GENERAL. INFORMATION ‘SERIAL NUMBER & ARRANGEMENT NUMBER LOCATION The Chassis Serial Number and Arrangement Number locations are listed below with a reference ill_stretion for clarification. CHASSiS SERIAL NUMBER stumped on Identification Plate, also om Katn Frame. Hae MAST ARRANGEMENT NUMBER stamped on right side of Guter hast above THTt Cylinder mounting bracket. The revision number will be stamped GARRIAGE ARRANGEMENT NUMBER siamped in center of carriage top. cross bar. The revision number will be stamped below Arrangement Number. Since various engines and transmissions are available, the location of serial numbers for these components have not been shown. G f CARRIAGE ARRANGEMENT NUMBER MAST ARRANSEMENT NUMBER: stemped on right side of outer mast CHASSIS. SERIAL NUMBER. UF R IDENTIFICATION PLATE aH CHASSIS SERIAL NUMBER i FORK PART NUMBER: also stamped on main stamped on upright frame portion of forkGENERAL INFORMATION REFERENCE NUMBERS (First Colunn) - The reference numbers listed in Sequence refer to the same number shown on parts illustrations. PART NUMBER (Second Column) - These are Caterpillar part numbers which are to be used when ordering parts. If (NSS) appears ir place of a part number, this indicates the part is NOT SERVICED SEPARATELY. DES:RIPTION (Third Column) - Parts are listed by noun only, unless additional information is required. QUANTITY (Fourth Column) - This column indicates quantity of parts required as follows: A. Parts that ave not indented in the description cotumn gives the quantity required to assembly the Lift Truck. B. Parts that ere indented in the description column gives the quantity required to assemble one assembly under which It is indented. SERIAL NUMBER LISTINGS - When a Parts Book Page has been revised because of some major change, the Lift Truck Serial Numbers that are affected will appear below the illustration.‘A RECOMMENDATION ON HOW TO ORDER PARTS To get fast service when you order parts, be sure you show the follow- ing Informanion: 1. Part Name 2. Part Number 3. Quantity 4, Model and Serial Number of fork lift truck 5, + All information for correct stipment. NOTE: When you are not sure what part to order, send a drawing or the used part to show what Is needed. Add your name to the used part to show who sent it. Many service parts in this book are in supply as an assembly. To get faster service and lower repair cost, order these parts by the assembly, set or kit.NAME Alternator ~ Alternator Moun Block Group Block Group - Short Camshaft Group Carburetor & Linkage Clutch Pump Mount ing Coil & Dist. Wi Cover Group Crankshaft Group -~ Cvlinder Head Group Distributor Group - Distributor Drive Group - Engine Group ~ Engine Mounting ~ Exhaust Manifold Group Fan Drive ~ Filter Group ~ oi1 Flywheel Group — Radiator & Hoses INDEX ENG PAGE 1.27 1.28 1.02 1.33 1.05 1.2h 1,31 1.25 1.09 1.06 1.08 1.22 1.13, 1.01 1.26 1.16 2t ii 1.21 ‘SEBN3021 INE SECTION NAME Fuel Pump Group Gear Group ~~~ Gerotor Group - Governor = Housing Group = Front - Housing Group - Fiywheel - Inlet Manifold Group ~~ Lines Group - oi1 Oi! Clatch Pump ~ Pan Group ---~~ Pulley Group ~ Rod & Piston Group — Serv. Gp. - Anti-Diesel - Starting Motor Universal Joint ~ Mechanism Group ---~ Water Lines Group Water Pomp Sroup Switches ~ Press - Water- COOLING SECTION 2.01 SEFN3009 1a SEFN3009 a EXHAUST SECTION Muffler & Pipes ~ 3.01 FUEL SECTION ‘Accelerator Controls --~-- 4.04 Fuel Tank 4.01 Air Cleaner Group 4.02 Fucl Lines 4.03 ELECTRICAL SECTION Battery 6 Cables ~ 5.01 Wiring = 5.04 Horn 5-03 TRANSMISSION SECTION - MECHANICAL Clutch ~~ Clutch Cover ~ 6.08 Gears, Shafts & Bearings - 6.08 — Nain Housing -~ Clutch Housing 6.09 Parking Brake Assembly Clutch O11 Lines 6.10 Reversing Assembly ~ Clutch Pedal & Linkage ~ 6.11 Transmission Assembly . Clutch Reiease Mechanism 6.09 Transmission Cover ~ Fad. & Rev. Controls - ARARRAD se2egee 6.12 Shift Controls --. INDEX SEFN3009 SEBN3021 TRANSMISSICN SECTION - POWERSHIFT NAME PAGE NAME Controls Group =~ 6.26 Parking Brake 7 Converter Housing ~ 6.17 Selector Valve + E-2 Converter Lines 6 Fi 6.24 Torque Converter 18 Fud. 6 Rev. Gears - Gasket § Seals - High/Low Range Gears Inching Pedal -~ Qutout Shaft 6 Flange ---E-k 6.18 Transfer Gears 6.23 Transmission Group 6.21 Transmission Hous 6.28 Serv. Kit ~ Trans 6.22 Serv. Kit - Transmission - E-12 ORIVE AXLE SECTION - MECHANICAL Axle Assembly § Drums ---F-1 7.99 Drive Shaft & U Joints = Housing Group “E-17 7.95 Reduction Gear As. Differential As. & CarrieE-15 7.02 Wheel Group --- Orive Axle Group ~ “th 7.01 ORIVE AXLE SECTION - POWERSHIFT Axle Assembly & Drums --~F-1 7.09 Drive Shaft & U Joints - Carrier & Housing -E-20 7.08 Drive Axle Group ~ Differential Assembly ---F-18 7.06 Wheel Group = PAGE 6.25 6.20 6.16 6.22 6.15 6.19 6.30 7.01 7.10 3SEFN3009 STEER AXLE SECTION Axie Beam & Mounting == hubs & Bearings ~ Steer Axle Linkage ~ Booster Assemb! Brake Group Brake Valve Assembly ~ Feedback Cylinder Counterweight ~ Cowl & Panel Decal & Instruct Plates -G-14 Firewall Group 6-9 Floor Plates =-=- 8.02 Steer Cylinder - 8.04 Steering Gear Group ~ 8.01 Wheel Group ~ BRAKE SFCTION 9.04 Foot Controls - 9.01 Lines Group - 9.03 Warning Light ----=~ 9.07 FRAME SECTION 19.07 Frame Assembly Gok 10.03 Guard Group -==~ 6-13 10.10 Hood ~ 6-10 10.05 Seat Group 6-8 10.02 Cowl & Panel (Gages) G-12 HYDRAULIC SECTION Control Valve - Control Valve Levers - Filter Group - Hydraulic Pump Hyd. Pump Mounting ~ Lines Group 11.03 Serv. Gp. - Steer Pump ~ 11.08 Tank ~ 1.100 Tile cyl & Moun H.0l Serv. Gp. - Seal ~ 11,02 Valve Lever Cover 10.01 10.09 10.06 10.04 10.08 11.16 11.04 11.05 Wit 11.09 Lgcs N NAME, Attachment Lines Chart ~ Attachment Hyd. Lines Carry-Over Valve ~~ Control Valve Levers ~ Cylinder Block Handler ~ Chain Rollers DEX SEFN3009 SEBN3021 ATTACHHENT HYDRAULIC SECTION PAGE NAME PAGE 12.01 Lines Group - Sideshift -I-11 12.05 12.02 Lines Gp. - Block HandlerI-13 12.07 12.08 Sideshift Cylinder 1-10 12.04 12.09 Valve Hoses 1-19 12.10 12.06, LIFT GROUP - MAST 13.04 Mast Arrangement Chart --J-4 13.02 13.04 Outer Mast ---- J-6 13.03 Inner Mast LIFT GROUP - CYLINDER € CHAIN Lift Cylinder - u-10 13.05 Ju Service Kit - Mast - 13.06 s$e z ‘SEFN3009 ’ LIFT GROUP - CARRIAGE Carriage Ar. Chart - Ah 14.01 Carriage - Block Handler 24-6 14.03 Carriage Assembly = Sid. 2a-5 14.02 Carriage - Sideshift ----2a-7 14.04 LIFT GROUP - FORKS Forks ~ 2A-17 15.03 Fork Chart - = DARTS, Forks - Block Handler ---2A-18 15.04 ACCESSORIES Back-Up Alarm 16.11 Stop & Tail Lights -----28-15 16.12 Cab Group - 16.02 Temp/Press Warning - - -2B-19 16.16 Floodlights 28-17 16.14 Turn Signals - 16.12 Heater & Defroster 2B-6 16.06 Wiper Group 16.0% Mirrors = 28-1 16.01 Wiring Group ~ 16.08 Rotating Warning Light -~28-12 16.09 Accumulator Group - 16.17ENGINE PERKINS 4.236 GAS ENGINE 694420 ENGINE GROUP (Mecnanical Trans.) (NSS) 1 €94K21 ENGINE GROUP (Powershift Trans.) (NSS) FAN DRIVE AND FLYWHEEL ASSEMBLY GOVERNOR CARBURETOR AND THROTTLE LINKAGE, DISTRIBUTOR COIL AND DISTRIBUTOR WIRING ENGINE MOUNTING ALTERNATOR ALTERNATOR AND MOUNTING STARTER OIL CLUTCH PUMP OIL CLUTCH PUMP MOUNTING HYDRAULIC UNIVERSAL JOINTS. pee GESCRIPTION Ns ENGINE GROUP - 7-81 Models V-110, V-130 and V-150 (Perkins 4,236 Gas) 1.01a Mis Pa ! 3 ct LEFT SIDE ° VASAT TN64O1 BLOCK GROUP (NSS) 1.02 Models V-110, ¥-130 and V-150 (Perkins 4.236 Gas) (Rev.) 3-826N9630 358068 0a2582 676004 358318 676807 358063 98011 676008 676803 676895 676804 107880 951343 5H4279 676002 676806 676802 Seow eens 19] 2H3738 20) 676816 21} 5P6900 22) oT0840 23) 8NO454 24] 365802 25) 328045 26| 6n9322 127) 676035 28] 676948 29] 6N9323 30} 692644 31] 371449 32] 329103 33] 9MT974 34) 676817 SPB 24h BOLT BOLT BOLT DOWEL e-3 (Rev.) Models V-110, V-130 and V-150 (Perkins 4.236 Gas) WN GN ECON ENRON ING BOLT - BRIDGE - BUSHING 1.037N64OS CYLINDER HEAD GROUP (NSS) DESCRIPTION lon} fe ar DESCRIPTION BOLT n8 | 358175 | VALVE ~ INLET BOLT 19 | 676833 | WASHER ~ BOLT 20 | 8No329 | INSERT BOLT j21 | 676063 | nuT ~ BOLT 122 | 676843 | PLATE -- BOLT 123 | 337639 | PLATE - COVER ASSEMBLY - 24) 3L1850 | PLUG GASKET. 25} 7M7410 | PLUG GASKET 26} 38313 | PLUG HEAD GROUP -: 127 | 676044 | PLUG CAP - 128 | 676013 | stud Lock 129} SM2B94 | WASHER ROTATOR 30 | 9M1974 | WASHER SEAL 31] 676045 | WASHER HS | 358155 SPRING - 16 | 358156 SPRING 358229 | GASKET KIT (#Parts. 17 | 358174 VALVE - EXHAUST - Inctuted In Kit) ->7> Models V-110, V-130 and V-150 (Perkins 4.236 Gas 7-8119342 SEBN3021 1.€4/1.05 NOTE [Re] BARE le" PAR WANE Nore [=| wan PART NAME i [meson TT [ROSAS ? [2esees |} [Sur 5 | seoees | oc | uare | 3 iuchen fs lheeze | lees IS jassise |2 |Sotew 7 |erevoe [5 [Scie fs Jegersr [2 [S60 5 Jervaao (1 ect fol sions || fitten 13] aurea | [ewes fe] sreso0 | fengeer 13) seao08 |4 loot fa] Bsasoo 4 [Poin aysast PG 1.04¢a) 2W7829 FRONT HOUSING GROUPENGINE 7N6403 CAMSHAFT GROUP (NSS) Ref] Part [Ret] Pare ind DESCRIPTION lary] |e | Member DESCRIPTION ' 1} ] 6} 307028 | suim - 2 1] [7 | 676896 | washer 3 1] ]8 | 676895 | washer 4 1] | 9} 676178 | washer 5 1 7-B1 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 1.05LT342 ‘SEBN3021 1,05/1.07 PART r 5 re] PART Nore [ie] ART [on PART AME NOTE] yDARE lor] PART NAME T | awesze Ty [omaRanarT ASSEN «2 [520080 [2 [waste ti |sagoer |2 | Waster 4 fa [ercees |7 | seaang ser in fb |Sroces | 1 | feanne St 8 |sresre | \cean F | eerae | |kev THE rouownNa srs se Nga : saesre |1 fesati Kit (AR 25MM (.0101N JUNDERSIZE 1 asaseo | + |éeatne wr an Sa 200 Yee a 932981 | 1 BEARING KIT (MAIN) ea (O30 MORSE i rears |2 |nasvest ure eve (HTH JERSE t roars | |nasies one . eyo (Cm vena | |sa2s62 | fazaend Srcomecrie Aon) 25 (O09 jnocrce w | | szoea | 1 Jdetana SareoMte TN n00) Su C20W moses w | |osesea | fees rcemecti aon) it Tl [GOON ONIEASLE PG1.06 7N6402 CRANKSHAFT GROUP 09496SEBN2021__XOUT_Betw_ 1,07/1.08 NUMBER] PART NAME ‘358145 76167 ASS i ig Save sean =[5; [PSTON GROUP AY BeLunes ING. PISTON Pa NSS 368148 398170 676883 329918 Nut 2weose |4 [RNG SET ROO ASSEM. (eaci NLunES) HIN BOLT 7N6404 CONNECTING ROD AND PISTON GROUP (NSS) 1A711342 SEBN3021 1.07/1.09 ENGINE: ; ie PART |, wumben! PART NAME NOTE PART NAME ‘asai47 [1 [AR ASSEN GAS) 358200 |¢ | ARM (LH) e7eos7 |2 | seANg ease |4 | BRACKET s7eose |2 | sPANG gsazo1 |4 | ap (RM) segos. |2 | ANG eiese: |i | Bott erecas |2 | washer e7eass |1 | pipe assem. gagoo7 |1 | siarr” ASSEN. ercoss |2 | ” Plus ereoso |3 | screw ‘savor9 |8 | NUT ereass [4 |sTu0 4Bi0e0 [4 [washer anzage |1 |steeve Grease [5 |TAPPET (VALVE) 7608s |8 [Roo 06432 |4 [Nur 309483 ‘7N6407 VALVE MECHANISM GROUP (NSS) PG1.08ENGINE 7N64O8 COVER GROUP = VALVE MECHANISM (NSS) Ret] Part DESCRIPTION lery| [No | Number DESCRIPTION [ov] 67€066*) CAP ASSEMBLY 1 5| 676069 | SCREW ~[ 4 676067 GASKET PEE 6 | 5P0537 | WASHER -[4 38199 | COVER 1 358229 | GASKET KIT (* Parts | 35gh92 GASKET 1 Included in Kit) , 7-81 Models V-110, ¥-130 and ¥-150 (Perkins 4.236 Gas) 1.097N6415 GEROTOR PUMP GROUP (NSS) Part Number Ret] DESCRIPTION Nel Pat Le DESCRIPTION [ary 489883 23737 102343, 010639. oT0284 051570 676927 676926 329941 676933 329949 676926 329910 676938 384618 328280 | BOLT - 17 BOLT - 18} BOLT = 19) BOLT - 20) BOLT BOLT 2 22 BUSHING 23) CHRCLIF 24 eLip ~ 25) GASKET - 26 GASKET ~ 27] GEAR - 28} HOUSING ASSEMBLY 29) cap 30) PIN ey PLUNGER, 328281 | SPRING 676931, | nut —— 329933 | PIPE ASSENeLY -. 678925} pour GROUP 329051 | SEAL 676929 | SHAFT 56777 | SLEEVE 676317 | STRASNER 8n7998 | poweL - 329932 | TUBE ASSEMBLY ~ SM1974 | WASHER 5P0537 | WASHER 676070 | WASHER BF7242 | WASHER 5H2894 | WASHER. Models V-110, V-130 and V-150 (Perkins 4.236 Gas) (Rev.) 3-82TNOMIT ENGINE OIL FILTER SROUP (NSS) Ret] Part DESCRIPTION Jory) RT Pe ner DESCRIPTION FILTER ASSEMBLY GASKET HEAD NUT ~ 1] | 5] 329039 | stun - HT] 6] 58244 | washer - 1 361745 | GASKET KIT ( Parts 2 Included in Kit} === 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas} wnENGINE 7N6409 HOUSING GROUP - FRONT (NSS) TNG419 PULLEY GROUP - CRANKSHAFT (NSS) 7N6411 GEAR GROUP - FRONT (NSS) [Ret] Part eo |e praise DESCRIPTION { DESCRIPTION 329056 | BEARING 2F2093 | BOLT ~ 142343 | gout - 489883 | BOLT - 6F7030 | gotT - @su7i7 | BOLT - 676143 | BOLT ~ 357290 | COVER TN6S25 | COVER ASSEMBLY 337865 | ooweL 676867 | FLANGE 691178 | GASKET 676200 | GASKET 329945 | ASKET 676306 | GASKET 371608 | GEAR - 676898 | GEAR ASSEMBLY - 673579 | GEAR --- NSS | HOUSING ASSEMBLY 19] 7N6524 HOUSING 20 | 358870 sTuD - 21 | 358872 STUD - 22 | 676897 | HUB 23 | 158736 | KEY au} 691179 | PLATE 25 | 676900 | PLATE 26 | 337849 | PLUG 27 | 7N6718 | PULLEY 26 | 357288 | seaL - 29 | 329913 | SPACER 30} 9nig74 | washer 31] 371610 | WASHER 32 328100 | WASHER 33} 542894 | WASHER 34] 676144 | WASHER 35| 676908 | WASHER 36 | 011648 | BOLT - 1.12 Models V-110, V-130 and V-150 (Perkins 4.236 Sas) 7-81ENGINE 7N7074 DRIVE GROUP - DISTRIBUTOR (NSS) TNO4IS ENGINE OIL LINES GROUP (NSS) DESCRIPTION DESCRIPTION 243738 | BOLT - LINE ASSEMLBY - 070284 | souT - 358871 | BoLr - 8u8315 | souT - SHAFT 358191 | CLAMP SPACER 358189 | cover STUD -. 337625 | ELBow sTup - 8N8314 | FITTING WASHER 358195 ] GASKET ~ WASHER 676280 | GASKET -- WASHER 358153 | GASKET - WASHER 358203 | HOUSING WASHER 7-81 Models V-110, ¥-130 and V-150 (Perkins 4.236 Gas) 11316 3. 7N6413 PAN GROUP ~ OIL (NSS) Port Ret] Part Number DESCRIPTION lory] [Nol _ Number DESCRIPTION lary 1] 489883 | BOLT 12] {10} 676208 | PLus 2 2| 676914 | Bout 6} [11] 329100 | PLus 1 3| 051594 | SoLT 3] fiz STUD (See Engine 4} 329099 | GAGE ASSEMBLY 1 Section) ~~ 2 5] 676207 | WASHER 1] }13] 329926 | TUBE ASSEMBLY 1 6| 329946 | GASKET 1 ]r4] omta74 | waster 20 7| 329956 | GASKET 1] ]15] 1wea3a | wasHER 2 8] 184202 | nuT 21 116 swz894 | washer 3 9} 329972 | PAN --~ 1 SES cece eeeeeeeeee eee ceed Models V-110, V-130 and V-150 (Perkins 4.236 Gas) (Rev.) 2-82Paris Included in 358229 Gasket Kit PNGIIG INLET MANIFOLD GROUP (NSS) DESCRIPTION 358214 358215 358216 358217 358212 314155, GASKET GASKET GASKET GASKET MANIFOLD - NUT --- 184203 3.45390 358750 358751 S2894 676073 PLUG. sTuD STUD WASHER WASHER 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 1.15ENGINE 7N6420 EXHAUST MANIFOLD GROUP (NSS) Parts Included in 358229 Gashet Kit Hur DESCRIPTION frei ae DESCRIPTION lary 1] 90324 | sour 3] | 6] 184203 | nur - 10 2| 332388 | eLeow i} | 7| 676863 | stuo 3 3] 676104 | GasKer - 2| | 9) 358222 | stun 2 4} 358218 |scasker - 2] | 9] 358219 | stuo 2 5 | 358213 | MANIFOLD - 1 10} 542894 | WASHER - 10) 16 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-81‘LY342 SEBN3021 1,16/1.18 7 NOTE [| CARE Aer PART NAME NOTE |S nea Al PART NAME fT pawarrs [1 |e SE 2 | Savers | + |seane 5 | Seuaoe a frat anere: [2 [Rare Is | Sseoco | foxser 6 [asrzeo |4 [Stun ie rou.onn peran Ri Soavmtaate 1 Lscovee [1 [rue acon arsase 7N6422 FUEL PUMP GROUP7N64I8 WATER LINES GROUP (NSS) wouanren— fea Part Number DESCRIPTION DESCRIPTION jOry 329968 | BODY SWITCH oT0924 | BOLT - 01.0639 | BOT 489883 | BOLT 243739 | BOLT 8NO479 | ELBOW 329952 | GASKET - 676836 | GASKET - 184203 | NUT = PLUG stud THERMOSTAT ~ WASHER ~ WASHER ~: WASHER ~ BUSHING aa +18 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-81691158 WATER PUMP GROUP (NSS) Ret] Pan Pert Ne | Necsaber DESCRIPTION fener DESCRIPTION 1 | 680610 | Bett - NSS ARETAINER 2] 504184 | Bout - ss “SHAFT = 3 | 677024 | Extension ~ NSS WASHER 4 | 677022 | FAN ASSEMBLY -- TELAT | HOUSING ~ ss | PUMP GROUP ----~ 329963 | GASKET 5] ov1648 | eoLt 32996) | *GASKET 6| 010627 | eoLt 158705 | “KEY 7) 323173 | BOLT 184202 | NUT 7N4442 } PUMP GROUP ~ 184206 ) NUT ~~ 8 | 74439 SEAL 280858 | PLUG - 9] 7NA4HO SEAL 677018 | PULLEY 10 | 704437 SEAL 328087 | stup - ni | Ns BEARING 4o37e4 | WASHER 2] Nss HOUSING 417318 | WASHER h3 } NSS CLIP ha nss *D|STANCE-PIECE n5 | NSS “FLANGE 354369 | KIT - PUMP (4 Indicates 6 | uss UAPELLER ~ Parts Included in Kit 1 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 1.197N6W12 HOUSING GROUP - FLYWHEEL (NSS) DESCRIPTION sana DESCRIPTION BOLT 676130 BOLT : 12} 14203 BOLT 13] 329979 DOWEL - 14] 329939 GASKET 15) 676008 GASKET 16| 1B5174 GASKET 17| 5P0537 | WASHER GASKET 18| 676810 | WASHER 329950 | GASKET 19) Lo34 | WASHER NSS | HOUSING ASSEMBLY -- | 7n6721_| HOUSING ~ WL 1.20 Models V-110, V-130 and V-150 (Perkins 4,236 Gas) (Rev.) 3-82FAN DRIVE AND FLYWHEEL ASSEMBLY 694420 ENGINE GROUP (Mechanical Transmission) (NSS) 694421 ENGINE GROUP (Powershift Transmission) (NSS) 6N9342 FLYWHEEL GROUP (Mechanical Transmission) (NSS) 675315 FLYWHEEL GROUP (Powershift Transmission) (MSS) DESCRIPTION Nrber DESCRIPTION 680610 | BELT 7M0B49 | _ WASHER - = 6F7027 | BOLT TNIO60 | FLYWHEEL AS. (Power 5P7076 | BOLT shift Transmission) ~ 213708 | BOLT 337687 | GEAR 501026 | CLAMP 051603 | BOLT 4KB864 | CLIP 2M0849 WASHER ~ 103647 | cock 5P14K2 | HOSE (70cm) 321267 | CONNECTOR 5Po741 707026 | CONNECTOR 3B7742 5P6009 371439 065490 672202 | SHEAVE 695290 8F2393 | TEE ~ 086904 | FITTING 348505 | VALVE 7N3285 | FLYWHEEL AS. — (Nech- 5P8244 | WASHER anical Transmission)~ 4A8912 | WASHER 337687 GEAR - 1H3244 | WASHER 051603 | BOLT -. 7-81 Models V-110, V~130 and V-150 (Perkins 4.236 Gas) 1.20694420 ENGINE GROUP (Mechanical Transmission) (NSS) 694421 ENGINE GROUP (Powershift Transmission) (NSS) Ret] Port [Ret] Part Ne | tertaber DESCRIPTION Ins ieasbed DESCRIPTION 1 | 8N8726 | DISTRIBUTOR GROUP - 1 5 | 8N7041 SENSOR ASSEMBLY 2 1372478 CAP ASSEMBLY - 1 6 | 1N3236 SHAFT ASSEMBLY 3 | 1N3235 PLATE ASSEMBLY -: 1 7 | 8N3667 A | 332361 ROTOR -~- 1 8 | 946761 272 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-81ef] Pan Number SERVICE GROUP - ANTI-DIESELING DESCRIPTION 7N5882 7N5881 OLI125 7N5878 583254 482043 KIT ANTI-DIESELING SOLENOID - BRACKET ASSEMBLY GASKET ~ LEVER Nut NUT 675829 4ntoo9, 7NS877 854626 28076 5P5623 efi [eran SCREW ASSEMBLY SHIM ~ SOLENOID - SPLICE ~ TERMINAL ~ WIRE (12dm) ~ 7-81 Models Y-119, V-130 and V-150 (Perkins 4,236 Gas)12335 CARBURETOR GROUP (NSS) 694420 ENGINE GROUP (Mechanical Transmission) (NSS) 69h421 ENGINE GROUP (Powershi ft Transmission) (NSS) DESCRIPTION DESCRIPTION 4p2152 536154 NSS 1N3340 12336 0L1125, 348201 589079 5F 7038 BOLT -- BRACKET - 695371 CARBURETOR ASSEMBLY - 56214 SOLENOID --~ 2F3219 CARBURETOR ASSEMBLY 5L426 GASKET - 602619 | SPRING GOVERNOR ~ 108912 | WASHER 3K6116 | WASHER 8N9159 | KIT - CARBURETOR - Models V-116, V-130 and V-150 (Perkins 4.236 Gas) 7-8)3-82 COIL AND D/STRIBUTOR WIRING 494420 ENGINE GROUP (Mechanical Trans.) (NSS) 694421 ENGINE GROUP (Powershife Trans.) (NSS) DESCRIPTION DESCRIPTION 0s1617 | BOLT ~ 369012 | coIL - 7N4128 | HARNESS ASSEMBLY 104716 | NUT -- 369013 | PACK ASSEMBLY -. 172311 | SCREW 6N9142 | SPARK PLUG 4BL274 | WASHER - WASHER ~ WASHER =: WIRE SET = WIRE AS. WIRE AS. WIRE AS. WIRE AS. 1wo760 | WIRE AS. (No. 1 Cyt)! (Wo. 2 Cyl) (No. 3 Cy!) (No. 4 Cyt). (Coit) --- (Rev.) Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 1.25ENGINE MOUNTING DESCRIPTION DESCRIPTION 243790 | NUT - (Powershift) = 688068 | SUPPORT ASSEMBLY (LH) (Mechanical) - 688069 | SUPPORT ASSEMBLY (RH) 384507 | WASHER 8F6437_ | WASHER 640047 | WASHER 384508 | WASHER 485272 | WASHER 485276 | WASHER 0S1627 688063 643274 4004S 616703, 1.26 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-8Fret Part ALTERNATOR Iho |_ Raber DESCRIPTION foe ones DESCRIPTION 684139 | ALTERNATOR 1] | 9] 689819 1| 689818 | BEARING -. 2| |10} 689826 2 | 689829 BRUSH ASSEMBLY t 11} 3N1200 RING ASSEMBLY 3 | 689828 DIODE - ISOLATION - | 1 12] 689820 ROTOR ASSEMBLY ~: 4} 819365 DIODE - RECTIFIER(-)] 1 13] 689823 “TATOR ASSEMBLY 5 | 689825 DIODE ~ RECTIFIER(+)]} 1 14} 689830 VOLTAGE REGULATOR - 6| 689816 | FAN -----~---. 1] 15} 189982 7 | 689817 HOUSING ~ FRONT - 1] 116] 819362 8 | 689827 HOUSING - REAR t 1-81 (Rev.) Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 27ALTERNATOR MOUNTING 494420 ENGINE GROUP (Mechanical Trans.) (NSS) 694421 ENGINE GROUP (Powershift Trans.) (NSS) fie Narre i DESCRIPTION |v) Number DESCRIPTION SMI974 | WASHER - 465270 | WASHER ~ ¥{osi618 | gout - 2 | 684129 | PULLEY - 1.28 Models V-119, V-130 and ¥-150 (Perkins 4.236 Gas) 7-81ENGINE Ye 18 6 OD! Pa yea jo St 2t34 + 1% Tay 7 36 STARTING MOTOR 694420 ENGINE GROUP (Mechanical Trans.) (NSS) | 694471 ENGINE GROUP (Powershift Trans.) (NSS) Part Part meek DESCRIPTION ory Number DESCRIPTION 7N8402 | STARTING MOTOR ~ 1 455106 | PIN - ~ 656572 | ARMATURE -~ Hl 081893 | PLUNGER ASSEMBLY 7NB823.| BEARING ASSEMBLY 1 081888 | RING - 64818 | BEARING ASSEMBLY -- |1 081896 | SCREW NSS BUSHING ~ 1 3F0379 | SCREW 26986 GaskeT 1 315178 | SCREW NE584 SEAL 1 781197 | SCREW 4mB482 | BOLT - 2 3H3627 | SCREW 658382 | Boot - 1 41321 | screw u8470 | BRUSH - 4 fmBh64 | SHOE - 083090 | DRIVE ASSEMBLY - 1 4B471 | SPRING ~ 083636 SPRING 1 081892 | SPRING ~ 083637 WARE 1 081887 | stop - 7NBB22 | FRAME ASSEMBLY - 1 48475 | SUPPORT ASSEMBLY 7NBB24 | GROMMET --- 1 372501 | SWITCH ASSEMBLY 48472 | HOLDER 2 989006 | WASHER ~------~- 53294 | HOLDER 2 218166 | WASHER ~ 695323 | HOUSING - 1 660122 | WASHER 988599 BUSHING ~ 1 358241 | WASHER 081894 | LeveR ASSEMBLY - 1 7N5268 | CASKET ~ 329681 | NUT ' 18] lnBa77 | PIN 1 7-81 Models V-110, ¥-130 and V-150 (Perkins 4.236 Gas) aENGINE Ont CLUTCH PUMP 694420 ENGINE GROUP (Mechanical Trans.) (NSS) Par Number DESCRIPTION Neda DESCRIPTION eVAMEUN— 88615 213878 1P3878 3K6325, 1PBA6S 098398 098388 098387 093132 PUMP ASSEMBLY 093133 BEARING 4F2291 BEARING 098384 BEARING 01.0626 BEARING 113768 8F4S10 SHI190 098397 098390, 1.30 Models V-110, V-130 and U-150 (Perkins 4.236 Ge-) 7-81i, Pup g” 8 Ge Le. i WS, He ey Cds SG 15, i — OIL CLUTCH PUP MOUNTING 594420 ENGINE GROUP Mechanical Trans.) (NSS) Rs | Rube _|__OESCRIPTION vail inceaee DESCRIPTION [ow| 1} 617108 3| 692229 | puticy 2| 9si58e to} 62214 | screw - 3| orouss ri} 192575 | screw - 4 | 688062 12] 52894 | wasHER 5] 188705 13] 4B5271 | WASHER 6} 104717 va} 94sio0 | wasHER 7| 616698 15| 495272 | wasHER 8| 697263 16] spa2i4 | WASHER 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas)HYDRAULIC UNIVERSAL JOINT 694420 ENGINE GROUP (Mechanical Trans.) (NSS) 694421 ENGINE GROUP (Powershift Trans.) (NSS) Part Far Number DESCRIPTION ory neue DESCRIPTION NSS | UNIVERSAL JOINT GROUP 148033 WASHER - 656233 | YOKE 11] 1H8034 WASHER ~ 673989 BOLT 12] 652548 CAP == 102343 Bout 384505 | WASHER 684740 YORE 38860! SCREW ~ 689698 TUBE 64685, YOKE ASSEMBLY 18032 CAP - 13) 312187 FITTING th} 683574 SPIDER & BEARING 15] 67030 | BOLT ------- 1.32 Models V-110, V-130 and V-150 (Perkins 4.236 Gav) 77N0991 6ngu 74 371449 7NG4ON 676013 1N4107 BLOCK GROUP - CYLINDER (SHORT) (PERKINS GAS 4.236) DESCRIPTION BLOCK GROUP COVER GROUP - CRANKSHAFT ASSEMBLY - SEAL --~ - PISTON GROUP - ROD 6~ sTup ~~~ - | FER [scar 676063 358065, 358066 358067 8N0329 | INSERT - 357296 | GASKET ~ 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 1.33ENGINE OIL PRESSURE AND WATER TEMPERATURE SWITCHES 523844 OPTIONAL ARRANGEMENT - CHASSIS (NSS) 523913 OPTIONAL ARRANGEMENT - CHASSIS (NSS) (With Gages Instead of Indicator Lights DESCRIPT!ON Pare Number DESCRIPTION ELBOW(P/S Trans.) SWITCH --~ 302010 SWITCH ASSEMBLY ~ Models V-110, V-130 and V-150 (Perkins 4.236 Gas)695250 695621 637095 695622 637095, 051594 oTo102 696047 1P4278 5P0597 695298 382110 482047 14717 695276 02582 743171 BAFFLE ~-~~ - BAFFLE ASSEMBLY (RH)- CHANNEL (66cm) ~--~ BAFFLE ASSEMBLY (LH)- RADIATOR DRAIN COCK PLUG ~~ NSS. 361863 361866 379497 361867 361864 ‘4Bt232 688298 657251 BF1434 4gu27h 5M2894 Ghortt 485271 4841280 5P6316 CAP ASSEMBLY ~ HOSE -~ RESERVOIR SCREW STRAP stud WASHER WASHER WASHER WASHER WASHER WASHER wrap_(3dm) 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 2.012.02 882664 695250 695621 637095 695622 637095, 051594 oT0102 696047 1P4278 5P0597 358664 3R5387 520741 9L5094 695298 382110 688026 627408 672580 688027 627408 6.2580 COOLING DESCRIPTION BUSHING BAFFLE - - BAFFLE ASSEMBLY (RH)~ CHANNEL (66cm) ---~ BAFFLE ASSEMBLY (LH)- CHANNEL (66cm) ~--~ BOLT - BOLT - BRACKET CLAMP CLAMP CLAMP CONNECTOR ELBOW ELBOW HOSE - HOSE - HOSE ASSEMBLY ~ HOSE ASSEMBLY ~ HOSE (178cm) FITTING =. 4ezo47 104717 695289 743171 002582 NSS. 361863 361866 379497 361867 361864 4g 1232 688298 687251 BF 1434 4B h274 5M2894 Ghortt 484280 4a5271 017043 051409 Nut RADIATOR ASSEMBLY - PLUG --- DRAINCOCK ~ RECOVERY GROUP ‘BRACKET CAP ~~ CAP ASSEMBLY HOSE - RESERVOIR = SCREW STRAP sTuD -: WASHER WASHER WASHER WASHER WASHER, WASHER, ELeow SCREW Models V-110, ¥-130 and V-150 (Perkins 4.236 NN PE FON Sooo eee eee537165 EXHAUST GROUP (NSS) 537263 MOUNTING GROUP - MUFFLER (NSS) Part DESCRIPTION ies} dame DESCRIPTION Jory 1} 3e19ts | Bot 13} 081614 | BOLT --------- 2 2) ost5gi | sour wh} 537264 | MUFFLER ASSEMBLY 1 3 15] 14716 2 4) 536953 | BRACKET - - 16} 184330 2 5] 784993 |CAP ASSEMBLY - - 171537265 | SHIELD ASSEMBLY 1 6] 1wa7i7 |wir - - 18] 309209 | NuT --~ 4 7| 617208 | CLAMP - - 19] 539117 | HOSE ASSEMBLY 1 8] 617209 |cLanP ~ ~ 20] 537267 | TUBE ASSEMBLY 1 9] 676104 | GASKET - 21} 537166 | TUBE ASSEMBLY 1 10 22} 485270 2]! 11] 695341 Mount --- 23 i NSS [MUFFLER GROUP 244) 206416 4 12] 104671 | BOLT ~~ J 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 3.01DESCRIPTION 24337 | SCREW 689584 9F9327 | SCREW 514733 | GASKET - 694065 | TANK ASSEMBLY - 687687 | HANGER ASSEMBLY - 677395 | UNIT ---: 482049 | NUT 002014 | VALVE ASSEMBLY 618252 | NUT 530055 | WIRE ASSEMBLY - 2ree’s | FELT (37du) 687723 | TERMINAL 6HOo-1 | PIN 2L8076 | TERMINAL 287409 - 5P6027 WIRE (3dm) WOT HM SUN— 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) worDESCRIPTION ee DESCRIPTION —_faty 7N7304 | CLEANER GROUP -- 53233 | FITTING 1 7N9388 COVER ASSEMBLY 8NO600 | GASKET - oe 7N9027 | ELEMENT ASSEMBLY ~ 5P1680 | HOSE (45cm) - - | aR 7Ngo28 | ELEMENT - SPO743 | HOSE (60cm) ~ ~ [ar 050509 | BOLT - 666328 INDICATOR ~- fd 081591 BOLT - awwh717 | NUT = J 12 538903 | BRACKET ASSEMBLY - 537953 | STRIP -|1 501026 | CLAMP 588978 | TEE -- 2] 246540 | CLAMP 537954 | TUBE ASSEMBLY ------- | 1 678638 | ELBOW 5m2894 | WASHER - 117] 695045 | ELBOW 9M7959 | CLAMP “]4 323631 ELBOW —___J 537010 CLEANER GROUP - AIR (NSS) 4.02 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-81Part Pare Neen DESCRIPTION Number DESCRIPTION 051588 | BOLT 5B7890 PLUG - 1P4278 | CLAMP 287409 Plus - 693686 | CONNECTOR 026619 | stu - 694080 | COUPLING - 694559 | FITTING 691152 | FERRULE 5P1420 | HOSE (127m) 026096 | FILTER ASSEMBLY - 468774 | NUT -- 026610 | BOWL ~ 5P1199 | TUBE (26cm) 026611 ELEMENT NSS | TUBE ASSEMBLY - 026612 5P1199 | TUBE (16cm) ~ 026613 389113 NUT 026614 082014 | VALVE 026615 384506 | WASHER - 026616 7-81 Models V-110, V-130 and ¥-150 (Perkins 4.236 Gas) 4.03697337 CONTROLS GROUP (NSS) ACCELERATOR CONTROLS GROUP DESCRIPTION DESCRIPTION 0s1594 697086 | CONTROL GROUP 01.1133, 6V1292 | JOINT ASSEMBLY 01.2070 1D4717 | NUT 695441 | BRACKET 184201 | NUT 536155 | BRACKET ASSENBLY 536169 | PEDAL ASSEMSLY 539091 | CABLE ASSEMBLY 3B4504 | WASHER - 701728 | CLIP ~~~ 384506 | WASHER - 4.08 Models V-110, ¥-130 and V-150 (Perkins 4.236 Gas) 7-81538686 538723 984701 oroioz 051588 4E4879 050509 537907 537879 537957 16119 seo747 16120 187252 302098 617659 spo747 682169 682157 622714 501026 388664 537884 5P5926 BRACKET ASSEMBLY ~ BRACKET ASSEMBLY — CABLE ASSEMBLY - BOLT CABLE (177em) NUT --~ TERMINAL TERMINAL CABLE ASSEMBLY - CABLE (88cm) - TERMINAL TERMINAL CLAMP COVER ASSEMBLY SEAL (Adm) - DESCRIPTION 184330 3N3 182 537932 537868 539476 5P6782 5P5926 537864 686434 481256 134337 2P4337 538684 689941 5P6000 5H2B9h, 5P0537 GROMMET ~---~ HOLDER NUT NUT NUT NUT PAN PLATE PLATE ASSEMBLY SEAL (3dm) SEAL (15dm) ROD ROD SCREW SCREW SCREW SHEET TE TUBE (6dm) WASHER WASHER 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas)ost6r4 685761 629233, 34504 685768 685764 HORN GROUP (NSS) DESCRIPTION HORN ASSEMBLY RELAY WASHER WIRE ASSEMBLY 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas)Y= YELLOW 540053 WIRING GROUP (NSS) SHOOS4 WIRING GROUP (HSS) (Frame End) Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-81540053 WIRING GROUP (NSS) 540054 WIRING GROUP (NSS) (Frame End) DESCRIPTION DESCRIPTION 0s1614 0T0102 538888 | BRACKET 539203 | CIRCUIT ASSEMBLY 963671 HOUSING - PLUG 7N7780 PIN =~ INT773. SOCKET - 980173 | CIRCUIT BREAKER - 145166 | CLIP - 99155 | cLiP 370089 | cLIP - uousé | Fuse - 403100 | GROMMET 538461 | HARNESS AS. - ENGINE- TR4MTS CONNECTOR --- 963667 HOUSING ~ PLUG ---— 787778 HOUSING - PLUG ---~ 1NT777 HOUSING - RECEPTACLE| 963677 HOUSING - RECEPTACLE] 747780 | PIN - 963695 PLUG - 7N7779 | SOCKET - 218076 | TERMINAL 2L8069 | TERMINAL 218066 | TER aL 538464 | HARNEL. AS. - FRAME 514069 | CONNECTOR - 6N9587 CONNECTOR - 963668 HOUSING - PLUG 963667 HOUSING - PLUG 963673 HOUSING - RECEPTACLE| 7N7780 963695 787779 2L8N66 | TERMINAL 218076 | TERMINAL 218067 | TERMINAL 2.8068 | TERMINAL 538509 | HARNESS AS.(Powershift Transmission Only) ~~ 77778 | HOUSING - PLUG ---- 7N7’77 | HOUSING - RECEPTACLE) 7N7186 | PIN ~~ - 7N7779 | SOCKET ~: 218076 | TERMINAL 38106 640035 689cin1 TH3244 5P0537 539600 218076 | TERMINAL 218067 | TERMINAL 218068 | TERMINAL 538660 | WiRE AS. (Nechan Transmission Only) 218075 | TERMINAL 218079 | TERMINAL 540039 | WIRE ASSEMBLY - 218066 | TERMINAL 2L8068 | TERMINAL oer copes eee ease er ooh es ec 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 5.05aR - BROWN Dk BL ~ DK. BLUE OK GR - DK. GREEN Gy ~ Grav UT aL = LT. Bue ELECTRICAL UT GR - UT) GREEN 0 = ORANGE > PINK PU ~ PURPLE R= RED 1 TAN > wie Y= YELLOW =? 10-12-13-14 ® E\e" 540053 WIRING GROUP (NSS) 5W0054 WIRING GROUP (NSS) (Panel End) Models V-110, ¥-130 and V-150 (Perkins 4.236 Gas} 7-81370050 539208, 7N9737, 7N7780 77779. BMB94B 538460 TKUAIS 7K96B9. 709737 963673 IN7777 963674 7N9738 7N7780 963695 3N7773 375433 5P2957 218065 2L8074 538871 375433, 5P2957 2L8075 45122 81.9801 27088 14717 ELECTRICAL 540053 WIRING GROUP (NSS) 540054 WIRING GROUP (NSS) (Panel End) Part DESCRIPTION Nonber 2 DESCRIPTION CLIP --~ DIODE ASSEMBLY HOUSING ~ PLUG Pin -~ SOCKET - FUSE - HARNESS AS. - PANEL - CONNECTOR ~ CONNECTOR ~. HOUS'rIG - PLUG HOUSING - RECEPTACLE HOUSING - RECEPTACLE HOUSING ~ RECEPTACLE HOUSING - RECEPTACLE PIN 4B2041 539602 538582 695166 538364 203077 172311 692338 6922k1 26015 5P6786 366463 769558 903721 691381 PLUG - 689941 SOCKET - -}) 4p5324 TERMINAL - ht 81434 TERMINAL, 7 538776 TERMINAL ~ 218076 TERMINAL - 54571 HARNESS ASSEMBLY -~-~ 538869 TERMINAL, - 375433 TERMINAL, - 218075 TERMINAL - ~ 538870 HOLDER - - 375433, LAMP. ~ 7 2.8075 LENS - NUT ~ 265298 305365 SPE Hehe ag Den HON HUN RNR nut PLATE PLATE (Mechanical Only) RELAY ~~ RETAINER ‘SCREW SCREW ‘SCREW SEAL - SOCKET - STRAPPING (3dm) SWITCH ASSEMBLY ~ KEY SET SWITCH ~ TERMINAL ~ WASHER - WIRE ASSEMBLY TERMINAL TERMINAL WIRE ASSEMBLY TERMINAL, TERMINAL WIRE ASSEMBLY TERMINAL TERMINAL WIRE ASSEMBLY 7-81 Models V-110, V-130 and ¥-150 (Perkins 4.236 Gas)ELECTRICAL 8, se 1e-15-16-2 267 542254 WIRING GROUP (NSS) 542803 WIRING GROUP (NSS) (u/Gages Instead of Indicator Lights) (Frame End) 5.08 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 1-62ELECTRICAL 542254 WIRING GROUP (NSS) 542803 WIRING GROUP (NSS) (w/Gages Instead of Indicator Lights) (Frame End) DESCRIPTION TERMINAL TERMINAL TERMINAL TERMINAL HARNESS AS. (Powershift 0s1614 oTor02 538888 980173 15166 218066 218076 32 | 218067 133 | 218068 538509 CIRCUIT BREAKER CLIP 370049 | CLIP Transmission Only) Buous6 | FUSE 135 | 2N7778 HOUSING - PLUG 403100 | GROMMET 36} 2N7777 HOUSING - RECEPTACLE] 538461 | HARNESS AS. - ENGINE- 37 | 7N7780 TRAN75 | CONNECTOR 963567 HOUSING - PLUG 7N7778 | HOUSING - PLUG 7N7777_ | HOUSING - RECEPTACLE 963677 | HOUSINGS - RECEPTACLE 7N7780 963695 7N7779. 218076 218063 218066 52253 | HARNESS AS. 514069 | CONNECTOR 6K1828 CONNECTOR 963668 | HOUSING ~ PLUG 963667 HOUSING - PLUG 963673 HOUSING - RECEPTACLE] 7N7780 | PIN 963695, PLUG - 7N7779_|__ SOCKET - 38 | 7N7779 39} 218076 40] 3«8106 fay | 17231 42] 640035 43) 691381 iit} 1H3244 | WASHER 45) 5P0537 | WASHER - 46] 539600 | WIRE ASSEMBLY - 47] 218076 TERMINAL ~ 48) 218067 | TERMINAL ~ 49) 218068 | TERMINAL - 50| 538660 | wiRE AS. (Mechanical Transmission Only) 51) 208075 | TERMIRAL 52| 2L8079 | TERMINAL ~ 53| 540039 | WIRE ASSEMBLY 5h] 218066 | TERMINAL ~ 55| 218068 | TERMINAL ~ 1-87 Models V-110, V=130 and V-150 (Perkins 4,236 Gas) 5.09ELECTRICAL 10-12-13-1 542254 WIRING GROUP (NSS) 542803 WIRING GROUP (NSS) (u/Gages Instead of Indicator Lights) (Panel End) 5.10 Models V-110, V+130 and v-150 (Perkins 4.236 Gas) 1-82542254 WIRING GROUP (NSS) 542803 WIRING GROUP (NSS) (w/Gages In Place of Indicator Lights) (Panel End) DESCRIPTION DESCRIPTION 2V7088 | LENS (Mech. Trans.) 104717 | nut 30) 482041 NUT 31] 539602 | PLATE 32] 695466 | RELAY 33] 538364 | RETAINER 34] 203077 | SCREW 35] 172311 | screw 36] 692338 | screw 37) 692241 SEAL =. 38] 260151 | SOCKET (Mech. Trans. 39] 5P6786 | STRAPPING (3dm) 40] 366463 | SWITCH ASSEMBLY 769558 | KEY SET - AT} 691381 TERMINAL 42| 675886 | TERMINAL 43] 689941 | THE ~~ 4h} 485324 | WASHER ~ 45) 8F1434 | WASHER ~ 46] 538776 | WIRE ASSEMBLY ~ 47) 218076 TERMINAL 48} 5PAS77 TERMINAL 49] 538869 | WIRE ASSEMBLY - 50) 375433 | TERMINAL 51] 218075 TERMINAL 52] 538870 | WIRE ASSEMBLY - 53) 375433 TERMINAL 54) 208075 | TERMINAL 370050 | cLiP - 539208 | DIODE ASSEMBLY 7N7937 | HOUSING - PLUG 7N7780 | PIN -- 7N7779 | SOCKET 88948 | FUSE ~ 542262 | HARNESS AS. ~ PANEL 74475 | CONNECTOR ~ NSS CONNECTOR ~ 709737 | HOUSING - PLUG 963673 HOUSING - RECEPTACLE 7N7777 | HOUSING - RECEPTACLE 963674 | HOUSING - RECEPTACLE 7N9738 | HOUSING - RECEPTACLE! 77780 | Pia 963695 | PLUG - 7N7773 | SOCKET ~ 375433} TERMINAL 5P2957 | TERMINAL 218065 | TERMINAL 2U8074 | TERMENAL 218066 | TERMINAL 218076 | TERMINAL 2U8075 | TERMINAL 538871 | HARNESS ASSEMBLY 375433 | TERMINAL 5P2957 | TERMINAL 28075 | TERMINAL 45122 | HOLDER - 819801 | LAMP (Mech. Trans.) AR aw oN eet oN oo oN Now ooo} Pee ee Sea gg 1-82, Models V-110, V-130 and V-150 (Perkins 4.236 Gas) aanTRANSMISSION MECHANICAL 4 SPEED TRANSMISSION 695146 TRANSMISSION GROUP (NSS) Serial Numbers 59WO0001 thru S9WOOKE6 eC 538199 | TRANSMISSION ASSEMBLY (Used with O11 Clutch) -- 4-82 (Rev.) Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 6.01TRANSMISSION 542933 MECHANICAL 4 SPEED TRANSMISSION 695146 TRANSHISSION GROUP (NSS) Effective Serial Numbers S9WOO4E7 a DESCRIPTION TRANSMISSION ASSEMBLY (Used with Of1 Clutch) ~- 4-82 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 6.010TRANSMISSION Serial Numbers 59W00001 thru 5900466 HAIN TRANSMISSION HOUSING, GEARS, SHAFTS AND BEARINGS 695146 TRANSMISSION GROUP (Mechanical Trans.) (NSS) 6.02 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) (Rev.) 4-82TRANSMISSION HAIN TRANSHISSION HOUSING, GEARS, SHAFTS AND BEARINGS 695146 TRANSMISSION GROUP (Mechanical Trans.) (NSS) Serial Numbers s9woooot BEARING BEARING BEARING BEARING ASSEMBLY - BEARING CUP -~ BOLT ASSEMBLY BOLT ASSEMBLY BOLT ASSEMBLY BOLT ASSEMBLY CASE ASSEMBLY cover, thru 59WOOKG6 682742 647377 213843 647389 677826 695141 695142 695143 695144 677825 677818 677820 677821 682818 DESCRIPTION RETAINER RETAINER ASSEMBLY ~ SEAL RETAINER RING ~~ RING (.087) ~ RING (.090) -. RING (.093) RING (.096) ~ RING & PIN ASSEMBLY - SHAFT ~ SHIM (,009 - .011) SHIM (.014 - .016) SPACER SPACER SPRING SYNCHRONIZER AS. RING ASSEMBLY -. GEAR WASHER RIT (# Indicates Parts in Kit) (See Cluteh, Cover As. & Reversing As. Pages)- 4~82 (Rev.) Models V-110, V-130 and V-150 (Perkins 4.236 Gas)2 9 a 9 2 a 2 ¢q rs FE Effective Serial Numbers SOMO0K67 MAIN TRANSMISSION HOUSING, GEARS, SHAFTS AND BEARINGS 695146 TRANSMISSION GROUP (Mechanical Trans.) (wss) Hodels V-110, V-130 and V-150 (Perkins 4.236 Gas) 4-82 6.03A,[firme [|__pesonvrrion [on] [Ra] Rie BEARING ASSEMBLY BEARING CUP - BOLT ASSEMBLY BOLT ASSEMBLY BOLT ASSEMBLY BOLT ASSEMBLY CASE ASSEMBLY COVER, P.T.0, WOT AW EW Ko COUNTERSHAFT TRANSMISSION MAIN TRANSHISSION HOUSING, GEARS, SHAFTS AND BEARINGS 695146 TRANSMISSION GROUP (Hechanical Trans.) (NSS) Effective Serial Numbers s9WOOK67 682742 647377 243843 643631 677826 695141 695142 695143, 695144 677825 52938 677820 677821 677822 647383 677827 533533 uss 677829 677831 682818 RETAINER RETAINER ASSEMBLY SEAL RING RING RING RING RING RING RING SHAFT ~ SHIM (.009 - .011) ~: SHIM (.01K - .016) -: SPACER SPACER SPRING SYNCHRONIZER AS. - RING ASSEMBLY GEAR ~~ WASHER KIT (# Indicates Parts in Kit) (See Clutch, Cover As. & Reversing As. Pages)~ 4-82 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 6.0386.04 647418 677846 677838 TRANSMISSION TRANSMISSION COVER AND SHIFT FORKS 695146 TRANSMISSION GROUP (Mechanical Trans.) (NSS) DESCRIPTION DESCRIPTION BALL BOLT BOLT ASSEMBLY COVER ASSEMBLY ~ TRUNNION ~ FORK AS. (Low & 2nd)- INSERT -=~ FORK AS. (3rd & 4th)- INSERT ~ GASKET us - PLUNGER RAIL (Low & 2nd) RAIL (3rd & th) SPRING WASHER * KIT (See Nain Transmission) -~ Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 7-31TRANSMISSION PARKING BRAKE ASSEMBLY 695146 TRANSMISSION GROUP (NSS) (Mechanical Transmission) DESCRIPTION DESCRIPTION 647430 | BAND ASSEMBLY ~ NUT 647431 LINING & RIVETS - NUT 647432 | LINING - NT 647433 | RiveTS - Pin 647434 | BoLT - PIN 647438 | GOLT SCREW 12029 | BOLT SPRING 647368 | BOLT - SPRING 647437 | BOLT - WASHER 538198 | BRACKET WASHER: 647444 | DRUM WASHER 647435 | LEVER = WIRE (15cm) ~ 647436 | LINK - YOKE --~ 682747 | NUT - 7-81 Hodels V-110, V~130 and V-150 (Perkins 4.236 Gas) 6.05TRANSMISSION TRANSMISSION REVERSING ASSEMB!~ 695146 TRANSMISSION GROUP (Mechanical Transmission) (NSS) 6.06 Models V-110, V-130 and V-150 (Perkins 4.236 Gas! 7-81TRANSMISSION TRANSMISSION REVERSING ASSEMBLY 695146 TRANSMISSION GROUP (Mechanical Transtission) {Nss) DESCRIPTION =] ELE [seer 1H9722 | PLUG NSS | PLUG 690717 | RAIL 682721 | RETAINER ASSEMBLY --- 677813 | RING 647396 | RING 682736 | RING 682732 | RING 682733 | RING 170034 | RING 682734 | RING 681594 | RING 681595 | RING 681596 | RING 681597 | RING (. 647394 | ROLLER 682722 | SEAL 682724 | SEAL 682714 | SHAFT 682715 | SPACER 682712 | spacer 682735 | SPACER 647422 | SPRING 682737 | stud 647395 | WASHER 677832 | WASHER 682711, | WASHER ‘ KIT, Gaskets 7 Seals (See Trans. Section)- 489783 | BALL -~ 681608 | BEARING ASSEMBLY 647392 | RING - 508785 | BEARING ASSEMBLY 647392 | RING NSS | BOLT 647350 | SCREW 647399 | BOLT ASSEMBLY 686648 | CLUTCH ---- 682710 | COUNTERSHAFT ~ 682728 | Cover - 682726 | FORK 682729 GASKET 682738 [GASKET 647398 [GASKET 682730 }KGASKET 682709 | GEAR 686650 | GEAR 682713 | GEAR 686649 | EAR 682731 | GEAR 686646 | GEAR ASSEMBLY 682708 | HOUSING 682716 | KEY - 677806 | PLATE-- 660730 | MAGNET 647393 | nur - 216267 | NUT - 682727 | PIN - xss___| PLue Ses sce a a poceeeepge ae ace Sea ana 7-81 Models V-110, V-130 and V-150 (Perkins 4.236 Gas) 6.07