Dongfeng Cummins

Techical
Operations

ENGINE MODEL： 6BT5.9-G2

CURVE & DATASHEET： FR93146

REV 01 15OCT2013
 Generator Engine Performance Data Basic Engine Model:
FR93146 @ 1500 RPM &1800RPM
DONGFENG CUMMINS ENGINE Co.,LTD 6BT5.9-G2
Xiangfan, Hubei Province, China Configuration CPL Code Revision
http://www.dcec.com.cn
FR93146
D402078GX02 CPL: 3076 2013/10/15
Compression Ratio: 17.3:1 Aspiration: Turbochanger
Bore: 102 mm Displacement: 5.9 L
Storke: 120 mm No. of Cylinders: 6
Emission Certification: Fuel System: BYC A/Electronic Governor
Governor Regulation: ≤5%

All data is based on the engine operating with fuel system, water pump, and 14.8 in H2O (3.7 kPa) inlet air restriction with 5.98 in
(152mm) inner diameter, and with 2.95 in Hg (10 kPa) exhaust restriction with 4.02 in (102 mm) inner diameter; not included are
alternator, fan, optional equipment and driven components. Coolant flows and heat rejection data based on coolants as 50% ethylene
glycol/50% water. All data is subject to change without notice.

Engine Speed Standby Power Prime Power Continuous Power

RPM kW HP kW HP kW HP
1500 92 123 86 115

1800 110 147 100 133

Engine Performance Data @ 1500 RPM Litre/hour

25.0
OUTPUT POWER FUEL CONSUMPTION
% kW HP g/kW.h L/h 20.0
STANDBY POWER
100 92 123 212 23.6 15.0
PRIME POWER
100 86 115 214 22.3 10.0
75 64.5 86 216 16.9
50 43 58 217 11.3 5.0
25 21.5 29 248 6.5
CONTINUOUS POWER 0.0
0 20 40 60 80 100
Engine Power Output - kW

Engine Performance Data @ 1800 RPM Litre/hour

35.0
OUTPUT POWER FUEL CONSUMPTION
30.0
% kW HP g/kW.h L/h
STANDBY POWER 25.0
100 110 147 235 31.3
20.0
PRIME POWER
100 100 133 235 28.5 15.0

75 75 100 228 20.7 10.0

50 50 67 238 14.4
5.0
25 25 33 297 9.0
CONTINUOUS POWER 0.0
0 20 40 60 80 100
Engine Power Output - kW

Curves shown above represent gross engine performance capabilities obtained and corrected in accordance with GB/T18297 conditions
of 99kPa (29.61 in. Hg) barometric pressure, 25°C (77°F) inlet air temperature, and 1 kPa (0.30 in. Hg) water vapor pressure with No.0
diesel fuel.
Above Source From CUMMINS AEB 26.02
 FR93146 (Continued) Page: 2
GENERAL ENGINE DATA
Approximate Engine Weight (wet)………………………………………………………….. -kg 411
Mass Moment of Inertia of Rotating Components (No Flywheel)…………………………………………………….……
2
-kg·m 0.25
Center of Gravity from Rear Face of Block………………………………………………………………… -mm 544
Center of Gravity above Crankshaft Centerline………………………………………………… -mm 155
Engine Idle Speed………………………………………………………………………………………………………… -RPM 750-850
Fire Order……………………………………………………………………………………………………………… 1-5-3-6-2-4

ENGINE MOUNTING
Maximum (Static) Bending Moment at Rear Face of Block………………………………………………………….-N.m
-N.m 1356

EXHAUST SYSTEM
Maximum Back Pressure……………………………………………………………………….………..
-kPa 10

AIR INTAKE SYSTEM

Maximum Intake Air Restriction with Heavy Duty Air Cleaner
— Dirty Element……….…………………………………….…………………………….-kPa 6.2
— Clean Element……….…………………………….……………………………. -kPa 3.7

LUBRICATION SYSTEM
Engine Oil Pressure for Engine Protection Devices:
— Idle Speed(Minimum )………………………………………………………………………………………………………… -kPa 207
— Governed Speed(Maximum )…………………………………………………………………………………………………-kPa 345
Maximum Oil Temperature………………….…………………….………………….……………….………………………………… -℃ 121
Minimum Required Lube System Capacity - Sump plus Filters…….……………………………………….-litre
-litre 16.4

FUEL SYSTEM
Type Injection System……………………………………………………………………………………………………… BYC A Direct Injection
Maximum Restriction at Lift Pump………...……………………………………………………………………………. -kPa 13.6
Maximum Fuel Inlet Temperature....................................................................................................................
-℃ 40
Total Drain Flow (constant for all loads)…………..………………………………………………………………………….… -litre/hr 30

COOLING SYSTEM
Coolant Capacity - Engine Only………………………………………………………………………………………… -litre 7.9
Maximum Coolant Friction Head External to Engine…………………………………………………………-kPa
-1800 rpm……………………………………………..……………………
-kPa 35
-1500 rpm……………………………………………..……………………
-kPa 28
Maximum Static Head of Coolant Above Engine Crank Centerline…………….………………………….
-m 14
Standard Thermostat (Modulating) Range………………………………….………...……….… -℃ 82 - 95
Minimum Pressure Cap……………………………………………………………………...…………………………-kPa -kPa 69
Maximum Top Tank Temperature for Standby / Prime Power…………….....…………………………………...…………………
-℃ 104 / 100
 FR93146 (Continued) Page: 3
ELECTRICAL SYSTEM
Cranking Motor (Heavy Duty, Positive Engagement)……………………………………………………………………………
-volt 12V 24V
Battery Charging System, Negative Ground………………………………………………………………………………..
-ampere 63 40
Maximum Allowable Resistance of Cranking Circuit…………………………………………………...…………….
-ohm 0.00075 0.002
Minimum Recommended Battery Capacity
—Cold Soak @ 0 to 32-F (-18 to 0-C)………………………………………………………………………….………..
-0°F CCA 625 312

EMISSIONS
Gaseous Emissions per GB 20891-2007, at 1500rpm：
—Weight-Specific NOx…………………………………………………………………… g/kW.h
—Weight-Specific HC………………………………………………………………………….-g/bhp-hr.
g/kW.h
—Weight-Specific CO………………………………………………………………………….-g/bhp-hr.
g/kW.h
—Weight-Specific Particulates………………………………………………………………………..-g/bhp-hr.
g/kW.h

Gaseous Emissions per GB 20891-2007, at 1800rpm：

—Weight-Specific NOx………………………………………………………………………… g/kW.h
—Weight-Specific HC………………………………………………………………………….-g/bhp-hr.
g/kW.h
—Weight-Specific CO………………………………………………………………………….-g/bhp-hr.
g/kW.h
—Weight-Specific Particulates………………………………………………………………………..-g/bhp-hr.
g/kW.h

Fuel Rating Option used for these Data: FR93146

STANDBY POWER PRIME POWER

Governed Engine Speed……………………………………………………….
-rpm 1800 1500 1800 1500
Engine Idle Speed………………………………………..……...…………-rpm
-rpm 750-850 750-850 750-850 750-850
Gross Engine Power Output……………………………………………………….….-kW
-kW 110 92 100 86
Piston Speed.......…………………………………….………………-m/s
-m/s 7.2 6.0 7.2 6.0
Friction Horsepower………………………………………………….….-kW
-kW 12.7 12.7 12.7 12.7
Engine Water Flow to Engine:……………………..………..……….-litre/sec.
-litre/sec. 2.8 2.0 2.8 2.0
Intake Air Flow………………………………………………..….-litre/sec.
-litre/sec. 112 108 111 100
Exhaust Gas Flow…………………………………………..……….-litre/sec.
-litre/sec. 319 280 312 250
Exhaust Gas Temperature…………………..…………………..……………………………………………………
-℃ 577 565 564 526
Radiated Heat to Ambient…………..……………………….-kW
-kW 21 21 19 19
Heat Rejection to Coolant……………..………………….-kW
-kW 71 61 68 54
Heat Rejection to Fuel…………………………………..…………………………………….-kW
-kW TBD TBD TBD TBD

ALL DATA CERTIFIED WITHIN 5%

TBD = To Be Decided N/A = Not Applicable N.A. = Not Available
All data is subject to change without notice, sorry for inform.
Dongfeng Cummins Engine Co., Ltd.