Air Car – The Future Of Transportation

123seminarsonly.com
123seminarsonly.com 123seminarsonly.com
 Introduction

Get ready. The future of transportation will soon be

whooshing down the road in the form of an unparalleled
“green,” earth-friendly technology that everyone will want to
get their hands on as soon as they can: The Air Car. It is
hard to believe that compressed air can be used to drive
vehicles. However that is true, and the “air car”, as it is
popularly known, has caught the attention of researchers
worldwide. It has zero emissions and is ideal for city driving
conditions.

123seminarsonly.com 123seminarsonly.com
 THE AIR CAR
Models:

123seminarsonly.com 123seminarsonly.com
 How do air engines work?
 Approximately 90m³ of compressed air is
stored in fibre tanks in the vehicle.
The engine is powered by compressed air,
stored in a carbon-fibre tank at 30 MPa
(4500 psi). The tank is made of carbon fibre
in order to reduce its weight.
The engine has injection similar to normal
engines, but uses special crankshafts and
pistons, which remain at top dead centre for
about 70 degrees of the crankshaft’s cycle;
this allows more power to be developed in
the engine.

The expansion of this air pushes the pistons and creates movement. The
atmospheric temperature is used to re-heat the engine and increase the
road coverage.
The air conditioning system makes
123seminarsonly.com
use of the expelled cold air
123seminarsonly.com
 How Compressed Air Can Fuel a Car
In practical terms compressed air at
300 bars is stored in the carbon fiber
tanks A. Air is released through the
main line firstly to an alternator B
where the first stage of
decompression takes place. The now
cold air passes through a heat
exchanger C which adds thermal
energy to the air and provides a
convenient opportunity for air
conditioning D.

The warmed compressed air now passes to the motor E. where a two
more stages of decompression and re-heating take place. The motor
drives the rear axle G through the transmission F. Control of engine speed
is through a conventional accelerator pedal H controlling a valve within the
motor.
123seminarsonly.com 123seminarsonly.com
 Compressed air tanks
The air tanks store 90m³ of air at 300 bars
of pressure (four tanks have a capacity of 90
litres, and they store 90m³ of air at a pressure
of 300 bars), just like tanks already used to
carry liquefied gases on some urban buses.
 That means that the tanks are prepared
and certified to carry an explosive product
such as methane gas.
In the case of an accident with air tank
breakage, there would be no explosion or
shattering because the tanks are not metallic
but made of glass fibre.

•An elongated crack would appear in the tank, without exploding,

and the air would simply escape, producing a loud but harmless
noise.
• Of course, since this technology is licensed to transport an
inflammable and explosive gas (Natural gas), it is perfectly capable
123seminarsonly.com 123seminarsonly.com
inoffensive and non-flammable air.
 The Body
The MDI car body is built with fibre
and injected foam, as are most of the
cars on the market today.

 This technology has two main

advantages: cost and weight.

Nowadays the use of sheet steel for car bodies is only

because of cost - it is cheaper to serially produce sheet steel
bodies than fibre ones.

However, fibre is safer (it doesn't cut like steel), is easier to

repair (it is glued), doesn't123seminarsonly.com
123seminarsonly.com rust etc.
 The chassis

Based on its experience in aeronautics, MDI has put

together highly-resistant, yet light, chassis, aluminum rods
glued together.
Using rods enables us to build a more shock-resistant
chassis than regular chassis.
Additionally, the rods are glued in the same way as aircraft,
allowing quick assembly and a more secure join than with
welding. This system helps to reduce manufacture time.
123seminarsonly.com 123seminarsonly.com
 The Air Filter
 The engine works with both air taken from the atmosphere
and air pre-compressed in tanks. Air is compressed by the on-
board compressor or at service stations equipped with a high-
pressure compressor.
 Before compression, the air must be filtered to get rid of any
impurities that could damage the engine. Carbon filters are
used to eliminate dirt, dust, humidity and other particles
which, unfortunately, are found in the air in our cities.
 This represents a true revolution in automobiles - it is the first
time that a car has produced minus pollution, i.e. it eliminates’
and reduces existing pollution rather than emitting dirt and
harmful gases. The exhaust pipe on the cars produces clean
air, which is cold on exit (between -15º and 0º) and is
harmless to human life. With this system the air that comes
out of the car is cleaner than the air that went in.
123seminarsonly.com 123seminarsonly.com
 Electrical system
 Guy Negre, inventor of the MDI Air Car, acquired the
patent for an interesting invention for installing electrics
in a vehicle.
 Using a radio transmission system, each electrical
component receives signals with a microcontroller.
 Thus only one cable is needed for the whole car. So,
instead of wiring each component (headlights,
dashboard lights, lights inside the car, etc), one cable
connects all electrical parts in the car.
 The most obvious advantages are the ease of
installation and repair and the removal of the
approximately 22 kg of wires no longer necessary.
 The entire system becomes an anti-theft alarm as soon
as the key is removed from the car.
123seminarsonly.com 123seminarsonly.com
 Refilling methods for Air Cars
In the mains

Tanks are refilled by plugging the car into a mains socket to feed
the motor-alternator which compresses the air with the motor-
compressor.

Refilling time obviously depends on the source of electricity

used. Here are our initial estimates:

For :
 230V : 3 hrs 30mins - 4hrs
 380V : 2hrs 30mins - 3hrs.
 115V : currently being tested.

123seminarsonly.com 123seminarsonly.com
 Refilling at a service-station

• As the energy is so easy to store, MDI

anticipates the installation of air stations
• These stations can refill a car in 3 minutes.

123seminarsonly.com 123seminarsonly.com
 HOW AIR CAR HELPS TO REDUCE
POLLUTION
The most important pollutants in car exhaust include:

 Carbon monoxide (a poison). Carbon monoxide is formed because

combustion is incomplete. Not enough oxygen is available fast enough
to react completely with all of the carbon available.
 Nitrogen oxides - Because of the pressure and temperature inside a
cylinder, nitrogen and oxygen in the air combine in various ways.
 Unburned hydrocarbons - not all of the hydrocarbons participate in the
reaction because there is so little time available during the combustion
phase.
 As about gasoline is the main source of pollution, if we use compressed
air instead of gasoline then we can improve environment.
 As we know that nitrogen is the main constituent of environment, in
case of air car we extract nitrogen from environment, liquefy it and used
as fuel in car, then there will be nitrogen, only the exhaust gas which is
not harmful to human being and environment. By using liquid nitrogen
(compressed air) in car, we123seminarsonly.com
123seminarsonly.com
can reduce pollution up to 70-80%.
 Advantages of Air Car
 Refueling can be done at home using an air compressor or at service
stations. The energy required for compressing air is produced at large
centralized plants, making it less costly and more effective to manage
carbon emissions than from individual vehicles.
 Compressed air engines reduce the cost of vehicle production by about
20%, because there is no need to build a cooling system, spark plugs,
starter motor, or mufflers.
 The rate of self-discharge is very low opposed to batteries that deplete
their charge slowly over time. Therefore, the vehicle may be left unused
for longer periods of time than electric cars.
 Expansion of the compressed air lowers its temperature; this may be
exploited for use as air conditioning.
 Compressed-air vehicles emit few pollutants, mostly dust from brake
and tire wear.
 Lighter vehicles would result in less wear on roads.

123seminarsonly.com 123seminarsonly.com
 Advantages of Air Car
 Reduction or elimination of hazardous chemicals such as gasoline or
battery acids/metals
 Compressed-air tanks can be disposed of or recycled with less
pollution than batteries
 The tank may be able to be refilled more often and in less time than
batteries can be recharged, with re-fueling rates comparable to liquid
fuels
 The price of fueling air powered vehicles will be significantly cheaper
than current fuels
 Much like electrical vehicles, air powered vehicles would ultimately be
powered through the electrical grid. Which makes it easier to focus on
reducing pollution from one source, as opposed to the millions of
vehicles on the road?
 Transportation of the fuel would not be required due to drawing power
off the electrical grid. This presents significant cost benefits. Pollution
created during fuel transportation
123seminarsonly.com
would be eliminated.
123seminarsonly.com
 Disadvantages
• Any conversion of energy between forms results in loss.
For conventional combustion motor cars, the energy is lost
when oil is converted to usable fuel - including drilling,
refinement, labor, storage, eventually transportation to the
end-user. For compressed-air cars, energy is lost when
electrical energy is converted to compressed air.
• Tanks get warm when filled rapidly. It would be difficult to
cool the tanks efficiently while charging and thus it would
either take a long time to fill the tanks, or they would have
to take less than a full charge (since heat drives up the
pressure).
• Refueling the compressed air container using a home or
low-end conventional air compressor may take as long as
4 hours though the123seminarsonly.com
123seminarsonly.com
specialized equipment at service
stations may fill the tanks in only 3 minutes.
 A car that runs on air, in India soon

 Tata Motors has signed an agreement with Motor

Development International of France to develop a car
that runs on compressed air, thus making it very
economical to run and be almost totally pollution free.

 Although there is no official word on when the car will be

commercially manufactured for India, reports say that it
will be sooner.

 The car could cost around Rs 350,000 in India and

would have a range of around 300 km between refuels.
The cost of a refill would be about Rs 90.

123seminarsonly.com 123seminarsonly.com
 Conclusion
• From all the disruption made one can say that by using air
car there is reduction in air pollution. The emission benefits
of introducing this zero emission technology are obvious.
Also, the aim of project is to cut cost, create job locally.
Also air car provides an answer to the shortage of fuel and
high price of fuel.
• With petrol and diesel prices going up and the price of oil
subjects to fluctuation for motorist, this becomes
headache; use of air motor is only the solution. All know
that there will be shortage of gasoline (petrol, diesel), in
future, engine that runs on compressed air is only the
alternative for it.
123seminarsonly.com 123seminarsonly.com
 Various models of Air Car

123seminarsonly.com 123seminarsonly.com
 Thank you

123seminarsonly.com 123seminarsonly.com