Journal of Pharmacognosy and Phytochemistry 2020; 9(4): 234-237

E-ISSN: 2278-4136
P-ISSN: 2349-8234
www.phytojournal.com Technologies to enhance the productivity and
JPP 2020; 9(4): 234-237
Received: 16-05-2020 profitability in mechanised semi dry rice
Accepted: 18-06-2020
cultivation
Vallal Kannan Sankaralingam
Assistant Professor (Agronomy)
Department of Irrigation and Vallal Kannan Sankaralingam
Drainage Engineering,
Agricultural Engineering College DOI: https://doi.org/10.22271/phyto.2020.v9.i4c.11679
and Research Institute (TNAU),
Kumulur, Trichy District,
Tamil Nadu, India Abstract
Experiments was conducted during dry season at Agricultural Engineering College and Research Institute
(TNAU), Kumulur in split plot design with three replication using ADT 49 (Medium duration) rice
variety with the objectives to find out alternate method of sowing to overcome the labour scarcity in dry
condition, to find out better spacing and crop geometry under mechanised sowing in dry condition and to
study the effect of water level and seed rate on productivity under semi dry condition. The main plot
treatment consisted of four levels of irrigation viz. Irrigation at critical stages up to 45 DAS (PI) and
submergence of 2.5 cm(I1), Supplemental irrigation through Alternate Wetting and Drying (AWD) from
45 DAS (PI) up to harvest(I2), Continuous submergence of 2.5 cm (Farmers practices under wet
condition)( I3) and Farmers practices (Farmers practices under dry condition).The sub plot treatment
consisted of four levels of crop geometry with different levels of seed rate viz., Mechanised sowing @
30 kg/ha (22.5x10 cm)( S1), Mechanised sowing 40 kg/ha (25 x15 cm)( S2), Mechanised sowing 50
kg/ha(25 x 8 cm) (S3) and Broad casting @ 75 kg/ha (S4). The experiment results showed that
mechanised sowing of seed @ 40kg ha-1(25x 15 cm) by multi crop planter under dry condition along with
supplemental irrigation through Alternate wetting and drying (AWD) method of irrigation had recorded
highest establishment percentage, optimum number of productive tillers, highest number of grains per
panicle, highest grain yield (7.91 t ha-1), net income (71,746 Rs ha-1), BCR (3.56) and highest water use
efficiency (0.60 kg ha-1 mm-1) and net changes in income of Rs. 60,574 ha-1 when compare to farmers
practices under semi dry rice cultivation.

Keywords: Mechanization, semi dry rice cultivation, alternate wetting and drying (AWD), partial
budgeting

Introduction
Rice is the important food crop of India covering about one-fourth of the total cropped area
and providing food to about half of the Indian population. Rice needs plenty of heat, plenty of
water, plenty of alluvium and plenty of labour to provide plenty of food for ever increasing
population. The demand for human activity in agriculture at a particular moment depends in
the first place on the growing season, the type of crop and its development stage. The timing of
the crop growing season is in most cases determined by temperature and/or water availability.
The method of cultivation of rice in a particular region depends largely on factors such as type
of land, type of soils, irrigation facilities, and availability of labourer, intensity and distribution
of rainfall. Considerable proportion of the total labour use in all agricultural operations is
associated with the rice cultivation. Indeed, rice was considered one of the most labour-
intensive crops. But the mechanization process has reduced the labour intensity in rice
cultivation. Agriculture mechanization is the application of mechanical technology and
increased power to agriculture, largely as a means to enhance the productivity of human labour
and often to achieve results well beyond the capacity of human labour. The farm
mechanization helps in effective utilization of inputs to increase the productivity of land and
labour. Besides it helps in reducing the hard work in farm operations.
Corresponding Author: The trend over the last 10 years indicates that the rice production is facing many constraints
Vallal Kannan Sankaralingam such as untimely release and non availability of water for the dry season, uncertainity in
Assistant Professor (Agronomy) rainfall, increase in labour cost coupled with poor efficiency of labour, increase in cost of
Department of Irrigation and
Drainage Engineering,
inputs and declining of soil fertility, leading to decrease in profitability for the farmers in rice
Agricultural Engineering College cultivation. Recent changes in rice production technology have improved the desirability
and Research Institute (TNAU), towards direct-seeding methods and there has been a rapid shift to the direct-seeding method
Kumulur, Trichy District, of rice establishment in Southeast Asia.
Tamil Nadu, India
~ 234 ~
Journal of Pharmacognosy and Phytochemistry http://www.phytojournal.com

Rice can be cultivated by different methods based on the type x15 cm)( S2), Mechanised sowing 50 kg/ha(25 x 8 cm) (S3)
of region. The principal rice ecosystems followed in southern and Broad casting @ 75 kg/ha (S4). The main plot treatment
states of India are Wet system, Dry system and Semi dry was imposed by using Parshal flume and the time taken for
system. In Dry Direct Seeded Rice (D-DSR), seeds can be each treatment was recorded and the quantity of water
sown before the start of the wet season, permitting the use of irrigated and total water requirement was calculated for each
early rains for crop establishment or up to 30 days after onset treatment. The sub plot treatment was imposed by using a
of rains for upland rice. After emergence, rice plants grow in multi crop planter fitted with an inclined plate seed metering
upland (aerobic) conditions until harvest (upland rice) or with mechanism under dry soil conditions and the quantum of seed
accumulated standing water in the field for a significant part and spacing was adjusted by fluted roller metering systems
of the crop cycle in rainfed low lands. Dry sown rice and calibrated for the required quantity of seed. The other
converted to flooded paddy 30 -40 DAS is called Semi dry agronomic practices of weed management viz., application of
rice in Tamil Nadu, India (Balasubramanian and Hill, 2002.) Pretilachlor@0.45l/ha on 5 DAS and two (power) weeding on
[1]
30 and 45 DAS were adopted along with recommended
Rice crop is strongly influenced by water supply, it is a semi - fertilizer application of 120: 50: 50 NPK kg/ha for delta zone.
aquatic plant requires near submergence. Water should be The experiment was conducted in Split plot design and
kept standing in the field throughout the growth period. Total replicated thrice.
water requirement of rice is 1200 - 1400 mm, maintenance of The observation on plant population (numbers/sq.m) at 15
water depths in field as recommended for high water use DAS was recorded and establishment percentage was
efficiency and yield. Tillering, panicle initiation, boot leaf calculated. The weed flora and weed count was recorded on
stage, heading/ panicle emergence and Flowering/anthesis 25 and 40 DAS. The growth and yield parameters of rice viz.,
(Reproductive phase) are critical crop growth stages for water plant height at PI and at harvest, tiller
stress, during these stages, soil moisture level should be production(numbers/hill), productive tillers (numbers/hill),
maintained at saturation level. Moisture stress at active number of grains per panicle (Table-1) were observed and
tillering phase causes 30% yield reduction and moisture stress grain and straw yields were calculated (Table-2). The
at reproductive phase causes 50 - 60% yield reduction. additional cost involved, cost reduction and net income
Moisture stress during rooting and tillering stage causes poor changes was calculated (Table-3) and depicted in fig. 1. The
root growth leading to poor crop establishment and low yield. quantity of water used, number of irrigation and water use
Precise water management is also a critical factor for high efficiency was calculated and presented in table-3.The cost of
productivity for both dry- and wet-seeded rice. Therefore, a cultivation, gross income, net income and BCR was
key concern is how the water requirement of rice culture can calculated (Table-4).
be reduced and how farmers can avoid puddling and
transplanting operations without yield penalty. Greater Results and Discussion
understanding is required about the maintenance of the The outcome of three year studies were pooled and analysed
population and their feeding zone, effect of weed pressure and on major parameters viz., grain yield, straw yield, economics,
supplementation of soil moisture through irrigation to water use efficiency and changes in net income through
enhance the production is important to develop management partial budgeting. All the parameters behaved in the same
strategies for direct-sown rice in the Tropics. With this trend in all the years in the treatment of supplemental
background, research was conducted at AEC&RI, Kumulur irrigation through AWD from PI(45DAS) to harvest had
for a period of three years (2014-2016) by changing crop achieved highest grain yield, straw yield, net income, BCR
geometry and seed rate by machine sowing and and higher water use efficiency. Increases in seed rate and
supplementation of water under mechanised direct sown rice continuous irrigation method has recorded reduction in weed
to enhance the production, profitability and water use density and increased plant population with higher
efficiency of rice under semidry condition. The same research establishment percentage. Mahajan et al, 2010 [3] suggested
was test verified through on farm trials in major semi dry that higher seed rates caused significant reductions in weed
areas of Tamil Nadu. dry matter, whereas higher than optimum seed rate (15–30
kg/ha) caused reduction in yield. Of all the seeding rates used,
Materials and Methods 15–30 kg/ha had the lowest grain-yield losses caused by
Experiments was conducted during dry season at AEC&RI, weeds. Therefore, it was concluded that optimum seed rate in
Kumulur in split plot design with three replication using ADT direct-seeded rice would minimize the effect of weed
49 (Medium duration) rice variety with the objectives to find competition on rice growth and grain yield and thus would
out alternate method of sowing to overcome the labour reduce herbicide use, promoting integrated-weed
scarcity in dry condition, to find out better spacing and crop management. Increase in seed rate up to 40 kg/ha is important
geometry under Mechanised sowing in dry condition and to under moisture stress treatment of I1- Irrigation at critical
study the effect of water level and seed rate on productivity stages up to 45 DAS(PI) and submergence of 2.5 cm and I4-
and water use efficiency under semi dry condition. Farmers’ practices (Dry conditions up to 45 days, then
The main plot treatment consisted of four levels of irrigation converted as wet condition). Roderick et al., 2011 [4] indicated
viz., Irrigation at critical stages up to 45 DAS (PI) and that the results of the impact analysis using both empirical
submergence of 2.5 cm(I1), Supplemental irrigation through approaches indicate that AWD, particularly the “Safe AWD”
Alternate Wetting and Drying (AWD) from 45 DAS (PI) up variant, reduces the hours of irrigation use (by about 38%),
to harvest(I2), Continuous submergence of 2.5 cm (Farmers without a statistically significant reduction in yields and
practices under wet condition)( I3) and Farmers practices profits. to achieve higher net change in income, the seed rate
(Farmers practices under dry condition).The sub plot should not increase beyond 40 kg/ha. The seed rate @ 40
treatment consisted of four levels of crop geometry with kg/ha has recorded higher grain yield, straw yield, net income,
different levels of seed rate viz., Mechanised sowing @ 30 BCR. Gareth et al., 2017 [2] found that at harvest the shoot
kg/ha (22.5x10 cm)( S1), Mechanised sowing 40 kg/ha (25 and grain mass was significantly greater for the plants grown
~ 235 ~
Journal of Pharmacognosy and Phytochemistry http://www.phytojournal.com

under AWD (9.0-9.4% and 12.0-15.4%, respectively) with the sowing @seed rate of 40 kg/ha(25x15cm) had achieved
plants grown under AWD having a greater number of higher grain yield (7.91 t/ha), net income (Rs.71746/ha) and
productive tillers. BCR(3.56), changes in net income of (Rs. 60574/ha)with
The treatment combination of supplemental irrigation through higher water use efficiency ( 0.60 kg/ kg ha-1 mm-1).
Alternate Wetting and Drying (AWD) along with machine

Table 1: Influence of seed rate and water regimes on grain yield ((t.ha-1)) under Mechanised semi dry rice cultivation
Sub plot treatments /Grain yield (t.ha-1)
Main plot treatments
S1 S2 S3 S4
2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean
I1 4.95 5.46 3.95 4.79 5.42 5.81 4.54 5.26 3.80 3.92 3.93 3.88 3.34 3.42 3.87 3.54
I2 6.77 7.45 6.03 6.75 7.90 8.42 7.42 7.91 5.40 5.98 6.69 6.02 4.92 5.15 5.7 5.26
I3 6.34 6.91 4.57 5.94 7.51 7.26 5.9 6.89 5.06 5.26 5.4 5.24 4.08 4.22 5.29 4.53
I4 4.43 4.62 2.73 3.93 4.24 4.52 2.68 3.81 3.40 3.66 3.09 3.38 3.08 3.25 2.63 2.99
Mean 5.62 6.11 4.32 6.27 6.50 5.14 4.42 4.71 4.78 3.86 4.01 4.37
Int Int
Main plot Sub plot
MxS SxM
SED 0.072 0.068 0.016 0.014
CD(p=0.05) 0.16 0.16 0.33 0.32

Table 2: Influence of seed rate and water regimes on straw yield ((t.ha-1)) under Mechanised semi dry rice cultivation
Sub plot treatments /Straw yield (t.ha-1)
Main plot treatments
S1 S2 S3 S4
2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean
I1 4.49 5.34 3.87 4.57 5.05 5.76 4.49 5.10 3.72 3.61 3.62 3.65 3.48 3.76 4.26 3.83
I2 6.10 7.60 6.15 6.62 7.35 8.93 7.86 8.05 5.18 6.70 7.49 6.46 5.02 5.88 6.48 5.79
I3 6.71 6.78 4.47 5.99 7.68 7.04 5.72 6.81 5.50 5.37 5.51 5.46 4.53 4.47 5.6 4.87
I4 4.14 4.53 2.68 3.78 4.02 4.57 2.71 3.77 3.25 3.81 3.22 3.43 2.93 3.45 2.79 3.06
Mean 5.36 6.06 4.29 6.03 6.57 5.20 4.41 4.87 4.96 3.99 4.39 4.78
Int Int
Main plot Sub plot
MxS SxM
SED 0.052 0.068 0.011 0.016
CD(p=0.05) 0.13 0.15 0.27 0.30

Table 3: Influence of water regimes on number of irrigation and water use efficiency of rice under Mechanised semi dry rice cultivation.
Total quantity of water used Water use efficiency
Number of irrigation
Treatment (m3. ha-1) (kg. ha-1 mm-1)
2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean
I1: Irrigation at critical stages up to 45 DAS (PI) and
22 20 24 22 9830 8546 9428 9268 0.32 0.54 0.43 0.43
submergence of 2.5 cm
I2: Supplemental irrigation through Alternate Wetting and
30 28 30 29 12912 9860 10260 11011 0.48 0.68 0.63 0.60
Drying (AWD) from 45 DAS (PI) up to harvest
I3: Continuous submergence of 2.5 cm 33 30 34 32 13556 11800 12400 12585 0.42 0.42 0.43 0.42
I4: F Farmers practices (Farmers practices under dry condition) 20 21 28 23 10750 9440 9980 10057 0.35 0.43 0.28 0.35

Table 4: Influence of seed rate and water regimes on economics under Mechanised semi dry rice cultivation
Cost of Cultivation (Rs. ha-1) Gross income(Rs. ha-1) Net income (Rs. ha-1) BCR (GI/COC)
Treatment
2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean 2014 2015 2016 Mean
I1S1 22670 27670 29470 26603 58710 65346 47258 57105 36040 42676 24588 34435 2.59 2.36 1.6 2.18
I1S2 22910 27910 29710 26843 64485 69638 54401 62841 41575 46728 31491 39931 2.81 2.5 1.83 2.38
I1S3 23150 28150 29950 27083 45480 46570 46677 46242 22330 23420 23527 23092 1.96 1.65 1.56 1.72
I1S4 23390 28390 30190 27323 40290 41553 47009 42951 16900 18163 23619 19561 1.72 1.46 1.56 1.58
I2S1 23170 28170 28770 26703 80235 89629 72492 80785 57065 66459 49322 57615 3.46 3.18 2.52 3.05
I2S2 23410 28410 29010 26943 93975 101798 89696 95156 70565 78388 66286 71746 4.01 3.58 3.09 3.56
I2S3 23650 28650 29250 27183 64470 72836 81443 72916 40820 49186 57793 49266 2.73 2.54 2.78 2.68
I2S4 23890 28890 29490 27423 59190 62899 69545 63878 35300 39009 45655 39988 2.48 2.18 2.36 2.34
I3S1 22970 27970 28170 26370 76635 82718 54644 71332 53665 59748 31674 48362 3.34 2.96 1.94 2.75
I3S2 23210 28210 28410 26610 90375 86793 70487 82552 67165 63583 47277 59342 3.89 3.08 2.48 3.15
I3S3 23450 28450 28650 26850 61380 63278 64962 63207 37930 39828 41512 39757 2.62 2.22 2.27 2.37
I3S4 23690 28690 28890 27090 49635 51020 63920 54858 25945 27330 40230 31168 2.1 1.78 2.21 2.03
I4S1 22370 27370 29370 26370 52725 55311 32667 46901 30355 32941 10297 24531 2.36 2.02 1.11 1.83
I4S2 22610 27610 29610 26610 50550 54308 32223 45694 27940 31698 9613 23084 2.24 1.97 1.09 1.77
I4S3 22850 27850 29850 26850 40575 44140 37289 40668 17725 21290 14439 17818 1.78 1.58 1.25 1.54
I4S4 23090 28090 30090 27090 36735 39298 31809 35947 13645 16208 8719 12857 1.59 1.4 1.06 1.35

~ 236 ~
Journal of Pharmacognosy and Phytochemistry http://www.phytojournal.com

Fig 1: Influence of Mechanised sowing and supplemental irrigation methods on changes in Net income (Rs.ha-1)

Table 5: Influence of seed rate and water regimes on Net Income changes (Partial budgeting) under Mechanised semi dry rice cultivation during
(Rs. ha-1).
Additional return (A) Reduced costs Additional cost Reduced return Net change in income
Treatment combinations
(Rs. ha-1) (B) (Rs. ha-1) (C ) (Rs. ha-1) (D) (Rs. ha-1) (A+B)-(C+D) (Rs. ha-1)
I1S1 20749 520 0 0 21269
I1S2 26466 280 0 0 26746
I1S3 11070 70 30 0 11110
I1S4 8728 0 200 0 8528
I2S1 45507 660 40 0 46127
I2S2 60194 540 160 0 60574
I2S3 41586 420 280 0 41726
I2S4 30669 300 400 0 30569
I3S1 33128 1020 0 0 34148
I3S2 43087 840 60 0 43867
I3S3 28567 720 180 0 29107
I3S4 21917 600 300 0 22217
I4S1 8436 720 0 0 9156
I4S2 7712 480 0 0 8192
I4S3 5161 240 0 0 5401
I4S4 0 0 0 0 0

Conclusion 4. Roderick Rejesus M, Florencia Palis G, Divina Gracia,

Sowing of seed by seed drill @ 40 kg/ha (25x 15 cm)with Rodriguez P, Ruben Lampayan M, Bas Bouman AM.
supplemental irrigation through alternate wetting and drying Impact of the alternate wetting and drying (AWD) water-
(AWD) method of irrigation from panicle initiation (PI) to saving irrigation technique: Evidence from rice producers
harvest is important to achieve higher yield parameters, grain in the Philippines Food policy. 2011; 36(2):280-288.
and straw yield and changes in net income also higher BCR
under semi dry rice cultivation.

Reference
1. Balasubramanian V, Hill JE. Direct seeding of rice in
Asia: emerging issues and strategic research needs for the
21st century. In Book -Pandey S, Mortimer M, Wade L,
Tuong TP, Lopez K, Hardy B, editors. 2002. Direct
seeding: research issues and opportunities. International
Rice Research Institute, 2002, 383.
2. Gareth Norton J, Mohammad Shafaei, Anthony Travis J,
Claire Deacon M, John Danku, Dawn Pond et al. 2017.
Impact of alternate wetting and drying on rice
physiology, grain production, and grain quality. 2017;
205:1-13.
3. Mahajan G, Gill MS, Singh K. Optimizing Seed Rate to
Suppress Weeds and to Increase Yield in Aerobic Direct-
seeded Rice in Northwestern Indo-Gangetic Plains.
Journal of new seeds. 2010; 11(3):225-238.
~ 237 ~