Icom IC-2200H Service Manual

SERVICE
MANUAL
VHF TRANSCEIVER
i2200H
INTRODUCTION DANGER
This service manual describes the latest service information NEVER connect the transceiver to an AC outlet or to a DC
for the IC-2200H VHF TRANSCEIVER at the time of publica- power supply that uses more than 16 V. This will ruin the
tion. transceiver.
MODEL VERSION SYMBOL DO NOT expose the transceiver to rain, snow or any liquids.
Europe EUR DO NOT reverse the polarities of the power supply when con-
Taiwan TPE necting the transceiver.
U.S.A. USA DO NOT apply an RF signal of more than 20 dBm (100 mW)
IC-2200H Korea KOR to the antenna connector. This could damage the transceiv-
Export EXP er’s front end.
Europe-1 EUR-1
Export-1 EXP-1 To upgrade quality, any electrical or mechanical parts and
internal circuits are subject to change without notice or
obligation.
ORDERING PARTS REPAIR NOTES

Be sure to include the following four points when ordering 1. Make sure a problem is internal before disassembling the
replacement parts: transceiver.
2. DO NOT open the transceiver until the transceiver is
1. 10-digit order numbers disconnected from its power source.
2. Component part number and name 3. DO NOT force any of the variable components. Turn
3. Equipment model name and unit name them slowly and smoothly.
4. Quantity required 4. DO NOT short any circuits or electronic parts. An insu-
lated tuning tool MUST be used for all adjustments.
<SAMPLE ORDER> 5. DO NOT keep power ON for a long time when the trans-
ceiver is defective.
1130008350 S.IC LV2105V IC-2200H MAIN UNIT 5 pieces 6. DO NOT transmit power into a signal generator or a
8810009610 Screw FH M2.6×6 ZK IC-2200H Cover 10 pieces sweep generator.
Addresses are provided on the inside back cover for your 7. ALWAYS connect a 40 dB to 50 dB attenuator between
convenience. the transceiver and a deviation meter or spectrum ana-
lyzer when using such test equipment.
8. READ the instructions of test equipment thoroughly
before connecting equipment to the transceiver.
Icom, Icom Inc. and are registered trademarks of Icom Incorporated (Japan) in the United States, the United Kingdom,
Germany, France, Spain, Russia and/or other countries.
TABLE OF CONTENTS
SECTION 1 SPECIFICATIONS
SECTION 2 INSIDE VIEWS
2-1 IC-2200H . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 - 1
2-2 HM-133V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 - 2
SECTION 3 OPTIONAL UNIT INSTALLATION
SECTION 4 CIRCUIT DESCRIPTION
SECTION 5 ADJUSTMENT PROCEDURES
SECTION 6 PARTS LIST
SECTION 7 MECHANICAL PARTS AND DISSASEMBLY
7-1 IC-2200H . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 - 1
7-2 HM-133V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 - 1
SECTION 8 SEMI-CONDUCTOR INFORMATION
SECTION 9 BOARD LAYOUTS
9-1 LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 - 1
9-2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 - 3
9-3 HM-133V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 - 5
9-4 HM-118TN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 - 7
SECTION 10 BLOCK DIAGRAMS
10 - 1 IC-2200H . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 - 1
10 - 2 HM-133V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 - 2
SECTION 11 VOLTAGE DIAGRAMS
11 - 1 LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 - 1
11 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 - 2
11 - 3 HM-133V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 - 3
SECTION 12 HM-118/N (OPTIONAL UNIT)
12 - 1 INSIDE VIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 - 1
12 - 2 BOARD LAYOUTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 - 1
12 - 3 MECHANICAL PARTS LIST AND DISSASEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 - 2
SECTION 13 UT-108 (OPTIONAL UNIT)
13 - 1 BOARD LAYOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 - 1
14 - 1 BOARD LAYOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 - 1
14 - 2 SEMI-CONDUCTOR INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 - 2
14 - 3 BLOCK DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 - 2
14 - 4 VOLTAGE DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 - 3
SECTION 1 SPECIFICATIONS
M GENERAL
• Frequency range :
Version Receive (MHz) Transmit (MHz)
[EUR] 118.000 – 174.000*1 144.000 – 146.000
[USA] 118.000 – 174.000*2 144.000 – 148.000
[EXP], [EXP-1] 118.000 – 174.000*2 136.000 – 174.000*2
[EUR-1], [TPE],
[KOR] 144.000 – 146.000 144.000 – 146.000
*1Specifications guaranteed 144.000 – 146.000 MHz only

2
* Specifications guaranteed 144.000 – 148.000 MHz only
• Mode : FM, AM (Receive only)
• Number of memory channel : 206 (include in 6 band edges memory and 1 call channel)
• Usable temperature range : –10˚C to +60˚C; +14˚F to +140˚F
• Scan type : Full, Program, Priority, Memory channel, Bank, Skip and Tone scans
• Frequency resolution : 5, 10, 12.5, 15, 20, 25, 30 and 50 kHz
• Frequency stability : ±10 ppm (–10˚C to +60˚C; +14˚F to +140˚F)
• Power supply requirement : 13.8 V DC ±15 % (negative ground)
• Current drain (at 13.8 V DC) : Receive Standby (squelched) 0.8 A
Max. audio 1.0 A
Transmit at 65 W or 50 W 15.0 A (except [TPE])
at 25 W 9.0 A
at 24 W 10.0 A ([TPE] only)
at 10 W 6 A (except [TPE])
at 5 W 5A
• Antenna connector : SO-239 (50 Ω)
• Dimensions : 140(W)×40(H)×146(D) mm;
(projections not included) 51⁄2(W)×19⁄16(H)×53⁄4(D) inch
• Weight : Approx. 1.25 kg; 2 lb 12 oz
M TRANSMITTER
• Output power : Version High Middle-high Middle-low Low
except
[TPE], [KOR] 65 W 25 W 10 W 5W
[KOR] 50 W 25 W 10 W 5W
[TPE] 24 W 10 W – 5W
• Modulation system : Variable reactance frequency

• Maximum frequency deviation : ±5.0/±2.5* kHz *except [EXP-1]
• Spurious emissions : Less than –60 dBc
• Microphone connector : 8-pin modular (600 Ω)
M RECEIVER
• Receive system : Double-conversion superheterodyne
• Intermediate frequency : 1st 21.7 MHz
2nd 450 kHz
• Sensitivity (at 12 dB SINAD) : Less than 0.18 µV
• Squelch sensitivity (threshold) : Less than 0.13 µV
• Selectivity : (Wide) More than ±6 kHz at 6 dB, More than ±14 kHz at 60 dB
(Narrow)* More than ±3 kHz at 6 dB, More than ±9 kHz at 55 dB
*except [EXP-1]
• Spurious and image rejection : More than 60 dB
• Audio output power (at 13.8 V) : More than 2.4 W at 10% distortion with an 8Ω load
• External speaker connector : 2-conductor 3.5(d) mm (1⁄8")/8Ω
All stated specifications are subject to change without notice or obligation.
1-1
• UT-115 SPECIFICATIONS
M GENERAL
• Usable temperature range : –10˚C to +60˚C; +14˚F to +140˚F
• Power supply requirement : 5.0 V DC
(4.5 V–8.5 V for AMBE IC VCC line)
• AF input level : 1 Vp-p typical
• Modulation output level : 350 mVp-p typical
• Demodulation input level : 500 mVp-p typical
• AF output level : 750 mVp-p typical
• CODEC type : AMBE
• Transfer speed : 4.8 kbps
• Control signal input voltage : 3.0 V–5.0 V for High
0 V for Low
• Control signal output voltage : Open collector for High
0 V for Low
• Current drain (at 5.0 V DC) : 55 mA typical
• Dimentions : 30(W)×38(D) mm;
(projections not included) 13⁄16(W)×11⁄2(D) inch
• Weight : Approx. 6 g; 7⁄32 oz
(accessoreis not included)
• Connector : AXN430C330
All stated specifications are subject to change without notice or obligation.
1-2
SECTION 2 INSIDE VIEWS
2-1 IC-2200H
• MAIN UNIT (TOP VIEW)
Power module
Power switch circuit (IC10: S-AV36)
Q28*: 2SC4684
Q30: DTA143TUA
Q31: DTC143ZU
Speaker
Discriminator
(X2: CDB450C24)
AF power amplifier 2nd
IF filter
IF filter
(IC9: TA7252AP) FI1: CFWS450F
FI2: CFWS450HT
AGC
VCO circuit (Q38: XP6501)
Reference oscillator
(X1: CR-779 21.25MHz)
*Located under side of the point
• MAIN UNIT (BOTTOM VIEW)
1st Mixer
Mixer
(Q19: 3SK299) C5V regulator
(IC8: TA78L05F)
APC controller
(IC6: NJM3404AV) +8V regulator
(IC7: TA7808F)
RF amplifier
(Q27: 3SK299)
IF amplifier TX/RX switch

(Q16: 2SC4406) (D6, D7: MA77)
FM IF IC
IF detector PLL IC
(IC4: TA31136FN) (IC1: LV2105V)
Enphasis switch
D/A converter (Q41: 2SC4617)
(IC5: M62363FP)
2-1
2-2 HM-133V
Reset IC
(IC3: BD5245G)
CPU
(IC1: µPD789071)
LED driver
Q4, Q5: 2SA1586
DS11*: LT1EP53A
LED driver
Q6, Q7: 2SA1586
DS10*: LT1EP53A
EE-PROM
(IC6:
IC6: BR24L02FV
BR24L02FV)
5V regulator [MAIN-A] unit only
Q1: 2SC2712
D1: MA8056
Data buffer circuit
Regulator switch Q2: DTC114EU
Q8: 2SC2712 Q3: DTA114EU
Q9: DTB113ZK
*Located under side of the point
2-2
SECTION 3 OPTIONAL UNIT INSTALLATION
➀ Remove [DIAL] and unscrew the 2 allen-socket bolts from ➄ Intall the unit as illustrated below. Insert tightly to avoid
the front panel using with an allen wrench (2.5 mm; 1⁄10″). bad contact.
Flat cable
Allen-socket
bolts
➁ Detach the front panel from the main unit. Insulation sheet
➅ Return the front panel and the allen-socket bolts to their

original position.
➂ Attach the insulation sheet (supplied as accessory) to IC NOTE: When attaching the front panel to the main unit,
on the Front unit. make sure the flat cable are running in the groove to pre-
➃ Remove the protective paper attached to the bottom of vent catching between front panel and main unit.
the optional unit to expose the adhesive strip.
3-1
SECTION 4 CIRCUIT DESCRIPTION
4-1 RECEIVER CIRCUITS The tunable bandpass filters (D13–D16) employ varactor
4-1-1 ANTENNA SWITCHING CIRCUIT diodes to tune the center frequency of the RF passband for
wide bandwidth receiving and good image response rejec-
(MAIN UNIT)
tion. These diodes are controlled by the CPU (LOGIC unit;
The antenna switching circuit functions as a low-pass filter
IC1) via the D/A convertor (IC5).
while receiving and a resonator circuit while transmitting.
The circuit does not allow transmit signals to enter receiver
circuits.
4-1-4 1ST MIXER AND 1ST IF CIRCUITS
Received signals enter the antenna connector and pass (MAIN UNIT)
through the low-pass filter (L47, L48, C208, C210, C217). The 1st mixer circuit converts the received signals to a fixed
The filtered signals are passed through the λ/4 type anten- frequency of the 1st IF signal with the PLL output frequency.
na switching circuit (D16, D19, L45, L46) and limiter circuits By changing the PLL frequency, only the desired frequency
(D15). The signals are then applied to the squelch attenua- will pass through a pair of crystal filters at the next stage of
tor circuit. the 1st mixer.
The RF signals from the bandpass filter are applied to the

4-1-2 SQUELCH ATTENUATOR CIRCUIT 1st mixer circuit (Q19). The applied signals are mixed with
the 1st LO signal coming from the RX-VCO circuit (Q7, D5,
(MAIN UNIT)
D38) to produce a 21.7 MHz 1st IF signal. The 1st IF signal
The attenuator circuit attenuates the signal strength to a
passes through a pair of crystal filters (FI3, FI4) to suppress
maximum of 10 dB to protect the RF amplifier from distortion
out-of-band signals. The filtered signal is amplified at the 1st
when excessively strong signals are received.
IF amplifier (Q16), and applied to the 2nd IF circuit via the
limiter circuit (D29).
The current flow of the antenna switching circuit (D16, D19)
is controlled by the [SQL] control via the attenuator con-
4-1-5 2ND IF AND DEMODULATOR CIRCUITS
troller (IC6a, D18). When the [SQL] control is rotated clock-
wise deeper than 12 o’clock, the current of D16 and D19 is (MAIN unit)
increased. In this case, D16 and D19 act as an attenuator. The 2nd mixer circuit converts the 1st IF signal to a 2nd IF
signal. A double-conversion superheterodyne system
improves the image rejection ratio and obtains stable receiv-
4-1-3 RF CIRCUIT (MAIN UNIT) er gain.
The RF circuit amplifies signals within the range of frequen-
The 1st IF signal from the IF amplifier (Q16) is applied to the
cy coverage and filters out-of-band signals.
2nd mixer section of the FM IF IC (IC4, pin 16) and is then
mixed with the 2nd LO signal for conversion to a 450 kHz
The signals from the squelch attenuator circuit pass through
2nd IF signal.
the tunable bandpass filter (D13). The filtered signals are
amplified at the RF amplifier (Q27) and then enter another
IC4 contains the 2nd mixer, limiter amplifier, quadrature
three-stage bandpass filters (D9–D11) to suppress unwant-
detector, S-meter detector, active filter and noise amplifier
ed signals. The filtered signals are applied to the 1st mixer
circuits, etc. A frequency from the PLL reference oscillator is
circuit (Q19).
used for the 2nd LO signal (21.25 MHz).
• 2ND IF AND DEMODULATOR CIRCUIT

AM Q37, Q38
2nd IF filter
detector FI1
(for wide) 450 kHz X1
21.25 MHz
FI2 16 PLL IC 1
(for narrow) IC1
8 7 3 2
Noise Noise
"SQLIN" signal from Active detector comp.
the D/A converter IC filter Mixer
Limiter
(IC5, pin 11) amp.
FM
detector
RSSI
IC4 TA31136FN
9 10 11 12 13 16
1st IF from the
IF amplifier (Q16)
AF signal "DETO" AM/FM "NOIS" signal to the CPU
selector (FRONT unit; IC1, pin 26)
R5V
IC12 "SD" signal to the CPU
X2
(FRONT unit; IC1, pin 4)
4-1
The 2nd IF signal from the 2nd mixer (IC4, pin 3) passes The audio signals are applied to the AF mute switch (MAIN
through the ceramic filter (FI1) (during wide channel spacing unit; Q29) via the VOL adjust pot (R61). The signals are
selection or passes through FI2 during narrow channel amplified at the AF amplifier (MAIN unit; IC9, pin 1) to obtain
spacing selection; [W/N] only). 2.4 W audio output power after being passed through the
emphasis switch (MAIN unit; Q41). The amplified AF signals
are applied to the speaker via the J4 (MAIN unit) and J6
4-1-6 AM/FM SELECTOR CIRCUIT (MAIN UNIT) (MAIN unit).
IC-2200H can receive AM and FM signal. The 2nd IF signal
is detected AM or FM detector circuits respectively.
4-1-8 SQUELCH CIRCUITS
(1) AM DETECTOR CIRCUIT (MAIN AND LOGIC UNITS)
The filtered signal is applied to the AM detector circuit (Q37, • NOISE SQUELCH
Q38) to demodulate 2nd IF signal into AM AF signals. The The noise squelch circuit cuts out AF signals when no RF
AM AF signals are applied to the AF circuit via the AM/FM signals are received. By detecting noise components in the
selector switch (IC12, pin 6). AF signals, the squelch circuit switches the AF mute switch.
(2) FM DETECTOR CIRCUIT A portion of detected audio signals from the FM IF IC (IC4,
The filtered signal is amplified at the limiter amplifier section pin 9) are applied to the active filter section of the IC (IC4,
(IC4, pin 5), and is then applied to the quadrature detector pin 8) as “SQLIN” signal, after passing through the D/A con-
section (IC4, pins 10, 11 and X2) to demodulate the 2nd IF verter (IC5, pin 12). The active filter section of the IC ampli-
signal into FM AF signals. The FM AF signals are output fies and filters noise components. The filtered signals are
from pin 9 (IC4) and are then applied to the AF circuit via the applied to the noise detector section in the IC and output
AM/FM selector switch (IC12, pin 7). from pin 13 as the “NOIS” signal.
The “NOIS” signal from IC4 (pin 13) is applied to the CPU
4-1-7 AF CIRCUITS (LOGIC UNIT) (LOGIC unit; IC1, pin 26). The CPU analyzes the noise con-
The AF circuits are composed of digital and analog AF cir- dition and outputs “AFMUTE” and “FILC” signals via the I/O
cuits. The AF signals are amplifies the demodulated AF sig- expander IC (LOGIC unit; IC2) to toggle the AF mute (Q29)
nals to drive a speaker. and emphasis (Q41) switches.
(1) IN CASE OF DIGITAL AF SIGNALS Even when the squelch is closed, the AF mute switch (Q29)
The digital AF signals are applied to the optional digital unit opens at the moment of emitting beep tones.
(UT-115*) via the J4 (pin 23) by the “DETO” line. The audio
signals that are converted to analog signals at the UT-115 • TONE SQUELCH
are applied to the analog selector circuit (IC525, pin 8) from The tone squelch circuit detects AF signals and opens the
the optional digital voice unit passed through the J4 (pin 22) squelch only when receiving a signal containing a matching
via the “AFOUT” line. The signals pass through the high- subaudible tone (CTCSS). When tone squelch is in use, and
pass filter (IC3c, pins 8, 9) from the analog selector (IC525, a signal with a mismatched or no subaudible tone is
pin 9), and are then applied to the analog switch (IC6, pin 1). received, the tone squelch circuit mutes the AF signals even
*Refer to “4-6 UT-115 CIRCUIT DESCRIPTION” (page 4-7 ) when noise squelch is open.
in detail.
AF signals from the FM IF IC (IC4, pin 9) are applied to the
(2) IN CASE OF ANALOG AF SIGNALS AM/FM selector (IC12, pin 6 or 7), and then pass through
The analog AF signals are applied to the analog selector the analog selector (LOGIC unit; IC525, pins 10, 11). The
(IC525, pin 11), and pass through the high-pass filter (IC3c, signals pass through the low-pass filter (LOGIC unit; Q3) to
pins 8, 9). The filtered signals are applied to the analog remove AF (voice) signals, and is applied to the CTCSS
switch (IC6, pin 1). decoder inside the CPU (LOGIC unit; IC1, pin 1) via the
“CTCIN” line to control the AF mute switch.
• AF CIRCUIT
"DETO" AF signal from the AM/FM

selector (MAIN unit; IC12, pin 1) 9
11
Analog selector 9 8 1 Analog switch 11
8 HPF
(IC525) 10 (IC6)
Optional unit IC3
(UT-115)
LOGIC unit
MAIN unit AF
volume
Speaker 5 1 Emphasis AF
(SP1) AF
switch mute R61
IC9
Q41 Q29
4-2
4-2 TRANSMITTER CIRCUITS • IN CASE OF ANALOG AF SIGNALS
4-2-1 MICROPHONE AMPLIFIER CIRCUIT The AF signals are applied to the DI/AN switch (IC522, pin
9), and are then reapplied to the switch (pin 4) from pin
(LOGIC unit)
8.The signals output from the switch (pin 3) as analog AF
The microphone amplifier circuit amplifies audio signals with
signals , and are then applied to the modulation circuit after
+6 dB/octave pre-emphasis characteristics from the micro-
being passed through the J3 via the “MODIN” line.
phone to a level needed for the modulation circuit.
The AF signals from the microphone pass through the

4-2-4 MODULATION CIRCUIT (MAIN UNIT)
microphone switch (IC2, D4), and are then amplified at the
The modulation circuit modulates the VCO oscillating signal
microphone amplifier (IC3a ,pin 2). The amplified signals
(RF signal) using the microphone audio signals.
pass through (or bypass) the ALC circuit.
The digital or analog audio signals (MODIN) change the
reactance of D2 and D4 to modulate the oscillated signal at
4-2-2 ALC CIRCUIT (LOGIC UNIT)
the TX-VCO circuit (Q6). The modulated signal is amplified
The ALC (Automatic Level Control) circuit reduces the gain
at the LO amplifier (Q9) and buffer amplifier (Q11), then
of IF amplifiers in order for the transceiver to output a con-
applied to the drive amplifiers.
stant RF power set by the RF power setting even when the
supplied voltage shifts, etc.
4-2-5 DRIVE AMPLIFIER CIRCUIT (MAIN UNIT)
• IN CASE OF PASSING THROUGH THE ALC CIRCUIT
The drive amplifier circuit amplifies the VCO oscillating sig-
The amplified signals are applied to the ALC switch (IC520,
nal to the level needed at the power amplifier.
pin 3), and are then output from pin 4. The signals are
applied to the ALC amplifier (IC514, pin 3), and are then
The RF signal from the buffer amplifier (Q11) passes
reapplied to the ALC switch (IC520, pin 8). The signals pass
through the T/R switch (D6) and is amplified at the pre-drive
through the high-pass filter (IC3d, pins 12, 14), and are then
(Q17) and drive (Q35) amplifiers. The amplified signal is
applied to the analog switch (IC6, pin 4).
applied to the power amplifier circuit.
• IN CASE OF BYPASSING THE ALC CIRCUIT
The amplified signals are applied to the ALC switch (IC520,
pin 2), and are then output from pin 1. The signals are 4-2-6 POWER AMPLIFIER CIRCUIT (MAIN UNIT)
applied to the ALC switch (IC520, pin 9) again, and then The power amplifier circuit amplifies the driver signal to an
pass through the high-pass filter (IC3d, pins 12, 14) via the output power level.
IC520, pin 10. The signals are applied to the analog switch
(IC6, pin 4). The RF signal from the drive amplifier (Q35) is applied to the
power module (IC10) to obtain 65 W (50 W for Korea ver-
sion, 25 W for Taiwan version) of RF power.
4-2-3 DIGITAL SWITCH CIRCUIT (LOGIC UNIT)
The amplified signals is passed through the antenna switch-
The signals from the analog switch (IC6, pin 3) pass through
ing circuit (D12), APC detector circuit (D14, D17, L39), and
the high-pass filter (IC3, pins 6, 7), and are then reapplied to
low-pass filter (L47, L48, C208, C210, C217) and is then
the analog switch (IC6, pin 9). The signals are applied to the
applied to the antenna connector.
DI/AN switch via the “MOD_I” line.
Control voltage for the power amplifier (IC10, pin 2) are con-
• IN CASE OF DIGITAL AF SIGNALS
trolled by the APC circuit to protect the power module from
The AF signals are applied to the DI/AN switch (IC522, pin
a mismatched condition as well as to stabilize the output
10), and are then applied to the optional digital voice unit
power.
after being passed through the J4 (pin 4) via the “ANA-
LOGUE_MOD_IN” line. The A/D converted AF signals are
applied to the DI/AN switch (IC522, pin 1) from the J4 (pin 3)
via the “DIGITAL_MOD_OUT” line. The digital AF signals
from DI/AN switch (IC522, pin 2) are applied to the modula-
tion circuit after being passed through the J3 via the
“MODIN” line.
• ALC CIRCUIT "THROUGH" from the CPU

(MAIN unit; IC1, pin 80)
IC520
Through
switch
MIC
MIC IC520 IC520 Switch to the modulator circuit
switch IC514
Microphone IC3A ALC ALC
IC2, D4 ALC IC525
switch switch
"ALC" from the CPU
(MAIN unit; IC1, pin 81)
"THROUGH" from the CPU Power
(MAIN unit; IC1, pin 80) supply Q524
4-3
4-2-7 APC CIRCUIT (MAIN UNIT) An oscillated signal from the VCO passes thorough the LO
The APC circuit protects the power amplifier from a mis- and buffer amplifiers (Q9, Q12) is applied to the PLL IC (IC1,
matched output load and stabilizes the output power. pin 6) and is prescaled in the PLL IC based on the divided
ratio (N-data). The reference signal is generated at the ref-
The APC detector circuit (D14, D17, L39) detects forward erence oscillator (X1) and is also applied to the PLL IC. The
signals and reflection signals at D14 and D17 respectively. PLL IC detects the out-of-step phase using the reference
The combined voltage is at minimum level when the anten- frequency and outputs it from pin 15. The output signal is
na impedance is matched at 50 Ω and is increased when it passed through the loop filter (Q2, R6, R11–R15, C11, C12)
is mismatched. and is then applied to the VCO circuit as the lock voltage via
the “LV” line.
The detected voltage is applied to the differential amplifier
(IC6, pin 2), and the power setting voltage is applied to the
other input (pin 1) for the reference. 4-3-2 VCO CIRCUIT (MAIN unit)
The VCO circuit contains a separate TX-VCO (Q6, D2, D4)
When antenna impedance is mismatched, the detected volt- and RX-VCO (Q7, D5, D38). The oscillated signal is ampli-
age exceeds the power setting voltage. The output voltage fied at the LO (Q9) and buffer (Q11) amplifiers, and is then
of the differential amplifier (IC6, pin 1) controls the input cur- applied to the T/R switching circuit (D6, D7). Then the Tx
rent of the power module (IC10) to reduce the output power. and Rx signals are applied to the pre-driver (Q17) and 1st
mixer (Q19) respectively.
A portion of the signal from Q4 is amplified at the buffer

4-3 PLL CIRCUITS amplifier (Q6) and is then fed back to the PLL IC (IC1 pin 2)
4-3-1 PLL CIRCUIT as the comparison signal.
A PLL circuit provides stable oscillation of the transmit fre-
quency and the receive 1st LO frequency. The PLL circuit
compares the phase of the divided VCO frequency to the
reference frequency. The PLL output frequency is controlled
by the divided ratio (N-data) of a programmable divider.
• APC CIRCUIT
HV
T8 Power detector circuit
RF signal Q17 Q35 IC10 L39
Pre Driver Power to the antenna
drive amp. amp.
Q26, Q39, Q40
—
TXC IC6
APC
amp.
T1 +
IC11 D14 D17
APC control circuit
• PLL CIRCUIT
RX VCO Q11
D7
Buffer to 1st mixer circuit
Q9
Q7, D5 D6
LO to transmitter circuit
TX VCO Q12
Buffer
Q6, D2, D4
Loop LPF
filter IC1 LV2105V
9 Charge Phase Programmable 6

Prescaler
pump detector divider
2
21.25 MHz 2nd LO signal Reference PLLCK
Shift register 3 PLLDATA
to the FM IF IC (IC4, pin 2) divider 4 PLLSTB
16
LPF
1
X1
21.25 MHz
4-4
4-3-3 REFERENCE OSCILLATOR CONTROL 4-5 PORT ALLOCATIONS
CIRCUIT (LOGIC AND MAIN UNITS) 4-5-1 D/A CONVERTER IC (MAIN UNIT; IC5)
The reference oscillator control circuit changes the refer- Pin Port
ence frequency when using digital voice function. Description
number name
When digital voice signals output from the optional digital Outputs RF tracking voltage while
2 T3
voice unit, the “REFMOD” signal outputs from it via the J4 receiving.
(pin 4) at the same time. The “REFMOD” signal is applied to 3 SQLATT Outputs attenuator control signal.
the amplifier (IC521, pin 3), and passes through the CTCSS
switch (IC524, pins 6 and 1). The signal is applied to the D/A Outputs reference frequency control
10 FC
convertor (MAIN unit; IC5, pin 13) via the “CTCSS” line. The voltage.
output signal from the D/A convertor (MAIN unit; IC5, pin 14) Outputs squelch control signal to
is applied to the reference oscillator (MAIN unit; X1) to con- 11 SQLIN
adjust threshold level.
trol the reference frequency while transmitting digital signals
as “DTC” line. 14 DTC Outputs DTCS slope correction signal.
Outputs transmitting deviation control
15 MOD
signal.
4-4 POWER SUPPLY CIRCUITS Outputs RF tracking voltage while

22 T2
receiving.
VOLTAGE LINES
• Outputs RF tracking voltage while
Line Description receiving.
23 T1
• Outputs transmitting power control
The 13.8 V voltage from the connected DC signal while transmitting.
HV power supply.
The same voltage as the HV line which is con-
trolled by the HVSW circuit (Q28, Q30, Q31).
When the [POWER] switch (LOGIC unit; S1) is
SWHV pushed, the CPU (LOGIC unit; IC1, pin 40) out- 4-5-2 EXPANDER IC (MAIN UNIT; IC2)
puts the “PWRON” control signal to the power Pin Port
switching circuit to turn the circuit ON. Description
number name
Common 5 V for the CPU (LOGIC unit; IC1) Outputs AF mute control signal.
4 AFMUTE
converted from the HV line by the C5V regulator High: While muting.
C5V circuit (IC8). The circuit outputs the voltage
Outputs R5 regulator (Q25) control
regardless of the power ON/OFF condition.
5 RXC signal.
Common 8 V converted from the SWHV line by Low: While receiving.
+8V the +8V regulator circuit (IC7).
Outputs T8 regulator (Q14 and Q15)
Common 5 V converted from the +8V line by the 6 TXC control signal.
+5V +5V regulator circuit (Q21, Q22). High: While transmitting.
Transmit 8 V controlled by the T8 regulator cir- Outputs 2nd IF filter select signal
cuit (Q14, Q15) using the “TXC” signal from the ([W/N] version ONLY).
T8 I/O expander IC (IC2, pin 6). The voltage is con- High: While wide passband width
verted from the +8V line at the regulator circuit. (±5.0 kHz) is selected (FI1 is
11 W/N
selected).
Receive 5 V controlled by the R5 regulator cir- Low: While narrow passband width
cuit (Q25) using the “RXC” signal from the I/O (±2.5 kHz) is selected (FI2 is
R5V expander IC (IC2, pin 5). The voltage is con- selected).
verted from the +5 V line at the regulator circuit.
Outputs VCO regualtor (Q1, Q3, Q5,
Q8, D1) control signal.
14 SHIFT
Low: While transmitting.
High: While receiving.
4-5
4-5-3 CPU (LOGIC UNIT; IC1) Pin Port
Description
Pin Port number name
Description
number name
53–55 IS0–IS2 Output initial matrix strobe signals.
Input port for the CTCSS/DTCS sig-
1 CTCIN 56, 57 KS1, KS2 Output key scan signals
nals.
Input ports for the keyboard matrix
Input port for squelch volume detect- 58–61 KR3–KR0
2 SQLV signals.
ing signal.
Input port for the [PTT] switch signal.
Input port for the [∫] and [√] switches 62 PTT
3 MICUD High: While transmitting.
from the external microphone.
Outputs digital/analog select signal
Input port for the S-meter voltage
4 SD 64 DI_SEC while the UT-115 is installed.
detecting signal.
High : Digital is selected.
5 LVIN Input port for the PLL lock voltage.
Outputs filter characteristic control sig-
Input port for the transceiver’s internal nal while the UT-115 is installed.
6 TEMP 65 TX_DIGI
temperature detecting signal. Low : While transmitting digital sig-
nal.
Input port for the weather channel
7 DET0 • Outputs serial data to D/A convertor
alert detecting sinal.
(MAIN unit; IC5, pin 8).
Outputs LCD backlight color select 66 SO
• Outputs DTMF clock signal to the
8 COLOR signal.
expander IC (MAIN unit; IC2, pin 2).
Low: Umber color is selected.
Outputs clock signal to the optional
9 DIM0 Output LCD backlight brightness con- 67 OPSCK
unit.
10 DIM1 trols signals
• Input port for the optional unit detect-
Outputs the CPU clock shift control
14 CSHIFT OPV1 ing signal.
signal. 68
DASTB • Outputs strobe signal to the D/A con-
19 RESET Input port for the reset signal. verter (MAIN unit; IC5, pin 6).
Input port for [POWER] switch. Input port for the optional unit detect-
25 PWRSW 69 OPV2
Low: [POWER] switch is pushed. ing signal.
Input port for the noise pulse signal for Input port for detecting signal whether
26 NOIS the multifunction microphone is con-
squelch and CPU.
73 EXTMIC nected or not.
28 DICK Low: The multifuntion microphone is
Input ports for encoder signals.
29 DIUD connected.
30 CLIN Input port for the cloning signal. Outputs low-pass filter cut-off frequen-
74 DUSE
31 CLOUT Output port for the cloning signal. cy control signal when using DTCS.
Outputs serial clock signal to the D/A Outputs clock signal to the EEPROM
34 SCK 75 ESCK
convertor (MAIN unit; IC5, pin 7). (IC5, pin 6).
35 BUSY Outputs “BUSY” signal to the UT-115. I/O port for data signals from/to the
76 ESDA
EEPROM (IC5, pin 5).
Outputs [POWER] switch control sig-
40 PWRON nal. Outputs the optional unit power supply
High: [POWER] is ON. 77 OP_PS controll signal.
High : Power is ON.
Outputs band shift signal.
42 BSHIFT Low : While receiving Air band Outputs the ALC circuit control signal.
80 THROUGH
(118–136 MHz). High : The ALC circuit is OFF.
Outputs strobe signal to the PLL IC Outputs the ALC circuit control signal.
43 PLLSTB 81 ALC
(MAIN unit; IC1, pin 4). High : The ALC circuit is ON.
Outputs clock signal to the PLL IC 84 OPT3

44 PLLCK I/O ports for the optional unit control
(MAIN unit; IC1, pin 2). 85 OPT2
signals.
86 OPT1
• Outputs strobe signal to the
EXSTB expander IC (MAIN unit; IC2, pin 1). 90, SEG1–
45 Output LCD segment signals.
OPV3 • Input port for the optional unit detect- 92–127 SEG36
ing signal. COM4–
128–131 Output LCD common signals.
46 UNLK Input port for the PLL unlock signal. COM1
Input port for the HM-133V remote VL3–

47 REMO 134–136 Output LCD device signals.
microphone signals. VL1
Output transmitting/receiving AF filter Input port for the current drain detect-
144 IDET
49 MICS select signal to the analog swtich (IC6, ing signal while transmitting.
51 AFON pin 6 [“AFON” is applied to the
pin 12]).
4-6
4-6 UT-115 CIRCUIT DESCRIPTION 4-7 UT-115 POWER SUPPLY CIRCUITS
4-6-1 RECEIVER CIRCUIT VOLTAGE LINES
The detected digital signals “FMDET” from the connected
transceiver via the J301 (pin 22) are amplified at the buffer Line Description
amplifier (IC251, pin 2). The amplified signals are applied to
The 5 V voltage from the connected transceiver
the GMSK modem circuit (IC252, pin 11), and are then
via the J301 (pin 29). The 5V line is controlled by
applied to the CPU (IC204) as clock synchronizer digital sig-
5V the +5V control circuit (Q50 and Q51). The cir-
nal. The digital signals from the CPU are applied to the
cuit is controlled by the “PSAVE” signal from the
AMBE voice CODEC IC (IC151) to precess code extention,
CPU (IC204, pin 58 and 59).
and are then applied to the linear CODEC IC (IC50) as 32
bits digital voice data. The applied digital signals are con- Common 3.3 V converted from the 5V line by the
verted to the analog AF signals at the D/A converter section 3.3V regulator circuit (IC1). One of the 3.3 V line
(IC50), and are then applied to the connected transceiver 3.3V is controlled by the +3V control circuit (Q400 and
via the J301 (pin 21) as “DAFOUT” signal. Q401). The circuit is controlled by the “PSAVE”
signal from the CPU (IC204, pin 58 and 59).
4-6-2 TRANSMITTER CIRCUIT Common 3.2 V converted from the 4.5–8 V line
The analog AF signals “AMODIN” from the connected trans- by the 3.2V regulator circuit (IC2). The circuit is
3.2V controlled by the “APWR” signal from the CPU
ceiver via the J301 (pin 4) are amplified at the buffer ampli-
fier (IC251, pin 6). The amplified signals are applied to the (IC204, pin 16).
linear CODEC IC (IC50, pin 5) to convert 32 bits digital voice
data at the A/D converter section via the “ADIN” line. The
digital signals are applied to the AMBE voice CODEC IC
(IC151) to process code compression, and are then applied
to the CPU (IC204). The digital signals from the CPU con- 4-8 UT-115 PORT ALLOCATIONS
vert to the GMSK base band signal at the GMSK modem 4-8-1 MODEM IC (IC252)
(IC252), and are then amplified at the buffer amplifier
(IC253, pin 5). The amplified signals are applied to the con- Pin Port
Description
nected transceiver via the J301 (pin 3). number name
Outputs 2.4576 MHz clock signal to
2 MCLK
the CPU (IC151, pin 39).
4-6-3 RESET CIRCUIT
The UT-115 has the reset IC (IC203). The IC outputs reset Outputs the PLL band width control
7 ACQ
signal to the CPU (IC204, pin 7) when “VDD” port (pin 2) signal while receiving.
becomes more than 2.8 V. Outputs transmitting data signal to the
19 TXDT
CPU (IC204, pin 54).
4-6-4 RS-232C CIRCUIT Input port for receiving data signal

20 RXDT
IC351 is a RS-232C compatible serial interface IC which from the CPU (IC204, pin 53).
converts data between the CPU and the external equipment Input port for receive clock signal from
(EX: Personal Computer). 21 RXCK
Outputs transmit clock signal to the
22 TXCK
4-6-5 LEVEL CONVERTER CIRCUIT CPU (IC204, pin 51).
The level converter circuit (Q305 and Q306) converts com-
munication data level between the CPU (IC204) and the
connected transceiver’s CPU.
Q301, Q302 and Q303 convert control signals level between
the UT-115 and the connected transceiver.
• UT-115 BLOCK DIAGRAM
-"TXD_2" signal to
CPU "DMOD" signal
the J301, pin 16 Level Modem Buffer
CODEC to the J301, pin 3
-"RXD_2" signal to converter
IC204 IC252 IC253B
the J301, pin 17 Q305, Q306
-"232C_RX" signal DSP "FMDET" signal

to the J301, pin 25 Buffer
RS-232C CODEC from the J301, pin 23
IC151
-"232C_TX" signal IC251A
to the J301, pin 26 IC351
"DAFOUT" signal to Linear

Buffer "AMODIN" signal
the J301, pin 22 CODEC IC50 from the J301, pin 4
IC251B
4-7
4-8-2 CPU (IC2)
Pin Port
Description
number name
Input port for the reset signal from the
7 RES reset IC (IC203, pin 1).
Low :The CPU is reset.
10 OSC2 Outputs 9.8304 MHz reference signal.
Input port for 9.8304 MHz reference
11 OSC1
signal.
Outputs 3.2V regulator circuit (IC2,
16 APWR
pin 3) control signal.
Outputs receive AF mute control signal
to the connected transceiver via the
29 RMUTE_C
J301 (pin 24).
High :While muting.
Outputs PTT signal to the connected
31 PTTOUT_C transceiver via the J301 (pin 2).
High :While transmitting.
Outputs transmit data signal to the
33 ATXD
CPU (IC151, pin 32).
Outputs clock signal to the CPU
34 ACLK
(IC151, pins 28 and 34).
Outputs strobe signal to the CPU
36 ASTB
(IC151, pins 30 and 38).
Input port for receive data signal from
37 ARXD
Outputs reset signal to the linear
38 ARES
CODEC IC (IC50, pin 13).
Output power save control signal to
58 the +3V controller circuit (Q400 and
PSAVE
59 Q401).
Low :Power save is ON.
Input port for the BUSY signal from the
connected transceiver via the J301
61 BUSY
(pin 6).
High :While receiving signals.
Input port for the PTT signal from the
connected transceiver via the J301
62 PTTIN
(pin 1).
High :While transmitting.
4-8
SECTION 5 ADJUSTMENT PROCEDURES
5-1 PREPARATION
Enter the adjustment mode when adjusting the IC-2200H Then the JIG cable as shown the page 5-2 is required .
■ REQUIRED TEST EQUIPMENT

EQUIPMENT GREDE AND RANGE EQUIPMENT GREDE AND RENGE
Output voltage : 13.8 V DC Frequency range : 0–400 MHz
DC power supply FM deviation meter
Current capacity : 20 A or more Measuring range : 0 to ±5 kHz
Measuring range : 0.1–100 W Frequency range : DC–400 MHz
Oscilloscope
RF power meter Frequency range : 50–400 MHz Measuring range : 0.01–10 V
(terminated type) Impedance : 50 Ω
SWR : Less than 1.2 : 1 Frequency range : 300–3000 Hz
Audio generator
Measuring range : 1–500 mV
Frequency range : 0.1–400 MHz
Frequency accuracy : ±1 ppm or better Power attenuation : 50 or 60 dB
Frequency counter Attenuator
Sensitivity : 100 mV or better Capacity : 150 W or more
Frequency range : 0.1–400 MHz

Standard signal Output level : 0.1 µV–32 mV
generator (SSG) (–127 to –17 dBm)
■ ENTERING THE ADJUSTMENT MODE

q Turn the transceiver’s power OFF.
w Connect the JIG cable to the [MIC] jack.
e Push and hold the [SET] and [MONI] keys, and then turn power ON.
NOTE: Exiting from the adjustment mode when the transciever’s power is OFF.
■ OPERATING ON THE ADJUSTMENT MODE

•
Change the adjustment value : [DIAL]
•
Verifying the adjustment value : [M/CALL] key
•
Forward the adjustment item : [BANK] key
•
Go back the adjustment item : [V/MHz] key
•
Store the adjustment value in the memory : [S.MW] key
CAUTION: Need to push the [S.MW] key when storing the adjustment value in the memory. Otherwise, the transceiver is not
adjusted properly.
IMPORTANT!: The transceiver need to be cancelled adjustment mode (as following method) to use normal mode when
adjustments are finished, otherwise the transceiver does not work properly.
q: Turn the power OFF.
w: Push and hold [S.MW] and [SET] keys, and then turn the power ON.
5-1
‘ CONNECTIONS
FM DEVIATION ATTENUATOR
METER 50 dB or 60 dB
to the antenna connector

RF POWER METER POWER SUPPLY
50 , 1 80 W 13.8 V, 20 A or more
STANDARD SIGNAL GENERATOR

0.1 300 MHz
127 to 17 dBm (0.1 V to 32 mV)
CAUTION!
DO NOT transmit
while an SSG is
connected to the
antenna connector.
JIG CABLE INFORMATION
AUDIO GENERATOR
300 Hz to 3 kHz
pin 5 (MICE)
pin 6 (MIC)
pin 7 (GND)
pin 4 (PTT)
NOTE: DO NOT adjust items
with "*" mark at below
explanation. Those items are
adjusted automatically when
other adjustment items are
adjusted.
to the microphone connector
ADJUSTMENT ITEM EXPLANATION
Starting item
Fr rE PO PO+[MID] PO+[MID]+[LOW] PO+[LOW] PU dE *dP dE+[DIGITAL] dt
*F1 *dt *C6 *CS *Et *dF Sr+[.] Sr Sq tr tr tr tr dt+[DIGITAL] *bP
*F2 *F3 *F4 *F5 *F6 *F7 *F8 *F9 *F0 *F1 *F2 *F3 *F4 *F5 *F6 *F7
*dE+[DIGITAL] *db *db *db *db *dd *dd *dd *dd *dE *dE *dE *FA *F9 *F8
*dE+[DIGITAL] *dE+[DIGITAL] *dd+[DIGITAL] *dd+[DIGITAL] *dd+[DIGITAL] *dd+[DIGITAL]
*db+[DIGITAL] *db+[DIGITAL] *db+[DIGITAL] *db+[DIGITAL] *db+[DIGITAL] *dd+[DIGITAL]
*PN *PP *51 *52 *53 *54 *55 *56 *57 *51+[.] *52+[.] *53+[.] *54+[.] *55+[.]
*dU *FN *FN *FN *FN *57+[.] *56+[.]
*Not adjust items
5-2
5-2 SOFTWARE ADJUSTMENTS (TRANSMITTING AND RECEIVING)
ADJUSTMENT ADJUSTMENT CONDITION OPERATION
REFERENCE 1 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set to 146.0000 MHz.
FREQUENCY • Loosely couple a frequency counter to the antenna • Push the [S.MW] key.
[Fr] connector on the rear panel.
• Transmitting
REFERENCE 1 • Operating frequency : 146.0 MHz • Push the [S.MW] key.
VOLTAGE • Receiving
[rE]
VHF 1 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set the VHF high power to 67 W.
OUTPUT • Connect an RF power meter to the antenna connector. • Push the [S.MW] key.
POWER • Transmitting
(High)
[PO]
(Middle) 2 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set the VHF middle power to 25 W.
[PO+MID] • Transmitting • Push the [S.MW] key.
(Middle-Low) 3 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set the VHF low power to 10 W.
[PO+MID+LOW] • Transmitting • Push the [S.MW] key.
(Low) 4 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set the VHF low power to 5 W.
[PO+LOW] • Transmitting • Push the [S.MW] key.
PROTECT 1 • Operating frequency : 146.0 MHz • Push the [S.MW] key while transmitting.
VOLTAGE • [High]/[Low] switch : High
[PU] • Connect an RF power meter to the antenna connector.
• Transmitting
FREQUENCY 1 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set to ±4.6 kHz.
DEVIATION • IF bandwidth : Wide • Push the [S.MW] key after finish adjustment.
(Analog) • Connect an audio generator to the [MIC] jack and set
[dE] as : 1 kHz/80 mV rms
• Connect an FM deviation meter to the antenna con-
nector and set as :
HPF : OFF
LPF : 20 kHz
De-emphasis : OFF
Detector : (P–P)/2
• Transmitting
DIGITAL VCO 1 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set to ±1.25 kHz.
DEVIATION • IF bandwidth : Wide • Push the [S.MW] key after finish adjustment.
[dE+DIGITAL] • No audio signal is applied to the [MIC] jack.
• Connect an FM deviation meter to the antenna con-
nector and set as :
HPF : OFF
LPF : 20 kHz
De-emphasis : OFF
• Transmitting
DTCS WAVE 1 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set to flat wave form as shown
FORM • IF bandwidth : Wide below.
[dt] • No audio signal is applied to the [MIC] jack. • Push the [S.MW] key after finish adjustment.
• DTCS code : 023
• Set an FM deviation meter as:
HPF : OFF Set to flat wave
LPF : 20 kHz form
De-emphasis : OFF
• Transmitting
5-3
SOFTWARE ADJUSTMENTS (TRANSMITTING AND RECEIVING)–Continued
ADJUSTMENT ADJUSTMENT CONDITION OPERATION
DIGITAL 1 • Operating frequency : 146.0 MHz • Turn the [DIAL] to set to ±0.85 kHz.
REFERENCE • IF bandwidth : Wide • Push the [S.MW] key after finish adjustment.
DEVIATION • No audio signal is applied to the [MIC] jack.
[dt+DIGITAL] • Connect an FM deviation meter to the antenna con-
nector and set as :
HPF : OFF
LPF : 20 kHz
De-emphasis : OFF
• Transmitting
RECEIVER 1 • Operating frequency : 118.020 MHz • Push the [S.MW] key.
SENSITIVITY • Connect an SSG to the antenna connector and set as
[tr] Level : 0.5 µV* (–113 dBm)
Modulation : 1 kHz
Deviation : ± 3.5 kHz
• Receiving
2 • Operating frequency : 136.020 MHz • Push the [S.MW] key.
• Receiving
• Receiving
• Receiving
SQUELCH 1 • Operating frequency : 145.020 MHz • Turn the [DIAL] to set to squelch tight point.
LEVEL • Connect an SSG to the antenna connector and set as • Turn the [DIAL] to set to squelch threshold point.
(Wide) Level : 0.1 µV* (–127 dBm) • Push the [S.MW] key.
[Sq] Modulation : 1 kHz
• Receiving
S-METER 1 • Operating frequency : 145.020 MHz • Push the [S.MW] key.
(FM mode) • Connect an SSG to the antenna connector and set as
[Sr] Level : 1.3 µV* (–105 dBm)
Modulation : 1 kHz
• Receiving
(AM mode) 2 • Operating frequency : 127.020 MHz • Push the [S.MW] key.
[Sr+.] • Connect an SSG to the antenna connector and set as
Level : 1.0 µV* (–107 dBm)
Modulation : 1 kHz
Deviation : 30 %
• Receiving
*This output level of a standard signal generator (SSG) is indicated as SSG’s open circuit.
5-4
5-3 UT-115 ADJUSTMENT PROCEDURES
• PREPARATION
Enter the adjustment mode when adjusting the UT-115.
■ REQUIRED TEST EQUIPMENT
EQUIPMENT GREDE AND RANGE EQUIPMENT GREDE AND RENGE
Output voltage : 5.0 V DC Frequency range : 0.1–100 MHz
DC power supply 1
Current capacity : 1 A or more Frequency counter Frequency accuracy : ±1 ppm or better
Sensitivity : 100 mV or better
Output voltage : 8.0 V DC
DC power supply 2
Current capacity : 1 A or more Frequency range : DC–400 MHz
Oscilloscope
Measuring range : 0.01–10 V
■ ENTERING THE ADJUSTMENT MODE

Connect J301, pin 14 to GND, then the UT-115 enters adjustment mode.
NOTE: Exit from the adjustment mode to disconnect J310, pin 14 from GND before the UT-115 adjustment is fihished
■ CONNECTION
• UT-115 BOTTOM VIEW
Power supply
5 V DC / 1 A
Power supply
8 V DC / 1 A
J301, Pin 14
Entering adjustment mode
5-5
5-4 TRIMMER ADJUSTMENTS
ADJUSTMENT
MEASUREMENT MEASUREMENT POINT
ADJUSTMENT VALUE
UNIT LOCATION
UNIT ADJUST
CODEC 1 MAIN Connect the frequency counter to 16.38400 MHz ±10 Hz MAIN C102
FREQUENCY the check point CP101.
SET
MODEM 1 MAIN Connect the frequency counter to 2.457600 MHz ±3 Hz MAIN C207
FREQUENCY the check point CP216.
SET
MODURATION 1 MAIN • Transmit the UT-115 to connect 350 mVp-p ±10 mV MAIN R264
OUTPUT J301, pin 1 to GND.
LEVEL
2 • Connect the oscilloscope to the
J301, pin 21.
3 Disconnect J301, pin 1 from GND.
• UT-115 TOP VIEW

C207
MODEM frequency set adjustment
C102
CODEC frequency set adjustment
• UT-115 BOTTOM VIEW CP216

MODEM frequency set check point
J301, Pin 1
Transmit the UT-115
J301, Pin 21
Modulation output level
check point
CP101
CODEC frequency set check point
5-6
SECTION 6 PARTS LIST
6-1 IC-2200H [LOGIC UNIT]

[LOGIC UNIT] REF ORDER DESCRIPTION M.
NO. NO.
REF ORDER DESCRIPTION M.
NO. NO. R16 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ) B
R17 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ) B
IC1 1140011860 S.IC M30220FCRP (FX-2698A) [EXP] B R18 7030005720 S.RESISTOR ERJ2GEJ 563 X (56 kΩ) B
1140011861 S.IC M30220FCRP (FX-2698A-1) [USA] B R19 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B
1140011910 S.IC M30220MA-132RP (FX-2698A-1) R20 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B
except [EXP] and [USA] B R21 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ) B
IC2 1130004200 S.IC TC4S66F (TE85R) B R22 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B
IC3 1110005340 S.IC NJM12902V-TE1 B R23 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
IC4 1110006210 S.IC BD5242FVE-TR B R24 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ) B
IC5 1140008650 S.IC HN58X2464TI B R25 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B
IC6 1130011770 S.IC CD4066BPWR T R26 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ) B
IC24 1110002860 S.IC TA75S393F (TE85R) T R27 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
IC514 1110005310 S.IC AN6123MS B [EXP] only B
IC520 1130011770 S.IC CD4066BPWR T 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ) [other] B
IC521 1130008560 S.IC TC75S51F (TE85L) B R28 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
IC522 1130011770 S.IC CD4066BPWR B R29 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B
IC524 1130011780 S.IC SN74AHC2G53HDCTR B R30 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ) B
IC525 1130011770 S.IC CD4066BPWR T R31 7030005720 S.RESISTOR ERJ2GEJ 563 X (56 kΩ) B
R32 7030007570 S.RESISTOR ERJ2GEJ 122X (1.2 kΩ) B
Q1 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) T R35 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
Q2 1590000430 S.TRANSISTOR DTC144EUA T106 B R36 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ) B
Q3 1590001650 S.TRANSISTOR XP4601 (TX) B R37 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
Q5 1590000660 S.TRANSISTOR DTC144TU T106 B R38 7030008400 S.RESISTOR ERJ2GEJ 182 X (1.8 kΩ) B
Q6 1510000510 S.TRANSISTOR 2SA1576A T106R B R39 7030005100 S.RESISTOR ERJ2GEJ 154 X (150 kΩ) B
Q7 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) B R40 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) T
Q8 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) B R41 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ) B
Q12 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) B R42 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B
Q513 1520000200 S.TRANSISTOR 2SB798-T2 DK B R43 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B
Q514 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) B R44 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B
Q515 1510000510 S.TRANSISTOR 2SA1576A T106R B R45 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ) B
Q524 1510000510 S.TRANSISTOR 2SA1576A T106R T R46 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ) T
Q525 1590000430 S.TRANSISTOR DTC144EUA T106 B R47 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) T
Q527 1590002230 S.TRANSISTOR UMG2N TL B R48 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B
Q528 1590002430 S.TRANSISTOR DTA144EE TL T R49 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ) B
R50 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B
R51 7030005530 S.RESISTOR ERJ2GEJ 100 X (10 Ω) B
D1 1730002280 S.ZENER MA8091-M (TX) T R52 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) T
D2 1790001250 S.DIODE MA2S111-(TX) T R53 7030007310 S.RESISTOR ERJ2GEJ 155 X (1.5 MΩ) B
D3 1730002280 S.ZENER MA8091-M (TX) B R55 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)
D4 1750000520 S.DIODE DAN222TL B [EUR], [EXP], [EXP-1] only B
D6 1750000370 S.DIODE DA221 TL B R56 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω) B
D7 1750000520 S.DIODE DAN222TL T R57 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ) B
D11 1710000611 DIODE 1SS133 T77 (26M/M) R60 7030005720 S.RESISTOR ERJ2GEJ 563 X (56 kΩ) B
[TPE], [KOR], [EUR-1] only B R61 7210001870 VARIABLE EVU-F2AF20 A14 (10KA) T
D13 1750000940 S.DIODE ISS400 TE61 R62 7210001860 VARIABLE EVU-F2AF20 B14 (10KB) T
except [EXP], [EXP-1] B R64 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B
D15 1750000940 S.DIODE ISS400 TE61 [EXP], [EXP-1] only B R67 7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ) B
D16 1750000940 S.DIODE ISS400 TE61 R69 7030005100 S.RESISTOR ERJ2GEJ 154 X (150 kΩ) B
[EUR], [EUR-1], [EXP], [EXP-1] only B R70 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ) B
[TPE], [KOR], [EXP], [EXP-1] only B R72 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ) B
[TPE], [EXP], [EXP-1] only B R75 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ) B
D23 1750000940 S.DIODE ISS400 TE61 [TPE], [KOR] only B R76 7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ) B
D25 1790001260 S.DIODE MA2S077-(TX) B R77 7030009290 S.RESISTOR ERJ2GEJ 562 X (5.6 kΩ) B
D27 1750000940 S.DIODE ISS400 TE61 except [EXP-1] B R78 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
D28 1750000940 S.DIODE ISS400 TE61 [EXP], [EXP-1] only B R79 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) B
D526 1790001250 S.DIODE MA2S111-(TX) B R80 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B
X1 6050011500 S.XTAL CR-739 (9.8304 MHz) B R83 7030005590 S.RESISTOR ERJ2GEJ 680 X (68 Ω) B
R84 7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ) B
R1 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ) T R86 7030009160 S.RESISTOR ERJ2GEJ 181 X (180 Ω) B
R2 7030005310 S.RESISTOR ERJ2GEJ 124 X (120 kΩ) T R87 7410000950 S.ARRAY EXB-V8V 102JV T
R3 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) T R89 7030009280 S.RESISTOR ERJ2GE B
R4 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B R91 7030005310 S.RESISTOR ERJ2GEJ 124 X (120 kΩ) B
R5 7030005230 S.RESISTOR ERJ2GEJ 334 X (330 kΩ) T R92 7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ) B
R7 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B R94 7030005570 S.RESISTOR ERJ2GEJ 820 X (82 Ω) B
R8 7030007290 S.RESISTOR ERJ2GEJ 222 X (2.2 kΩ) T R96 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ) B
R11 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B R101 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) B
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount
6-1
[LOGIC UNIT] [LOGIC UNIT]
REF ORDER REF ORDER
DESCRIPTION M. DESCRIPTION M.
NO. NO. NO. NO.
R104 7030005080 S.RESISTOR ERJ2GEJ 823 X (82 kΩ) C53 4030017500 S.CERAMIC ECJ0EC1H560J B
[USA] only B C54 4030016790 S.CERAMIC ECJ0EB1C103K B
7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ) [other] B C55 4030017600 S.CERAMIC ECJ0EC1H080C B
R105 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B C56 4030017760 S.CERAMIC ECJ0EB1H222K B
R106 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B C57 4030018110 S.CERAMIC ECJ0EB1H272K B
R107 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B C59 4030017640 S.CERAMIC ECJ0EC1H150J B
R108 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B C62 4030017460 S.CERAMIC ECJ0EB1E102K B
R109 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ) C64 4030016790 S.CERAMIC ECJ0EB1C103K B
[USA] only B C65 4030016790 S.CERAMIC ECJ0EB1C103K B
R112 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ) B C66 4030016790 S.CERAMIC ECJ0EB1C103K T
R114 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ) B C67 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
R128 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B C68 4030016930 S.CERAMIC ECJ0EB1A104K B
R133 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C70 4030016790 S.CERAMIC ECJ0EB1C103K T
R134 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B C71 4030016790 S.CERAMIC ECJ0EB1C103K B
R136 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B C73 4510005860 S.ELECTROLYTIC ECEV1HA2R2SR B
R515 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B C75 4030017450 S.CERAMIC ECJ0EB1E271K B
R516 7030010040 S.RESISTOR ERJ2GE-JPW T C76 4030017040 S.CERAMIC ECJ0EB1A333K B
R517 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B C77 4510005860 S.ELECTROLYTIC ECEV1HA2R2SR B
R519 7030005010 S.RESISTOR ERJ2GEJ 681 X (680 Ω) B C78 4030016790 S.CERAMIC ECJ0EB1C103K B
R520 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C79 4030017440 S.CERAMIC ECJ0EC1H221J B
R523 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B C82 4030017730 S.CERAMIC ECJ0EB1E471K B
R524 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B C583 4030016930 S.CERAMIC ECJ0EB1A104K T
R525 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B C584 4030016930 S.CERAMIC ECJ0EB1A104K T
R527 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B C586 4510005600 S.ELECTROLYTIC ECEV1CS100SR B
R530 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C587 4550006250 S.TANTALUM TEESVA 1A 106M8L B
R531 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) T C588 4030017490 S.CERAMIC C1608 JB 1A 105K-T B
R532 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) T C591 4030017460 S.CERAMIC ECJ0EB1E102K T
R536 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) T C594 4030017460 S.CERAMIC ECJ0EB1E102K B
R537 7030005010 S.RESISTOR ERJ2GEJ 681 X (680 Ω) T C595 4030017460 S.CERAMIC ECJ0EB1E102K T
R542 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C600 4030017460 S.CERAMIC ECJ0EB1E102K T
R543 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C601 4550006210 S.TANTALUM ECST1CX106R T
R545 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ) T C602 4550006250 S.TANTALUM TEESVA 1A 106M8L B
R546 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) T
R548 7030000240 S.RESISTOR MCR10EZHJ 68 Ω (680) T
R549 7030000240 S.RESISTOR MCR10EZHJ 68 Ω (680) B J1 6450002210 CONNECTOR 3017-8821 <KIN> T
R550 7030010040 S.RESISTOR ERJ2GE-JPW B J3 6510024230 S.CONNECTOR 08-6210-0363-40-800 B
R551 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) B J4 6510021970 S.CONNECTOR AXN330C130P B
C1 4030017460 S.CERAMIC ECJ0EB1E102K B DS1 5030002660 LCD IS08264E00V2 T

C4 4030017460 S.CERAMIC ECJ0EB1E102K T DS2 5040001760 S.LED SEC 2422C T
C5 4030017420 S.CERAMIC ECJ0EC1H470J T DS3 5040001760 S.LED SEC 2422C T
C7 4030017460 S.CERAMIC ECJ0EB1E102K B DS4 5040001760 S.LED SEC 2422C T
C8 4030016790 S.CERAMIC ECJ0EB1C103K T DS5 5040001760 S.LED SEC 2422C T
C19 4030016790 S.CERAMIC ECJ0EB1C103K B DS13 5040001760 S.LED SEC 2422C T
C20 4030017460 S.CERAMIC ECJ0EB1E102K B
C23 4030017460 S.CERAMIC ECJ0EB1E102K T
C28 4030017460 S.CERAMIC ECJ0EB1E102K B S1 2260001890 S.SWITCH SKQDPA T
C30 4030017420 S.CERAMIC ECJ0EC1H470J B S2 2260001890 S.SWITCH SKQDPA T
C31 4030017420 S.CERAMIC ECJ0EC1H470J T S3 2260001890 S.SWITCH SKQDPA T
C32 4510004630 S.ELECTROLYTIC ECEV1CA100SR B S4 2260001890 S.SWITCH SKQDPA T
C33 4030013960 S.CERAMIC C1005 JB 1C 473K-T-N B S5 2260001890 S.SWITCH SKQDPA T
C34 4030017790 S.CERAMIC ECJ0EB1E682K B S6 2260001890 S.SWITCH SKQDPA T
C35 4030017040 S.CERAMIC ECJ0EB1A333K B S7 2260001890 S.SWITCH SKQDPA T
C36 4030016930 S.CERAMIC ECJ0EB1A104K B S8 2260001890 S.SWITCH SKQDPA T
C37 4030016790 S.CERAMIC ECJ0EB1C103K B S9 2250000460 ENCODER EVQ-VENF0224B T
C38 4030018080 S.CERAMIC ECJ0EB1H182K B S10 2260001890 S.SWITCH SKQDPA T
C41 4030016930 S.CERAMIC ECJ0EB1A104K B EP1 6910012350 S.BEAD MMZ1608Y 102BT T
C42 4030016950 S.CERAMIC ECJ0EB1A473K B EP2 6910012350 S.BEAD MMZ1608Y 102BT B
C44 4030018240 S.CERAMIC ECJ0EB1E562K B EP4 6910012350 S.BEAD MMZ1608Y 102BT B
C45 4030016790 S.CERAMIC ECJ0EB1C103K B EP5 6910012350 S.BEAD MMZ1608Y 102BT T
C46 4030016970 S.CERAMIC ECJ0EB1C223K B EP6 6910012350 S.BEAD MMZ1608Y 102BT B
C48 4030017760 S.CERAMIC ECJ0EB1H222K B EP8 6910012350 S.BEAD MMZ1608Y 102BT B
C52 4030017420 S.CERAMIC ECJ0EC1H470J T EP11 8930062251 LCD CONTACT SRCN-2698-SP-N-W-1 T
6-2
[LOGIC UNIT] [MAIN UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
EP12 0910057732 PCB B 6048B D30 1750000550 S.DIODE 1SS355 TE-17 B
D31 1790001250 S.DIODE MA2S111-(TX) B
D38 1720000730 S.VARICAP MA2S30400L T
FI1 2020001520 CERAMIC CFWLA450KFFA-B0 (CFWS450F) T

FI2 2020001460 CERAMIC CFWLA450KHFA-B0 (CFWS450HT)
[MAIN UNIT] except [EXP-1] T
FI3 2030000270 MONOLITH FL-363 (21.7 MHz) T
REF ORDER FI4 2030000270 MONOLITH FL-363 (21.7 MHz) T
DESCRIPTION M.
NO. NO.
IC1 1130008350 S.IC LV2105V-TLM B X1 6050011870 S.XTAL CR-779 (21.250 MHz) T

IC2 1130011760 S.IC CD4094BPWR T X2 6070000200 DISCRIMINATOR CDBLA450KCAY24-B0 (CDB450C24) T
IC4 1110003490 S.IC TA31136FN (D,EL) B
IC5 1190000350 S.IC M62363FP-650C B
IC6 1110004050 S.IC NJM3404AV-TE1 B L1 6200009350 S.COIL ELJRE R22G-F3 T
IC7 1180001250 S.IC TA7808F (TE16L) B L2 6200003640 S.COIL MLF1608E 100K-T T
IC8 1180000970 S.IC AN78L05M-(E1) B L3 6200001620 S.COIL ELJFC 1R0K-F B
IC9 1110002550 IC TA7252AP T L6 6200009920 S.COIL C2012C-R10G T
IC10 1150002180 S.IC S-AV36 (I) T L7 6200010570 S.COIL C6342A-R11J-A T
IC11 1110004050 S.IC NJM3404AV-TE1 T L8 6200004870 S.COIL ELJFC 2R7K-F T
IC12 1130011780 S.IC SN74AHC2G53HDCTR T L9 6200004880 S.COIL ELJFC 3R3K-F T
L10 6200001620 S.COIL ELJFC 1R0K-F B
L11 6200009350 S.COIL ELJRE R22G-F3 T
Q1 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) B L12 6200009350 S.COIL ELJRE R22G-F3 T
Q2 1590001650 S.TRANSISTOR XP4601 (TX) B L13 6200006980 S.COIL ELJRE R10G-F T
Q3 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) B L14 6200006990 S.COIL ELJRE 56NG-F B
Q4 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) B L15 6200007000 S.COIL ELJRE 82NG-F T
Q5 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) B L18 6200005730 S.COIL ELJRE 39NG-F B
Q6 1530002920 S.TRANSISTOR 2SC4226-T1 R25 T L19 6200004920 S.COIL MLF1608A 2R2K-T B
Q7 1530002920 S.TRANSISTOR 2SC4226-T1 R25 T L20 6200005740 S.COIL ELJRE 47NG-F B
Q8 1590001040 S.TRANSISTOR DTA113ZU T106 B L21 6200006670 S.COIL ELJRE 68NG-F B
Q9 1530002920 S.TRANSISTOR 2SC4226-T1 R25 T L22 6200006670 S.COIL ELJRE 68NG-F B
Q10 1560000810 S.FET 2SK1069-4-TL T L25 6200003280 S.COIL NL 252018T-2R2J B
Q11 1530002920 S.TRANSISTOR 2SC4226-T1 R25 T L26 6200003280 S.COIL NL 252018T-2R2J B
Q12 1530002920 S.TRANSISTOR 2SC4226-T1 R25 T L31 6200009890 S.COIL C2012C-82NG T
Q13 1590000720 S.TRANSISTOR DTA144EUA T106 except [EXP-1] T L32 6200009890 S.COIL C2012C-82NG T
Q14 1510000590 S.TRANSISTOR 2SA1362-Y (TE85L) T L37 6200010050 S.COIL AS080547-47N T
Q15 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) T L38 6200009930 S.COIL C2012C-68NG T
Q16 1530003220 S.TRANSISTOR 2SC4406-4-TL B L39 6200010050 S.COIL AS080547-47N T
Q17 1530000370 S.TRANSISTOR 2SC3356-T1B B L40 6200010420 S.COIL FHW1210HC 1R0JGT T
Q19 1580000760 S.FET 3SK299-T1 U73 B L42 6200007370 S.COIL ELJFC R82K-F B
Q21 1590001010 S.TRANSISTOR DTB113ZK T146 T L43 6200009460 S.COIL 0.25-1.9-7TL 67N T
Q22 1590000430 S.TRANSISTOR DTC144EUA T106 T L45 6200008150 S.COIL 0.35-1.6-7TL 44N T
Q25 1590001010 S.TRANSISTOR DTB113ZK T146 T L46 6200010060 S.COIL AS080647-56N T
Q26 1590000720 S.TRANSISTOR DTA144EUA T106 B L47 6200010060 S.COIL AS080647-56N T
Q27 1580000760 S.FET 3SK299-T1 U73 B L48 6200010060 S.COIL AS080647-56N T
Q28 1530002970 S.TRANSISTOR 2SC4684 (TE16R) B L52 6200002650 S.COIL NL 252018T-R18J B
Q29 1530003090 S.TRANSISTOR 2SC4213-B (TE85R) B L56 6200006670 S.COIL ELJRE 68NG-F B
Q30 1510000890 S.TRANSISTOR DTA143TU T106 T L57 6190001520 S.COIL ZBFS5101-PT T
Q31 1590001320 S.TRANSISTOR DTC143ZUA T106 T L58 6190001520 S.COIL ZBFS5101-PT T
Q34 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) B L59 6190001520 S.COIL ZBFS5101-PT T
Q35 1530002340 S.TRANSISTOR 2SC2954-T1 B L60 6190001520 S.COIL ZBFS5101-PT T
Q36 1590001040 S.TRANSISTOR DTA113ZU T106 T L61 6200003640 S.COIL MLF1608E 100K-T T
Q37 1590001190 S.TRANSISTOR XP6501-(TX) .AB T L62 6200003640 S.COIL MLF1608E 100K-T T
Q38 1590001190 S.TRANSISTOR XP6501-(TX) .AB T
Q39 1590000430 S.TRANSISTOR DTC144EUA T106 B
Q40 1590000430 S.TRANSISTOR DTC144EUA T106 B R1 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) T
Q41 1530003630 S.TRANSISTOR 2SC4617 TLS B R2 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
R3 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) T
R4 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) [EXP] T
D1 1790001250 S.DIODE MA2S111-(TX) B 7030003310 S.RESISTOR ERJ3GEYJ 820 V (82 Ω) [other] T
D2 1750000720 S.VARICAP HVC375BTRF T R5 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B
D3 1750000770 S.VARICAP HVC376BTRF T R6 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B
D4 1720000730 S.VARICAP MA2S30400L T R7 7510001660 S.THRMISTOR NTCG16 4LH 473KT T
D5 1720000730 S.VARICAP MA2S30400L T R8 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T
D6 1790000620 S.DIODE MA77 (TX) B R9 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
D7 1790000620 S.DIODE MA77 (TX) B R10 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) T
D9 1750000710 S.VARICAP HVC350BTRF B R11 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
D10 1750000710 S.VARICAP HVC350BTRF B R12 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B
D11 1750000710 S.VARICAP HVC350BTRF B R13 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) B
D12 1710001060 DIODE XB15A407 T R14 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) B
D13 1750000710 S.VARICAP HVC350BTRF B R15 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) B
D14 1790000980 S.DIODE MA742 (TX) T R16 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) B
D15 1750000550 S.DIODE 1SS355 TE-17 T R17 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) B
D16 1710000870 S.DIODE HVU131TRF T R18 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) B
D17 1790000980 S.DIODE MA742 (TX) T R19 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) T
D18 1790001250 S.DIODE MA2S111-(TX) B R20 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) T
D19 1710001080 DIODE XB15A308 T R21 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B
D20 1730000520 ZENER RD20E B2 T R22 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
D21 1790000700 DIODE DSA3A1 T R23 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) T
D23 1790001250 S.DIODE MA2S111-(TX) except [EXP-1] B R24 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) B
D24 1790001250 S.DIODE MA2S111-(TX) except [EXP-1] T R25 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T
D25 1790001250 S.DIODE MA2S111-(TX) except [EXP-1] T R26 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
D26 1790001250 S.DIODE MA2S111-(TX) except [EXP-1] B R27 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) T
D27 1710001060 DIODE XB15A407 T R28 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
D29 1750000370 S.DIODE DA221 TL B R29 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
6-3
[MAIN UNIT] [MAIN UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
R30 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) T R154 7030003330 S.RESISTOR ERJ3GEYJ 121 (120 Ω)
V B
R31 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T R155 7030003500 S.RESISTOR ERJ3GEYJ 332 V
(3.3 kΩ) B
R32 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) T R156 7030003640 S.RESISTOR ERJ3GEYJ 473 V
(47 kΩ) B
R33 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) T R157 7030003640 S.RESISTOR ERJ3GEYJ 473 V
(47 kΩ) B
R34 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T R168 7030003370 S.RESISTOR ERJ3GEYJ 271 (270 Ω)
V B
R35 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) T R169 7030003230 S.RESISTOR ERJ3GEYJ 180 (18 Ω)
V B
R36 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T R170 7030003370 S.RESISTOR ERJ3GEYJ 271 (270 Ω)
V B
R37 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) T R171 7030003440 S.RESISTOR ERJ3GEYJ 102 V
(1 kΩ)
R39 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T except [EXP-1] B
R40 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T R172 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R41 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) T except [EXP-1] T
R42 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) T R173 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R43 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) B R174 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B
R44 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B R175 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) T
R45 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T R176 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
R46 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B R177 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) B
R47 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) T R178 7030003270 S.RESISTOR ERJ3GEYJ 390 V (39 Ω) B
R48 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) T R179 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) B
R52 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) B R183 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B
R54 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) B R184 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R55 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B R185 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω) B
R56 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B R186 7030005501 S.RESISTOR ERA3YKD 124V (120 kΩ) T
R57 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B R187 7030005501 S.RESISTOR ERA3YKD 124V (120 kΩ) T
R58 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B R188 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T
R59 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) B R189 7030005981 S.RESISTOR ERA3YED 333V T
R60 7030003260 S.RESISTOR ERJ3GEYJ 330 V (33 Ω) B R190 7030005981 S.RESISTOR ERA3YED 333V T
R71 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B R195 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B
R72 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) B R201 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) T
R73 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) B R202 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
R90 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) B R209 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) T
R92 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω) T R212 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) T
R93 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) B R213 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) T
R95 7030000230 S.RESISTOR MCR10EZHJ 56 Ω (560) T R214 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R96 7030000410 S.RESISTOR MCR10EZHJ 1.8 kΩ T R220 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ) T
R104 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B R224 7030003860 S.RESISTOR ERJ3GE JPW V [EXP-1] only B
R106 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B R225 7030003860 S.RESISTOR ERJ3GE JPW V [EXP-1] only T
R107 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B R226 7030003860 S.RESISTOR ERJ3GE JPW V B
R108 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) B R228 7520000120 POSISTOR PTFM04BC222Q2N34B0 T
R109 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ) B R229 7030003860 S.RESISTOR ERJ3GE JPW V B
R110 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B R230 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B
R111 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B R231 7030003860 S.RESISTOR ERJ3GE JPW V T
R112 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) T R232 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T
R113 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B R233 7030003860 S.RESISTOR ERJ3GE JPW V B
R114 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B R234 7030011140 RESISTOR ERJ8GEYJ JPW T
R117 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B R236 7030003860 S.RESISTOR ERJ3GE JPW V B
R120 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T
R121 7030000260 S.RESISTOR MCR10EZHJ 100 Ω (101) T
R122 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B C1 4550006160 S.TANTALUM ECST1CY155R B
R123 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) B C2 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
R124 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) T C4 4030011600 S.CERAMIC C1608 JB 1E 104K-T T
R125 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) T C5 4030006900 S.CERAMIC C1608 JB 1H 103K-T T
R126 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) T C7 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
R127 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) B C8 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
R128 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C9 4030007060 S.CERAMIC C1608 CH 1H 270J-T T
R129 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C10 4510004640 S.ELECTROLYTIC ECEV1CA470SP T
R130 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) B C11 4550006250 S.TANTALUM TEESVA 1A 106M8L B
R131 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) B C12 4550007060 S.TANTALUM ECSTIAX336R B
R135 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C13 4030007030 S.CERAMIC C1608 CH 1H 150J-T T
except [EXP-1] T C14 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
R136 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C15 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
except [EXP-1] T C16 4030007020 S.CERAMIC C1608 CH 1H 120J-T T
R137 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C17 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
except [EXP-1] B C20 4030007090 S.CERAMIC C1608 CH 1H 470J-T T
R138 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C21 4030007050 S.CERAMIC C1608 CH 1H 220J-T T
except [EXP-1] B C22 4030007060 S.CERAMIC C1608 CH 1H 270J-T B
R139 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) C23 4030007070 S.CERAMIC C1608 CH 1H 330J-T B
except [EXP-1] B C24 4550006250 S.TANTALUM TEESVA 1A 106M8L B
R140 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) C25 4030009920 S.CERAMIC C1608 CH 1H 050B-T T
except [EXP-1] T C26 4030007010 S.CERAMIC C1608 CH 1H 100D-T T
R150 7030006070 S.RESISTOR ERJ12YJ101U (100 Ω) T C28 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
R152 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) B C29 4030006980 S.CERAMIC C1608 CH 1H 070D-T T
R153 7030003330 S.RESISTOR ERJ3GEYJ 121 V (120 Ω) B C30 4030006950 S.CERAMIC C1608 CH 1H 040C-T B
6-4
REF ORDER REF ORDER
NO. NO. NO. NO.
C31 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C148 4030007150 S.CERAMIC C1608 CH 1H 151J-T B
C32 4030007020 S.CERAMIC C1608 CH 1H 120J-T T C149 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C34 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T T C152 4030009510 S.CERAMIC C1608 CH 1H 010B-T B
C36 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C153 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C37 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T T C154 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C38 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C157 4510006250 S.ELECTROLYTIC ECEV1CA331UP T
C39 4030011600 S.CERAMIC C1608 JB 1E 104K-T B C158 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C40 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C160 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C41 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C161 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C42 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C162 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T B
C45 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C164 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C47 4030011600 S.CERAMIC C1608 JB 1E 104K-T B C166 4510006220 S.ELECTROLYTIC ECEV1CA101UP T
C49 4030007010 S.CERAMIC C1608 CH 1H 100D-T T C169 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C50 4030006940 S.CERAMIC C1608 CH 1H 030C-T T C170 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C53 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C174 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C54 4030007000 S.CERAMIC C1608 CH 1H 090D-T T C175 4510006250 S.ELECTROLYTIC ECEV1CA331UP T
C55 4030007050 S.CERAMIC C1608 CH 1H 220J-T T C176 4030011040 S.CERAMIC GRM31M4C2H2R0CY21L T
C56 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C177 4510004630 S.ELECTROLYTIC ECEV1CA100SR T
C57 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C178 4030006950 S.CERAMIC C1608 CH 1H 040C-T B
C60 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C181 4510004440 S.ELECTROLYTIC ECEV1HA010SR T
C61 4030007050 S.CERAMIC C1608 CH 1H 220J-T B C182 4030007150 S.CERAMIC C1608 CH 1H 151J-T B
C62 4030007020 S.CERAMIC C1608 CH 1H 120J-T T C184 4030006960 S.CERAMIC C1608 CH 1H 050C-T B
C64 4030011600 S.CERAMIC C1608 JB 1E 104K-T T C187 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C65 4030007050 S.CERAMIC C1608 CH 1H 220J-T B C188 4510004440 S.ELECTROLYTIC ECEV1HA010SR T
C66 4030007050 S.CERAMIC C1608 CH 1H 220J-T B C189 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C67 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C190 4030011020 S.CERAMIC GRM31M4C2H1R0CY21L T
C68 4030007000 S.CERAMIC C1608 CH 1H 090D-T T C191 4030007020 S.CERAMIC C1608 CH 1H 120J-T T
C69 4510004630 S.ELECTROLYTIC ECEV1CA100SR T C192 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C71 4030007090 S.CERAMIC C1608 CH 1H 470J-T B C194 4510006220 S.ELECTROLYTIC ECEV1CA101UP T
C72 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C195 4510004640 S.ELECTROLYTIC ECEV1CA470SP T
C73 4030007050 S.CERAMIC C1608 CH 1H 220J-T B C196 4030011020 S.CERAMIC GRM31M4C2H1R0CY21L T
C74 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C197 4030007020 S.CERAMIC C1608 CH 1H 120J-T T
C76 4030006980 S.CERAMIC C1608 CH 1H 070D-T B C200 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C77 4030006900 S.CERAMIC C1608 JB 1H 103K-T B C201 4030007050 S.CERAMIC C1608 CH 1H 220J-T T
C78 4030011600 S.CERAMIC C1608 JB 1E 104K-T B C204 4510006260 S.ELECTROLYTIC ECEV1AA471UP T
C80 4030007050 S.CERAMIC C1608 CH 1H 220J-T B C206 4030011110 S.CERAMIC GRM31M2C2H9R0DV01L T
C81 4030006900 S.CERAMIC C1608 JB 1H 103K-T B C207 4510006020 ELECTROLYTIC 16 MV 2200 HC T
C82 4510004630 S.ELECTROLYTIC ECEV1CA100SR T C208 4030011210 S.CERAMIC GRM31M2C2H330JV01L T
C83 4030012600 S.CERAMIC C2012 JB 1A 105M-T B C209 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C84 4030007170 S.CERAMIC C1608 CH 1H 221J-T B C210 4030011160 S.CERAMIC GRM31M2C2H150JV01 T
C87 4030007100 S.CERAMIC C1608 CH 1H 560J-T B C215 4030011600 S.CERAMIC C1608 JB 1E 104K-T T
C88 4030007100 S.CERAMIC C1608 CH 1H 560J-T B C216 4030011600 S.CERAMIC C1608 JB 1E 104K-T T
C89 4030006900 S.CERAMIC C1608 JB 1H 103K-T B C217 4030011230 S.CERAMIC GRM31M2C2H390JV01L T
C90 4030007070 S.CERAMIC C1608 CH 1H 330J-T B C218 4030011190 S.CERAMIC GRM31M2C2H270JV01L T
C91 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C221 4030010780 S.CERAMIC C1608 CH 1H 1R5C-T T
C93 4030006910 S.CERAMIC C1608 CH 1H 0R5C-T B C222 4030006900 S.CERAMIC C1608 JB 1H 103K-T B
C94 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C224 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C95 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C225 4030017200 S.CERAMIC GRM31BR32J102KY01L T
C97 4030006960 S.CERAMIC C1608 CH 1H 050C-T B C227 4030011210 S.CERAMIC GRM31M2C2H330JV01L T
C100 4030007120 S.CERAMIC C1608 CH 1H 820J-T B C230 4510004630 S.ELECTROLYTIC ECEV1CA100SR except [EXP-1] T
C111 4030009990 S.CERAMIC C1608 CH 1H 200J-T B C241 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C117 4030006900 S.CERAMIC C1608 JB 1H 103K-T B C243 4030017810 S.CERAMIC C1608 CH 1H 102J-T B
C118 4510004640 S.ELECTROLYTIC ECEV1CA470SP T C244 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C120 4030006900 S.CERAMIC C1608 JB 1H 103K-T B C245 4030008680 S.CERAMIC C2012 JF 1C 105Z-T B
C124 4030006960 S.CERAMIC C1608 CH 1H 050C-T B C250 4030007100 S.CERAMIC C1608 CH 1H 560J-T B
C125 4510004630 S.ELECTROLYTIC ECEV1CA100SR T C251 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C127 4030006920 S.CERAMIC C1608 CH 1H 010C-T B C252 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
C128 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C253 4030007020 S.CERAMIC C1608 CH 1H 120J-T B
C131 4030007120 S.CERAMIC C1608 CH 1H 820J-T B C254 4550006080 S.TANTALUM TEESVB2 1C 106M8L B
C133 4030006920 S.CERAMIC C1608 CH 1H 010C-T B C255 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C136 4030009560 S.CERAMIC C1608 CH 1H R75B-T B C257 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C139 4030007120 S.CERAMIC C1608 CH 1H 820J-T B C265 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
6-5
[MAIN UNIT] 6-2 HM-133V
REF ORDER [MAIN UNIT]
DESCRIPTION M.
NO. NO.
C271 4550006140 S.TANTALUM ECST1EY474R T NO. NO.
C272 4030011600 S.CERAMIC C1608 JB 1E 104K-T T
C273 4550006480 S.TANTALUM TEESVA 1C 475M8L T IC1 1140005870 S.IC µPD7564AG-555-E1 B
C278 4510004540 S.ELECTROLYTIC ECEV0JA470SR T IC2 1130008630 S.IC MC14028BF-EL B
C279 4510004440 S.ELECTROLYTIC ECEV1HA010SR T IC3 1110006010 S.IC S-80845CLUA-B66-T2 B
C280 4550006130 S.TANTALUM ECST1VY224R B
C281 4510005830 S.ELECTROLYTIC ECEV1HAN010R T
C282 4030006860 S.CERAMIC C1608 JB 1H 102K-T B Q1 1530001940 S.TRANSISTOR 2SC2712-BL (TE85R) B
C283 4030006860 S.CERAMIC C1608 JB 1H 102K-T B Q2 1590000680 S.TRANSISTOR DTC114EUA T106 B
C284 4030008880 S.CERAMIC C1608 JB 1H 223K-T B Q3 1590001330 S.TRANSISTOR DTA114EUA T106 B
C285 4030008920 S.CERAMIC C1608 JB 1H 473K-T Q4 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) B
except [EXP-1] T Q5 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) B
C286 4030006860 S.CERAMIC C1608 JB 1H 102K-T B Q6 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) B
C287 4030017810 S.CERAMIC C1608 CH 1H 102J-T B Q7 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) B
C288 4030011810 S.CERAMIC C1608 JB 1A 224K-T B Q8 1530001940 S.TRANSISTOR 2SC2712-BL (TE85R) B
C289 4030006860 S.CERAMIC C1608 JB 1H 102K-T T Q9 1590001010 S.TRANSISTOR DTB113ZK T146 B
C290 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C291 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
C292 4030006860 S.CERAMIC C1608 JB 1H 102K-T T D1 1790000950 S.ZENER MA8056-M (TX) B
C293 4030006860 S.CERAMIC C1608 JB 1H 102K-T B D3 1750000550 S.DIODE 1SS355 TE-17 B
C295 4030006850 S.CERAMIC C1608 JB 1H 471K-T T D5 1750000550 S.DIODE 1SS355 TE-17 B
C299 4030012600 S.CERAMIC C2012 JB 1A 105M-T T D8 1750000550 S.DIODE 1SS355 TE-17 B
D12 1750000550 S.DIODE 1SS355 TE-17 B
D13 1750000550 S.DIODE 1SS355 TE-17 B
J4 6450002220 CONNECTOR PJ-0008P-5 <KUO> B D14 1750000550 S.DIODE 1SS355 TE-17 B
J6 6510014960 S.CONNECTOR B2B-ZR-SM3-TF T D15 1750000550 S.DIODE 1SS355 TE-17 B
J7 6450001430 CONNECTOR HSJ1462-01-010 B D16 1730002280 S.ZENER MA8091-M (TX) B
J11 6510024240 S.CONNECTOR 04-6274-036-000-800 T D17 1730002280 S.ZENER MA8091-M (TX) B
D18 1730002280 S.ZENER MA8091-M (TX) B
D19 1750000550 S.DIODE 1SS355 TE-17 B
W1 8900011880 CABLE OPC-1210 (P=0.5 N=36 L=70)
W5 7120000470 JUMPER ERDS2T0
W6 8900010980 CABLE OPC-1131 <CMI> X1 6060000530 CERAMIC CSBLB600KJ28T-B0 (CSB600J200T) B
EP1 6910012350 S.BEAD MMZ1608Y 102BT B L1 6200001520 S.COIL MLF2012D R82K-T B

EP2 6910012350 S.BEAD MMZ1608Y 102BT B L2 6200001520 S.COIL MLF2012D R82K-T B
EP3 6910012350 S.BEAD MMZ1608Y 102BT T
EP4 6910012350 S.BEAD MMZ1608Y 102BT T
EP5 6910012350 S.BEAD MMZ1608Y 102BT B R2 7030000400 S.RESISTOR MCR10EZHJ 1.5 kΩ B
EP6 6910012350 S.BEAD MMZ1608Y 102BT B R3 7030000400 S.RESISTOR MCR10EZHJ 1.5 kΩ B
EP7 6910012350 S.BEAD MMZ1608Y 102BT T R4 7030000400 S.RESISTOR MCR10EZHJ 1.5 kΩ B
EP8 6910012350 S.BEAD MMZ1608Y 102BT B R5 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B
EP9 9040901901 TUBE IRRAX 0.7 (d) L=12 mm R6 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B
EP10 0910057743 PCB B 6076C R7 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B
EP11 6910000640 BEAD FSRH090160RN000B R8 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) B
[USA], [EUR], [EUR-1] only R9 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
EP12 6910000640 BEAD FSRH090160RN000B R10 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B
[USA], [EUR], [EUR-1] only R11 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B
R12 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R14 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B
R27 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) B
R30 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) B
R35 7030000400 S.RESISTOR MCR10EZHJ 1.5 kΩ B
C1 4030006850 S.CERAMIC C1608 JB 1H 471K-T B

C2 4510006220 S.ELECTROLYTIC ECEV1CA101UP B
C3 4030007130 S.CERAMIC C1608 CH 1H 101J-T B
6-6
[MAIN UNIT] [MAIN-A UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
C4 4030007130 S.CERAMIC C1608 CH 1H 101J-T B D16 1730002280 S.ZENER MA8091-M (TX) B
C12 4030006860 S.CERAMIC C1608 JB 1H 102K-T B X1 6060000610 S.CERAMIC EFOS4914E3 B
C15 4030006860 S.CERAMIC C1608 JB 1H 102K-T B L1 6200001520 S.COIL MLF2012D R82K-T B
C16 4030006860 S.CERAMIC C1608 JB 1H 102K-T B L2 6200001520 S.COIL MLF2012D R82K-T B
C19 4030006860 S.CERAMIC C1608 JB 1H 102K-T B R2 7030000400 S.RESISTOR MCR10EZHJ 1.5 kΩ B
C23 4030006860 S.CERAMIC C1608 JB 1H 102K-T B R5 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B
C24 4030006860 S.CERAMIC C1608 JB 1H 102K-T B R6 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B
C29 4510004630 S.ELECTROLYTIC ECEV1CA100SR B R10 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B
C30 4030011600 S.CERAMIC C1608 JB 1E 104K-T B R11 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B
C31 4510004630 S.ELECTROLYTIC ECEV1CA100SR B R12 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
J1 6510023110 CONNECTOR 3008L-8P8C <KIN> B R15 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B
DS1 5010000120 S.LED LN1371G-(TR) T R19 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B
DS2 5010000120 S.LED LN1371G-(TR) T R22 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B
DS7 5010000120 S.LED LN1371G-(TR) T R35 7030000400 S.RESISTOR MCR10EZHJ 1.5 kΩ B
DS10 5010000150 S.LED LT1EP53A T R37 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) B
DS11 5010000150 S.LED LT1EP53A T R38 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) B
MC1 7700002310 MICROPHONE EM-140 T R41 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R42 7030003860 S.RESISTOR ERJ3GE JPW V B
S1 2260000980 SWITCH SKHHLP014A B R44 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
EP1 6910012350 S.BEAD MMZ1608Y 102BT B R47 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
EP5 0910055172 PCB B 5811B R51 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B

C2 4510006220 S.ELECTROLYTIC ECEV1CA101UP B
[MAIN-A BOARD] C10 4030007050 S.CERAMIC C1608 CH 1H 220J-T B
REF ORDER C12 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
DESCRIPTION M.
NO. NO. C13 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
IC1 1140011490 S.IC µPD789071MC-041-5A4-E1 B C15 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
IC3 1110006310 S.IC BD5245G-TR B C16 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
IC6 1130012030 S.IC BR24L02FV-WE2 B C17 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
Q1 1530001940 S.TRANSISTOR 2SC2712-BL (TE85R) B C21 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
Q2 1590000680 S.TRANSISTOR DTC114EUA T106 B C22 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
Q3 1590001330 S.TRANSISTOR DTA114EUA T106 B C23 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
Q4 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) B C24 4030006860 S.CERAMIC C1608 JB 1H 102K-T B
Q8 1530001940 S.TRANSISTOR 2SC2712-BL (TE85R) B C29 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
Q9 1590001010 S.TRANSISTOR DTB113ZK T146 B C30 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
C31 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
D1 1790000950 S.ZENER MA8056-M (TX) B

D3 1750000940 S.DIODE ISS400 TE61 B J1 6510023110 CONNECTOR 3008L-8P8C <KIN> B
D4 1750000940 S.DIODE ISS400 TE61 B
D5 1750000940 S.DIODE ISS400 TE61 B
D6 1750000940 S.DIODE ISS400 TE61 B DS1 5010000120 S.LED LN1371G-(TR) T
6-7
[MAIN-A UNIT] 6-3 UT-108 (OPTIONAL UNIT)
REF ORDER [MAIN UNIT]
DESCRIPTION M.
NO. NO.
DS7 5010000120 S.LED LN1371G-(TR) T NO. NO.
DS8 5010000120 S.LED LN1371G-(TR) T
DS10 5010000150 S.LED LT1EP53A T IC1 1130007560 S.IC LC73881M-TLM B
DS11 5010000150 S.LED LT1EP53A T IC2 1130007300 S.IC TC4W66FU (TE12L) B
MC1 7700002310 MICROPHONE EM-140 T X1 6050005090 XTAL CR-245 (4.194304 MHz) T
S1 2260000980 SWITCH SKHHLP014A B L1 6200001260 S.COIL MLF2012A 1R8M-T B
EP5 0910057281 PCB B 6094A R5 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
C1 4550006300 S.TANTALUM ECST1AY475R B

C4 4030011600 S.CERAMIC C1608 JB 1E 104K-T B
J1 6510018440 S.CONNECTOR AXN430C330P B
EP1 0910050481 PCB B 5191A
6-8
6-4 UT-115 (OPTIONAL UNIT)
REF ORDER REF ORDER
NO. NO. NO. NO.
IC1 1180002390 S.REG S-812C33AMC-C2N-T2 T R260 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
IC2 1180002370 S.REG R1111N321B-TR T R261 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B
IC50 1130011630 S.IC AD73311ARS T R262 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ) T
IC101 1130008360 S.IC TC7SHU04FU (TE85L) B R264 7310004610 S.TRIMMER EVM-2WSX80 B15 (104) T
IC103 1130006890 S.IC TC7S04FU (TE85R) T R267 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) B
IC151 1130010920 S.IC AMBE-2020 T R268 7030006610 S.RESISTOR ERJ2GEJ 394 X (390 kΩ) B
IC202 1130010460 S.IC TC7SH08FU (TE85L) B R269 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ) B
IC203 1110005730 S.IC S-80928CNMC-G8Y-T2 B R270 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B
IC204 1140010770 S.IC HD64F3687FP B R308 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) T
IC251 1110005290 S.IC NJM2115V-TE1 B R309 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) T
IC252 1110005430 S.IC CMX589AD5 B R315 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) T
IC253 1110006200 S.IC NJM13404V-TE1 B R316 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) T
IC254 1130004200 S.IC TC4S66F (TE85R) B R317 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B
IC351 1120002980 S.IC MAX3226EAE-T T R318 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) T
Q50 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) T
Q51 1590000430 S.TRANSISTOR DTC144EUA T106 B
Q201 1590000430 S.TRANSISTOR DTC144EUA T106 B C1 4550006250 S.TANTALUM TEESVA 1A 106M8L T
Q251 1590000430 S.TRANSISTOR DTC144EUA T106 B C5 4030017460 S.CERAMIC ECJ0EB1E102K B
Q301 1590000430 S.TRANSISTOR DTC144EUA T106 B C8 4030016930 S.CERAMIC ECJ0EB1A104K T
Q305 1590001660 S.TRANSISTOR XP4312 (TX) B C11 4550006480 S.TANTALUM TEESVA 1C 475M8L T
Q306 1590001660 S.TRANSISTOR XP4312 (TX) B C50 4030016930 S.CERAMIC ECJ0EB1A104K T
Q400 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) B C51 4030016970 S.CERAMIC ECJ0EB1C223K T
C54 4550006250 S.TANTALUM TEESVA 1A 106M8L T
C55 4030016930 S.CERAMIC ECJ0EB1A104K T
D151 1790001240 S.DIODE MA2S728-(TX) T C56 4030016950 S.CERAMIC ECJ0EB1A473K B
D152 1790001250 S.DIODE MA2S111-(TX) B C57 4030016930 S.CERAMIC ECJ0EB1A104K T
C102 4540000070 S.TRIMMER TZY2Z100A001 T
X101 6050011240 S.XTAL CR-708 (16.384 MHz) T C103 4030017590 S.CERAMIC ECJ0EC1H070C T
X201 6050011700 S.XTAL CR-760 (9.8304 MHz) T C104 4030016930 S.CERAMIC ECJ0EB1A104K B
C150 4550000460 S.TANTALUM TEESVA 1C 105M8L T
L50 6200003960 S.COIL MLF1608A 1R0K-T T C151 4030016930 S.CERAMIC ECJ0EB1A104K T
L151 6200003960 S.COIL MLF1608A 1R0K-T B C152 4030016930 S.CERAMIC ECJ0EB1A104K T
L201 6200003960 S.COIL MLF1608A 1R0K-T B C153 4030016930 S.CERAMIC ECJ0EB1A104K T
L351 6200003960 S.COIL MLF1608A 1R0K-T T C154 4030016930 S.CERAMIC ECJ0EB1A104K T
R1 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) T C157 4030016930 S.CERAMIC ECJ0EB1A104K T
R2 7030000180 S.RESISTOR MCR10EZHJ 22 Ω (220) T C159 4030016930 S.CERAMIC ECJ0EB1A104K T
R50 7030005010 S.RESISTOR ERJ2GEJ 681 X (680 Ω) T C201 4030016930 S.CERAMIC ECJ0EB1A104K B
R51 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) T C202 4030017590 S.CERAMIC ECJ0EC1H070C B
R52 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B C203 4030016930 S.CERAMIC ECJ0EB1A104K B
R53 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C204 4030017390 S.CERAMIC ECJ0EC1H180J T
R54 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) T C205 4030016930 S.CERAMIC ECJ0EB1A104K B
R56 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B C207 4540000080 S.TRIMMER TZY2R200A001 T
R58 7030010040 S.RESISTOR ERJ2GE-JPW B C252 4030017490 S.CERAMIC C1608 JB 1A 105K-T B
R59 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) T C253 4030017400 S.CERAMIC ECJ0EC1H220J B
R100 7030010040 S.RESISTOR ERJ2GE-JPW T C256 4030016930 S.CERAMIC ECJ0EB1A104K B
R101 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) B C257 4030017030 S.CERAMIC ECJ0EB1A273K B
R102 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) B C258 4030017030 S.CERAMIC ECJ0EB1A273K B
R103 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) T C259 4030017760 S.CERAMIC ECJ0EB1H222K T
R201 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B C262 4030017490 S.CERAMIC C1608 JB 1A 105K-T B
R203 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) B C333 4030017460 S.CERAMIC ECJ0EB1E102K T
R204 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) B C351 4030011810 S.CERAMIC C1608 JB 1A 224K-T T
R205 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) B C352 4030011810 S.CERAMIC C1608 JB 1A 224K-T T
R206 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B C353 4030011810 S.CERAMIC C1608 JB 1A 224K-T T
R209 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) B C354 4030011810 S.CERAMIC C1608 JB 1A 224K-T T
R211 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C355 4030011600 S.CERAMIC C1608 JB 1E 104K-T T
R212 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B C401 4550006250 S.TANTALUM TEESVA 1A 106M8L B
R218 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B J301 6510018440 S.CONNECTOR AXN430C330P B
R221 7030010040 S.RESISTOR ERJ2GE-JPW B
R251 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) B EP1 0910057812 PCB B 6071B
6-9
SECTION 7 MECHANICAL PARTS AND DISSASEMBLY
7-1 IC-2200H
[CHASSIS PARTS] [ACCESSORIES]
REF. ORDER REF. ORDER
DESCRIPTION QTY. DESCRIPTION QTY.
NO. NO. NO. NO.
J1 6510004880 Connector MR-DS-E 01 1 F1 5210000080 Fuse FGB 20A 1
SP1 2510001030 Speaker VS-57-0837A 1 W1 8900010990 DC power cable OPC-1132 1
MP1 8010019380 2698 chassis 1 MC1 0880001490 Microphone HM-133V 1

MP2 8110008040 2698 cover 1
MP3 8930045600 2088 SP rubber 1 MP1 8010019260 2633 mobile bracket 1
MP4 8930062130 Thermally sheet (AP) 1 MP2 8820000530 Flange bolt M4 × 8 NI 4
MP6 8810008660 Screw PH BT M3 × 8 NI-ZU 12 MP3 8810000470 Screw PH M5 × 12 (+-) 4
MP7 8810009610 Screw FH M2.6 × 6 ZK 4 MP4 8810000950 Screw PH A M5 × 12 4
MP8 8810005160 Cap bolt M3 × 20 ZK 2 MP5 8850000150 Flat washer M5 NI BS 4
MP6 8850000390 Spring washer M5 4
MP7 8830000120 Nut M5 4
MP8 8930007300 Mic hanger [USA] only 1
[LOGIC UNIT] MP9 8930062650 Insulation sheet (HS) 1
REF. ORDER DESCRIPTION QTY.
NO. NO.
J1 6450002210 Connector 3017-8821 1
MC1 W1
R61 7210001870 Variable resistor EVU-F2AF20 A14 1 MP2
R62 7210001860 Variable resistor EVU-F2AF20 B14 1
MP3
S9 2250000460 Switch EVQ-VENF0224B 1 MP4
MP5
DS1 5030002660 LCD IS08264E00V2 1
MP6
MP7
EP11 8930062251 LCD contact SRCN-2698-SP-N-W-1 1
MP1 8210020350 2698 front panel 1 MP1 F1 MP8 MP9

MP2 8210020340 2698 reflector 1
MP3 8930061130 2698 2-button 1
MP4 8930061140 2698 7-button 1
MP5 8930045610 2088 LCD filter 1
MP6 8810008990 Screw PH BT M2 × 10 ZK 4
MP7 8510015700 2698 front plate 1
MP8 8610011620 Knob N316 1 7-2 HM-133V
MP9 8610011610 Knob N317 2
[CHASSIS PARTS]
MP11 8930062710 Sponge (HR) 1
MP12 8930062700 Himelon sheet (CM) 1 REF. ORDER DESCRIPTION QTY.
NO. NO.
W1 8900011270 Cable OPC-1153 1
[MAIN UNIT]
MP1 8210018830 2539 front panel [HM-133] 1
REF. ORDER 8210018890 2539 front panel (A) [HM-133S] 1
DESCRIPTION QTY.
NO. NO. 8210018910 2539 front panel (B) [HM-133V] 1
J4 6450002220 Connector PJ-0008P-5 1 MP2 8210018840 2539 rear panel 1
J7 6450001430 Connector HSJ1462-01-010 1 MP3 8930057380 2539 PTT button 1
MP4 8930057390 2539 LED lens 2
W6 8900010980 DC power cable OPC-1131 1 MP5 8930057570 2539 SW rubber 1
MP6 8930057520 2539 keyboard [HM-133] 1
MP1 8510014470 2509 VCO case 1 8930057710 2539 keyboard (A) [HM-133S] 1
MP2 8510014460 2509 VCO cover 1 8930057700 2539 keyboard (B) [HM-133V] 1
MP3 8930005320 Filter spacer 2 MP8 8810009370 Screw PH BT M3 × 12 ZK 2
MP4 8930062610 2698 M-holder 1 MP9 8810009560 Screw PH BT M2 × 6 ZK 3
[MAIN/MAIN-A UNIT]
REF. ORDER DESCRIPTION QTY.
Screw abbreviations BT, A: Self-tapping NO. NO.
PH: Pan head FH: Flat head J1 6510023110 Connector 3008L-8P8C 1
ZK: Black BS: Brass

S1 2260000980 Switch SKHHLP014A 1
NI: Nickel NI-ZU: Nickel-Zinc
MC1 7700002310 Microphone EM-140 1
7-1
MP3 (C)
(2 13/32)
MP2 (C)
61.0
(2 1/8)
54.3
J1 (C)
HM-133V
MAIN/MAIN-A UNIT MP6 (C)
MP9 (C)
104.0
(4 3/32)
Unit: mm (inch)
S1 (M)
Unit abbreviations MP8 (C)
(C):CHASSIS PARTS MP6 (C)
(1 1/4)
31.5
(M): MAIN/MAIN-A UNIT
MC1 (M)
MP5 (C) MP1 (C)

MP4 (C)
J1 (M) MP1 (C)

MP6 (L)
MP7 (L)
R61 (L)
MP4 (C)
MAIN UNIT
W1 (C) J1 (L)
J7 (M)
J4 (M)
R62 (L)
MP12 (L) A W6 (M)
IC-2200H A
LOGIC UNIT MP6 (C)
MP3 (L) S9 (L) MP1 (M)
Unit abbreviations
(C):CHASSIS PARTS MP1 (L) B
(L): LOGIC UNIT MP2 (L)
(M): MAIN UNIT MP5 (L)
EP11 (L) MP2 (M)
MP8 (C)
MP4 (M)
DS1 (L)
MP9 (L)
MP11 (L) MP3 (C) MP6 (C)
(1 1/16)
27.3
MP4 (L)
(1 31/32)
50.0
SP1 (C) B
(8 5/32)
207.5
(5 3/4)
146.0
MP8 (L)
140.0
(5 1/2)
MP2 (C)
(1 9/16)
40.0
141.0
Unit: mm (inch) (5 9/16)
MP7 (C)
7-2
SECTION 8 SEMI-CONDUCTOR INFORMATION
• TRANSISTORS AND FET’S • DIODES
2SA1362 Y 2SA1576A T106 R 2SA1586 GR 2SB798 T2 DK 2SC2712 BL 1SS133 1SS355 1SS400 DA221 TL DAN222TL
(Symbol: AEY) (Symbol: FR) (Symbol: SG) (Symbol: DK) (Symbol: BL) (Symbol: A) (Symbol: A) (Symbol: K) (Symbol: N)
B A1
B B B B Yellow
A C A C
C C C C C C
E E E E A2
E
2SC2954 T1 2SC3356 2SC4116 BL 2SC4116 GR 2SC4213 B DSA3A1 HVC350B HVC375B HVC376B HVU131TRF
(Symbol: QK) (Symbol: R25) (Symbol: LL) (Symbol: LG) (Symbol: AB) (Color: Green) (Symbol: B0) (Symbol: B8) (Symbol: B9) (Symbol: P1)
B green
B B B B
A C A C A C A C
C C C C C
E E E E
E
2SC4226 T1 R25 2SC4406 2SC4617 TLS 2SC4684 2SK1069 4 TL MA2S077 MA2S111 MA2S30400 L MA77 MA742
(Symbol: R25) (Symbol: JT) (Symbol: BS) (Symbol: C4684) (Symbol: FJ) (Symbol: S) (Symbol: A) (Symbol: K) (Symbol: 4B) (Symbol: M1U)
E
B B B S
B A C A C A C A C
C C C E G
C
E E E B C D
3SK299 T1 U73 DTA113 ZU T106 DTA114EUA T106 DTA143TUA DTA144 EE TL MA8056 M MA8091 M RD20E B2 XB15A308 XB15A407
(Symbol: U73) (Symbol: 111) (Symbol: 14) (Symbol: 93) (Symbol: 16) (Symbol: 5-6) (Symbol: 9-1) (Symbol: 20 B2) (Symbol: T8)
D G2 B B B B
A C A C A C
C C C C
S G1 E E E E
DTA144EUA T106 DTB113ZK DTC114EUA T106 DTC143ZUA DTC144EUA T106

(Symbol: 16) (Symbol: G11) (Symbol: 24) (Symbol: E23) (Symbol: 26_)
B B B B B
C C C C C
E E E E E
DTC144TU T106 UMG2N XP4601 XP6501 AB

(Symbol: 06) (Symbol: G2) (Symbol: 5C) (Symbol: 5N)
B B1 C1 E1 C1 E1 C1
C E1 B1 B2 E2 B1
E B2 C2 C2 E2 B2 C2
8-1
SECTION 9 BOARD LAYOUTS
9-1 LOGIC UNIT
• TOP VIEW
PWR VOL
DIAL
7 1
S.MW/MW
8 14 14 8 7 1
1 7 8 14
MICROPHONE SQL SET/LOCK MONI/ANM LOW/DUP TONE/T-SCAN M/CALL/PRIO V/MHz/SCAN BANK/OPT
2 8
J1
MICUD
MICIN
PTT
MIC
to the microphone
EXTMIC
MICE
GND
8V
1 7
9-1
• BOTTOM VIEW (LOGIC UNIT)
J4
15 OPV1 OPSCK 16
OPV2 SI
OPV3 OPSO
GND NC
OPT3 CCS
OPT2 REFMOD
OPT1 AFOUT
SIG_OUT DETO to the optional unit
NC RX_MUTE
BUSY 232RX
NC 232TX
MIC_IN NC
MIC_OUT +8V
PTTO +5V
1 PTTI GND 30
109 108
5 4
8 1 7 1
144 73
1 72 8 14
1 14
7 8
1 8
4 5
36 37
1 36
J3
VOLOUT
MICGND
MICGND
POWON
PLLSTB
BSHIFT
DIGI_W
CLONE
CTCSS
MODIN
EXSTB
REF_V
PLLCK
232RX
232TX
TEMP
DETO
UNLK
OPV1
NOIS
IDET
GND
GND
GND
LVIN
SCK
C5V
+8V
+8V
+8V
+5V
+5V
+5V
SO
OE
SD
to the MAIN unit J11
9-2
• TOP VIEW
9-2 MAIN UNIT
9-3
EP12
EP
11
black
red
DC power
16
1
8
J11
36
232TX
35
232RX
GND
CLONE
PWRON
LVIN
VOLOUT
C5V
+8V
+8V
+8V
EXSTB
GND
GND
SO
PLLCK
PLLSTB
OE
BSHIFT
DEGI_W
REF_V
UNLK
MODIN
TEMP
to the LOGIC unit J3

SCK
OPV1
GND
GND
1
8
+5V
+5V
4
5
+5V
IDET
DETO
CTCSS
2
SD
1
NOIS
4
1
5
8
ANT
unit J1
CHASSIS
• BOTTOM VIEW (MAIN UNIT)
DATA SP
4 1
5 8
1 24 1 16
1 16
8 9
8 9
13
12
9-4
9-3 HM-133V NOTE:
• TOP VIEW (MAIN UNIT) HM-133V’s main unit has 2 versions (MAIN or MAIN-A). • TOP VIEW (MAIN-A UNIT)
MAIN unit employs old type CPU, MAIN-A unit employs new type one.
Make sure to be used whether MAIN unit or MAIN-A unit before servicing.
VFO/LOCK MR/CALL BANK/OPTION VFO/LOCK MR/CALL BANK/OPTION
F-2 F-2
F-1 F-1
FUNC FUNC
DTMF-S DTMF-S
1 2 3 A 1 2 3 A
4 5 6 B 4 5 6 B
7 8 9 C 7 8 9 C
* 0 # D 0 # D
*
9-5
• BOTTOM VIEW (MAIN-A UNIT) • BOTTOM VIEW (MAIN UNIT)
PTT PTT
30 16 1 16
1 15
8 9
1 8 11 10
4 5
20 1
8 2 8 2
J1 J1
MDATA
MDATA
MU/D
MU/D
PTT
MIC
PTT
MIC
to the IC-2200H to the IC-2200H
LOGIC unit J1 LOGIC unit J1
M8VSW
M8VSW
MICE
MICE
M8V
M8V
E
E
7 1 7 1
9-6
9-4 HM-118TN
• TOP VIEW • BOTTOM VIEW (HM-118TN)
UP DN
14 8
11 10
1 7
PTT
UP DOWN
LOCK
20 1
8 2
J1
MICE
GND
NC
8V
to the IC-2200H
LOGIC unit J1
HANG
PTT
MIC
U/D
7 1
9-7
SECTION 10 BLOCK DIAGRAMS
10-1 IC-2200H +8V
IC11 NJM3404V
CURRENT HV
Q1 2SC4116 Rx 96.300-152.300MHz DET
SHIFT VCO Q3 2SC4116 Tx 136.000-174.000MHz
REG Q5 2SC4116
Q8 DTA113ZU ANTENNA
D1 MA2S111 T8 T8
for CPU D12 XB15A407
Q6 2SC4226 D6 MA77 IC10 D19 XB15A308
IC1 LV2105V Q2 XP4601 D2 HVC375B D7 MA77 S-AV36 D16 HVU131TRF
CP D4 MA2S304 50-100mW
REF PLL LOOP LO TX/RX PRE DRIVE PWR ANT
OSC OUT AMP BUFF DRIVE SW LPF
IC FIL SW AMP AMP Tx* 136.000-174.000MHz
(LOOP-SW) Rx* 118.000-174.000MHz
Q9 2SC4226 Q11 2SC4226 Q17 2SC3356 Q35 2SC2954
MOD D30 1SS355 *Depended on versions
Q4 2SC4116
D3 HVC376B
X1 CR-779
(21.25MHz)
Q10 2SK1069 Q7 2SC4226
D5,D38 MA2S304
APC PWR
DC AMP BUFF LPF
CTRL DET
Q12 2SC4226
IC6a NJM3404AV D14 MA742
R5V Q26 DTA144EU D17 MA742
IC11 NJM3404V
Q39,Q40 DTC144EU
R5V R5V
IC4 TA31136FN D9 HVC350B
Q16 FI3 FL-363 D10 HVC350B D31 MA2S111 IC6a NJM3404AV
2SC4406 D29 DA221 FI4 FL-363 D11 HVC350B Q27 3SK299 D13 HVC350B D18 MA2S111 D15 1SS355
LPF IF DET-IC
(2nd-MIX,IF-AMP, IF XTAL RF
NOISE-AMP,FMDET, AMP LIMIT BPF AMP BPF ATT LIMIT
BPF
RSSI,SQLSW) Q19
Q36 DTA113ZU 21.7MHz 3SK299
T1
AM MODE IC12 SN74AHC2G53HDCT T2
REG AGC T3 AGC T3 SQLATT
X2 CDB450C24
AM/FM Q13 DTA144EU
AM DET R5V +5V +8V SWHV C5V HV
SELECT Q34 2SC4116 T8
W/N SW SQLIN
D23-D26 MA2S111
BSHIFT DETO
Q37,Q38 *ONLY W/N Ver.
XP6501 AGC
DTC/FC
IC5 R5 T8 +5 +8 C5V
CERAMIC CERAMIC D/A REG
M62363FP REG REG REG REG
BPF BPF
DETO
Q25 Q14 2SA1362 Q21 IC7 IC8

AGC FI1 FI2 DTB113ZK Q15 2SC4116 DTB113ZK TA7808F TA78L05F
CTCSS
MODIN
CFWS450F CFWS450HT Q22
RXC
DTC144EU
TXC
MAIN W6
DETOUT(DIGI_AFI) PWRON
IC525 CD4066BPER IC3c NJM12902V HVSW
EXP
PORT
LOGIC ANALOG HPF Q28 2SC4684 REVERSE
SEL IC2 CD4094BPWR Q30 DTA143TUA & OVER
IC522 CD4066BPWR IC522 CD4066BPWR Q31 DTC143ZU VOLTAGE
PROTECT
AN MOD_I DI/AN DI/AN
DI_SEC SW SW D20 RD20E
D21 DSA3A1
DIGI,AN MIC_OUT
THROUGH DIGITAL MOD OUT
EXT MIC IC3A ANALOGUE MOD IN/MIC_IN
RXAF
NJM12902V AFOUT(DIGI_AFOUT)
VOLIN
MIC MIC MIC THROUGH
JACK SW AMP SW IC520
CD4066BPWR IC3d NJM12902V IC3b NJM12902V Q525 DTC144EU
IC2 T/R
TC4S66F ANALOG SW AFOUT CUTOFF TX_DIGI
Q528 DTA144EE HPF CTCSS/ LPF SWHV
D4 IC6 CD4066BPWR SHIFT
DAN222 IC520 IC520 IC525 TONE IC524
CD4066BPWR CD4066BPWR CD4066BPWR TXAF SN74AHC2G53HDCT Q29 Q41
SIG_OUT Q2 2SC4213 2SC4617 IC9
ALC ALC ALC SECRET DTC144EU TA7252AP
SW AMP SW SW SECRET CUTOFF VOLOUT AF EMPHASIS AF AF OUT
IC24 TA75S393F IC514 SW SHIFT DS1 CTCSS MUTE SW AMP SP
IS08264E LPF J4
D1 MA8091 AN6123MS SW
Q527 Q6 2SA1576 CLONE EXT SP-JACK
UMG2N LCD DIMMER Q7,Q8,Q12 2SC4116
ALC SECRET DS2-DS13 SEC2422C DIGI
ALC Q524 SECRET DIGI,AN
MICDATA PS 2SA1576
IC525
BUFF
CD4066BPWR
Q1 2SC4116
THROUGH D7-D9,D21 DAN222 DIAL
D2 MA2S111
INT/KEY D11 1SS133 J7
MATRIX D12-D17,D22,D23, RS-232C TX/RX/GND
PTT SW Q3 XP4601 D27,28 1SS400 VOL SQL
CTCIN
LPF
CLONE
BUFF Q5 DTC144TU
DETO CPU D6 DA221
X1 IC1 M30220
CR-739
D25 MA2S077
SP1
CLOCK Q515 2SA1576
SHIFT
REFMOD AN
AMP
D526 MA2S111 REG
C5V
Q514 2SC4116
Explanatory notes
SD/NOIS Q513 2SB798 VOLTAGE LINE
RESET EEPROM TX
OPTION OPTION
AMP RX
REG CONNECT
LVIN IC4 BD5242FVE IC5 HN58X2464TI IC521 TC75S51F COMMON
DATA/CONTROL/BUS,ets
OP_PS
10 - 1
10-2 HM-133V
5V (MAIN)
IC3 S-80845CLUA
D13 1SS355
Q8 2SC2712 Q1 2SC2712 (MAIN-A)
Q9 DTB113ZK D1 MA8056 IC3 BD5245G
M8V REG CTRL 5V REG RESET
DS1-DS8 LN1371G D16,D17 MA8091
BACK
PROTECTO
LIGHT
MIC MIC
GND Q2 DTC114EU
Q3 DTA114EU
DATA
MDATA BUFF
PROTECTO
D18 MA8091
DATA
RESET
LED/ Q4,Q5 2SA1586

CPU DRIVER DS11 LT1EP53A
IC2
MC14028BF IC1
µPD7564AG (MAIN)
µPD789071 (MAIN-A)
MATRIX LED/ Q6,Q7 2SA1586
DRIVER DRIVER DS10 LT1EP53A
D14,D15 1SS355 (MAIN only)
(MAIN only)
EE-PROM IC6
BR24L02FV
KEY MATRIX
(MAIN -A only)
Explanatory notes
D3-D7,D9-D12
1SS355 (MAIN) DATA BAS
1SS400 (MAIN-A)
COMMON
TX
VOLTAGE LINE
10 - 2
SECTION 11 VOLTAGE DIAGRAMS
11-1 LOGIC UNIT
LOGIC UNIT +8V +8V +8V +8V

SIG_OUT
+8V
+5V +5V +5V +5V +5V
C5V C5V C5V C5V
330k
100k
0.01
MOD_I
+8V
VOLIN
R5
R6
C8
R15
C36
R2 R13
0.01
0.01
C78
C66
0.1
4 1.9V
1k
120k 12k 1.9V 1.9V
+8V
1 5 V+ IC3 R56 R72 R81
4 REMO 1 220k 120k
3 IC2 IC3 GND NJM12902V IC3 DIAL
R14
C32
10k
2 TC4S66F NJM12902V 11 NJM12902V IC6 S9
10
D1 MA8091
R538
R539
C72 0.033 R75 68k
120k
R96
C56
39k
R91
1 5 3 12 CD4066BPWR EVQ-VENF02
47k
47k
270p
R1 12k
R3 10k
IC3
C75
IC24 + 1 + 14 0.0022 R76
2 13 1 14 NJM12902V 1
C69
TA75S393F - -
0.1
R105
I/O1 VDD C73 2.2 R74 150k 18k A
100k
100k
R23
2 1.9V 2 13 6 2
C5V
+8V
+5V
TX: 5.0V IC3 -
R519
CP1 R39 150k O/I1 CONT1 7 B
1.5M
R8 C41 C54
1.8k
R38
R53
RX: 0V
680
NJM12902V 3 12 5 3
2.2k R103 0.1 0.01 O/I2 CONT4 C71 0.01 R73 180k + NC
3 4 R104 9 4 11 4
-
R109
150k Q527 8 I/O2 I/O4 COM
10 5 10
27k
C5V
82k
+5V
UMG2N +
0.0056
C588
C57 CONT2 O/I4
100k
C47
R49
R92
C77
22k
27k
18k
D2 MA2S111
3.9k
1.5k
R12
R45
R84
[USA]
0.1
2.2
6 9
R9
0.0027 Q525
C74
C33 18k C79 C42 C44 CONT3 O/I3
1
PTT 4 3 DIGI 7 8 DTC144EU
R69 150k
0.047 [OTHER] 220p 0.047 0.0056 VSS I/O3
R67 18k
R71 10k
R70 39k
R78 100k
R64
R19 1k
1M
R50
1M
2
0.033
100k
R30
TX_DIGI
15k
R35
C76
RMUT
TX: 0V
AFON
Q1
R10
10k
RX: 4.5V 2SC4116 5 1 AN
MMUT
MICS
D4
DAN222 BIAS BIAS BIAS 1.9V
DIUD
DICK
J1 7.5V EXTM1
MICIN EP1 THROUGH
SECRET
GND EP2
DI_SEC
MIC DS1
EXTM1
MIC EP3 Q528 +5V IS08264E
MICE EP4 DTA144EE C5V
S40
S39
S38
S37
S36
S35
S34
S33
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
R20 1k
S9
S8
S7
S6
S5
S4
S3
S2
S1
to the PTT EP5 MICUD
microphone R47 R134 R18 R60 R31
EXTMIC EP6
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
R101 4.7k 100k 10k 56k 56k 56k
MICUD EP7 +5V +5V
8V EP8 +8V
SEG36
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
COM1
COM2
COM3
COM4
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
0.001
0.001
R52
C591
C595
IC520 IC525 1k
D3 MA8091
C11 0.001
C16 0.001
C20 0.001
C23 0.001
C28 0.001
CD4066BPWR CD4066BPWR EXTMIC

C31 47p
1 14 1 14
C5V
+8V
+5V
I/O1 VDD I/O1 VDD R27 R36

2 13 2 13 REF_V REF_V
O/I1 CONT1 O/I1 CONT1 39k 12k
3 12 3 12
COM1
COM2
COM3
COM4
SEG36
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
SEG19
SEG18
O/I2 CONT4 O/I2 CONT4
4 11 4 11 C5V C5V
I/O2 I/O4 I/O2 I/O4
0.01
C45
+5V 5 10 5 10 IDET IDET
CONT2 O/I4 CONT2 O/I4
ALC 6 9 6 9
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
R546
CONT3 O/I3 CONT3 O/I3
100k
R107 100k
R129 100k
0.01
C70
R11 100k
R543 47k
7 8 7 8 Q2
VSS I/O3 VSS I/O3 C43
C584
J4 DTC144EU
P97/AN7
AVCC
VREF
P130/ADTRG/DAO
AVSS
P131/DA1
P132/DA2
VSS
VL1
VL2
VL3
C1
C2
COM0
COM1
COM2
COM3
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16/P100
SEG17/P101
SEG18/P102
C583
0.047
0.1
DUSE
0.1
16 15 R26 22k
0.001
OPV1 R4 10k OPV1 MIC_IN/ANALOGUE_MOD_IN
C39
OPSCK OPSCK MIC_OUT/DIGI_MOD_OUT
+8V
OPV2 R128 10k OPV2 DETO DETO DETO DETO
SI SI AF OUT AFOUT CTCIN 1 108 SEG17
P96/AN6 SEG19/P103
C5V
MIC_IN/ANALOGUE_MOD_IN
+5V
OPV3 R106 10k EXSTB SQLV 2 107 SEG16
MIC_OUT/DIGI_MOD_OUT
P95/AN5 SEG20/P104
OPSO OPSO +5V +5V MICUD 3 106 SEG15
R114
P94/AN4 SEG21/P105
470p
0.01
C81
C82
SD 4 105 SEG14
12k
at ALC ON: 0.95V
R533
R525
P93/AN3 SEG22/P106
0.001
0.001
C592
C600
100
LVIN 5 104 SEG13
AF OUT
47k
IC514 P92/AN2 SEG23/P107
C5V
+8V
+5V
+5V
OPT3 OPT3 R516 C585 AN6123MS IC522 TEMP 6 103 SEG12

0 0.1 CD4066BPWR P91/AN1 SEG24/P110
CCS CCS 3 2 DETO 7 102 SEG11
INPUT DET R41 12k C5V P90/AN0 SEG25/P111
OPT2 OPT2 4 1 14 COLOR 8 101 SEG10
R517
C587
GND I/O1 VDD D25 P87/TA7IN SEG26/P112
REFMOD 5 1 2 13 DIGI DIM0 9 100 SEG9
1M
10
OUTPUT VCC O/I1 CONT1 MA2S077 C53 56p P86/TA7OUT SEG27/P113
to the OPT1 OPT1 3 12 DIM1 10 99 SEG8
R537
C586
R536 C599 O/I2 CONT4 P85/TA6IN SEG28/P114
680
optional AFOUT R7 100 AFOUT 10k 0.1 4 11 DIM2 11 98 SEG7
10
R112
I/O2 I/O4 X1 R51 P84/TA6OUT SEG29/P115
0.01
unit
C80
SIG_OUT SIG_OUT at ALC ON: 1.3V 5 10 MOD_I OE 12 97 SEG6
12k
CONT2 O/I4 CR-739 10 P83/TA5IN SEG30/P116
MODIN
DETO DETO/DIGI_AFI DETO 6 9 13 96 SEG5
VOLIN
Q524 R515 CONT3 O/I3 CSHIFT P82/TA5OUT SEG31/P117
at ALC ON: 4.95V 7 8 14 95 SEG4
2SA1576 100 VSS I/O3 R48 P81/TA4IN/INT5 SEG32/P120
RX_MUTE RX_MUTE +5V 15 94 SEG3
1M R135 10k P80/TA4OUT/INT5 SEG33/P121
BUSY BUSY 16 93
REFMOD
R531 R532 C594 CNVSS VSS

232RX EP9 232RX 17 92 SEG2
C5V
+8V
+5V
47k 47k 0.001 XCIN SEG34/P122
C55
C59
15p
THROUGH 18 91 C5V
8p
R133 47k XCOUT IC1 VCC
232TX EP10 232TX RESET 19 M30220MA-132RP 90 SEG1
RESET SEG35/P123
MIC_IN MIC_IN/ANALOGUE_MOD_IN AN 20 89
DIGITAL: 5.0V XOUT SEG36/P124
+5V +5V 21 88
VSS SEG37/P125
MIC_OUT MIC_OUT/DIGI_MOD_OUT XIN 22 87
XIN SEG38/P126
0.001
C596 Q515 R137
C597
+8V IC524 C5V 23 86 OPT1
0.001 2SA1576 SN74AHC2G53HDCT 47k VCC SEG39/P127
PTTO PTTO 24 85 OPT2
P77/NMI SEG40/P00
+5V 1 8 C5V PWRSW 25 84 OPT3
R530
R534
R520 COM VCC P76/INT2 SEG41/P01

PTTI PTTI 2 7 26 83
47k
47k
47k INH Y0 P75/INT1 SEG42/P02
C67
C68
0.1
GND 3 6 27 82
10
R550 R549 R548 GND Y1 P74/INT0 SEG43/P03
30 1 4 5 DIGI DICK 28 81 ALC
R541 47k
R542 47k
R524
R521
R136
0 68 68 GND A P73/CTS2/RTS2 SEG44/P04
100k
3 5 10k DIUD 29 80 THROUGH
47k
- 4 P72/CLK2 SEG45/P05
1 CLIN 30 79 DIGI
+ Explanatory notes
C602
C601
P71/RXD2/SCL SEG46/P06
+5V 2 CLOUT 31 78 AN
10
10
R523
R522 P70/TXD2/SDA SEG47/P07

IC521 VOLTAGE LINE 32 77 OP_PS
1M
150k TC75S51F P67/TXD1 P10/KI0

+8V 33 76 ESDA
P66/RXD1 P11/KI1
CTCSS TX LINE 34 75 ESCK
P65/CLK1 P12/KI2
Q513 BUSY 35 74 DUSE
2SB798 R527 R22 1k P64/CTS1/RTS1/C P13/KI3
+5V SQLV SQLV 36 73 EXTMIC
RX LINE
P46/TA3OUT/INT4
10k P63/TXD0 P14/KI4
OP_PS VOLIN OPSO
P60/CTS0/RTS0
Q514
P47/TA3IN/INT4
2SC4116 SI
P44/TA2OUT
P42/TA1OUT
P40/TA0OUT
COMMON LINE
P57/CKOUT
R42 1M
R43 1M
R44 1M
R62 R61
0.001
1k[EXP/-1]
P55/TB5IN
P54/TB4IN
P53/TB3IN
P52/TB2IN
P51/TB1IN
P50/TB0IN
P45/TA2IN
P43/TA1IN
P41/TA0IN
R545
MODIN
P62/RXD0
C40
+8V
P61/CLK0
EVU-F2AF20B14 EVU-F2AF20A14
P56/INT3
P33/KI19
P32/KI18
P31/KI17
P30/KI16
P27/KI15
P26/KI14
P25/KI13
P24/KI12
P23/KI11
P22/KI10
C5V
C5V
+8V
+5V
+5V
1k
P21/KI9
P20/KI8
P17/KI7
P16/KI6
P15/KI5
DIGITAL LINE
C593
R526
D526
0.01
C19
R55
only
VOLOUT SCK
0.1
P35
P34
MA2S111
1k
NOIS
D11 1SS133 [TPE], [KOR], [EUR-1]
+5V R46
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
5.0V D13 1SS400 except [EXP/-1] 1k
C5V C5V C5V C5V
D15 1SS400 [EXP/-1]
CTCIN +5V +5V
D16 1SS400 [EUR/-1], [EXP/-1]
R24
R25
0.01
0.01
15k
10k
C37
C65
0.7V
RX_MUTE
R108
SECRET
D17 1SS400 [TPE], [KOR], [EXP/-1]
TX_DIGI
PWRON
R28 C51
PLLSTB
DI_SEC
DIGI_W
BSHIFT
OPSCK
J3
10k
EXSTB
PLLCK
REMO
MMUT
RMUT
AFON
100k 0.027
UNLK
OPV1
OPV2
PTTO
D22 1SS400 [TPE], [EXP/-1]
MICS
PTTI
CCS
NOIS NOIS RESET
KR3
KR2
KR1
KR0
KS1
KS2
PTT
IS0
IS1
IS2
SO
D23 1SS400 [TPE], [KOR]
SD SD
D27 1SS400 except [EXP-1]
0.033
CTCSS +8V
3
2
1
Q3
C35
1.3V XP4601 D28 1SS400 [EXP/-1]

DETO
CT
SUB
VOUT
IDET IDET 4 3 KR0 KR0

C5V
R16
BD5242FVE-TR
R17 R21 DS3 DS2 DS9 DS8

68k
+5V +5V +5V

68k 68k SEC2422C SEC2422C SEC2422C SEC2422C
+5V 5 2 V-MHz/SCAN MONI/ANM
0.001
C14
+5V D7 S2 D9 S6 R R R R
0.0068
R34
0.0018
68k
GND
VDD
MICGND 6 1 DAN222 SKQDPA DAN222 SKQDPA
R87
C34
COMEXP
C38
1k
IC4
MICGND G G G G
R37 KS2 D11
OPV1 OPV1
4
0.2V 100k
SCK SCK
BAND1 W/N
KS1
+8V
DS5 DS4 DS11 DS10
IS2
TEMP TEMP
R29 D22 D27 SEC2422C SEC2422C SEC2422C SEC2422C
0.022
C49
0.0022
1.2k
R32
KR0
0.1
MODIN M-CALL/PRIO SET/LOCK

C46
10k
C48
UNLK UNLK S3 S7 R R R R
IS0
IS1
REF_V REF_V +5V +5V SKQDPA SKQDPA
D13 D23 D28
DIGI_W DIGI_W C5V C5V G G G G
BSHIFT BSHIFT ESCK
to the MAIN TXFREF BAND2 ANI
unit J11 OE OE ESDA
C5V
PLLSTB PLLSTB KR1 KR1 DS7 DS6 DS13 DS12

SEC2422C SEC2422C SEC2422C SEC2422C
C5V
R40
+8V
R58
47k
PLLCK PLLCK KS1 KS1

100k
SO SO PWRSW IS2 IS2 R R R R
GND IC5 D6 CLIN IS1 IS1
C52
R57
47p
GND HN58X2464TI DA221 Q5 IS0 IS0 G G G G

15k
R59
15k
EXSTB EXSTB 1 8 DTC144TU KR2 KR2

A0 VCC
+8V +8V +8V 2 7
A1 WP BAND3
+8V 3 6 TONE/T-SCAN S-MW/MW
A2 SCL D16 R83 68
0.01
C64
+8V 4 5 D8 S4 D21 S8 DIMMER DIM0 DIM1 DIM2

VSS SDA S1
KS1
KS2
C5V C5V C5V DAN222 SKQDPA DAN222 SKQDPA DIM-1 0V 0V 5.0V

PWR Q7 R89 390
0.001
VOLOUT R80 R79
IS2
IS1
VOLOUT CLOUT DIM-2 0V 5.0V 5.0V
C62
D15 D17 1k 4.7k 2SC4116 Q6

LVIN LVIN DIM-3 5.0V 0V 5.0V DIM0
R93 1k R86 180 2SA1576
POWON POWON PWRON DIM-4 5.0V 5.0V 5.0V
SCRAM BAND4
CLONE CLONE
R82 R85 Q8 R94 82
GND LOW/DUP BANK/OPT 2SC4116
1k 8.2k
232RX 232RX S5 S10 DIM1
R97 150
232TX 232TX SKQDPA SKQDPA
R551 Q12 R100 330

C10 0.001
C13 0.001
C15 0.001
C1 0.001
C4 0.001
C7 0.001
C9 0.001
C30 47p
C5 47p
10k 2SC4116
DIM2
KR3 KR3
R77 5.6k
COLOR
11 - 1
11-2 MAIN UNIT
MAIN UNIT TXC TX: 7.8V

RX: 0V
TXC
Q14 R150 L40
2SA1362 100 1µ
+8V +8V T8 T8 T8 CHASSIS
TX: 6.9V TX: 6.7V IC10 UNIT
C176
0.001
C174
R181
R182
0.001
0.001
C69
R60
Q1
2.2k
4.7k
R47
R50
RX: 0V RX: 0V S-AV36
C63
C72
10
33
J1
2p
22
22
2SC4116 D27 C225 L37 L39 L47 L48 J3
XB15A407 0.001 47n 47n 56n 56n W5
VGG
VDD
OUT
MA2S111
TX: 0V
0.001
R183
C254
Q8 ANT
0.001
0.001
0.001
0.001
R57
C251
C252
L21
68n
L56
68n
IN
33k
2.2k
4.7k
R48
RX: 7.0V
C14
C91
C2
4.7k
10
DTA113ZU
C218
C227
C196
C217
C208
C210
R131
R178 D12
C190
R5
27p
33p
39p
33p
15p
82k
1
2
3
4
1p
D1
39 XB15A407
1p
+8V
TX: 6.6V
+8V
Q3 R22 Q5 RX: 0V R45 C90 R185
R179
R177
C191
C197
2SC4116 1k 100k 33p 15 C250 R180
C10
2SC4116 L57 L59
150
150
12p
12p
Q15
47
C242 R152 C74 L18 R54 56p 15 ZBFS5101-PT ZBFS5101-PT
2SC4116
1SS355
C253
0.001 47 0.001 39n 22 Q35
0.001
C64
R16 C28
R184
0.1
12p
TXC
C59
2SC2954
0.001
0.001
C118
C246
C122
22k 0.001
D30
R95 L58 L60
1k
SHIFT
47
R153
R154
Q17 R92 270 56 ZBFS5101-PT ZBFS5101-PT
C76
HV
120
120
7p
MA742
MA742
2SC3356
0.001
R23 C36
1.8k
R27
+8V
C17
D14
D17
0.001
0.001
0.001
C125
0.001
C123
C137
C247
C215
22k 0.001 R231
C302
1.8k
R96
10µ
L61
0.1
0
10
0.001
R35
R41
330
470
C44
R1 D2 D4 C20 TX: 4.2V 5.4V 4.9V
Explanatory notes
MA77
RX: 0V
R186
R124
R126
68k HVC375B MA2S304 47p
120k
8.2k
8.2k
MOD Q6 IC11
D6
0.001
C257
2SC4226 NJM3404AV
VOLTAGE LINE
C2012C-
0.22µ
0.22µ
0.001
0.001
0.001
100k
100k
C25
R4
R34
R39
82
1 8
C48
C56
L11
L12
10µ
0.001
R189
5p
C300
C7
R10G
0.82µ
0.001
L2
L14 C67 D7 C240 R169 L20 C88 R193
C198
33k
TX LINE
L42
0.001
56n 0.001 MA77 0.001 18 47n 56p 330k R108 12k
C297
L6
LV 2 7
C34 R32 - +
C29
C49 R188
2.7µ
8.2k
R19
7p
0.5p 10 RX LINE
L8
R168
R170
10p C54 100k C163 0.001
C61
C65
C79
C87
22p
22p
39p
56p
L22
68n
4.7k
4.7k
R49
R51
TI
270
270
TX: 0V 9p 3 6
+ - R187 L62
RX: 3.5V
COMMON LINE
R106
R232 120k 10µ
R28
+8V
4 5
10k
Q11
1k
R25 R30 100k
2SC4226 TX: 0.3V
R220
R190
R191
10k 2.7k
0.001
0.001
0.001
0.001
330k
270k
+8V
R42 RX: 7.8V
C255
C258
C256
C301
4.9V
33k
470 R233 HV HV
0.001
0.001
L1 D5 C21 0
C38
C31
+8V +8V +8V
0.22µ MA2S304 22p
0.001
0.001
0.001
100k
0.1µ
R40
L13
Q9
C57
C58
C70
R230
2SC4226
47k
Q7 Q40
MA2S304
0.001
R221
R192
C288
R194
C259
Q39
560k
270k
C26 R103 R109
0.22
2SC4226 DTC144EU 2
110n
27p
0.01
10p 470k 3.9k DTC144EU 100k 1 -

C9
C50 R107
C5
L7
3
D38 3p + 4.7k
Q12 IC6
C55
22p
0.001
0.001
C37 R33
C169
C293
C32
C153
12p
3.3µ
NJM3404AV
5.6k
R20
2SC4226 Q26
PTH9M04
0.5p 10
L9
0.001
0.001
0.001
0.001
C149
R104
0.1
C294
C283
C282
C296
R5V
+8V
HV
DTA144EU
IDET
TXC
0.1
1k
R228
0.001
0.001
0.01
TX: 0V
R31
1k
MOD
RX: 1.1V
LV
C42
C290
C228
J11 REF_V
TI TI
1 2 SD D31 MA2S111
SD AGC1 AGC1
NOIS NOIS R5V R5V R5V R5V R5V
DETO DETO TX: 0V
R214
R174
TX: 0V
R56
C108 R76 R195 C178 L52 C184 L45 L46

470
0.01
RX: 4.6V
C89
100
CTCSS CTCSS
10k
0.001 100 R234 RX: 3.9V 100k 4p 0.18µ 5p 44n 56n

+5V +5V
0
HVU131TRF
IDET IDET
XB15A308
R226
C111
R110
C162
C245
R113
C182
C221
C201
C206
150p
1SS355
0.001
R78
C77 C80 C244 R62 FI3 FI4
C160
L38
68n
L43
67n
2.2µ
2.5p
1.5p
20p
L25
22p
+5V
1k
9p
1k
1k
0.01 22p 0.1 1k FL-363 FL-363 C124 C136 C133 C145 C152 C158
0
D15
+5V
5p 0.75p 1p 1p 1p 0.001
D19
HVC350B
D16
GND
R119
R123
C243 R72
R5V
Q19
220k
C97
2.2µ
0.5p
6.8k
C93
L19
GND
5p
DA221
0.001 1.5k 3SK299
C127
C131
C139
C141
C148
150p
D13
Q27 R127
L31
82n
L32
82n
2.2µ
L26
82p
82p
SCK SCK Q16
D29
1p
2p
3SK299 120k
AGC1
OPV1 OPV1 2SC4406

R5V
0.001
100k
R79
R81
HVC350B
HVC350B
HVC350B
R128
C113
220
10k
R58
MODIN MODIN D18
0.001
0.001
0.001
R101
C222
R111
R114
R117
C164
C286
C170
R90 100k
220k
0.001
0.001
220k
C128
C180
0.01
R93
100
47k
10k
TEMP TEMP 220k MA2S111 6
7 -
D11
D10
T1
D9
REF_V REF_V 5 SQLATT
+
SCK
+8V
+5V
LV
UNLK UNLK IC6
0.001
0.001
R129
C209
C187
C193
R130
0.001
100k
C211
BSHIFT BSHIFT NJM3404AV
0.1
27k
0.001
0.001
C138
C146
to the LOGIC DEGI_W DEGI_W
unit J3 PLLSTB PLLSTB
T2
T3
T3
OE OE T2
+8V
HV
SO SO
T3
SQLATT
T2
T1
TX: 0V
PLLCK PLLCK R5V R5V R5V R5V RX: 5.0V
CP1 R88
GND PLLDATA AGC1 AGC1
R11 R63 220 470
GND 10k +5V
R9
+8V 10k LVIN Q25
CDB450C24
0.001
0.001
C82
C53 R43 C75
C86
C95
EXSTB EXSTB DTB113ZK IC5
10
L3 1µ 0.001 8.2k EP1 EP2 0.001
100k
3.3k
R73
R66
+8V M62363FP-650C
+8V +8V 1 24
VIN1 VIN8
X2
RX FM-Wide: 4.6V
0.001
0.001
R36
R46
C66
C71
C73
C161
L10
680
22p
47p
22p
VOLOUT VOLOUT 2 23
C15
1µ
1k
LV
R6 R21 RX FM-Narrow: 0V VOUT1 VOUT8

C5V C5V 3 22
C100
470 100 VOUT2 VOUT7
82p
PWRON PWRON 4 21
VIN2 VIN7
AGC1
RXC
LVIN LVIN 5 20
R5V
Q10 VDD GND

R12
C11
R18
100
390
2SK1069 R225 0 R224 0

1.5
GND OPV1 6 19
C1
IC4
10
0.001
(only W (only W TA31136FN LD RESET

C51
CLONE CLONE SCK 7 18

EXSTB
SCK
version) version) CLK VDAREF

C5V
+8V
+5V
1.5k
R52
232TX EP5 1 16 8 17
R29 R229 OSCIN MIXIN R173 10k DI DO
C12
C24
232RX EP6 R7 C224 2 15 SO 9 16 MODIN

33
10
47k 10k 0 0.1 OSCOUT GND VIN3 VIN6
R137
35 36 FI1 3 14 FC 10 15 MOD
0.001
R138
MIXOUT N-REC VOUT3 VOUT6
12k
R37
D24 D23
47k
0.001
0.001
0.001
C52
CFWS450F 4 13 SQLIN 11 14 DTC

12k
R15 MA2S111 MA2S111 C216 0.1 VCC N-DET VOUT4 VOUT5
5 12 12 13 CTCCS
270k I O IFIN RSSI VIN4 VIN5
TEMP 6 11
DEC IFOUT C134 0.001
C40
C41
C292
7 10 +5V
FILOUT QUAD
100k
R14
0.1
1M
8 9
C4
R8
0.033
R140
C120
C140
C117
FILIN AFOUT
0.01
0.01
0.01
C98
15k
C232
J7
0.001
C78
C83
R71
0.01
C81
0.1
232TX EP4
6
IC9
C94
0.1
470
1
FI2 TA7252AP J6
DATA 232RX EP3 D25 CFWS450HT D26
0.001
0.001
XP4601
BOOT
R155
C105
C101
MA2S111 MA2S111 C84
3.3k
GND
OUT
VCC
DC
1.4V I O 220p
NF
+5V
+8V
HV
IN
Q2
R136
R135
R139
R26 L15 Q34 C188
12k
12k
15k
1
1
2
3
4
5
6
7
10k 82n 1
R55
C85 R64 R157
47k
2SC4116
220p 100k 47k
C241
R171
C230
R172
R125
C195
R13 2.7k
0.001
0.047
220k
100k
R44
C62
C68
C192
C204
C285
100
12p
R17
Q13
9p
0.1
10
22
47
1k
C233
R156
470 J4
DEGI_W
0.001
C281 R2 R10 C13 R122
C266
DTA144EU
2.2k
C279 1
R59
47k
0.1
SQLIN
1 1k 47k 15p 47k
DTC Q4 VOLOUT
C278
C280
C194
0.001
NOIS
0.22
2SC4116
100
only W/N version
C60
47
0.001
SD
C185
SP
C16
C22
R3 C284
12p
27p
CLONE
HVC376B
470k 0.022
W/N
FC
X1 R176
AFMUTE
CR-779 1k
0.001
D3
C23
C30
AGC1
33p
2.2k
R24
R5V
4p
C8
R175 R112 Q29 Q41 R237

EXSTB
2SC4213 2SC4617
SCK
47k 33k 47k

C5V
0.001
C47
+8V
+5V
0.1
+5V FILC
C45
AGC1 AGC1 R209
R118
C181
R238
C299
EP7 100
0.001
C287
10k
47k
1
1
SHIFT R5V R5V
C271
C272
R202
R201
TXC
0.001
C39
0.47
R203 C269
C291
0.1
470
13.0V
0.1
AGC1
1k 7.9V
R204
180k 0.01
100k
RX FM[W/N]: 0V IC7 PWRON

RX AM: 1.75V Q28 W6
BSHIFT TA7808F
R5V
2SC4684
IC2 IC1 +8V 2 1 HV HV HV
O I
0.001
C265
DSA3A1
CD4094BPWR LV2105V Q36 G POWER
0.001
C157
C166
C295
C207
C154
470p
2200
0.001
0.001
0.001
0.001
C168
C172
C200
C205
DTA113ZU
330
100
1 16 C5V 1 16 3
8
7
6
5
Q31
D21
R205
C273
STR V+ XIN XOUT

330k
R121
SN74AHC2G53HDCT
SO 2 15 2 15 DTC143ZU
VCC
Y0
Y1
A
4
4.7
D OE CL OUT 100
3 14 3 14
CLK Q5 DI PE
AFMUTE 4 13 4 13 RX FM[W/N]: 5.1V
0.001
XP6501
XP6501
C179
C175
R120
Q1 Q6 CE VCCD RX AM: 0.2V
330
RXC 5 12 5 12 8 Q30
10k
Q2 Q7 EP8 VCCR GNDD
Q38
Q37
TXC 6 11 6 11 V+ IC6 DTA143TUA 13.8V

Q3 Q8 PI PDN
+5V
+8V
COM
GND
GND
W/N 7 10 7 10 GND NJM3404AV

1
+5V
+8V
IC8
INH
IC12
Q4 Q'S GNDR PDP

0.001
C289
8 9 8 9 4 AN78L05M CP3
GND QS TEST CP R213 5.1V 2 1 HV
1
2
3
4
10 O I
G CP4
RD20E
Q21 Q22
0.001
0.001
C177
C173
C189
0.001
R236
C212
DTB113ZK DTC144EU 3
D20
10
R223
C268
R212
R207
0 R208
C5V
C5V
0.001
180k
+8V
+5V
C267
0.01
47k
22k
PLLDATA
680k
PLLSTB
PLLCK
DETO
UNLK
FILC
SCK
OE
+5V +5V +5V +5V

+8V +8V +8V +8V
C5V C5V C5V C5V
11 - 2
11-3 HM-133V
• MAIN UNIT • MAIN-A UNIT
C:5.0V
MAIN UNIT Q1 MAIN-A UNIT Q1

C:5.0V
2SC2712
5V 5V 5V 2SC2712
5V 5V 5V
C23 0.001
C25 0.001
0.001
C23
C25
R5 470
C2 100
0.001 C2 R5 470
C24 0.001
100
1.5k
1.5k
R35
1.5k
1.5k
1.5k
1.5k
1.5k
1.5k
R35
MA8056
MA8056
R2
R4
R3
R4
R3
R2
0.001
R:7.7V C:3.8V C:3.8V C:3.8V
C29
C29
R:7.5V C:3.8V C:3.8V C:3.8V
C24
10
10
T:7.6V T:7.5V
D1
D1
DS5 DS3 DS1 DS7 DS5 DS3 DS1
DS7 LN1371G
LN1371G LN1371G LN1371G LN1371G LN1371G LN1371G LN1371G
C:7.6V
C:7.7V M8V Q9 C:3.8V M8V C:3.8V
DTB113ZK Q9
DS6 DS4 DS2 DTB113ZK DS8 DS6 DS4 DS2
DS8 LN1371G LN1371G LN1371G
Q8 LN1371G LN1371G LN1371G LN1371G J1 Q8 LN1371G
J1 2SC2712 L1 0.82µ
L1 0.82µ M8V M8V 2SC2712
M8V M8V
MU/D MU/D
M8VSW M8VSW
C12 0.001 5V
to the IC-2200H PTT
to the IC-2200H PTT 5V EP2
EP2 LOGIC unit J1 MICE MICE
LOGIC unit J1 MICE MICE R38 220k
R36
MIC EP3 MIC
10k
MIC EP3 MIC R36 Q2
DTC114EU E R8 12k
E 10k R7 33k R6 33k
R38 220k R37 1.5k R7 33k R6 33k MDATA EP4 MDATA
MDATA EP4 MDATA
D18 MA8091
C16 0.001
C18 0.001
C17 0.001
C21 0.001
C19 0.001
C22 0.001
R37 Q3
L2 0.82µ
D18 MA8091
C11 22p
C10 22p
R41 10k
Q2
C9 22p
C5 22p
R8 12k Q3 1.5k DTA114EU
C22 0.001
C21 0.001
C19 0.001
C18 0.001
C17 0.001
C16 0.001
L2 0.82µ
EP1
C11 22p
C10 22p
DTC114EU
R41 10k
C9 22p
C5 22p
DTA114EU
EP1
MICE
MICE
5V 5V
R15 470
C26 0.001
R14 680
R11 680
R10 680
C30 0.1
0.001
C27
C30 0.1
MA8091
470p
MC1 R40 2.2k R39 2.2k
C1
Q7 Q6 Q5 Q4
MA8091
D16
MC1 C1 R39 2.2k 2SA1586 2SA1586 2SA1586 2SA1586
MA8091
470p C31
D16
5V 5V
D17
R40 MICE 10 MICE
MA8091
S1 C31
R13
2.2k
10k
10k
R16
10
R12
R9
10k
0.001
0.001
10k
SKHHLP014A
R15
R10
R11
R14
MICE MICE
470
680
680
680
PTT
D17
C27
C26
F:1.9V
R:6.8V F:1.9V D:1.9V
Q7 Q6 Q5 Q4 T:6.8V
R:7.1V 2SA1586 2SA1586 2SA1586 2SA1586
G
R
R
F-1 T:7.0V T:1.9V P:1.9V
S2 R13 Explanatory notes
5V
R16 10k R9 DS10 DS11
R12 LT1EP53A LT1EP53A
10k F:1.9V 10k 10k LED-S2
VOLTAGE LINE
F-2 F:1.9V D:1.9V SEND
S3 LED-M2
TX LINE LED-M1
G
G
R
R
T:1.9V P:1.9V
Explanatory notes
1SS355
1SS355
MKEY-08
VFO
NOTE MKEY-07
D15
D14
DS11
MODE-R(LED-M1)
S4 DS10
MODE-G(LEDM2)
F: FUNC acting VOLTAGE LINE LT1EP53A LT1EP53A MKEY-06
D: DTMF acting MKEY-05
5V
P: PTT-M acting TX LINE MKEY-04
MR MKEY-03
S5 C: COMMON
R: RX MKEY-02
MKEY-01
T: TX
MKEY-00
BAND
S6
D3 1SS355
UP 5V 5V
S7 D4 1SS355
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
R51 1k
R50 1k
R49 1k
R48 1k
R47 1k
R46 1k
R45 1k
R44 1k
R43 1k
D5 1SS355
DN IC2
P11
P12
P13
P14
P15
P00
P01
P02
P03
P04
P05
P06
P07
P20/SCK20/ASCK20
P21/SO20/TXD20
S8 D6 1SS355 MC14028BF
1 16 5V
D7 1SS355 2 Q4 VDD 15
0.001
3 Q2 Q3 14
C12
D8 1SS355 4 Q0 Q1 13
5 Q7 B 12
D9 1SS355 Q9 C
1SS400
1SS400
1SS400
1SS400
1SS400
1SS400
1SS400
1SS400
1SS400
6 11
7 Q5 D 10
D10
D11
D12
D10 1SS355 Q6 A IC1
D9
D6
D5
D3
D4
D7
8 9 µPD789071MC-041-5A4
VSS Q8
D11 1SS355
P26/INTP2/CPT90
P22/SI120/RXD20
P27/TI80/TO80
D12 1SS355
5V
A B C D
P31/BZO90
5V 5V
P25/INTP1
P24/INTP0
P30/TO90
P23/SS20
RESET
R18 470k
VDD
VPP
VSS
P10
MKEY-I0
X2
X1
A B C D R19 470k S12
S9 S10 S11 R22 4.7k
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
R20 470k
UP BAND 3 6 9 # DN
R21 470k
S9 S10 S11 S12
MKEY-I1 MASK
S7 S6 S13 S14 S15 S16 S8 0
R23 4.7k FLASH R18 10k
3 6 9 # 5V 5V
IC1 µPD7564AG-555 10k
R22 100k R19 47k
1 20 C13
P00/INTO0 VSS
R42 0
R23 100k 2 19 F-2 MR 2 5 8 0 DTMF 0.001
R24 100k 3 P01/SCK P113 18 5V
S13 S14 S15 S16 PTT
4 P02/SO P112 17
R25 100k
SKHHLP014A
C15 0.001
P03/SI P111
8
7
6
5
5 16 MKEY-I2
6 P80 P110 15 S3 S5 S17 S18 S19 S20 S25
VCC
WP
SCL
SDA
R24 4.7k
5V
2 5 8 0 DTMF R30 7 P81 P103 14
BR24L02FV-W
5.6k 8 P82 P102 13
S1
9 CL2 P101 12
CL1 P100 F-1 VFO 1 4 7 FUNC
10 11
VDD RESET
VSS
S17 S18 S19 S20 S25
IC6
X1
A0
A1
A2
CSB600J200T
MKEY-I3 EFOS4914E3
S2 S4 S21 S22 S23 S24 S26
1
2
3
4
R25 4.7k
1 4 7 FUNC IC3 C:5.0V
S-80845CLUA-B66-T2 IC3 BD5245G
X1
C14 R27 10k

NOTE 1 5
5V 0.047 OUT CD
F: FUNC acting 5V 2
I O VDD 4
C14 0.01
S21 S22 S23 S24 S26 D: DTMF acting 3
R26 47k
R27 1M
R34 47k
R33 47k
R32 47k
R31 47k
R29
0.001
D19 G VSS NC
0.001
100p
1SS355
100p
C15
100 P: PTT-M acting

C13
1SS355
C3
C4
C: COMMON C:5.0V
D13
R: RX
T: TX
11 - 3
SECTION 12 HM-118/N (OPTIONAL UNIT)
12-1 INSIDE VIEW (HM-118/N) 12-2 BOARD LAYOUTS
• TOP VIEW (MAIN UNIT)
UP swtich DOWN switch

(S3: SKHHLM) (S4: SKHHLM)
PTT switch
UP DOWN LOCK switch (S1: JPM1990-2013R)
(S2: SSSS81560A)
Microphone
(MC1: KUC2123-030245)
• TOP VIEW (MAIN-A UNIT)
12 - 1
12-3 MECHANICAL PARTS LIST AND DISSASEMBLY
• BOTTOM VIEW (MAIN UNIT)
UP DN [CHASSIS PARTS] [MAIN/MAIN-A UNIT]

REF. ORDER REF. ORDER
DESCRIPTION QTY. DESCRIPTION QTY.
NO. NO. NO. NO.
MP1 8210015430 2129 front panel [HM-118] 1 MC1 7700002120 Microphone KUC2123-030245 1
8210015431 2129 front panel-1 [HM-118N] 1
MP2 8210015330 1743 REAR PANEL [HM-118] 1 W1 8900008000 Cable OPC-784 [HM-118] 1
8210015331 1743 REAR PANEL-1 [HM-118N] 1 8900008001 Cable OPC-784A [HM-118N]
MP4 8930046350 1743 hook plate 1
MP5 8930046530 1743 PTT button [HM-118] 1 S1 2230001020 Switch JPM1990-2013R 1
8930052400 2129 PTT button [HM-118N] 1 S2 2220000620 Switch SSSS81560A 1
MP12 8930046930 1135 U/D button (B) [HM-118] 1 S3 2260002500 Switch SKHHLM 1
8930025191 1135 U/D button-1 [HM-118N] 1 S4 2260002500 Switch SKHHLM 1
MP13 8610010640 Knob K-226 1
MP15 8810009760 Screw PH BT M3 × 12 ZK 2
MP16 8810009260 Screw PH BT 2 × 6 NI 3 Screw abbreviations BT: Self-tapping PH: Pan head
MP18 8810008890 Screw FH M3 × 6 NI 1 FH: Flat head ZK: Black
MP19 8830001060 Nut M3 NI 1 NI: Nickel
MP25 8810009810 Screw PH BT M3 × 14 ZK 1
PTT MP27 8930052390 1743 SW rubber [HM-118N] 1
UP DOWN
LOCK
MP4 (C)
MP2 (C) MP25 (C)
MP18 (C)
MP5 (C)
MP15 (C)
• BOTTOM VIEW (MAIN-A UNIT) MP19 (C)
MP12 (C)
UP DN
MC1 (M) S4 (M)
MAIN/MAIN-A UNIT
S3 (M)
S1 (M)
MP16 (C)
S2 (M)
MP13 (C)
HM-118/N
W1 (M)
PTT Unit abbreviations
UP DOWN (C):CHASSIS PARTS
LOCK
(M): MAIN/MAIN-A UNIT
MP1 (C)
12 - 2
13-1 BOARD LAYOUT
• TOP VIEW • BOTTOM VIEW
4 1
1 10
5 6 5 8
J1
1 PTTIN_C AGND 30
PTTOUT 5V
DMOD VCC_8V
AMODIN TXD
F_RXD 232_TX
BUSY_C 232_RX
RES RMUTE
NC FMDET
NC DAFOUT
NC REFMOD
NC NC
GND FLASH
GND RXD_2_C
P01 TXD_2_C
15 NC NC 16
to the IC-2200H
LOGIC unit J4
13 - 1
14-1 BOARD LAYOUT
• TOP VIEW • BOTTOM VIEW
16 1
25 1
1 20 1 8
26 100 17 64
4 5 J301
1 PTTIN_C AGND 30
PTTOUT 5V
DMOD VCC_8V
13 12 AMODIN TXD
10 11 F_RXD 232_TX
BUSY_C 232_RX
RES RMUTE
32 49 NC FMDET
NC DAFOUT
NC REFMOD
33 48 NC NC
GND FLASH
50 76 24 1 GND RXD_2_C
51 75 P01 TXD_2_C
1 16 15 NC NC 16
5 4 to the IC-2200H
LOGIC unit J4
8 1
8 9
14 - 1
14-2 SEMICONDUCTOR INFORMATION 14-3 BLOCK DIAGRAM
• TRANSISTORS AND FET’S
2SA1586 GR DTC144EUA T106 XP4312
(Symbol: SG) (Symbol: 26_) (Symbol: 7T)
FOR FM_TRANCEVER
OPTION CONNECTOR
B E1 C1
B
C C B1 B2 FLASH WRITER F_RXD
RES
E E C2 E2 Explanatory notes
Q305 XP4312 TXD
VOLTAGE LINE
Q306 XP4312
TX LINE
LEVEL FOR FM_TRANCEVER CPU TXD_2
RX LINE
CONVERT RXD_2
LINE
DATA BUS LINE
• DIODES
MA2S111 MA2S728 IC351
(Symbol: A) (Symbol: B) MAX3226
RS-232C_DATA 232_RX
RS-232C 232_TX
A C A C
IC253A
NJM13404
BUFF REFMOD
IC253B
NJM13404
BUFF DMOD
IC252
X201 CMX589AD5
CR-760
CPU 2.4576MHz MODEM
9.8304MHz
IC204
IC251A
HD64F3687
NJM2115
BUFF FMDET
RESET IC203
IC101 S-80928CNMC
TC7SHU04
IC151
16.384MHz DSP
INV AMBE-2020
CODEC
X101
CR-708 DAFOUT
IC251B
LINEAR NJM2115
CODEC BUFF AMODIN
IC50
AD73311
Q50 2SA1586
Q51 DTC144
+5V
5V
CTRL
PSAVE
3.3V
Q400 2SA1586 IC1

Q401 DTC144 S-812C33AMC
+3V 3.3V 3.3V

3.3V 5V
CTRL REG
PSAVE IC2
R1111N321B
3.2V 3.2V VCC: 4.5-8.5V

REG
J301
APWR
14 - 2
14-4 VOLGTAGE DIAGRAM
3.3V
L201
1µ
3.3V 3.3V 3.3V
3.3V
C401
0.001
C2
10
10
C5
APWR APWR 3.3V
X201 IC203
IC1 IC2 CR-760 S-80928CNMC
3.3V
S-812C33AMC-C2N-T2 4.0-8.5V R1111N321B 3.2V
(9.8304 MHz) RES 1 5
OUT CD
TZY2R200A001
3 4 1 5 PSAVE ON: L(0.0V) 2
C206
VOUT NC VDD VOUT VDD
0.01
2 2 PSAVE OFF: H(3.3V) 3 4
C151
C152
C157
C159
C202
C204
VIN GND VSS NC
C10
R209
R2
C9
22
10
4.7
0.1
0.1
18p
1 5 3 4
APWR
C7
C8
0.1
0.1
0.1
0.1
7p
GND NC CE NC 1k
C1
10
C207
R400
100k
C11
PSAVE ON: L(0.0V)
47k
4.7
AEPR
R1
Q401
5V
PSAVE OFF: H(3.3V) R401 Q400

DTC144EU 2SA1586
5.6k
APWR
VCC_8V
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
C203
R212
R217
R216
47k
47k
47k
0.1
GND
ENCODER_EN
VDD
NC
NC
EPR
NC
NC
NC
NC
NC
NC
NC
VDD
VDD
GND
GND
VDD
NC
NC
NC
NC
NC
NC
GND
R211
3.2V PSAVE OFF: L(0.0V)
47k
PSAVE ON: H(3.3V)
C205
0.1
R220 0
PSAVE PSAVE
AEPR
26 100 APWR
GND NC R221 0
VCC_8V SCLK 27 99
CODEC_RX_CLK NC
16
15
14
13
12
11
10
28 98
9
8
7
6
5
4
3
2
1
Q50 L50 CHAN_RX_CLK NC
5.0V SEN 29 97
P35
P34
P51/WKP1
P50/WKP0
VCC
OSC1
OSC2
VSS
TEST
RES
VCL
X1
X2
AVCC
PB7/AN7
PB6/AN6
R202
R203
R204
R205
2SA1586 1µ CODEC_RX_STRB NC
4.7k
4.7k
4.7k
RES
30 96
1k
CHAN_RX_STRB NC
Q51 SO 31 95 P86
CODEC_RX_DATA NC
100k
C54
C55
R60
R59
0.1
DTC144EU ATXD 32 94 P87

10
10k CHAN_RX_DATA NC
33 93 TXD
CODEC_TX_CLK NC
ACLK 34 92 17 64
CHAN_TX_CLK NC P36 PB5/AN5
35 91 18 63 P01
PSAVE OFF: L(0.0V) GND NC R201 P37 PB4/AN4
PSAVE ON: H(5.0V) 36 90 19 62 PTTIN
VDD VDD 1k P52/WKP2 PB0/AN0
37 89 P85 20 61
CODEC_TX_STRB GND P53/WKP3 PB1/AN1
IC50 ASTB 38 IC151 88 21 60 BUSY
3.3V
R206
C50 R51 AD73311ARS R57 CHAN_TX_STRB AMBE-2020 GND P54/WKP4 PB2/AN2
39 87 22 59
1k
0.1 1k 47k VDD VDD P55/WKP5/ADTRG PB3/AN3
DAFOUT 1 20 40 86 NMI 23 58 PSAVE
VOUTP SE GND VAD_EN P10/TMOW P30
2 19 SI 41 85 Q201 24 57
VOUTN SDI CODEC_TX_DATA CODEC_SEL1 P11/PWM IC204 P31
0.022
R50
680
3 18 ARXD 42 84 DTC144EU 25 56
C51
AVDD1 SDIFS CHAN_TX_DATA CODEC_SLE0 P12 HD64F3687 P32

AGND 4 17 43 83 FLASH 26 55
AGND1 SDOFS NC SLEEP_EN P56/SDA P33
5 16 44 82 27 54 TXDT
R58 R52 VINP SDO VDD SLIP_EN P57/SCL P17/IRQ3/TRGV
6 15 45 81 ACQ 28 53 RXDT
0 100 VINN MCLK VDD BAUD_SEL1 P74/TMRIV P16/IRQ2
ADIN 7 14 46 80 F_RXD 29 52 RXCK
REFOUT SCLK VDD BAUD_SEL0 P75/TMCIV P15/IRQ1/TMIB1
8 13 ARES 47 79 30 51 TXCK
REFCAP RESET VDD SOFT_EN P76/TMOV P14/IRQ0
0.047
9 12 48 78 31 50 TXD_2
C56
AVDD2 DVDD VDD NC 3.3V P24 P72/TXD_2

C57
0.1
CP50 10 11 49 77 32 49 RXD_2
AGND2 DGND VDD CHANN_SEL1 P63/FTIOD0 P71/RXD_2
ADREF 50 76
R218
GND VDD
47k
P70/SCK3_2
CLOCK_MODE
0.001
P62/FTIOC0
P66/FTIOC1
P67/FTIOD1
P61/FTIOB0
P60/FTIOA0
P64/FTIOA1
P65/FTIOB1
C201
C333
CHANN_SEL0
P20/SCK3
IC202
0.1
RATE_SEL0
RATE_SEL1
RATE_SEL2
RATE_SEL3
RATE_SEL4
P21/RXD
P22/TXD
TC7SH08FU
X2/CLKIN
PTTOUT_C
VCC_8V
RMUTE_C
C150
RESETN
C58
0.1
5 1
NMI
P85
P86
P87
P23
DCEL
5V
GND
GND
GND
GND
GND
VDD
VDD
VDD
NC
NC
NC
NC
NC
NC
NC
X1
2
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
L151 3.2V
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
1µ
RXD 4 3
PSAVE
X101
R219
CP216
CR-708
47k
C153
C154
C155
C156
D151
TZY2Z100A001
0.1
0.1
0.1
0.1
MA2S728
Q202
C103
DTC144EU
7p
R151
R152
RMUTE
47k
C102
1k
R101 R102 3.2V
1M 100
ARXD
ARES
AEPR
ARES
ATXD
ACLK
ASTB
C104
C106
IC101 IC103
0.1
0.1
TC7SHU04FU TC7S04FU
MCLK
ACQ
1 5 1 5
PSAVE
2 2 CP101
ACQ
MCLK
TXCK
RXCK
RXDT
TXDT
TXD_2
RXD_2
R103
1k
RXD
3 4 3 4
TXD
NMI
P85
P86
P87
CP254
R100
3.3V
CP256
0
CP255
Q251
DTC144EU D152 J301
MA2S111
ACQ P01
DCEL DCEL PTTOUT_C
MCLK
3.25V
TXD_2_C
C260 TX: 350mVp-p P01
VCC_8V
R56 4.7V 1
RXD_2_C
5V
100
GND
RXD_2_C
Q305 Q306 FLASH R316 100 FLASH
C250
XP4312 XP4312
TXCK
RXCK
RXDT
TXDT
CP252 GND
4
1
0.1
MCLK
ADIN 1 6 TXD_2_C 1 6 CCS

-
100k
C53 R54
R55
+ 2 5 TXD_2 2 5 REFMOD REFMOD

0.1 47k 3.25V
NJM13404V
AMODIN
+ 3 4 RXD_2 3 4 DAFOUT DAFOUT
R53 -
IC253
R253
R254
R255
R261
C256
47k
ADREF FMDET FMDET to the IC-2200H
47k
47k
47k
47k
IC252
0.1
R267 BUSY: H(3.3V)
DCEL
CMX589AD5 LOGIC unit JJ4
5
100k
1 24 RMUTE RMUTE
5
XTAL VDD CP251

2 23 TX: 350mVp-p Q302 RES R315 100 RES
C261
XTAL/CLK_RX S/N
- 3 22 TXCK DTC144EU 232_RX 232_RX
0.1
CLKDIVA TXC R269 C262

+ 4 21 RXCK BUSY BUSY_C
CLKDIVB RXC 33k 1
PTTIN
5 20 RXDT 232_TX 232_TX
NJM2115V
RX_HOLD RXD L351

+ 6 19 TXDT 3.3V F_RXD R317 100 F_RXD
RXDCACQ TXD 1µ
- 7 18 3.3V 3.3V TXD R318 100 TXD
IC251
PLLACQ TXP R264 RX: L(0.0V)

8 17 R262 100k AMODIN AMODIN
PTTOUT_C
TX: H(3.3V)
C355
RX_PSAVE TXE 22k 3.25V
C253 22p 9 16 VCC_8V
4
0.1
R260 VBIAS TXO
R256 100k 10 15 Q303 DMOD DMOD
100k RXFB BT
11 14 IC351 DTC144EU 5V
C263
R270
RX_SIG_IN DOC1 MAX3226EAE

12 13 PTTOUT
47k
0.1
VSS DOC2
IC254 1 16 AGND AGND
0.0022
R252
C255
R257
R258 READY FORCEOFF

0.027
0.027
100k
C257
C258
TC4S66F
C259
C351 0.22 2 15 PTTIN_C

47k
100k C1+ VCC

1
1 5 C352 0.22 3 14 Q301

V+ GND
4 13 DTC144EU
VCC_8V
R251
Q252 C1- T1OUT

2 C353 0.22 5 12 PTTIN
47k
5V
DTC144EU C2+ FORCEON

6 11
R268
3 4 DCEL
Explanatory notes C354 0.22 7
C2- T1IN
10
390k
C252
V- INVALID
8 9
VOLTAGE LINE R1IN R1OUT RX: L(0.0V)
1
TX: H(3.3V)
VCC_8V
TX LINE
R308
R309
5V
100
100
RX LINE
REFMOD
232_RX
232_TX
FMDET
DMOD
VCC_8V VCC_8V VCC_8V VCC_8V VCC_8V

5V 5V 5V 5V 5V
4.5-8.5V 5.0V
14 - 3
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan S-14017HZ-C1
C 2004 Icom Inc.

Icom IC-2200H Service Manual

Uploaded by

Copyright:

Available Formats

Icom IC-2200H Service Manual

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Icom IC-2200H Service Manual

Uploaded by

Copyright:

Available Formats

SERVICE

ORDERING PARTS REPAIR NOTES

*1Specifications guaranteed 144.000 – 146.000 MHz only

• Modulation system : Variable reactance frequency

All stated specifications are subject to change without notice or obligation.

All stated specifications are subject to change without notice or obligation.

*Located under side of the point

• MAIN UNIT (BOTTOM VIEW)

IF amplifier TX/RX switch

*Located under side of the point

➅ Return the front panel and the allen-socket bolts to their

The RF signals from the bandpass filter are applied to the

• 2ND IF AND DEMODULATOR CIRCUIT

"DETO" AF signal from the AM/FM

The AF signals from the microphone pass through the

• ALC CIRCUIT "THROUGH" from the CPU

A portion of the signal from Q4 is amplified at the buffer

9 Charge Phase Programmable 6

4-4 POWER SUPPLY CIRCUITS Outputs RF tracking voltage while

Outputs clock signal to the PLL IC 84 OPT3

Input port for the HM-133V remote VL3–

4-6-4 RS-232C CIRCUIT Input port for receiving data signal

• UT-115 BLOCK DIAGRAM

-"232C_RX" signal DSP "FMDET" signal

"DAFOUT" signal to Linear

■ REQUIRED TEST EQUIPMENT

Frequency range : 0.1–400 MHz

■ ENTERING THE ADJUSTMENT MODE

■ OPERATING ON THE ADJUSTMENT MODE

to the antenna connector

STANDARD SIGNAL GENERATOR

*F1 *dt *C6 *CS *Et *dF Sr+[.] Sr Sq tr tr tr tr dt+[DIGITAL] *bP

*dE+[DIGITAL] *dE+[DIGITAL] *dd+[DIGITAL] *dd+[DIGITAL] *dd+[DIGITAL] *dd+[DIGITAL]

*db+[DIGITAL] *db+[DIGITAL] *db+[DIGITAL] *db+[DIGITAL] *db+[DIGITAL] *dd+[DIGITAL]

*dU *FN *FN *FN *FN *57+[.] *56+[.]

*Not adjust items

ADJUSTMENT ADJUSTMENT CONDITION OPERATION

ADJUSTMENT ADJUSTMENT CONDITION OPERATION

■ ENTERING THE ADJUSTMENT MODE

• UT-115 BOTTOM VIEW

• UT-115 TOP VIEW

• UT-115 BOTTOM VIEW CP216

6-1 IC-2200H [LOGIC UNIT]

C1 4030017460 S.CERAMIC ECJ0EB1E102K B DS1 5030002660 LCD IS08264E00V2 T

FI1 2020001520 CERAMIC CFWLA450KFFA-B0 (CFWS450F) T

IC1 1130008350 S.IC LV2105V-TLM B X1 6050011870 S.XTAL CR-779 (21.250 MHz) T

EP1 6910012350 S.BEAD MMZ1608Y 102BT B L1 6200001520 S.COIL MLF2012D R82K-T B

C1 4030006850 S.CERAMIC C1608 JB 1H 471K-T B

C1 4030006850 S.CERAMIC C1608 JB 1H 471K-T B

D1 1790000950 S.ZENER MA8056-M (TX) B

MC1 7700002310 MICROPHONE EM-140 T X1 6050005090 XTAL CR-245 (4.194304 MHz) T

S1 2260000980 SWITCH SKHHLP014A B L1 6200001260 S.COIL MLF2012A 1R8M-T B

C1 4550006300 S.TANTALUM ECST1AY475R B

J1 6510018440 S.CONNECTOR AXN430C330P B

EP1 0910050481 PCB B 5191A

SP1 2510001030 Speaker VS-57-0837A 1 W1 8900010990 DC power cable OPC-1132 1

MP1 8010019380 2698 chassis 1 MC1 0880001490 Microphone HM-133V 1

MP1 8210020350 2698 front panel 1 MP1 F1 MP8 MP9

ZK: Black BS: Brass

F1 dt C6 CS Et dF Sr+[.] Sr Sq tr tr tr tr dt+[DIGITAL] *bP

dE+[DIGITAL] dE+[DIGITAL] dd+[DIGITAL] dd+[DIGITAL] dd+[DIGITAL] dd+[DIGITAL]

db+[DIGITAL] db+[DIGITAL] db+[DIGITAL] db+[DIGITAL] db+[DIGITAL] dd+[DIGITAL]

dU FN FN FN FN 57+[.] *56+[.]