An Dispatch 20B

Motorola
MCS-2000 Radios to
223 Series Adapter Panels
AN-DISPATCH-020 Rev B 21 MAY 2009

Table of Contents
1.0 General ..................................................................................................... 3

2.0 Interconnect Cable Assembly ................................................................ 3
3.0 223 Series Adapter Panels ...................................................................... 4
3.1 TRA-223 Setup .....................................................................................................4
3.1.1 TRA-223 Dip Switch Settings ..................................................................4
3.2 DSP-223 Setup ......................................................................................................4
3.2.1 DSP-223 Jumper Settings ........................................................................4
3.3 IP-223 Setup .........................................................................................................5
3.3.1 IP-223 Jumper Settings ............................................................................5
2 AN-DISPATCH-020
Motorola
MCS-2000 Radios to
223 Series Adaptor Panels
1.0 General
This application note is intended to show how to assemble a cable and set up the hardware of the
different 223 series adapter panels (TRA-223, DSP-223, and IP-223) to a Motorola MCS-2000
Series mobile radio.
2.0 Interconnect Cable Assembly

A cable assembly is required to connect to the 25-pin accessory connector of the MCS to the
various 223 Series adapter panels.
Use the following chart to make this interconnect cable assembly.
TABLE 1. Interconnect Cable Assembly Pin Out
TRA-223 DSP-223 IP-223 Series MCS-2000
Signal
DB-25 Pin DB-25 Pin DB-25 Pin DB-25 Pin
25 25 25 23 MIC +
24 24 24 11 RX+
14 14 14 21 PTT
7 7 7 10 GND
10 10 20 22 COR
AN-DISPATCH-020 3
3.0 223 Series Adapter Panels
3.1 TRA-223 Setup
3.1.1 TRA-223 Dip Switch Settings
Set the TRA-223 dip switches as shown in Table 2.
REFERENCE: For more information, see the TRA-223 Technical Manual
(P/N 803570).
TABLE 2. Front Panel Dip Switch - TRA-223
Switch Setting Signal

2-Wire = On
1 As appropriate
4-Wire = Off
4-Wire = On
2 As appropriate
2-Wire = Off
Full-Duplex = On
3 As appropriate
Half-Duplex = Off
4 On Squelch
Radio Rx Level
5 Off On = Speaker
Off = High impedance
Radio Tx Level
6 On On = Low Level
Off = High Level
7 On Ground on PTT Relay Common
8 Off Ground on Monitor Relay Common
3.2 DSP-223 Setup

No software programming is required.
3.2.1 DSP-223 Jumper Settings
To set the DSP-223 jumpers, do the following:
1. Set the following jumpers to the A position:
J14, J15, J22, J23, J24, J25 and J27.
•
2. Set the following jumpers to B position:
J12 and J13.
•
3. Solder close JP2.
4. For 2- or 4-wire operation:.
J19, J20, and J21.
•
REFERENCE: For more information, see the DSP-223 Technical Manual

(P/N 803274), DSP to Console Connection section.
4 AN-DISPATCH-020
3.3 IP-223 Setup
Set the IP-223 jumpers as shown in Table 3.
3.3.1 IP-223 Jumper Settings
TABLE 3. IP-223 Jumper Settings
Line 1 Jumper Setting Line 2

J33, J34 B = 4-wire J5, J6
J16, J21 A = Single Ended J19, J20
J14 Hanging on Center Pin = 10 Ohm J24
J3, J9, J11 A = Single Ended J25, J28, J29
J13 B = High J27
J17, J22 B = 600 Ohms J10, J15
R377 Solder bridge the pads together R381
AN-DISPATCH-020 5
Revision History
Document Title: Motorola MCS-2000 Radios to 223 Series Adapter Panels
Document Number: AN-DISPATCH-020
Revision Change Description Date
A Update brand, format and new document number. 01-OCT-2009
B Section 2.0 and 3.3. 21-MAY-2010
Suggestions or comments:
Contact technical support with suggestions or comments concerning this application note.
Technical Support:
Email: TelexDispatchtechsupport@us.bosch.com
Fax: 1-402-467-3279
Phone: 1-800-898-6723
Bosch Security Systems, Inc.

8601 East Cornhusker Highway
Lincoln Nebraska 68507
Phone: (800) 752-7560 Fax: (402) 467-3279
Email: Telexdispatch@us.bosch.com
Web: www.telex.com

An Dispatch 20B

Uploaded by

Copyright:

Available Formats

An Dispatch 20B

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

An Dispatch 20B

Uploaded by

Copyright:

Available Formats

Motorola

AN-DISPATCH-020 Rev B 21 MAY 2009

1.0 General ..................................................................................................... 3

2.0 Interconnect Cable Assembly

Switch Setting Signal

3.2 DSP-223 Setup

REFERENCE: For more information, see the DSP-223 Technical Manual

Line 1 Jumper Setting Line 2

Document Title: Motorola MCS-2000 Radios to 223 Series Adapter Panels

Document Number: AN-DISPATCH-020

Revision Change Description Date

A Update brand, format and new document number. 01-OCT-2009

B Section 2.0 and 3.3. 21-MAY-2010

Bosch Security Systems, Inc.

Phone: (800) 752-7560 Fax: (402) 467-3279

You might also like