UNIT-CIDER 700

11112/99
REVISiON 1

APV
I Standard Apple Cider Pasteurizer
Instruction Manual
•

.)<;<:" .
,.;~

~
 API} Standard Apple Cider Pasteurizer

Instruction Manual

1.0 INTRODUCTION concentration for 316 stainless steel plate heat

exchanger plates is 200 PPM at 185° F (85°C).
1.1 General
1.5 Tubular Heat Exchanger Design
The purpose of this manual is to provide instructions
for the safe installation. operation and maintenance of Standard Apple Cider Pasteurizers designed using
your APV Standard Apple Cider Pasteurizer. an APV Tubular Heat Exchanger offer greater
flexibility. In addition to apple cider that can be
1.2 Safety processed in a plate heat exchanger. the tubular
design can process a wider range of cider blends.
Safe installation. operation and maintenance of the The tubular heat exchanger offers less regeneration
(77%) than the plate heat exchanger. but can
process apple cider with particle sizes up to '" and
! Warning cider with heavier pectin deposits. The tubular heat
Read and understand the entire manual before
unpacking the equipment and installing it.
exchanger is also more resistant to attack by
chlorides than the plate heat exchanger. The
maximum chloride concentration for the tubular heat
APV Standard Apple Cider Pasteurizer requires exchanger is 500 PPM at 185° F (85°C).
proper training of all plant operating personnel.
Section 2.0. titled "Safety Instructions", should be 1.6 Standard Pasteurizer Components
read and understood before proceeding. This section
discusses general safety practices. In addition. The APV Standard Apple Cider Pasteurizer is
specific hazards are indicated by the appropriate comprised of the following standard components:
hazard label in bold type throughout this manual.
APV Heat Exchanger (Plate or TUbular)
It is the objective of APV to identify each area of APV Holding Loop
potential hazard and guide workers in safe operation, Feed Balance Tank - 30 Gallon
service and maintenance procedures. Hot Water Boiler - Natural Gas or Propane
Pasteurized Juice Temperature Recorder
1.3 General Apple Cider Pasteurizer Design Product & Utility Valves
Product Pumps with Variable Frequency Drive on 2nd
APV Standard Apple Cider Pasteurizers are available Stainless Steel Base
in flow rates of 2, 5, and 10 GPM using either APV Stainless Steel Piping
Plate or APV Tubular heat exchangers. These Temperature and Pressure Indicators
pasteurizers are designed to thermally process cider, UL Listed Electrical Enclosure
up to 15° Brix, from 40°F to 170°F (4.4°C to 76°C)
using regeneration and 185°F (85°C) hot water. The Standard options that can be provided on an APV
cider is held for 10 seconds in an APV holding loop StandardApple CiderPasteurizer are listed in Section 1.9.
and is then cooled to 40°F (4.4°C) using regeneration
and 34°F (1.1°C) chilled water. The pasteurizers are 1.7 Receiving and Inspection
assembled. wired and air tubed on a 304SS base. All
product and utility piping is stainless steel and the Standard Apple Cider Pasteurizers are fully assembled
equipment is capable of being cleaned in place (C1P). and inspected before shipment and are properly
prepared for transportation. Upon receipt of this
1.4 Plate Heat Exchanger Design equipment, check all received items against the
packing list for damage or missing parts. Components
Standard Apple Cider Pasteurizers designed using an removed for safe shipment have been match marked
APV Plate Heat Exchanger are supplied with 316 for easy reassembly. Damage or loss should be
stainless steel flow plates. The plate heat exchanger reported immediately to the carrier or insurance
is known for providing high heat transfer, and agent.
consequently high rates of heat recovery or
regeneration (85% or better on clear juices). The
plate heat exchanger is the preferred solution for
cider which is filtered to a minimum of '110" without
heavy pectin deposits. The maximum chloride
 APV Standard Apple Cider Pasteurizer

Instruction Manual

1.8 Selecting an Apple Cider Pasteurizer typical options available on customized units include, a
shell and tube hot water recirculation unit, an electric
Table 1.1 is used to select the proper Apple Cider hot water heater, an apple cider feed flow meter and
Pasteurizer for your specific needs. PLC control. Contact your APV representative for
more information.
Use the following steps to identify the appropriate
Standard Shell and Tube Hot Water Recirculation Unit 1.9 Standard options
model.
The following standard options are available on the
1. Determine cider flow rate in GPM (LPM). APV Standard Apple Cider Pasteurizer:
2. Determine cider particulate size.
3. Note maximum CIP chloride concentration. 1. Air compressor with air tank
4. Choose either the plate or tubular heat 2. Air Cooled Glycol Chiller
exchanger model. 3. Balance Tank Level Control
4. Pressure Tube Hot Water Recirculation Unit
If the standard Apple Cider Pasteurizer models listed 5. Ice Builder
below do not meet specific requirements, call your 6. SR15S Stainless Steel Plate Heat Exchanger
APV representative for more information and a Frame
quotation on a Custom Apple Cider Pasteurizer.
Custom pasteurizers are available in a wide range of
apple cider flow rates and heating ranges. Some

APPLE CIDER PLATE HEAT EXCHANGER TUBULAR HEAT EXCHANGER

PASTEURIZER MODELS MODELS

PPAC-02 PPAC-05 PPAC-10 PTAC-02

MODEL
I I PTAC-05
I PTAC-10

Apple Cider Flowrate 2GPM 5GPM 10GPM 2GPM 5GPM 10GPM

@40°F (8 LPM) (19 LPM) (38 LPM) (8 LPM) (19 LPM) (38 LPM)

Hot Water Flowrate 4GPM 10GPM 20GPM 8GPM 12GPM 40GPM

@185°F (15 LPM) (38 LPM) (76 LPM) (30 LPM) (46 LPM) (152 LPM)

Heating BTU's 19,000 47,000 94,000 30,000 75,000 150,000

Maximum Particle
< 1/16" (1.5mm) < 1/4" (6mm)
Size
Minimum Heat
85% 77%
Regeneration
Max CIP Chloride
200 PPM @ 185°F (85°C) 500 PPM @ 185°F (85°C)
Concentration

TABLE 1.1
 APV Standard Apple Cider Pasteurizer

Instruction Manual

2.0 SAFETY INSTRUCTIONS

2.3 Operating Zone

2.1 General Statement
An operating zone should be established around the
APV Standard Apple Cider Pasteurizers are designed Apple Cider Pasteurizer. A brightly painted guard rail
and built with due consideration and care for or warning stripe should define the zone. Only the
generally accepted safety standards. However, like operator or other authorized personnel should be
any mechanical device, proper and safe performance allowed within the operating zone when control
of this equipment depends upon using sound and circuits are energized or the unit is operating. No
prudent operating, maintenance and servicing tools or other equipment should be kept within the
procedures under properly trained supervision. operating zone. Refer to paragraph 3.3 for space
requirements.
For your protection, and the protection of others,
learn and always follow the safety rules outlined in 2.4 Pressure and Temperature Ratings
this section. Observe warning signs on machines and
act accordingly. Form safe working habits by reading
the rules and abiding by them. Keep this booklet MAXIMUM DESIGN MAXIMUM DESIGN
WORKING PRESSURE WORKING TEMPERATURE
handy and review it from time to time to refresh your
understanding of the rules. PRODUCT WATER PRODUCT WATER
SIDE SIDE SIDE SIDE
2.2 Hazard Level Identification 100 PSIG 50 PSIG 250°F 250°F
(6.8 bar) (3.4 bar) (121°C) (121°C)
Definitions for identifying the various hazard levels TABLE 2.1
shown on warning labels or to indicate proper safety Pressure and temperature ratings for APV Standard
procedures in the instruction manual are provided in Apple Cider Pasteurizers are listed below in Table
the following labels. 2.1. These equipment ratings must not be exceeded
at any time during startup or operation of the unit.

! Danger 2.5 Installation

The use of the word "Danger" always signifies
an immediate hazard with a high likelihood of Utility sources, such as water, steam, electric, air and
severe personal injury or death if instructions, hydraulic, should be installed by trained and
including recommended precautions, are not authorized personnel only. Installations must comply
followed.
with all applicable codes and standards, including
those established by the general industry standards
of OSHA.
! Warning
The use of the word "Warning" signifies the 2.6 Safety Instructions
presence of hazards or unsafe practices that
could result in severe personal injury or death if Before Starting a Unit
instructions, including recommended Be certain that all necessary guards and safety
precautions, are not followed. devices are installed and operating properly. This
includes safety screens or pressure relief devices.

Be sure all personnel are clear of the unit.

! Caution
The use of the word "Caution" always signifies
Remove (from the operating zone) any materials,
possible hazards that could result in minor
personal injury or damage to product or property tools or other foreign objects that could cause injury
if instructions, including recommended to personnel or damage the unit.
precautions, are not followed.
 APV Standard Apple Cider Pasteurizer

Instruction \I1anual

3.9 Utility Requirements

Utility requirements for the Standard Apple Cider

Pasteurizers are listed ir"l Table 3.1. The data in
Table 3.1 is a guide only to the maximum expected
utility requirements for a Standard Apple Cider
Pasteurizer.

PLATE HEAT EXCHANGER TUBULAR HEAT EXCHANGER

UTILITY REQUIREMENTS
MODELS MODELS
PPAC-02 PPAC-05 PPAC-10 PTAC-02 PTAC-05 PTAC-10
Water Make-up supplied at USgpm 5 5 5 5 5 5
20 psig (1.4 kg/cm 2 ) minimum Ipm 19 19 19 19 19 19
Chilled Water supplied at USgpm 7 16 36 8 16 26
34OF (1.1 0C) and 45 psig (3 kg/cm 2 ) Ipm 27 61 137 30 61 99
Hot Water supplied at USgpm I 4 10 20 8 12 40
185°F (85°C) and 20 psg(1.4 kgfcni) Ipm 15 38 76 30 46 152
Hot Water Boiler Rating BTU/hr 19,000 47,000 94,000 30,000 75,000 150,000
kw 5.5 14 29 8.8 22 44
Electrical 230/460VAC hp I 3 3 3 3 3 3
3 phase 50160 Hz kw 2.2 2.2 2.2 2.2 2.2 2.2
Instrument Air, dry & oil free, cfm 1 1 1 1 1 1
supplied at 100 psig (7 kg/cm 2 ) m3lhr 1.7 1.7 1.7 1.7 1.7 1.7
Natural Gas (Note 1) cfm 43 113 150 75 113 225
m3/hr 73 192 255 127 192 382
Propane (Note 1) Iblhr 2 5.2 6.9 3.5 5.2 10.3
kg/hr 0.9 2.4 3.1 1.6 2.4 4.7
Pasteurizer Volume US Gal 4.5 6.5 9 15 27 67
Liters 17 25 34 55 102 254
Table 3.1
Note 1 - Select the utility requirement for either Natural Gas or Propane, depending on boiler gas supply.
 APV Standard Apple Cider Pasteurizer
Instruction Manual

APPLE CIDER PASTEURIZER WITH PLATE HEAT EXCHANGER

STANDARD EQUIPMENT
MODEL
Heat Exchanger Balance i
! Holding Flow
NUMBER Feed Diversion Boiler
I HE1301B Tank Pump Loop B1003N
Valve
I
TK1101A
I PP1104C HL1300N
PV1306E
PPAC-02 SR15 30 Gal I 3 HP 1"00
1"T/C
19,000
I i 2 x 1.5 10 BTUfHR
3 HP 1" 00 47,000
PPAC-05 SR15 30 Gal 1"T/C
I I 2 x 1.5 10 BTU/HR
i 3 HP 1.5" 00 94,000
PPAC-10 SR15 30 Gal 1" TIC
I 2 x 1.5 10 BTU/HR
3 HP 1"00 30,000
PTAC-02 SOT - C - 25.4 x 19 30 Gal
I 2 x 1.5 10
1"T/C
BTU/HR
3 HP 1"00 75,000
PTAC-05 sor - C - 38.1 x 25.4 30 Gal
I 2 x 1.5 10
1" TIC
BTU/HR
3 HP 1.5" 00 150,000
30 Gal
PTAC-10 SOT - C - 50.8 x 38.1
I 2 x 1.5 10
1" TIC
BTU/HR

TABLE 3.2

FIGURE 3.2
PLATE HEAT EXCHANGER

~CD·~T ~~
TlcnQlA
APPLE CIDER PASTEURIZER
P&IDIAGRAM
,po, COP
 Ai'\{ St8ndard Apple Cider Pasteurizer
tnstrucnon Manual

STANDARD APPLE CIDER PLATE HEAT EXCHANGER PASTEURIZER

WEIGHTSAND DIMENSIONS
DIMENSIONS WEIGHT VOLUMES

MODEL Width
A
-I Length
B
Height
C
Panel
D*
Dry
f
I Flooded Flooded
n
4'6 8'6" 6'0' 2'5" lOS 1900 2200 US Gal 45
PPAC·02
(U) (2.6) (1,85) (0]6) (kg) (864) (1000) (Liters) (17)
4'6" 8'S· 6'0· 2'6" los 2000 2300 US Gal 65
(1,~) {2J3) ( 1.85) (0,76) (kg) (910) (1O(6) (liters) (25)
4'0" 8'8" ,on 2'0" lOS 2100 2400 9
(1,4) (2.6) 85) (0.75) (kg) (955) (1091 ) (34)
TABLE 3.3A
• Minimum clearance for panel door opening

,~< '"

;leI:. t~~~-'~cE;~};:;i':;;'~~' FIGURE 3.3,1A

PLATE HEAT EXCHANGER

APPLE CIDER PASTEURIZER

ELEVATION VIEW

FIGURE 3.3.2A

PLATE HEAT EXCHANGER

APPLE ClOER PASTEURIZER

PLAN VIEW