PAKISTAN INTERNATIONAL AIRLINES

ENGINEERING AND MAINTENANCE DEPARTMENT

ATR 42 500 CARD NO : ATR 42 PK DY
Man Hour: 01 Hour 10 Min
DAILY CHECK
ISSUE NO :19
Dated: JUNE 09, 2023

(For Technical Records Office Use Only) Daily Sheet No: _________________
Log-Book collected Time: __________
TABLE A: Flight Description (To be filled in by Technical Records Office):
Technical Log Book Pages.
Flight No. Time Date Shift
From To Missing
Arrival PK-

Departure PK-

TABLE B: Aircraft Time Details (To be filled in by Technical Records Office):

Total Total Engine

Total A/C Engine Cycles
Date A/C Reg. Station A/C A/C Operating Hours
Landings
Hours Cycles #1 #2 #1 #2

AP-

TABLE: Work Completion Checklist (To be filled in by technical Records &Cardex Office):

S/NO. ITEMS / ENTRIES TO BE CHECKED / VERIFIED SIGN DATE

1- Check the package against master copy for completion.

2- Check that carried forward items of Tech. Log are accomplished.

3- Make logbook entries of AircraftandEngine HOURS / LDGS/CYCLES.

4- Update Hard Time components / Inspections record in the computer.

5- Make entries of unscheduled component removals in the computer.

6- Check that all TSRs are carried out.

7- Check that all Sheets / Task Cards are signed.

List of Effective Pages

PAGE NO. DATE PAGE NO. DATE
1 of 5 JUNE 09, 2023 4 of 5 JUNE 09, 2023
2 of 5 JUNE 09, 2023 5 of 5 JUNE 09, 2023
3 of 5 JUNE 09, 2023 6 of 6 JUNE 09, 2023
Attachment: Dated: April 24,2015

ATR42-500 Daily Check Sheet Page 1 of 6

CARD NO: ATR 42 PK -DY Section 9.2 Dated: June 09, 2023
 PAKISTAN INTERNATIONAL AIRLINES
NOTE: Daily Check shall be accomplished at an interval of 24 hours. In case aircrafts completes 24
hours where daily check performance is not possible, the check shall be carried out maximum
within 48 hours.
Signature
S/N ON-BOARD DOCUMENTS TECH ENGR
1 Check for the presence of all aircraft documents as per
available on aircraft

Signature
S/N AEROSPACE TECH ENGR
1 General :
Make sure Main and Nose Landing Gear locks & wheel chocks are
correctly installed.
Review Technical Log Bookand undertake corrective actions as
required.
Review Major Item Change Sheet and take compliance action
Certify that all Snags and Rectification carried out at Out-Stations have
been checked at Base and release as considered satisfactory.
2 Carry out Transit check as per card No . ATR 42 -PK-TR

Landing Gears :ZONES 710 730 740

3 Check of Main and Nose landing Gear Structure including EMERGENCYs
and wheel well for damage, evidence of leakage.
Check Nose Wheel Steering Condition and free fall assister.
Check of Main and Nose Landing Gear Wheels for Condition and Tires for
Pressure and Wear(ref. MP # A-32-41-XX-00ZZZ-360Z-A).
Tires Inflating Pressures:
Main Wheel Nose Wheel
126 PSI ( 8.7 bar ) All Tires 63 PSI ( 4.4 bar ) except Michelin
Radial Tires 70 PSI (4.8 bar)
Check and note down Main and Nose Landing gear Tires
pressure:ZONES 710 730 740
CAUTION: Tire pressure must be checked and corrected whenever
possible when the tires are cold & service with nitrogen only
If tire pressures are taken when tires are warm, (refer: MP # A-32-41-XX-
00ZZZ-360Z-A) for further instructions.
Tires Pressures obtained:
MAIN WHEEL NOSE WHEEL

LEFT RIGHT
Outboard Inboard Inboard Outboard Port side Starboard
side

4 Main Gear Free Fall Assister :

Gain access to free fall assister and by means of inspection mirror check
that the RED MARKER of the pressure loss indicator is not visible.
( if RED Marker is visible refer : MP# A-12-14-32-03ZZZ-214Z-A)
=======================================================================================
ATR42-500 Daily Check Sheet Page 2 of 6
CARD NO: ATR 42 PK -DY Section 9.2 Dated: June 09, 2023
 PAKISTAN INTERNATIONAL AIRLINES
S/N AEROSPACE Signature
TECH ENGR
5 Flight Compartment :
Check cockpit including windshield and side windows for general
condition/damage and cleanliness.
Carry out Inspection of IPAD STAND for it condition, proper installation and its
availability of certification decals
( ref: RRB Approval # RRB/04/ATR42-001/23,Dated:31-05-2023 )
6 Cockpit Communication/Documentation Door
GVI of cockpit communication door hatch and its locking latch for general
condition, cleanliness. Confirm the satisfactory operation of Cockpit
communication door hatch
(Ref: RRB meeting# 4/2020 dated 14/9/2020)
7 Passenger Compartment :
Check passenger cabin including galley & lavatory for general condition,
cleanliness and evidence of any water leakage.
Check lavatory waste bin for condition.
8 Cargo Compartment:
Check cargo compartments for general condition and cleanliness.
9 Emergency Equipment :
Check emergency equipment for presence and proper stowage as per Emergency
Equipment Chart.
10 Flight Controls:
Check the movement of Flight Controls after disengagement of Gust
Lock Lever.
11 (a) Propeller :
Examine the propeller for signs of oil leakage and seepage. If
leakage/seepage is observed, proceed in the guidelines of CHECK
section of HS MM P5206, 61-10-00.
(b) Blades :
Visually examine all blades for cracks, nicks, gouges or damage to
the erosion coatings, signs of lightning strike, and tip area erosion.
If crack indication is observed, proceed in the guidelines of CHECK
section of HS MM P5206, 61-10-00.
(c) Spinner :
Visually examine the spinner, spinner collar and bulkhead filler for
cracks, gouges, dents and missing rivets. If crack indication is
observed, proceed in the guidelines of CHECK section of HS MM
P5206, 61-10-00. Clean rubber, plastic and fiberglass surfaces of
[

propeller blades with mild soap and warm water applied with a soft
cloth. Rinse with fresh water and dry with a soft cloth . (Ref. AMM
MP# A-61-11-60-00ZZZ-250Z-A)
12 Engine Nacelles: *Examine the engine intake area and
corresponding nacelle (LH & RH) Zones for any loose/missing
fasteners particularly access panels 451BL, 451BR, 461BL and 461BR. Take
necessary action and record findings in Tech Log.
13 Engine Oil Level Check :ZONE-433 443
Visual

ACC. 435AL 445AL(Ref. MP# A-12-13-79-00ZZZ-310Z-A

NOTE: vicing and therefore higher oil
consumption.
CAUTION: Do not check oil level via sight gauge more than 30 minutes after
shutdown. (15 +/- 5 minutes are considered optimum). Before this shutdown, An
engine run with propeller feathered for 20 seconds minimum must be made. (See
PWC EMM 720000 engine servicing).
=======================================================================================
ATR42-500 Daily Check Sheet Page 3 of 6
CARD NO: ATR 42 PK -DY Section 9.2 Dated: June 09 ,2023
 PAKISTAN INTERNATIONAL AIRLINES

Signature
S/N AEROSPACE TECH ENGR
14 Endorse and sign off corrective actions in Technical Log Book.
15 Review log book for oil added /Engines Operating Hours and record in the following
Performa.
16 Calculate Engines Oil Consumption Rate ( If more than normal trouble shoot and
take corrective action)
17 Propeller Deicer:
Check for any lifted edges/tab or any separation from the blade. Repair if needed.
Oil Scavenge Filter : Zones: 434 444
18 Visual check of oil scavenge filter impending by-pass indicator-
Acc : 436AR, 446AR. (ref .MP# A-79-22-60-00ZZZ-281Z-A)
Main Oil Filters : Zones: 433 443
19 Visual check of main oil filter impending by pass indicator
Acc : 435AL, 445AL. (ref .MP# A-79-22-60-00ZZZ-281Z-A)

Engine Oil Consumption Data

ENGINE OPERATING
OIL ADDED HOURS Calculate:
SECTOR (S) LEFT RIGHT LEFT RIGHT Oil Consumption Rate
ENGINE ENGINE ENGINE ENGINE
1
RATE = Total Oil added
2 Total Operating hours
3
Engine ( LH ) = _______________
4 ( Quart / Hour )

5 Engine ( RH ) = ________________
( Quart / Hour )
TOTAL
NOTE:0.5 lb/hr (0.227 kg/hr) is maximum oil consumption permissible which is equivalent to
0.270 quart/hr (0.256 liter/hr): (Ref. Current Rev. of PWC 127E MM 72-00-00)
Signature
S/N AVIONICS TECH ENGR
1 General:
Ensure Ground handling and Service Bus CBs are opened
Review Technical Log Book and undertake corrective actions as required
Review Major Item Change Sheet and take compliance action
Certify that all Snags and Rectification carried out at Out-Stations have been
checked at Base and release as considered satisfactory.
2 Carry out Transit check as per card No. ATR 42 -PK-TR
StaticPorts& All Probes:
3 Check static ports and all probes for no damage, covers removed/installed.
Flight Compartment:ZONE-210:
4 Put all CBs in and check for any CB popping out
Check all engine instruments for normal indication.
Perform operational test of Stall Warning and Stick Pusher
(Refer : MP# A-27-36-XX-00ZZZ-320Z-A)
Perform operational test of engine fire detection and warning system by
MP# A-26-12-XX-00ZZZ-320Z-A)

=======================================================================================
ATR42-500 Daily Check Sheet Page 4 of 6
CARD NO: ATR 42 PK -DY Section 9.2 Dated: June 09, 2023
 PAKISTAN INTERNATIONAL AIRLINES
Signature
S/N AVIONICS TECH ENGR

Wing Equipment:
5 Check emergency equipment for presence and proper stowage as per Emergency
Equipment Chart.
PROTECTIVE BREATHING EQUIPMENT ( PBE)
For Air Liquid PBE P/N : 15-40F-11 :
Check & ensure that life of PBE has not expired.

Check that protective seal is intact & in position.

PBE.

6 Battery Voltage :ZONE-210

Check battery voltage as per MP# A-24-31-80-00ZZZ-367Z-A

7 Operational Test of the following systems : ZONE-210

HF System & VHF System
Interphone System & Oxygen mask
Mike/ Boom mike & PA system
Voice recorder quality of 4-channels
ADF system & VOR /ILS
DME & ATC
Weather Radar & Low Range altimeter
Marker Beacon system
TCAS & EGPWS

8 Endorse and sign off corrective actions in Technical Log Book.

Emergency Lighting :
9 Check of Emergency Lights System for Correct Luminance.
(Refer : MP# A-33-5X-XX-00ZZZ-360Z-A)
HYDRAULIC

a) Do a Check of the hydraulic fluid level with the sight glass indicator on the top
of the reservoir for NORMAL range after arrival & before servicing and mark
accordingly.

Hydraulic Reservoir Status

NRM SVC
NRM: Normal status of reservoir SVC: Replenishment required
1 In condition of low level fill the hydraulic reservoir with oil and record uplift(s) quantity
in table and also record in ATLB.

Uplift Quantity Recorded in Quart

Extracted From JIC A-29-XX-XX-00ZZZ-281Z-A

Note:
a) In case of replenishment of reservoir, recorded quantity must be entered in the box.
b) In case of -e Not Required) in the
box.

Cabin Maintenance Checks

Perform checks as per attach

IMPORTANT NOTE:
Cabin Maintenance Daily Check Card are to be attached with this Sheet by Cardex
section before printing of the subject Card.
=======================================================================================
ATR42-500 Daily Check Sheet Page 5 of 6
CARD NO: ATR 42 PK -DY Section 9.2 Dated: June 09, 2023