Technical Data Sheet

Opto Interrupter

ITR9606
█ Features
․Fast response time
․High analytic
․Cut-off visible wavelength λp=940nm
․High sensitivity
․Pb free
․The product itself will remain within RoHS compliant version.
█ Descriptions
The ITR9606 consist of an infrared emitting diode
and an NPN silicon phototransistor, encased
side-by-side on converging optical axis in a black
Thermoplastic
Housing The phototransistor receives radiation
from the IRED only .This is the normal
Situation. But when an object is in between ,
phototransistor could not receives the radiation.
For additional component information , please
refer to IR928-6C and PT928-6C

█ Applications
․Mouse Copier
․Switch Scanner
․Floppy disk driver
․Non-contact Switching
․For Direct Board
█ Device Selection Guide
Device No. Chip Material LENS COLOR
IR928-6C GaAlAs Water clear
PT928-6C Silicon Water clear

Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev 3 Page: 1 of 6

Device No：CDRX-096-004 Prepared date：08-08-2005 Prepared by：Denky
 ITR9606
█ Package Dimensions

Notes:
1.All dimensions are in millimeters
2.Tolerances unless dimensions ±0.2mm
3.Lead spacing is measured where the lead emerge from the package
4.Above specification may be changed without notice. EVERLIGHT will reserve authority
on material change for above specification
5.These specification sheets include materials protected under copyright of
EVERLIGHT corporation . Please don＇t reproduce or cause anyone to reproduce them
without EVERLIGHT＇s consent
6.When using this product , please observe the absolute maximum ratings and the
instructions for use outlined in these specification sheets. EVERIGHT assumes
no responsibility for any damage resulting from use of the product which does
not comply with the absolute maximum ratings and the instructions included
in these specification sheets.

Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev 3 Page: 2 of 6

Device No：CDRX-096-004 Prepared date：08-08-2005 Prepared by：Denky
 ITR9606
█ Absolute Maximum Ratings (Ta=25℃)
Parameter Symbol Ratings Unit
Power Dissipation at(or below) 25℃ Free
Pd 100 mW
Air Temperature
Reverse Voltage VR 5 V
Input
Forward Current IF 50 mA
Peak Forward Current (*1)
IFP 1 A
Pulse width ≦100μs, Duty cycle=1%
Collector Power Dissipation PC 75 mW
Collector Current IC 50 mA
Output
Collector-Emitter Voltage B VCEO 30 V
Emitter-Collector Voltage B VECO 5 V
Operating Temperature Topr -25~+85 ℃
Storage Temperature Tstg -40~+85 ℃
Lead Soldering Temperature (*2)
Tsol 260 ℃
(1/16 inch form body for 5 seconds)
(＊1) tw=100 μsec. , T=10 msec. (＊2) t=5 Sec
█ Electro-Optical Characteristics (Ta=25℃)
Parameter Symbol Min. Typ. Max. Unit Conditions
VF1 --- 1.2 1.6 IF=20mA
Forward Voltage VF2 --- 1.4 1.85 V IF=100mA,tp=100μs,tp/T=0.01

VF3 --- 2.6 4.0 IF=1A,tp=100μs,tp/T=0.01

Input
Reverse Current IR --- --- 10 μA VR=5V
Peak Wavelength λP --- 940 --- nm IF=20mA
View Angle 2θ1/2 --- 60 --- Deg IF=20mA
Dark Current ICEO --- --- 100 nA VCE=20V,Ee=0mW/cm2
Output C-E Saturation IC=2mA
VCE(sat) --- --- 0.4 V
Voltage ,Ee=1mW/cm2
VCE=5V
Collect Current IC(ON) 0.5 --- 10 mA
IF=20mA
Transfer
Rise time tr --- 15 --- μsec VCE=5V
Characteristics
IC=1mA
Fall time tf --- 15 --- μsec
RL=1KΩ

Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev 3 Page: 3 of 6

Device No：CDRX-096-004 Prepared date：08-08-2005 Prepared by：Denky
 ITR9606
█ Typical Electrical/Optical/Characteristics Curves for IR
Fig.1 Forward Current vs. Fig.2 Spectral Distribution
Ambient Temperature
140
100
IF=20mA
120 Ta=25°C
80
100

80 60

60
40
40

20 20

0
0
-40 -20 0 20 40 60 80 100

Fig.5 Relative Intensity vs. Fig.6 Relative Radiant Intensity vs.

Forward Current Angular Displacement
1000 -20 -10 0 10 20
Ie-Radiant Intensity(mW/sr)

30
100
1.0 40

10 0.9 50
0.8 60
0.7 70
0 80
0 1 2 3
10 10 10 10 10 4
IF-Forward Current (mA) 0.6 0.4 0.2 0 0.2 0.4 0.6

Fig.7 Relative Intensity vs. Fig.8 Forward Current vs.

Ambient Temperature(°C) Ambient Temperature(°C)
1.3
15
Ie-Radiant Intensity (mW/sr)

10 1.2
IF=20mA IF=20mA

5 1.1

0 1
25 50 75 100 120 25 50 75 100 120

Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev 3 Page: 4 of 6

Device No：CDRX-096-004 Prepared date：08-08-2005 Prepared by：Denky
 ITR9606
█ Typical Electrical/Optical/Characteristics Curves for PT
Fig.1Collector Power Dissipation vs. Fig.2 Spectral Sensitivity
Ambient Temperature
100 1.0
Ta=25 C
80 0.8

60 0.6

40 0.4

20 0.2

0 0
-25 0 25 50 75 85 100 100 300 500 700 900 1100 1300

Fig.3 Relative Collector Current vs. Fig.4 Collector Current vs.

Ambient Temperature Irradiance
160 100
2
140
C
120
10
100
80
1
60
40
0.1
20
0
0 10 20 30 40 50 60 70 0.01
0.5 1 1.5 3
2

Fig.5 Collector Dark Current vs. Fig.6 Collector Current vs.

Ambient Temperature Collector-Emitter Voltage
10 14
12
10
10
8
10
6

10 4
2
10
50 75 100
0
0 25
0 1 2 3 4

Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev 3 Page: 5 of 6

Device No：CDRX-096-004 Prepared date：08-08-2005 Prepared by：Denky
 ITR9606
█ Reliability Test Item And Condition
The reliability of products shall be satisfied with items listed below.
Confidence level：90%
LTPD：10%
Test Sample Failure
NO. Item Test Condition Hours/ Size Judgement Ac/Re
Cycle Criteria
More than
90% of lead to
1 Solder Heat TEMP : 260℃ ± 5 ℃ 5 sec 22 PCs be covered by 0/1
soldering
H : +100℃ 15 mins
IR≧U×2
300
2 Temperature Cycle 5 min 22 PCs Ee≦L×0.8 0/1
cycle
VF≧U×1.2
L : -40℃ 15 min
H : +100℃ 5 min U :Upper
specification
10 sec 300 limit
3 Thermal Shock 22 PCs 0/1
cycle L :Lower
L : -10℃ 5 min specification
limit
4 High Temperature 1000
TEMP. : +100℃ 22 PCs 0/1
Storage hrs
5 Low Temperature 1000
TEMP. : -40℃ 22 PCs 0/1
Storage hrs
6 VCE=5V 1000
DC Operating Life 22 PCs 0/1
IF=20mA hrs
7 High Temperature / 85℃ / 85% R.H. 1000
22 PCs 0/1
High Humidity hrs

EVERLIGHT ELECTRONICS CO., LTD. Tel: 886-2-2267-2000, 2267-9936

Office: No 25, Lane 76, Sec 3, Chung Yang Rd, Fax: 886-2267-6244, 2267-6189, 2267-6306
Tucheng, Taipei 236, Taiwan, R.O.C http:\\www.everlight.com

Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev 3 Page: 6 of 6

Device No：CDRX-096-004 Prepared date：08-08-2005 Prepared by：Denky