Service Manual: XR-M500R/M550

XR-M500R/M550
SERVICE MANUAL
US Model
Canadian Model
Ver 1.1 2002.09
XR-M550
AEP Model
UK Model
XR-M500R
Photo: XR-M550
Dolby noise reduction manufactured under license from

Dolby Laboratories Licensing Corporation.
DOLBY and the double-D symbol ; are trademarks
of Dolby Laboratories Licencing Corporation.
Model Name Using Similar Mechanism
NEW
Tape Transport Mechanism Type
MG-25E-136
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (US model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION

19 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 1% total harmonic distortion.
Other specifications
Cassette player section
Tape track
Wow and flutter
Frequency response
Signal-to-noise ratio
Signal-to-noise ratio
4-track 2-channel stereo

0.08 % (WRMS)
30 20,000 Hz
66 dB (stereo),
72 dB (mono)
Harmonic distortion at 1 kHz
0.6 % (stereo),
0.3 % (mono)
Separation
35 dB at 1 kHz
Frequency response
30 15,000 Hz
Cassette type
Dolby B NR
Dolby NR off
TYPE II, IV
67 dB
61 dB
MW/LW (XR-M500R)
TYPE I
64 dB
58 dB
Tuning range
Aerial terminal
Intermediate frequency
Sensitivity
Tuner section
FM
Tuning range
Antenna terminal
Usable sensitivity
Selectivity
87.5 108.0 MHz (XR-M500R)

87.5 107.9 MHz (XR-M550)
External antenna connector
10.7 MHz/450kHz
8 dBf
75 dB at 400 kHz
MW: 531 1,602 kHz

LW: 153 279 kHz
External aerial connector
10.7 MHz/450 kHz
MW: 30 V
LW: 40 V
AM (XR-M550)
Tuning range
Antenna terminal
Sensitivity
530 1,710 kHz

External antenna connector
10.7 MHz/450 kHz
30 V
Continued on next page
FM/AM (MW/LW) CASSETTE CAR STEREO

9-870-088-13
Sony Corporation
2002I0500-1
C 2002.09
e Vehicle Company
Published by Sony Engineering Corporation
TABLE OF CONTENTS
Power amplifier section

Outputs
Speaker outputs
Speaker impedance
4 8 ohms
Maximum power output 50 W 4 (at 4 ohms)
General
Outputs
Inputs
Tone controls
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
Audio output (2) (M500R)

Audio output (3) (M550)
Power aerial relay control
lead
Power amplifier control
lead
Telephone ATT control
lead
Illumination control lead
Bass 9 dB at 100 Hz
Treble 9 dB at 10 kHz
12 V DC car battery
(negative earth)
Approx. 178 50 182 mm
(7 1/8 2 7 4/1 in.)
(w/h/d)
Approx. 182 53 163 mm
(7 1/4 2 1/8 6 1/2 in.)
(w/h/d)
Approx. 1.3 kg (2lb. 14 oz.)
Card remote commander
RM-X96 (XR-M500R)
RM-X94 (XR-M550)
Parts for installation and
connections (1 set)
1.
SERVICING NOTES ............................................... 3
2.
GENERAL
Location of Controls (XR-M500R) ................................
Setting the Clock .............................................................
Changing the Sound and Display Setting .......................
Locations of Controls (XR-M550) .................................
Setting the Clock .............................................................
Changing the Sound and Display Setting .......................
Installation (XR-M500R) ................................................
Installation (XR-M550) ..................................................
Connections (XR-M500R) ..............................................
Connections (XR-M550) ................................................
4
4
4
5
5
5
6
7
8
12
3.
DISASSEMBLY ......................................................... 15
4.
ASSEMBLY ................................................................. 19
5.
MECHANICAL ADJUSTMENTS ....................... 24
6.
ELECTRICAL ADJUSTMENTS
Tape Deck Section .......................................................... 24
Tuner Section .................................................................. 25
Design and specifications are subject to change

without notice.
7.
DIAGRAMS
7-1. Block Diagram TUNER/TAPE Section ..................

7-2. Block Diagram MAIN Section ................................
7-3. Block Diagram
DISPLAY/BUS CONTROL Section .......................
7-4. Block Diagram POWER SUPPLY Section .............
7-5. Note for Printed Wiring Boards and
Schematic Diagrams .......................................................
7-6. Printed Wiring Board
MAIN Board (Component Side) ..............................
7-7. Printed Wiring Board
MAIN Board (Conductor Side) ................................
7-8. Schematic Diagram MAIN Board (1/4) ..................
7-12. Printed Wiring Board SUB Board ............................
7-13. Schematic Diagram SUB Board ..............................
7-14. Printed Wiring Board DISPLAY Board ..................
7-15. Schematic Diagram DISPLAY Board .....................
7-16. IC Pin Function Description ...........................................
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
44
8.
EXPLODED VIEWS ................................................ 51
9.
ELECTRICAL PARTS LIST ............................... 55
Flexible Circuit Board Repairing

Keep the temperature of the soldering iron around 270 C during repairing.
Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
Be careful not to apply force on the conductor when soldering
or unsoldering.
Notes on chip component replacement
Never reuse a disconnected chip component.
Notice that the minus side of a tantalum capacitor may be damaged by heat.
SECTION 1
SERVICING NOTES
PRECAUTION ON OPEN/CLOSE FRONT PANEL
The front panel opens to the bottom of main unit.
In performing the repair, place the main unit on the base having
the height exceeding 1 cm.
MODEL IDENTIFICATION
There are four types of main board in according of destination for
XR-M500R.
MAIN BOARD (Componet Side)
front panel
XR-M500R/M550
base
1cm
R719
( SIDE VIEW)
IC601
Open the front panel by supplying the power through the following steps:
R720
1. Disconnect the motor connector (CN501) from main board.

2. Supply the power to the motor.
Voltage
:9V
Violet wiring : MOTOR
Gray wiring : MOTOR +
MAIN BOARD (Conductor Side)
gray wiring
violet
wiring
+
connector
(CN501)
R625
R626
R625 R626 R719 R720
TYPE A
TYPE B
TYPE C
TYPE D
Indicated language
English, Spanish,
Swedish, Portuguese
German, Italian, Dutch,
French
English, German
English, Polish, Czeck,
Turkish
TYPE A, B, C, or D can also be identified from the front panel

display language.
For a switching method of display language, see page 4.
SECTION 2
GENERAL
This section is extracted from

instruction manual.
(XR-M500R)
Location of controls
Security side
The corresponding buttons of the unit
control the same functions as those on
the card remote commander.
10 Reset button 8
2 Main display window
3 OPEN button 38
4qa Receptor for the card remote
commander
5 Volume adjust buttons
6 DSPL/PTY (display mode change/
programme type) button
7 Sub display window
8 MENU button
9 Z (eject) button 11
qs LISTbutton
qd OFF button* 9
qf MODE button
qg SOURCE(TUNER/TAPE/CD/MD) button
qh AF button 16, 18
qj Number buttons
During radio reception:
Preset number select
13, 14, 17, 33, 34
During tape playback:
(1) REP 12
During CD/MD playback:
(1) REP 28
(2) SHUF 28
Operation side
PTY
D-BASS
AF
REP
SHUF
TA
D
UN
SO
MODE
SOURCE
OFF
DISC
LIS
M
EN
U
DSPL
DISC
R
TE
EN
qk TA button 16, 17, 18

ql SOUND button
w; PRST/DISC+/ (cursor up/down) buttons
SEEK/AMS/+ (cursor left/right) buttons
13
wa ENTER button
ws CLOSE button
wd D-BASSbutton
* Warning when installing in a car
without ACC (accessory) position on
the ignition key switch
Be sure to press(OFF) on the unit for
two seconds to turn off the clock display
after turning off the engine.
When you press (OFF) only momentarily,
the clock display does not turn off and this
causes battery wear.
CLOSE
XR-M500R
Setting the clock

The clock uses a 24-hour digital indication.
Tips
You can use the convenient CT function to set
the clock automatically (page 20).
When the D.Info mode is set to on, the time is
always displayed (except for some functions of
SA mode) (page 23).
Changing the sound and

display settings
Example: To set the clock to 10:08
The following items can be set:
Set (Setting)
Press(MENU), then M or m repeatedly

until Clock appears.
1 Press(ENTER).
The hour indication flashes.
2 PressM or m to set the hour.
3 Press,.
The minute indication flashes.
4 PressM or m to set the minute.
Press(MENU).
PressM or m repeatedly until the desired

item appears.
Each time you press m, the item changes as
follows:
Example
Clock (page 10).

CT (Clock Time) (page 20).
Beep to turn the beep sound on or off.
RM (Rotary Commander) to change the
operative direction of the rotary commander.
Select norm to use the rotary
commander as the factory-set position.
Select rev when you mount the rotary
commander on the right side of the
steering column.
English/Spanish/Portuguese/Swedish to
change the display language to English,
Spanish, Portuguese or Swedish.
Clock t CT t Beep t RM t English/

Spanish/Portuguese/Swedisht D.Info t SA
t Dimmer t Contrast t M.Dspl*1 t A.Scrl*2
*1 When no CD or MD is playing, this item will
not appear.
*2 When the radio is off, or when no tape, CD,
or MD is playing, this item will not appear.
Note
The displayed item will differ depending on the
source.
Tip
You can easily switch among categories (Set,
Snd (Sound), P/M (Play Mode) and Dis) by
pressing M or m for two seconds.
Dis (Display)
D.Info (Dual Information) to display the
clock and the play mode simultaneously (on),
or to display the information alternately (off).
SA (Spectrum Analyzer) to change the
display pattern of the equalizer display
(page 25).
Dimmer to change the brightness of the
display (When the Illumination terminal
connected).
Select on to dim the display.
Select off to deactivate Dimmer.
Contrast to adjust the contrast if the
indications in the display are not
recognisable because of the units installed
position.
M.Dspl (Motion Display) to turn the
motion display on or off.
A.Scrl (Auto Scroll) (page 27).
Press, to select the desired setting

(Example: on or off).
Press(ENTER).
After the mode setting is complete, the
display returns to normal playback mode.
continue to next page t
Press(ENTER).
The clock starts.
10
23
24
(XR-M550)
(XR-M500R)
Installation
Instalacin
Montering
Instalao
Precautions
Precauciones
Skerhetsfreskrifter
Precaues
If you mount other Sony equipment with this

unit, it is better to mount this unit in the lower
position.
There must be a distance of at least 15 cm
between the cassettes slot of the unit and shift
lever to insert cassette easily. Choose the
installation location carefully so the unit does
not interfere with gear shifting and other driving
operations.
When the front panel is open, a portion of it will
extend down from the unit. When you install the
unit, make sure that this portion of the front
panel is not obstructed in its open position (by
the ashtray, for example).
Choose the installation location carefully so that
the unit will not interfere with normal driving
operations.
Avoid installing the unit in areas subject to dust,
dirt, excessive vibration, or high temperatures,
such as in direct sunlight or near heater ducts.
Use only the supplied mounting hardware for a
safe and secure installation.
Si monta otro equipo Sony con esta unidad, es

preferible montar esta unidad en la posicin ms
baja.
Para que sea posible insertar la cinta con
facilidad, debe haber una distancia de al menos
15 cm entre la ranura de insercin de cintas de la
unidad y la palanca de cambios.
Instale la unidad en un lugar que no entorpezca
las operaciones de cambio de marchas o de
conduccin en general.
Cuando el panel frontal est abierto, una parte
de l sobresaldr de la unidad. Cuando instale la
unidad, compruebe que dicha parte del panel
frontal no queda obstruida en la posicin de
apertura (debido al cenicero, por ejemplo).
Elija cuidadosamente el lugar de montaje de
forma que la unidad no interfiera las funciones
normales de conduccin.
Evite instalar la unidad donde pueda quedar
sometida a altas temperaturas, como a la luz
solar directa o al aire de calefaccin, o a polvo,
suciedad, o vibraciones excesivas.
Para realizar una instalacin segura y firme,
utilice solamente la ferretera de montaje
suministrada.
Om du monterar annan Sony-utrustning till

denna enhet r det bst att montera denna enhet
i det undre lget.
Fr att du ska kunna stta i och ta ut bandet
mste avstndet vara minst 15 cm mellan
kassettfacket p enheten och vxelspaken. Nr
du installerar enheten vljer du en plats s att
enheten inte r i vgen nr du kr.
Nr frontpanelen r ppen befinner sig en liten
del av den under enhetens bottenplan. Se till att
du installerar enheten s att den hr delen gr fri
(frn t.ex. askkoppen) nr frontpanelen r
ppen.
Var noga nr du vljer var i bilen du monterar
bilstereon, s att den inte sitter i vgen nr du
kr.
Montera inte bilstereon dr den utstts fr
vrme,
t ex solsken eller varmluft, eller dr den utstts
fr damm, smuts och/eller vibrationer.
Anvnd endast de medfljande
monteringstillbehren fr att vara sker p att
bilstereon monteras p ett skert och korrekt
stt.
prefervel montar este aparelho na posio

mais baixa, se quiser montar simultaneamente
outros equipamentos da Sony.
Para colocar com facilidade a cassete, deve haver
uma distncia de pelo menos 15 cm entre a
ranhura de introduo da cassete e a alavanca
das mudanas.
Escolha o local de instalao de forma a que o
aparelho no interfira com as mudanas de
velocidade ou com as outras manobras de
conduo.
Quando o painel frontal estiver aberto, pode
puxar a parte extensvel baixo. Quando instalar
a unidade, verifique se essa parte do painel
frontal no est presa na posio aberta (pelo
cinzeiro, por exemplo).
Escolha com cuidado um local apropriado para
a montagem do aparelho, para que este no
interfira com as manobras necessrias
conduo do veculo.
Evite instalar o aparelho onde possa estar sujeito
a altas temperaturas, como em locais expostos
directamente luz do sol, ao ar quente dos
aquecimentos, ou sujeitos a p, sujidade ou
vibrao excessiva.
Para efectuar uma instalao segura utilize
unicamente o hardware de montagem fornecido.
Mounting angle adjustment

Adjust the mounting angle to less than 20.
Tillten monteringsvinkel
Ajuste del ngulo de montaje
Monteringsvinkeln fr inte vara strre n 20

grader.
Ajuste el ngulo de montaje a menos de 20.
Ajuste do ngulo de montagem

Ajuste o ngulo de montagem a menos de 20.
Extended portion of the front panel.

Parte sobresaliente del panel frontal.
Utskjutande del av frontpanelen.
Parte extensvel do painel frontal.
8.5 mm
15 cm
15.5 mm
Installation in the dashboard
Instalacin en el salpicadero
Montera p instrumentbrdan
Instalao no tablier
Dashboard
Salpicadero
Instrumentbrda
Tablier
Fire wall
Panel cortafuegos
Brandsker
mellanvgg
Painel corta-fogo
1
4
5
5
Bend these claws outward
for a tight fit, if necessary.
Si es necesario, doble estas

uas hacia afuera para que
encaje firmemente.
7
2
Fr att f en tt passning
bj dessa flikar vid behov.
Se necessrio,dobre as
unhas para prender melhor.
With the UP marking up

Con la marca UP hacia arriba
Med mrkningen UP vnd uppt
Com a marca UP para cima
Note
To prevent malfunction, install only with the supplied
screws 5.
Nota
Para evitar fallos de funcionamiento, realice la
instalacin nicamente con los tornillos suministrados
5.
Observera
Anvnd bara de medfljande skruvarna 5, s
undviker du ondiga fel.
Nota
Para evitar avarias, instale o aparelho apenas com os
parafusos fornecidos 5.
Reset button
Botn de restauracin
Nollstllningsknappen
Boto de reinicializao
When the installation and connections are

complete, be sure to press the reset button with a
ballpoint pen, etc.
Cuando finalice la instalacin y las conexiones,

cercirese de pulsar el botn de restauracin con
un bolgrafo, etc.
Kom ihg att anvnda en penna eller ngot annat

spetsigt freml fr att trycka p
nollstllningsknappen nr anslutningen och
monteringen r klar.
Quando terminar a instalao e as ligaes, no se

esquea de carregar no boto de reinicializao
com a ponta de uma caneta, esferogrfica, etc.
(XR-M550)
(XR-M500R)
Connections
Conexiones
Anslutning
Ligaes
Cautions
Precauciones
Skerhetsfreskrifter
Cuidado
This unit is designed for negative earth 12 V DC

operation only.
Be careful not to pinch any wires between a
screw and the body of the car or this unit or
between any moving parts such as the seat
railing, etc.
Connect the power connecting cord 8 to the
unit and speakers before connecting it to the
auxiliary power connector.
Run all earth wires to a common earth point.
Connect the yellow cord to a free car circuit
rated higher than the units fuse rating. If you
connect this unit in combination with other
stereo components, the car circuit they are
connected to must be rated higher than the sum
of the individual components fuse rating. If
there are no car circuits rated as high as the
units fuse rating, connect the unit directly to the
battery. If no car circuits are available for
connecting this unit, connect the unit to a car
circuit rated higher than the units fuse rating in
such a way that if the unit blows its fuse, no
other circuits will be cut off.
Esta unidad ha sido diseada para alimentarse

con 12 V CC, negativo a masa, solamente.
Tenga cuidado de no atrapar ningn cable entre
algn tornillo y la carrocera del automvil o
esta unidad o entre las partes mviles, como por
ejemplo los rales del asiento, etc.
Conecte el cable de conexin de alimentacin 8
a la unidad y los altavoces antes de conectarlo al
conector de alimentacin auxiliar.
Conecte todos los conductoresde puesta a
masa a un punto comn.
Conecte el cable amarillo a un circuito libre del
automvil de potencia nominal superior a la del
fusible de la unidad. Si conecta esta unidad en
combinacin con otros componentes estreo, la
potencia nominal del circuito del automvil a los
que dichos componentes estn conectados debe
ser superior a la suma de la potencia nominal
del fusible de los componentes. Si no existen
circuitos de automvil de potencia nominal tan
alta como la del fusible de la unidad, conecte
sta directamente a la batera. Si no hay circuitos
de automvil disponibles para conectar esta
unidad, conecte la misma a un circuito de
automvil de potencia nominal superior a la del
fusible de la unidad de forma que no se
desactiven otros circuitos si el fusible de dicha
unidad se funde.
Denna bilstereo r endast avsedd fr anslutning

till ett negativt jordat, 12 V bilbatteri.
Var noga med att inga kablar klms mellan
ngon skruv eller att de blir klmda mellan
rrliga delar som t.ex. bilstet.
Anslut strmkabeln 8 till enheten och
hgtalarna innan du ansluter den till den yttre
strmanslutningen.
Dra samtliga jordledningar till en och samma
jordningspunkt.
Anslut den gula kabeln till en ledig bilkrets med
ett hgre amperetal n enhetens. Om du kopplar
bde denna enhet och andra stereokomponenter
till en och samma bilkrets, mste den bilkrets de
kopplas till ha en hgre ampere n summan av
de enskilda delarnas amperestyrka. Om det inte
finns ngra bilkretsar med en s hg
amperestyrka som enhetens ska du ansluta
enheten direkt till batteriet. Om inga bilkretsar
finns fr anslutning till enheten ska du ansluta
enheten till en bilkrets med ett hgre amperetal
n enhetens skring, s att det r denna som gr
i stllet fr bilens.
Este aparelho foi concebido para funcionar

somente com corrente contnua de 12 V com
negativo massa.
Tenha cuidado para que os fios no fiquem
entalados entre os parafusos e a carroaria do
automvel ou a caixa do aparelho, nem entre as
peas mveis, por exemplo, as calhas dos
bancos, etc.
Ligue o cabo de alimentao de corrente 8 ao
aparelho e aos alifalantes antes de o ligar ao
conector de corrente auxiliar.
Ligue todos os cabos de massa num ponto de
massa comum.
Ligue o cabo amarelo a um circuito elctrico
livre do automvel, cuja potncia nominal seja
superior dos fusveis do aparelho. Se ligar este
aparelho em srie com outros componentes
estreo, a potncia nominal do circuito elctrico
do automvel onde os ligar tem de ser superior
soma da potncia nominal dos fusveis de
todos os componentes individuais. Se no
houver nenhum circuito elctrico do automvel
com uma potncia nominal to elevada como a
dos fusveis do aparelho, ligue-o directamente
bateria. Se no estiver disponvel nenhum
circuito elctrico do automvel para ligao
deste aparelho, ligue-o a um circuito elctrico do
automvel com uma potncia nominal superior
dos fusveis do aparelho, de tal modo que, se o
aparelho rebentar os fusveis respectivos,
nenhum outro circuito seja cortado.
Warning when installing in a car

without ACC (accessory) position
on the ignition key switch
Advertencia sobre la instalacin

en un automvil que no
disponga de posicin ACC
(accesorios) en el interruptor de
la llave de encendido
Var frsiktig nr du gr
installationen i en bil dr
tndningslset saknar
tillbehrslge (ACC)
Aviso sobre a instalao num

automvel sem posio ACC
(acessrios) na chave de ignio
Be sure to press (OFF) on the unit for two

secondsto turn off the clock display after
turned off the engine.
When you press (OFF) momentarily, the clock
display does not turn off and this causes battery
wear.
Asegrese de pulsar (OFF) en la unidad

durante dos segundos para desactivar la
indicacin del reloj una vez apagado el motor.
Si pulsa (OFF) momentneamente, la indicacin
del reloj no se desactivar y esto causar el
desgaste de la batera.
Notes of connection example
Notas de ejemplo de conexiones
Notes on the control leads

The power aerial control lead (blue) supplies +12 V
DC when you turn on the tuner or when you
activate the ATA (Automatic Tuner Activation), AF
(Alternative Frequency) or the TA (Traffic
Announcement) function.
A power aerial without a relay box cannot be used
with this unit.
When your car has a built-in FM/MW/LW aerial in
the rear/side glass, it is necessary to connect the
power aerial control lead (blue) or the accessory
power input lead (red) to the power terminal of the
existing aerial booster. For details, consult your
dealer.
Notas sobre cables de control

El cable de control (azul) de la antena motorizada
suministra + 12 V CC al activar el sintonizador o la
funcin ATA (activacin automtica del
sintonizador), AF (frecuencias alternativas) o TA
(anuncios de trfico).
Con esta unidad no podr utilizarse una antena
motorizada sin caja de rels.
Si el automvil dispone de antena de FM/MW/LW
incorporada en el cristal trasero/lateral, ser
necesario conectar el cable de control de antena
motorizada (azul) o el cable de entrada de
alimentacin accesoria (rojo) al terminal de potencia
del amplificador de antena existente. Para ms
informacin, consulte con el proveedor.
Warning
If you have a power aerial without a relay box,
connecting this unit with the supplied power
connecting cord 8 may damage the aerial.
Advertencia
Si dispone de una antena motorizada sin dispositivo
de rel, la conexin de esta unidad con el cable de
conexin de alimentacin 8 suministrado puede
daar la antena.
Memory hold connection

When the yellow power input lead is connected,
power will always be supplied to the memory circuit
even when the ignition switch is turned off.
Notes on speaker connection
Before connecting the speakers, turn the unit off.
Use speakers with an impedance of 4 to 8 ohms, and
with adequate power handling capacities.
Otherwise, the speakers may be damaged.
Do not connect the terminals of the speaker system
to the car chassis,and do not connect the terminals
of the right speaker with those of the left speaker.
Do not attempt to connect the speakers in parallel.
Do not connect any active speakers (with built-in
amplifiers) to the speaker terminals of the unit.
Doing so may damage the active speakers. Be sure
to connect passive speakers to these terminals.
Conexin para proteccin de la memoria

Si conecta el cable de entrada de alimentacin
amarillo, el circuito de la memoria recibir siempre
alimentacin, incluso aunque ponga la llave de
encendido en la posicin de apagado.
Notas sobre la conexin de los altavoces
Antes de conectar los altavoces, desconecte la
alimentacin de la unidad.
Utilice altavoces con una impedancia de 4 a
8 ohmios, y con la potencia mxima admisible
adecuada, ya que de lo contrario podra daarlos.
No conecte los terminales del sistema de altavoces al
chasis del automvil, ni los del altavoz izquierdo a
los del derecho.
No intente conectar los altavoces en paralelo.
No conecte altavoces activos (con amplificadores
incorporados) a los terminales de altavoces de la
unidad. Si lo hiciese, podra daar tales altavoces.
Por lo tanto, cercirese de conectar altavoces pasivos
a estos terminales.
Glm inte att trycka p (OFF) p enheten

under tv sekunder fr att stnga av klockans
teckenfnster efter det att du har stngt av
motorn.
Om du bara trycker p (OFF) ett kort gonblick
slocknar inte klockans teckenfnster vilket kan
leda till att batteriet laddas ur.
Verifique se carregou em (OFF) no aparelho

durante dois segundos para desactivar o visor
do relgio depois de ter desligado o motor.
Se carregar ligeiramente em (OFF), no desactiva
o visor do relgio o que provoca o desgaste da
bateria.
Att observera angende

anslutningsexemplen
Notas sobre o exemplo de

ligao
Att observera angende de olika styrkablarna

Motorantennens styrkabel (bl) leder + 12 volts
likstrm nr kanalvljaren sls p eller nr
radiomottagningsautomatik ATA, mottagning av
alternativa frekvenser AF eller mottagning av
trafikmeddelanden TA aktiverats.
En motorantenn utan styrreldosa kan inte anslutas
till denna bilstereo.
Om bilen har en FM/MW/LW-antenn som r inbyggd
i sido- eller bakrutan, mste du ansluta
motorantennens styrkabel (bl) eller
tilbehrsstrmkabeln (rd) till strmterminalen p
antennfrstrkaren. Din terfrsljare kan ge dig
mer information.
Notas sobre os fios de controlo

O fio de controlo da antena elctrica (azul) fornece
+12 V CC quando ligar o sintonizador ou quando
activar as funes ATA (Activao automtica do
sintonizador), AF (frequncia alternativa) ou TA
(Informaes de trnsito).
No pode utilizar uma antena elctrica sem caixa de
rel com este aparelho.
Se o seu automvel tiver uma antena de FM/MW/LW
montada no vidro traseiro/lateral, tem de ligar o fio
de controlo da antena elctrica (azul) ou o fio de
entrada de alimentao para os acessrios
(vermelho) ao terminal de alimentao do
intensificador do sinal da antena existente.
Varning
Om du har en motorantenn utan reldosa kan
antennen skadas om du ansluter enheten med den
medfljande strmkabeln 8.
Advertncia
Se a antena elctrica no tiver uma caixa de rel, o
facto de ligar este aparelho com o cabo de
alimentao 8 fornecido, pode provocar danos na
antena.
Anslutning fr minnesstd
Nr du anslutit den gula, ingende strmkabeln
frsrjs minneskretsen med strm hela tiden, ven nr
tndlset sls ifrn.
Att observera angende hgtalarnas anslutning
Sl av bilstereon innan du ansluter hgtalarna.
Anslut endast hgtalare, vars impedans varierar frn
4 till 8 ohm och som har tillrcklig
effekthanteringskapacitet fr att skydda hgtalarna
mot skador.
Anslut inte ngot av hgtalaruttagen till bilens
chassi. Anslut inte heller uttagen p hger hgtalare
till uttagen p vnster hgtalare.
Anslut inte hgtalarna parallellt.
Anslut inte aktiva hgtalare (med inbyggda slutsteg)
till bilstereons hgtalaruttag, eftersom de kan skada
de aktiva hgtalarna. Var noga med att bara ansluta
passiva hgtalare till dessa uttag.
Ligao para alimentao contnua da memria

Quando o fio amarelo de entrada de alimentao for
ligado, os circuitos de memria ficaro com
alimentao continua, mesmo se a chave de ignio
estiver desligada.
Notas sobre a ligao dos altifalantes
Antes de ligar os altifalantes, desligue o aparelho.
Utilize altifalantes com impedncia de 4 a 8 ohm, e
com potncia mxima admissvel adequada. Caso
contrrio, os altifalantes podero sofrer avarias.
No ligue os terminais do sistema de altifalantes ao
chassisdo automvel, e no ligue os terminais do
altifalante direito aos terminais do altifalante
esquerdo.
No tente ligar os altifalantes em paralelo.
No ligue nenhum sistema de altifalantes activos
(com amplificadores incorporados) aos terminais dos
altifalantes do aparelho. Caso o faa, poder avariar
o sistema de altifalantes activos. Portanto, no se
esquea de ligar altifalantes passivos a estes
terminais.
Connection example
Ejemplo de conexiones
Anslutningarna enligt exemplet
Exemplo de ligaes
*1 Note for the aerial connecting

If your car aerial is an ISO (International
Organisation for Standardisation) type, use the
supplied adaptor 6 to connect it.
First connect the car aerial to the supplied adaptor,
then connect it to the aerial jack of the master unit.
*2 RCA pin cord (not supplied)
*1 Nota sobre la conexin de la antena

Si la antena del automvil es del tipo ISO
(International Organization for Standardization),
emplee el adaptador suministrado 6 para
conectarla.
En primer lugar, conecte la antena del automvil al
adaptador suministrado y, a continuacin, a la
toma de antena de la unidad principal.
* Cable con clavijas RCA (no suministrado)
*1 Angende antennanslutning
Om motorantennen r av ISO-typ (International
Organization for Standardization), anvnder du
medfljande adapter 6 fr att ansluta den.
Anslut frst motorantennen till medfljande
adapter och drefter till antennuttaget p
huvudenheten.
*2 Kabel med RCA-kontakter (medfljer inte)
*1 Nota referente ligao da antena

Se a antena do automvel for uma antena de tipo
ISO (International Organization for
Standardization), utilize o adaptador fornecido 6
para fazer a ligao respectiva.
Ligue primeiro a antena do automvel ao
adaptador fornecido e depois ficha tipo jack de
antena do sistema principal.
*2 Cabo de terminais RCA (no fornecido)
*2
Source selector
(not supplied)
Selector de fuente
(no suministrado)
Supplied to the CD/MD changer

Suministrado con el cambiador de CD/MD
Medfljer CD/MD-vxlaren
Fornecido para o permutador de CD/MD
Vljare fr ljudklla
(medfljer inte)
Selector de fonte
(no fornecido)
XA-C30
Supplied to XA-C30
Suministrado con el XA-C30
Medfljer XA-C30
Fornecido para o XA-C30
BUS AUDIO IN
from car aerial*1
de la antena del automvil*1
frn bilantenn*1
da antena do automvel*1
Rotary commander RM-X4S (not supplied)

Mando rotativo RM-X4S (no suministrado)
Vridkontroll RM-X4S (medfljer inte)
Comando rotativo RM-X4S (no fornecido)
AUDIO OUT FRONT

REMOTE IN
Insert with the cord upwards.

Insertar con el cable hacia arriba.
Stt in med kabeln vnd uppt.
Inserir com o fio virado para cima.
BUS
CONTROL IN
AUDIO OUT REAR
8
Fuse (10 A)
Fusible (10 A)
Skring (10 A)
Fusivel (10 A)
Blue/white striped
Con raya azul/blanca
Bl/vit-randig
Azul com listras brancas
AMP REM
Max. supply current 0.3 A

Corriente mx. de alimentacin de 0,3 A
Maximal strmtillfrsel 0,3 A
Corrente mxima de 0,3 A
Light blue
Azul celeste
Ljusbl
Azul claro
to the interface cable of a car telephone

al cable de interfaz de un telfono para
automvil
ATT
WARNING
VARNING
Auxiliary power connectorsmay vary depending on

the car. Be sure to check the power connection
diagram. Improper connections may damage your
car. If the supplied power connecting cord can not
be used with your car, consult your nearest Sony
dealer.
Typen av yttre strmanslutning varierar frn bil till

bil. Kontrollera strmanslutningsschemat som
medfljer enheten s att du ansluter p rtt stt.
Felaktig anslutning kan skada bilen. Kontakta
nrmaste Sony-terfrsljare om den medfljande
strmkabeln inte passar till din bil.
ADVERTENCIA
ADVERTNCIA
Los conectoresde alimentacin auxiliar pueden

variar en funcin del automvil. Asegrese de
consultar el diagrama de conexin de alimentacin.
Las conexiones incorrectaspueden daar el
automvil. Si no es posible utilizar con el automvil
el cable de conexin de alimentacin suministrado,
pngase en contacto con el proveedor Sony ms
prximo.
till mobiltelefonens grnssnittskabel

Ao cabo de interface de um telefone para
automvel
to a cars auxiliary power connector

a un conector de alimentacin auxiliar del automvil
till bilens yttre strmanslutning.
a um conector de alimentao auxiliar do automvel
to a cars speaker connector

a un conector de altavoces del automvil
till bilens hgtalaranslutning
ao conector de um altifalante do automvel
Purple
Prpura
Violett
Violeta
Grey
Gris
Gr
Cinzento
Speaker, Rear, Right

Altavoz, parte posterior, derecho
Hgtalare, bakre, hger
Altifalante, Parte de trs, Direito
Speaker, Rear, Right

Altavoz, parte posterior, derecho
Hgtalare, bakre, hger
Altifalante, Parte de trs, Direito
Speaker, Front, Right

Altavoz, parte frontal, derecho
Hgtalare, frmre, hger
Altifalante, Parte da frente, Direito
Speaker, Front, Right

Altavoz, parte frontal, derecho
Hgtalare, frmre, hger
Altifalante, Parte da frente, Direito
Os conectoresde corrente auxiliares podem variar

de carro para carro. No se esquea de verificar o
diagrama de ligao de corrente fornecido com o
aparelho. As ligaes mal executadas podem
danificar o seu carro. Se no puder utilizar o cabo
de alimentao fornecido no seu carro, contacte o
agente Sony da sua zona.
White
Blanco
Vit
Branco
Green
Verde
Grn
Verde
Speaker, Front, Left

Altavoz, parte frontal, izquierdo
Hgtalare, frmre, vnster
Altifalante, Parte da frente, Esquerdo
Yellow
Amarillo
Gul
Amarelo
continuous power supply

suministro de alimentacin continua
kontinuerlig strmfrsrjning
alimentao de corrente contnua
Red
Rojo
Rd
Vermelho
switched power supply

suministro conmutado de alimentacin
switchad strmfrsrjning
alimentao de corrente comutada
Speaker, Front, Left

Altavoz, parte frontal, izquierdo
Hgtalare, frmre, vnster
Altifalante, Parte da frente, Esquerdo
Blue
Azul
Bl
Azul
power aerial control

control de antena motorizada
styrning av motorantenn
antena elctrica
Black
Negro
Svart
Preto
earth
toma de tierra
jord
Terra
Speaker, Rear, Left

Altavoz, parte posterior, izquierdo
Hgtalare, bakre, vnster
Altifalante, Parte de trs, Esquerdo
Speaker, Rear, Left

Altavoz, parte posterior, izquierdo
Hgtalare, bakre, vnster
Altifalante, Parte de trs, Esquerdo
Orange/
switched illumination power supply
White
fuente de alimentacin de iluminacin
Naranja/
conmutada
6
blanco
Switchad strmfrsrjning till belysning
Orange/vit
fonte de alimentao comutada para
Cor de laranja/
iluminao
branco
Positions 1, 2 and 3 do not have pins.

Las posiciones 1, 2 y 3 no disponen de terminales.
Positionerna 1, 2 och 3 saknar stift.
As posies 1, 2 e 3 no tm terminais.
Negative polarity positions 2, 4, 6, and 8 have striped cords.

Las posiciones de polaridad negativa 2, 4, 6 y 8 tienen cables con raya.
De negativa polpositionerna 2, 4, 6 och 8 har randiga kablar.
As posies 2, 4, 6 e 8 (polaridade negativa) tm cabos s riscas.
Power connection diagram

Auxiliary power connector may vary depending
on the car. Check your cars auxiliary power
connector diagram to make sure the connections
match correctly. There are three basic types
(illustrated below). You may need to switch the
positions of the red and yellow leads in the car
stereos power connecting cord.
After matching the connections and switched
power supply leads correctly, connect the unit to
the cars power supply. If you have any questions
and problems connecting your unit that are not
covered in this manual, please consult the car
dealer.
Diagrama de conexin de
alimentacin
El conector de alimentacin auxiliar puede variar
en funcin del automvil. Compruebe el
diagrama del conector de alimentacin auxiliar
del automvil para asegurarse de que las
conexiones coinciden correctamente. Existen tres
tipos bsicos, ilustrados a continuacin. Es posible
que sea necesario cambiar las posiciones de los
cables rojo y amarillo del cable de conexin de
alimentacin del sistema estreo del automvil.
Despus de hacer coincidir correctamente las
conexiones y los cables de alimentacin
conmutada, conecte la unidad al suministro de
alimentacin del automvil. Si desea realizar
alguna consulta o solucionar algn problema
referentes a la conexin de la unidad que no
aparezcan en este manual, consulte con el
concesionario automovilstico.
Strmanslutningsschema
Diagrama de ligao de corrente
Typen av yttre strmanslutning varierar frn bil

till bil. Kontrollera schemat till strmanslutningen
s att du ansluter p rtt stt. Det finns tre
grundlggande anslutningstyper (visas nedan).
Du kan behva skifta plats p bilstereons rda och
gula strmfrsrjningskablar.
Koppla kablarna fr kontinuerlig respektive
switchad strmfrsrjning p rtt stt och anslut
sedan enheten till bilens strmanslutning. Om du
fr problem eller har frgor som inte besvaras i
den hr bruksanvisningen kan du kontakta
bilterfrsljaren.
O conector auxiliar de corrente pode variar de

carro para carro. Verifique o diagrama do
conector auxiliar de corrente para se certificar de
que as ligaes esto bem feitas. Existem trs tipos
de conectores (ilustrados abaixo).
Depois de fazer a correspondncia entre as
ligaes e os terminais de alimentao de corrente
comutada, ligue o aparelho fonte de alimentao
do carro. Se tiver alguma dvida ou problema
relacionado com o aparelho que no esteja
includo neste manual, consulte o concessionrio.
Red
Rojo
Rd
Red
Rojo
Rd
Vermelho
Auxiliary power connector

Conector de alimentacin auxiliar
Yttre strmanslutning
Conector de corrente auxiliar
Red
Rojo
Rd
Vermelho
Yellow
Amarillo
Gul
Amarelo
10
Red
Rojo
Rd
Vermelho
Yellow
Amarillo
Gul
Amarelo
Yellow
Amarillo
Gul
Amarelo

Red
Rojo
Rd
Vermelho

Yellow
Amarillo
Gul
Amarelo
Yellow
Amarillo
Gul
Amarelo
Red
Rojo
Rd
Vermelho
Red
Rojo
Rd
Vermelho
Yellow
Amarillo
Gul
Amarelo

Red
Rojo
Rd
Vermelho

the car without ACC position

automvil sin posicin ACC
bil utan ACC-lge
o carro sem posio ACC
Yellow
Amarillo
Gul
Amarelo
Yellow
Amarillo
Gul
Amarelo
Connection diagram
Diagrama de conexiones
Equipmentused in illustrations
(not supplied)
Front speaker
Altavoz delantero
Frmre hgtalare
Altifalante dianteiro
For connecting two or more CD/MD changers, the

source selector XA-C30 (optional) is necessary.
Equipo utilizado en las ilustraciones

(no suministrado)
Kopplingsschema
Utrustning som visasi illustrationer
(medfljer inte)
Equipamento utilizadonas ilustraes

(no fornecido)
Power amplifier
Amplificador de potencia
Effektfrstrkare
Amplificador de potncia
Rear speaker
Altavoz trasero
Bakre hgtalare
Altifalante traseiro
Si desea conectar dos o ms cambiadores, necesitar el

selector de fuente XA-C30 (opcional).
Diagrama de ligaes
CD/MD changer
Cambiador de CD/MD
CD/MD-skivvxlare
Permutador CD/MD
Fr anslutning av tv eller flera vxlare krvs vljarna

XA-C30 (tillval).
Para ligar um ou mais permutadores, necessrio o

selector de fonte XA-C30 (opcional).
B
BUS AUDIO IN
BUS AUDIO IN
DAB tuner unit
Sintonizador DAB
DAB-tunerenhet
Sintonizador DAB
XT-100DAB*
BUS CONTROL IN
* not supplied
no suministrado
medfljer inte
no fornecido
BUS CONTROL IN
D
BUS CONTROL IN
Digital equalizer pre-amplifier

Preamplificador ecualizador
digital
BUS
AUDIO IN
AUDIO
OUT FRONT
AUDIO OUT REAR
Source selector*
Selector de fuente *
Vljare fr ljudklla*
Selector de fonte *
BUS
CONTROL IN
Digital frfrstrkare med

equaliser
Pr-amplificador equalizador
digital
XDP-210EQ*, XDP-4000X*
AUDIO OUT
REAR
* not supplied
no suministrado
medfljer inte
no fornecido
Note
Be sure to connect the earth cord before
connecting the amplifier.
Obsevera
Var noga med att frst ansluta jorden, innan du
ansluter frstrkaren.
Nota
Asegrese de conectar primero el cable de puesta a
masa antes de realizar la conexin al amplificador.
Nota
Antes de fazer a ligao ao amplificador tem de ligar
primeiro o cabo de ligao massa.
* not supplied
no suministrado
medfljer inte
no fornecido
When connecting a digital equalizer pre-amplifier

(XDP-210EQ, XDP-4000X)
Use an optional exterior amplifier. The built-in
amplifier of this unit can not be used in this case. For
details, refer to the Installation/Connections manual
XDP-210EQ, XDP-4000X.
For details about the connection, refer to the
Instllation/Connections manual XDP-210EQ, XDP4000X. (not supplied)
Nr du ansluter en digital frfrstrkare med

equaliser (XDP-210EQ, XDP-4000X.)
Anvnd en valfri extern frstrkare. Den inbyggda
frstrkaren kan inte anvndas i detta fall. Mer
information finns i Montering/
Anslutninghandboken XDP-210EQ, XDP-4000X.
Mer information om hur du ansluter utrustning
finns i Montering/Anslutninghandboken
XDP-210EQ, XDP-4000X. (medfljer inte)
Si conecta un preamplificador ecualizador digital

(XDP-210EQ, XDP-4000X.)
Utilice un amplificador opcional externo. El
amplificador incorporado de esta unidad no puede
utilizarse en este caso. Para ms informacin, consulte
el manual de instalacin/conexiones de la unidad XDP210EQ, XDP-4000X.
Para obtener informacin detallada sobre la conexin,
consulte el manual de instalacin/conexiones de la
unidad XDP-210EQ, XDP-4000X. (no suministrada)
Se ligar um pr-amplificador equalizador digital

(XDP-210EQ, XDP-4000X.)
Utilize um amplificador exterior opcional. O
amplificador integrado neste aparelho no pode
ser utilizado neste caso. Para obter mais
informaes, consulte o manual de Instalao/
Ligaes XDP-210EQ, XDP-4000X.
Para obter mais informaes sobre a ligao,
consulte o manual de Instalao/ Ligaes do
XDP-210EQ, XDP-4000X. (no fornecido)
11
(XR-M550)
12
13
14
SECTION 3
DISASSEMBLY
See page 3 for Servicing Notes.
Note: Follow the disassembly procedure in the numerical order given.
MECHANISM DECK (MG-25E-136)
1 screw
flexible board
Note: Don't pull out flexible board
from front panel assy.
2 front panel ass'y
1 screw
4 two screws
5 mechanism deck
(MG-25E-136)
3 connector
(CN400)
3 flexible board
(CN401)
4 two screws
(PTP2.6 6)
15
FRONT PANEL ASSY

1 cover (flexible)
2 flexible board
(CN402)
Note for Installation of Flexible Board
2 flexible cover
1 Set the flexible board to

be at the position in the figure.
3 front panel ass'y
MOTOR BLOCK ASSY, CAM (R) ASSY
2 screw
(PTT2.6 8)
3 motor block ass'y
2 screw
(PTT2.6 6)
4 screw
(PTT2.6 8)
4 screw
(PTT2.6 6)
1 connector
(CN602)
5 cam (R) assy
16
SUB PANEL (XR) SUB ASSY
2 screw
(PTT2.6 6)
1 flexible board
(CN601)
3 sub panel (XR) sub ass'y
2 two screws
(PTT2.6 6)
2 screw
(PTT2.6 6)
MAIN BOARD
1 two screws
(PTT2.6 6)
1 screw
(PTT2.6 6)
2 three ground screws
3 main board
17
HEAT SINK
2 cord (with connector) (ANT)

5 cord (with connector) (SUB OUT)
6 two screws
(PTT2.6 12)
6 three screws
(PTT2.6 8)
1 connector
(CN100)
4 screw
(PTT2.6 6)
3 connector
(CN200)
6 two screws
(PTT2.6 8)
7 heat sink
18
SECTION 4
ASSEMBLY
Note: Follow the assembly procedure in the numerical order given.
4-1. FRONT PANEL MACHINERY

MOTOR BLOCK ASSY
2 stop ring
1 cam (L)
7 bracket (motor) ass'y
hole
6 washer (M)
switch
5 gear (C)
4 gear (B)
concave portion
6 washer (M)
Set bracket (motor) assy
to be at the position in the
figure.
3 gear (A)
Note: When installing cam (L), adjust the hole and concave portion.
8 two screws
(PTT2.6 6)
8 screw
(B2.6 6)
CAM (R) ASSY
2 stop ring
1 cam (R)
hole
concave portion
Note: When installing cam (R), adjust the hole and concave portion.
19
CAM (R) ASSY, MOTOR BLOCK ASSY
gray wiring
1 Supply the power to the motor.

Voltage
: 9V
Violet wiring : MOTOR
Gray wiring : MOTOR +
2 Motor stops at full open position.

violet wiring
full open position
8 screw
(PTT2.6 8)
4 screw
(PTT2.6 8)
8 screw
(PTT2.6 6)
7 connector
(CN602)
4 screw
(PTT2.6 6)
6 motor block ass'y

7 connector
(CN501)
3 cam (R) ass'y
20
4-2.
MECHANISM DECK
HOUSING
7 Holder the hanger by bending the claw.

5 Fit projection on C part.
2 Install the hanger onto
two claws of the housing.
1 Install the catch to the hanger.

hanger
4 Fit claw on B part.
3 Put the housing

under A part.
6 Fit projection on D part.
housing
C part
8 Hold the hanger by
bending the claw.
D part
A part
B part
ARM (SUCTION)
2 Move the arm (suction) in the arrow
direction and fit on projection.
projection
1 Fit the arm (suction) on the shaft.
21
LEVER (LDG-A) / (LDG-B)
shaft A
shaft A
shaft B
shaft B
shaft C
1 Fit the lever (LDG-A) on

shafts A C and install it.
3 type-E stop ring 2.0

2 Fit the lever (LDG-B) on
shafts A and B and
install it.
GEAR (LDG-FT)
gear (LDG-D)
6 polyethylene washer
hole
hole
5 gear (LDG-FT)
lever (LDG-A)
gear (LDG-FB)
4 Align hole in the gear (LDG-D)
with hole the lever (LDG-A).
1
2 tension spring (LD-2)
2 tension spring (LD-1)
22
3 Move the lever (LDG-B)

in the arrow direction.
GUIDE (C)
2 guide (C)
1 three claws
MOUNTING POSITION OF CAPSTAN/REEL MOTOR (M901)
two precision screws

(P2 2)
capstan/reel motor
(M901)
30
23
SECTION 5
MECHANICAL ADJUSTMENTS
1. Clean the following parts with a denatured-alcohol-moistened
swab:
playback head
pinch roller
rubber belt
capstan
idler
2. Demagnetize the playback head with a head demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. The adjustments should be performed with the power supply
voltage (14.4 V) unless otherwise noted.
SECTION 6
ELECTRICAL ADJUSTMENTS
TEST MODE
<Set the Test Mode>
1. Turn ON the regulated power supply. (All LEDs on the set
lights up, and the clock is displayed.)
Note: Press the [OFF] button, if the clock is not displayed.
2. Push the preset [4] button.
3. Push the preset [5] button.
4. Press the preset [1] button for more than two seconds.
5. Then the display indicates all lights, the test mode is set.
Torque Measurement
Mode
Torque Meter
Meter Reading
CQ-102C
2.95 6.73 mNm

30 65 gcm
(0.42 0.90 ozinch)
CQ-102C
0.05 0.44mNm
0.5 4.5 gcm
(0.01 0.06 ozinch)
Reverse
CQ-102RC
2.95 6.73 mNm

(25 55 gcm)
(0.42 0.90 ozinch)
Reverse
Back Tension
CQ-102RC
0.05 0.44mNm
0.5 4.5 gcm
(0.01 0.06 ozinch)
FF, REW
CQ-201B
5.89 19.61 mNm

60 200 gcm)
(0.83 2.78 ozinch)
Forward
Forward
Back Tension
Tension Meter
Forward
CQ-403A
Reverse
CQ-403R
See the adjustment location from on page 25 for the

adjustment.
TAPE DECK SECTION
0 dB=0.775 V
Tape Speed Adjustment

Setting:
test tape
WS-48A
(3 kHz, 0 dB)
set
Tape Tension Measurement

Mode
<Release the Test mode>

1. Push the [OFF] button.
Meter Reading
more than 90 g
(more than 3.18 oz)
more than 90 g
(more than 3.18 oz)
speed checker
or
frequency counter
10 k
AUDIO OUT REAR jack (CN300)
Procedure:
1. Put the set into the FWD PB mode.
2. Adjust adjustment resistor for inside capstan motor so that the
reading on the speed checker or frequency counter becomes in
specification.
Specification: Constant speed
Speed checker
Frequency counter
1.5 to +2.5%
2,955 to 3,075 Hz
Adjustment Location: See page 25.
24
Dolby Level Adjustment

Setting:
[SOURCE] button
: ON
Preset [MENU] (PLAY MODE) and
[DISC ] buttons
: NR off
[SOUND] (BAS) button
: Center
[SOUND] (TRE) button
: Center
[SOUND] (BAL) button
: Center
[SOUND] (FAD) button
: Center
[+] (VOL) button
: Maximum
Adjustment Location:
SET UPPER VIEW
TUX100
MAIN board
test tape
P-4-D400
TP (DOLBY-L)/
(400Hz, 0 dB) TP (DOLBY-R) level meter
Tape Speed
Adjustment
set
Procedure:
1. Put the set into the FWD PB mode.
2. Adjust RV400 (L-CH) and RV401 (R-CH) so that the level
meter reading is 60.5 dB (0.37 to 0.41 V).
RV401
Dolby Level
Adjutment (R-ch)
TUNER SECTION
Tuner section adjustments are done automatically in this set.
RV400
Dolby Level
Adjutment (L-ch)
SET BOTTOM VIEW
TP (DOLBY-R)
Dolby Level
Adjustment
TP (DOLBY-L)
25
MEMO
26
XR-M500R/M550
SECTION 7
DIAGRAMS
7-1.
BLOCK DIAGRAM TUNER/TAPE Section

BACKUP +5V
D101
TUNER VCC
TUNER +5V
BU 5V
2 FM-ANT
16
VCC
11
(FM/AM ANTENNA)
VDD
FM/AM TUNER UNIT

TUX100
MPX
MPX 10
AM-ANT
FM AGC
S-METER
RDSDET
SDA
SCL
AM-IF
17 18
14
12 13
19
AM-DET
AM
8
MUTING
Q102
D102
DATA
CLOCK
TAPE L
27
TAPE
IN1
R-CH
19
18
16
17
SC
57 kHz
OUT
18
16
BAND-PASS
MPX
FILTER
14
MS
OUT
MULTI
PATH
DETECTOR
CIN
SIGNAL
QUALITY
DECODER
CLOCKED
COMPARATOR
(Page 28)
(Page 28)
(Page 28)
(Page 28)
5
4
RDS/RDBS
DEMODULATOR
& DECODER
INTERFACE
REGISTER
IIC BUS
SLAVE
TRANSCEIVER
SCL
10
SDA
9
BUFFER
Q750
OSCILLATOR
& CLOCK
OSCI
20
LVIN
19
MSSW
DOLBY
R-CH
INSW
TAPESW
REV
R-CH
AMS
DET
PBR
IN1
DRSW
32
RDS DECODER
IC700
24
R-CH
R-CH
R-CH
R-CH
LINE
OUT1
DOLBY
NR AMP
MUTE
DAVN
29
OSCO
PB
OUT1
R-CH
REV
L-CH
(Page 28)
DATA
RV400
DOLBY LEVEL (L)
PBF
IN1
EQ AMP
FWD
R-CH
(XR-M500R)
MPTH
34
DATA,CLOCK
CLOCK
TAPE EQUALIZER AMP,

DOLBY NR AMP, AMS
IC401
FWD
L-CH
MUTING CONTROL
SWITCH
Q105
AM-IF
HP901
(PLAYBACK)
(Page 28)
MUTING
Q101
E2P-SIO
E2P-CKO
BAND-PASS
FILTER
IC750
20
NOISE DET
DISCHARGE
SWITCH
Q751
X700
4.332MHz
MUTE
SWITCH
Q404
10 11
51
53
MTLOUT
DOLBY
AMSON
AMSIN
E2P-SIO
E2P-CKO
FM AGC
VSM
LM-LOD
LM-EJ
TAPEON
64 67
REGULATOR
Q400
05
BATT B+
Q403
LOADING/TAPE
OPERATION
9
7
OUT1
OUT2
IN1
MOTOR
DRIVE
IN2
REEL
CM-ON
POS0 POS3
59
57
TAPE OPERATION
SWITCH
BUFFER
50
56
32
BATT B+
REGULATOR
CONTROL SWITCH
Q401
VCC
SYSTEM CONTROLLER
IC601 (1/4)
61 60
M901
(CAPSTAN/REEL)
75
62
REEL SENSOR B+
CAPSTAN/REEL
MOTOR DRIVE
Q402
52
TUNATT
NS MASK
QUALITY
120
DAVN
23
MPTH
7
N-ROUT
LEVEL
EJECT/FF/REW/
REV/FWD MODE DETECT
3
4
TAPE
DETECT
TAKE-UP
REEL
SENSOR
SUPPLY
REEL
SENSOR
SIGNAL PATH
: FM
: AM (MW/LW)
: TAPE PLAY
LOADING/TAPE OPERATION
MOTOR DRIVE
IC400
REEL SENSOR BOARD
27
27
XR-M500R/M550
SIGNAL PATH
: FM
7-2. BLOCK DIAGRAM MAIN Section
: AM (MW/LW)
: TAPE PLAY
: BUS AUDIO IN
CN300 (1/2)
BUS
AUDIO IN
INPUT SELECT, FM MPX,

ELECTRICAL VOLUME
IC100
SPEANA
(Page 29)
(XR-M500R)
R-CH
(Page 27)
11
4
(Page 27)
SEL
AM
FD1L
TAPE L
TONE
CONTROL
SOFT
MUTE
LOUDNESS
VOLUME
OUTPUT
SELECTOR
1
AM
INPUT
MULTIPLEXER
LOUDNESS
MUTE
MONO
FADER
MIXER
OUTSSL
24
OUTSSR
23
OUT LF
30
OUT LR
29
OUTSWL
SUBWOOFER
+PHASE CONTROL
MONO
FADER
OUTSWR
CN300 (2/2)
(XR-M550)
LINE DRIVER
IC200
26
R-CH
25
R
MUTING
Q251
(XR-M500R)
AM-IF
12
MPX
AMIF
AM/FM NOISE
BLANKER
13
L.P.F
MPX
D203
DEMODULATOR
STEREO ADJUST
STEREO BLEND
PILOT
CANCELATION
S&H
(Page 27)
L.P.F.
(Page 27)
AUDIO OUT
FRONT
MUTING
Q250
HIGHCUT
R-CH
R-CH
R
D204
MUTING
Q201
PILOT DET
20 21
LINE DRIVER
IC200
QUAL
17
(L)
SUB OUT
(MONO)
18
LEVEL
MPIN
MUTING
Q204
SM
SCL
SDA
IIC BUS
(XR-M550)
D/A
CONVERTER
PLL
QUALITY
DIGITAL
CONTROL
AUDIO OUT
REAR
MUTING
Q200
R-CH
(R)
D200
MUTING
Q254
14 15
CN200
CN301 (1/2)
(POWER CONNECTOR)
POWER AMP
IC300
(Page 27)
LEVEL
1
OUT2+ 5
FL+
12 IN2
9
OUT2 3
FL
4
OUT4+ 21
FR+
14 IN4
12
OUT4 23
DATA, CLOCK
DATA
OUT1+ 9
CLOCK
RL+
11 IN1
10
OUT1 7
RL
3
RR+
OUT3+ 17
OUT3 19
STBY
31
11
MUTE
70 71
VOL ATT
15 IN3
IIC-SCL
IIC-SDA
(Page 27)
FR
22
RR
15
TEST
TESTIN 84
13
LEVEL SHIFT
Q603
TEL-MUTE 16
TEL-ATT
SYSTEM CONTROLLER
IC601 (2/4)
AMP ON
ST-BY 55
(Page 30)
(Page 29)
AMP MUTING
SWITCH
Q222
MUTE
BATT
B+
MUTE
D205
BATTERY OFF
MUTE DRIVER
Q223
MUTING
CONTROL SWITCH
Q220, 221
05
D206
28
28
D201
BATT
B+
XR-M500R/M550
7-3. BLOCK DIAGRAM DISPLAY/BUS CONTROL Section
LIQUID CRYSTAL DISPLAY

DRIVE CONTROLLER
IC607
LIQUID CRYSTAL DISPLAY DRIVER

IC901
DIMMER 86
69
64
66
70
60
62
VLCD 85
97 LCD-INH
99 LCD-CLK
98 LCD-CE0
100 LCD-DATA
OSC
SPECTRUM ANALYZER BAND-PASS FILTER

IC102
1 71
LCD-INH
LCD-SCK
LCD-CE0
LCD-CE1
TX/LCD-DATA
RX
83 76
52 ILL-ON
(Page 30)
COM1 COM8 SEG1 SEG71
ILL ON
LED903 908,
LED911 916
(LCD BACK LIGHT)
LED DRIVE
Q905, 906
LIQUID CRYSTAL
DISPLAY
(OPERATION SIDE)
LCD902
96
B.P.F.
f: 6.8Hz
to
14.4kHz
MUTING
Q611
105 SPE-IN
OSC
C906, R972
LIQUID CRYSTAL DISPLAY DRIVER
IC902
REGISTER
A
10
B
11
C
12
SEL
14
(Page 28)
DECODER
40
41
42
43
SPE-A
SPE-B
SPE-C
SPE-SEL
97
99
98
100
LINK-OFF 50
LEVEL SHIFT
Q503
86 EXTAL
X602
18.432MHz
UNISI
UNISCK
BUS-ON
BU-IN
NMI
85 XTAL
D628
SCHMITT TRIGGER
IC606
LIQUID CRYSTAL
DISPLAY
(SECURITY SIDE)
LCD901
REGULATOR
D909
LCD +9V
REGULATOR
CONTROL SWITCH
Q910
VLCD 85
DATA
CLK
BUS-ON
BU IN
LSW-SW1, LSW-SW2
LCD-SW2 84
LCD-SW1 85
LED SW1
LED SW2
SP-LAT
57
46 47
33
L
(Page 30)
96
D611
OSC
BOOT
81 RES
98
101
38
49
82
OSC
UNISO 97
LCD-INH
LCD-CLK
LCD-CE1
LCD-DATA
1 69
D103
MUTE
MULTI AOUT
17
PLEXER
PEAK
HOLD
83 76
H
(Page 28)
AIN
COM1 COM8 SEG1 SEG69
SPECTRUM
ANALYZER BUFFER
IC101
SPEANA
BATT B+
C911, R982
TH601
SONY BUS INTERFACE
IC501
7
BATT
12 13
RX
TX
S901
(RESET)
S902
RESET
115 116
SPELAT
90 RESET
86 HSTX
106
BOOT
BACK UP +5V
SYSRST
6
RESET SIGNAL
GENERATOR
IC602
LED SW1
LED SW2
13
UNISO 18
9
DATA
UNISI 17
SYSTEM CONTROLLER
IC601 (3/4)
8
CLK
+9V
REGULATOR
IC503
X0
X1
X0A
X1A
BEEP
PACK SW
KEY IN0
KEY IN1
RC IN0
RC IN1
KEY ACK
40 98 97 96
92
93
74
73
15
111
46 47
48 72
79
MOT+
MOT
85 RAMBU
FP CTRL
RAM RESET
IC603
BACK UP +5V
I-DET
UNICKO 19
BATT B+
D509
X601
3.68MHz
X600
32.768kHz
14
OUT2
MOTOR
DRIVE
BU-IN 77
D627
CLOSE
RNF
16
DATA
IN
DATA
DATA
OUT
MOTOR OVER LOAD

DETECT
IC500, Q500
D513
CLK
IN
BUS
ON
CLK
BUS ON
SWITCH
BUS
ON
4
4
SIRCS 24
J500
REMOTE IN
(XR-M550)
05
29
29
BUS ON/OFF
SWITCH
Q505
10
BU IN
BATTERY
CHECK
BATT
CLK
6
BUS ON
BATT B+
SIRCS BUFFER
Q506
REMOTE CONTROL
RECEIVER
IC900 (SUB Board)
LSW902, 904 918,

LSW921 925,
S901, 902
DATA
80 AD ON
LSW901 919,
LSW921 925,
S901, 902
11
RESET
BATTERY CHECK
Q504
D501
(XR-M500R)
OPEN
OUT1
12
BU IN
BZ600
(BUZZER)
VCC
M BATT
VREF
M601
FRONT PANEL
OPEN/CLOSE
BUS-ON 14
KEY ACTIVE
SWITCH
Q600, 601
S901
CASSETTE
IN/OUT DETECT
REFERENCE
VOLTAGE SWITCH
Q501, 502
5 4 12
BUS-ON
RST
RESET
SWITCH
BACK UP +5V
BUZZER DRIVE
Q604
FRONT PANEL
OPEN/CLOSE MOTOR DRIVE
IC502
11
RESET
REMOTE CONTROL
RECEIVER
IC903 (DISPLAY Board)
D508
D505
BATT B+
D502
3
SIRCS
CN500
BUS CONTROL IN
(FOR SONY BUS)
XR-M500R/M550
7-4.
BLOCK DIAGRAM POWER SUPPLY Section
SYSTEM CONTROLLER
IC601 (4/4)
CN301 (2/2)
(POWER CONNECTOR)
ACC IN 81
ACCESSORY
CHECK
Q608
ILL IN 95
ILLUMINATION
LINE DETECT
Q607
D904
CASSETTE SLOT
INDICATOR
D905
D318
D315
7
ACC
D316
14
ILL
B+ SWITCH
Q900, 901
Z
CLOSE SW 99
TUNER VCC
OPEN SW 100
FRONT PANEL
OPEN/CLOSE DETECT
CLOSE
BATT B+
TUNER +5V
TUNER CIRCUIT/
RDS DECODER (IC701)
B+ (XR-M500R)
+5V REGULATOR
Q100
B+ SWITCH
Q103, 104
16
+9V REGULATOR
IC605
B+
OPEN
ANTENNA
REMOTE SWITCH
Q300, 301
TH301
AMP
REMOTE SWITCH
Q302, 303
TH300
D308
6
ANT-R
TU-ON 114
FLS-PWON 82
D609
B+
SPECTRUM ANALYZER
CONTROL (IC102)
B+
+5V REGULATOR
Q106, 107
RIPPLE FILTER
IC604
D309
5
AMP-R
PW ON 83
BACK UP +5V
AMP ON
+6V REGULATOR
IC604
(Page 28)
(Page 29)
LCD +9V
LCD DRIVER
(IC901, 902)
B+
(Page 29)
ILL ON
LED901
(ILLUMINATION)
LSW912
B+ SWITCH
Q903, 904
Z
LCD-SW1
05
(XR-M500R)
LED917 921, LSW901 911,
LSW913 919, 921 925
(FOR ILLUMINATION)
B+ SWITCH
Q901, 902
(XR-M550)
LCD-SW2
LED917 921, LSW902, 904 911,
LSW913 918, 921 925
(FOR ILLUMINATION)
30
30
LCD-SW1, LCD-SW2
XR-M500R/M550
7-5.
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:

X : parts extracted from the component side.
Y : parts extracted from the conductor side.
b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from

the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
Note on Schematic Diagram:

All capacitors are in F unless otherwise noted. pF: F
50 WV or less are not indicated except for electrolytics
and tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.
f
: internal component.
C : panel designation.
U : B+ Line.
H : adjustment for repair.
Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : AM (MW)
[
] : LW
: TAPE PLAYBACK
Voltages are taken with a VOM (Input impedance 10 M).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Circled numbers refer to waveforms.
Signal path.
F : FM
f : AM (MW/LW)
L : BUS AUDIO IN
E : TAPE PLAY
Please refer to servicing notes (page 3) for system of
TYPE A, B, C and D.
Waveforms
MAIN Board
DISPLAY Board
1 IC701 5 OSCI
1 IC901 y; OSC
2.4 Vp-p
232 ns
3.2 Vp-p
22.8 s
2 IC601 ud XIA
2 IC902 y; OSC
3.1 Vp-p
306 s
22.8 s
3 IC601 od X1
5.5 Vp-p
272 ns
4 IC607 ih EXTAL
3 Vp-p
54 ns
31
31
3.2 Vp-p
XR-M500R/M550
7-6.
PRINTED WIRING BOARD MAIN Board (Component Side)
Semiconductor Location
Ref. No.
Location
Ref. No.
Location
D100
D101
D102
D103
D104
D200
D201
D202
D203
D204
D300
D301
D302
D303
D304
D305
D306
D307
D310
D311
D312
D315
D316
D318
D400
D500
D501
D502
D505
D506
D507
D508
D509
D511
D512
D513
D604
D606
D607
D610
D611
D627
D628
D701
D750
D-13
C-13
G-8
I-9
D-13
B-9
I-5
H-6
B-9
A-9
C-7
B-7
B-6
C-7
B-8
C-8
B-8
C-8
B-3
C-4
E-3
B-5
B-6
B-5
F-3
F-4
B-2
I-4
F-4
G-4
G-4
G-4
H-2
H-4
H-4
G-4
D-2
H-5
D-2
J-3
J-6
J-9
I-5
F-8
F-13
IC502
IC503
IC601
IC602
IC603
IC606
IC607
IC700
IC750
G-2
H-3
F-6
E-5
D-5
J-7
I-8
J-12
F-14
IC100
IC101
IC102
IC202
IC400
IC401
IC501
F-11
G-9
J-6
C-11
F-3
H-11
H-4
Q100
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q200
Q201
Q204
Q220
Q221
Q222
Q250
Q251
Q254
Q300
Q302
Q401
Q402
Q403
Q404
Q500
Q501
Q502
Q503
Q504
Q505
Q506
Q600
Q601
Q602
Q603
Q604
Q605
Q606
Q607
Q608
Q611
Q750
Q751
E-13
D-12
E-12
E-8
F-8
H-8
K-6
K-6
B-11
B-11
C-12
I-6
H-6
I-6
B-10
B-10
C-12
E-4
E-4
G-3
E-3
F-3
H-11
I-3
I-2
I-2
F-4
F-4
G-5
I-4
D-6
D-6
G-8
G-7
J-3
F-9
E-9
D-4
D-4
I-10
F-13
G-14
(Page 40)
32
32
XR-M500R/M550
7-7. PRINTED WIRING BOARD MAIN Board (Conductor Side)

(M500R)
GRN
WHT
GRY
VIO
RL+
RL
FL+
FL
FR+
FR
RR+
RR
10
11
12
13
14
15
16
ACC
GND
GRN/BLK
WHT/BLK
GRY/BLK
VIO/BLK
TO
CN301
WHT
GRN
VIO
GRY
WHT/BLK
GRN/BLK
VIO/BLK
GRY/BLK
LIGHT BLU
BLU/WHT
BLU
RED
BLK
RED
ILL
BLU
ANT REM
NC
BATT
NC
NC
ORG/WHT
ATT
AMP REM
YEL
BLK
ORG/WHT
YEL
(M550)
10
11
12
WHT/BLK
WHT
GRN/BLK
GRN
VIO/BLK
VIO
GRY/BLK
GRY
13
LIGHT BLU
BLU/WHT
14
ORG/WHT
BLU
FRONT LCH (+)

REAR LCH ()
REAR LCH (+)
REAR RCH ()
REAR RCH (+)
FRONT RCH ()
FRONT RCH (+)
ATT
AMP REM
ILL IN
ANT REM
15
RED
FRONT LCH ()
16
YEL
BLK
ACC
BATT
GND
Ref. No.
(Page 38)
33
33
D308
D309
D317
D320
D401
D503
D504
D510
D515
D516
D601
D602
D603
D608
D609
D612
D613
D617
D618
Location
D-4
D-4
C-2
A-6
D-2
B-3
B-3
I-3
G-2
G-2
F-5
F-5
F-5
F-4
E-5
J-2
J-2
K-9
K-9
Ref. No.
Location
D619
D620
D621
D623
D624
D625
D626
J-9
J-9
K-9
J-9
J-10
K-10
J-9
IC200
IC201
IC300
IC500
IC604
IC605
D-10
D-11
A-8
H-3
C-1
D-1
Q301
Q303
Q400
E-3
E-3
G-3
XR-M500R/M550
7-8.
SCHEMATIC DIAGRAM MAIN Board (1/4) See page 31 for Waveforms.
See page 42 for IC Block Diagrams.
(Page
35)
(Page 37)
(Page 36)
34
34
7-9.
SCHEMATIC DIAGRAM MAIN Board (2/4)
XR-M500R/M550
(Page 34)
(Page 36)
(Page 37)
35
35
XR-M500R/M550
7-10. SCHEMATIC DIAGRAM MAIN Board (3/4)
See page 31 for Waveforms.
(Page 34)
(Page 35)
(Page
37)
36
36
XR-M500R/M550
Ver 1.1
7-11. SCHEMATIC DIAGRAM MAIN Board (4/4)
(Page 35)
(Page 34)
(Page 41)
(Page
36)
(Page 39)
37
37
XR-M500R/M550
7-12. PRINTED WIRING BOARD SUB Board

Semiconductor
Location
Ref. No.
Location
D900
D901
D902
D903
D904
D905
B-1
A-1
A-2
A-1
A-9
A-10
IC900
A-11
Semiconductor
Location
Ref. No.
Location
D907
D908
A-9
A-10
Q900
Q901
B-12
A-12
(Page 33)
FOR TEST
38
38
XR-M500R/M550
7-13.
SCHEMATIC DIAGRAM SUB Board
(Page 37)
39
39
XR-M500R/M550
7-14.
PRINTED WIRING BOARD DISPLAY Board
Semiconductor
Location
Ref. No.
Location
LED901
LED903
LED904
LED907
LED908
LED911
LED912
LED913
LED914
LED915
LED916
A-1
B-2
A-2
B-2
B-2
B-13
B-13
C-2
C-13
B-13
A-13
IC901
IC902
IC903
B-7
B-8
C-2
Q901
Q902
B-2
B-2
(Page 32)
Semiconductor
Location
Ref. No.
Location
D902
D903
D904
D905
D906
D907
D908
D909
B-12
C-11
C-11
C-10
C-11
B-11
C-11
C-12
LED905
LED906
LED917
LED918
LED919
LED920
LED921
B-10
B-10
B-3
C-3
B-2
C-2
A-2
Q903
Q904
Q905
Q906
Q910
B-3
C-4
C-4
C-3
C-12
40
40
XR-M500R/M550
7-15. SCHEMATIC DIAGRAM DISPLAY Board
(Page
37)
41
41
IC Block Diagrams
MAIN Board
OUTSWL
OUTSWR
OUTSSL
OUTSSR
27
26
25
24 23
SEL
N.C.
C
B
A
OUTRR
28
N.C.
OUTRF
29
TEST
OUTLR
30
AOUT
OUTLF
33 32 31
BA3834F
GND
IC102
TDA7402TR
ACINLR
ACINRF
ACINRR
IC100
18
17
16
15
14 13 12 11 10
MULTIPLEXER
MIXER
MONO- MONOFADER FADER
ACINLF 34
SWINR 35
SWINL 36
ACIN
ACOUTR 37
ACOUTL 38
MAIN
FRONT
OUTPUT
SELECTOR
SUBWOOFER
+PHASE
CONTROL
REAR
REGISTER
SW
SECOND
CREF 39
REGISTER
REGISTER
REGISTER
IIC-BUS
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
68Hz
B.P.F.
170Hz
B.P.F.
420Hz
B.P.F.
1kHz
B.P.F.
2.4kHz
B.P.F.
5.9kHz
B.P.F.
14.4kHz
B.P.F.
21 SCL
20 SDA
DIGITAL CONTROL
HIGH-CUT
VOLUME
SOFTMUTE
COMPANDER
7 8
DIFOUT
N.C.
CIN
AIN
VCC
N.C.
SUPPLY
TREBLE
RREF
DIFFERENTIAL
AMPLIFIER
BASS
19 GND
18 SM
S&H
PULSE
FORMER
25kHz
LP
QUAL
17 QUAL
LOUDNESS
LOUDNESS
IN-GAIN
IN-GAIN
+AUTO ZERO
MUTE
MULTIPATH
DETECTOR
DEMODULATOR
+STEREO ADJUST
+STEREO BLAND
MUX 40
BEEP
D/A
CONVERTER
PILOT
CANCELATION
16 MPOUT
15 MPIN
IC200, 201
14 LEVEL
VCCL 1
INL 2
MAIN SOURCE
SELECTOR
MIXING
SELECTOR
SECOND SOURCE
SELECTOR
VCC 1
NC 2
BUFFER
VCCL
SVRL 3
INPUT
MULTIPLEXER
MAIN
CH0
AUX
AM
1 2
3 4 5 6
7 8 9 10
11
SEL
SER
FD1L+
FD1L
FD1R+
FD1R
FD2L+
FD2L
FD2R+
FD2R
AM
AM/FM
NOISE BLANKER
12 AMIF
VCCL
SIGNAL
AMP
15 CL
14 LGND
VCCR
INMR 5
12 OUTR
SIGNAL
AMP
11 RGND
REFERENCE
BUFFER
INR 7
VCCR 8
42
42
VCCR
LIFT
AMP
10 CR
SVRR 6
BUFFER
CONTROL
CIRCUIT
IN2 4
MOTOR
DRIVE
CIRCUIT
9 OUT1
8 NC
7 OUT2
BUFFER
13 OUTL
INML 4
10 NC
BUFFER
IN1 3
13 MPX
REFERENCE
LB1930M-TLM
16 CL+
S-GND 5
80kHz
LP
FM
LIFT
AMP
BUFFER
PLL
IC400
NJM2160AM-TE2 (XR-M550)
PIL DET
PHONO
REGISTER
PEAK
HOLD
BIASC
HP
MD2 43
MD2G 44
REGISTER
PEAK
HOLD
VREFC
VOICE
BANDPASS
MAIN
REGISTER
22 VDD
LP
MD1 41
MD1G 42
DECODER
CR+
6 P-GND
AUXIN1
DIREF
LINEOUT1
TCH1
29
28 27
26
25
24
23 22 21
120/
70
MSSW
TAPEIN1
30
NC
GND
IC501
PBOUT1
CXA2510AQ-T4
PBEQ1
+
NR BIAS
PBFB1 31
PBRIN1 32
MS
MODE
X1
TAPE EQ
NR
MODE
FWD/RVS
VCT
LPF
CLK 4
VREF 5
DATA 6
9 DATA IN
GND 7
8 DATA OUT
F3
F1
13 DGND
X1
PBRIN2 39
PBFB2 40
12 MSTC
+
+
T1
120/
70
11 FF
OFF/B
4 5
8 9 10
PBEQ2
PBOUT2
VCC
TAPEIN2
AUXIN2
MSLPF
LINEOUT2
TCH2
NC
PLAY
NR
SCOUT
VREF
MPX
VSSA
VDDA
AFIN
MAD
PSWN
16 RNF
15 NC
14 OUT2
SAA6588T/V2-118 (XR-M500R)
CIN
IC700
BA6288FS-E2
LVIN
20
19
18
17
16
15
14
13
12 11
DRIVER
13 NC
MULTI
PATH
DETECTOR
57kHz
8th ORDER
BAND-PASS FILTER
12 VREF
CLOCKED
COMPARATOR
TSD
SIGNAL QUALITY
DECODER
4
FIN
NC
7
8
CLOCK
CONTROL
LOGIC
PAUSE
DETECTOR
POWER SUPPLY
& RESET
DRIVER
VCC
RST
BUS ON
CLK IN
BU IN
14 MSOUT
PBREF2 38
VM
BATTERY
SWITCH
16 NRSW
PBFIN2 37
1
2
3
BATT 3
13
12
11
10
MS ON/ 15 NC
OFF
DETECT
VCC
+
GND
NC
OUT1
RESET
SWITCH
18 TAPESW
17 INSW
F2
PBFIN1 34
IC502
RST 2
14 VCC
19 DRSW
TAPE/AUX
VCT 35
PBGND 36
BUS ON
SWITCH
20 MSMODE
PBREF1 33
BUS ON 1
NR
T2
BA8270FV-E2
OFF/B
IC401
RDS/RDBS
DEMODULATOR
RDS/RDBS
DECODER
4
CLOCK
INTERFACE
REGISTER
DATA
11 RIN
DATA
10 NC
9 NC
OSCILLATOR
& CLOCK
1 2
10
OSCO
OSCI
VSSD
VDDD
DAVN
SDA
SCL
IIC BUS SLAVE

TRANSCEIVER
TCON
TEST
CONTROL
MRO
MPTH
NC
POWER
SAVE
43
7-16.
IC PIN FUNCTION DESCRIPTION
MAIN BOARD IC601 (SYSTEM CONTROLLER)

MB90574BPMT-G-257-BND (XR-M500R) MB90574BPMT-G-262-BND (XR-M550)
Pin No.
Pin Name
I/O
Description
NC
Not used (open)
AMSIN
Whether a music is present or not from CXA2510AQ (IC401) is detected at auto music sensor
L: music is present, H: music is not present
AMSON
Tape auto music sensor control signal output to the CXA2510AQ (IC401)
L is output to lower the gain for audio level at FF/REW mode
SPE LAT
Serial data latch pulse output for spectrum analyzer section to the liquid crystal display drive
controller (IC607)
MUTE
Audio line muting on/off control signal output terminal H: muting on
SYSRST
System reset signal output to the liquid crystal display drive controller (IC607) and SONY bus
interface (IC501) L: reset
N-ROUT
Forward/reverse direction control signal output to the CXA2510AQ (IC401)

L: forward direction, H: reverse direction
VCC
Power supply terminal (+5V)
NC
10
E2P-SIO
I/O
Two-way data bus for tuner EEPROM with the FM/AM tuner unit (TUX100)
Not used (fixed at L)
11
E2P-CKO
I/O
Two-way bus clock signal for tuner EEPROM with the FM/AM tuner unit (TUX100)
12
RX
Flash memory write data input from the liquid crystal display drive controller (IC607)
13
TX
Flash memory write data output to the liquid crystal display drive controller (IC607)
14
BUS-ON
Bus on/off control signal output to the liquid crystal display drive controller (IC607) and SONY
bus interface (IC501) L: bus on
15
BEEP
Beep sound drive signal output terminal
16
TEL-MUTE
Telephone detection signal input terminal At input of H, the signal is attenuated by 20 dB
17
UNISI
Serial data input from the SONY bus interface (IC501)
18
UNISO
Serial data output to the SONY bus interface (IC501)
19
UNICKO
Serial clock signal output to the liquid crystal display drive controller (IC607) and SONY bus
interface (IC501)
20 to 22
NC
Not used (open)
23
MTLOUT
METAL on/off control signal output to the CXA2510AQ (IC401) H: METAL on
24
SIRCS
Sircs remote control signal input from the remote control receiver (IC900, 903)
25 to 30
NC
Not used (open)
31
VOLATT
Pre amplifier muting on/off control signal output to the electrical volume (IC100)
L: muting on
32
TUATT
Muting on/off control signal output of the FM/AM tuner signal L: muting on
33
VSS
Ground terminal
34
Connected to coupling capacitor for the power supply
35, 36
NC
Not used (open)
37
ANT CUT
Tuner system power supply on/off control signal output terminal H: tuner power on
Not used (open)
38
DVCC
Power supply terminal (+5V) (for D/A converter)
39
DVSS
Ground terminal (for D/A converter)
40
FP CTRL
Front panel open/close motor (M601) speed control signal output to the BA6288FS (IC502)
41
NC
Not used (open)
42
AVCC
Power supply terminal (+5V) (for analog system)
43
AVRH
Reference voltage (+5V) input terminal (for A/D converter)
44
AVRL
Reference voltage (0V) input terminal (for A/D converter)
45
AVSS
44
Ground terminal (for analog system)
Pin No.
46
Pin Name
KEYIN0
I/O
Description
Key input terminal (A/D input) (LSW901 to LSW912, S900)

TA, SOUND, D-BASS, MENU, DISC +, . m, LIST, > M, ENTER, DISC , CLOSE,
OPEN, Z keys input
(LSW901 TA, LSW903 D-BASS: XR-M500R only)
47
KEYIN1
Key input terminal (A/D input) (LSW913 to LSW919, LSW921 to LSW925, S902)
6 to 3, SHUF 2, REP 1, AF, +, PTY DSPL (XR-M500R), DSPL (XR-M550), , OFF, SOURCE,
MODE o keys input
(LSW919 AF: XR-M500R only)
48
RCIN0
Rotary remote commander key input terminal (A/D input)
49
NC
Not used (open)
50
QUALITY
Noise level detection signal input at SEEK mode (A/D input)

Used for the XR-M500R only (XR-M550: Not used open)
51
FMAGC
FM AGC detection signal input from the FM/AM tuner unit (TUX100) (A/D input)
52
MPTH
Multi-path detection signal input from the RDS decoder (IC700) (A/D input)
53
VSM
FM and AM signal meter voltage detection input from the FM/AM tuner unit (TUX100)
(A/D input)
54
VCC
55
ST-BY
Standby on/off control signal output terminal L: standby mode, H: amplifier on
56
NS-MASK
Discharge control signal output for the noise detection circuit H: discharge
57
REEL
Rotation detect signal input from supply reel sensor and take-up reel sensor on the deck
mechanism
58
NC
59
TAPE ON
Tape system power supply on/off control signal output terminal H: tape on
60
LM-EJ
Motor drive signal output to the loading/tape operation motor drive (IC400) H active
(For the eject direction and reverse side operation) *1
61
LM-LOD
Motor drive signal output to the loading/tape operation motor drive (IC400) H active
(For the loading direction and forward side operation) *1
62
CM ON
Capstan/reel motor (M901) drive signal output terminal H: motor on
63
VSS
Ground terminal
64
POS0
65
POS1
66
POS2
67
POS3
68
NC
Not used (open)
69
FLASH-W
Internal flash memory data write mode detection signal input terminal L: data write mode
Not used (pull up)
70
IIC SDA
I/O
Two-way data I C bus with the FM/AM tuner unit (TUX100), RDS decoder (IC700) and
electrical volume (IC100) (RDS decoder is XR-M500R only)
71
IIC SCL
I C bus clock signal output to the FM/AM tuner unit (TUX100), RDS decoder (IC700) and
electrical volume (IC100) (RDS decoder is XR-M500R only)
72
RCIN1
Rotary remote commander shift key input terminal
73
X1A
Sub system clock output terminal (32.768 kHz)
74
X0A
Sub system clock input terminal (32.768 kHz)
75
DAVN
Data transmit completed detection signal input from the RDS decoder (IC700) H active
76
CDON-IN
CD/MD on/off control signal input terminal (fixed at L in this set)
77
BU-IN
Battery detection signal input from the SONY bus interface (IC501) and battery detect circuit
L is input at low voltage
POS0: L: EJECT mode, H: others mode

Tape position (EJECT/FF/REW/REV/
POS1: L: FF and FWD mode, H: others mode
FWD mode) detect input from the tape
POS2: L: REW mode, H: others mode
operation switch on the deck mechanism
POS3: L: REV and EJECT mode, H: others mode
45
Pin No.
Pin Name
I/O
Description
78
NC
Not used (open)
79
KEYACK
Input of acknowledge signal for the key entry Acknowledge signal is input to accept function
and eject keys in the power off status On at input of H
80
AD ON
A/D converter power control signal output terminal

When the KEYACK (pin ul) that controls reference voltage power for key A/D conversion input
is active, L is output from this terminal to enable the input
81
ACCIN
Accessory detection signal input terminal L: accessory on
82
FLS PWON
Power on/off control signal output of the illumination LED and liquid crystal display driver
(IC901, 902) H: power on
83
PW-ON
Main system power supply on/off control signal output terminal H: power on
84
TESTIN
Setting terminal for the test mode L: test mode, Normally: fixed at H
85
RAMBU
Internal RAM reset detection signal input from the RN5VD33AA (IC603)
Input terminal to check that RAM data are not destroyed due to low voltage
This checking is made within 100 msec after reset
86
HSTX
Hardware standby input terminal L: hardware standby mode
87
MD2
Setting terminal for the CPU operational mode (fixed at L in this set)
88
MD1
Setting terminal for the CPU operational mode (fixed at H in this set)
89
MD0
Setting terminal for the CPU operational mode (fixed at H in this set)
90
RESET
System reset signal input from the reset signal generator (IC602) and reset switch (S901, 902)
L: reset L is input for several 100 msec after power on, then it changes to H
91
VSS
92
X0
Main system clock input terminal (3.68 MHz)
Reset signal input in this set
Ground terminal
93
X1
Main system clock output terminal (3.68 MHz)
94
VCC
95
ILLIN
Auto dimmer control illumination line detection signal input terminal

L is input at dimmer detection
96
I-DET
Detection signal input from the motor overload detection circuit for the front panel open/close
motor (M601)
L is input when the motor current exceeds the specified value
97
MOT
Front panel open/close motor (M601) drive signal (in panel close direction) output to the
BA6288FS (IC502) H active *2
98
MOT+
Front panel open/close motor (M601) drive signal (in panel open direction) output to the
BA6288FS (IC502) H active *2
99
CLOSE SW
Front panel open/close detect switch input terminal L is input when the front panel is closed
100
OPEN SW
Front panel open/close detect switch input terminal L is input when the front panel is opened
101 to 103
SCODE0 to
SCODE3
Setting terminal for security code
104, 105
DSTSEL1,
DSTSEL2
Destination setting terminal (A/D input) XR-M500R: fixed at L, XR-M550: fixed at H
106
BOOT
Serial data output to the liquid crystal display drive controller (IC607)
107
DSP GAIN
Not used (open)
108
DSP ON
Power supply on/off control signal output terminal H: DSP on
109
NC
Not used (open)
46
Not used (open)
110
EMPH-IN
Emphasis control signal input terminal
111
PACK SW
Cassette in/out detect switch (S901) L: cassette in
112
4V SEL
Input terminal of whether line driver is mounted or not is detected

L: line driver is mounted (XR-M550), H: line driver is not mounted (XR-M500R)
113
P SEL
Power select input terminal
Not used (open)
Pin No.
Pin Name
I/O
Description
114
TUNON
Tuner system power supply on/off control signal output terminal

H: tuner power on
115, 116
LED SW1,
LED SW2
Security/operation side select control signal output to the liquid crystal display drive controller
(IC607)
117, 118
NC
Not used (open)
119
VSS
Ground terminal
120
DOLBY
Dolby-B on/off select signal output to the CXA2510AQ (IC401) H: dolby on
*1 Loading/tape operation motor control

Mode
STOP
LOADING/
FORWARD
LM-LOD (pin ya )
LM-EJ (pin y; )
Terminal
EJECT/
REVERSE
BRAKE
*2 Front panel open/close motor (M601) control

Mode
Terminal
STOP
FRONT PANEL FRONT PANEL

OPEN
OPEN
BRAKE
MOT (pin oj )
MOT+ (pin ok )
47
MAIN BOARD IC607 HD6432355A22F (LIQUID CRYSTAL DISPLAY DRIVE CONTROLLER)

Pin No.
Pin Name
I/O
Description
1, 2
PG3, PG4
Not used (open)
VSS
Ground terminal
NC
Not used (open)
VCC
6 to 9
PC0 to PC3
Not used (open)
10
VSS
Ground terminal
11 to 14
PC4 to PC7
Not used (open)
15 to 18
PB0 to PB3
Not used (open)
19
VSS
Ground terminal
20 to 23
PB4 to PB7
Not used (open)
24 to 27
PA0 to PA3
Not used (open)
28
VSS
Ground terminal
29 to 32
PA4/IRQ4 to
PA7/IRQ7
Not used (open)
33
SP-LAT
Serial data latch pulse input for spectrum display from the system controller (IC601)
H active
34
P66/IRQ2
Not used (open)
35, 36
VSS
Ground terminal
37
P65/IRQ1
Not used (open)
38
BUS-ON
Bus on/off control signal output from the system controller (IC601)
L: bus on
39
VCC
40
SPE-A
41
SPE-B
42
SPE-C
43
SPE-SEL
44
VSS
45
DSP SEL
Spectrum analyzer display data select signal input from the BA3834F (IC102)
46, 47
LED SW1,
LED SW2
Security/operation side select control signal input from the system controller (IC601)
H active
48
PE7
Not used (open)
Battery detect signal input from the SONY bus interface (IC501) and battery detect circuit
L is input at low voltage
Output select control signal output to the BA3834F (IC102)
*1
Ground terminal
49
BU-IN
50
LINK-OFF
Link on/off control signal output for the SONY bus L: link on, H: link off
51
PD2
Not used (open)
52
ILL-ON
Power on/off control signal output of the illumination LED H: power on
*1 Output select logic table

Terminal
GND
GND
68Hz
170Hz
420Hz
1kHz
2.4kHz
5.9kHz 14.4kHz
SPE-A (pin r; )
SPE-B (pin ra )
SPE-C (pin rs )
SPE-SEL (pin rd )
is don't care
48
IC102 (pin qj )
AOUT
Pin No.
Pin Name
I/O
Description
53
VSS
Ground terminal
54, 55
NC
Not used (open)
56
PD6
Not used (open)
57
BOOT
Serial data input at the flash memory writing mode L is input when writing change
58
VCC
59
NC
Not used (open)
60
TX/LCD-DATA
Display serial data output to the liquid crystal display driver (IC901, 902)
Output terminal for UART transfer data when writing into internal flash memory data
61
SP-SI
Spectrum analyzer display serial data input terminal
62
RX
Input terminal for UART transfer data when writing into internal flash memory data
63
SP-SCK
Spectrum analyzer display serial data transfer clock signal input terminal
64
LCD-SCK
Display serial data transfer clock signal output to the liquid crystal display driver (IC901, 902)
65
VSS
Ground terminal
66
LCDCE0
Chip enable signal output to the liquid crystal display driver (IC901) H active
67, 68
VSS
Ground terminal
69
LCD-INH
Blank indicate control signal output to the liquid crystal display driver (IC901, 902)
L: no display
70
LCDCE1
Chip enable signal output to the liquid crystal display driver (IC902) H active
71
NC
Not used (open)
72 to 78
P27 to P21
Not used (open)
79
FL W
Flash memory data write control signal output terminal H: active
80
FWE
Flash memory data write enable signal input terminal
81
RES
System reset signal input from the reset signal generator (IC602) and reset switch (S901, 902)
L is input for several 100 msec after power on, then it changes to H
82
NMI
Non maskable interrupt input terminal

Connect the backup detect circuit (BU-IN pin rl) in this set
83
STBY
Hard ware standby input terminal
84
VCC
85
XTAL
System clock output terminal (18.432 MHz)
86
EXTAL
System clock input terminal (18.432 MHz)
87
VSS
Ground terminal
88
PF7
Not used (open)
89
VCC
90 to 96
PF6 to PF0
Not used (open)
97
UNI-SO
Serial data output to the SONY bus interface (IC501)
98
UNI-SI
Serial data input from the SONY bus interface (IC501)
99, 100
VSS
Not used (pull down)
Ground terminal
101
UNICKI
Serial clock signal input from the system controller (IC601)
102
P53/ADTRG
Not used (open)
103
AVCC
Power supply terminal (+5V) (for A/D converter)
104
VREF
Reference voltage (+5V) input terminal (for A/D converter)
105
SPE-IN
Peak hold voltage detect signal input from the BA3834F (IC102)
106 to 110
P41/AN1 to
P45/AN5
49
Pin No.
Pin Name
I/O
111
P46/AN6/DA0
112
P47/AN7/DA1
113
AVSS
Ground terminal (for A/D converter)
114
VSS
Ground terminal
115 to 122
P17 to P10
Not used (open)
123
MD0
Setting terminal for the CPU operational mode (fixed at H)
124
MD1
125
MD2
126 to 128
PG0 to PG2
Not used (open)
50
Description
SECTION 8
EXPLODED VIEWS
NOTE:
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
Parts Color Cabinet's Color
(1)
Items marked * are not stocked since they

are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
The mechanical parts with no reference number in the exploded views are not supplied.
Hardware (# mark) list and accessories and
packing materials are given in the last of the
electrical parts list.
Please refer to servicing notes (page 3) for

system of TYPE A, B, C and D.
SUB PANEL SECTION
MG-25E-136
#1
8
F1
7
5
3
2
6
#1
10
#1
7
12
#1
11
1
Front Panel ass'y
Ref. No.
Part No.
Description
Remark
1
1
2
2
3
X-3378-724-1
X-3378-725-1
3-044-475-01
3-044-475-11
3-044-482-01
PANEL (XR) SUB ASSY, SUB (M500R)

PANEL (XR) SUB ASSY, SUB (M550)
DOOR, CASSETTE (M550)
DOOR, CASSETTE (M500R)
SPRING (CASSETTE DOOR)
4
5
6
7
3-044-478-01
1-677-721-11
1-792-584-11
3-045-756-01
BUTTON (EJECT) (Z)

SUB BOARD
CABLE, FLAT
SCREW (PANEL)
Ref. No.
Part No.
Description
Remark
* 8
9
9
* 10
* 11
3-041-156-11 COVER
1-792-194-11 CORD (WITH CONNECTOR) (POWER) (M550)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(M500R)
3-045-762-01 COVER (FLEXIBLE)
3-048-640-01 SHEET (SUB PANEL)
* 12
F1
3-049-388-01 CUSHION (SUB PANEL)

1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE)
51
Ver 1.1
(2)
FRONT PANEL SECTION
61
60
59
58
#6
55
63
57
64
56
LCD901
LCD902
53
52
#6
65
66
55
78
67
69
81
77
#3
68
76
75
51
70
74
71
M500R
80
Ref. No.
Part No.
Description
51
52
53
55
* 56
X-3378-768-1
3-045-781-01
3-045-702-01
1-694-685-11
3-045-703-02
PANEL (MAIN) ASSY, FRONT

BUTTON (RESET) (MAIN)
BRACKET (LCD) (MAIN)
CONDUCTIVE BOARD, CONNECTION
PLATE (LCD) MAIN, LIGHT GUIDE
* 57
58
59
* 60
* 61
3-045-705-02
1-694-686-11
1-694-687-11
3-045-706-01
X-3378-710-1
SHEET (MAIN), REFLECTION

BRACKET (LCD) (SUB)
BRACKET (PANEL) ASSY
63
64
65
65
66
3-045-708-01
3-045-707-01
A-3283-018-A
A-3283-019-A
3-045-726-01
SHEET (SUB), DIFFUSION

PLATE (LCD) SUB, LIGHIT GUIDE
DISPLAY BOARD, COMPLETE (M550)
DISPLAY BOARD, COMPLETE (M500R)
BUTTON (SOURCE)
67
68
69
3-045-725-01 BUTTON (+/-)

3-045-727-01 PLATE (RING), LIGHT GUIDE
3-045-730-01 BUTTON (SEEK) (DSO) (M500R)
(DISC +,> M, - DISC, .)
*
*
*
*
52
Remark
Ref. No.
69
70
71
71
72
73
74
74
75
76
77
* 78
80
81
LCD901
73
Part No.
72
Description
Remark
3-045-739-01 BUTTON (SEEK) (M550)

(DISC +,> M, - DISC, .)
3-045-734-01 CUSHION (SEEK)
3-044-469-11 PANEL (SUB), FRONT (M500R)
3-044-469-21 PANEL (SUB), FRONT (M550)
3-045-733-01 BUTTON (CLOSE)
3-045-731-01 BUTTON (ENTER)
(LIST, ENTER, SOUND, MENU)
3-045-724-01 BUTTON (6KEY) (M550) (1, 2, 3, 4, 5, 6)
3-045-724-11 BUTTON (6KEY) (M500R)
(AF, 1, 2, 3, 4, 5, 6, TA)
3-045-728-11 BUTTON (MODE) (DSPL, MODE o)
3-045-729-01 BUTTON (OFF)
3-045-735-01
3-045-704-01
3-045-732-01
1-677-340-11
1-803-913-11
BUTTON (OPEN)
BUTTON (D-BASS) (M500R)
FLEXIBLE BOARD
DISPLAY PANEL, LIQUID CRYSTAL
LCD902 1-803-914-11 DISPLAY PANEL, LIQUID CRYSTAL
(3)
MAIN BOARD SECTION
109
108
112
#9
M601
110
115
107
108
106
#1
#2
#8
#1
125
108
111
#8
#2
119
#2
#10
112
#4
126
#2
118
#2
117
#2
113
114
M550
105
TUX100
#8
104
103
120
#1
#2
#1
116
#8
102
122
123
#8
121
#1
101
#8
124
Ref. No.
Part No.
Description
Part No.
Description
* 101
102
103
* 104
105
X-3378-559-1
A-3315-066-A
3-045-722-01
X-3378-713-1
X-3378-717-1
CHASSIS (XR) ASSY

SHAFT ASSY, DRIVE
CAM (L)
BRACKET (L) ASSY
ARM (B-L) ASSY
*
*
*
*
*
118
118
119
120
120
3-044-471-01
3-044-471-11
3-047-525-01
A-3294-887-A
A-3294-889-A
HEAT SINK (M550)

HEAT SINK (M500R)
PLATE (BUS, BAR), GROUND
MAIN BOARD, COMPLETE (M550)
MAIN BOARD, COMPLETE (M500R: TYPE C)
106
107
108
109
* 110
X-3378-715-1
A-3326-298-A
3-342-940-01
3-045-713-01
X-3378-711-1
ARM (A-L) ASSY

SWITCH BOARD, COMPLETE
WASHER (M)
GEAR (A)
BRACKET (MOTOR) ASSY
* 120
* 120
* 120
121
* 122
A-3294-890-A
A-3294-891-A
A-3294-892-A
3-045-723-01
X-3378-714-1
MAIN BOARD, COMPLETE (M500R: TYPE A)

MAIN BOARD, COMPLETE (M500R: TYPE D)
MAIN BOARD, COMPLETE (M500R: TYPE B)
CAM (R)
BRACKET (R) ASSY
111
112
113
114
115
3-045-715-01
3-376-464-11
3-045-759-01
3-019-565-01
1-777-246-31
GEAR (C)
SCREW(+PTT 2.6X6),GROUND POINT
HEAT SINK (REG)
BRACKET (IC)
CORD (WITH CONNECTOR) (ANT)
123
124
125
126
127
X-3378-718-1
X-3378-716-1
3-045-714-01
3-048-645-01
3-048-644-01
ARM (B-R) ASSY

ARM (A-R) ASSY
GEAR (B)
SPRING (ARM L)
SPRING (ARM R)
* 116
117
Remark
3-049-689-01 SHEET, INSULATING

1-790-375-21 CORD (WITH CONNECTOR)
(SUB OUT(MONO)) (M550)
Ref. No.
127
Remark
M601
X-3378-769-1 MOTOR ASSY (FRONT PANEL OPEN/CLOSE)
TUX100 A-3220-738-A FM/AM TUNER UNIT (TUX-020)
53
(4)
MECHANISM DECK SECTION

(MG-25E-136)
160
159
163
158
A
HP901
161
155
154
162
157
#12
156
M901
164
153
152
not supplied
#7
168
168
166
167
165
151
Ref. No.
Part No.
Description
Part No.
Description
151
* 152
153
154
155
A-3291-667-A
3-019-130-01
3-019-131-01
3-020-539-01
3-020-540-01
CLUTCH (FR) ASSY

LEVER (LDG-A)
LEVER (LDG-B)
SPRING (LD-1), TENSION
SPRING (LD-2), TENSION
161
162
163
164
165
3-933-346-01
3-933-344-01
3-014-798-01
3-364-151-01
A-3220-607-A
CATCHER
GUIDE (C)
SCREW (HEAD), SPECIAL
WASHER
MECHANISM DECK ASSY
156
157
158
* 159
160
3-020-542-01
3-341-753-11
3-020-533-01
3-020-532-01
3-020-534-01
GEAR (LOADING FT)

WASHER, POLYETHYLENE
HOUSING
ARM (SUCTION)
HANGER
166
167
168
HP901
M901
3-017-302-01
3-936-853-01
3-701-437-21
1-500-157-21
A-3291-665-A
BELT (25)
FLYWHEEL (F)
WASHER
HEAD, MAGNETIC (PLAYBACK)
MOTOR ASSY, MAIN (CAPSTAN/REEL)
54
Remark
Ref. No.
Remark
Ver 1.1
SECTION 9
ELECTRICAL PARTS LIST
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
one.
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
Please refer to servicing notes (page 3) for
system of TYPE A, B, C and D.
DISPLAY

are seldom required for routine service.
Some delay should be anticipated when ordering these items.
SEMICONDUCTORS
In each case, u: , for example:
uA. . : A. .
uPA. . : PA. .
uPB. . : PB. .
uPC. . : PC. .
uPD. . : PD. .
CAPACITORS
uF: F
COILS
uH: H
Ref. No.
Part No.
Description
Remark
*
*
A-3283-018-A DISPLAY BOARD, COMPLETE (M550)

A-3283-019-A DISPLAY BOARD, COMPLETE (M500R)
************************
*
*
1-694-685-11
1-694-686-11
1-694-687-11
3-045-702-01
3-045-703-01

PLATE (LCD) (MAIN), LIGHT GUIDE
*
*
*
*
*
3-045-704-01
3-045-705-01
3-045-706-01
3-045-707-01
3-045-708-01
SHEET (MAIN), DIFFUSION

BRACKET (LCD) (SUB)
PLATE (LCD) SUB, LIGHT GUIDE
Ref. No.
Part No.
When indicating parts by reference

number, please include the board.
Description
Remark
< IC >
IC901
IC902
IC903
8-759-653-26 IC LC75878W
8-759-653-26 IC LC75878W
8-749-012-25 IC RS-170-TU
< LIQUID CRYSTAL DISPLAY >

< LED >
< CAPACITOR >

C901
C902
C903
C904
C905
1-164-004-11
1-164-004-11
1-165-176-11
1-165-176-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.047uF
0.047uF
0.047uF
10%
10%
10%
10%
10%
25V
25V
16V
16V
16V
C906
C907
C908
C909
C910
1-115-412-11
1-164-004-11
1-165-176-11
1-165-176-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
0.1uF
0.047uF
0.047uF
0.047uF
5%
10%
10%
10%
10%
25V
25V
16V
16V
16V
C911
C912
C913
1-115-412-11 CERAMIC CHIP

680PF
0.1uF
0.1uF
5%
10%
10%
25V
25V
25V
LED901
LED903
LED904
LED905
LED906
8-719-076-58
8-719-076-58
8-719-076-58
8-719-079-26
8-719-079-26
LED NSSW440-BRS (ILLUMINATION)

LED NSSW440-BRS (LCD BACK LIGHT)
LED NSSB440-WRST-THR (LCD BACK LIGHT)
LED NSSB440-WRST-THR (LCD BACK LIGHT)
LED907
LED908
LED911
LED912
LED913
8-719-076-58
8-719-076-58
8-719-076-58
8-719-076-58
8-719-076-58

LED914
LED915
LED916
LED917
LED918
8-719-076-58
8-719-076-58
8-719-076-58
8-719-078-39
8-719-078-39

LED CL-170SR-CD-T (ILLUMINATION)
LED CL-170SR-CD-T (ILLUMINATION)
LED919 8-719-078-39 LED CL-170SR-CD-T (ILLUMINATION)

LED921 8-719-078-39 LED CL-170SR-CD-T (MODE o)
< CONNECTOR >

< SWITCH >
CN901
1-794-184-21 CONNECTOR, FPC 14P

< DIODE >
D902
D903
D904
D905
D906
8-719-422-41
8-719-977-12
8-719-977-12
8-719-977-12
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA8051-L-TX
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
D907
D908
D909
8-719-977-12 DIODE MA8068-M-TX

8-719-420-14 DIODE MA8082-M (TX)
8-719-422-80 DIODE MA8075-H-TX
LSW901 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (TA)

(M500R)
LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOUND)
LSW903 1-771-883-11 SWITCH, TACTILE (WITH LED) (D-BASS)
(M500R)
LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU)
LSW905 1-771-883-11 SWITCH, TACTILE (WITH LED) (DISC +)
LSW906
LSW907
LSW908
LSW909
LSW910
1-771-883-11
1-771-476-11
1-771-476-11
1-771-476-11
1-771-883-11
SWITCH, TACTILE (WITH LED) (. m)

SWITCH, KEY BOARD (WITH LED) (LIST)
SWITCH, KEY BOARD (WITH LED) (> M)
SWITCH, KEY BOARD (WITH LED) (ENTER)
SWITCH, TACTILE (WITH LED) (DIISC -)
LSW911 1-771-883-11 SWITCH, TACTILE (WITH LED) (CLOSE)
55
DISPLAY
Ref. No.
Part No.
Description
LSW912
LSW913
LSW914
LSW915
1-771-476-11
1-771-883-11
1-771-883-11
1-771-883-11
SWITCH, KEY BOARD (WITH LED) (OPEN)

SWITCH, TACTILE (WITH LED) (6)
Remark
LSW916
LSW917
LSW918
LSW919
1-771-883-11
1-771-883-11
1-771-883-11
1-771-476-11

SWITCH, TACTILE (WITH LED) (SHUF 2)
SWITCH, TACTILE (WITH LED) (REP 1)
SWITCH, KEY BOARD (WITH LED) (AF)
(M500R)
LSW921 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (+)

LSW922 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (PTY DSPL)
(M500R)
LSW922 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(M550)
LSW923 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (-)
LSW924 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF)
LSW925 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
< TRANSISTOR >
Q901
Q902
Q903
Q904
Q905
8-729-900-53
8-729-106-60
8-729-106-60
8-729-900-53
8-729-904-66
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q906
Q910
8-729-904-66 TRANSISTOR
DTC114EKA-T146
2SB1132-T101-QR
2SB1132-T101-QR
DTC114EKA-T146
DTD113EK-T-146
DTD113EK-T-146
DTC114EKA-T146
< RESISTOR >

R901
R902
R903
R904
R905
1-218-879-11
1-218-875-11
1-218-871-11
1-218-867-11
1-218-859-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
22K
15K
10K
6.8K
3.3K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R906
R907
R908
R909
R910
1-218-859-11
1-218-855-11
1-218-851-11
1-218-851-11
1-218-847-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
2.2K
1.5K
1.5K
1K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R911
R912
R913
R914
R915
1-219-286-11
1-219-286-11
1-219-286-11
1-218-871-11
1-218-867-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
10K
6.8K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R916
R917
R918
R919
R920
1-218-863-11
1-218-859-11
1-218-855-11
1-218-851-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
3.3K
2.2K
1.5K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R921
R922
R923
R924
R926
1-218-847-11
1-219-286-11
1-219-286-11
1-219-286-11
1-216-829-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
1K
680
680
680
4.7K
2%
2%
2%
2%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R927
R928
R929
R930
R931
1-216-833-11
1-216-827-11
1-216-833-11
1-216-829-11
1-216-827-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
10K
3.3K
10K
4.7K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
56
Ref. No.
Part No.
Description
Remark
R932
R933
R934
R935
R936
1-216-035-00
1-216-025-00
1-216-025-00
1-216-025-00
1-216-025-00
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
270
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R937
R938
R940
R941
R942
1-216-025-00
1-216-025-00
1-216-025-00
1-216-025-00
1-216-025-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R943
R945
R947
R949
R951
1-216-025-00
1-216-035-00
1-216-035-00
1-216-029-00
1-216-029-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
270
270
150
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R953
R955
R957
R959
R961
1-216-029-00
1-216-029-00
1-216-029-00
1-216-029-00
1-216-029-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
150
150
150
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R963
R964
R965
R967
R968
1-216-029-00
1-216-811-11
1-216-833-11
1-216-805-11
1-216-821-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
150
150
10K
47
1K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R969
R970
R971
R972
R974
1-216-809-11
1-216-809-11
1-216-809-11
1-216-841-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
47K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R975
R976
R977
R978
R979
1-216-825-11
1-216-825-11
1-216-825-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
2.2K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R980
R981
R982
R984
R985
1-216-809-11
1-216-821-11
1-216-841-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
47K
2.2K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R986
R987
R988
R989
R990
1-216-825-11
1-216-825-11
1-216-037-00
1-216-821-11
1-216-025-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
2.2K
2.2K
330
1K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/10W
(M550)
R991
1-216-025-00 RES-CHIP
100
5%
R992
1-216-025-00 RES-CHIP
100
5%
1/10W
(M550)
1/10W
(M550)
< SWITCH >

S901
1-771-027-21 SWITCH, KEYBOARD (RESET)
S902
1-771-884-11 SWITCH, TACTILE (MODE o)
**************************************************************
MAIN
Ref. No.
Part No.
Description
*
*
*
*
*
A-3294-887-A
A-3294-889-A
A-3294-890-A
A-3294-891-A
A-3294-892-A
MAIN BOARD, COMPLETE (M550)

MAIN BOARD, COMPLETE (M500R: TYPE C)
MAIN BOARD, COMPLETE (M500R: TYPE A)
MAIN BOARD, COMPLETE (M500R: TYPE D)
MAIN BOARD, COMPLETE (M500R: TYPE B)
**********************
3-019-565-01
3-044-471-01
3-044-471-11
3-045-759-01
7-685-792-09
*
*
*
*
Remark
Ref. No.
Part No.
Description
Remark
C139
C140
C141

1uF
22PF
2.2uF
C142
C143
C144
C145
C146
1-164-346-11
1-126-157-11
1-163-038-00
1-163-038-00
1-163-038-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
10uF
0.1uF
0.1uF
0.1uF
C147
C148
C150
C168
1-163-038-00
1-126-157-11
1-163-251-11
1-163-038-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
100PF
0.1uF
20%
5%
C170
1-124-234-00 ELECT
22uF
20%
C200
0.001uF
5%
C201
0.001uF
5%
16V
50V
25V
25V
16V
C202
1-125-972-61 ELECT
100uF
20%
C203
1-125-972-61 ELECT
100uF
20%
C204
1-126-157-11 ELECT
10uF
20%
25V
16V
25V
16V
25V
C205
C206
1-126-157-11 ELECT
10uF
0.1uF
20%
10%
C208
0.1uF
C208
0.22uF
C209
0.1uF
C209
0.22uF
C210
100PF
5%
C211
1-126-157-11 ELECT
10uF
20%
C220
1-124-234-00 ELECT
22uF
20%
C221
1-124-234-00 ELECT
22uF
20%
C222
1-126-157-11 ELECT
10uF
20%
C223
1-126-159-11 ELECT
0.47uF
20%
C224
C225
1-125-972-61 ELECT
1-104-942-11 ELECT
100uF
1uF
20%
20%
C226
C227
1-104-942-11 ELECT
1uF
1uF
20%
C228
0.1uF
10%
C229
0.001uF
10%
C250
0.001uF
5%
C251
0.001uF
5%
BRACKET (IC)
HEAT SINK (M550)
HEAT SINK (M500R)
HEAT SINK (REG)
SCREW +PTT 2.6X6 (S)
7-685-793-09 SCREW +PTT 2.6X8 (S)

7-685-794-09 SCREW +PTT 2.6X10 (S)
5%
20%
< BUZZER >

BZ600
1-529-078-11 BUZZER, PIEZOELECTRIC

< CAPACITOR/SHORT >
C101
C102
C103
C105
C106
1-164-346-11
1-163-233-11
1-163-809-11
1-163-809-11
1-124-589-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
18PF
0.047uF
0.047uF
47uF
C107
C108
C110
C111
C113
1-163-037-11
1-124-589-11
1-164-004-11
1-164-505-11
1-163-037-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
47uF
0.1uF
2.2uF
0.022uF
10%
20%
10%
C114
C115
C116
C118
C119
1-104-942-11
1-104-942-11
1-164-346-11
1-164-346-11
1-163-263-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
1uF
330PF
20%
20%
C120
C121
C123
C124
C125
C126
1-164-346-11
1-163-017-00
1-163-021-11
1-107-823-11
1-124-589-11
1-163-038-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
1uF
0.0047uF
0.01uF
0.47uF
47uF
0.1uF
10%
10%
10%
20%
C127
1-124-584-00 ELECT
100uF
20%
C127
1-126-157-11 ELECT
10uF
20%
C128
1uF
C128
C129
1-216-295-00 SHORT
0 (M500R)
1uF
C129
1-216-295-00 SHORT
0 (M500R)
C130
1uF
C130
C131
1-216-295-00 SHORT
0 (M500R)
1uF
C131
C132
1-216-295-00 SHORT
0 (M500R)
1uF
C137
C138

1uF
1uF
5%
10%
10%
20%
10%
5%
50V
50V
16V
16V
50V
16V
50V
50V
16V
16V
25V
10V
(M550)
16V
(M500R)
16V
(M550)
16V
(M550)
16V
(M550)
16V
(M550)
16V
(M550)
16V
16V
16V
50V
16V
16V
16V
25V
25V
25V
25V
16V
50V
25V
(M550)
16V
(M550)
50V
(M550)
50V
(M550)
16V
(M550)
16V
(M550)
16V
16V
25V
(M550)
25V
(M550)
25V
(M500R)
25V
(M550)
25V
(M500R)
50V
(M550)
16V
(M550)
16V
(M550)
16V
(M550)
16V
(M550)
50V
(M500R)
16V
50V
(M550)
50V
16V
(M550)
25V
(M550)
50V
(M550)
50V
(M550)
50V
(M550)
57
MAIN
Ref. No.
Part No.
Description
Remark
C252
1-125-972-61 ELECT
100uF
20%
C253
1-125-972-61 ELECT
100uF
20%
C254
C255
C258
1-126-157-11 ELECT
1-126-157-11 ELECT
10uF
10uF
0.1uF
20%
20%
C258
0.22uF
C259
0.1uF
C259
0.22uF
C260
0.0018uF 10%
C261
1-126-157-11 ELECT
10uF
20%
C269
0.001uF
10%
C304
0.22uF
10%
25V
(M500R)
50V
(M550)
16V
(M550)
50V
(M550)
25V
C305
C306
C307
C308
1-126-157-11
1-164-004-11
1-163-235-11
1-163-235-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
22PF
22PF
20%
10%
5%
5%
16V
25V
50V
50V
C309
C310
C311
C312
C313
1-163-235-11
1-163-235-11
1-163-235-11
1-163-235-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
22PF
22PF
0.001uF
5%
5%
5%
5%
10%
50V
50V
50V
50V
50V
C314
C315
C316
C317
C318
1-126-572-11
1-126-572-11
1-163-251-11
1-163-009-11
1-163-009-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
100PF
0.001uF
0.001uF
20%
20%
5%
10%
10%
35V
35V
50V
50V
50V
C319
C320
C321
1-111-233-11 ELECT
5600uF
0.1uF
0.22uF
20%
10%
10%
C400
0.22uF
C401
100PF
5%
16V
25V
25V
(M550)
25V
(M500R)
50V
C402
C403
C404
C405
C406
1-163-251-11
1-163-251-11
1-163-251-11
1-163-251-11
1-163-251-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C407
C408
C409
C410
C411
1-163-038-00
1-163-263-11
1-163-263-11
1-163-263-11
1-163-263-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
330PF
330PF
330PF
330PF
5%
5%
5%
5%
25V
50V
50V
50V
50V
C412
C413
C414
C415
C416
1-163-038-00
1-126-157-11
1-124-234-00
1-163-021-11
1-163-021-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
22uF
0.01uF
0.01uF
20%
20%
10%
10%
25V
16V
16V
50V
50V
C417
C418
1-124-234-00 ELECT
1-124-589-11 ELECT
22uF
47uF
20%
20%
16V
16V
58
16V
(M550)
16V
(M550)
16V
16V
25V
(M550)
25V
(M500R)
25V
(M550)
Ref. No.
Part No.
Description
Remark
C419
C420
C421

0.47uF
0.47uF
68PF
10%
10%
5%
16V
16V
50V
C422
C423
C424
C425
C426
1-164-004-11
1-164-004-11
1-107-823-11
1-126-935-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
0.47uF
470uF
0.01uF
10%
10%
10%
20%
10%
25V
25V
16V
16V
50V
C427
C500
C501
C502
C503
1-163-023-00
1-164-004-11
1-164-004-11
1-163-009-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.015uF
0.1uF
0.1uF
0.001uF
0.1uF
5%
10%
10%
10%
10%
50V
25V
25V
50V
25V
C504
C505
C506
C507
C508
1-164-004-11
1-164-004-11
1-124-229-00
1-163-021-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
33uF
0.01uF
0.1uF
10%
10%
20%
10%
10%
25V
25V
10V
50V
25V
C509
C510
C511
C512
C513
C514
1-124-589-11
1-163-021-11
1-164-004-11
1-163-038-00
1-163-037-11
1-163-021-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.01uF
0.1uF
0.1uF
0.022uF
0.01uF
20%
10%
10%
16V
50V
25V
25V
25V
50V
C601
0.0047uF 10%
C601
0.047uF
C602
C603
C604
C605
1-163-038-00
1-163-038-00
1-163-038-00
1-163-038-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
C606
C607
C608
C609
C610
1-163-102-00
1-163-235-11
1-163-038-00
1-163-009-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
24PF
22PF
0.1uF
0.001uF
0.01uF
C611
C612
C613
C614
C615
1-126-157-11
1-163-038-00
1-163-017-00
1-164-489-11
1-164-004-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.0047uF
0.22uF
0.1uF
C616
C617
C618
C619
C620
1-124-584-00
1-163-038-00
1-110-654-11
1-128-057-11
1-164-004-11
ELECT
CERAMIC CHIP
ELECT (BLOCK)
ELECT
CERAMIC CHIP
100uF
0.1uF
0.047F
330uF
0.1uF
C621
C622
C623
C624
C625
1-124-589-11
1-163-038-00
1-163-038-00
1-163-038-00
1-163-038-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.1uF
0.1uF
0.1uF
0.1uF
C626
C627
C628
C629
C630
C631
1-163-038-00
1-126-154-11
1-163-021-11
1-164-004-11
1-163-038-00
1-163-038-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.01uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
5%
5%
10%
10%
20%
5%
10%
10%
20%
20%
10%
20%
20%
10%
10%
50V
(M500R)
25V
(M550)
25V
25V
25V
25V
50V
50V
25V
50V
50V
16V
25V
50V
16V
25V
10V
25V
0V
6.3V
25V
16V
25V
25V
25V
25V
25V
6.3V
50V
25V
25V
25V
MAIN
Ref. No.
Part No.
Description
C632
C633
C634
C635
C636
C637
C670
1-126-157-11
1-164-004-11
1-163-133-00
1-163-251-11
1-164-505-11
1-163-021-11
1-164-004-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C671
C700

0.1uF
10%
0.0022uF 10%
C701
330PF
5%
C702
560PF
5%
C703
2.2uF
C704
0.1uF
C705
0.1uF
C707
27PF
5%
C708
27PF
5%
C709
0.1uF
C710
470PF
5%
C713
1-124-589-11 ELECT
47uF
20%
C750
0.1uF
C751
470PF
5%
C752
0.001uF
10%
C753
0.001uF
10%
C754
0.001uF
10%
C755
10PF
0.5PF
C756
0.47uF
C757
0.1uF
C758
Remark
10uF
0.1uF
470PF
100PF
2.2uF
0.01uF
0.1uF
0.047uF
20%
10%
5%
5%
10%
10%
10%
16V
25V
50V
50V
16V
50V
25V
25V
100V
(M500R)
50V
(M500R)
50V
(M500R)
16V
(M500R)
25V
(M500R)
25V
(M500R)
50V
(M500R)
50V
(M500R)
25V
(M500R)
50V
(M500R)
16V
(M500R)
25V
(M500R)
50V
(M500R)
50V
(M500R)
50V
(M500R)
50V
(M500R)
50V
(M500R)
25V
(M500R)
25V
(M500R)
25V
(M500R)
Ref. No.
CN602
Part No.
Description
Remark
1-506-468-11 PIN, CONNECTOR 3P

< DIODE >
D100
D101
D102
D103
D104
D105
8-719-065-09
8-719-074-47
8-719-065-00
8-719-065-00
8-719-988-61
8-719-058-24
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ5.1-Y (TPH3)
CRS02 (TE85L)
02DZ3.9-X (TPH3)
02DZ3.9-X (TPH3)
1SS355TE-17
RB501V-40TE-17 (M550)
D200
D201
D202
D203
D204
8-719-065-00
8-719-073-01
8-719-073-01
8-719-065-00
8-719-065-00
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ3.9-X (TPH3) (M550)

MA111-TX
MA111-TX
02DZ3.9-X (TPH3)
02DZ3.9-X (TPH3)
D205
D206
D300
D300
D301
D301
8-719-065-13
8-719-801-78
8-719-074-47
8-719-079-97
8-719-074-47
8-719-079-97
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ5.6-Z (TPH3)
1SS184
CRS02 (TE85L) (M550)
CRZ22 (TE85L. SONY) (M500R)
CRS02 (TE85L) (M550)
D302
D302
D303
D303
D304
8-719-074-47
8-719-079-97
8-719-074-47
8-719-079-97
8-719-074-47
DIODE
DIODE
DIODE
DIODE
DIODE
CRS02 (TE85L) (M550)

CRS02 (TE85L) (M550)
CRS02 (TE85L) (M550)
D304
D305
D305
D306
D306
D307
8-719-079-97
8-719-074-47
8-719-079-97
8-719-074-47
8-719-079-97
8-719-074-47
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE

CRS02 (TE85L) (M550)
CRS02 (TE85L) (M550)
CRS02 (TE85L) (M550)
D307
D308
D309
D310
D311
8-719-079-97
8-719-074-47
8-719-074-47
8-719-074-47
8-719-074-47
DIODE
DIODE
DIODE
DIODE
DIODE

CRS02 (TE85L)
CRS02 (TE85L)
CRS02 (TE85L)
CRS02 (TE85L)
D312
D315
D316
D317
D318
8-719-065-48
8-719-073-01
8-719-073-01
8-719-049-38
8-719-065-09
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ18-Y (TPH3)
MA111-TX
MA111-TX
1N5404TU
02DZ5.1-Y (TPH3)
D320
D400
D401
D500
D501
8-719-065-13
8-719-065-28
8-719-074-47
8-719-073-01
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ5.6-Z (TPH3)
02DZ9.1-Z (TPH3)
CRS02 (TE85L)
MA111-TX
MA111-TX
D502
D503
D504
D505
D506
8-719-073-01
8-719-065-18
8-719-065-18
8-719-065-46
8-719-065-48
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ16-Z (TPH3)
02DZ18-Y (TPH3)
D507
D508
D509
D510
D511
8-719-065-48
8-719-065-16
8-719-801-78
8-719-065-18
8-719-058-24
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ18-Y (TPH3)
02DZ6.2-Z (TPH3)
1SS184-TE85L
02DZ6.8-Y (TPH3)
RB501V-40TE-17
D512
D513
8-719-065-48 DIODE 02DZ18-Y (TPH3)

8-719-073-01 DIODE MA111-TX
< CONNECTOR/JACK >

* CN100
* CN200
CN300
CN301
* CN400
1-506-984-11 PIN, CONNECTOR (PC BOARD) 2P

1-506-985-11 PIN, CONNECTOR (PC BOARD) 3P (M550)
1-794-068-11 JACK, PIN 6P
(BUS AUDIO IN, AUDIO OUT REAR/FRONT)
CN401
CN402
CN500
* CN501
* CN601
1-766-260-11
1-794-185-21
1-580-907-31
1-568-951-11
1-764-908-11
CONNECTOR, FFC/FPC (ZIF) 7P

CONNECTOR, FPC 14P
PLUG, CONNECTOR (BUS CONTROL IN)
PIN, CONNECTOR 2P
59
Ver 1.1
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
D515
D516
D601
8-719-073-01 DIODE MA111-TX

8-719-073-01 DIODE MA111-TX
8-719-073-01 DIODE MA111-TX
D602
D603
D604
D606
8-719-067-56
8-719-073-01
8-719-067-56
8-719-073-01
DIODE
DIODE
DIODE
DIODE
MA112-TX
MA111-TX
MA112-TX
MA111-TX
D607
D608
D609
D610
D611
8-719-073-01
8-719-067-56
8-719-801-78
8-719-065-18
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
MA112-TX
1SS184-TE85L
02DZ6.8-Y (TPH3)
MA111-TX
L17
L300
L700
D612
D613
D617
D618
D619
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
Q100
Q101
Q102
Q103
Q104
8-729-920-86
8-729-920-21
8-729-920-21
8-729-903-46
8-729-207-56
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1664-QR
DTC314TK-T-146
DTC314TK-T-146
2SB1132-T100-QR
RN1402-TE85L
D620
D621
D623
D624
D625
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
Q105
Q106
Q107
Q200
Q201
8-729-020-67
8-729-230-49
8-729-216-22
8-729-021-95
8-729-021-95
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
XN1A312-TX
2SC2712L-TE85L
2SA1162-YG-TE85L
RN1441-A (TE85L)
RN1441-A (TE85L)
D626
D627
D628
D701
D750
8-719-065-18
8-719-820-05
8-719-820-05
8-719-065-09
8-719-421-69
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
1SS181-TE85L
1SS181-TE85L
02DZ5.1-Y (TPH3) (M500R)
MA133-TX (M500R)
Q204
Q220
Q221
Q222
Q223
8-729-920-21
8-729-207-68
8-729-144-85
8-729-144-85
8-729-230-49
TRANSISTOR
TRANSISTOR
FET
FET
TRANSISTOR
DTC314TK-T-146 (M550)
RN2402-TE85L
2SK1133-T1B
2SK1133-T1B
2SC2712L-TE85L
Q250
Q251
Q254
Q300
Q301
8-729-021-95
8-729-021-95
8-729-920-21
8-729-207-56
8-729-041-38
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN1441-A (TE85L)
RN1441-A (TE85L)
DTC314TK-T-146 (M550)
RN1402-TE85L
2SB1241TV2Q
Q302
Q303
Q400
Q401
Q402
8-729-207-56
8-729-041-38
8-729-931-15
8-729-020-67
8-729-903-46
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN1402-TE85L
2SB1241TV2Q
2SD1858-R-TV2
XN1A312-TX
2SB1132-T100-QR
Q403
Q404
Q500
Q501
Q502
8-729-207-56
8-729-207-56
8-729-207-56
8-729-230-49
8-729-216-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN1402-TE85L
RN1402-TE85L
RN1402-TE85L
2SC2712L-TE85L
2SA1162-YG-TE85L
Q503
Q504
Q505
Q506
Q600
8-729-230-49
8-729-207-56
8-729-216-22
8-729-027-38
8-729-207-68
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712L-TE85L
RN1402-TE85L
2SA1162-YG-TE85L
DTA144EKA-T146
RN2402-TE85L
Q601
Q603
Q604
Q605
Q606
8-729-207-68
8-729-230-49
8-729-207-56
8-729-920-86
8-729-020-67
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN2402-TE85L
2SC2712L-TE85L
RN1402-TE85L
2SD1664-QR
XN1A312-TX
Q607
Q608
Q611
Q750
Q751
8-729-230-49
8-729-230-49
8-729-920-21
8-729-230-49
8-729-207-56
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712L-TE85L
2SC2712L-TE85L
DTC314TK-T-146
2SC2712L-TE85L (M500R)
RN1402-TE85L (M500R)
IC700
IC750
8-759-650-68 IC SAA6588T/V2-118 (M500R)

8-759-385-17 IC NJM4580E (TE2) (M500R)
< JACK >
< SHORT >

FB10
FB11
FB12
FB13
FB16
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
< IC >
IC100
IC101
IC102
IC200
IC201
8-759-653-27
8-759-385-17
8-759-392-22
8-759-593-97
8-759-593-97
IC
IC
IC
IC
IC
TDA7402TR
NJM4580E (TE2)
BA3834F
NJM2160AM-TE2 (M550)
NJM2160AM-TE2 (M550)
IC202
IC300
IC300
IC400
IC401
8-759-385-17
8-759-660-96
8-759-663-88
8-759-527-33
8-752-079-79
IC
IC
IC
IC
IC
NJM4580E (TE2) (M550)

TDA7560 (M550)
TA8268H (M500R)
LB1930M-TLM
CXA2510AQ-T4
IC500
IC501
IC502
IC503
IC601
8-759-701-01
8-759-593-98
8-759-580-33
8-759-668-14
8-759-668-45
IC
IC
IC
IC
IC
NJM2904M
BA8270FV-E2
BA6288FS-E2
PQ09DZ1U
MB90574BPMT-G-262-BND (M550)
IC601
IC602
IC603
IC604
IC605
8-759-668-46
8-759-571-49
8-759-495-76
8-759-540-27
8-759-528-47
IC
IC
IC
IC
IC
MB90574BPMT-G-257-BND (M500R)
XC61AN4102PR
RN5VD33AA-TL
TA78DL06AS
PQ09RA11
IC606
IC607
8-759-277-63 IC TC7W14FU (TE12R)

8-759-684-69 IC HD6432355A26F
60
J500
1-764-270-21 JACK (REMOTE IN)

< COIL >
1-469-549-21 INDUCTOR
1-419-476-31 INDUCTOR
1-469-555-21 INDUCTOR
1uH
250uH
10uH (M500R)
< TRANSISTOR >
MAIN
Ref. No.
Part No.
Description
Remark
< RESISTOR >
Description
Remark
1-216-837-11 METAL CHIP
22K
5%
R220
1-216-841-11 METAL CHIP
47K
5%
R221
R222
1-216-805-11 METAL CHIP

1-216-841-11 METAL CHIP
47
47K
5%
5%
R223
R224
1-216-073-00 METAL CHIP

1-216-049-11 RES-CHIP
10K
1K
5%
5%
R224
R225
R226
1-216-295-00 SHORT
1-216-845-11 METAL CHIP
1-216-057-00 METAL CHIP
0 (M550)
100K
5%
2.2K
5%
R227
1-216-057-00 METAL CHIP
2.2K
R228
8-719-058-24 DIODE RB501V-40TE-17
R229
1-216-298-00 METAL CHIP
2.2
5%
R230
R231
1-216-049-11 METAL CHIP

1-216-049-11 METAL CHIP
1K
1K
5%
5%
R232
R233
R234
R250
1-216-845-11
1-216-841-11
1-216-845-11
1-216-049-11
100K
47K
100K
1K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
(M550)
R250
1-216-295-00 SHORT
0 (M500R)
R251
1-216-049-11 RES-CHIP
1K
5%
1/10W
(M550)
R251
R252
1-216-295-00 SHORT
1-218-725-11 RES-CHIP
0 (M500R)
24K
5%
R253
1-218-725-11 RES-CHIP
24K
5%
R254
1-202-926-11 RES-CHIP
36K
5%
1/10W
(M550)
R255
1-202-926-11 RES-CHIP
36K
5%
1/16W
(M550)
1/16W
(M550)
1/16W
(M550)
R256
R257
R258
R259
R260
1-216-033-00
1-216-033-00
1-216-081-00
1-216-081-00
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
22K
22K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R261
R265
R266
1-216-049-11 METAL CHIP

1-216-081-00 METAL CHIP
1-216-085-00 METAL CHIP
1K
22K
33K
5%
5%
5%
1/10W
1/10W
1/10W
(M550)
R267
1-216-033-00 METAL CHIP
220
5%
R268
1-216-081-00 METAL CHIP
22K
5%
R300
R301
R302
1-216-085-00 METAL CHIP

1-216-085-00 METAL CHIP
1-216-049-11 RES-CHIP
33K
33K
1K
5%
5%
5%
1/10W
(M550)
1/10W
(M550)
1/10W
1/10W
1/10W
R304
R308
R309
R310
R311
1-216-049-11
1-216-025-00
1-216-206-00
1-216-214-00
1-216-089-00
1K
100
2.2K
4.7K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/8W
1/10W
1-216-049-11
1-216-057-00
1-216-025-00
1-216-025-00
1-216-295-00
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
SHORT
1K
2.2K
100
100
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R106
R107
R109
R110
R111
1-216-089-00
1-216-085-00
1-216-025-00
1-216-025-00
1-216-065-00
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
33K
100
100
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R112
R113
R114
R115
R116
1-216-073-00
1-216-073-00
1-216-073-00
1-216-073-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R117
R118
R119
R120
R121
1-216-833-11
1-216-059-00
1-216-001-00
1-216-073-00
1-216-073-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.7K
10
10K
10K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R122
R123
R124
R125
R126
1-216-097-00
1-216-073-00
1-216-073-00
1-216-073-00
1-216-073-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R127
R128
R129
R130
R131
R200
1-216-819-11
1-216-037-00
1-216-295-00
1-216-089-00
1-216-864-11
1-216-049-11
METAL CHIP
METAL CHIP
SHORT
RES-CHIP
SHORT
RES-CHIP
680
5%
330
5%
0 (M550)
47K
5%
0 (M500R)
1K
5%
1/16W
1/10W
R200
1-216-295-00 SHORT
0 (M500R)
R201
1-216-049-11 RES-CHIP
1K
R201
R202
1-216-295-00 SHORT
1-218-725-11 RES-CHIP
0 (M500R)
24K
5%
R203
1-218-725-11 RES-CHIP
24K
5%
R204
1-202-926-11 RES-CHIP
36K
5%
R205
1-202-926-11 RES-CHIP
36K
5%
R206
R207
R208
R209
1-216-033-00
1-216-033-00
1-216-081-00
1-216-081-00
220
220
22K
22K
5%
5%
5%
5%
R214
1-216-097-00 RES-CHIP
100K
5%
R215
R216
1-216-081-00 METAL CHIP

1-216-085-00 METAL CHIP
22K
33K
5%
5%
R217
1-216-033-00 METAL CHIP
220
5%
R218
1-216-081-00 METAL CHIP
22K
5%
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
Part No.
R220
R100
R101
R102
R103
R105
5%
Ref. No.
1/10W
1/10W
(M550)
1/16W
(M550)
1/10W
1/10W
1/10W
1/10W
1/10W
(M550)
1/10W
1/10W
(M550)
1/10W
(M550)
1/10W
(M550)
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
5%
1/16W
(M550)
1/16W
(M500R)
1/16W
1/16W
(M550)
1/10W
1/10W
(M500R)
1/16W
1/10W
(M550)
1/10W
(M550)
1/10W
(M550)
1/10W
1/10W
1/16W
(M550)
1/16W
(M550)
1/16W
(M550)
1/16W
(M550)
61
MAIN
Ref. No.
Part No.
Description
R312
R313
R314
R316
R317
1-216-214-00
1-216-206-00
1-216-089-00
1-216-295-00
1-216-230-00
RES-CHIP
RES-CHIP
RES-CHIP
SHORT
RES-CHIP
4.7K
2.2K
47K
0
22K
5%
5%
5%
1/8W
1/8W
1/10W
5%
1/8W
R330
R400
R401
R402
R403
1-216-049-11
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R404
R405
R406
R407
R408
1-216-027-00
1-216-027-00
1-216-109-00
1-216-109-00
1-216-075-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
120
120
330K
330K
12K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R409
R410
R411
R412
R413
1-216-079-00
1-216-079-00
1-216-075-00
1-216-198-00
1-216-681-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
18K
18K
12K
1K
18K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/8W
1/10W
R414
R415
R416
R417
R418
1-216-150-00
1-216-150-00
1-216-057-00
1-216-150-00
1-216-150-00
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10
10
2.2K
10
10
5%
5%
5%
5%
5%
1/8W
1/8W
1/10W
1/8W
1/8W
R419
R420
R421
R422
R423
1-216-065-00
1-216-073-00
1-216-073-00
1-216-113-00
1-216-089-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
4.7K
10K
10K
470K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R500
R501
R502
R503
R504
1-216-081-00
1-216-097-00
1-216-065-00
1-216-073-00
1-216-085-00
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
22K
100K
4.7K
10K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R505
R506
R507
R508
R509
1-216-681-11
1-216-833-11
1-218-716-11
1-216-833-11
1-216-809-11
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
18K
10K
10K
10K
100
0.5%
5%
0.5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R510
R511
R512
R513
R514
1-216-089-00
1-216-845-11
1-216-809-11
1-216-841-11
1-216-025-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
47K
100K
100
47K
100
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/10W
R515
R516
R517
R518
R519
1-216-057-00
1-216-073-00
1-216-809-11
1-216-025-00
1-216-134-00
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
2.2K
10K
100
100
2.2
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
1/8W
R520
R521
R522
R523
R524
1-216-089-00
1-216-134-00
1-216-073-00
1-216-134-00
1-216-025-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
47K
2.2
10K
2.2
100
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/8W
1/10W
R525
R526
R527
1-216-833-11 RES-CHIP
1-216-017-00 RES-CHIP
1-216-049-11 RES-CHIP
10K
47
1K
5%
5%
5%
1/16W
1/10W
1/10W
62
Remark
Ref. No.
Part No.
Description
Remark
R600
R601
1-216-081-00 RES-CHIP
1-216-295-00 SHORT
22K
5%
0 (M550)
1/10W
R602
R603
1-216-025-00 RES-CHIP
1-216-864-11 METAL CHIP
100
0
5%
5%
R605
R606
R607
1-216-845-11 METAL CHIP

1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
100K
5%
5%
5%
1/10W
1/16W
(M550)
1/16W
1/16W
1/16W
R608
R609
R611
R612
R613
1-216-845-11
1-216-845-11
1-216-097-00
1-216-025-00
1-216-073-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
100K
100K
100K
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/10W
R614
R615
R616
R617
R618
1-216-025-00
1-216-025-00
1-216-073-00
1-216-097-00
1-216-073-00
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
100
100
10K
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R619
R620
R621
R622
R623
1-216-845-11
1-216-821-11
1-216-049-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100K
1K
1K
100K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R624
R625
R626
R632
R633
1-216-845-11
1-216-295-00
1-216-295-00
1-216-825-11
1-216-845-11
METAL CHIP
SHORT
SHORT
METAL CHIP
METAL CHIP
100K
5%
1/16W
0 (M500R: TYPE A, D/M550)
0 (M500R: TYPE A, C/M550)
2.2K
5%
1/16W
100K
5%
1/16W
R634
R635
R636
R638
1-216-839-11
1-216-821-11
1-216-097-00
1-216-845-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
33K
1K
100K
100K
5%
5%
5%
5%
R639
1-216-845-11 METAL CHIP
100K
5%
1/16W
1/16W
1/10W
1/16W
(M500R)
1/16W
R640
R641
R642
R643
R644
1-216-845-11
1-216-845-11
1-216-097-00
1-216-085-00
1-216-073-00
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
33K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/10W
R645
R646
R647
R648
R649
1-216-073-00
1-216-061-00
1-216-025-00
1-216-037-00
1-216-845-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
10K
3.3K
100
330
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/16W
R650
R651
R652
R653
R654
1-216-049-11
1-216-025-00
1-216-049-11
1-216-081-00
1-216-097-00
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
1K
100
1K
22K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R655
R656
R657
R658
R659
1-216-081-00
1-216-097-00
1-216-821-11
1-216-821-11
1-216-049-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
22K
100K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/10W
R660
R661
R662
R663
1-216-097-00
1-216-097-00
1-216-813-11
1-216-033-00
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100K
100K
220
220
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
R664
1-216-097-00 RES-CHIP
100K
5%
1/10W
R756
1-216-061-00 METAL CHIP
3.3K
5%
R665
R666
R667
R668
R669
1-216-097-00
1-218-716-11
1-216-809-11
1-218-716-11
1-216-809-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
100
10K
100
5%
0.5%
5%
0.5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R757
1-216-097-00 RES-CHIP
100K
5%
R758
1-216-121-00 RES-CHIP
1M
5%
R759
1-216-025-00 RES-CHIP
100
5%
R670
R671
R672
R673
R674
1-216-025-00
1-216-025-00
1-216-025-00
1-216-025-00
1-216-295-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT
100
100
100
100
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R760
1-216-295-00 SHORT
0 (M500R)
R675
R676
R677
R678
R679
1-216-025-00
1-216-809-11
1-216-025-00
1-216-809-11
1-216-845-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100K
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/16W
1/16W
R680
R681
R682
R700
1-216-845-11
1-216-845-11
1-216-097-00
1-216-001-00
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
100K
100K
100K
10
5%
5%
5%
5%
R701
1-216-113-00 METAL CHIP
470K
5%
1/16W
1/16W
1/10W
1/10W
(M500R)
1/10W
(M500R)
1-216-049-11 RES-CHIP
1K
5%
1/10W
(M500R)
1/16W
(M500R)
1/16W
(M500R)
1/16W
(M500R)
1/16W
(M500R)
R703
1-216-830-11 METAL CHIP
5.6K
5%
R704
1-216-817-11 METAL CHIP
470
5%
R705
1-216-809-11 METAL CHIP
100
5%
R706
1-216-809-11 METAL CHIP
100
5%
R718
R719
1-216-295-00 SHORT
1-216-845-11 METAL CHIP
R720
1-216-845-11 METAL CHIP
R738
1-216-025-00 RES-CHIP
R739
1-216-295-00 SHORT
0 (M550)
100K
5%
1/16W
(M500R: TYPE B, C)
100K
5%
1/16W
(M500R: TYPE B, D)
100
5%
1/10W
(M500R)
0 (M500R)
R740
1-216-864-11 METAL CHIP
5%
R741
1-216-864-11 METAL CHIP
5%
R742
1-216-864-11 METAL CHIP
5%
R743
1-216-864-11 METAL CHIP
5%
R750
1-216-057-00 METAL CHIP
2.2K
5%
R751
1-216-073-00 METAL CHIP
10K
5%
R752
1-216-073-00 METAL CHIP
10K
5%
R753
1-216-065-00 RES-CHIP
4.7K
5%
R754
1-216-057-00 METAL CHIP
2.2K
5%
R755
1-216-057-00 METAL CHIP
2.2K
5%
RV400
RV401
1-238-090-11 RES, ADJ, CERMET

1-238-090-11 RES, ADJ, CERMET
10K
10K
< TUNER >

< THERMISTOR >
TH300
TH301
TH601
1-810-940-11 THERMISTOR, POSITIVE

< VIBRATOR >
X600
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X601
1-767-833-21 VIBRATOR, CERAMIC (3.68MHz)
X602
X700
1-579-242-41 VIBRATOR, CRYSTAL (4.332MHz) (M500R)
**************************************************************
1-677-721-11 SUB BOARD
**********
< CAPACITOR >
C900
0.1uF
10%
25V
< CONNECTOR >

CN900
1/10W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
1-233-412-11 RES, CHIP NETWORK 1K (3216)

1-233-810-21 RES, NETWORK 100K (3216)
< VARIABLE RESISTOR >
1/16W
(M500R)
1/16W
(M500R)
1/16W
(M500R)
1/16W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
1/10W
(M500R)
< COMPOSITION CIRCUIT BLOCK >

RB13
RB14
R702
SUB

< DIODE >
D900
D901
D902
D903
D904
8-719-065-18
8-719-065-18
8-719-073-01
8-719-065-09
8-719-079-10
DIODE 02DZ6.8-Y (TPH3)

DIODE MA111-TX
LED CL-220UB-X-TS
(CASSETTE SLOT INDICAOR)
D905
D906
D907
D908
8-719-072-57
8-719-065-18
8-719-065-48
8-719-065-48
LED CL-170UB-X-T (Z)

DIODE 02DZ18-Y (TPH3)
< IC >
IC900
8-749-012-25 IC RS-170-TU
63
SUB
Ref. No.
SWITCH
Part No.
Description
Remark
< TRANSISTOR >

Q900
Q901
RN1402-TE85L
RN2402-TE85L
< RESISTOR >

R900
R901
R902
R903
R905
1-216-025-00
1-216-041-00
1-216-085-00
1-216-021-00
1-216-049-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100
470
33K
68
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >

S900
S901
1-692-135-21 SWITCH, KEY BOARD (Z)

1-762-947-21 SWITCH, PUSH (1 KEY)
(CASSETTE IN/OUT DETECT)
S902
1-692-135-21 SWITCH, KEY BOARD (RESET)
**************************************************************
A-3326-298-A SWITCH BOARD, COMPLETE
***********************
For the parts on the SWITCH board, replace the entire mounted board.
**************************************************************
MISCELLANEOUS
**************
6
9
9
81
115
117
F1
1-792-584-11 CABLE, FLAT

(M500R)
1-677-340-11 FLEXIBLE BOARD
1-777-246-21 CORD (WITH CONNECTOR) (ANT)
1-790-375-11 CORD (WITH CONNECTOR)
(SUB OUT(MONO)) (M550)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE)
M601
X-3378-769-1 MOTOR ASSY (SERVICE USE)

(FRONT PANEL OPEN/CLOSE)
M901
A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL)
HP901 1-500-157-21 HEAD, MAGNETIC (PLAYBACK)
************************************************************
**************
HARDWARE LIST
**************
#1
#2
#3
#6
#7
7-685-792-09
7-685-793-09
7-621-772-09
7-685-104-19
7-627-553-17

SCREW +B 2X3
SCREW +P 2X6 TYPE2 NON-SLIT
PRECISION SCREW +P 2X2 TYPE3
#8
7-624-102-04 STOP RING 1.5, TYPE -E
#9
7-627-553-28 SCREW,PRECISION +P 2X2.5
#10
7-685-794-09 SCREW +PTT 2.6X10 (S)
#12
7-624-104-04 STOP RING 20, TYPE-E
************************************************************
ACCESSORIES & PACKING MATERIALS
*******************************
1-418-812-41 WIRELESS REMOTE COMMANDER (RM-X94)
(M550)
1-418-812-71 WIRELESS REMOTE COMMANDER (RM-X96)
(M500R)
64
Ref. No.
Part No.
Description
Remark
3-047-781-11 MANUAL, INSTRUCTION

(ENGLISH, FRENCH, SPANISH) (M550)
(ENGLISH, SPANISH, SWEDISH, PORTUGUESE)
(M500R: AEP, UK)
(FRENCH, GERMAN,DUTCH, ITALIAN, GREEK)
(M500R: AEP)
3-047-783-31 MANUAL, INSTRUCTION (GERMAN)
(M500R: GERMAN)
(ENGLISH, CZECK, POLISH, TURKISH, RUSSIAN)
(M500R: SOUTH EUROPEAN)
3-047-782-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH, FRENCH, SPANISH) (M550)
(ENGLISH, SPANISH, SWEDISH, PORTUGUESE)
(M500R: AEP, UK)
(FRENCH, GERMAN, DUTCH, ITALIAN, GREEK)
(M500R: AEP, GERMAN)
(ENGLISH, CZECK, POLISH, TURKISH, RUSSIAN)
(M500R: SOUTH EUROPEAN)
3-044-623-01 HOLDER, BATTERY (FOR RM-X94/X96)
************************************************************
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTION

*************************************
501
502
503
504
505
* 506
507
508
509
510
511
512
1-465-459-21 ADAPTER, ANTENNA (M500R)

(M500R)
3-014-370-21 FRAME, FITTING
3-030-929-02 SPRING, FITTING
3-048-118-01
X-3366-405-1
3-934-325-01
X-3378-770-1
3-916-012-01
KEY
SCREW ASSY (EXP), FITTING(M500R)
SCREW (+K 5X8 TP)
COLLAR ASSY
BRACKET (ND), FITTING ASSIST (M550)
X-3368-725-1 SCREW ASSY, FITTING (M550)

3-934-325-01 SCREW (+K 5X8 TP)
Ref. No.
Part No.
XR-M500R
Description
501
Remark
502
ANTENNA ADAPTER
1
POWER CORD
1
507
BUSHING
1
FITTING SCREW
1
XR-M550
503
510
POWER CORD
1
FITTING SUPPORT (ND)

1
511
+ P4 6
1
+ P4 12
1
504
505
506
KEY 1
FRAME 1
508
+ K5 8
2
FITTING SPRING
2
509
COLLAR 1
512
+K8
4
65
XR-M500R/M550
MEMO
66
XR-M500R/M550
US Model
Canadian Model
SERVICE MANUAL
XR-M550
AEP Model
UK Model
XR-M500R
SUPPLEMENT-1
File this supplement with the service manual.
Subject: Board Modification

(ECN-CSA03404/CSB02152)
In this set, following boards have been changed in the midway of production.
Only XR-M550 is the object of changing MAIN/SUB boards.
TABLE OF CONTENTS
1.
NEW/FORMER TYPE DISCRIMINATION ............ 2
2.
DIAGRAMS
2-1. Note for Printed Wiring Boards and

Schematic Diagrams ..............................................................
2-2. Printed Wiring Boards
MAIN Board (Component Side) (XR-M550 Only) ........
2-3. Printed Wiring Boards
MAIN Board (Conductor Side) (XR-M550 Only) ........
2-4. Schematic Diagram
MAIN Board (1/4) (XR-M550 Only) ..............................
2-8. Printed Wiring Boards SUB Board (XR-M550 Only) ....
2-9. Schematic Diagram SUB Board (XR-M550 Only) .......
2-10. Printed Wiring Boards DISPLAY Board ........................
2-11. Schematic Diagram DISPLAY Board ............................
3
4
5
6
7
8
9
10
11
12
13
3.
EXPLODED VIEWS ....................................................... 14
4.
ELECTRICAL PARTS LIST ...................................... 14
1. NEW/FORMER TYPE DISCRIMINATION

MAIN Board (Component Side) (XR-M550 only)
Former type : 1-677-719-11

New Type : 1-680-700-11
SUB Board (Component Side) (XR-M550 only)
Former type : 1-677-721-11

New Type : 1-680-701-11
DISPLAY Board (Component Side)
Former type : 1-677-725-11

New Type : 1-677-725-12
2. DIAGRAMS
2-1.
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:

X : parts extracted from the component side.
Y : parts extracted from the conductor side.
b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from

the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
DISPLAY board is four-layer printed board.

However, the patterns of layers 2 and 3 have not been included in this diagrams.
Note on Schematic Diagram:

All capacitors are in F unless otherwise noted. pF: F
50 WV or less are not indicated except for electrolytics
and tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.
f
: internal component.
C : panel designation.
U : B+ Line.
H : adjustment for repair.
Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
Voltages are dc with respect to ground under no-signal
(detuned) conditions.
no mark : FM
(
) : AM
: TAPE PLAYBACK
Voltages are taken with a VOM (Input impedance 10 M).
Circled numbers refer to waveforms.
Signal path.
F : FM
f : AM
L : BUS AUDIO IN
E : TAPE PLAY
XR-M500R/M550
2-2. PRINTED WIRING BOARDS MAIN Board (Component Side)
(XR-M550 Only)
Ref. No.
Location
Ref. No.
D100
D103
D104
D200
D201
D202
D203
D205
D206
D300
D301
D302
D303
D304
D305
D306
D307
D310
D311
D312
D316
D400
D500
D501
D502
D505
D506
D507
D508
D509
D511
D513
D606
D607
D610
D611
D627
D628
D-13
I-9
D-13
B-9
I-5
H-6
B-9
J-4
H-6
B-7
B-7
B-6
B-7
B-8
B-8
B-8
B-8
C-4
C-4
E-3
B-6
F-3
F-4
B-1
I-4
F-4
G-4
G-4
G-4
H-2
H-4
G-4
H-5
D-2
J-3
J-6
J-9
I-5
IC503
IC601
IC602
IC606
IC607
Location
H-3
F-6
E-5
J-7
I-8
IC100
IC101
IC102
IC202
IC400
IC401
IC501
IC502
F-11
G-9
J-6
C-11
F-3
H-11
H-4
G-2
Q100
Q103
Q104
Q106
Q107
Q200
Q201
Q204
Q220
Q221
Q222
Q223
Q250
Q251
Q254
Q300
Q302
Q402
Q403
Q404
Q405
Q406
Q500
Q501
Q502
Q503
Q504
Q505
Q506
Q600
Q603
Q604
Q605
Q606
Q607
Q608
Q611
Q612
E-13
E-8
F-8
K-6
K-6
B-11
B-11
C-12
I-6
I-6
I-6
J-4
B-10
B-10
C-12
E-4
E-4
E-3
F-3
H-11
G-3
G-3
H-3
J-2
I-2
F-4
F-4
G-5
I-4
E-6
G-7
J-4
F-9
F-9
D-4
D-4
I-9
F-9
R228
D-9
(Page 12)
XR-M500R/M550
2-3. PRINTED WIRING BOARDS MAIN Board (Conductor Side)
(XR-M550 Only)
Ref. No.
(Page 10)
D308
D309
D317
D401
D503
D504
D510
D515
D609
D612
D613
D617
D618
D619
D620
D621
D623
Location
D-4
D-4
C-2
D-2
B-3
B-2
I-3
G-2
E-5
J-2
J-2
K-9
K-9
J-9
J-9
K-9
J-9
Ref. No.
Location
D624
D625
D626
D640
D641
J-10
J-10
J-9
F-4
F-4
IC200
IC201
IC300
IC500
IC604
IC605
D-10
D-11
A-7
H-3
C-1
D-1
Q301
Q303
Q400
E-3
E-3
G-3
XR-M500R/M550
2-4.
(XR-M550 Only)
(Page
7)
(Page 9)
(Page 8)
XR-M500R/M550
2-5.
(XR-M550 Only)
(Page 6)
(Page 8)
(Page 9)
XR-M500R/M550
Ver 1.1
2-6.
SCHEMATIC DIAGRAM MAIN Board (3/4) (XR-M550 Only)
(Page 6)
(Page 7)
(Page
9)
XR-M500R/M550
2-7.
SCHEMATIC DIAGRAM MAIN Board (4/4) (XR-M550 Only)
(Page 7)
(Page 6)
(Page 13)
(Page 8)
(Page 11)
XR-M500R/M550
2-8. PRINTED WIRING BOARDS SUB Board
(XR-M550 Only)
Semiconductor
Location
Ref. No.
Location
D900
D901
D902
D903
D904
D905
D906
B-1
A-1
A-2
A-1
A-9
A-10
A-12
IC900
A-12
Semiconductor
Location
Ref. No.
Location
D907
D908
A-9
A-10
Q900
Q901
B-12
A-12
(Page 5)
10
10
XR-M500R/M550
2-9.
SCHEMATIC DIAGRAM SUB Board
(XR-M550 Only)
(Page 9)
11
11
XR-M500R/M550
2-10.
PRINTED WIRING BOARDS DISPLAY Board
Semiconductor
Location
Ref. No.
Location
D910
C-2
IC901
IC902
IC903
B-7
B-8
C-2
LED901
LED903
LED904
LED907
LED908
LED911
LED912
LED913
LED914
LED915
LED916
A-1
B-2
A-2
B-2
B-2
B-13
B-12
C-2
C-13
B-13
A-13
Q901
Q902
B-2
B-1
(Page 4)
Semiconductor
Location
Ref. No.
Location
D902
D903
D904
D905
D906
D907
D908
D909
B-12
C-11
C-11
C-10
C-11
B-11
C-11
C-12
LED905
LED906
LED917
LED918
LED919
LED920
LED921
B-10
C-10
B-3
C-3
B-2
B-2
A-2
Q903
Q904
Q905
Q906
Q910
B-3
C-4
C-4
C-3
C-12
12
12
XR-M500R/M550
2-11. SCHEMATIC DIAGRAM DISPLAY Board
(Page 9)
13
13
DISPLAY
3. EXPLODED VIEWS
4. ELECTRICAL PARTS LIST
DIFFERENT PARTS LIST

Page
Former Type
Ref. No. Part No.
51
53
* 120
Description
New Type
Remark
Ref. No. Part No.
Description
1-677-721-11 SUB BOARD
* 5
* 5
1-677-721-11 SUB BOARD (M500R)

1-680-701-11 SUB BOARD (M550)
A-3294-887-A MAIN BOARD, COMPLETE (M550)
* 120
Remark
Items marked * are not stocked since they are seldom required for routine service.
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
one.
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable

are seldom required for routine service.
SEMICONDUCTORS
In each case, u: , for example:
uA. .
: A. .
uPA. . : PA. .
uPB. . : PB. .
uPC. . : PC. .
uPD. . : PD. .
CAPACITORS
uF: F
COILS
uH: H
Ref. No.
Part No.
*
*
A-3283-018-A DISPLAY BOARD, COMPLETE (M550)

A-3283-019-A DISPLAY BOARD, COMPLETE (M500R)
************************
Description
Remark
*
*
1-694-685-11
1-694-686-11
1-694-687-11
3-045-702-01
3-045-703-02

PLATE (LCD) (MAIN), LIGHT GUIDE
*
*
*
*
*
3-045-704-01
3-045-705-03
3-045-706-01
3-045-707-01
3-045-708-01
SHEET (MAIN), DIFFUSION

BRACKET (LCD) (SUB)
PLATE (SUB) SUB, LIGHT GUIDE
Description
Remark
< IC >
IC901
IC902
IC903
8-759-653-26 IC LC75878W
8-759-653-26 IC LC75878W
8-749-012-25 IC RS-170-TU

< LED >
C901
C902
C903
C904
C905
1-164-004-11
1-164-004-11
1-165-176-11
1-165-176-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.047uF
0.047uF
0.047uF
10%
10%
10%
10%
10%
25V
25V
16V
16V
16V
C906
C907
C908
C909
C910
1-115-412-11
1-164-004-11
1-165-176-11
1-165-176-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
0.1uF
0.047uF
0.047uF
0.047uF
5%
10%
10%
10%
10%
25V
25V
16V
16V
16V
C911
C912
C913

680PF
0.1uF
0.1uF
5%
10%
10%
25V
25V
25V
CN901
Part No.
< LIQUID CRYSTAL DISPLAY >
< CAPACITOR >
< CONNECTOR >
Ref. No.
When indicating parts by reference

number, please include the board.
LED901
LED903
LED904
LED905
8-719-079-49
8-719-076-58
8-719-076-58
8-719-079-26
LED
LED
LED
LED
NSSW450-BRSTVR (ILLUMINATION)
NSSW440-BRS (LCD BACK LIGHT)
NSSB440-WRST-THR
(LCD BACK LIGHT)
LED906 8-719-079-26 LED NSSB440-WRST-THR
(LCD BACK LIGHT)
LED907
LED908
LED911
LED912
LED913
8-719-076-58
8-719-076-58
8-719-076-58
8-719-076-58
8-719-076-58
LED
LED
LED
LED
LED

LED914
LED915
LED916
LED917
LED918
8-719-076-58
8-719-076-58
8-719-076-58
8-719-078-39
8-719-078-39
LED
LED
LED
LED
LED

CL-170SR-CD-T (ILLUMINATION)
CL-170SR-CD-T (ILLUMINATION)

LED921 8-719-078-39 LED CL-170SR-CD-T (MODE o)
1-794-184-11 CONNECTOR, FPC (ZIF) 14P

< SWITCH >
< DIODE >
14
D902
D903
D904
D905
D906
8-719-422-41
8-719-977-12
8-719-977-12
8-719-977-12
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA8051-L-TX
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
D907
D908
D909
D910
8-719-977-12
8-719-420-14
8-719-422-80
8-719-978-33
DIODE
DIODE
DIODE
DIODE
MA8068-M-TX
MA8082-M (TX)
MA8075-H-TX
UDZS-TE17-6.8B
14
LSW901 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (TA)

(M500R)
LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOUND)
LSW903 1-771-883-11 SWITCH, TACTILE (WITH LED) (D-BASS)
(M500R)
LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU)
LSW905 1-771-883-11 SWITCH, TACTILE (WITH LED) (DISC +)
LSW906
LSW907
LSW908
LSW909
1-771-883-11
1-771-476-11
1-771-476-11
1-771-476-11
SWITCH, TACTILE (WITH LED) (. m)

SWITCH, KEY BOARD (WITH LED) (LIST)
SWITCH, KEY BOARD (WITH LED) (> M)
SWITCH, KEY BOARD (WITH LED) (ENTER)
DISPLAY
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
R932
R933
R934
R935
R936
1-216-037-00
1-216-033-00
1-216-025-11
1-216-033-00
1-216-025-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
330
220
100
220
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R937
R938
R940
R941
R942
1-216-033-00
1-216-025-11
1-216-033-00
1-216-025-11
1-216-025-11
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
220
100
220
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R943
R945
R947
R949
R951
1-216-025-11
1-216-035-00
1-216-035-00
1-216-029-00
1-216-029-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
270
270
150
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R953
R955
R957
R959
R961
1-216-029-00
1-216-029-00
1-216-029-00
1-216-029-00
1-216-029-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
150
150
150
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R963
R964
R965
R967
R968
1-216-029-00
1-216-811-11
1-216-833-11
1-216-805-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
150
10K
47
1K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R969
R970
R971
R972
R974
1-216-809-11
1-216-809-11
1-216-809-11
1-216-841-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
47K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R975
R976
R977
R978
R979
1-216-825-11
1-216-825-11
1-216-825-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
2.2K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R980
R981
R982
R984
R985
1-216-809-11
1-216-821-11
1-216-841-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
47K
2.2K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R986
R987
R988
R989
R990
1-216-825-11
1-216-825-11
1-216-037-00
1-216-821-11
1-216-025-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
2.2K
2.2K
330
1K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/10W
(M550)
R991
1-216-025-11 RES-CHIP
100
5%
R992
1-216-025-11 RES-CHIP
100
5%
1/10W
(M550)
1/10W
(M550)
LSW910 1-771-883-11 SWITCH, TACTILE (WITH LED) (DISC )

LSW911
LSW912
LSW913
LSW914
LSW915
1-771-883-11
1-771-476-11
1-771-883-11
1-771-883-11
1-771-883-11
LSW916
LSW917
LSW918
LSW919
1-771-883-11
1-771-883-11
1-771-883-11
1-771-476-11
SWITCH, TACTILE (WITH LED) (CLOSE)

SWITCH, KEY BOARD (WITH LED) (OPEN)

SWITCH, TACTILE (WITH LED) (SHUF 2)
SWITCH, TACTILE (WITH LED) (REP 1)
SWITCH, KEY BOARD (WITH LED) (AF)
(M500R)
LSW921 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (+)
LSW922 1-771-476-11 SWITCH, KEY BOARD (WITH LED)
(M500R: PTY DSPL/M550: DSPL)
LSW923 1-771-476-11 SWITCH, KEY BOARD (WITH LED) ()
LSW924 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF)
LSW925 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
< TRANSISTOR >
Q901
Q902
Q903
Q904
Q905
8-729-900-53
8-729-106-60
8-729-106-60
8-729-900-53
8-729-904-66
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q906
Q910
DTC114EKA-T146
2SB1132-T101-QR
2SB1132-T101-QR
DTC114EKA-T146
DTD113EK-T-146
DTD113EK-T-146
DTC114EKA-T146
< RESISTOR >

R901
R902
R903
R904
R905
1-218-879-11
1-218-875-11
1-218-871-11
1-218-867-11
1-218-859-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
22K
15K
10K
6.8K
3.3K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R906
R907
R908
R909
R910
1-218-859-11
1-218-855-11
1-218-851-11
1-218-851-11
1-218-847-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
2.2K
1.5K
1.5K
1K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R911
R912
R913
R914
R915
1-219-286-11
1-219-286-11
1-219-286-11
1-218-871-11
1-218-867-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
10K
6.8K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R916
R917
R918
R919
R920
1-218-863-11
1-218-859-11
1-218-855-11
1-218-851-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
3.3K
2.2K
1.5K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R921
R922
R923
R924
R926
1-218-847-11
1-219-286-11
1-219-286-11
1-219-286-11
1-216-829-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
1K
680
680
680
4.7K
2%
2%
2%
2%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R927
R928
R929
R930
R931
1-216-833-11
1-216-827-11
1-216-833-11
1-216-829-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
3.3K
10K
4.7K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< SWITCH >

S901
1-771-027-21 SWITCH, KEYBOARD (WITH LED) (RESET)
S902
1-771-884-11 SWITCH, TACTILE (WITH LED) (MODE o)
**************************************************************
15
MAIN
Ref. No.
Part No.

*********************
Description
Remark
*
*
*
3-019-565-01
3-044-471-01
3-045-759-01
7-685-792-09
7-685-793-09
BRACKET (IC)
HEAT SINK
HEAT SINK (REG)
7-685-795-09 SCREW +PTT 2.6X12 (S)

< BUZZER >
BZ600
Part No.
Description
Remark
C205
1-126-157-11 ELECT
10uF
20%
16V
C206
C208
C209
C210
C211
1-107-826-11
1-164-360-11
1-164-360-11
1-162-927-11
1-126-157-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
100PF
10uF
10%
16V
16V
16V
50V
16V
C220
C221
C223
C224
C225
1-124-234-00
1-124-234-00
1-126-159-11
1-125-972-61
1-164-346-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
22uF
22uF
0.47uF
100uF
1uF
20%
20%
20%
20%
16V
16V
50V
16V
16V
C226
C227
C228
C229
C230
1-124-257-00
1-164-346-11
1-107-826-11
1-162-964-11
1-115-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2.2uF
1uF
0.1uF
0.001uF
1uF
20%
50V
16V
16V
50V
10V
C231
C250
C251
C252
C253
1-115-156-11
1-164-357-11
1-164-357-11
1-125-972-61
1-125-972-61
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
1uF
0.001uF
0.001uF
100uF
100uF
C254
C255
C258
C259
C260
1-126-157-11
1-126-157-11
1-164-360-11
1-164-360-11
1-162-927-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.1uF
0.1uF
100PF
5%
16V
16V
16V
16V
50V
C261
C269
C304
C305
C306
1-126-157-11
1-162-964-11
1-107-826-11
1-126-157-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
10uF
0.001uF
0.1uF
10uF
0.1uF
20%
10%
10%
20%
10%
16V
50V
16V
16V
16V
C307
C308
C309
C310
C311
1-162-919-11
1-162-919-11
1-162-919-11
1-162-919-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
22PF
22PF
22PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C312
C313
C314
C315
C316
1-162-919-11
1-162-964-11
1-126-160-11
1-126-572-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
22PF
0.001uF
1uF
4.7uF
100PF
5%
10%
20%
20%
5%
50V
50V
50V
35V
50V
C318
C319
C320
C321
C400
1-162-964-11
1-126-936-11
1-107-826-11
1-115-467-11
1-165-128-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
3300uF
0.1uF
0.22uF
0.22uF
10%
20%
10%
10%
50V
16V
16V
10V
16V
C401
C402
C403
C404
C405
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C406
C407
C408
C409
C410
1-162-927-11
1-164-156-11
1-162-961-11
1-162-961-11
1-162-961-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
330PF
330PF
330PF
5%
10%
10%
10%
50V
25V
50V
50V
50V
C411
330PF
10%
50V
5%
20%
1-504-920-11 BUZZER
< CAPACITOR >
C101
C102
C103
C105
C107
1-115-156-11
1-162-918-11
1-165-176-11
1-165-176-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
18PF
0.047uF
0.047uF
0.022uF
C110
C111
C113
C114
C115
1-107-826-11
1-164-505-11
1-164-227-11
1-104-942-11
1-104-942-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
2.2uF
0.022uF
1uF
1uF
10%
20%
20%
16V
16V
25V
50V
50V
C116
C118
C119
C120
C121
1-115-156-11
1-115-156-11
1-162-961-11
1-115-156-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
330PF
10%
1uF
0.0047uF 10%
10V
10V
50V
10V
50V
C123
C124
C125
C126
C127
1-162-970-11
1-107-823-11
1-124-589-11
1-164-156-11
1-124-584-00
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
0.47uF
47uF
0.1uF
100uF
25V
16V
16V
25V
10V
C128
C129
C130
C131
C132
1-115-156-11
1-115-156-11
1-115-156-11
1-115-156-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
1uF
1uF
10V
10V
10V
10V
10V
C137
C138
C139
C140
C141
1-115-156-11
1-115-156-11
1-115-156-11
1-162-919-11
1-164-505-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
22PF
2.2uF
10V
10V
10V
50V
16V
C142
C143
C144
C145
C146
1-115-156-11
1-126-157-11
1-164-156-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
10uF
0.1uF
0.1uF
0.1uF
C147
C150
C168
C170
C200
1-164-156-11
1-162-927-11
1-164-156-11
1-124-234-00
1-164-357-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
100PF
0.1uF
22uF
0.001uF
20%
5%
25V
50V
25V
16V
50V
C201
C202
C203
C204
1-164-357-11
1-125-972-61
1-125-972-61
1-126-157-11
CERAMIC CHIP
ELECT
ELECT
ELECT
0.001uF
100uF
100uF
10uF
5%
20%
20%
20%
50V
16V
16V
16V
16
Ref. No.
5%
10%
10%
10%
10%
10%
10%
20%
20%
5%
20%
5%
10V
50V
16V
16V
25V
10V
16V
25V
25V
25V
10%
10%
5%
5%
20%
20%
20%
20%
10V
50V
50V
16V
16V
MAIN
Ref. No.
Part No.
Description
C412
C413
C414
C415
1-164-156-11
1-126-157-11
1-124-234-00
1-162-970-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.1uF
10uF
22uF
0.01uF
Remark
20%
20%
10%
25V
16V
16V
25V
C416
C418
C419
C420
C421
1-162-970-11
1-124-589-11
1-107-823-11
1-107-823-11
1-162-925-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
0.47uF
0.47uF
68PF
10%
20%
10%
10%
5%
25V
16V
16V
16V
50V
C422
C423
C424
C425
C426
1-107-826-11
1-107-826-11
1-107-823-11
1-126-935-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
0.47uF
470uF
0.01uF
10%
10%
10%
20%
10%
16V
16V
16V
16V
25V
C427
C500
C501
C502
C505
1-164-245-11
1-107-826-11
1-107-826-11
1-162-964-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.015uF
0.1uF
0.1uF
0.001uF
0.1uF
10%
10%
10%
10%
10%
25V
16V
16V
50V
16V
C506
C507
C508
C509
C510
1-124-229-00
1-162-970-11
1-107-826-11
1-124-589-11
1-162-970-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
33uF
0.01uF
0.1uF
47uF
0.01uF
20%
10%
10%
20%
10%
10V
25V
16V
16V
25V
C511
C512
C513
C514
C601
1-107-826-11
1-164-156-11
1-164-227-11
1-162-970-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.022uF
0.01uF
0.047uF
10%
10%
10%
10%
16V
25V
25V
25V
16V
C602
C603
C604
C605
C606
1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-163-102-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
24PF
5%
25V
25V
25V
25V
50V
C607
C608
C610
C611
C612
1-162-919-11
1-164-156-11
1-162-970-11
1-126-157-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
22PF
0.1uF
0.01uF
10uF
0.1uF
C613
C615
C616
C618
C619
1-162-968-11
1-107-826-11
1-124-584-00
1-110-654-11
1-128-057-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT (BLOCK)
ELECT
0.0047uF
0.1uF
100uF
0.047F
330uF
10%
10%
20%
50V
16V
10V
20%
6.3V
C620
C621
C622
C623
C624
1-107-826-11
1-124-589-11
1-164-156-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.1uF
0.1uF
0.1uF
10%
20%
16V
16V
25V
25V
25V
C625
C626
C627
C628
C629
1-164-156-11
1-164-156-11
1-124-589-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47uF
0.01uF
0.1uF
C630
C631
C632
C633
1-164-156-11
1-164-156-11
1-126-157-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.1uF
Ref. No.
10%
20%
50V
25V
25V
16V
25V
20%
10%
10%
25V
25V
16V
25V
16V
20%
10%
25V
25V
16V
16V
Description
Remark
470PF
10%
50V
C635
C636
C670
C671
1-162-927-11
1-164-505-11
1-107-826-11
1-107-826-11
100PF
2.2uF
0.1uF
0.1uF
5%
50V
16V
16V
16V
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10%
10%
< CONNECTOR >

* CN100
* CN200
CN300
CN301
* CN400

1-774-700-11 JACK, PIN 6P
(BUS AUDIO IN, AUDIO OUT REAR/FRONT)
CN401
CN402
CN500
CN501
* CN601
1-766-260-11
1-794-185-11
1-580-907-31
1-568-951-11
1-764-908-11
CN602
5%
Part No.
C634

CONNECTOR, FPC (ZIF) 14P
PLUG, CONNECTOR (BUS CONTROL IN)
PIN, CONNECTOR 2P

< DIODE >
D100
D103
D104
D200
D201
8-719-065-09
8-719-065-00
8-719-988-61
8-719-065-00
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ5.1-Y (TPH3)
02DZ3.9-X (TPH3)
1SS355TE-17
02DZ3.9-X (TPH3)
1SS355TE-17
D202
D203
D205
D206
D300
8-719-988-61
8-719-065-00
8-719-065-12
8-719-914-43
8-719-079-97
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
02DZ3.9-X (TPH3)
02DZ5.6-Y (TPH3)
DAN202K-T-146
CRZ22 (TE85L.SONY)
D301
D302
D303
D304
D305
8-719-079-97
8-719-079-97
8-719-079-97
8-719-079-97
8-719-079-97
DIODE
DIODE
DIODE
DIODE
DIODE
CRZ22 (TE85L.SONY)
CRZ22 (TE85L.SONY)
CRZ22 (TE85L.SONY)
CRZ22 (TE85L.SONY)
CRZ22 (TE85L.SONY)
D306
D307
D308
D309
D310
8-719-079-97
8-719-079-97
8-719-053-18
8-719-053-18
8-719-017-94
DIODE
DIODE
DIODE
DIODE
DIODE
CRZ22 (TE85L.SONY)
CRZ22 (TE85L.SONY)
1SR154-400TE-25
1SR154-400TE-25
MA8180-TX
D311
D312
D316
D317
D400
8-719-017-94
8-719-017-94
8-719-988-61
8-719-049-38
8-719-065-28
DIODE
DIODE
DIODE
DIODE
DIODE
MA8180-TX
MA8180-TX
1SS355TE-17
1N5404TU
02DZ9.1-Z (TPH3)
D401
D500
D501
D502
D503
8-719-074-47
8-719-988-61
8-719-988-61
8-719-988-61
8-719-065-18
DIODE
DIODE
DIODE
DIODE
DIODE
CRS02 (TE85L)
1SS355TE-17
1SS355TE-17
1SS355TE-17
02DZ6.8-Y (TPH3)
D504
D505
D506
D507
D508
8-719-065-18
8-719-065-46
8-719-056-93
8-719-056-93
8-719-065-16
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
02DZ16-Z (TPH3)
UDZ-TE-17-18B
UDZ-TE-17-18B
02DZ6.2-Z (TPH3)
D509
8-719-914-43 DIODE DAN202K-T-146
17
Ver 1.1
MAIN
Ref. No.
Part No.
Description
D510
D511
D513
D515
8-719-065-18
8-719-058-24
8-719-988-61
8-719-914-44
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
RB501V-40TE-17
1SS355TE-17
DAP202K-T-146
Remark
D606
D607
D609
D610
D611
8-719-988-61
8-719-988-61
8-719-914-43
8-719-065-18
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
DAN202K-T-146
02DZ6.8-Y (TPH3)
1SS355TE-17
D612
D613
D617
D618
D619
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
D620
D621
D623
D624
D625
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
8-719-065-18
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
02DZ6.8-Y (TPH3)
D626
D627
D628
D640
D641
8-719-065-18
8-719-914-44
8-719-914-44
8-719-914-43
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y (TPH3)
DAP202K-T-146
DAP202K-T-146
DAN202K-T-146
1SS355TE-17
Ref. No.
Part No.
Description
Remark
< SHORT >

JR501
JR502
1-216-864-11 SHORT
1-216-864-11 SHORT
0
0
< COIL >

L17
L300
1-469-549-21 INDUCTOR
1-419-476-31 CHOKE COIL
1uH
250uH
< TRANSISTOR >

Q100
Q103
Q104
Q106
Q107
8-729-052-35
8-729-049-43
8-729-038-68
8-729-120-28
8-729-216-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
STD1664
STB1132Y
KRC103S
2SC2412K-T-146-R
2SA1162-YG-TE85L
Q200
Q201
Q204
Q220
Q221
8-729-920-31
8-729-920-31
8-729-920-21
8-729-038-55
8-729-028-66
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC343TK-T-146
DTC343TK-T-146
DTC314TK-T-146
KRA103S
DTC115EKA-T146
Q222
Q223
Q250
Q251
Q254
8-729-144-85
8-729-120-28
8-729-920-31
8-729-920-31
8-729-920-21
FET
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK1133-T1B
2SC2412K-T-146-R
DTC343TK-T-146
DTC343TK-T-146
DTC314TK-T-146
Q300
Q301
Q302
Q303
Q400
8-729-038-68
8-729-041-38
8-729-038-68
8-729-041-38
8-729-931-15
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC103S
2SB1241TV2Q
KRC103S
2SB1241TV2Q
2SD1858-R-TV2
Q402
Q403
Q404
Q405
Q406
8-729-049-43
8-729-038-68
8-729-038-68
8-729-038-55
8-729-038-68
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
STB1132Y
KRC103S
KRC103S
KRA103S
KRC103S
Q500
Q501
Q502
Q503
Q504
8-729-038-68
8-729-120-28
8-729-216-22
8-729-120-28
8-729-038-68
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC103S
2SC2412K-T-146-R
2SA1162-YG-TE85L
2SC2412K-T-146-R
KRC103S
Q505
Q506
Q600
Q603
Q604
8-729-038-55
8-729-038-55
8-729-038-55
8-729-120-28
8-729-038-68
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRA103S
KRA103S
KRA103S
2SC2412K-T-146-R
KRC103S
Q605
Q606
Q607
Q608
Q611
8-729-920-85
8-729-038-68
8-729-120-28
8-729-120-28
8-729-920-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1664-T101-QR
KRC103S
2SC2412K-T-146-R
2SC2412K-T-146-R
DTC314TK-T-146
Q612
< SHORT >

FB10
FB11
FB12
FB13
FB16
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
< IC >
IC100
IC101
IC102
IC200
IC201
8-759-653-27
8-759-909-71
8-759-392-22
8-759-593-97
8-759-593-97
IC
IC
IC
IC
IC
TDA7402TR
BA4558F-E2
BA3834F
NJM2160AM-TE2
NJM2160AM-TE2
IC202
IC300
IC400
IC401
IC500
8-759-909-71
8-759-827-14
8-759-527-33
8-752-079-79
8-759-701-01
IC
IC
IC
IC
IC
BA4558F-E2
TA8268AH
LB1930M-TLM
CXA2510AQ-T4
NJM2904M (TE2)
IC501
IC502
IC503
IC601
IC602
8-759-593-98
8-759-580-33
8-759-668-14
8-759-668-45
8-759-828-22
IC
IC
IC
IC
IC
BA8270FV-E2
BA6288FS-E2
PQ09DZ1U
MB90574BPMT-G-262-BND
XC61CN4102MR
IC604
IC605
IC606
IC607
8-759-540-27
8-759-528-47
8-759-277-63
8-759-684-69
IC
IC
IC
IC
TA78DL06AS
PQ09RA11
TC7W14FU (TE12R)
HD6432355A26F
< RESISTOR/DIODE >
< JACK >

J500
18
1-764-270-21 JACK, STEREO MINIATURE (DIA.3.5)

(REMOTE IN)
KRA103S
R100
R101
R102
R103
R105
1-216-821-11
1-216-825-11
1-216-809-11
1-216-809-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
1K
2.2K
100
100
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
MAIN
Ref. No.
Part No.
Description
Remark
R106
R107
R109
R110
R111
1-216-841-11
1-216-839-11
1-216-809-11
1-216-809-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
33K
100
100
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R112
R113
R114
R115
R116
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R117
R118
R119
R120
R121
1-216-833-11
1-216-826-11
1-216-797-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.7K
10
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R122
R123
R124
R125
R126
1-216-845-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R129
R130
R131
R200
R201
1-216-864-11
1-216-841-11
1-216-864-11
1-216-809-11
1-216-809-11
SHORT
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
0
47K
0
100
100
5%
1/16W
5%
5%
1/16W
1/16W
R202
R203
R204
R205
R206
1-218-725-11
1-218-725-11
1-202-926-11
1-202-926-11
1-216-813-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
24K
24K
36K
36K
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R207
R208
R209
R214
R215
1-216-813-11
1-216-837-11
1-216-837-11
1-216-845-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
22K
22K
100K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R216
R217
R218
R220
R221
1-216-839-11
1-216-813-11
1-216-837-11
1-216-841-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
220
22K
47K
47
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R222
R223
R224
R225
R226
1-216-841-11
1-216-833-11
1-216-864-11
1-216-845-11
1-216-825-11
METAL CHIP
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
47K
10K
0
100K
2.2K
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R227
R228
R229
R230
R231
1-216-825-11
8-719-058-24
1-216-298-00
1-216-821-11
1-216-821-11
METAL CHIP
2.2K
DIODE RB501V-40TE-17
METAL CHIP
2.2
METAL CHIP
1K
METAL CHIP
1K
5%
1/16W
5%
5%
5%
1/10W
1/16W
1/16W
R232
R233
R234
R250
R251
1-216-845-11
1-216-837-11
1-216-845-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
22K
100K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R252
R253
1-218-725-11 RES-CHIP
1-218-725-11 RES-CHIP
24K
24K
5%
5%
1/16W
1/16W
Ref. No.
Part No.
Description
Remark
R254
R255
R256
1-202-926-11 RES-CHIP
1-202-926-11 RES-CHIP
1-216-813-11 METAL CHIP
36K
36K
220
5%
5%
5%
1/16W
1/16W
1/16W
R257
R258
R259
R260
R261
1-216-813-11
1-216-837-11
1-216-837-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
22K
22K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R265
R266
R267
R268
R300
1-216-837-11
1-216-839-11
1-216-813-11
1-216-837-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
33K
220
22K
33K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R301
R302
R304
R308
R309
1-216-839-11
1-216-821-11
1-216-821-11
1-216-809-11
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
1K
1K
100
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R310
R311
R312
R313
R314
1-216-065-00
1-216-841-11
1-216-073-00
1-216-057-00
1-216-841-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
10K
2.2K
47K
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/10W
1/16W
R315
R316
R319
R330
R400
1-216-073-00
1-216-864-11
1-216-841-11
1-216-821-11
1-216-845-11
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
10K
0
47K
1K
100K
5%
1/10W
5%
5%
5%
1/16W
1/16W
1/16W
R401
R402
R403
R404
R405
1-216-845-11
1-216-845-11
1-216-845-11
1-216-810-11
1-216-810-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
120
120
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R406
R407
R408
R409
R410
1-216-851-11
1-216-851-11
1-216-834-11
1-216-836-11
1-216-836-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330K
330K
12K
18K
18K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R411
R412
R413
R416
R419
1-216-834-11
1-216-049-11
1-216-681-11
1-216-825-11
1-216-829-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
1K
18K
2.2K
4.7K
5%
5%
0.5%
5%
5%
1/16W
1/10W
1/10W
1/16W
1/16W
R420
R421
R422
R423
R431
1-216-833-11
1-216-833-11
1-216-853-11
1-216-841-11
1-216-001-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
470K
47K
10
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R432
R433
R434
R500
R501
1-216-001-00
1-216-001-00
1-216-001-00
1-216-837-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
10
10
22K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/16W
R502
R503
R504
R505
1-216-829-11
1-216-833-11
1-216-839-11
1-216-836-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
33K
18K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
19
MAIN
Ref. No.
Part No.
Description
Remark
R506
1-216-833-11 METAL CHIP
10K
5%
1/16W
R507
R508
R509
R510
R511
1-218-716-11
1-216-833-11
1-216-809-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
100
47K
100K
0.5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R512
R513
R514
R515
R516
1-216-809-11
1-216-841-11
1-216-809-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
100
2.2K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R517
R518
R519
R521
R523
1-216-809-11
1-216-809-11
1-216-298-00
1-216-298-00
1-216-298-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
2.2
2.2
2.2
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/10W
R524
R526
R527
R600
R601
1-216-809-11
1-216-805-11
1-216-821-11
1-216-837-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
100
47
1K
22K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R602
R603
R605
R606
R607
1-216-809-11
1-216-864-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
100
0
100K
100K
100K
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
R608
R609
R611
R612
R613
1-216-845-11
1-216-845-11
1-216-845-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R614
R615
R616
R617
R618
1-216-809-11
1-216-809-11
1-216-833-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
10K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R619
R620
R621
R622
R623
1-216-845-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1K
1K
100K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R624
R625
R626
R633
R634
1-216-845-11
1-216-864-11
1-216-864-11
1-216-845-11
1-216-839-11
METAL CHIP
SHORT
SHORT
METAL CHIP
METAL CHIP
100K
0
0
100K
33K
5%
1/16W
5%
5%
1/16W
1/16W
R635
R636
R639
R640
R641
1-216-821-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R642
R643
R644
R645
R646
1-216-845-11
1-216-839-11
1-216-833-11
1-216-833-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
33K
10K
10K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R647
1-216-809-11 METAL CHIP
100
5%
1/16W
Ref. No.
Part No.
Description
R648
R649
R650
R651
1-216-815-11
1-216-864-11
1-216-821-11
1-216-809-11
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
330
0
1K
100
5%
1/16W
Remark
5%
5%
1/16W
1/16W
R652
R653
R654
R655
R656
1-216-821-11
1-216-837-11
1-216-841-11
1-216-829-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
22K
47K
4.7K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R657
R658
R659
R660
R661
1-216-821-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R662
R663
R664
R665
R666
1-216-813-11
1-216-813-11
1-216-845-11
1-216-845-11
1-218-716-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
100K
100K
10K
5%
5%
5%
5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
R667
R668
R669
R670
R671
1-216-809-11
1-218-716-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
100
100
100
5%
0.5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R672
R673
R674
R675
R676
1-216-809-11
1-216-809-11
1-216-864-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
100
100
0
100
100
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R677
R678
R679
R680
R681
1-216-809-11
1-216-809-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R682
R711
R718
1-216-845-11 METAL CHIP

1-216-845-11 METAL CHIP
1-216-864-11 SHORT
100K
100K
0
5%
5%
1/16W
1/16W
< COMPOSITION CIRCUIT BLOCK >

RB13
RB14
1-233-412-11 RES, CHIP NETWORK 1K (3216)

1-233-810-21 RES, NETWORK 100K (3216)
< VARIABLE RESISTOR >
RV400
RV401
1-238-090-11 RES, ADJ, CERMET 10K

1-238-090-11 RES, ADJ, CERMET 10K
< THERMISTOR >
TH300
TH301
TH601

< TUNER UNIT >
20

< VIBRATOR >
X600
X601
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)

MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
SUB
SWITCH
Remark
X602
**************************************************************
1-680-701-11 SUB BOARD (M550)
**********
1-783-268-31 CABLE, FLAT

< CAPACITOR >
C900
0.1uF
10%
16V
< CONNECTOR >

CN900

< DIODE >
D900
D901
D902
D903
D904
8-719-065-18
8-719-065-18
8-719-988-61
8-719-065-09
8-719-079-10

DIODE 1SS355TE-17
LED CL-220UB-X-TS
(CASSETTE SLOT INDICATOR)
D905
D906
D907
D908
8-719-072-57
8-719-065-18
8-719-065-48
8-719-065-48
LED CL-170UB-X-T (Z)

< IC >
IC900
8-749-012-25 IC RS-170-TU
< TRANSISTOR >
Q900
Q901
KRC103S
KRA103S
< RESISTOR >

R900
R901
R902
R903
R905
1-216-809-11
1-216-817-11
1-216-839-11
1-216-807-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
470
33K
68
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< SWITCH >

S900
S901
1-692-135-21 SWITCH, KEY BOARD (Z)

1-762-947-12 SWITCH, PUSH (1 KEY)
(CASSETTE IN/OUT DETECT)
S902
1-692-135-21 SWITCH, KEY BOARD (RESET)
**************************************************************
A-3326-298-A SWITCH BOARD, COMPLETE
***********************
For the parts on the SWITCH board, replace the entire mounted board.
21
XR-M500R/M550
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
1.1
Date
2000.03
2000.05
2000.12
2002.09
Description of Revision
New
Correction-1
Supplement-1
Correction of Part No. for IC601 on MAIN board
Incorporation of Correction-1
(RPC-02001)

Service Manual: XR-M500R/M550

Uploaded by

Document Informationclick to expand document information

Copyright:

Available Formats

Service Manual: XR-M500R/M550

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Service Manual: XR-M500R/M550

Uploaded by

Copyright:

Available Formats

XR-M500R/M550

Ver 1.1 2002.09

Dolby noise reduction manufactured under license from

Model Name Using Similar Mechanism

Tape Transport Mechanism Type

POWER OUTPUT AND TOTAL HARMONIC DISTORTION

4-track 2-channel stereo

87.5 108.0 MHz (XR-M500R)

MW: 531 1,602 kHz

530 1,710 kHz

Continued on next page

FM/AM (MW/LW) CASSETTE CAR STEREO

Power amplifier section

Audio output (2) (M500R)

SERVICING NOTES ............................................... 3

MECHANICAL ADJUSTMENTS ....................... 24

Design and specifications are subject to change

7-1. Block Diagram TUNER/TAPE Section ..................

EXPLODED VIEWS ................................................ 51

ELECTRICAL PARTS LIST ............................... 55

Flexible Circuit Board Repairing

1. Disconnect the motor connector (CN501) from main board.

R625 R626 R719 R720

TYPE A, B, C, or D can also be identified from the front panel

This section is extracted from

qk TA button 16, 17, 18

Setting the clock

Changing the sound and

Example: To set the clock to 10:08

The following items can be set:

Press(MENU), then M or m repeatedly

The hour indication flashes.

2 PressM or m to set the hour.

The minute indication flashes.

4 PressM or m to set the minute.

PressM or m repeatedly until the desired

Clock (page 10).

Clock t CT t Beep t RM t English/

Press, to select the desired setting

continue to next page t

The clock starts.

If you mount other Sony equipment with this

Si monta otro equipo Sony con esta unidad, es

Om du monterar annan Sony-utrustning till

prefervel montar este aparelho na posio

Mounting angle adjustment

Ajuste del ngulo de montaje

Monteringsvinkeln fr inte vara strre n 20

Ajuste el ngulo de montaje a menos de 20.

Ajuste do ngulo de montagem

Extended portion of the front panel.

Installation in the dashboard

Si es necesario, doble estas

With the UP marking up

When the installation and connections are

Cuando finalice la instalacin y las conexiones,

Kom ihg att anvnda en penna eller ngot annat

Quando terminar a instalao e as ligaes, no se