN-18 22 F792-M20 WH-18 BUSS BAR D 200-M105 BK-18

1
BUSS BAR D 1698681
G939-X60 PK-18 J992-X78 YL-18 E907-X20 GY-18 E902-X15 PU-18 F848-X10 OR-18 23 F848-M117 OR-18 G730-M35 PK-18 106-M79 RD-18 1698681
A-C6 AG-C1 200-M130 BK-18 403-M194 GN-18
G939-X59 PK-18 278-X55 BK-18 E903-X16 YL-18 F849-X11 WH-18 24 F849-M118 WH-18 106-M134 RD-18 1552269 3E3364 200-M18 BK-12 892-M122 BR-18

101-AA1 RD-0
G939-X40 PK-18 J993-X79 PK-18 E904-X17 BR-18 J994-X77 GY-18 25 140-M3 BU-14 203-A15 BK-18 1 203-AG1 BK-18 893-M111 GN-18 NN-C2
G939-X38 PK-18 F850-X12 PK-18 F846-X8 PU-18 E905-X18 BU-18 F791-X26 BU-18 26 F791-M19 BU-18 G731-M36 GY-18 140-M6 BU-14 2 201-M145 BK-18 N931-M133 GY-18 7E6513
F786-X72 GY-18 E903-X16 YL-18 E906-X19 OR-18 F792-X27 WH-18 27 F792-M20 WH-18 G731-M37 GY-18 158-M144 BR-14 207-M156 BK-18 XMSN TEMP SNSR
CONN 36 C-C5
G G
1187226 1
279-X56 BK-18 E904-X17 BR-18 E907-X20 GY-18 F788-X28 PU-18 28 F788-M120 PU-18 G731-M59 GY-18 176-M112 YL-14 FUSE PANEL 302-M157 OR-18 106-M79 RD-18 1552267 A701-NN1 GY-16 INJECTOR 1
N-C4
977-X5 YL-18 321-X32 BR-18 E908-X43 BR-18 F789-X29 YL-18 29 F789-M116 YL-18 176-M115 YL-18 304-M96 WH-8 106-M134 RD-18 +8V RD-18 A 709-C60 OR-18 D789-NN19 WH-16 1906017 FUEL PRESS SNSR
2 3E3370 1112350
F783-X1 GN-18 G939-X61 PK-18 F849-X11 WH-18 450-X45 YL-18 E909-X44 WH-18 G731-X30 GY-18 30 G731-M36 GY-18 892-M8 BR-18 200-M21 BK-14 203-AG1 BK-18 203-AG1 BK-18 306-M109 GN-18 140-M3 BU-14 GROUND BK-18 B G939-C55 PK-18
G939-X2 PK-18 G939-X2 PK-18 J995-X80 PU-18 G939-X38 PK-18 F790-X31 BR-18 31 F790-M57 BR-18 893-M9 GN-18 200-M131 BK-14 310-M84 PU-18 140-M6 BU-14 SIGNAL WH-18 C K977-C61 PK-18 N940-N49 BU-16 A OR-18 +5V
F785-X62 WH-18 G939-X69 PK-18 140-X64 BU-18 F847-X51 YL-18 G939-X40 PK-18 321-X32 BR-18 32 321-M7 BR-18 F842-M199 BU-18 200-M160 BK-10 101-AA1 RD-0 158-M144 BR-14 ECPC PUMP
D786-NN13 BR-16 NOTE C N941-N42 YL-16 B YL-18 GROUND
F784-X67 YL-18 G939-X83 PK-18 G939-X58 PK-18 306-X33 GN-18 33 306-M109 GN-18 F843-M214 YL-18 306-M109 GN-18 176-M112 YL-14 1361679 C-C16 D788-NN16 BK-16 A745-N12 WH-16 C GN-18 SIGNAL
G939-X69 PK-18 140-X49 BU-18 140-X49 BU-18 K977-X47 PK-18 337-X34 WH-18 34 337-M136 WH-18 F848-M117 OR-18 403-M194 GN-18 176-M115 YL-18 1552269
F781-X75 BR-18 140-X37 BU-14 306-X33 GN-18 306-X33 GN-18 K978-X48 BU-18 140-X37 BU-14 35 140-M3 BU-14 F849-M118 WH-18 H-6 403-M162 GN-18 200-M21 BK-14 BK-18 1 K978-C58 BU-18
NN-C3
7E6513
202-X41 BK-14 337-X34 WH-18 337-X34 WH-18 892-X35 BR-18 36 892-M8 BR-18 F850-M217 PK-18 403-M177 GN-18 403-M177 GN-18 200-M131 BK-14 BK-18 2 975-C59 WH-18 A701-NN1 GY-16 N-C5 BACKUP SPD TMG SNSR
1 3E3370
202-X52 BK-18 G730-X86 PK-18 851-X76 WH-18 140-X37 BU-14 893-X36 GN-18 37 893-M9 GN-18 592-M73 BU-14 20A CONVERTER 200-M160 BK-10 A702-NN2 PU-16 A702-NN2 PU-16 INJECTOR 2
1906017
1296628
276-X53 BK-18 202-X41 BK-14 G939-X38 PK-18 38 G939-M181 PK-18 975-M69 WH-18 592-M73 BU-14 306-M109 GN-18 A703-NN3 BR-16 D789-NN18 WH-16 996-N40 GN-16 A OR-18 +V
277-X54 BK-18 851-X76 WH-18 G730-X86 PK-18 202-X52 BK-18 975-X39 WH-18 39 975-M33 WH-18 975-M168 WH-18 H-6 ECPC XMSN IN SPD A704-NN4 GN-16
2
N944-N38 PU-16 B BK-18 GROUND
C-C17
278-X55 BK-18 G939-X38 PK-18 G939-X38 PK-18 276-X53 BK-18 G939-X40 PK-18 40 G939-M12 PK-18 975-M110 WH-18 892-M8 BR-18 20A CONVERTER 1835011 1552269 A705-NN5 BU-16 F732-N56 PK-16 C WH-18 SIGNAL
1843579 NN-C4
279-X56 BK-18 G939-X40 PK-18 G939-X40 PK-18 277-X54 BK-18 202-X41 BK-14 41 202-M148 BK-14 892-M123 BR-18 PLUG M-C25 HERE WHEN USED PLUG INTO M-C44 403-M177 GN-18 BK-18 1 E909-C57 WH-18 NOTE E A706-NN6 GY-16 7E6513
280-X57 BK-18 G939-X58 PK-18 G939-X58 PK-18 278-X55 BK-18 E908-X43 BR-18 42 E908-M11 BR-18 892-M161 BR-18 UNUSED 1 WHEN 20A CONV IS USED 592-M73 BU-14 BK-18 2 E908-C56 BR-18 D787-NN9 GN-16 1 N-C6
751-X21 GN-18 279-X56 BK-18 E909-X44 WH-18 43 E909-M13 WH-18 975-M29 WH-18 893-M9 GN-18 +24V SWITCHED IN 2 186-MG1 WH-14 A703-NN3 BR-16 INJECTOR 3
3E3364
752-X22 YL-18 280-X57 BK-18 G730-X42 PK-18 44 G730-M35 PK-18 975-M30 WH-18 893-M124 GN-18 UNUSED 3 200-MG2 BK-12 892-M8 BR-18 D786-NN13 BR-16 D790-NN21 OR-16 1906017
PWR TRAIN OIL TEMP SW 2
755-X24 OR-18 NOTE E 751-X21 GN-18 450-X45 YL-18 45 450-M175 YL-18 975-M32 WH-18 893-M165 GN-18 +12V MEMORY OUT 4
CONV BRKR 1
892-M123 BR-18 892-M8 BR-18 4W9972 PT-C1 C-C18 D786-NN11 BR-16 D786-NN14 BR-16 F732-N56 PK-16 1 BACKUP SPEED TIMING
G939-X73 PK-18 F788-X28 PU-18 752-X22 YL-18 709-X46 OR-18 46 709-M15 OR-18 975-M34 WH-18 UNUSED 5 892-M122 BR-18 892-M123 BR-18 3E3364 1552269 2
419-X66 YL-18 F789-X29 YL-18 755-X24 OR-18 K977-X47 PK-18 47 K977-M16 PK-18 975-M33 WH-18 450-M175 YL-18 UNUSED 6
MG-C2 3T2662 CONN 35MG-C1 892-M182 BR-18 892-M161 BR-18 200-PT1 BK-18 1 443-C51 YL-18 D788-NN15 BK-16 D787-NN9 GN-16 NOTE C
1779654 1779649
F780-X65 PK-18 G731-X30 GY-18 F788-X28 PU-18 K978-X48 BU-18 48 K978-M17 BU-18 975-M31 WH-18 709-M15 OR-18 592-MG5 BU-12 15A
592-MG3 BU-12 892-M161 BR-18 893-M9 GN-18 T°
2 201-C52 BK-18 D788-NN7 BK-16 D788-NN16 BK-16 D788-NN17 BK-16 ADAPTER
CABLE AS.
892-X35 BR-18 F789-X29 YL-18 140-X49 BU-18 49 140-M6 BU-14 975-M23 WH-18 975-M69 WH-18 +24V BATTERY IN 1 186-MG1 WH-14 186-MG1 WH-14 1 893-M124 GN-18 D788-NN17 BK-16 NN-C5
N-C7
7X1695
6V3093
893-X36 GN-18 G731-X30 GY-18 975-X50 WH-18 50 975-M34 WH-18 975-M25 WH-18 E793-M167 BU-18 GROUND 2 200-MG2 BK-12 200-MG2 BK-12 2 893-M165 GN-18 893-M165 GN-18 ENGINE SPD 1552269
C-C19 7E6513
140-X71 BU-18 F842-X3 BU-18 892-X35 BR-18 F847-X51 YL-18 51 975-M66 WH-18 H-7 +12V OUTPUT 3 592-MG4 BU-12 592-MG5 BU-12
CONV BRKR 2
592-MG3 BU-12 3 893-M111 GN-18 6V2455 1552269 D789-NN12 WH-16 D789-NN18 WH-16 F723-N31 PK-16 1
3T2662 1
893-X36 GN-18 202-X52 BK-18 52 202-M76 BK-18 E794-M158 YL-18 4 592-MG6 BU-12 592-MG7 BU-14 4 893-M174 GN-18 104-M78 YL-14 BK-18 1 450-C53 YL-18 D789-NN19 WH-16 A704-NN4 GN-16 INJECTOR 4 F724-N4 PU-16 2
306-X33 GN-18 F848-X10 OR-18 J992-X78 YL-18 53 975-M27 WH-18 E908-M11 BR-18 592-MG6 BU-12 592-MG7 BU-14 893-M9 GN-18 186-M92 RD-14 WH-18 2 G939-C54 PK-18 D790-NN20 OR-16 1906017 TRANSDUCER-MAGNETIC
15A 2 6V2197
F849-X11 WH-18 F842-X3 BU-18 J993-X79 PK-18 54 975-M164 WH-18 E909-M13 WH-18 893-M124 GN-18 186-M85 RD-14 D790-NN10 OR-16 D790-NN20 OR-16
337-X34 WH-18 F850-X12 PK-18 F848-X10 OR-18 F850-X12 PK-18 55 F850-M217 PK-18 975-M24 WH-18 K977-M16 PK-18 197-M86 RD-14 D790-NN21 OR-16
H-5 NN-C6 N-C8
G730-X86 PK-18 900-X25 PU-18 F849-X11 WH-18 J995-X80 PU-18 56 975-M125 WH-18 K978-M17 BU-18 CONN 35 N931-M133 GY-18 NOTE E 7E6513 3E3370
SPD TMG SNSR
1296628
975-X39 WH-18 F850-X12 PK-18 57 RECEPTACLE AS M-C20 200-M18 BK-12 D791-NN8 YL-16 D791-NN22 YL-16 1
977-X5 YL-18 900-X25 PU-18 58 977-M113 YL-18 200-M166 BK-14 1855627 1779654 200-M97 BK-14 D791-NN23 YL-16 A705-NN5 BU-16 INJECTOR 5 996-N41 GN-16 A OR-18 +V
J994-X77 GY-18 975-X39 WH-18 NOTE E 59 NOTE E E908-M11 BR-18 200-M203 BK-18 1 186-M85 RD-14 200-M105 BK-18 D791-NN23 YL-16 1906017 N944-N39 PU-16 B BK-18 GROUND
2
J992-X78 YL-18 977-X5 YL-18 60 E909-M13 WH-18 200-M206 BK-14 2 200-M18 BK-12 200-M130 BK-18 999-N30 WH-16 C WH-18 SIGNAL
J993-X79 PK-18 J994-X77 GY-18 61 G939-M12 PK-18 201-M142 BK-18 592 BU-14 3 592-M188 BU-12 592-M73 BU-14
F J995-X80 PU-18 J992-X78 YL-18
J993-X79 PK-18
62
63
G939-M181 PK-18
K977-M16 PK-18
201-M147
201-M154
BK-18
BK-18
4 592-M73 BU-14 D786-NN14 BR-16
D788-NN15 BK-16
NOTE C
N-C9 INLET AIR TEMP F
J995-X80 PU-18 64 K978-M17 BU-18 202-M198 BK-18 1698670 1078618
NN-C7
65 M-C25 7E6513 N940-N50 BU-16 A OR-18 +V
DRIVE TRAIN CONTROL 66 106-M134 RD-18 290-M139 BK-18 1552273 104-M78 YL-14 1
N941-N44 YL-16 B BK-18 GROUND
67 158-M144 BR-14 291-M141 BK-18 +24 V BATTERY IN 1 186-M92 RD-14 186-M92 RD-14 A706-NN6 GY-16 INJECTOR 6 C967-N9 BU-16 C WH-18 SIGNAL
68 200-M131 BK-14 +24 V SWITCHED IN 2 308-M216 YL-18 186-M85 RD-14 D791-NN22 YL-16 1906017
2
ROPS A/C M-C31 69 200-M206 BK-14 308-M169 YL-18 GROUND 3 200-M130 BK-18 197-M86 RD-14
H-5
7T5957 70 200-M21 BK-14 334-M200 BU-18 +12 V MEMORY OUT 4 A513-M94 PK-18 N-C10 COOLANT TEMP SENS
1 592-M73 BU-14 201-M142 BK-18 337-M136 WH-18 +12 V SWITCHED OUT 5 592-M128 BU-18 200-M18 BK-12 1698670 1022240
2 200-M21 BK-14 201-M147 BK-18 GROUND 6 200-M105 BK-18 200-M97 BK-14 A745-N12 WH-16 N940-N51 BU-16 A OR-18 +V
201-M154 BK-18 447-M150 PK-18 10A CONVERTER 200-M105 BK-18 A746-N19 PK-16 N941-N48 YL-16 B BK-18 GROUND
1591549
CONN 8 CONN 7 M-C26
7T5957
521-M159 YL-14
M-C21
200-M130 BK-18 A747-N17 GY-16 995-N13 BU-16 C WH-18 SIGNAL
290-M139 BK-18 592-M129 BU-14 1552269
592-M73 BU-14 A751-N3 YL-16
12V OUTLET 2 1 592-M129 BU-14 SEAT SUSPENSION 291-M141 BK-18 608-M155 GN-14 F723-N31 PK-16

D790-NN10 OR-16
D786-NN11 BR-16
D789-NN12 WH-16
1172311 1476523 H-11 N-C11

A701-NN1 GY-16
A702-NN2 PU-16
A703-NN3 BR-16
A704-NN4 GN-16
A705-NN5 BU-16
A706-NN6 GY-16
D788-NN7 BK-16
D791-NN8 YL-16
D787-NN9 GN-16
2 200-M131 BK-14 447-M150 PK-18 ACCESSORY POWER CONNECTOR 1 197-M86 RD-14 200-M87 BK-14 F724-N4 PU-16 3E3370
TURBO OUTLET PRESS
200-TC8 BK-14 158-TC1 BR-14 158-TF1 BR-14 158-T15 BR-14 521-M159 YL-14 609-M204 YL-14 (UNSWITCHED) 2 200-M97 BK-14 308-M216 YL-18 1112351
593-TC6 GN-14 521-TC2 YL-14 521-TF2 YL-14 521-T14 YL-14 MONITOR SERVICE CONNECTOR 592-M73 BU-14 630-M64 GY-16 H-10 N940-N52 BU-16 A OR-18 +5V
200-TC3 BK-14 200-TF3 BK-14 200-T13 BK-14 M-C30 MOTOR 592-M129 BU-14 779-M170 WH-18 M-C27 592-M188 BU-12 994-N8 GY-16 N941-N43 YL-16 B YL-18 GROUND
1965330 3E3364
593-TC5 GN-14 608-M155 GN-14 780-M171 PU-18 592-M128 BU-18 995-N13 BU-16 A746-N19 PK-16 C GN-18 SIGNAL
593-TC6 GN-14 1 290-M139 BK-18 609-M204 YL-14 E735-M140 PU-18 ACCESSORY POWER CONNECTOR 1 104-M78 YL-14 A513-M94 PK-18

H-13
593-TC7 GN-14 CONN 15 291-M141 BK-18 E735-M140 PU-18 F790-M57 BR-18 (SWITCHED) 200-M87 BK-14 996-N1 GN-16 996-N40 GN-16
200-BK

H-6

H-9

H-8
2 2
NN-C1

H-4
200-TC9 BK-14 200-TC9 BK-14 3 E735-M140 PU-18 E793-M167 BU-18 G731-M59 GY-18 996-N41 GN-16 N-C12 ATM PRESSURE
3E5179 3E3370
593-TC7 GN-14 200-TC8 BK-14 4 201-M142 BK-18 E794-M158 YL-18 F842-M199 BU-18 1118125
CONN 45

10
11
12
1
2
3
4
5
6
7
8
9
892-M123 BR-18 F843-M214 YL-18 999-N30 WH-16 N940-N53 BU-16 A OR-18 +5V
158-T15 BR-14 DATALINK SERVICE CONNECTOR M-C24 893-M124 GN-18 N-C2 C967-N9 BU-16 N941-N47 YL-16 B YL-18 GROUND
1552269 1552252
ROPS A/C M-C18 200-M153 BK-14 F848-M117 OR-18 FLEXXAIRE FAN A747-N17 GY-16 C GN-18 SIGNAL
9W1951
ROPS LIGHTING (STD,WD) 200-T6 BK-14 176-M112 YL-14 1 200-M14 BK-14 F849-M118 WH-18 CONN 41 (CUSTOM PRODUCT) N940-N49 BU-16
CJ-C2

A702-N10 PU-16
A703-N15 BR-16
A704-N18 GN-16
A705-N23 BU-16
A706-N28 GY-16
E799-N33 BR-16
L985-N22 YL-16
F701-N35 BR-16
L984-N14 OR-16
F700-N37 BU-16
200-T8 BK-14 A 106-M134 RD-18 200-M166 BK-14 2 F850-M217 PK-18 N940-N50 BU-16
CONN 6

A701-N6 GY-16

L983-N5 WH-16
200-T10 BK-14 B 201-M147 BK-18 NOTE E 200-M203 BK-18 H-6 C-C7 CJ-C1 F708-CJ2 YL-18 3E3364 N940-N51 BU-16 N-C13 ENGINE OIL PRESS
1552272 3E3376 3E3370 1112350
C 200-M160 BK-10 975-M168 WH-18 F709-CJ3 BU-18 N942-CJ4 OR-18 1 N940-N52 BU-16
D 893-M124 GN-18 977-M113 YL-18 H-7 H-7 N942-C20 OR-18 1 N942-CJ4 OR-18 998-CJ7 BR-18 2 N940-N29 BU-16 N940-N53 BU-16 N940-N54 BU-16 A OR-18 +5V
608-TR1 GN-14 608-T4 GN-14 200-T13 BK-14 CONN 14 E 892-M123 BR-18 G939-M12 PK-18 998-C47 BR-18 2 998-CJ1 BR-18 N940-N54 BU-16 N941-N45 YL-16 B YL-18 GROUND
H-11 CJ-C3
200-TR2 BK-14 200-T6 BK-14 200-T18 BK-14 F 321-M7 BR-18 G939-M181 PK-18 F708-C18 YL-18 3 F708-CJ2 YL-18 998-CJ1 BR-18 N940-N55 BU-16 994-N8 GY-16 C GN-18 SIGNAL
1552272
609-TR3 YL-14 609-T21 YL-14 200-T17 BK-14 G 630-M64 GY-16 F709-C19 BU-18 4 F709-CJ3 BU-18 998-CJ5 BR-18
E 200-TR4 BK-14 200-T18 BK-14 H E793-M167 BU-18 779-M170 WH-18 OPERATOR PLATFORM OPERATOR PLATFORM 998-CJ6 BR-18 F709-CJ3 BU-18 1 N941-N42 YL-16 E
200-T16 BK-14 J E794-M158 YL-18 780-M171 PU-18 998-CJ7 BR-18 998-CJ5 BR-18 2 N941-N43 YL-16 N-C14 FUEL TEMP SENS
975-M110 WH-18 516-EE3 GN-14 CONN 31 998-CJ6 BR-18 3 N941-N44 YL-16 1698670 1022240
CONN 13 M-C23 JM-C1 CONN 31
B C
EE-C1 BLOWER1 N942-CJ4 OR-18 F708-CJ2 YL-18 4 N941-N45 YL-16 N940-N55 BU-16 A OR-18 +V
1552252 176-M112 YL-14 517-EE4 BU-14 3E3364 3E6387 1552264 E-C17 JE-C1 N941-N25 YL-16 N941-N46 YL-16 N941-N46 YL-16 B BK-18 GROUND
A D
521-T14 YL-14 608-T1 GN-14 1 608-M155 GN-14 200-M166 BK-14 515-EE7 GY-14 1 BK-14 1 3E3388 1552264 N941-N47 YL-16 A751-N3 YL-16 C WH-18 SIGNAL
BLOWER RESISTOR MOTOR WHEN USED PLUG INTO C-C7
200-T10 BK-14 2 200-M153 BK-14 1259740 200-EE9 BK-14 2 WH/RD-14 2 201-JM1 BK-18 1958710 270-E70 BK-18 1 103-E55 RD-18 N941-N48 YL-16
608-T4 GN-14 158-T15 BR-14 3 158-M144 BR-14 C568-EE12 WH-14 3 EEC CODE PLUG 271-E58 BK-18 2 103-E7 RD-18
608-T3 GN-14 521-T14 YL-14 4 521-M159 YL-14 4 272-E63 BK-18 3 200-JE1 BK-18 103-E36 RD-14 201-C52 BK-18 CONN 44 N944-N24 PU-16 N944-N38 PU-16
CONN 5 608-T1 GN-14 200-T16 BK-14 5 200-M206 BK-14 4 SPEED BLOWER SW
515-EE6 GY-14 EE-C2 BLOWER2 5 201-JM2 BK-18 273-E67 BK-18 4 200-JE2 BK-18 C-C6 TURBO INLET PRESS SENS 443-C51 YL-18 N944-N39 PU-16
1571361 1552269 3E6386 3E3370 1619926 NOTE E C-C13 N-C3
609-T19 YL-14 6 609-M204 YL-14 LEFT WASHER 515-EE1 GY-14 515-EE7 GY-14 6 274-E65 BK-18 5 200-JE3 BK-18 450-C53 YL-18 1552264 3E3388
447-T11 PK-18 7 447-M150 PK-18 7T8891 515-EE8 GY-14 515-EE8 GY-14 1 BK-14 7 201-JM3 BK-18 275-E60 BK-18 6 105-E5 RD-18 997-C28 OR-18 A OR-18 +5V 709-C60 OR-18
609-T21 YL-14 201-T12 BK-18 8 201-M154 BK-18 200-HH6 BK-18
2
MOTOR
1
529-HH3 WH-18 E-C2 200-EE2 BK-14 2 WH/RD-14
MOTOR
8 201-E71 BK-18 7 200-JE4 BK-18 108-E56 BU-16 CONN 40 993-C29 BR-18 B YL-18 GROUND 975-C59 WH-18 1 F700-N36 BU-16
608-TV1 GN-14 608-T3 GN-14 609-T20 YL-14 9 780-M171 PU-18 1552273 200-EE9 BK-14 NOTE E 8 201-E71 BK-18 113-E74 OR-18 M-C32 M-C33 CF-C1 F714-C30 PK-18 C GN-18 SIGNAL 2 E799-N32 BR-16
1 1552267 3E3370 3E3370
200-TV2 BK-14 200-T8 BK-14 609-T19 YL-14 10 779-M170 WH-18 HH-C2 6
BK 1 124-E30 GN-14 200-EE10 BK-14 200-EE2 BK-14 E-C7 201-E99 BK-18 115-E8 RD-14 E908-C56 BR-18 3 F713-N27 OR-16
609-TV3 YL-14 609-T20 YL-14 11 200-M14 BK-14 FRONT WASHER WH 6 200-EE11 BK-14 8T9834 113-M99 OR-18 A A 116-CF2 BR-16 E909-C57 WH-18 F702-C27 GN-18 4 F702-N26 GN-16
3T4412
200-TV4 BK-14 200-T17 BK-14 12 630-M64 GY-16 7T8891 5
GY 5 C568-E25 WH-14 522-EE5 WH-14 + BATTERY 1 113-E74 OR-18 411-E1 PK-18 B B 307-CF1 OR-16 H-13 F708-C18 YL-18 G939-C54 PK-18 5 F704-N20 OR-16
2 1 4
MOTOR 506-HH4 PU-18 3
GN 4 516-E27 GN-14 THERMOSTAT
GROUND 2 201-E57 BK-18 201-E71 BK-18 663-E103 GY-18 337-M138 WH-18 C C 337-CF3 WH-16 F709-C19 BU-18 G939-C55 PK-18 F714-C30 PK-18 6 F714-N2 PK-16
CONN 12 BU 3 3E5464 HARNESS CODE 1 3 271-E58 BK-18 ACTION LAMP
600-E94 BR-18 K977-C61 PK-18 7 T920-N21 YL-16
M-C10 BR 2 °T ACTION ALARM 4 410-E37 WH-18 1230304 337-M137 WH-18 F714-C30 PK-18 K978-C58 BU-18 8 F701-N34 BR-16 A701-N6 GY-16
1552269 HH-C3 2
447-T11 PK-18 3T4412 CAT DATA LINK + 5 893-E59 GN-18 113-E74 OR-18 116-E35 RD-14 337-M136 WH-18 FOR ENGINE PRELUBE 993-C29 BR-18 A702-N10 PU-16
201-T12 BK-18 1 975-M110 WH-18 HARNESS CODE 5 6 275-E60 BK-18 E-C25 200-E95 BK-18 124-E30 GN-14 PLUG CF-C1 INTO M-C32 997-C28 OR-18 108-C13 BU-16 ADEM-II ENGINE CONTROL A703-N15 BR-16 E799-N32 BR-16
2 321-M7 BR-18 REAR WASHER 522-E92 WH-14 7 1 2 1182765 200-E97 BK-18 113-M99 OR-18 998-C47 BR-18 200-C6 BK-14 C-C14 J1 (A KEY) 1457806 J2 (B KEY) N-C1 A704-N18 GN-16 F700-N36 BU-16
7T8891 C 3E6286 3E6287
2 1 E-C14 EE-C3 8 200-E104 BK-18 450-M175 YL-18 CONN 43 N942-C20 OR-18 207-C17 BK-18 A705-N23 BU-16 F701-N34 BR-16

H-7
200-HH7 BK-18 MOTOR 507-HH1 WH-18 200-E93 BK-14 1552273 3E3382 FUEL LEVEL 9 447-E61 PK-18 201-E99 BK-18 200-E105 BK-18 140-E34 BU-18 103-M77 RD-14 709-M15 OR-18 302-C45 OR-18 18 BACKUP SPD TIMING SNSR + OPTIONAL ACTIVE S/T POWER 1 996-N1 GN-16 A706-N28 GY-16 F702-N26 GN-16
OPERATOR PLATFORM C568-E25 WH-14 1 C568-EE12 WH-14 HYD OIL TEMP 10 442-E62 GY-18 411-E113 PK-18 201-E52 BK-18 140-E119 BU-18 105-M98 RD-18 200-M166 BK-14 E793-M167 BU-18 M-C22 C-C1 304-C50 WH-8 12 BACKUP SPD TIMING SNSR - TURBO INLET PRESSURE 2 F714-N2 PK-16 A745-N12 WH-16
AC SW 2 200-EE10 BK-14 11 411-E79 PK-18 411-E1 PK-18 201-E53 BK-18 140-E120 BU-18 108-M100 BU-16 200-M203 BK-18 E794-M158 YL-18 3E6286 1130580 310-C7 PU-18 E793-C40 BU-18 1 ATA DATALINK - FUEL TEMPERATURE 3 A751-N3 YL-16 A746-N19 PK-16 F704-N20 OR-16
HH-C4 1259257
CAB RIGHT WASHER 3T4412 515-E26 GY-14 3 515-EE1 GY-14 HARNESS CODE 2 12 272-E63 BK-18 201-E57 BK-18
CONN 34 NOTE E 113-M75 OR-18 200-M206 BK-14 610-M186 OR-14 1 610-C2 OR-14 F715-C32 PU-18 2 THROTTLE SW (LOW IDLE) BOTTOM S/T- / TDC PROBE - 4 F724-N4 PU-16 A747-N17 GY-16 F713-N27 OR-16
7T8891 516-E27 GN-14 4 516-EE3 GN-14 ACTION LAMP 13 411-E79 PK-18 RESISTOR 290-E76 BK-18 198-E12 RD-18 114-M72 RD-18 201-M142 BK-18 975-M69 WH-18 302-M157 OR-18 2 302-C45 OR-18 322-C3 GY-18 892-C43 BR-18 3 CAT DATALINK - INJECTOR COMMON 1 & 2 5 L983-N5 WH-16 A751-N3 YL-16 F714-N2 PK-16
2 1 A E-C15
200-HH8 BK-18 MOTOR 530-HH2 OR-18 600- 517-E28 BU-14 5 517-EE4 BU-14 CAT DATA LINK - 14 892-E64 BR-18 1166203 1552269 291-E75 BK-18 200-E93 BK-14 E-C1 M-C2 115-M205 RD-14 201-M147 BK-18 E908-M11 BR-18 200-M178 BK-14 3 200-C6 BK-14 403-C4 GN-18 102-C22 RD-14 4 +BATTERY (UNSWITCHED) INJECTOR 1 6 A701-N6 GY-16 T920-N21 YL-16
E-C21 B 1030213 9X4391
3E7996 1
200-E82 BK-18 6 522-EE5 WH-14 SPI LOAD 15 C414-E40 BU-18 1 663-E103 GY-18 403-E69 GN-18 116-M88 RD-14 201-M154 BK-18 E909-M13 WH-18 310-M84 PU-18 4 310-C7 PU-18 521-C15 YL-14 229-C49 BK-14 5 GROUND 3.5A DRVR & OPT SOL RTRN} 7 E799-N7 BR-16 E799-N33 BR-16
HH-C5 2 CONN 27 HARNESS CODE 4 16 274-E65 BK-18 2 600-E94 BR-18 426-E66 BR-18 200-E97 BK-18 113-E74 OR-18 1 113-M75 OR-18 124-M104 GN-14 202-M198 BK-18 K977-M16 PK-18 522-M193 WH-14 5 522-C16 WH-14 522-C16 WH-14 150-C8 RD-14 6 +BATTERY (SWITCHED) ENGINE OIL PRESSURE 8 994-N8 GY-16 E799-N32 BR-16 A701-N6 GY-16
3T4412 3
567-E29 WH-14 KEY START SW 17 442-E62 GY-18 200-E82 BK-18 201-E15 BK-18 2 201-M151 BK-18 140-M58 BU-18 K978-M17 BU-18 322-M90 GY-18 6 322-C3 GY-18 610-C2 OR-14 E794-C44 YL-18 7 ATA DATALINK + INLET AIR TEMP 9 C967-N9 BU-16 E799-N7 BR-16 A702-N10 PU-16
200-HH5 BK-18 1428858 E-C6 OPERATOR SW INPUT 18 E735-E23 PU-18 443-E68 YL-18 200-E83 BK-18 608-E32 GN-14 3 608-M155 GN-14 140-M202 BU-18 290-M139 BK-18 521-M67 YL-14 7 521-C15 YL-14 F716-C33 WH-18 8 THROTTLE SW (LOW IDLE PARITY) 10 A703-N15 BR-16
LIGHT PIPE2
D LEFT SPEAKER
6T7695 HA-C1 L
4 5
567-E29 WH-14
R
YL-16 1
1552272
308-E3 YL-18 POWERTRAIN FILTER
19
20 426-E66 BR-18
1239294 447-E61 PK-18
600-E96 BR-18
200-E95 BK-18
200-E72 BK-14
124-E30 GN-14
115-E8 RD-14
4
5
124-M104 GN-14
115-M205 RD-14
158-M185 BR-14
160-M201 PU-18
291-M141 BK-18 102-M61 RD-14
108-M65 BU-16
108-M65 BU-16
403-M162 GN-18
8
9
108-C13 BU-16
403-C4 GN-18
F710-C31 BR-18
229-C49 BK-14
893-C5 GN-18 9
10
CAT DATALINK +
INJECTOR 2
11
12 A702-N10 PU-16 F700-N37 BU-16
A704-N18 GN-16
A705-N23 BU-16
D
508-HA11 PU-18 1552273 2 21 E-C18 600-E98 BR-18 200-E93 BK-14 6 200-M207 BK-14 176-M184 YL-18 308-M169 YL-18 130-M176 GN-18 E793-M167 BU-18 10 E793-C40 BU-18 11 HYD FAN (CAT PROP VALVE) 13 F700-N11 BU-16 F700-N36 BU-16 A706-N28 GY-16
+
1 2

GND 6 D OFF C C 3T3158

- 509-HA10 WH-18 504-HA3 YL-18 4 GN-16 MOTOR H 200-E83 BK-18 PU-16 3 307-E4 OR-18 HARNESS CODE 3 22 273-E67 BK-18 663-E101 GY-18 200-E87 BK-18 610-E33 OR-14 7 610-M186 OR-14 198-M71 RD-18 334-M200 BU-18 150-M62 RD-14 E794-M158 YL-18 11 E794-C44 YL-18 229-C49 BK-14 13 FUEL PRESSURE 14 A745-N12 WH-16 F700-N11 BU-16
C ON S
1 521-E84 YL-18 ST B
OR-16 4 105-E5 RD-18 SERVICE 23 290-E76 BK-18 663-E102 GY-18 200-E16 BK-14 8 200-M152 BK-14 200-M152 BK-14 337-M136 WH-18 200-M178 BK-14 130-M176 GN-18 12 F710-C31 BR-18 F717-C34 YL-18 14 THROTTLE SW (HIGH IDLE) COOLANT TEMPERATURE 15 995-N13 BU-16 E799-N33 BR-16
200-HA5 BK-16 2 BK-16 T° 200-E83 BK-18 BR-16 SENSOR SUPPLY 24 200-E95 BK-18 200-E104 BK-18 116-E35 RD-14 9 116-M88 RD-14 200-M203 BK-18 207-M156 BK-18 F715-M1 PU-18 13 F715-C32 PU-18 N942-C20 OR-18 15 FLEXXAIRE FAN MAN PURGE SW COOLANT FLOW SWITCH 16 F700-N37 BU-16
108-HA1 BU-16 108-HA1 BU-16 6 GY-16 SPI CLOCK 25 E708-E46 PK-18 600-E96 BR-18 E735-E23 PU-18 200-E105 BK-18 609-E31 YL-14 10 609-M187 YL-14 200-M207 BK-14 447-M150 PK-18 H-8 F716-M52 WH-18 14 F716-C33 WH-18 102-C22 RD-14 16 INJECTOR COMMON 3 & 4 17 L984-N14 OR-16 F701-N35 BR-16 F701-N35 BR-16
B+ P
B B H
503-HA4 BR-18 3 BR-16 CONN 22 200-E82 BK-18 E-C24 26 892-E64 BR-18 200-E16 BK-14 105-E5 RD-18 11 105-M98 RD-18 521-M159 YL-14 302-M157 OR-18 F717-M53 YL-18 15 F717-C34 YL-18 150-C8 RD-14 17 INJECTOR 3 18 A703-N15 BR-16 F701-N34 BR-16 L983-N5 WH-16
505-HA2 BU-18 505-HA2 BU-18 5 OR-16 H-C3 HH-C1 521-E100 YL-18 2 1
1552267 27 LIGHT PIPE 893-E59 GN-18 307-E4 OR-18 12 200-M179 BK-14 200-M63 BK-14 592-M129 BU-14 304-M96 WH-8 F718-M2 BU-18 16 F718-C42 BU-18 F721-C38 GY-18 19 START AID SW OPTIONAL RETARDER SOL LO/HI 19 F701-N16 BR-16 F701-N16 BR-16 L984-N14 OR-16
1552273 3E3382 521-E85 YL-14 521-E85 YL-14 YL-18 A POWERTRAIN TEMP 28 443-E68 YL-18 1239294 N931-E80 GY-18 308-E3 YL-18 13 308-M132 YL-18 200-M149 BK-10 H-11 310-M84 PU-18 F702-M56 GN-18 17 F702-C27 GN-18 F718-C42 BU-18 20 THROTTLE SW (HIGH IDLE PARITY) ATMOSPHERIC PRESSURE 20 A747-N17 GY-16 L985-N22 YL-16
REAR WIPER
4 3
REAR WIPER SW 1477979 507-H1 WH-18 1 507-HH1 WH-18 BR-18 B 998-E111 BR-18 29 1 2

E-C19 410-E37 WH-18 201-E99 BK-18 103-E36 RD-14 14 103-M77 RD-14 200-M87 BK-14 608-M155 GN-14 403-M162 GN-18 998-M82 BR-18 18 998-C26 BR-18 A700-C24 OR-18 21 21
108-HA29 BU-16

3T6655 C 3T3158
530-H2 OR-18 2 530-HH2 OR-18 600-E81 BR-18 BK-18 C F721-E107 GY-18 ALTERNATOR 30 403-E69 GN-18 201-E71 BK-18 108-E56 BU-16 15 108-M100 BU-16 609-M204 YL-14 892-M182 BR-18 A700-M54 OR-18 19 22 INJECTOR 4 22 A704-N18 GN-16 F702-N26 GN-16 A745-N12 WH-16
CONN 11 529-H3 WH-18 3 529-HH3 WH-18 START AID SW HARNESS CODE 0 31 270-E70 BK-18 201-E53 BK-18 630-E73 GY-16 16 630-M64 GY-16 200-M74 BK-10 630-M64 GY-16 893-M174 GN-18 F721-M60 GY-18 20 F721-C38 GY-18 23 TURBO OUTLET PRESSURE 23 A746-N19 PK-16 F704-N20 OR-16 A746-N19 PK-16
L
504-HA3 YL-18 HA-C3 506-H4 PU-18 4 506-HH4 PU-18 REAR FLOODS SW 1339405 32 200-E97 BK-18 105-E5 RD-18 201-E52 BK-18 600-E114 BR-18 17 600-M51 BR-18 200-M22 BK-18 200-M166 BK-14 779-M170 WH-18 892-M182 BR-18 21 892-C43 BR-18 F719-C36 BR-18 24 CRANK W/O INJECT (N.C.) USER SHUTDOWN 24 F704-N20 OR-16 F713-N27 OR-16 A747-N17 GY-16
W P H-C1
1552252 3E5179 200-H5 BK-18 5 200-HH5 BK-18 3E-8767 CLEAR 33 291-E75 BK-18 600-E98 BR-18 201-E21 BK-18 18 200-M190 BK-14 200-M206 BK-14 780-M171 PU-18 201-M93 BK-18 893-M174 GN-18 22 893-C5 GN-18 E793-C40 BU-18 F720-C37 GN-18 25 CRANK W/O INJECT (N.O.) 25 F714-N2 PK-16 A751-N3 YL-16
503-HA4 BR-18 500-HA17 BR-18 1 500-H17 BR-18 6
A
REAR FLOODS &RIPPER INSTRUMENT SUPPLY 34 E707-E49 GN-18 201-E38 BK-18 19 E735-M140 PU-18 308-M215 YL-18 102-M61 RD-14 23 102-C22 RD-14 E794-C44 YL-18 26 CAN SHIELD GROUND 26 T920-N21 YL-16 F724-N4 PU-16 F724-N4 PU-16
507-HA20 WH-18 508-HA11 PU-18 2 508-H26 PU-18 600-E86 BR-18 3E8769 SPI DATA 35 C413-E43 YL-18 113-E74 OR-18 307-E4 OR-18 201-E15 BK-18 20 201-M151 BK-18 F790-M57 BR-18 322-M90 GY-18 150-M62 RD-14 24 150-C8 RD-14 27 INJECTOR COMMON 5 & 6 27 L985-N22 YL-16 F723-N31 PK-16 F723-N31 PK-16
E-C22 B
501-HA16 GN-18 3 501-H18 GN-18 3E7996 1
200-E87 BK-18 36 200-E104 BK-18 308-E3 YL-18 201-E54 BK-18 G939-E2 PK-18 21 G939-M121 PK-18 G731-M59 GY-18 443-M10 YL-18 25 443-C51 YL-18 F708-C18 YL-18 28 FLEXXAIRE FAN PULL SOL INJECTOR 5 28 A705-N23 BU-16
525-HA12 GY-18 4 525-H14 GY-18 H-C4 L 2
37 200-E105 BK-18 201-E38 BK-18 892-E64 BR-18 22 892-M122 BR-18 201-M91 BK-18 F842-M199 BU-18 443-M10 YL-18 201-M93 BK-18 26 201-C52 BK-18 F702-C27 GN-18 998-C35 BR-18 29 DIGITAL SENSOR RETURN COOLANT FLOW SW RETURN 29 N944-N24 PU-16
524-HA13 BU-18 5 524-H13 BU-18 1552273
GND 3
38 201-E52 BK-18 E735-E22 PU-18 201-E21 BK-18 893-E59 GN-18 23 893-M111 GN-18 201-M93 BK-18 F843-M214 YL-18 521-M67 YL-14 450-M175 YL-18 27 450-C53 YL-18 993-C29 BR-18 30 ANALOG SENSOR RETURN ENGINE ANALOG SENSOR RETURN 30 N941-N25 YL-16 994-N8 GY-16
523-HA14 BR-18 6 523-H12 BR-18 527-H8 GN-18 4 GN-16 MOTOR H 39 201-E53 BK-18 F721-E107 GY-18 201-E57 BK-18 447-E61 PK-18 24 447-M150 PK-18 201-M145 BK-18 522-M193 WH-14 G939-M196 PK-18 28 G939-C54 PK-18 F708-C18 YL-18 31 DECELERATOR PEDAL 31 F702-N26 GN-16 995-N13 BU-16 994-N8 GY-16
B B H 2
528-HA7 PK-18 509-HA10 WH-18 7 509-H25 WH-18 1
4 5
HYDRAULIC FILTER 40 N931-E80 GY-18 201-E57 BK-18 442-E62 GY-18 25 442-M126 GY-18 201-M147 BK-18 F848-M117 OR-18 610-M186 OR-14 G939-M197 PK-18 29 G939-C55 PK-18 F709-C19 BU-18 32 32 F713-N27 OR-16 996-N1 GN-16 995-N13 BU-16
T° 3
502-HA15 OR-18 8 502-H19 OR-18 200-H6 BK-16 2 BK-16 CATERPILLAR MONITORING SYSTEM 290-E76 BK-18 F848-E14 OR-18 N931-E80 GY-18 26 N931-M133 GY-18 201-M142 BK-18 F849-M118 WH-18 A700-M54 OR-18 E908-M11 BR-18 30 E908-C56 BR-18 F714-C30 PK-18 33 CAN DATA LINK + 33 999-N30 WH-16 996-N1 GN-16
CONN 4 RIGHT WIPER SW 103-HA24 RD-18 9 103-H21 RD-18 108-H10 BU-16 6 GY-16
6 1847766 H-24 202-E89 BK-18 F848-E14 OR-18 27 F848-M117 OR-18 F850-M217 PK-18 F702-M56 GN-18 E909-M13 WH-18 31 E909-C57 WH-18 F715-C32 PU-18 F709-C19 BU-18 34 FLEXXAIRE FAN PUSH SOL INJECTOR 6 34 A706-N28 GY-16 C967-N9 BU-16 999-N30 WH-16
B+ P 6 D
108-HA28 BU-16

ME-C1 ME-C2 3T6655 5

BACKUP ALARM
1552269 3E3364
10 526-H7 YL-18 3 BR-16
C
291-E75 BK-18 F849-E13 WH-18 202-E121 BK-18 291-E75 BK-18 28 291-M141 BK-18 201-M127 BK-18 F715-M1 PU-18 K978-M17 BU-18 32 K978-C58 BU-18 F716-C33 WH-18 A700-C24 OR-18 35 DIGITAL SENSOR +8V 35 L983-N5 WH-16 C967-N9 BU-16
1236449 11 528-H9 PK-18 5 OR-16 6 E-C9 403-E69 GN-18 202-E122 BK-18 290-E76 BK-18 29 290-M139 BK-18 201-M154 BK-18 977-M113 YL-18 F716-M52 WH-18 975-M69 WH-18 33 975-C59 WH-18 F717-C34 YL-18 997-C28 OR-18 36 ANALOG SENSOR POWER +5V ENGINE ANALOG SENS PWR +5V 36 N940-N29 BU-16 L984-N14 OR-16 N940-N29 BU-16
L GAUGE CLUSTER
BK-18 2 975-ME2 WH-18 2 527-HA8 GN-18 12 RIGHT WIPER 1666928 1552273 410-E37 WH-18 977-E18 YL-18 521-E85 YL-14 30 521-M68 YL-14 201-M26 BK-18 975-M168 WH-18 F717-M53 YL-18 709-M15 OR-18 34 709-C60 OR-18 F718-C42 BU-18 37 OPTIONAL ACTIVE S/T 37 999-N30 WH-16 L985-N22 YL-16 N941-N25 YL-16
W P
BK-18 1 321-ME1 BR-18 1 1171881 +V DISPLAY OR-18 1 E707-E48 GN-18 426-E66 BR-18 998-E111 BR-18 290-E76 BK-18 A513-E77 PK-18 31 A513-M94 PK-18 201-M28 BK-18 G939-M12 PK-18 F718-M2 BU-18 K977-M16 PK-18 35 K977-C61 PK-18 F721-C38 GY-18 38 38 N940-N29 BU-16 N944-N24 PU-16
526-HA9 YL-18 108-H20 BU-16 608-E32 GN-14 GROUND BK-18 2 201-E52 BK-18 442-E62 GY-18 G939-E17 PK-18 291-E75 BK-18 522-E92 WH-14 32 522-M193 WH-14 G939-M181 PK-18 H-12 F721-M60 GY-18 207-M156 BK-18 36 207-C17 BK-18 892-C43 BR-18 39 CAN DATA LINK - BOTTOM S/T+ / TDC PROBE + 39 F723-N31 PK-16 N941-N25 YL-16
530-HA21 OR-18 108-H28 BU-16 H-C6 L 630-E73 GY-16 E-C11 CLOCK GN-18 3 E708-E45 PK-18 443-E68 YL-18 G939-E19 PK-18 307-E4 OR-18 426-E66 BR-18 33 426-M101 BR-18 202-M198 BK-18 998-M102 BR-18 308-M215 YL-18 37 893-C5 GN-18 F710-C31 BR-18 40 START AID RELAY 40 N944-N24 PU-16
108-H10 BU-16 1552273 1552267 DATA WH-18 4 C413-E42 YL-18 447-E61 PK-18 308-E3 YL-18 E735-E24 PU-18 34 E735-M140 PU-18 290-M139 BK-18 998-M55 BR-18 38 993-C29 BR-18 GROUND STRAP TIE POINT T920-N21 YL-16
WINCH SOL
CONN 3 108-H15 BU-16 524-H13 BU-18 4 GN-16
GND
MOTOR H LAMP SW
2 1
YL-18 A F849-E13 WH-18 LOAD YL-18 5 C414-E41 BU-18 663-E101 GY-18 F849-E13 WH-18 35 F849-M118 WH-18 291-M141 BK-18 998-M70 BR-18 39 997-C28 OR-18

H-20
4 3
1529095 KW-C2 1753950
1552269
KW-C1 108-H22 BU-16 1 BR-18 B F848-E14 OR-18 HARNESS CODE BU-18 6 663-E102 GY-18 403-E69 GN-18 977-E18 YL-18 36 977-M113 YL-18 200-M87 BK-14 998-M82 BR-18 40 N942-C20 OR-18 ENGINE
1552267 108-H32 BU-16 200-H11 BK-16 2 BK-16 T° BK-18 C G939-E17 PK-18 E735-E23 PU-18 124-E30 GN-14 411-E1 PK-18 592-E78 BU-18 37 592-M95 BU-18 308-M216 YL-18
B B H 1 H-10
780-KW2 PU-18 780-KW1 PU-18 525-HA12 GY-18 CONN 10 108-H15 BU-16 892-E64 BR-18 200-E82 BK-18 426-E66 BR-18 443-E68 YL-18 443-M10 YL-18 998-C35 BR-18
C C
BK-18 1 A 6 GY-16 P BI DIRECTIONAL MODE SW LAMP LAMP 38 M-C29 C-C12
B+ 1339405 1239294 1239294 1275485 1275486
108-HA27 BU-16

BK-18 2 779-KW4 WH-18 B HA-C2 H-C2 523-H12 BR-18 3 BR-16

C C
1 2

893-E59 GN-18 200-E93 BK-14 442-E62 GY-18 403-E69 GN-18 39 403-M194 GN-18 308-M169 YL-18 592-M128 BU-18 G939-M196 PK-18
780-KW3 PU-18 C LEFT WIPER SW 3E5179 1552252 525-H14 GY-18 5 OR-16 E-C13 E-C12 E-C20
N931-E80 GY-18 200-E83 BK-18 443-E68 YL-18 F721-E107 GY-18 40 F721-M60 GY-18 308-M132 YL-18 308-M216 YL-18 592-M188 BU-12 G939-M197 PK-18 304-M96 WH-8 1 304-C50 WH-8 998-C26 BR-18 CYL LIGHTS (STD, WD)
3T6655 108-HA6 BU-16 2 108-H32 BU-16 1552267 447-E61 PK-18 411-E1 PK-18 41 411-M89 PK-18 308-M215 YL-18 A513-M94 PK-18 998-C47 BR-18
LEFT WIPER 3T3158 3T3158
511-HA18 BR-18 1 511-H30 BR-18 1171882
B1 E-C5 2 1
YL-18 A 200-E104 BK-18 C413-E44 YL-18 521-E85 YL-14 521-E85 YL-14 42 JACKET WATER HEATER CONN 46
L 2 4 3
524-HA13 BU-18 528-HA7 PK-18 3 528-H9 PK-18 1552264 BR-18 B 977-E18 YL-18 663-E101 GY-18 C413-E43 YL-18 522-E92 WH-14 522-E92 WH-14 43 322-M90 GY-18 103-M77 RD-14 NOTE E 1890751 G-C3
W P
512-HA19 GN-18 4 512-H29 GN-18 GY 5 BK-18 C G939-E19 PK-18 200-E105 BK-18 C413-E42 YL-18 600-E81 BR-18 592-E78 BU-18 998-E111 BR-18 44 998-M102 BR-18 105-M98 RD-18 BK 1552269
H-C5 L
523-HA14 BR-18 506-HA23 PU-18 5 506-H4 PU-18 1552273 BR 3 103-E7 RD-18 AUTO DOWNSHIFT SW 663-E102 GY-18 A513-E77 PK-18 198-E12 RD-18 45 198-M71 RD-18 334-M200 BU-18 108-M100 BU-16 BK
H-20 610-G11 OR-14 1 610-TE1 OR-14
GND 1339405
529-HA22 WH-18 526-HA9 YL-18 7 526-H7 YL-18 501-H18 GN-18 4 GN-16 MOTOR H PK 6 115-E8 RD-14 C414-E39 BU-18 103-E7 RD-18 G731-E20 GY-18 46 G731-M59 GY-18 403-M194 GN-18 113-M75 OR-18 GN 200-G9 BK-14 2 200-TE2 BK-14
CONN 2 B2
527-HA8 GN-18 8 527-H8 GN-18 1 BU 2 116-E35 RD-14 E-C8 LAMP GEAR MODULE E-C10 C414-E40 BU-18 115-E8 RD-14 600-E96 BR-18 140-E34 BU-18 47 140-M58 BU-18 411-M89 PK-18 113-M99 OR-18
KA-C1 T° 3 H-24
SWEEP LIGHTING (SIDE) KA-C2
1552269
108-HA6 BU-16 529-HA22 WH-18 9 529-H3 WH-18 200-H16 BK-16 2 BK-16 PU 8
2 1
1552267 1680369 1552273 C414-E41 BU-18 116-E35 RD-14 600-E81 BR-18 202-E89 BK-18 48 202-M198 BK-18 114-M72 RD-18
1552269 530-HA21 OR-18 10 530-H2 OR-18 108-H20 BU-16 6 GY-16 YL 4 600-E90 BR-18 YL-18 A +V DISPLAY OR-18 1 E707-E50 GN-18 200-E87 BK-18 600-E98 BR-18 F790-E106 BR-18 49 F790-M57 BR-18 426-M101 BR-18 115-M205 RD-14
B+ P 4 3
B B H
1 630-KA1 GY-16 1 502-HA15 OR-18 507-HA20 WH-18 11 507-H1 WH-18 500-H17 BR-18 3 BR-16 OR 1 BR-18 B 201-E21 BK-18 GROUND BK-18 2 201-E53 BK-18 E707-E50 GN-18 600-E91 BR-18 600-E94 BR-18 A700-E115 OR-18 50 A700-M54 OR-18 116-M88 RD-14
2 200-KA2 BK-16 2 12 502-H19 OR-18 5 OR-16 7 BK-18 C E735-E22 PU-18 CLOCK GN-18 3 E708-E47 PK-18 E707-E49 GN-18 600-E91 BR-18 998-E116 BR-18 51 998-M55 BR-18 442-M126 GY-18 124-M104 GN-14 CYLINDER LIGHTS (10)
608-TA1 GN-14 FRONT WIPER SW 200-HA25 BK-16 6 200-H33 BK-16 FRONT WIPER
4
OPERATOR MONITOR SW DATA WH-18 4 C413-E44 YL-18 E707-E48 GN-18 F702-E117 GN-18 52 F702-M56 GN-18 140-M58 BU-18 CONN 42
200-TA2 BK-14 RIPPER FLOOD 3T6655 1477976 1339405 LOAD YL-18 5 C414-E39 BU-18 600-E86 BR-18 600-E114 BR-18 F843-E118 YL-18 53 F843-M214 YL-18 140-M202 BU-18 CV-C1 CC-C2
FOR NORMAL C-C10 1552269
609-TA3 YL-14 1470319 609-E31 YL-14 HARNESS CODE BU-18 6 E708-E47 PK-18 600-E90 BR-18 608-E32 GN-14 54 443-M10 YL-18 160-M201 PU-18 OPERATING MODE 3E3370 1552267
L CONN 21 CC-C1
200-TA4 BK-14 W P 501-HA16 GN-18 B3
610-E33 OR-14 ACTION ALARM E-C3 E708-E46 PK-18 609-E31 YL-14 55 447-M150 PK-18 158-M185 BR-14 200 BK-18 A 998-C14 BR-18 3E3364
610-CC4 OR-14 1 CYL FLOOD 1
H-C7 E-C16 3E6328 1470319
CONN 6 200-H6 BK-16 1552272 3E3376
1552269 E708-E45 PK-18 600-E114 BR-18 610-E33 OR-14 56 176-M184 YL-18 B F719-C36 BR-18 610-CC3 OR-14 200-CC5 BK-14 2
500-HA17 BR-18 200-H11 BK-16 BK-18 2 201-E38 BK-18 608-E32 GN-14 630-E73 GY-16 NOTE E 57 521-M180 YL-14 198-M71 RD-18 C F720-C37 GN-18 CONN 46 1 610-CC1 OR-14 610-CC4 OR-14
506-HA23 PU-18 200-H16 BK-16 103-H21 RD-18 1 103-E55 RD-18 RD-18 1 410-E37 WH-18 609-E31 YL-14 58 521-M68 YL-14 521-M159 YL-14 200-M207 BK-14 2 200-CC2 BK-14 200-CC5 BK-14 CC-C3
200-H27 BK-18 108-H22 BU-16 4 108-E56 BU-16 610-E33 OR-14 663-E101 GY-18 59 521-M67 YL-14 H-9 CV-C2 200-CC6 BK-14
1552269
200-H31 BK-14

HA-C4 200-H5 BK-18 A513-H23 PK-18 3 A513-E77 PK-18 630-E73 GY-16 663-E103 GY-18 60 200-M74 BK-10 3E3370 610-CC3 OR-14 1 CYL FLOOD 2
1552267 1470319
592-H24 BU-18 2 592-E78 BU-18 663-E102 GY-18 61 522-M193 WH-14 200-M149 BK-10 201 BK-18 A 200-CC6 BK-14 2
RD-16 A 103-HA24 RD-18 H-25 H-25 103-E55 RD-18 62 200-M152 BK-14 B
WH-16 B 200-HA26 BK-16 CAB 108-E56 BU-16 A700-E115 OR-18 63 592-M128 BU-18 201-M91 BK-18 C
BK-16 C 64 592-M188 BU-12 201-M127 BK-18 NOTE: USE ONLY FOR
H-C8 CRANK WITHOUT FUEL
DOME LAMP 1552264
12V RADIO
NOTE F
SERVICE BRAKE PEDAL SW A513-E77 PK-18 E735-E22 PU-18 65 592-M129 BU-14 201-M145 BK-18 INJECTION SWEEP LIGHTING (08)
1327077
608-TG1 GN-14 3E6389 EROPS THROTTLE JUMPER CONN 32 592-E78 BU-18 E735-E23 PU-18 66 201-M151 BK-18
200-TG2 BK-14 200-HA25 BK-16 592-H24 BU-18 6 RD + BATTERY (12V) E735-E24 PU-18 67 592-M95 BU-18 CA-C2
KK-C1 E-C23 1552269
609-TG3 YL-14 200-HA5 BK-16 A513-H23 PK-18 5 YL +B MEMORY USED ON EROPS MACHINES ONLY 3E3376 1552272
68 403-M194 GN-18
200-TG4 BK-14 ANTENNA 509-H25 WH-18 1 WH/BK,GN/BK LEFT SPKR - 69 A513-M94 PK-18 892-M122 BR-18 CA-C1 610-CA4 OR-14 1 SWEEP FLOOD 1
3E3364
CONN 5 RIGHT SPEAKER
8E1118 508-H26 PU-18 2 WH/GN LEFT SPKR + CONN 30 CONN 30 G731-KK1 GY-18 1 G731-E20 GY-18 F702-E117 GN-18 70 608-M155 GN-14 893-M111 GN-18 IDENT PART NO CHG LOC DESCRIPTION NOTE 610-CA3 OR-14 200-CA5 BK-14 2 1470319
6T7695 200-H27 BK-18 3 BK GROUND 198-KK2 RD-18 2 198-E12 RD-18 F721-E107 GY-18 N931-M133 GY-18 1 610-CA1 OR-14 610-CA4 OR-14
HARNESS AS.
CONN 46 CA-C3
108-H28 BU-16 4 NC F715-RM1 PU-18 3 F790-E106 BR-18 609-M204 YL-14 2 200-CA2 BK-14 200-CA5 BK-14
B +
-
511-HA18 BR-18
512-HA19 GN-18
HEADLINER
GND
512-H29 GN-18
511-H30 BR-18
7
8
GY/BK,PU/BK
GY/PU
RIGHT SPKR -
RIGHT SPKR + WHEN USED
F716-RM2 WH-18
F717-RM3 YL-18 WHEN USED
4 G731-E20 GY-18
892-E64 BR-18
609-M187 YL-14
609-M189 YL-14
609-M191 YL-14 609-M191 YL-14
200-M63 BK-14
H-4 A
C
164-3742
164-3733
03
00
H-9
E-3/G-3
FUSE PANEL
ENGINE
200-CA6 BK-14
610-CA3 OR-14
1552269

1 SWEEP FLOOD 2
B
ANTENNA PLUG INTO F718-RM4 BU-18 PLUG INTO E-C29 893-E59 GN-18 201-M93 BK-18 E 193-8561 00 C-8 DASH 200-CA6 BK-14 2 1470319
HC HC
RA-C1 998-RM5 BR-18 M-C1 1552272 F843-E118 YL-18 308-M215 YL-18 G 185-7157 00 C-2/H-1 RADIATOR GUARD
600-RM6 BR-18 +V RD-18 1 140-E119 BU-18 600-M51 BR-18 322-M90 GY-18 H 169-9635 00 C-12 ROOF ATCH
INCHING PEDAL POSITION J 136-2088 03 G-12 DIFF STEER DRIVETRAIN
CAB 200-RM7 BK-18 1263741 GROUND BK-18 2 202-E121 BK-18 F848-E14 OR-18
USED ON PSDD MACHINES ONLY SIGNAL WH-18 3 F843-E118 YL-18 F849-E13 WH-18 610-M186 OR-14 443-M10 YL-18 L 164-3736 01 A-9/A-13 RH FENDER
M 172-4858 04 C-7/G-14/H-8 PLATFORM
OPERATOR PLATFORM 4 630-M64 GY-16 521-M67 YL-14
H-12 N 145-0176 00 D-2/F-1 BASIC ENGINE
977-E18 YL-18 779-M170 WH-18
THROTTLE SW 998-E111 BR-18 780-M171 PU-18 522-M193 WH-14 P 164-6853 00 H-12/H-14 BASIC TRANSMISSION
E-C27
3E9044 R 194-9380 00 A-9/A-12 RH CONSOLE
ROPS LIGHTING (10) 1552267 998-E116 BR-18 A700-M54 OR-18 610-M186 OR-14
CONN 30 +BAT RD-18 A 140-E120 BU-18 E735-M140 PU-18 A700-M54 OR-18 T 172-4857 02 D-14 FUEL TANK
A BRAKE POSITION SNSR CA 183-1982 00 B-1 RH SWEEP LIGHTS (08) ATCH
M-C1 1471680 GROUND BK-18 B 202-E122 BK-18 114-M72 RD-18 F702-M56 GN-18 F702-M56 GN-18
B 3E3388 CC 183-1982 00 B-1 RH CYLINDER LIGHTS (10) ATCH
SIGNAL YL-18 C F790-E106 BR-18 G939-E2 PK-18 158-M185 BR-14 F715-M1 PU-18 F715-M1 PU-18
1 CF 120-6547 04 E-6/I-4 PRELUBE ATCH
608-TL5 GN-14 322-R1 GY-18 F715-RA1 PU-18 F715-RA1 PU-18 1 F715-M1 PU-18 G939-E19 PK-18 176-M184 YL-18 F716-M52 WH-18 F716-M52 WH-18
2 CG XXX-XXXX -- E-4 DEMAND FAN ATCH
608-TL3 GN-14 200-TL7 BK-14 114-R2 RD-18 F716-RA2 WH-18 2 F716-M52 WH-18 E-C28 G939-E17 PK-18 200-M22 BK-18 F717-M53 YL-18 F717-M53 YL-18
3 CH 183-4273 00 G-4 AIR CONDITIONER ATCH
200-TL4 BK-14 608-TL5 GN-14 609-TL6 YL-14 F718-RA4 BU-18 F717-RA3 YL-18 3 F717-M53 YL-18 1552267 200-M190 BK-14 F718-M2 BU-18 F718-M2 BU-18 CJ XXX-XXXX 00 E-4 FLEXXAIRE FAN CUSTOM PRODUCT
WIRES THAT HAVE BATTERY VOLTAGE WHEN
608-TL3 GN-14 200-TL8 BK-14 5 4
F716-RA2 WH-18 F718-RA4 BU-18 4 F718-M2 BU-18 DECEL PEDAL POSITION
+BAT RD-18 A A700-E115 OR-18 N931-E80 GY-18 201-M26 BK-18 F721-M60 GY-18 F721-M60 GY-18 CV 121-2844 00 C-4 CRANK W/O INJ THE KEY SWITCH IS OFF.
608-TL1 GN-14 998-RA10 BR-18 998-RA5 BR-18 5 998-M70 BR-18 GROUND BK-18 B 998-E116 BR-18 201-M28 BK-18 F790-M57 BR-18 998-M55 BR-18
CONN 6 1602443 EE 172-9290 00 D-10 BLOWER
WIRES THAT HAVE BATTERY VOLTAGE WHEN
D 6
F717-RA3 YL-18 600-RA6 BR-18 6 600-M51 BR-18 SIGNAL YL-18 C F702-E117 GN-18 322-M90 GY-18 G731-M59 GY-18 998-M70 BR-18 HA 169-9636 00 C-13 HEADLINER ATCH
200-TL4 BK-14 779-RW4 WH-18 C
200-RA7 BK-18 7 200-M22 BK-18 411-M89 PK-18 892-M122 BR-18 998-M102 BR-18 HH 150-9046 01 D-11 WASHER PUMP ATCH THE KEY SWITCH IS ON.
200-TL2 BK-14 8 426-M101 BR-18 893-M111 GN-18 G939-M196 PK-18 KA 160-8769 01 A-15 RIPPER FLOOD ATCH
608-TL1 GN-14 200-TL7 BK-14 201-R7 BK-18 OPERATOR PLATFORM 442-M126 GY-18 F842-M199 BU-18 G939-M197 PK-18 KK 164-9541 00 B-8 SERVICE BRAKE
STARTING CIRCUIT.
200-TL2 BK-14 411-R8 PK-18 M-C35
CONN 29 521-M180 YL-14 F843-M214 YL-18
3E3388 H-23 KW 170-4891 00 A-15 WINCH (REAR) ATCH SYMBOL DESCRIPTION
779-RW3 WH-18
BLADE FLOAT CTRL
THIS DIAGRAM IS FOR THE D7X DIFFERENTIAL STEER ME 179-0787 00 I-15 BACKUP ALARM PIGTAIL CATERPILLAR MONITORING SYSTEM CIRCUIT.
176-RW1 YL-18 200-RA8 BK-18 200-RA7 BK-18 780-R4 PU-18 1 780-M171 PU-18 600-M51 BR-18 F848-M117 OR-18 TRACTOR 172-6083 CHG. 02 MF 172-4855 00 A-8 IMPLEMENT LOCKOUT
2000189 BLADE, SPADE, RING,
600-RA11 BR-18 176-R5 YL-18 2 176-M184 YL-18 MF-C2 779-M170 WH-18 F849-M118 WH-18 MG 185-5628 00 F-8 20A CONVERTER PIGTAIL ATCH PANEL LAMP CIRCUIT. OR SCREW TERMINAL
CONN 20 600-RA6 BR-18 779-R9 WH-18 3 779-M170 WH-18 1552269 780-M171 PU-18 F850-M217 PK-18 FOR A SINGLE SHEET VERSION OF THIS DIAGRAM MP 210-2509 00 I-14 XMSN JUMPER
CONN 9 998-RA13 BR-18 322-R1 GY-18 4 322-M90 GY-18 BK-18 1 334-MF5 BU-18 F715-M1 PU-18 CONTACT DESIGN CONTROL MR 184-4761 00 I-12 LH FENDER LIGHTS ATCH
HYD OIL TEMP SW
4W9972 AH-C1 L-C2 998-RA5 BR-18 114-R2 RD-18 5 114-M72 RD-18 BK-18 2 975-MF3 WH-18 140-MF9 BU-18 F716-M52 WH-18 975-M168 WH-18 MT 184-4761 00 A-11 RH FENDER LIGHTS ATCH TURN SIGNAL AND WASHER/WIPER CIRCUIT. SPLICE

608-TH3 GN-14 608-TH5 GN-14 3E3364 779-RW5 WH-18 779-R9 WH-18 201-R7 BK-18 201-M28 BK-18 F717-M53 YL-18 977-M113 YL-18 WIRE AS.
1552269 6
137-9755
COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE NN 4P-9537 03 E-2 INJECTOR CIRCUIT NOT CONNECTED
200-TH4 BK-14 608-TH5 GN-14 200-TH7 BK-14 200-AH1 BK-18 1 442-L3 GY-18 176-RW1 YL-18 176-R5 YL-18 411-R8 PK-18 7 411-M89 PK-18 DETENT COIL F718-M2 BU-18 998-M55 BR-18 MACHINE WITH THE KEY AND ENGINE OFF AND AG 171-7215 00 G-8/I-11 PP 144-7872 00 H-13 TRANSMISSION HEATER AND AIR CONDITIONER CIRCUIT.
608-TH3 GN-14 609-TH6 YL-14 2 201-L4 BK-18 780-RW6 PU-18 780-R4 PU-18 8 MF-C3 334-MF1 BU-18 998-M70 BR-18 998-M70 BR-18 TRANSMISSION SHIFTER IN NEUTRAL. JE 184-6633 00 E-9 RA 160-5574 03 B-10 THROTTLE SW
608-TH1 GN-14 200-TH8 BK-14
T°
1552269 334-MF5 BU-18
CONN 33 998-M102 BR-18 JK 184-0870 00 H-12 RM 194-1094 00 B-10 EROPS THROTTLE JUMPER
ELECTRICAL CONNECTION
H-23 GROUND CIRCUIT. TO MACHINE STRUCTURE

A 200-TH2 BK-14
CONN 5 ATTACH WINCH SW WINCH FREE SPOOL
(ON D7 & D8)
1
2
334-MF6 BU-18
975-MF7 WH-18
334-MF6 BU-18 MF-C1
1552252
M-C13
3E5179 G939-M121 PK-18 G939-M196 PK-18
NOTE A: WITH HARNESS "TL", REPLACE FUSE WITH
8M-0456 (20A) FUSE}
JM
CL
195-8710
172-4860
00
01
E-9
H-10
RW
TA
165-0107
186-0636
03
00
A-12
B-15
WINCH RH CONSOLE
SWEEP LIGHTING (SIDE)
ATCH
ATCH A
201-L2 BK-18 ENGINE CONTROL CIRCUIT. INTERNAL ELECTRICAL
200-TH4 BK-14 OPERATOR PLATFORM IMPLEMENT LOCKOUT SW
F842-MF8 BU-18 334-MF1 BU-18 1 334-M200 BU-18 G939-M197 PK-18 NOTE B: WITH HARNESS "CA" OR "CE", REPLACE FUSE WITH CABLE AS. TC 109-3875 04 E-15 ROPS AC ATCH CONNECTION TO SURFACE
608-TH1 GN-14 200-TH7 BK-14 1890135 MF-C4 F850-MF11 PK-18 F842-MF8 BU-18 2 F842-M199 BU-18 G939-M12 PK-18 8M-8948 (15A) FUSE} AA 167-1882 00 G-8 TE 151-6172 00 C-2 RH CYL LIGHTS (STD, WD) ATCH OF COMPONENT
200-TH2 BK-14 L-C1 M-C17 1552267 140-MF9 BU-18 140-M202 BU-18 G939-M181 PK-18 NOTE C: TIE BACK TO HARNESS WITH STRAP (3S-2093) AM 170-4068 00 I-11 TF 110-2915 00 D-15 FUEL TANK TO ROPS AC ATCH
3E3388 1552264
3 START AID CIRCUIT.
GN-18 C 975-MF10 WH-18 975-MF3 WH-18 975-MF4 WH-18 4 975-M168 WH-18 AN 6T-5267 03 I-11 TG 186-0636 00 B-15 SWEEP LIGHTING (SIDE) ATCH
CONN 19 1 158-M185 BR-14 158-M185 BR-14 WH-18 B 140-MF9 BU-18 975-MF10 WH-18 5 160-M201 PU-18 N931-M133 GY-18 NOTE E: THE FOLLOWING WIRE PAIRS MUST BE TWISTED AP 8V-0622 00 I-11 TH 175-0451 00 C-15 ROPS LIGHTING (10) ATCH
CONNECTOR

2 521-M180 YL-14 521-M180 YL-14 BK-18 A F850-MF11 PK-18 975-MF7 WH-18 6 200-M203 BK-18 AT LEAST 1 TURN / 25 MILLIMETERS: AR 170-4859 00 B-2/I-5 TL 175-0451 00 C-15 ROPS LIGHTING (10) ATCH POWER TRAIN CONTROL CIRCUIT.
ATCH WIRE, CABLE,
3 200-M190 BK-14 200-M190 BK-14 975-MF2 WH-18 F850-MF11 PK-18 7 F850-M217 PK-18 AW 6T-5268 03 H-4/I-10 TM 183-1982 00 G-1 LH SWEEP LIGHTS (08) ATCH COMPONENT
IMPLEMENT LOCKOUT SW 2 (892-BR, 893-GN), (E902-PU, E903-YL), AY 7P-6682 01 H-4 TN 183-1982 00 H-1 LH CYLINDER LIGHTS (10) ATCH
426-L1 BR-18 4 426-M101 BR-18 426-M101 BR-18 MF-C5 975-MF4 WH-18 8
CONN 26
1913587
3E3376 (E904-BR, E905-BU), (E900-WH, E901-GN), CE 185-6392 00 H-2 TP 151-6172 00 H-2 LH CYL LIGHTS (STD, WD) ATCH ALL DASHED LINES ARE ATTACHMENTS.
PTRAIN FLT PRESS SW 2 201-L2 BK-18 5 201-M26 BK-18 201-M26 BK-18 9
(E906-OR, E907-GY), (E908-BR, E909-WH), L# CIRCUIT GROUPING
1647577 L-C3 442-L3 GY-18 6 442-M126 GY-18 M-C34 MT-C2 MT-C1 442-M126 GY-18 GN-18 3 10 HC 9U-8746 01 B-12 TR 185-9607 00 E-14 ROPS LIGHTING (STD, WD) ATCH
1552269 1552269 1552269
(450-YL, G939-PK), (E793-BU, E794-YL) HF 167-1880 00 G-7 TV 185-9607 00 D-14 ROPS LIGHTING (STD, WD) ATCH
DESIGNATION
7 3E3364 WH-18 2 F842-MF8 BU-18 11 NOTE F: 173-6530 AM/FM RADIO (U.S.)
BK-18 1 201-L5 BK-18 8
H-22 609-M189 YL-14 1 609-MT2 YL-14 1 WH-18 RH FENDER FLOOD BK-18 1 975-MF2 WH-18 12 173-6532 AM/FM RADIO W/ CASSETTE (U.S.)
BK-18 2 426-L1 BR-18 200-M179 BK-14 2 200-MT1 BK-14 2 BK-18 1355549 4
200-M179 BK-14
H-22 609-M189 YL-14

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1