Autographpc Case Report: General Description
Autographpc Case Report: General Description
Autographpc Case Report: General Description
PB03_20210510.apcx (Case 0)
General Description
Customer Name: Texcal Mahato EP Ltd Reservoir: Unknown Well: PB-03
Well API#: 33.1 Country: INDONESIA State:
Engineer: PUTRDED01 Project Date: 05/11/2021 Print Date: 05/31/2021
Project:
Case Number: Case 0 Case Description:
Page 1 of 18
Pump Normal Curves
Page 2 of 18
Design Values
Casing Pressure (Pc): 10 psi Tubing Pressure (Pt): 100 psi Flow @ Std Cond (Qsc): 1015 BPD
Well Flowing Pressure (Pwf): 879 psi Pump Intake Pressure (Pip): 849 psi Total Dynamic Head (TDH): 3200 ft
Pump Intake VDepth: 5365 ft Perfs Vertical Depth: 5453 ft
Inflow performance
Inflow Model: Composite IPR Productivity Index: 1.18 BPD/psi Reservoir Pressure (Pr): 1739 psi
Datum Vertical Depth: 5453 ft Static Pressure @ Datum: 1739 psi
Page 3 of 18
Fluid Data
Sol Gas/Oil Ratio Above
Oil Specific Gravity: 0.86 Deg API: 33.1 61.32 scf/STB
Bubble Point (Rs):
Water Specific Gravity: 1.0 Water Cut: 0% Fluid Surface Temperature: 105.0 ºF
Producing GOR: 70.0 scf/STB Producing GLR: 70.0 scf/STB Bottom Hole Temperature: 245.0 ºF
Gas Properties
Gas Specific Gravity: 1.18 Bubble Point Pressure: 308 psia
N2: 0% H2S: 0% CO2: 0%
Gas Separation
Natural Separation Eff: N/A Mechanical Separation Eff: N/A User-entered Sep Eff: 0%
LT Gas Separator: None UT Gas Separator: None Packer Installed: No
PVT Correlations
Bubble Point Pressure / Rs: Standings Oil Formation Vol Fac: Standings
Oil Compressibility: Kartoatmodjo Gas Compressibility: Hall & Yarborough
LEGAL NOTICE: Because of the uncertainty of variable well conditions and the necessity of relying on facts, information and supporting services furnished by others, Baker Hughes is unable to guarantee the accuracy of any chart interpretation, research analysis, or recommendations
contained herein. While best efforts should be used in gathering and interpreting such information, USERS OF THIS REPORT AGREE THAT Baker Hughes SHALL NOT BE RESPONSIBLE FOR ANY DAMAGES ARISING FROM THE USE OF THIS REPORT.
Page 4 of 18
Pump Summary
400CENTURION P10SND 184 Stages
BHP / RPM: 41.48 HP / 3094 RPM Intake / Discharge Viscosity: 1.02 / 1.06 cp
Efficiency: 50.61 % Intake / Discharge Ch: 1.0 / 1.0
Total Dynamic Head: 3200 ft Intake / Discharge Cq: 1.0 / 1.0
GIP: 0% Intake / Discharge Cbhp: 1.0 / 1.0
Intake / Discharge Pressure: 849 / 1931 psi Flow / Head / Power Adj Factor: 1.0 / 1.0 / 1.0
Intake / Discharge Flow Rate: 1142 / 1140 BPD Pump Range Min/BEP/Max: 650 / 1000 / 1400 BPD @ 60 Hz
Intake / Discharge Spec Gravity: .78 / .78 Pump OP Range Min/BEP/Max: 574 / 883 / 1236 BPD @ 53 Hz
CMP = Compression, FLT = Floater, MDLR = AR Modular
Stage Description: 400CENTURION P10SND Pump Construction: FLT
141.2 HP @ 53 Hz / 41.5 HP / Shaft
Stage Count: 184 STD Shaft HP Limit/Op HP/Loading:
load =(STD 29%) / (HS 20%)
Page 5 of 18
Seal Section Summary
Selected: 513GSB3 DB Shaft Load: 42 HP
Oil: CL6 Shaft HP Limit: 442 HP @ 53 Hz
Operating Temp: 300 ºF Shaft Load %: 10%
Seal Bearing Type: HL Oper Thrust Bearing Load: 402 lbf
Seal Shaft Material: STD Max Thrust Bearing Load: 726 lbf
Thrust Bearing Capacity: 5933 lbf
Oper Thrust Loading %: 7%
Max Thrust Loading %: 12%
Motor Summary
Motor Np @60 Hz Line Freq: 562SP_ 100HP 1005V 61A Motor Load: 48%
Motor Np HP @Op Hz: 88 HP Motor Op HP: 42 HP
Motor Np V @Op Hz: 887 V Motor Op Volt: 753 V
Motor Np Amp: 61 A Motor Op Amp: 35 A
Operating RPM: 3094 RPM Motor Op Temp: 313 ºF
Liquid Vel Past Mtr: 1.5 ft/s Motor Op Pwr Factor: 80
Zenith 150C-400bar E7 MW 456 -
Sensor: Motor Op Eff: 88%
Aflas
Pot Head: CentrLink 20 Motor OP Freq: 53 Hz
Motor KVA: 46
Page 6 of 18
Controller Summary
Panel: VSD Output Current: 67 A
Input kVA: 52 Output Voltage: 465 V
Cost $/KWH: 0.05
Page 7 of 18
Equipment
Amperage: 34.94 A
Surface KVA: 52.78 KVA Supply Line Freq: 60.0 Hz
Surface Volt: 872.1 V Controller: VSD 2150-VT 163kVA 480V/ 196A
Surface Cable: #4 CELF5.0kV 100.0 ft Total Oil Produced: 1015 BPD
Total Water Produced: 0 BPD
Power Cable: #4 CELF5.0kV 5787 ft
Total Gas Produced: 71 Mscf/D
Tbg Pressure: 100.0 psi
Qg Up Tubing: 71.05 Mscf/D
Csg Pressure: 10.0 psi
Qg Up Casing: 0 Mscf/D
Pump
CENTURION P10SND
N/A 4.0 in 17.5 ft Stages 184
41.48 HP
Intake
N/A 0 in 0 ft
Seal 513GSB3
N/A 5.13 in 6.9 ft DB
Motor
Motor Lead:
562SP_
N/A 5.62 in 8.3 ft Nameplate: 100HP 1005V 61A (60Hz) #4 MLE-
KLHT5.0kV 55.0
Operating: 88HP 887V 35A (53Hz)
ft
Oper Temp: 313.0ºF
Sensor Base
N/A N/A N/A Zenith 150C-400bar
E7 MW 456 - Aflas
Total MD: N/A
Page 8 of 18
Field Service Information
Well Information
Customer Name: Texcal Mahato EP Ltd
Well: PB-03
Controller Setup
Motor ADR @ 60 Hz: 62 HP 900V / 42A (Use this rating for doing calculations when setting up controller)
Min Hz: 45
Max Hz: 60 (Max Hz is where target production is expected but actual setup should be higher based on operation expectations)
Sensitivity Analysis
Freq Flow Pip Gip MtrLoad MtrV MtrA SurfV MtrTemp
(Hz) (BPD) (psi) (%) (%) (V) (A) (V) (ºF)
45 807.3 1025 0 34.37 602.2 27.66 694.5 300.3
46 833.7 1003 0 35.96 620.2 28.51 715.7 301.6
47 860.1 980.3 0 37.6 638.5 29.39 737.1 303.0
48 886.4 958.0 0 39.28 657.1 30.28 758.9 304.4
49 912.6 935.8 0 40.99 675.9 31.18 781.1 305.9
50 938.7 913.7 0 42.74 695.1 32.11 803.6 307.6
51 964.8 891.6 0 44.52 714.4 33.05 826.5 309.3
52 990.8 869.6 0 46.34 734.1 34.01 849.7 311.1
53 1017 847.6 0 48.2 754.0 34.98 873.3 313.0
54 1043 825.7 0 50.09 774.1 35.97 897.2 315.1
55 1068 803.9 0 52.02 794.5 36.98 921.4 317.2
56 1094 782.1 0 53.98 815.2 38.0 946.0 319.5
57 1120 760.4 0 55.98 836.1 39.03 970.9 322.0
58 1145 738.7 0 58.01 857.2 40.08 996.2 324.5
59 1171 717.1 0 60.07 878.6 41.15 1022 327.2
*60 1196 695.6 0 62.16 900.2 42.22 1048 330.1
61 1221 674.2 0 64.28 922.0 43.31 1074 333.1
Page 9 of 18
Field Service Information
Page 10 of 18
Inflow performance Curve ( Composite_IPR )
Page 11 of 18
2-D Well Profile
Page 12 of 18
Well Pressure & Temperature Gradient
Page 13 of 18
Pump Curves @ 53 Hz
Page 14 of 18
Pump Stage Curves
184-400CENTURION P10SND
Page 15 of 18
Turpins Plot
Page 16 of 18
Main Cable Clearance
Page 17 of 18
MLE Clearance
Page 18 of 18