Service Manual: HCD-H551

HCD-H551
SERVICE MANUAL AEP Model

UK Model
E Model
Tourist Model
HCD-H551 is the tuner, deck, CD and

amplifier section in MHC-G55/551. Photo: E model
Dolby noise reduction manufactured under license from Model Name Using Similar Mechanism NEW
Dolby Laboratories Licensing Corporation.
“DOLBY” and the double-D symbol a are trademarks of CD CD Mechanism Type CDM28-5BD19
Dolby Laboratories Licensing Corporation. SECTION Base Unit Type BU-5BD19
Optical Pick-up Type KSS-213BA/F-NP
TAPE Model Name Using Similar Mechanism HCD-H501
DECK
SECTION Tape Transport Mechanism Type TCM-220WR2E
SPECIFICATIONS
CD player section Tourist model:
System Compact disc and digital 76.0 – 108.0 MHz
audio system Other models:
Laser Semiconductor (λ = 780nm) 87.5 – 108.0 MHz
Emission duration: Aerial FM lead aerial
continuous Aerial terminals 75 ohm unbalanced
Laser output Max 44.6 µW* Intermediate frequency
*This output is the value 10.7 MHz
measured at a distance of
200mm from the objective AM tuner section
lens surface on the Optical Tuning range
Pick-up Block with 7mm German, Italian models:
aperture. AM: 531 – 1,602 kHz (with
Wavelength 780 – 790 nm the interval set at 9 kHz)
Frequency response AEP, UK, East European models:
2 Hz – 20 kHz (±0.5 dB) MW: 531 – 1,602 kHz (with
Signal-to-noise ratio the interval set at 9 kHz)
More than 90 dB LW: 153 – 279 kHz (with
Dynamic range More than 90 dB the interval set at 3 kHz)
Other models:
Tuner section MW: 531 – 1,602 kHz (with
FM stereo, FM/AM superheterodyne tuner the interval set at 9 kHz)
530 – 1,710 kHz (with the
FM tuner section interval set at 10 kHz)
East European model: SW: 5.95 – 17.90 MHz
65.0 – 78.0 MHz, — Continue on next page —
COMPACT DISC DECK RECEIVER

87.5 – 108.0 MHz
MICROFILM
—1—
Downloaded from www.Manualslib.com manuals search engine
Aerial AM loop aerial, General
External aerial terminals Power requirements
Intermediate frequency AEP, UK, German, Italian, East European
450 kHz models:
220 – 230 V AC, 50/60 Hz
Amplifier section Malaysia model:
AEP, UK, German, Italian, East European 220 – 240 V AC, 50/60 Hz
models: Thailand model:
DIN power output 220 V AC, 50/60 Hz
20 W + 20 W (6 ohms, at Other models:
1 kHz, DIN) 110 – 120 V or 220 – 240 V
Continuous RMS power output AC, 50/60 Hz
30W+30W (6 ohms, at Adjustable with the voltage
1kHz, 10% THD) selector
Music power output Power consumption
40 W + 40 W (6 ohms, at 67 W
1 kHz, 10% THD) Dimensions Approx. 280 x 325 x 360 mm
E, Saudi Arabia, Hong Kong, Singapore, (11 1/8 x 12 7/8 x 14 1/4 in)
Malaysia, Taiwan, Tourist, Thailand, Indonesian (w/h/d)
models: incl. projecting parts and
Peak music power output controls
400 W Mass Approx. 7.5 kg (16 lb 9 oz)
Continuous RMS power output
30 W + 30 W (6 ohms at Design and specifications are subject to
1 kHz, 10% THD) change without notice.
Inputs
VIDEO IN (phono jacks):
Voltage 250 mV,
impedance 47 kilohms
MIX MIC (phone jacks):
ensitivity 1 mV,
impedance 10 kilohms
Outputs
PHONES (stereo phone jack):
accepts headphones of 8 ohms
or more.
SPEAKER: accepts impedance of 6 to
16 ohms.
E, Saudi Arabia, Hong Kong,
Singapore, Malaysia, Taiwan, Tourist,
Thailand, Indonesian models:
SUPPER WOOFER:
Voltage 1 V, impedance
1 kilohms
Tape player section

Recording system
4-track 2-channel stereo
Frequency response
(DOLBY NR OFF)
40 – 13,000 Hz (±3 dB),
using Sony TYPE I cassette
40 – 14,000 Hz (±3 dB),
using Sony TYPE II cassette
Wow and flutter
±0.15% W.Peak (IEC)
0.1% W.RMS (NAB)
±0.2% W.Peak (DIN)
—2—
MODEL IDENTIFICATION
CAUTION
— BACK PANEL — Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
Parts No.
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing

• Keep the temperature of soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
Laser component in this product is capable of emitting radiation

MODEL PARTS No.
exceeding the limit for Class 1.
AEP model 4-979-273-0π
UK model 4-979-273-1π
This appliance is classified as a
German model 4-979-273-2π CLASS 1 LASER product.
Italian model 4-979-273-3π The CLASS 1 LASER
East European model 4-979-273-4π PRODUCT MARKING is
located on the rear exterior.
E model 4-979-274-0π
Saudi Arabia, Taiwan model 4-979-274-1π
Malaysia model 4-979-274-2π
Singapore model 4-979-274-3π This caution
Hong Kong model 4-979-274-4π label is located
inside the unit.
Tourist model 4-979-274-5π
Indonesian model 4-979-274-6π
Thailand model 4-979-274-7π
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED

LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND
IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
—3—
TABLE OF CONTENTS
Section Title Page Section Title Page
SECTION 1. SERVICING NOTE ................................ 5 SECTION 7. EXPLODED VIEWS

7-1. Case Section ...................................................................... 71
SECTION 2. GENERAL ....................................................... 6 7-2. Back Panel Section ............................................................ 72
7-3. Front Panel Section 1 ......................................................... 73
SECTION 3. DISASSEMBLY 7-4. Front Panel Section 2 ......................................................... 74
3-1. Front Panel .......................................................................... 8 7-5. CD Mechanism Section (CDM28-5BD19) ....................... 75
3-2. TC Mechanism Deck ........................................................... 8 7-6. Base Unit Section (BU-5BD19) ........................................ 76
3-3. HP Board, Jog Board and Panel Board ............................... 9 7-7. TC Mechanism Section 1 (TCM-220WR2E) .................... 77
3-4. CD Block ........................................................................... 10 7-8. TC Mechanism Section 2 (TCM-220WR2E) .................... 78
3-5. CD Mechanism Deck ........................................................ 10
SECTION 8. ELECTRICAL PARTS LIST .................... 79
SECTION 4. MECHANICAL ADJUSTMENTS .......... 11
• Abbreviation
SECTION 5. ELECTRICAL ADJUSTMENTS G: German model.
DECK Section ............................................................................. 11 IT: Italian model.
TUNER Section ........................................................................... 14 EE: East European model.
CD Section ................................................................................... 16 EA: Saudi Arabia model.
SP: Singapore model.
SECTION 6. DIAGRAMS MY: Malaysia model.
TW: Taiwan model.
6-1. Circuit Boards Location .................................................... 18
HK: Hong Kong model.
6-2. Block Diagrams
IA: Indonesian model.
• Tuner Section (AEP, UK, G, IT, EE Model) .................. 19
TH: Thailand model.
• Tuner Section
JE: Tourist model.
(E, EA, SP, MY, TW, HK, IA, JE Model) ...................... 21
• Tuner Section (TH Model) ............................................. 23
• Deck Section .................................................................. 25
• CD Section ..................................................................... 27
• Main Section .................................................................. 29
6-3. Printed Wiring Board — Tuner Section —
(AEP, UK, G, IT, EE Model) ............................................. 31
6-4. Schematic Diagram — Tuner Section —
(AEP, UK, G, IT, EE Model) ............................................. 32
(E, EA, SP, MY, TW, HK, IA, JE Model) .......................... 34
(E, EA, SP, MY, TW, HK, IA, JE Model) .......................... 37
(TH Model) ........................................................................ 37
(TH Model) ........................................................................ 38
6-9. Printed Wiring Board — Main Section — ........................ 42
6-10. Schematic Diagram — Main Section — ........................... 45
6-11. Schematic Diagram — Deck Section — ........................... 49
6-12. Printed Wiring Board — Deck Section — ........................ 53
6-13. Printed Wiring Board — Panel Section — ........................ 55
6-14. Schematic Diagram — Panel Section — ........................... 57
6-15. Schematic Diagram — CD Section — .............................. 61
6-16. Printed Wiring Board — CD Section — ........................... 63
6-17. IC Block Diagrams — CD Section — .............................. 65
6-18. IC Pin Functions
• IC501 Graphic Control (ASD042) .................................. 67
• IC701 Master Control (TMP87CP64YF) ....................... 68
—4—
SECTION 1
SERVICING NOTE
NOTES ON LASER DIODE EMISSION CHECK
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-up
The laser diode in the optical pick-up block may suffer electrostatic
block. Therefore, when checking the laser diode emission, observe
break-down because of the potential difference generated by the
from more than 30 cm away from the objective lens.
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also use
[Switching the channel step 9 KHz/10 KHz]
the procedure in the printed matter which is included in the repair
parts.
Press ENTER/NEXT button and POWER button simultaneously
The flexible board is easily damaged and should be handled with
to switch the AM channel step 9 KHz and 10 KHz. Be sure not to
care.
change with carelessness.
HOW TO OPEN THE DISC TRAY WHEN POWER SWITCH
TURNS OFF
Insert a tapering driver into the aperture of the unit bottom, and
turn in the direction of arrow.
* To close the disc tray, turn the driver in the reverse direction.
[FL Display Tube, LED All Lit and Key Check mode]
When the TUNER/BAND , DISPLAY/DEMO , and MENU 2 When the AMS dial is rotated in the clockwise direction, the count
buttons are pressed simultaneously, the FL display tube and LEDs increases in the following order.
will all light up. Press any button to enter the key check mode. J1 n J2 n J3.
When the key check mode is entered, the FL display tube displays When rotated in the counterclockwise direction, it decreases in the
“K 1 J0 V0”. Each time a button is pressed, the counter increases in following order.
the following order, K 2 n K 3 n K 4. J0 n J9 n J8.
If buttons already pressed once are pressed again, the counter will To exit form the test mode, press the TUNER/BAND , DISPLAY/
not increase. When the VOLUME knob is rotated in the + direction, DEMO , MENU 2 buttons simultaneously again.
the count increases in the following order.
V1 n V2 n V3.
When rotated in the–direction, it decreases in the following order.
V0 n V9 n V8.
—5—
SECTION 2 This section is extracted from
GENERAL instruction manual.
(AEP, UK, German, Italian, East European

models)
(E, Saudi Arabia, Hong Kong, Malaysia,

Singapore, Taiwan, Tourist, Thailand,
Indonesian models)
1 VIDEO IN jacks (22)

2 SPEAKER L/R connectors (4)
3 SUPER WOOFER jack (22)
4 ANTENNA terminals (4)
5 Voltage selector (Except Malaysia, Thailand
models) (5)
—6—
—7—
SECTION 3
DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
4 Two screws
3-1. FRONT PANEL (+BVTP2.6X8)
1 Remove the connectors

(Main board: CN402, CN702)
(HP board: CN513)
CN402
CN702
CN513
2 Two screws
(+BVTT3X8)
5 Remove the claws

(Three positions)
3 Two screws
(+BVTT3X8)
3-2. TC MECHANISM DECK
6 TC mechanism deck 5 Three screws

(+BVTP2.6X8)
3 Cassette holder
assembly (A), (B)
2 Remove the claws

(Four positions)
1 Push the EJECT button.

(Two positions)
4 Torsion spring
(L), (R)
—8—
3-3. HP BOARD, JOG BOARD AND PANEL BOARD
*Note: It will be easy to remove if you push

lightly from the hole of the JOG board
with some screwdrivers or etc.
Screw driver
3 Nut
4 Nut
1 Knob (VOL) * Note
2 Knob (JOG) * Note
.
!™ JOG board
5 Two screws
(+BVTP2.6X8)
6 HP board
8 Six screws
(+BVTP2.6X8) 7 Six screws
(+BVTP2.6X8)
!£ Panel board
9 Two claws
!¡ Claw
0 Three claws
—9—
3-4. CD BLOCK
4 CD block
1 Remove the connectors (CD mechanism deck
(Main board: CN201) and CD chassis)
(Loading board: CN291) 3 Two screws
(+BVTP3X8)
2 PC board holder
CN291
CN201
3-5. CD MECHANISM DECK

1 Two screws
(+BVTP3X8)
3 Remove the CD mechanism

deck direction of arrow.
2 Two claws
— 10 —
SECTION 4 SECTION 5
MECHANICAL ADJUSTMENTS ELECTRICAL ADJUSTMENTS
Precaution DECK SECTION 0 dB=0.775V
1. Clean the following parts with a denatured alcohol-moistened
swab: 1. Demagnetize the record/playback head with a head damagnetizer.
record/playback heads pinch rollers 2. Do not use a magnetized screwdriver for the adjustments.
erase head rubber belts 3. After the adjustments, apply suitable locking compound to the
capstan idlers parts adjusted.
2. Demagnetize the record/playback head with a head demagnetizer. 4. The adjustments should be performed with the rated power supply
3. Do not use a magnetized screwdriver for the adjustments. voltage unless otherwise noted.
4. After the adjustments, apply suitable locking compound to the 5. The adjustments should be performed in the order given in this
parts adjusted. service manual. (As a general rule, playback circuit adjustment
5. The adjustments should be performed with the rated power supply should be completed before performing recording circuit
voltage unless otherwise noted. adjustment.)
6. The adjustments should be performed for both L-CH and R-CH.
Torque Measurement 7. Switches and controls should be set as follows unless otherwise
specified.
Torque Torque meter Meter reading
DOLBY NR switch: OFF
36 to 61 g • cm
FWD CQ-102C
(0.5 - 0.84 oz • inch) Tape Signal Used for
FWD 2 to 6 g • cm P-4-A100 10 kHz, –10 dB Azimuth Adjustment
CQ-102C
back tension (0.02 - 0.08 oz • inch)
WS-48B 3 kHz, 0 dB Tape Speed Adjustment
36 to 61 g • cm
REV CQ-102RC P-4-L300 315 Hz, 0 dB Level Adjustment
(0.5 - 0.84 oz • inch)
REV 2 to 6 g • cm
CQ-102RC
back tension (0.02 - 0.08 oz • inch) Record/Playback Head Azimuth Adjustment
61 to 143 g • cm (Deck A, Deck B)
FF/REW CQ-201B
(0.85 - 1.99 oz • inch)
100 g or more Note: Perform this adjustments for both decks.
FWD tension CQ-403A
(3.53 oz or more)
100 g or more
Procedure:
REV tension CQ-403R 1. Mode : Playback
(3.53 oz or more)
test tape
P-4-A100 main board
(10kHz, –10dB) CN403
Pin 3 (L-CH) level meter
Pin 1 (R-CH)
set +
–
main board
CN403
Pin 2 (GND)
— 11 —
2. Turn the adjustment screw and check output peaks. If the peaks Tape Speed Adjustment (Deck A)
do not match for L-CH and R-CH, turn the adjustment screw so
that outputs match within 1 dB of peak. Note: Start the Tape Speed adjustment as below after setting the
test mode.
The tape speed can be changed with the HIGH SPEED
DUBBING button during the test mode.
Method :
L-CH 1. Turn the power switch on.
peak output
within 2. Press the DISPLAY/DEMO button, MENU 1 button and
level
1dB within 1dB TUNER/BAND button simultaneously.
Procedure :
Mode: Playback
test tape WS-48B frequency counter
R-CH (3kHz, 0dB)
peak
screw
position set +
screw
L-CH R-CH –
position
peak peak
main board
CN403 Pin 3 (L-CH)
3. Mode: Playback Pin 1 (R-CH)
1. Insert the WS-48B into the deck A to playback.
test tape
P-4-A100 main board 2. Press the HIGH SPEED DUBBING button. Then at HIGH
(10kHz, –10dB) CN403 SPEED mode.
Pin 3 (L-CH) 3. Adjust the RV652 on the MD board so that the frequency
oscilloscope
counter reading becomes 6,000 ± 30 Hz.
Pin 2 (GND) 4. Press the HIGH SPEED DUBBING button again to be set the
L
NORMAL SPEED mode.
set
5. Set to the playback mode.
R 6. Adjust the RV651 on the MD board so that the frequency
counter reading becomes 3,000 ± 15 Hz.
Pin 1 (R-CH) Frequency difference between deck A and deck B the beginning
of the tape should be within ± 1.5%.
Waveform of oscilloscope
Adjustment Location: MD board
Playback Level Adjustment (Deck A, Deck B)

in phase 45˚ 90˚ 135˚ 180˚
good wrong Procedure:
Mode: Playback
4. After the adjustments, apply suitable locking compound to the

parts adjusted. test tape P-4-L300 level meter
(315Hz, 0dB)
Adjustment Location: Playback Head (Deck A)
Record/Playback/Erase Head (Deck B) set
main board
CN403 Pin 3 (L-CH)
Pin 1 (R-CH)
Deck A is RV311 (L-CH) and RV411 (R-CH), deck B is RV301
(L-CH) and RV401 (R-CH)
so that adjustment within the following adjustment level.
Adjustment level:
FWD side REV side CN403 playback level: 301.5 to 338.3 mV (–8.2 to –7.2 dB)
level difference between the channels: within ± 0.5 dB
Adjustment screw Adjustment Location: MD board
— 12 —
Record Bias Adjustment (Deck B) Record Level Adjustment (Deck B)
Procedure: Procedure:
1. Press FUNCTION button to Select VIDEO. 1. Press FUNCTION button to Select VIDEO.
2. Mode: record 2. Mode: record
VIDEO IN
1) 315Hz
2) 10kHz
} 50 mV (–23.8 dB) VIDEO IN
315kHz 50mV (–23.8 dB)
AF OSC AF OSC
blank tape blank tape
600 CS-123 600 CS-123
attenuator attenuator
set set
3. Mode: Playback 3. Mode: Playback

recorded recorded
level meter
position portion level meter
set set
main board main board

CN403 Pin 3 (L-CH) CN403 Pin 3 (L-CH)
Pin 1 (R-CH) Pin 1 (R-CH)
4. Confirm playback the signal recorded in step 2 become adjustment 4. Confirm playback the signal recorded in step 2 become adjustment
level as follows. level as follows.
If these levels do not adjustment level, adjust the RV341 (L-CH) If these levels do not adjustment level, adjust the RV301 (L-CH)
and RV441 (R-CH) on the MD board to repeat steps 2 and 3. and RV351 (R-CH) on the main board to repeat steps 2 and 3.
Adjustment level: The playback output of 10 kHz level difference Adjustment level:
against 315 Hz reference should be ± 0.5 dB. CN403 PB level: 47.3 to 53.1 mV (–24.3 to –23.3 dB)
Adjustment Location: MD board Adjustment Location: MAIN board
Adjustment Location:
[MD BOARD] (Conductor Side) [MAIN BOARD] (Component Side)
RV341 (L CH), 441 (R CH)
Record Bias Adjustment
1 3
RV651 (Normal speed) RV351
RV301 RV652 (High speed) RV651 RV652
CN403
RV401 RV341 Tape Speed Adjustment
RV441 RV351 IC401
RV311 Record Level Adjustment
RV301 (L CH), 401(R CH) RV301
Playback Level Adjustment RV411
(R CH)
(Deck B)
RV311 (L CH), 411 (R CH) RV301
Playback Level Adjustment Record Level Adjustment
(Deck A) (L CH)
— 13 —
TUNER SECTION 0dB=1µV
Note: As a front-end (FE1) is difficult to repair if faulty, replace it

with new one.
AM Tuned Level Adjustment

Note: FM Tuned Level adjustment should be performed after this
AM Tuned Level Adjustment.
Setting:
loop antenna
Band: AM or MW
loop antenna (Supplied accessories)
AM RF SSG
set
AM antenna
30% amplitude 60cm terminal (TM1)
modulation by
Field strength dB (µV/m) = SSG output level dB (µV/m) –26dB.
400Hz signal
Modulation: 999 kHz (at 9 kHz step)
1,050 kHz (at 10 kHz step) Adjustment Location:
EXCEPT Thailand model
Procedure: [TCB BOARD] (Component Side)
1. Set the output of SSG so that the input level of the set becomes 55
dB. RV41
2. Tune the set to 999 kHz or 1,050 kHz. RV41
3. Adjust RV41 (EXCEPT Thailand model), RV42 (Thailand model) AM Tuned Level
Adjustment
to the point (moment) when the TUNED indicator will change
from going off to going on.
Adjustment Location: TCB board

RV42 IC41 TM1
FM Tuned Level Adjustment
Note: This adjustment should be after AM Tuned Level Adjustment. RV42
FM Tuned Level
Setting: Adjustment
Band: FM
FM RF stereo signal FE1

generator
75 coaxial Thailand model
[TCB BOARD] (Component Side)
set RV42
RV42
Carrier frequency: 98MHz AM Tuned Level
Modulation: AUDIO 1kHz, 75kHz FM ANTENNA terminal Adjustment
deviation (100%) (TM1)
Output level: 25dB (at 75 open)
Procedure: RV41 IC2 TM1

1. Supply a 25 dB 98 MHz signal from the ANTENNA terminal.
2. Tune the set to 98 MHz.
3. Adjust RV42 (EXCEPT Thailand model), RV41 (Thailand model) RV41
to the point (moment) when the TUNED indicator will change FM Tuned Level
from going off to going on. Adjustment
Adjustment Location: TCB board FE1
— 14 —
SW OSC Voltage Adjustment Adjustment Location:
(E, EA, MY, SP, HK, TW, IA model)
[TCB BOARD] — Component Side —
Setting:
Band: SW
Procedure: D1, CV2, T2

1. Connect digital Voltmeter to diode D1 center lead and ground. SW OSC Voltage
Adjustment
2. Adjust for a following value reading on digital voltmeter.
CV2 CV1
Adjustment Reading on digital
Set frequency
part voltmeter
IC41 D1
5.95 MHz T2 1.2 ± 0.1 V
SW TM1
17.9 MHz CV2 8.5 ± 0.2 V T1
T2
CV1, T1
SW Tracking Adjustment SW Tracking
(E, EA, MY, SP, HK, TW, IA model) Adjustment
Setting:
Band: SW
AM RF SSG level meter • Abbreviation
EA: Saudi Arabia model.
MY: Malaysia model.
set SP: Singapore model.
HK: Hong Kong model.
30% amplitude SPEAKER terminal TW: Taiwan model.
modulation by IA: Indonesian model.
AM ANTENNA terminal
400Hz signal
Procedure:
Adjust for maximum reading on level meter.
Set frequency Adjustment

part
7 MHz T1
SW
17 MHz CV1
• Repeat the procedures is each adjustment several times, and the

frequency coverage and tracking adjustment should be finally done
by the trimmer capacitors.
— 15 —
S Curve Check
CD SECTION
Procedure :
Note: oscilloscope
1. CD Block is basically designed to operate without adjustment. BD board
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. TP (FE)
3. Use an oscilloscope with more than 10M impedance. TP (VC)
4. Clean the object lens by an applicator with neutral detergent when
the signal level is low than specified value with the following
1. Connect oscilloscope to test point TP (FEO).
checks.
2. Connect between test point TP (FOK) and Ground by lead wire.
5. Adjust the focus bias adjustment when optical block is replaced.
3. Turn Power switch on.
4. Put disc (YEDS-18) in and turned Power switch on again and
Focus Bias Adjustment
actuate the focus search. (actuate the focus search when disc table
oscilloscope is moving in and out.)
BD board 5. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within 2.4 ± 0.7
TP (RF) Vp-p.
TP (VC)
S-curve waveform
6. After check, remove the lead wire connected in step 2.
Procedure: symmetry
1. Connect oscilloscope to test point TP (RF).
(Ground terminal : TP (VC))
2. Turned Power switch on.
3. Put disc (YEDS-18) in and playback. A
within 2.4 ± 0.7 Vp-p
4. Adjust RV101 so that the waveform is clear. B
(Clear RF signal waveform means that the shape “ ” can be clearly
distinguished at the center of the waveform.)
5. After adjustment, check the RF signal level.
Note: • Try to measure several times to make sure than the ratio of
A : B or B : A is more than 10 : 7.
• RF signal
• Take sweep time as long as possible and light up the
VOLT/DIV: 200 mV
brightness to obtain best waveform.
TIME/DIV: 500 nS
RF Level Check
Procedure :
level: 1.3 ± 0.3 Vp-p
oscilloscope
BD board
TP (RF)
TP (VC)
1.Connect oscilloscope to test point TP (RF) on BD board.

2.Turned Power switch on.
3.Put disc (YEDS-18) in and playback.
4.Confirm that oscilloscope waveform is clear and check RF signal
level is correct or not.
Note: Clear RF signal waveform means that the shape “ ” can be
clearly distinguished at the center of the waveform.
RF signal waveform
VOLT/DIV: 200 mV
TIME/DIV: 500 nS
level: 1.3 ± 0.3 Vp-p
— 16 —
E-F Balance Check Adjustment Location:
oscilloscope [BD BOARD] — Component Side —

BD board
RF
FOK
TP (TEO)
TP (VC) RV101
IC102
IC101
Procedure: TEI
1. Connect test point TP701 (ADJ) on Main board to Ground with a RV103
lead wire. FEO FEI
2. Connect oscilloscpe to test point TP (TEO). TEO
3. Turned Power switch on. RV102
4. Put disc (YEDS-18) in and playback. VC
5. Confirm that the oscilloscope waveform is symmetrical on the
top and bottom in relation to 0Vdc, and check this level.
Traverse waveform
IC104
A PCK
0V
B GND
level: 300 ± 100 mVp-p [MAIN BOARD] — Conductor Side —

Specified level: • A – B x 100 = less than ± 7%
2 (A + B)
• A + B = 300 ± 100 mVp-p
6. Remove the lead wire connected in step 1.
Focus/Tracking Gain Adjustment (RV102, RV103)
This gain has a margin, so even if it is slightly off.

There is no problem.
Therfore, do not perform this adjustment.
Please note that it should be fixed to mechanical center position when
you moved and do not know original position.
IC701
TP701
(ADJ)
— 17 —
SECTION 6
DIAGRAMS
6-1. CIRCUIT BOARDS LOCATION
TRANSFORMER board
TCB board
PANEL board MAIN board
HP board
POWER AMP board

JOG board
Note: pA is including in MD board.
BD board
LOADING board
pA
MOTOR board
LEAF SWITCH board
MD board (including p A)
— 18 —
6-18. IC PIN FUNCTIONS
• IC501 GRAPHIC CONTROL (ASD042)
Pin No. Pin Name I/O Function

1 to 7 GR7-1 O Fluorescent indicator tube grid signal output.
8 VDD – +5V
9, 10 LED9, 10 O LED drive signal output
11 KEY SELECT O Not used. (Open)
12 VOL IN B I Volume encoder signal input.
13 REQ GM I/O Request signal from/to master control.
14 CLK MG I Serial clock input.
15 DATA GM O Serial data output to master control.
16 DATA MG I Serial data input from master control.
17 RESET I Reset signal input.
18 PANEL SW I CD door open detection input. (Not used) (Open)
19 LED SELECT O LED select signal output.
20 AVSS – Ground
21 to 24 SPEANA IN1-4 I Spectram analizer signal input. (Connected to ground)
25 to 28 KEY IN1-4 I Key matrix input.
29 AVDD –
+5V
30 AVREF –
31 JOG IN B I Jog dial encoder signal input.
32 XT2 I Not used. (open)
33 VSS – Ground
34 X1 I
X’tal (5 MHz).
35 X2 O
36 to 39 LED8-5 O LED drive signal output. (Not used) (open)
40, 41 LED4,3 O
LED drive signal output.
42, 43 LED2,1 O
44 VOL IN A I Volume encoder signal input.
45 JOG IN A I Jog dial encoder signal input.
46 RDY MG I Ready signal from master contorl.
47 SIRCS IN I SIRCS signal input.
48 IC (VPP) – Ground
49, 50 LED12, 13 O
LED drive signal output.
51 LED11 O
52 VDD – +5V
53 to 70 SEG22-5 O Fluorescent indicator tube segment signal output.
71 V. LOAD – –25V for Fluorescent indicator tube.
72 to 75 SEG4-1 O Fluorescent indicator tube segment signal output.
76 to 80 GR12-8 O Fluorescent indicator tube grid signal output.
— 67 —
• IC701 MASTER CONTROL (TMP87CP64YF)
1 VSS – Ground
2 XOUT O
X’tal (10 MHz).
3 XIN I
4 RESET I Reset signal input.
5 XOUT O
X’tal for clock (32.768 MHz).
6 XIN I
7 GND (test) – Ground
8 AC CUT I Back up signal input.
9 SUPER WOOFER ON O Not used. (Connected to ground)
10 ST-MUTE ON O Mute signal output for tuner.
11 180-A-PLAY I
12 180-B-PLAY I Tape detection signal input. (Not used) (Connected to ground)
13 180-B-REC I
14 CLK CHK I Not used. (pull up)
15 UP-SW I Disc table up detect. (Not used) (Connected to ground)
16 IN-SW I Loading in detection signal input.
17 ENCODER-0 I
18 ENCODER-1 I Disctray address detect encoder input. (Not used) (Connected to ground)
19 ENCODER-2 I
20 OUT SW OPEN I Loading out detection signal input.
21 LOAD IN O
Loading motor control signal output.
22 LOAD OUT O
23 TBL-L O
Table motor control signal output. (Not used) (Open)
24 TBL-R O
25 SCOR I Sub-code sync signal input.
26 TBL-SENS I CD Table sensor signal input. (Not used) (Connected to ground)
27 RDS INT I RDS data start input. (Not used) (Connected to ground)
28 RDS DATA I RDS data start output. (Not used) (Connected to ground)
29 DF LAT O Latch signal for digital filter.
30 SENS I Table sence signal input.
31 XRST O Reset signal output for CD.
32 MG-RDY O Ready signal to graphic control.
33 ADJ I Test mode input.
34 GM-REQ I Request signal from graphic control.
35 MG-CLK O Clock signal to graphic control.
36 GM-DATA I Data input from graphic control.
37 MG-DATA O Data output to graphic control.
38 CD-CLK O Clock output. Serial bus line.
39 ADJ-2 I Test mode input.
40 CD-DATA O Data output. Serial bus line.
— 68 —
41 AUB IN I
Audio bus in/output. (Not used) (Open)
42 AUB OUT O
43 FOCUS SW O Focus switching signal output.
44 SQ-CLK O Subcode Q data read clock output.
45 SQ-DATA I Subcode Q data input.
46 X-LAT O Latch signal digital signal processor.
47 TEST I Test land.
48 VAREF I Analog reference voltage input.
49 VASS –
Ground
50 VSS –
51 VDD – +5V
52 SPEC I
Destination detection setting input.
53 DESTINATION I
54 DISC SENS I Not used. (Connected to ground)
55 TC RELAY O REC/PB select signal output.
56 A-SHUT I
57 B-SHUT I
58 B-HALF I
Control signal input from deck.
59 A-HALF I
60 220-A-PLAY I
61 220-B-PLAY I
62 62427 LAT O PLL latch output.
63 K-CON-LAT O Not used. (Open)
64 VOL LAT (AV) O Latch signal for electrical volume. (Not used) (Open)
65 REAR SP RELAY B O
Not used. (Open)
66 FRONT SP RELAY C O
67 POWER ON O Power on signal output.
68 CD POWER O CD power control signal output.
69 PROLOG LAT O Not used. (Open)
70 MUTE O Mute signal for AMP.
71 COM CLK O PLL clock output.
72 COM DIN I PLL data input.
73 COM DATA O PLL data output.
74 K CON ON O Not used. (Open)
75 LIDDED LED O Disc No. LED drive signal output. (Not used) (Open)
76 PROLOG ON O PRO LOGIC control output. (Not used) (Open)
77 DBFB-HIGH O DBFB switching signal output.
78 URG STB STDBY I Not used. (Pull-down)
79 URG STB ON O Not used (Open)
80 TC A O Deck A, B select output.
— 69 —
81 NORM O NORMAL/HIGH control signal output.
82 BIAS OFF O Bias oscillation output.
83 REC MUTE O Mute output.
84 NR OFF O Dolby ON/OFF signal output.
85 PB O REC/PB control signal output.
86 PASS. AMP/DOLBY O Dolby switching signal output.
87 LINE MUTE ON O Mute signal output for deck.
88 CAP. M-HIGH O Capstan motor control signal output.
89 A-TRG O
Trigger motor control signal output.
90 B-TRG O
91 TRG LOW O Trigger motor high/low contorol signal output.
92 CAP M ON O Capstan motor ON/OFF control signal output.
93 STEREO I Stereo dection signal from tuner.
94 TUNED I Tuned detection signal from tuner.
95 ST-CE O Latch signal output for tuner.
96 DELAY SEL MIC O
97 DELAY ON O
Not used. (Connected to ground)
98 DELAY LEVEL A O
99 DELAY LEVEL B O
100 VDD – +5V
— 70 —
NOTE:
• Items marked “*” are not stocked since they are • Abbreviation
seldom required for routine service. Some delay G: German model The components identified by
should be anticipated when ordering these items. IT: Italian model mark ! or dotted line with mark !
• The mechanical parts with no reference number in EE: East European model are critical for safety.
the exploded views are not supplied. EA: Saudi Arabia model Replace only with part number
• Hardware (# mark) list and accessories and packing HK: Hong Kong model specified.
materials are given in the last of this parts list. SP: Singapore model
MY: Malaysia model
TW: Taiwan model
JE: Tourist model
TH: Thailand model
IA: Indonesian model
7-1. CASE SECTION
#1
2 1
CDM28-5BD19
#1
11
3 10
not supplied
#1
4
#1
9
8
3 5 7
6
FRONT PANEL
#2
#2
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
1 4-978-836-01 PANEL, LOADING * 5 A-4303-518-A TCB BOARD (E,EA,HK,MY,SP,TW)

2 4-978-748-21 CASE (EXCEPT IA) * 5 A-4303-520-A TCB BOARD (JE)
2 4-983-000-01 CASE (IA) * 5 A-4303-537-A TCB BOARD (TH)
3 3-363-099-01 SCREW (CASE 3 TP2) 6 1-769-946-11 WIRE (FLAT TYPE)(11 CORE)
4 1-751-086-11 WIRE (FLAT TYPE)(13 CORE)(TH) 7 1-769-940-11 WIRE (FLAT TYPE)(11 CORE)
4 1-773-012-11 WIRE (FLAT TYPE)(15 CORE)(EXCEPT TH) 8 1-773-158-11 WIRE (FLAT TYPE)(21 CORE)
* 5 A-4303-506-A TCB BOARD (IA) 9 1-776-166-11 WIRE (FLAT TYPE)(19 CORE)
* 5 A-4303-514-A TCB BOARD (AEP,UK) * 10 4-978-853-01 CHASSIS, CDM
* 5 A-4303-515-A TCB BOARD (G,IT) * 11 4-951-620-01 SCREW (2.6X8), +BVTP
* 5 A-4303-516-A TCB BOARD (EE)
— 71 —
7-2. BACK PANEL SECTION
(EXCEPT UK, E, JE, TH Model)
58 (HK Model)
58 (EA, SP,
CNP1601
TW, IA Model)
(UK Model)
CNP1601
58
(E, JE, TH
Model)
CNP1601
51 (E, JE, TH Model)
F1603
56
59 60
#2 #2
#1 (p) #1
F1602 #3
#1
F1601
57 #1 #1
T1601
#1
53 54
#1
The components identified by
mark ! or dotted line with mark !
55 (including p) are critical for safety.
Replace only with part number
not supplied
52 specified.
53
* 51 1-659-332-11 TRANSFORMER BOARD * 59 4-979-273-11 PANEL, BACK (UK)
52 1-537-770-21 TERMINAL BOARD, GROUND * 59 4-979-273-21 PANEL, BACK (G)
53 4-965-822-01 FOOT * 59 4-979-273-31 PANEL, BACK (IT)
* 54 A-4389-425-A MAIN BOARD, COMPLETE (AEP,UK)
* 54 A-4389-426-A MAIN BOARD, COMPLETE (G,IT) * 59 4-979-273-41 PANEL, BACK (EE)
* 59 4-979-274-01 PANEL, BACK (E)
* 54 A-4389-427-A MAIN BOARD, COMPLETE (EE) * 59 4-979-274-11 PANEL, BACK (EA,TW)
* 54 A-4389-428-A MAIN BOARD, COMPLETE (E,EA,HK,MY,SP,TW) * 59 4-979-274-21 PANEL, BACK (MY)
* 54 A-4389-429-A MAIN BOARD, COMPLETE (JE) * 59 4-979-274-31 PANEL, BACK (SP)
* 54 A-4390-120-A MAIN BOARD, COMPLETE (TH)
* 54 A-4390-506-A MAIN BOARD, COMPLETE (IA) * 59 4-979-274-41 PANEL, BACK (HK)
* 59 4-979-274-51 PANEL, BACK (JE)
* 55 A-4389-444-A POWER AMP BOARD, COMPLETE * 59 4-979-274-61 PANEL, BACK (IA)
(AEP,UK,G,IT,EE) * 59 4-979-274-71 PANEL, BACK (TH)
* 55 A-4389-445-A POWER AMP BOARD, COMPLETE 60 4-956-370-12 BAND, PLUG FIXED (UK, HK)
(E,JE,EA,HK,MY,SP,TW,IA) ! CNP1601 1-575-651-11 CORD, POWER (EXCEPT UK,E,JE,TH)
* 55 A-4390-127-A POWER AMP BOARD, COMPLETE (TH)
* 55 A-4390-513-A POWER AMP BOARD, COMPLETE (IA) ! CNP1601 1-575-653-11 CORD, POWER (E,JE)
* 56 3-703-244-00 BUSHING (2104), CORD (EXCEPT E,JE,TH,IA) ! CNP1601 1-751-326-31 CORD, POWER (TH)
! CNP1601 1-751-520-21 CORD, POWER (UK)
56 3-703-571-11 BUSHING (S)(4516), CORD (E,JE,TH) ! F1601 1-532-504-31 FUSE, TIME LAG (4.0A 250V)
56 4-966-266-01 BUSHING (S)(FBS002), CORD (IA) ! F1602 1-532-504-31 FUSE, TIME LAG (4.0A 250V)
* 57 4-979-520-01 HEAT SINK ! F1603 1-532-503-31 FUSE, TIME LAG (1.6A 250V)
! 58 1-569-007-11 ADAPTER, CONVERSION 2P (E,JE) (E,JE,EA,HK,SP,TW,IA)
! 58 1-569-008-11 ADAPTER, CONVERSION 2P (EA,SP,TW,IA)
! T1601 1-429-438-11 TRANSFORMER, POWER (AEP,UK,G,IT,EE)
! 58 1-770-019-11 ADAPTOR, CONVERSION PLUG 3P (HK) ! T1601 1-429-465-11 TRANSFORMER, POWER
* 59 4-979-273-01 PANEL, BACK (AEP) (E,JE,EA,HK,MY,SP,TW,IA,TH)
— 72 —
7-3. FRONT PANEL SECTION 1
113
116
not supplied 114
Supplied with
J501, J601
113
115
119
108 FL501 113

119
112
Supplied with
101 S562 111
113
107 109
117
110
108
Supplied with S561 111
106
102
#11 TCM-220WR2E
104 118 #11
117
103
111 3-354-957-01 JOINT (LOCK LEVER)

101 X-4946-727-1 HOLDER (A) ASSY, CASSETTE (EXCEPT IA) * 112 1-659-333-11 JOG BOARD
101 X-4947-193-1 HOLDER (A) ASSY, CASSETTE (IA)
102 4-959-231-11 SPRING (L), TORSION 113 4-951-620-01 SCREW (2.6X8), +BVTP
103 4-959-232-11 SPRING (R), TORSION * 114 1-659-331-11 HP BOARD
104 X-4946-728-1 HOLDER (B) ASSY, CASSETTE (EXCEPT IA) * 115 4-978-168-01 HOLDER, FL TUBE
* 116 A-4389-446-A PANEL BOARD, COMPLETE (AEP,UK,G,IT,EE)
104 X-4947-194-1 HOLDER (B) ASSY, CASSETTE (IA) * 116 A-4389-447-A PANEL BOARD, COMPLETE
106 4-978-733-01 KNOB, VOL (EXCEPT IA) (E,JE,EA,HK,MY,SP,TW)
106 4-978-733-11 KNOB, VOL (IA) * 116 A-4390-128-A PANEL BOARD, COMPLETE (TH)
107 4-978-732-01 KNOB, JOG (EXCEPT IA) * 116 A-4390-514-A PANEL BOARD, COMPLETE (IA)
107 4-978-732-11 KNOB, JOG (IA) 117 3-354-963-01 DAMPER
* 118 4-980-439-01 FULCRUM, HOLDER
108 4-980-219-01 BUTTON (EJECT)(E5) * 119 4-932-810-11 CUSHION (FL)
* 109 3-354-953-01 LEVER (LOCK LEVER L)
* 110 3-354-954-01 LEVER (LOCK LEVER R) FL501 1-517-489-11 INDICATOR TUBE, FLUORESCENT
— 73 —
7-4. FRONT PANEL SECTION 2
151
160
159
152
158
161
163
154
164
157
not supplied
162
153
155 156
157 X-4946-707-1 BUTTON (TC-PLAY) ASSY

151 X-4946-712-1 PANEL ASSY, FRONT (AEP,UK,G,IT,EE) 158 4-978-744-31 PLATE, ORNAMENTAL, MULTI
151 X-4946-714-1 PANEL ASSY, FRONT (E,JE,EA,HK,MY,SP,TW,TH)
151 X-4947-189-1 PANEL ASSY, FRONT (IA) 159 4-978-742-01 HOLDER, MULTI LED
152 X-4946-706-1 BUTTON (T/B) ASSY 160 4-978-839-01 BUTTON, MULTI
153 4-978-716-01 WINDOW, FL 161 4-978-837-01 BUTTON, POWER
162 4-978-851-01 INDICATOR, REC
154 4-962-708-11 EMBLEM (4-A), SONY 163 X-4946-713-1 BUTTON (CD-PLAY) ASSY
155 4-978-745-11 PLATE, ORNAMENTAL, JOG
156 4-930-336-61 FOOT (FELT) 164 X-4946-801-1 BUTTON (ENTER/NEXT)(E5) ASSY
— 74 —
7-5. CD MECHANISM SECTION
(CDM28-5BD19)
206
205
204
203
(including rB)
207 208
#1
202 209
not supplied
210
M903
rB
BU-5BD19
213 #1
211
201
212
* 207 4-960-839-01 CAM

201 4-960-836-01 TABLE, DISC 208 4-960-838-03 BASE (MD)
202 4-960-835-01 HOLDER (M) 209 4-917-583-21 BRACKET, YOKE
203 1-452-719-11 MAGNET ASSY 210 4-933-134-01 SCREW (+PTPWH M2.6X6)
204 4-960-842-01 GEAR (P)
205 4-960-841-01 PULLEY (S) 211 4-959-996-01 SPRING (932), COMPRESSION
212 4-960-834-01 HOLDER (BU)
206 4-927-649-01 BELT * 213 1-650-836-11 LOADING BOARD
M903 A-4604-363-A MOTOR (L) ASSY (LOADING)
— 75 —
7-6. BASE UNIT SECTION
301
(BU-5BD19)
302
rA 303
#5
305
M101 304
(including M102
rA)
304
S101
306

307 mark ! or dotted line with mark !
are critical for safety.
specified.
308
! 301 8-848-367-11 OPTICAL PICK-UP KSS-213BA/F-NP 306 4-917-564-01 GEAR (P), FLATNESS
302 1-769-069-11 WIRE (FLAT TYPE)(16 CORE) * 307 A-4673-402-A BD BOARD, COMPLETE
303 4-917-567-01 GEAR (M) 308 4-951-620-01 SCREW (2.6X8), +BVTP
304 4-951-940-01 INSULATOR (BU) M101 X-4917-523-4 MOTOR ASSY (SPINDLE)
305 4-917-565-01 SHAFT, SLED M102 X-4917-504-1 MOTOR ASSY (SLED)
S101 1-572-085-11 SWITCH, LEAF (LIMIT)
— 76 —
7-7. TC MECHANISM SECTION 1
(TCM-220WR2E)
#6
369
371 (including pA)
#6
372
365
364
not supplied 373

366
362
HP101 357
363 369
356 358 361 365
364
373
359 367
355
369
not supplied 366
360
not supplied
362
354 368 357
HRPE101 363
not supplied 353
361
356
not supplied 359
355
352 358
#10 360
351 354
not supplied
not supplied 353
352
#10
351
362 X-3370-643-1 PINCH LEVER (REV) ASSY

351 3-908-560-01 SPRING, AZIMUTH ADJUSTMENT 363 X-3367-588-1 PINCH LEVER (FWD) ASSY
352 3-919-684-01 SCREW, AZIMUTH ADJUSTMENT 364 3-908-613-01 GEAR (S), REEL
* 353 X-3367-584-2 SLIDER (HEAD) ASSY 365 3-917-141-01 SPRING, COMPRESSION
354 3-908-556-01 SPRING, HEAD TOGGLE
355 3-908-558-02 FITTING BLOCK, HEAD 366 X-3371-305-1 REEL (T) ASSY
367 3-669-465-01 WASHER (1.5), STOPPER
356 3-908-557-02 ROTARY BLOCK, HEAD 368 X-3370-173-1 TU ASSY
* 357 3-908-559-01 STOPPER, AZIMUTH 369 3-911-116-21 RIVET, PUSH
358 3-908-555-01 SLIDER (REV SLIDER) * 371 A-2007-435-A MD BOARD, COMPLETE
359 3-917-143-11 SPRING, TENSION
360 3-388-848-01 SCREW (P2X6)(B TIGHT) 372 3-930-972-01 DETENT, HALF
373 3-917-142-01 SPRING, COMPRESSION
361 3-911-113-01 SPRING, TENSION HP101 1-500-093-11 HEAD, MAGNETIC (PLAYBACK)
HRPE101 1-500-094-11 HEAD, MAGNETIC (REC/PB/ERASE)
— 77 —
7-8. TC MECHANISM SECTION 2
(TCM-220WR2E)
pA: MOTOR board (Supplied with MD board)
M2
425
pA
418 419
421
#9
#8
420 410
417 421
402 411 #8
416 410
409
#10 424
413
422 415
407
419
408 406
405
412
414 423
407
#4
413 404
403
#7
401
#7 402
not supplied
M1
414 X-3370-171-1 FLYWHEEL (BR) ASSY

401 3-908-597-01 CAM (A) 415 3-908-600-01 LEVER (REV-B)
402 3-908-608-11 SCREW, STEP
403 X-3367-590-2 ARM (A) ASSY, FR * 416 1-650-669-11 LEAF SWITCH BOARD
404 X-3370-169-1 FLYWHEEL (AR) ASSY 417 3-908-598-01 CAM (B)
405 3-928-047-01 PULLEY, TENSION 418 X-3369-849-2 ARM (B) ASSY, FR
419 3-914-111-01 SPRING (FR), TORSION
406 3-908-599-01 LEVER (REV-A) 420 3-908-604-01 LEVER (TRIGGER B)
407 3-908-601-01 SPRING (REV LEVER), TORSION
408 3-908-603-01 LEVER (TRIGGER A) 421 3-911-115-01 WASHER, STOPPER
409 X-3370-170-1 FLYWHEEL (BF) ASSY 422 3-917-176-11 BELT (B)
410 3-908-605-01 SPRING (TRIGGER), TORSION 423 X-3370-172-1 FLYWHEEL (AF) ASSY
424 X-3371-441-1 CHASSIS ASSY, MECHANICAL
411 3-908-609-01 GEAR, TRIGGER * 425 A-2007-435-A MD BOARD, COMPLETE
412 3-913-845-11 BELT (A)
413 3-913-846-11 BELT (FR) M1 X-3371-223-1 MOTOR ASSY (CAPSTAN)
M2 A-2004-410-A MOTOR ASSY (TRIGGER)
— 78 —
SECTION 8 BD
ELECTRICAL PARTS LIST
Note:
• Due to standardization, replacements in the parts • CAPACITORS
list may be different from the parts specified in the uF : µ F
diagrams or the components used on the set. • COILS
• Items marked “*” are not stocked since they are uH : µ H
seldom required for routine service. Some delay • Abbreviation
specified.
should be anticipated when ordering these items. G: German model
• RESISTORS IT: Italian model
When indicating parts by reference All resistors are in ohms EE: East European model
number, please include the board METAL: Metal-film resistor EA: Saudi Arabia model
name. METAL OXIDE: Metal Oxide-film resistor HK: Hong Kong model
F : nonflammable SP: Singapore model
• SEMICONDUCTORS MY: Malaysia model
In each case, u: µ , for example: TW: Taiwan model
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB..., JE: Tourist model
uPC...: µ PC..., uPD...: µ PD... TH: Thailand model
IA: Indonesian model
* A-4673-402-A BD BOARD, COMPLETE C137 1-164-232-11 CERAMIC CHIP 0.01uF 50V
****************** C139 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
C140 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
< CAPACITOR > C141 1-163-038-91 CERAMIC CHIP 0.1uF 25V
C142 1-163-038-91 CERAMIC CHIP 0.1uF 25V
C101 1-126-607-11 ELECT CHIP 47uF 20% 4V
C102 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V C145 1-135-201-11 TANTALUM CHIP 10uF 20% 4V
C103 1-164-346-11 CERAMIC CHIP 1uF 16V C146 1-135-201-11 TANTALUM CHIP 10uF 20% 4V
C105 1-163-038-91 CERAMIC CHIP 0.1uF 25V C147 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V
C106 1-164-695-11 CERAMIC CHIP 0.0022uF 5% 50V C148 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V
C149 1-164-346-11 CERAMIC CHIP 1uF 16V
C107 1-164-695-11 CERAMIC CHIP 0.0022uF 5% 50V
C108 1-164-232-11 CERAMIC CHIP 0.01uF 50V C153 1-135-259-11 TANTAL. CHIP 10uF 20% 6.3V
C109 1-164-232-11 CERAMIC CHIP 0.01uF 50V C154 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
C111 1-163-038-91 CERAMIC CHIP 0.1uF 25V < CONNECTOR >
C112 1-163-038-91 CERAMIC CHIP 0.1uF 25V CNU101 1-770-014-11 CONNECTOR, FFC/FPC 16P
C113 1-164-695-11 CERAMIC CHIP 0.0022uF 5% 50V CNU102 1-770-013-11 CONNECTOR, FFC/FPC 19P
C115 1-126-607-11 ELECT CHIP 47uF 20% 4V < IC >
IC101 8-752-069-56 IC CXA1782BQ
C117 1-164-005-11 CERAMIC CHIP 0.47uF 25V IC102 8-759-291-06 IC BA6397FP
C118 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V IC103 8-752-372-94 IC CXD2507AQ
C119 1-163-038-91 CERAMIC CHIP 0.1uF 25V IC104 8-759-185-29 IC PCM1710U-B
C120 1-135-201-11 TANTALUM CHIP 10uF 20% 4V
C121 1-163-038-91 CERAMIC CHIP 0.1uF 25V < TRANSISTOR >
C122 1-164-232-11 CERAMIC CHIP 0.01uF 50V Q101 8-729-010-08 TRANSISTOR MSB710-R
C123 1-163-038-91 CERAMIC CHIP 0.1uF 25V Q102 8-729-424-08 TRANSISTOR UN2111
C124 1-126-607-11 ELECT CHIP 47uF 20% 4V Q103 8-729-421-22 TRANSISTOR UN2211
C126 1-163-038-91 CERAMIC CHIP 0.1uF 25V < RESISTOR >
C127 1-164-695-11 CERAMIC CHIP 0.0022uF 5% 50V R102 1-216-001-00 METAL CHIP 10 5% 1/10W
C128 1-163-135-00 CERAMIC CHIP 560PF 5% 50V R103 1-216-049-91 METAL GLAZE 1K 5% 1/10W
C129 1-163-038-91 CERAMIC CHIP 0.1uF 25V R104 1-216-097-91 METAL GLAZE 100K 5% 1/10W
C130 1-164-336-11 CERAMIC CHIP 0.33uF 25V R105 1-216-093-00 METAL CHIP 68K 5% 1/10W
C132 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25V R107 1-216-093-00 METAL CHIP 68K 5% 1/10W
C133 1-163-145-00 CERAMIC CHIP 0.0015uF 5% 50V R108 1-216-093-00 METAL CHIP 68K 5% 1/10W
C134 1-164-346-11 CERAMIC CHIP 1uF 16V R109 1-216-097-91 METAL GLAZE 100K 5% 1/10W
C135 1-163-251-11 CERAMIC CHIP 100PF 5% 50V R112 1-216-083-00 METAL CHIP 27K 5% 1/10W
— 79 —
BD HP
R114 1-216-101-00 METAL CHIP 150K 5% 1/10W < SWITCH >

R115 1-216-101-00 METAL CHIP 150K 5% 1/10W
R116 1-216-061-00 METAL CHIP 3.3K 5% 1/10W S101 1-572-085-11 SWITCH, LEAF (LIMIT)
R117 1-216-069-00 METAL CHIP 6.8K 5% 1/10W
R118 1-216-049-91 METAL GLAZE 1K 5% 1/10W < VIBRATOR >
R119 1-216-089-91 METAL GLAZE 47K 5% 1/10W X101 1-579-280-11 VIBRATOR, CRYSTAL (16.9344MHz)
R120 1-216-089-91 METAL GLAZE 47K 5% 1/10W
R121 1-216-114-00 METAL GLAZE 510K 5% 1/10W **************************************************************
R122 1-216-097-91 METAL GLAZE 100K 5% 1/10W
R123 1-216-099-00 METAL CHIP 120K 5% 1/10W * 1-659-331-11 HP BOARD
********
R124 1-216-091-00 METAL CHIP 56K 5% 1/10W
R125 1-216-069-00 METAL CHIP 6.8K 5% 1/10W < CAPACITOR >
R126 1-216-063-91 METAL GLAZE 3.9K 5% 1/10W
R127 1-216-089-91 METAL GLAZE 47K 5% 1/10W C520 1-162-306-11 CERAMIC 0.01uF 30% 16V
R128 1-216-105-91 METAL GLAZE 220K 5% 1/10W C521 1-162-306-11 CERAMIC 0.01uF 30% 16V
C640 1-162-306-11 CERAMIC 0.01uF 30% 16V
R129 1-216-049-91 METAL GLAZE 1K 5% 1/10W C641 1-124-257-00 ELECT 2.2uF 20% 50V
R130 1-216-079-00 METAL CHIP 18K 5% 1/10W C642 1-162-294-31 CERAMIC 0.001uF 10% 50V
R131 1-216-079-00 METAL CHIP 18K 5% 1/10W
R132 1-216-061-00 METAL CHIP 3.3K 5% 1/10W C643 1-162-282-31 CERAMIC 100PF 10% 50V
C645 1-124-465-00 ELECT 0.47uF 20% 50V
R136 1-216-073-00 METAL CHIP 10K 5% 1/10W
R137 1-216-065-00 METAL CHIP 4.7K 5% 1/10W C648 1-124-257-00 ELECT 2.2uF 20% 50V
R138 1-216-049-91 METAL GLAZE 1K 5% 1/10W C649 1-124-589-11 ELECT 47uF 20% 16V
C650 1-124-589-11 ELECT 47uF 20% 16V
R139 1-216-033-00 METAL CHIP 220 5% 1/10W C651 1-162-306-11 CERAMIC 0.01uF 30% 16V
R140 1-216-081-00 METAL CHIP 22K 5% 1/10W C652 1-162-306-11 CERAMIC 0.01uF 30% 16V
R141 1-216-061-00 METAL CHIP 3.3K 5% 1/10W
R142 1-216-061-00 METAL CHIP 3.3K 5% 1/10W < CONNECTOR >
R143 1-216-121-91 METAL GLAZE 1M 5% 1/10W
* CN513 1-568-935-11 PIN, CONNECTOR 8P
R144 1-216-073-00 METAL CHIP 10K 5% 1/10W
R145 1-216-097-91 METAL GLAZE 100K 5% 1/10W < IC >
R146 1-216-097-91 METAL GLAZE 100K 5% 1/10W
R147 1-216-049-91 METAL GLAZE 1K 5% 1/10W IC601 8-759-634-51 IC M5218AP
R148 1-216-049-91 METAL GLAZE 1K 5% 1/10W
< JACK >
R149 1-216-049-91 METAL GLAZE 1K 5% 1/10W
R150 1-216-037-00 METAL CHIP 330 5% 1/10W J501 1-770-226-11 JACK (LARGE TYPE)(PHONES)
R151 1-216-037-00 METAL CHIP 330 5% 1/10W J601 1-770-226-11 JACK (LARGE TYPE)(MIX MIC)
R152 1-216-037-00 METAL CHIP 330 5% 1/10W
R153 1-216-082-00 METAL GLAZE 24K 5% 1/10W < RESISTOR >
R154 1-216-065-00 METAL CHIP 4.7K 5% 1/10W R640 1-249-429-11 CARBON 10K 5% 1/4W
R156 1-216-085-00 METAL CHIP 33K 5% 1/10W R641 1-249-441-11 CARBON 100K 5% 1/4W
R157 1-216-069-00 METAL CHIP 6.8K 5% 1/10W R642 1-249-417-11 CARBON 1K 5% 1/4W F
R158 1-216-001-00 METAL CHIP 10 5% 1/10W R643 1-249-417-11 CARBON 1K 5% 1/4W F
R644 1-249-435-11 CARBON 33K 5% 1/4W
< VARIABLE RESISTOR >
R645 1-249-429-11 CARBON 10K 5% 1/4W
RV101 1-241-396-11 RES, ADJ, METAL GLAZE 22K R646 1-247-881-00 CARBON 120K 5% 1/4W
RV102 1-241-396-11 RES, ADJ, METAL GLAZE 22K R647 1-247-807-31 CARBON 100 5% 1/4W
RV103 1-241-396-11 RES, ADJ, METAL GLAZE 22K
**************************************************************
— 80 —
JOG LEAF SWITCH LOADING MAIN
* 1-659-333-11 JOG BOARD S1002 1-692-832-11 SWITCH, PUSH (1 KEY)(B PLAY)
********* S1003 1-572-248-11 SWITCH, LEAF (A HALF)
S1004 1-571-281-21 SWITCH, LEAF (A CrO2)
< CAPACITOR > S1005 1-571-281-21 SWITCH, LEAF (REC A)
S1006 1-572-248-11 SWITCH, LEAF (B HALF)
C524 1-162-306-11 CERAMIC 0.01uF 30% 16V
C525 1-162-306-11 CERAMIC 0.01uF 30% 16V S1008 1-571-281-21 SWITCH, LEAF (B CrO2)
C526 1-162-306-11 CERAMIC 0.01uF 30% 16V S1009 1-571-281-21 SWITCH, LEAF (REC B)
C527 1-162-306-11 CERAMIC 0.01uF 30% 16V
**************************************************************
< DIODE >
* 1-650-836-11 LOADING BOARD
D582 8-719-812-44 DIODE TLO124 (ENTER/NEXT) *************
< RESISTOR > < CONNECTOR >
R511 1-249-409-11 CARBON 220 5% 1/4W F * CN291 1-568-943-11 PIN, CONNECTOR 5P

R512 1-249-411-11 CARBON 330 5% 1/4W
R513 1-249-413-11 CARBON 470 5% 1/4W F < SWITCH >
R514 1-249-415-11 CARBON 680 5% 1/4W F
R560 1-249-417-11 CARBON 1K 5% 1/4W F S291 1-572-086-11 SWITCH, LEAF (LOAD OUT)
S292 1-572-086-11 SWITCH, LEAF (LOAD IN)
R582 1-249-407-11 CARBON 150 5% 1/4W F
**************************************************************
< SWITCH >
* A-4389-425-A MAIN BOARD, COMPLETE (AEP,UK)
S511 1-554-303-21 SWITCH, TACTILE (FREQUENCY -) *****************************
S512 1-554-303-21 SWITCH, TACTILE (FREQUENCY +)
S513 1-554-303-21 SWITCH, TACTILE (ENTER/NEXT) * A-4389-426-A MAIN BOARD, COMPLETE (G,IT)
S514 1-554-303-21 SWITCH, TACTILE (DBFB) *************************
S560 1-554-303-21 SWITCH, TACTILE (KARAOKE PON/MPX)
* A-4389-427-A MAIN BOARD, COMPLETE (EE)
S561 1-467-869-11 ENCODER, ROTARY (VOLUME) *************************
S562 1-467-968-11 ENCODER, ROTARY (MULTI FUNCTION CONTROL)
* A-4389-428-A MAIN BOARD, COMPLETE (E,EA,HK,MY,SP,TW)
************************************************************** ***************************************
* 1-650-669-11 LEAF SWITCH BOARD * A-4389-429-A MAIN BOARD, COMPLETE (JE)

***************** *************************
< CONNECTOR > * A-4390-120-A MAIN BOARD, COMPLETE (TH)

*************************
* CN1001 1-568-854-11 SOCKET, CONNECTOR 11P
* A-4390-506-A MAIN BOARD, COMPLETE (IA)
< TRANSISTOR > ************************
Q1001 8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H 1-537-770-21 TERMINAL BOARD, GROUND
Q1002 8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< RESISTOR > < CAPACITOR >
R1001 1-249-412-11 CARBON 390 5% 1/4W F C201 1-126-961-11 ELECT 2.2uF 20% 50V
R1002 1-249-412-11 CARBON 390 5% 1/4W F C202 1-162-600-11 CERAMIC 0.0047uF 30% 16V
R1003 1-249-414-11 CARBON 560 5% 1/4W F C203 1-124-472-11 ELECT 470uF 20% 10V
R1004 1-247-834-11 CARBON 1.3K 5% 1/4W C204 1-162-282-31 CERAMIC 100PF 10% 50V
R1005 1-247-818-11 CARBON 300 5% 1/4W C205 1-162-282-31 CERAMIC 100PF 10% 50V
< SWITCH > C206 1-162-306-11 CERAMIC 0.01uF 30% 16V

C207 1-162-306-11 CERAMIC 0.01uF 30% 16V
S1001 1-692-832-11 SWITCH, PUSH (1 KEY)(A PLAY) C208 1-162-306-11 CERAMIC 0.01uF 30% 16V
— 81 —
MAIN
C209 1-126-952-11 ELECT 1000uF 20% 16V C908 1-130-479-00 MYLAR 0.0047uF 5% 50V
C251 1-126-961-11 ELECT 2.2uF 20% 50V C909 1-130-474-00 MYLAR 0.0018uF 5% 50V
C910 1-126-964-11 ELECT 10uF 20% 50V
C252 1-162-600-11 CERAMIC 0.0047uF 30% 16V C911 1-126-964-11 ELECT 10uF 20% 50V
C301 1-130-479-00 MYLAR 0.0047uF 5% 50V C912 1-136-165-00 FILM 0.1uF 5% 50V
C302 1-162-290-31 CERAMIC 470PF 10% 50V
C303 1-164-159-11 CERAMIC 0.1uF 50V C913 1-136-165-00 FILM 0.1uF 5% 50V
C305 1-124-903-11 ELECT 1uF 20% 50V C914 1-126-964-11 ELECT 10uF 20% 50V
C915 1-162-600-11 CERAMIC 0.0047uF 30% 16V
C306 1-124-902-00 ELECT 0.47uF 20% 50V C930 1-164-159-11 CERAMIC 0.1uF 50V
C307 1-126-964-11 ELECT 10uF 20% 50V C931 1-136-153-00 FILM 0.01uF 5% 50V
C308 1-126-964-11 ELECT 10uF 20% 50V
C309 1-124-903-11 ELECT 1uF 20% 50V C933 1-124-902-00 ELECT 0.47uF 20% 50V
C310 1-126-933-11 ELECT 100uF 20% 10V C935 1-164-159-11 CERAMIC 0.1uF 50V
C936 1-126-964-11 ELECT 10uF 20% 50V
C351 1-130-479-00 MYLAR 0.0047uF 5% 50V C938 1-162-290-31 CERAMIC 470PF 10% 50V
C352 1-162-290-31 CERAMIC 470PF 10% 50V C939 1-126-967-11 ELECT 47uF 20% 10V
C353 1-164-159-11 CERAMIC 0.1uF 50V
C356 1-124-902-00 ELECT 0.47uF 20% 50V C951 1-136-169-00 FILM 0.22uF 5% 50V
C952 1-136-169-00 FILM 0.22uF 5% 50V
C359 1-124-903-11 ELECT 1uF 20% 50V
C401 1-164-159-11 CERAMIC 0.1uF 50V C956 1-136-156-00 FILM 0.018uF 5% 50V
C957 1-130-480-00 MYLAR 0.0056uF 5% 50V
C402 1-164-159-11 CERAMIC 0.1uF 50V C958 1-130-479-00 MYLAR 0.0047uF 5% 50V
C403 1-164-159-11 CERAMIC 0.1uF 50V C959 1-130-474-00 MYLAR 0.0018uF 5% 50V
C404 1-126-933-11 ELECT 100uF 20% 16V
C962 1-136-165-00 FILM 0.1uF 5% 50V
C704 1-164-159-11 CERAMIC 0.1uF 50V
C705 1-136-165-00 FILM 0.1uF 5% 50V C965 1-162-600-11 CERAMIC 0.0047uF 30% 16V
C1002 1-126-768-11 ELECT 2200uF 20% 16V
C710 1-162-306-11 CERAMIC 0.01uF 30% 16V
C1006 1-126-933-11 ELECT 100uF 20% 10V
C720 1-164-159-11 CERAMIC 0.1uF 50V C1008 1-126-933-11 ELECT 100uF 20% 16V
C789 1-126-923-11 ELECT 220uF 20% 10V C1009 1-162-306-11 CERAMIC 0.01uF 30% 16V
C810 1-136-153-00 FILM 0.01uF 5% 50V C1010 1-136-165-00 FILM 0.1uF 5% 50V
C811 1-136-153-00 FILM 0.01uF 5% 50V
C1011 1-136-165-00 FILM 0.1uF 5% 50V
C825 1-109-889-11 ELECT 1uF 20% 50V C1013 1-126-916-11 ELECT 1000uF 20% 6.3V
C901 1-136-169-00 FILM 0.22uF 5% 50V C1015 1-126-964-11 ELECT 10uF 20% 50V
C902 1-136-169-00 FILM 0.22uF 5% 50V
C1016 1-126-952-11 ELECT 1000uF 20% 16V
C907 1-130-480-00 MYLAR 0.0056uF 5% 50V
C1021 1-126-964-11 ELECT 10uF 20% 50V
— 82 —
MAIN
C1022 1-126-968-11 ELECT 100uF 20% 50V D1001 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
C1023 1-126-968-11 ELECT 100uF 20% 50V
C1025 1-126-925-11 ELECT 470uF 20% 10V D1002 8-719-200-82 DIODE 11ES2 (IA)
D1003 8-719-200-82 DIODE 11ES2 (IA)
C1223 1-126-923-11 ELECT 220uF 20% 10V
C1224 1-124-925-11 ELECT 2.2uF 20% 100V D1004 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
D1005 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
C1248 1-136-495-11 FILM 0.068uF 5% 50V D1006 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
(AEP,UK,G,IT,EE)
C1249 1-136-495-11 FILM 0.068uF 5% 50V D1007 8-719-987-63 DIODE 1N4148M
(AEP,UK,G,IT,EE) D1008 8-719-001-43 DIODE UZL-11M1-TA (IA,TH)
C1250 1-162-306-11 CERAMIC 0.01uF 20% 50V D1008 8-719-001-42 DIODE UZL-11M1 (EXCEPT IA,TH)
(AEP,UK,G,IT,EE) D1009 8-719-987-63 DIODE 1N4148M
C1270 1-130-781-00 FILM 0.22uF 10% 100V D1010 8-719-987-63 DIODE 1N4148M
C1271 1-130-781-00 FILM 0.22uF 10% 100V D1011 8-719-010-43 DIODE UZ-5.6BSC
C1272 1-164-159-11 CERAMIC 0.1uF 50V D1013 8-719-200-82 DIODE 11ES2 (IA)
(AEP,UK,G,IT,EE) D1013 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
C1298 1-136-495-11 FILM 0.068uF 5% 50V D1014 8-719-200-82 DIODE 11ES2 (IA)
(AEP,UK,G,IT,EE) D1014 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
C1299 1-136-495-11 FILM 0.068uF 5% 50V
(AEP,UK,G,IT,EE) D1016 8-719-200-82 DIODE 11ES2 (IA)
C1300 1-162-306-11 CERAMIC 0.01uF 20% 50V D1016 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
(AEP,UK,G,IT,EE) D1017 8-719-200-82 DIODE 11ES2 (IA)
D1017 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
< CONNECTOR > D1018 8-719-200-82 DIODE 11ES2 (IA)
CN201 1-770-067-11 CONNECTOR, FFC/FPC 19P D1018 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
CN401 1-568-838-11 SOCKET, CONNECTOR 21P D1021 8-719-200-82 DIODE 11ES2 (IA)
* CN402 1-568-830-11 SOCKET, CONNECTOR 11P D1021 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
* CN403 1-568-449-11 HOUSING, CONNECTOR(PC BOARD)3P D1022 8-719-200-82 DIODE 11ES2 (IA)
* CN404 1-568-449-11 HOUSING, CONNECTOR(PC BOARD)3P D1022 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
* CN702 1-568-830-11 SOCKET, CONNECTOR 11P D1023 8-719-011-05 DIODE UZ-27BS

* CN703 1-568-832-11 SOCKET, CONNECTOR 13P (TH) D1059 8-719-987-63 DIODE 1N4148M
* CN703 1-568-834-11 SOCKET, CONNECTOR 15P (EXCEPT TH) D1069 8-719-987-63 DIODE 1N4148M
D1095 8-719-987-63 DIODE 1N4148M
< DIODE > D1096 8-719-987-63 DIODE 1N4148M
D201 8-719-987-63 DIODE 1N4148M D1097 8-719-200-82 DIODE 11ES2 (IA)

D202 8-719-987-63 DIODE 1N4148M D1097 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
D205 8-719-010-33 DIODE UZ-4.7BSB D1098 8-719-200-82 DIODE 11ES2 (IA)
D401 8-719-933-54 DIODE HZS9A2L D1098 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
D701 8-719-987-63 DIODE 1N4148M D1099 8-719-200-82 DIODE 11ES2 (IA)
D702 8-719-987-63 DIODE 1N4148M D1099 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA)
D703 8-719-987-63 DIODE 1N4148M D1204 8-719-987-63 DIODE 1N4148M
D706 8-719-200-82 DIODE 11ES2 (IA) D1250 8-719-028-23 DIODE D3SBA20-4101
D706 8-719-024-99 DIODE 11ES2-NTA2B (EXCEPT IA) D1309 8-719-987-63 DIODE 1N4148M
D708 8-719-987-63 DIODE 1N4148M
D1001 8-719-200-82 DIODE 11ES2 (IA)
— 83 —
MAIN
< FUSE > Q902 8-729-119-78 TRANSISTOR 2SC403SP-51

Q951 8-729-119-78 TRANSISTOR 2SC403SP-51
! F1601 1-532-504-31 FUSE,TIME-LAG (4.0A 250V) Q952 8-729-119-78 TRANSISTOR 2SC403SP-51
! F1602 1-532-504-31 FUSE,TIME-LAG (4.0A 250V) Q953 8-729-141-26 TRANSISTOR 2SC3622A-LK
Q954 8-729-141-26 TRANSISTOR 2SC3622A-LK
< FUSE HOLDER >
Q1001 8-729-118-01 TRANSISTOR 2SB1116
FH1001 1-533-217-31 HOLDER, FUSE Q1002 8-729-900-36 TRANSISTOR DTC124ES
FH1002 1-533-217-31 HOLDER, FUSE Q1003 8-729-030-18 TRANSISTOR 2SD2525
FH1003 1-533-217-31 HOLDER, FUSE Q1006 8-729-030-19 TRANSISTOR 2SB1640
FH1004 1-533-217-31 HOLDER, FUSE Q1204 8-729-900-63 TRANSISTOR DTA124ES
< IC > Q1205 8-729-900-36 TRANSISTOR DTC124ES

Q1206 8-729-900-80 TRANSISTOR DTC114ES
IC201 8-759-822-09 IC LB1641 Q1207 8-729-119-76 TRANSISTOR 2SA1175-HFE
IC401 8-759-289-38 IC HA12195NT Q1208 8-729-119-76 TRANSISTOR 2SA1175-HFE
IC402 8-759-822-09 IC LB1641
IC701 8-759-392-42 IC TMP87CS64YF-6397 < RESISTOR >
IC702 8-759-165-80 IC PST600C-T
R201 1-249-415-11 CARBON 680 5% 1/4W F
IC802 8-759-000-48 IC MC14052BCP R202 1-249-435-11 CARBON 33K 5% 1/4W
IC901 8-759-331-39 IC M62427FP R203 1-249-425-11 CARBON 4.7K 5% 1/4W F
IC1001 8-759-231-53 IC TA7805S R206 1-249-425-11 CARBON 4.7K 5% 1/4W F
IC1002 8-759-604-86 IC M5F7807 R207 1-249-425-11 CARBON 4.7K 5% 1/4W F
IC1003 8-759-604-86 IC M5F7807
R208 1-249-425-11 CARBON 4.7K 5% 1/4W F
IC1004 8-759-604-90 IC M5F7907L R209 1-249-413-11 CARBON 470 5% 1/4W F
IC1202 8-759-111-68 IC UPC1237HA R210 1-249-413-11 CARBON 470 5% 1/4W F
R251 1-249-415-11 CARBON 680 5% 1/4W F
< JACK > R252 1-249-435-11 CARBON 33K 5% 1/4W
J801 1-774-725-11 JACK, PIN 2P (VIDEO (AUDIO)) R301 1-249-430-11 CARBON 12K 5% 1/4W
J1201 1-774-785-11 JACK, PIN 1P (SUPER WOOFER) R302 1-249-431-11 CARBON 15K 5% 1/4W
(E,EA,HK,MY,SP,TW,IA,TH) R303 1-249-432-11 CARBON 18K 5% 1/4W
R304 1-249-428-11 CARBON 8.2K 5% 1/4W F
< COIL > R305 1-249-425-11 CARBON 4.7K 5% 1/4W F
L1201 1-420-872-00 COIL, AIR-CORE (AEP,UK,G,IT,EE) R306 1-247-840-00 CARBON 2.4K 5% 1/4W
L1251 1-420-872-00 COIL, AIR-CORE (AEP,UK,G,IT,EE) R307 1-249-433-11 CARBON 22K 5% 1/4W
R308 1-249-421-11 CARBON 2.2K 5% 1/4W F
< TRANSISTOR > R309 1-249-428-11 CARBON 8.2K 5% 1/4W F
R310 1-249-417-11 CARBON 1K 5% 1/4W F
Q351 8-729-119-78 TRANSISTOR 2SC403SP-51 R351 1-249-430-11 CARBON 12K 5% 1/4W
Q402 8-729-900-65 TRANSISTOR DTA144ES R354 1-249-428-11 CARBON 8.2K 5% 1/4W F
Q403 8-729-801-93 TRANSISTOR 2SD1387 R355 1-249-425-11 CARBON 4.7K 5% 1/4W F
R356 1-247-840-00 CARBON 2.4K 5% 1/4W
Q406 8-729-900-80 TRANSISTOR DTC114ES
Q407 8-729-422-57 TRANSISTOR UN4111 R357 1-249-433-11 CARBON 22K 5% 1/4W
Q408 8-729-119-76 TRANSISTOR 2SA1175-HFE R358 1-249-421-11 CARBON 2.2K 5% 1/4W F
Q409 8-729-900-80 TRANSISTOR DTC114ES R359 1-249-428-11 CARBON 8.2K 5% 1/4W F
Q410 8-729-900-65 TRANSISTOR DTA144ES R360 1-249-417-11 CARBON 1K 5% 1/4W F
R401 1-249-425-11 CARBON 4.7K 5% 1/4W F
Q411 8-729-900-65 TRANSISTOR DTA144ES
Q412 8-729-900-65 TRANSISTOR DTA144ES R402 1-249-425-11 CARBON 4.7K 5% 1/4W F
Q701 8-729-119-78 TRANSISTOR 2SC403SP-51 R403 1-249-425-11 CARBON 4.7K 5% 1/4W F
Q820 8-729-422-57 TRANSISTOR UN4111 R404 1-249-417-11 CARBON 1K 5% 1/4W F
R406 1-249-437-11 CARBON 47K 5% 1/4W

specified.
— 84 —
MAIN
R407 1-249-437-11 CARBON 47K 5% 1/4W R740 1-249-427-11 CARBON 6.8K 5% 1/4W F
R408 1-249-437-11 CARBON 47K 5% 1/4W (G,IT)
R409 1-249-429-11 CARBON 10K 5% 1/4W R740 1-249-435-11 CARBON 33K 5% 1/4W
R410 1-247-882-11 CARBON 130K 5% 1/4W (EE)
(AEP,UK)
R413 1-247-864-11 CARBON 24K 5% 1/4W (TH)
R415 1-249-429-11 CARBON 10K 5% 1/4W (JE)
(EE)
R417 1-249-429-11 CARBON 10K 5% 1/4W
R419 1-249-429-11 CARBON 10K 5% 1/4W (AEP,UK,G,IT)
R420 1-249-429-11 CARBON 10K 5% 1/4W R743 1-249-413-11 CARBON 470 5% 1/4W F
R421 1-249-429-11 CARBON 10K 5% 1/4W R744 1-247-807-31 CARBON 100 5% 1/4W
R745 1-247-807-31 CARBON 100 5% 1/4W
R454 1-249-425-11 CARBON 4.7K 5% 1/4W F R746 1-249-429-11 CARBON 10K 5% 1/4W
R455 1-249-425-11 CARBON 4.7K 5% 1/4W F
R456 1-249-411-11 CARBON 330 5% 1/4W R747 1-249-429-11 CARBON 10K 5% 1/4W
R751 1-247-807-31 CARBON 100 5% 1/4W
R461 1-249-417-11 CARBON 1K 5% 1/4W F R752 1-247-807-31 CARBON 100 5% 1/4W
R701 1-249-429-11 CARBON 10K 5% 1/4W
R758 1-247-807-31 CARBON 100 5% 1/4W
R708 1-249-429-11 CARBON 10K 5% 1/4W
R763 1-249-429-11 CARBON 10K 5% 1/4W
R717 1-247-807-31 CARBON 100 5% 1/4W
R720 1-247-807-31 CARBON 100 5% 1/4W R821 1-249-417-11 CARBON 1K 5% 1/4W F
R826 1-249-441-11 CARBON 100K 5% 1/4W
R727 1-247-807-31 CARBON 100 5% 1/4W
R730 1-247-807-31 CARBON 100 5% 1/4W R901 1-249-421-11 CARBON 2.2K 5% 1/4W F
R902 1-249-421-11 CARBON 2.2K 5% 1/4W F
R732 1-247-807-31 CARBON 100 5% 1/4W
R909 1-249-419-11 CARBON 1.5K 5% 1/4W F
R737 1-247-807-31 CARBON 100 5% 1/4W
R738 1-249-427-11 CARBON 6.8K 5% 1/4W F R911 1-249-421-11 CARBON 2.2K 5% 1/4W F
R740 1-249-415-11 CARBON 680 5% 1/4W F R913 1-249-429-11 CARBON 10K 5% 1/4W
(JE) R914 1-249-437-11 CARBON 47K 5% 1/4W
R915 1-249-441-11 CARBON 100K 5% 1/4W
R740 1-249-423-11 CARBON 3.3K 5% 1/4W F
(TH)
— 85 —
MAIN
R917 1-247-903-00 CARBON 1M 5% 1/4W R1238 1-249-419-11 CARBON 1.5K 5% 1/4W

R930 1-249-429-11 CARBON 10K 5% 1/4W
R1249 1-249-389-11 CARBON 4.7 5% 1/4W F
R932 1-249-425-11 CARBON 4.7K 5% 1/4W F (AEP,UK,G,IT,EE)
R941 1-249-429-11 CARBON 10K 5% 1/4W
R1266 1-249-429-11 CARBON 10K 5% 1/4W
R945 1-249-421-11 CARBON 2.2K 5% 1/4W F R1270 1-249-389-11 CARBON 4.7 5% 1/4W F
R951 1-249-421-11 CARBON 2.2K 5% 1/4W F (AEP,UK,G,IT,EE)
R952 1-249-421-11 CARBON 2.2K 5% 1/4W F R1271 1-249-389-11 CARBON 4.7 5% 1/4W F
R955 1-249-441-11 CARBON 100K 5% 1/4W (AEP,UK,G,IT,EE)
R1272 1-249-407-11 CARBON 150 5% 1/4W F
R956 1-247-891-00 CARBON 330K 5% 1/4W
R959 1-249-419-11 CARBON 1.5K 5% 1/4W F (E,JE,EA,HK,MY,SP,TW,IA,TH)
R1295 1-249-433-11 CARBON 22K 5% 1/4W
R962 1-249-441-11 CARBON 100K 5% 1/4W (E,JE,EA,HK,MY,SP,TW,IA,TH)
R963 1-249-429-11 CARBON 10K 5% 1/4W
R964 1-249-437-11 CARBON 47K 5% 1/4W R1299 1-249-389-11 CARBON 4.7 5% 1/4W F
R965 1-249-441-11 CARBON 100K 5% 1/4W (AEP,UK,G,IT,EE)
R1303 1-249-425-11 CARBON 4.7K 5% 1/4W F
R967 1-247-903-00 CARBON 1M 5% 1/4W R1304 1-249-425-11 CARBON 4.7K 5% 1/4W F
R968 1-249-431-11 CARBON 15K 5% 1/4W ! R1601 1-217-637-00 FUSIBLE 1 5% 1/4W F
R970 1-247-903-00 CARBON 1M 5% 1/4W ! R1602 1-219-122-91 FUSIBLE 0.33 5% 1/4W F
R1001 1-249-421-11 CARBON 2.2K 5% 1/4W F
R1002 1-249-409-11 CARBON 220 5% 1/4W F ! R1603 1-219-122-91 FUSIBLE 0.33 5% 1/4W F
! R1604 1-217-637-00 FUSIBLE 1 5% 1/4W F
R1003 1-249-417-11 CARBON 1K 5% 1/4W F
R1007 1-249-417-11 CARBON 1K 5% 1/4W F < VARIABLE RESISTOR >
R1020 1-249-409-11 CARBON 220 5% 1/4W F
R1021 1-249-409-11 CARBON 220 5% 1/4W F RV301 1-238-600-11 RES, ADJ, CARBON 10K
R1022 1-249-421-11 CARBON 2.2K 5% 1/4W F RV351 1-238-600-11 RES, ADJ, CARBON 10K
R1023 1-249-417-11 CARBON 1K 5% 1/4W F < RELAY >

R1220 1-249-389-11 CARBON 4.7 5% 1/4W F
(AEP,UK,G,IT,EE) RY1201 1-515-920-11 RELAY (24V)
R1221 1-249-389-11 CARBON 4.7 5% 1/4W F
(AEP,UK,G,IT,EE) < TERMINAL >
R1222 1-249-407-11 CARBON 150 5% 1/4W F
R1223 1-249-407-11 CARBON 150 5% 1/4W F G1001 1-537-770-21 TERMINAL BOARD,GROUND (AEP,UK,G,IT,EE)
(TH) TM1201 1-537-240-31 TERMINAL BOARD (CHECKER PIN)(SPEAKER)
! R1226 1-215-864-00 METAL OXIDE 150 5% 1W F < VIBRATOR >

R1231 1-249-437-11 CARBON 47K 5% 1/4W
(E,JE,EA,HK,MY,SP,TW,IA,TH) X701 1-579-175-11 VIBRATOR, CERAMIC (10MHz)
R1233 1-249-425-11 CARBON 4.7K 5% 1/4W F X702 1-567-098-41 VIBRATOR, CRYSTAL (32kHz)
R1234 1-249-425-11 CARBON 4.7K 5% 1/4W F
R1235 1-249-435-11 CARBON 33K 5% 1/4W **************************************************************
R1236 1-249-441-11 CARBON 100K 5% 1/4W

R1237 1-249-429-11 CARBON 10K 5% 1/4W

specified.
— 86 —
MD
* A-2007-435-A MD BOARD, COMPLETE IC611 8-759-710-59 IC NJM4580D-D

*******************
(including MOTOR board) < COIL >
< CAPACITOR > L331 1-410-780-11 INDUCTOR 27mH

L431 1-410-780-11 INDUCTOR 27mH
C301 1-162-289-31 CERAMIC 390PF 10% 50V
C302 1-126-968-11 ELECT 100uF 20% 6.3V < TRANSISTOR >
C303 1-162-282-31 CERAMIC 100PF 10% 50V
C304 1-107-715-11 ELECT 22uF 20% 16V Q621 8-729-142-46 TRANSISTOR 2SC2001-LK
C304 1-130-483-00 MYLAR 0.01uF 5% 50V Q622 8-729-142-46 TRANSISTOR 2SC2001-LK
Q623 8-729-030-18 TRANSISTOR 2SD2525
C305 1-107-715-11 ELECT 22uF 20% 16V Q651 8-729-900-65 TRANSISTOR DTA144ES
C311 1-162-289-31 CERAMIC 390PF 10% 50V
C313 1-162-282-31 CERAMIC 100PF 10% 50V < RESISTOR >
C314 1-130-487-00 MYLAR 0.022uF 5% 50V
C315 1-126-233-11 ELECT 22uF 20% 50V R301 1-247-881-00 CARBON 120K 5% 1/4W
R302 1-249-409-11 CARBON 220 5% 1/4W F
C331 1-137-427-11 FILM 120PF 5% 50V R303 1-249-433-11 CARBON 22K 5% 1/4W
C332 1-162-288-31 CERAMIC 330PF 10% 50V R304 1-247-889-00 CARBON 270K 5% 1/4W
C401 1-162-289-31 CERAMIC 390PF 10% 50V
C402 1-126-968-11 ELECT 100uF 20% 6.3V R311 1-247-881-00 CARBON 120K 5% 1/4W
R312 1-247-807-31 CARBON 100 5% 1/4W
C404 1-130-483-00 MYLAR 0.01uF 5% 50V R315 1-247-850-11 CARBON 6.2K 5% 1/4W
C413 1-162-282-31 CERAMIC 100PF 10% 50V
C414 1-130-487-00 MYLAR 0.022uF 5% 50V R401 1-247-881-00 CARBON 120K 5% 1/4W
R402 1-249-409-11 CARBON 220 5% 1/4W F
C431 1-137-427-11 FILM 120PF 5% 50V R404 1-247-889-00 CARBON 270K 5% 1/4W
C433 1-162-209-31 CERAMIC 27PF 5% 50V
R412 1-247-807-31 CARBON 100 5% 1/4W
C611 1-124-907-11 ELECT 10uF 20% 50V R415 1-247-850-11 CARBON 6.2K 5% 1/4W
C621 1-137-150-11 FILM 0.01uF 5% 100V
C622 1-126-961-11 ELECT 2.2uF 20% 50V R601 1-249-409-11 CARBON 220 5% 1/4W F
R602 1-249-409-11 CARBON 220 5% 1/4W F
C623 1-136-155-00 FILM 0.015uF 5% 50V R608 1-249-409-11 CARBON 220 5% 1/4W F
C624 1-130-481-00 MYLAR 0.0068uF 5% 50V R609 1-249-433-11 CARBON 22K 5% 1/4W
C625 1-130-481-00 MYLAR 0.0068uF 5% 50V R611 1-249-409-11 CARBON 220 5% 1/4W F
C627 1-124-903-11 ELECT 1uF 20% 50V
! R621 1-212-851-00 FUSIBLE 5.6 5% 1/4W F
C642 1-104-664-11 ELECT 47uF 20% 16V ! R622 1-212-851-00 FUSIBLE 5.6 5% 1/4W F
C651 1-161-494-00 CERAMIC 0.022uF 25V R623 1-249-432-11 CARBON 18K 5% 1/4W
R624 1-249-432-11 CARBON 18K 5% 1/4W
< CONNECTOR >
R625 1-249-429-11 CARBON 10K 5% 1/4W
* CN601 1-568-864-11 SOCKET, CONNECTOR 21P R651 1-247-856-00 CARBON 11K 5% 1/4W
* CN602 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P R652 1-247-856-00 CARBON 11K 5% 1/4W
* CN651 1-564-521-11 PLUG, CONNECTOR 6P R653 1-249-441-11 CARBON 100K 5% 1/4W
< IC > < VARIABLE RESISTOR >
IC601 8-759-710-59 IC NJM4580D-D RV301 1-238-598-11 RES, ADJ, CARBON 2.2K

IC602 8-759-143-54 IC uPC1330HA
specified.
— 87 —
MD PANEL
RV311 1-238-598-11 RES, ADJ, CARBON 2.2K D589 8-719-032-87 DIODE SEL5420S-TP (·)(DECK A)
RV341 1-238-551-11 RES, ADJ, CARBON 220K D590 8-719-032-87 DIODE SEL5420S-TP (ª)(DECK A)
RV401 1-238-598-11 RES, ADJ, CARBON 2.2K D601 8-719-033-06 DIODE SEL5920A (CD)
RV411 1-238-598-11 RES, ADJ, CARBON 2.2K D611 8-719-033-06 DIODE SEL5920A (TUNER)
D621 8-719-033-06 DIODE SEL5920A (TIMER)
RV441 1-238-551-11 RES, ADJ, CARBON 220K
RV651 1-238-599-11 RES, ADJ, CARBON 4.7K < FLUORESCENT INDICATOR >
RV652 1-238-599-11 RES, ADJ, CARBON 4.7K
FL501 1-517-489-11 INDICATOR TUBE, FLUORESCENT
< TRANSFORMER >
< IC >
T621 1-423-980-11 TRANSFORMER, BIAS OSCILLATION
IC501 8-759-375-45 IC ASD042
************************************************************** IC502 8-759-332-18 IC GP1U27XB
* A-4389-446-A PANEL BOARD, COMPLETE (AEP,UK,G,IT,EE) < TRANSISTOR >

**************************************
* A-4389-447-A PANEL BOARD, COMPLETE Q502 8-729-119-76 TRANSISTOR 2SA1175-HFE
********************* Q503 8-729-119-76 TRANSISTOR 2SA1175-HFE
(E,JE,EA,HK,MY,SP,TW) Q504 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q507 8-729-119-76 TRANSISTOR 2SA1175-HFE
* A-4390-128-A PANEL BOARD, COMPLETE (TH)
************************* Q508 8-729-119-76 TRANSISTOR 2SA1175-HFE
* A-4390-514-A PANEL BOARD, COMPLETE (IA) Q510 8-729-119-76 TRANSISTOR 2SA1175-HFE
************************* Q511 8-729-119-76 TRANSISTOR 2SA1175-HFE
* 4-932-810-11 CUSHION (FL)
* 4-978-168-01 HOLDER, FL TUBE Q602 8-729-119-76 TRANSISTOR 2SA1175-HFE
< CAPACITOR >
< RESISTOR >
C513 1-162-294-31 CERAMIC 0.001uF 10% 50V
C514 1-124-589-11 ELECT 47uF 20% 16V R500 1-249-419-11 CARBON 1.5K 5% 1/4W F
C515 1-164-159-11 CERAMIC 0.1uF 50V R501 1-249-401-11 CARBON 47 5% 1/4W F
C522 1-162-306-11 CERAMIC 0.01uF 30% 16V R502 1-249-413-11 CARBON 470 5% 1/4W F
C530 1-124-261-00 ELECT 10uF 20% 50V R503 1-249-411-11 CARBON 330 5% 1/4W
R504 1-249-413-11 CARBON 470 5% 1/4W F
C531 1-124-261-00 ELECT 10uF 20% 50V
C532 1-164-159-11 CERAMIC 0.1uF 50V R505 1-249-419-11 CARBON 1.5K 5% 1/4W F
(AEP, UK, G, IT, EE) R506 1-249-401-11 CARBON 47 5% 1/4W F
R507 1-249-403-11 CARBON 68 5% 1/4W F
< CONNECTOR > R508 1-247-807-31 CARBON 100 5% 1/4W
R509 1-249-407-11 CARBON 150 5% 1/4W F
R510 1-249-407-11 CARBON 150 5% 1/4W F
< DIODE > R515 1-249-419-11 CARBON 1.5K 5% 1/4W F
R516 1-249-401-11 CARBON 47 5% 1/4W F
D579 8-719-032-87 DIODE SEL5420S-TP (TUNER/BAND) R517 1-249-403-11 CARBON 68 5% 1/4W F
D580 8-719-812-44 DIODE TLO124 (EFFECT ON/OFF) R518 1-247-807-31 CARBON 100 5% 1/4W
D581 8-719-033-06 DIODE SEL5920A (GROOVE)
D583 8-719-057-28 DIODE SML78420-TP4 (fl)(TH) R519 1-249-407-11 CARBON 150 5% 1/4W F
D583 8-719-056-12 DIODE SML79420C-TP4 (fl)(IA) R520 1-249-407-11 CARBON 150 5% 1/4W F
R521 1-249-409-11 CARBON 220 5% 1/4W F
D583 8-719-056-13 DIODE SML79423C-TP15 (fl) (EXCEPT IA,TH) R522 1-249-411-11 CARBON 330 5% 1/4W
D585 8-719-033-06 DIODE SEL5920A (P PAUSE) R523 1-249-413-11 CARBON 470 5% 1/4W F
D586 8-719-812-44 DIODE TLO124 (r REC)
D587 8-719-032-87 DIODE SEL5420S-TP (·)(DECK B) R524 1-249-415-11 CARBON 680 5% 1/4W F
D588 8-719-032-87 DIODE SEL5420S-TP (ª)(DECK B) R525 1-249-417-11 CARBON 1K 5% 1/4W F
— 88 —
PANEL
R526 1-249-419-11 CARBON 1.5K 5% 1/4W F R586 1-249-407-11 CARBON 150 5% 1/4W F
R527 1-249-421-11 CARBON 2.2K 5% 1/4W F R587 1-247-807-31 CARBON 100 5% 1/4W
R531 1-249-419-11 CARBON 1.5K 5% 1/4W F R601 1-249-403-11 CARBON 68 5% 1/4W F
R532 1-249-401-11 CARBON 47 5% 1/4W F R611 1-249-403-11 CARBON 68 5% 1/4W F
R533 1-249-413-11 CARBON 470 5% 1/4W F R621 1-249-403-11 CARBON 68 5% 1/4W F
R534 1-249-409-11 CARBON 220 5% 1/4W F R631 1-249-417-11 CARBON 1K 5% 1/4W F

R536 1-249-413-11 CARBON 470 5% 1/4W F R633 1-249-417-11 CARBON 1K 5% 1/4W F
R537 1-249-415-11 CARBON 680 5% 1/4W F R650 1-249-429-11 CARBON 10K 5% 1/4W
R538 1-249-417-11 CARBON 1K 5% 1/4W F R651 1-249-421-11 CARBON 2.2K 5% 1/4W F
R541 1-249-423-11 CARBON 3.3K 5% 1/4W F
R542 1-249-425-11 CARBON 4.7K 5% 1/4W F < SWITCH >
R543 1-247-807-31 CARBON 100 5% 1/4W
S500 1-554-303-21 SWITCH, TACTILE (POWER)
R544 1-247-807-31 CARBON 100 5% 1/4W S501 1-554-303-21 SWITCH, TACTILE (LOOP)
R545 1-247-807-31 CARBON 100 5% 1/4W S502 1-554-303-21 SWITCH, TACTILE (§ OPEN/CLOSE)
R546 1-247-807-31 CARBON 100 5% 1/4W S503 1-554-303-21 SWITCH, TACTILE (p)
R547 1-247-807-31 CARBON 100 5% 1/4W S504 1-554-303-21 SWITCH, TACTILE (fl)
R548 1-247-807-31 CARBON 100 5% 1/4W
S505 1-554-303-21 SWITCH, TACTILE (TIMER)
R549 1-249-429-11 CARBON 10K 5% 1/4W S506 1-554-303-21 SWITCH, TACTILE (DISPLAY/DEMO)
R550 1-249-409-11 CARBON 220 5% 1/4W F S507 1-554-303-21 SWITCH, TACTILE
R551 1-249-437-11 CARBON 47K 5% 1/4W (MULTI FUNCTION CONTROL 1)
R561 1-249-429-11 CARBON 10K 5% 1/4W S508 1-554-303-21 SWITCH, TACTILE
S509 1-554-303-21 SWITCH, TACTILE
R563 1-249-401-11 CARBON 47 5% 1/4W F (MULTI FUNCTION CONTROL 3)
R564 1-249-401-11 CARBON 47 5% 1/4W F
R565 1-249-429-11 CARBON 10K 5% 1/4W S510 1-554-303-21 SWITCH, TACTILE
R567 1-249-429-11 CARBON 10K 5% 1/4W S515 1-554-303-21 SWITCH, TACTILE (MENU 1)
S516 1-554-303-21 SWITCH, TACTILE (MENU 2)
R568 1-249-429-11 CARBON 10K 5% 1/4W S517 1-554-303-21 SWITCH, TACTILE (MENU 3)
R569 1-249-429-11 CARBON 10K 5% 1/4W S519 1-554-303-21 SWITCH, TACTILE (P FILE)
R570 1-249-437-11 CARBON 47K 5% 1/4W
R571 1-249-429-11 CARBON 10K 5% 1/4W S520 1-554-303-21 SWITCH, TACTILE (EFFECT ON/OFF)
R572 1-249-429-11 CARBON 10K 5% 1/4W S521 1-554-303-21 SWITCH, TACTILE (SURROUND)
S522 1-554-303-21 SWITCH, TACTILE (·)(DECK B)
R573 1-249-429-11 CARBON 10K 5% 1/4W S523 1-554-303-21 SWITCH, TACTILE (ª)(DECK B)
R574 1-249-429-11 CARBON 10K 5% 1/4W S524 1-554-303-21 SWITCH, TACTILE ())(DECK B)
R575 1-249-429-11 CARBON 10K 5% 1/4W
R576 1-249-429-11 CARBON 10K 5% 1/4W S525 1-554-303-21 SWITCH, TACTILE (p)(DECK B)
R577 1-247-903-00 CARBON 1M 5% 1/4W S526 1-554-303-21 SWITCH, TACTILE (0)(DECK B)
S527 1-554-303-21 SWITCH, TACTILE (P PAUSE)
R578 1-247-807-31 CARBON 100 5% 1/4W S528 1-554-303-21 SWITCH, TACTILE (r REC)
R579 1-249-437-11 CARBON 47K 5% 1/4W S529 1-554-303-21 SWITCH, TACTILE (CD SYNCHRO)
R580 1-249-407-11 CARBON 150 5% 1/4W F
R581 1-247-807-31 CARBON 100 5% 1/4W S530 1-554-303-21 SWITCH, TACTILE (HIGH SPEED DUBBING)
R583 1-247-807-31 CARBON 100 5% 1/4W S533 1-554-303-21 SWITCH, TACTILE (TUNER/BAND)
S534 1-554-303-21 SWITCH, TACTILE (FUNCTION)
R584 1-247-807-31 CARBON 100 5% 1/4W S535 1-554-303-21 SWITCH, TACTILE (GROOVE)
R585 1-247-807-31 CARBON 100 5% 1/4W S536 1-554-303-21 SWITCH, TACTILE (DIRECTION)
— 89 —
PANEL POWER AMP
S537 1-554-303-21 SWITCH, TACTILE (DOLBY NR) < DIODE >

S538 1-554-303-21 SWITCH, TACTILE ())(DECK A)
S539 1-554-303-21 SWITCH, TACTILE (p)(DECK A) D1201 8-719-987-63 DIODE 1N4148M
S540 1-554-303-21 SWITCH, TACTILE (0)(DECK A) D1202 8-719-987-63 DIODE 1N4148M
S541 1-554-303-21 SWITCH, TACTILE (·)(DECK A) D1251 8-719-987-63 DIODE 1N4148M
S542 1-554-303-21 SWITCH, TACTILE (ª)(DECK A) < IC >
< VIBRATOR > IC1201 8-749-920-13 IC STK-4132MK2 (E,JE,EA,HK,MY,SP,TW,IA,TH)

IC1201 8-749-920-19 IC STK-4122-2-K (AEP,UK,G,IT,EE)
X501 1-760-489-11 VIBRATOR, CERAMIC (5MHz)
< TRANSISTOR >
**************************************************************
Q1201 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
* A-4389-444-A POWER AMP BOARD, COMPLETE Q1251 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
***************************
(AEP, UK, G, IT, EE) < RESISTOR >
* A-4389-445-A POWER AMP BOARD, COMPLETE R1201 1-249-417-11 CARBON 1K 5% 1/4W F

*************************** R1202 1-249-437-11 CARBON 47K 5% 1/4W
(E,JE,EA,HK,MY,SP,TW) R1203 1-249-415-11 CARBON 680 5% 1/4W F
R1204 1-249-437-11 CARBON 47K 5% 1/4W
* A-4390-127-A POWER AMP BOARD, COMPLETE (TH) R1205 1-249-425-11 CARBON 4.7K 5% 1/4W F
*******************************
R1206 1-249-425-11 CARBON 4.7K 5% 1/4W F
* A-4390-513-A POWER AMP BOARD, COMPLETE (IA) R1207 1-249-425-11 CARBON 4.7K 5% 1/4W F
****************************** R1208 1-249-425-11 CARBON 4.7K 5% 1/4W F
! R1209 1-212-881-11 FUSIBLE 100 5% 1/4W F
< CAPACITOR > ! R1210 1-208-602-11 WIREWOUND 0.22 10% 2W F
C1201 1-126-963-11 ELECT 4.7uF 20% 50V R1211 1-249-417-11 CARBON 1K 5% 1/4W F
C1227 1-164-159-21 CERAMIC 0.1uF 50V R1242 1-249-435-11 CARBON 33K 5% 1/4W
C1246 1-164-159-11 CERAMIC 0.1uF 50V R1251 1-249-417-11 CARBON 1K 5% 1/4W F
(AEP,UK,G,IT,EE) R1252 1-249-437-11 CARBON 47K 5% 1/4W
C1251 1-126-963-11 ELECT 4.7uF 20% 50V R1253 1-249-415-11 CARBON 680 5% 1/4W F
C1252 1-162-288-31 CERAMIC 330PF 10% 50V
R1254 1-249-437-11 CARBON 47K 5% 1/4W
C1253 1-162-286-31 CERAMIC 220PF 10% 50V R1255 1-249-425-11 CARBON 4.7K 5% 1/4W F
C1260 1-136-495-11 FILM 0.068uF 5% 50V
! R1259 1-212-881-11 FUSIBLE 100 5% 1/4W F
C1261 1-136-495-11 FILM 0.068uF 5% 50V ! R1260 1-208-602-11 WIREWOUND 0.22 10% 2W F
C1296 1-164-159-11 CERAMIC 0.1uF 50V R1261 1-249-417-11 CARBON 1K 5% 1/4W F
(AEP,UK,G,IT,EE) R1262 1-249-431-11 CARBON 15K 5% 1/4W
R1263 1-249-441-11 CARBON 100K 5% 1/4W

specified.
— 90 —
POWER AMP TCB
R1268 1-249-397-11 CARBON 22 5% 1/4W F C46 1-163-077-00 CERAMIC CHIP 0.1uF 10% 25V
R1269 1-249-397-11 CARBON 22 5% 1/4W F C47 1-126-967-11 ELECT 47uF 20% 16V
************************************************************** C49 1-124-902-00 ELECT 0.47uF 20% 50V
C50 1-124-903-11 ELECT 1.0uF 20% 50V
* A-4303-514-A TCB BOARD, COMPLETE (AEP,UK)
**************************** C51 1-124-903-11 ELECT 1.0uF 20% 50V
C52 1-126-964-11 ELECT 10uF 20% 50V
* A-4303-515-A TCB BOARD, COMPLETE (IT,G) C53 1-126-964-11 ELECT 10uF 20% 50V
************************ C54 1-126-157-11 ELECT 10uF 20% 16V
C55 1-126-157-11 ELECT 10uF 20% 16V
* A-4303-516-A TCB BOARD, COMPLETE (EE)
*********************** C56 1-126-157-11 ELECT 10uF 20% 16V
< CAPACITOR > C58 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50V
C1 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V (AEP,UK,IT,G)
C2 1-126-967-11 ELECT 47uF 20% 16V C59 1-163-989-11 CERAMIC CHIP 33000PF 10% 25V (EE)
C6 1-163-038-91 CERAMIC CHIP 0.1uF 25V (AEP,UK,IT,G)
C60 1-163-989-11 CERAMIC CHIP 33000PF 10% 25V (EE)
C7 1-101-004-00 CERAMIC 0.01uF 50V (EE) C61 1-126-301-11 ELECT 1.0uF 20% 50V
C11 1-216-295-11 METAL CHIP 0 5% 1/10W C64 1-126-967-11 ELECT 47uF 20% 16V
(IT,G) C65 1-163-031-11 CERAMIC CHIP 0.01uF 50V
C66 1-126-162-11 ELECT 3.3uF 20% 50V
C16 1-163-038-91 CERAMIC CHIP 0.1uF 25V C67 1-126-933-11 ELECT 100uF 20% 10V
C19 1-163-249-11 CERAMIC CHIP 82PF 5% 50V C68 1-162-306-11 CERAMIC 0.01uF 30% 16V
(AEP,UK,EE)
C21 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V C71 1-162-306-11 CERAMIC 0.01uF 30% 16V
C22 1-163-031-11 CERAMIC CHIP 0.01uF 50V C72 1-126-967-11 ELECT 47uF 20% 16V
C23 1-163-235-11 CERAMIC CHIP 22PF 5% 50V C120 1-163-105-00 CERAMIC CHIP 33PF 5% 50V
(AEP,UK,IT,G)
C26 1-126-967-11 ELECT 47uF 20% 16V < FILTER >
C28 1-126-967-11 ELECT 47uF 20% 16V
C29 1-162-306-11 CERAMIC 0.01uF 30% 16V CF1 1-567-389-11 FILTER, CERAMIC (EE)
C30 1-124-925-11 ELECT 2.2uF 20% 100V CF1 1-579-374-71 FILTER, CERAMIC (AEP,UK,IT,G)
CF2 1-760-393-11 FILTER, CERAMIC (AEP,UK,IT,G)
C31 1-163-031-11 CERAMIC CHIP 0.01uF 50V CF3 1-567-389-11 FILTER, CERAMIC (EE)
C32 1-163-038-91 CERAMIC CHIP 0.1uF 25V CF3 1-760-393-11 FILTER, CERAMIC (AEP,UK,IT,G)
C34 1-163-091-00 CERAMIC CHIP 8PF 50V < CONNECTOR >
(IT,G)
C34 1-163-229-11 CERAMIC CHIP 12PF 5% 50V * CN1 1-568-834-11 SOCKET, CONNECTOR 15P
(AEP,UK,EE)
< DIODE >
C36 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V D21 8-719-976-99 DIODE DTZ5.1B
C37 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V D41 8-719-016-74 DIODE 1SS352
C40 1-163-031-11 CERAMIC CHIP 0.01uF 50V < FRONTEND >
C41 1-163-031-11 CERAMIC CHIP 0.01uF 50V FE1 1-693-335-11 FRONT END (3 GANG)(EE)
C42 1-163-038-91 CERAMIC CHIP 0.1uF 25V FE1 1-233-542-11 FRONT END (4 GANG)(AEP,UK,IT,G)
C43 1-163-038-91 CERAMIC CHIP 0.1uF 25V FE2 1-233-514-11 ENCAPSULATED COMPONENT (AEP,UK,EE)
C44 1-163-031-11 CERAMIC CHIP 0.01uF 50V FE2 1-239-260-11 ENCAPSULATED COMPONENT (IT,G)
— 91 —
TCB
< IC > < TRANSISTOR >
IC21 8-759-288-54 IC LC72130 Q1 8-729-201-27 TRANSISTOR 2SC2715Y

IC41 8-759-176-03 IC LA1835 Q2 8-729-201-27 TRANSISTOR 2SC2715Y
Q3 8-729-201-27 TRANSISTOR 2SC2715Y
< IFT > Q4 8-729-201-27 TRANSISTOR 2SC2715Y
Q5 8-729-424-08 TRANSISTOR UN2111
IFT41 1-409-636-11 TRANSFORMER, IF (CERAMIC FILTER)
Q9 8-729-216-22 TRANSISTOR 2SA812-M5M6 (AEP,UK,EE)
< JUMPER RESISTOR > Q11 8-729-421-22 TRANSISTOR UN2211 (AEP,UK,EE)
Q12 8-729-421-22 TRANSISTOR UN2211 (AEP,UK,EE)
JR1 1-216-295-91 METAL CHIP 0 5% 1/10W Q13 8-729-421-22 TRANSISTOR UN2211 (AEP,UK,EE)
(IT,G) Q14 8-729-421-22 TRANSISTOR UN2211 (AEP,UK,EE)
JR2 1-216-295-91 METAL CHIP 0 5% 1/10W
(AEP,UK,EE) < RESISTOR >
JR3 1-216-295-91 METAL CHIP 0 5% 1/10W
(IT,G) R1 1-249-401-11 CARBON 47 5% 1/4W F
JR6 1-216-295-91 METAL CHIP 0 5% 1/10W R2 1-216-037-00 METAL CHIP 330 5% 1/10W
(AEP,UK,IT,G) R3 1-216-037-00 METAL CHIP 330 5% 1/10W
(IT,G) R6 1-216-081-00 METAL CHIP 22K 5% 1/10W
(AEP,UK,EE) R8 1-216-037-00 METAL CHIP 330 5% 1/10W
JR9 1-216-295-91 METAL CHIP 0 5% 1/10W R9 1-216-081-00 METAL CHIP 22K 5% 1/10W
(AEP,UK,EE) R10 1-216-037-00 METAL CHIP 330 5% 1/10W
JR46 1-216-296-11 METAL CHIP 0 5% 1/8W
R13 1-216-037-00 METAL CHIP 330 5% 1/10W
JR51 1-216-295-91 METAL CHIP 0 5% 1/10W (AEP,UK,EE)
(AEP,UK,EE) R19 1-216-073-00 METAL CHIP 10K 5% 1/10W
JR52 1-216-295-91 METAL CHIP 0 5% 1/10W (AEP,UK,EE)
JR53 1-216-296-11 METAL CHIP 0 5% 1/8W
(AEP,UK,EE) R21 1-216-049-91 METAL CHIP 1.0K 5% 1/10W
R22 1-216-049-91 METAL CHIP 1.0K 5% 1/10W
JR54 1-216-295-91 METAL CHIP 0 5% 1/10W R23 1-216-049-91 METAL CHIP 1.0K 5% 1/10W
R24 1-216-025-91 METAL CHIP 100 5% 1/10W
< JUMPER RESISTOR > R25 1-249-417-11 CARBON 1.0K 5% 1/4W F
JW4 1-249-413-11 CARBON 470 5% 1/4W R26 1-249-437-11 CARBON 47K 5% 1/4W
(AEP,UK,IT,G) R27 1-249-429-11 CARBON 10K 5% 1/4W
JW5 1-249-413-11 CARBON 470 5% 1/4W R28 1-249-417-11 CARBON 1.0K 5% 1/4W F
(AEP,UK,IT,G) R29 1-216-061-00 METAL CHIP 3.3K 5% 1/10W
R30 1-216-186-00 METAL CHIP 330 5% 1/8W
< COIL >
R31 1-216-025-91 METAL CHIP 100 5% 1/10W
L2 1-414-142-11 MICRO INDUCTOR 1uH (AEP,UK,IT,G) R32 1-249-425-11 CARBON 4.7K 5% 1/4W F
L3 1-410-521-11 MICRO INDUCTOR 100uH R33 1-249-425-11 CARBON 4.7K 5% 1/4W F
L4 1-410-515-11 INDUCTOR 33uH (AEP,UK,IT,G) R34 1-216-065-00 METAL CHIP 4.7K 5% 1/10W
L41 1-407-500-00 MICRO INDUCTOR 4.7mH (AEP,UK,EE) R35 1-216-214-00 METAL CHIP 4.7K 5% 1/8W
L41 1-410-119-11 MICRO INDUCTOR (EL TYPE) 1mH (IT,G)
R36 1-216-025-91 METAL CHIP 100 5% 1/10W
< FILTER > R37 1-216-073-00 METAL CHIP 10K 5% 1/10W
R38 1-216-089-91 METAL CHIP 47K 5% 1/10W
LPF41 1-239-845-11 FILTER, LOW PASS R39 1-249-429-11 CARBON 10K 5% 1/4W
LPF42 1-239-845-11 FILTER, LOW PASS R42 1-216-073-00 METAL CHIP 10K 5% 1/10W
— 92 —
TCB
R43 1-216-042-00 METAL CHIP 510 5% 1/10W C11 1-163-038-91 CERAMIC CHIP 100000PF 25V
R44 1-216-013-00 METAL CHIP 33 5% 1/10W
R45 1-249-423-11 CARBON 3.3K 5% 1/4W F C14 1-163-038-91 CERAMIC CHIP 100000PF 25V
R46 1-216-073-00 METAL CHIP 10K 5% 1/10W C15 1-136-162-00 METALIZED FILM 0.056uF 5% 50V
R47 1-216-097-91 METAL CHIP 100K 5% 1/10W C16 1-163-038-91 CERAMIC CHIP 100000PF 25V
C17 1-163-031-11 CERAMIC CHIP 10000PF 50V
R48 1-249-417-11 CARBON 1.0K 5% 1/4W F C18 1-163-088-00 CERAMIC CHIP 5PF 50V
R49 1-216-049-91 METAL CHIP 1.0K 5% 1/10W
R50 1-216-065-00 METAL CHIP 4.7K 5% 1/10W C21 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V
R51 1-216-065-00 METAL CHIP 4.7K 5% 1/10W C22 1-163-031-11 CERAMIC CHIP 10000PF 50V
R53 1-249-429-11 CARBON 10K 5% 1/4W C23 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
R55 1-216-162-00 METAL CHIP 33 5% 1/8W C26 1-126-967-11 ELECT 47uF 20% 50V
R56 1-249-393-11 CARBON 10 5% 1/4W F
R91 1-216-295-91 METAL CHIP 0 5% 1/10W C28 1-126-967-11 ELECT 47uF 20% 50V
(AEP,UK,EE) C29 1-162-306-11 CERAMIC 10000PF 20% 16V
R92 1-216-073-00 METAL CHIP 10K 5% 1/10W C30 1-124-925-11 ELECT 2.2uF 20% 100V
(AEP,UK,EE) C31 1-163-031-11 CERAMIC CHIP 10000PF 50V
R99 1-249-399-11 CARBON 33 5% 1/4W F C32 1-163-038-91 CERAMIC CHIP 100000PF 25V
< VARIABLE RESISTOR > C33 1-163-038-91 CERAMIC CHIP 100000PF 25V
RV41 1-238-601-11 RES, ADJ, CARBON 22K C35 1-163-038-91 CERAMIC CHIP 100000PF 25V
RV42 1-238-600-11 RES, ADJ, CARBON 10K C36 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V
< TERMINAL >
C38 1-162-211-31 CERAMIC 33PF 5% 50V
TM1 1-537-488-11 TERMINAL BOARD (ANT)(ANTENNA) C39 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V
< VIBRATOR > C41 1-163-031-11 CERAMIC CHIP 10000PF 50V
X21 1-760-549-11 VIBRATOR, CRYSTAL (4.5MHz)
X41 1-760-220-11 FILTER, CERAMIC (10.7MHz) C43 1-163-038-91 CERAMIC CHIP 100000PF 25V
X42 1-527-981-00 FILTER, CERAMIC (450kHz) C44 1-163-031-11 CERAMIC CHIP 10000PF 50V
X43 1-577-075-11 OSCILLATOR, CERAMIC (456kHz) C45 1-163-038-91 CERAMIC CHIP 100000PF 25V
************************************************************** C47 1-126-967-11 ELECT 47uF 20% 50V
* A-4303-506-A TCB BOARD, COMPLETE (IA) C48 1-163-031-11 CERAMIC CHIP 10000PF 50V
******************** C49 1-124-902-00 ELECT 0.47uF 20% 50V
C50 1-124-903-11 ELECT 1.0uF 20% 50V
* A-4303-518-A TCB BOARD, COMPLETE (E,EA,HK,SP,MY,TW) C51 1-124-903-11 ELECT 1.0uF 20% 50V
******************** C52 1-126-964-11 ELECT 10uF 20% 50V
* A-4303-520-A TCB BOARD, COMPLETE (JE) C53 1-126-964-11 ELECT 10uF 20% 50V
******************** C54 1-126-157-11 ELECT 10uF 20% 16V
C55 1-126-157-11 ELECT 10uF 20% 16V
< CAPACITOR > C56 1-126-157-11 ELECT 10uF 20% 16V
C2 1-126-967-11 ELECT 47uF 20% 16V C58 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50V
C3 1-163-038-91 CERAMIC CHIP 100000PF 25V C59 1-163-989-11 CERAMIC CHIP 0.033uF 10% 25V
C6 1-163-038-91 CERAMIC CHIP 100000PF 25V C61 1-126-301-11 ELECT 1uF 20% 50V
C7 1-101-004-00 CERAMIC 0.01uF 50V
C9 1-163-031-11 CERAMIC CHIP 10000PF 50V C64 1-126-967-11 CAP, ELECT 47uF 20% 50V
C10 1-163-031-11 CERAMIC CHIP 10000PF 50V C65 1-163-031-11 CERAMIC CHIP 10000PF 50V
— 93 —
TCB
C66 1-126-162-11 ELECT 3.3uF 20% 50V L41 1-410-119-11 MICRO INDUCTOR (EL TYPE) 1mH
C67 1-126-933-11 ELECT 100uF 20% 16V
< FILTER >
C68 1-162-306-11 CERAMIC 10000PF 20% 16V
C71 1-162-306-11 CERAMIC 10000PF 20% 16V LPF41 1-239-845-11 FILTER, LOW PASS
C72 1-126-967-11 ELECT 47uF 20% 50V LPF42 1-239-845-11 FILTER, LOW PASS
< FILTER > < TRANSISTOR >
CF1 1-567-389-11 FILTER, CERAMIC Q1 8-729-201-27 TRANSISTOR 2SC2715Y-TE85L

CF3 1-567-389-11 FILTER, CERAMIC Q2 8-729-201-27 TRANSISTOR 2SC2715Y-TE85L
Q3 8-729-201-27 TRANSISTOR 2SC2715Y-TE85L
< CONNECTOR > Q4 8-729-201-27 TRANSISTOR 2SC2715Y-TE85L
Q5 8-729-424-08 TRANSISTOR UN2111
Q8 8-729-033-67 TRANSISTOR 2SK211-Y-TE85L
< VARIABLE CAPACITOR > Q9 8-729-216-22 TRANSISTOR 2SA812-T1-M5M6
Q10 8-729-216-22 TRANSISTOR 2SA812-T1-M5M6
CV1 1-141-227-00 CAP, TRIMMER 20PF Q12 8-729-421-22 TRANSISTOR UN2211
CV2 1-141-227-00 CAP, TRIMMER 20PF Q13 8-729-421-22 TRANSISTOR UN2211
< DIODE > Q14 8-729-421-22 TRANSISTOR UN2211
D1 8-719-976-30 DIODE KV1560NT < RESISTOR >

D21 8-719-976-99 DIODE DTZ5.1B
D41 8-719-016-74 DIODE 1SS352 R1 1-249-401-11 CARBON 47 5% 1/4W
R2 1-216-037-00 METAL CHIP 330 5% 1/10W
< FRONT END > R3 1-216-037-00 METAL CHIP 330 5% 1/10W
R5 1-216-037-00 METAL CHIP 330 5% 1/10W
FE1 1-233-532-11 ENCAPSULATED COMPONENT (EXCEPT JE) R6 1-216-081-00 METAL CHIP 22K 5% 1/10W
FE1 1-693-251-11 FRONT END (JE)
FE2 1-239-262-11 ENCAPSULATED COMPONENT R7 1-216-037-00 METAL CHIP 330 5% 1/10W
R8 1-216-037-00 METAL CHIP 330 5% 1/10W
< IC > R9 1-216-081-00 METAL CHIP 22K 5% 1/10W
R10 1-216-037-00 METAL CHIP 330 5% 1/10W
IC21 8-759-288-54 IC LC72130 R11 1-216-081-00 METAL CHIP 22K 5% 1/10W
IC41 8-759-176-03 IC LA1835
R12 1-216-037-00 METAL CHIP 330 5% 1/10W
< IFT > R13 1-216-037-00 METAL CHIP 330 5% 1/10W
R14 1-216-081-00 METAL CHIP 22K 5% 1/10W
IFT41 1-409-636-11 TRANSFORMER, IF (CERAMIC FILTER) R18 1-216-065-00 METAL CHIP 4.7K 5% 1/10W
R19 1-216-073-00 METAL CHIP 10K 5% 1/10W
< JUMPER RESISTOR >
R20 1-216-121-91 METAL CHIP 1.0M 5% 1/10W
JR45 1-216-295-91 METAL GLAZE 0 5% 1/10W R21 1-216-049-91 METAL CHIP 1.0K 5% 1/10W
JR48 1-216-295-91 METAL GLAZE 0 5% 1/10W R24 1-216-025-91 METAL CHIP 100 5% 1/10W
JR49 1-216-296-91 METAL GLAZE 0 5% 1/8W
R25 1-249-417-11 CARBON 1K 5% 1/4W
JR50 1-216-295-91 METAL GLAZE 0 5% 1/10W R26 1-249-437-11 CARBON 47K 5% 1/4W
JR54 1-216-295-91 METAL GLAZE 0 5% 1/10W
R30 1-216-186-00 METAL CHIP 330 5% 1/8W
< COIL > R31 1-216-025-91 METAL CHIP 100 5% 1/10W
R32 1-249-425-11 CARBON 4.7K 5% 1/4W
L1 1-410-521-11 MICRO INDUCTOR 100uH R33 1-249-425-11 CARBON 4.7K 5% 1/4W
L3 1-410-521-11 MICRO INDUCTOR 100uH R34 1-216-065-00 METAL CHIP 4.7K 5% 1/10W
— 94 —
TCB
R36 1-216-025-91 METAL CHIP 100 5% 1/10W C6 1-162-306-11 CERAMIC 10000PF 30% 16V
R37 1-216-073-00 METAL CHIP 10K 5% 1/10W
R38 1-216-089-91 METAL CHIP 47K 5% 1/10W C7 1-101-004-00 CERAMIC 0.01uF 50V
R39 1-249-429-11 CARBON 10K 5% 1/4W C8 1-162-306-11 CERAMIC 10000PF 30% 16V
C9 1-162-306-11 CERAMIC 10000PF 30% 16V
R42 1-216-073-00 METAL CHIP 10K 5% 1/10W C11 1-164-159-21 CERAMIC 0.1uF 50V
R43 1-216-042-00 METAL CHIP 510 5% 1/10W C12 1-162-198-31 CERAMIC 8.2PF 10% 50V
R44 1-216-013-00 METAL CHIP 33 5% 1/10W
R45 1-249-423-11 CARBON 3.3K 5% 1/4W C14 1-162-306-11 CERAMIC 10000PF 30% 16V
R46 1-216-073-00 METAL CHIP 10K 5% 1/10W C21 1-102-960-00 CERAMIC 24PF 5% 50V
C22 1-164-159-21 CERAMIC 0.1uF 50V
R48 1-249-423-11 CARBON 3.3K 5% 1/4W C24 1-104-664-11 ELECT 47uF 20% 16V
R49 1-216-061-00 METAL CHIP 3.3K 5% 1/4W
R51 1-216-065-00 METAL CHIP 4.7K 5% 1/10W C26 1-126-964-11 ELECT 10uF 20% 50V
C27 1-164-159-21 CERAMIC 0.1uF 50V
R53 1-249-429-11 CARBON 10K 5% 1/4W C28 1-124-925-11 ELECT 2.2uF 20% 100V
R54 1-249-399-11 CARBON 33 5% 1/4W C29 1-102-960-00 CERAMIC 24PF 5% 50V
R55 1-216-162-00 METAL CHIP 33 5% 1/10W
R56 1-249-393-11 CARBON 10 5% 1/4W C30 1-162-294-31 CERAMIC 0.001uF 10% 50V
C41 1-126-933-11 ELECT 100uF 20% 10V
R93 1-216-073-00 METAL CHIP 10K 5% 1/10W C43 1-126-962-11 ELECT 3.3uF 20% 50V
R94 1-216-073-00 METAL CHIP 10K 5% 1/10W
R99 1-249-399-11 CARBON 33 5% 1/4W F C44 1-162-306-11 CERAMIC 10000PF 30% 16V
C45 1-124-589-11 ELECT 47uF 20% 16V
< VARIABLE RESISTOR > C46 1-162-600-11 CERAMIC 4700PF 30% 16V
C47 1-162-294-31 CERAMIC 0.001uF 10% 50V
RV41 1-238-601-11 RES, ADJ, CARBON 22K C48 1-126-160-11 ELECT 1.0uF 20% 50V
C49 1-136-159-00 METALIZED FILM 0.033uF 5% 50V
< TRANSFORMER > C50 1-136-159-00 METALIZED FILM 0.033uF 5% 50V
C51 1-162-600-11 CERAMIC 4700PF 30% 16V
T1 1-409-505-11 COIL (ANT. SW3) C52 1-162-600-11 CERAMIC 4700PF 30% 16V
T2 1-402-960-11 COIL (OSC SW3) C53 1-126-964-11 ELECT 10uF 20% 50V
< TERMINAL > C54 1-126-157-11 ELECT 10uF 20% 16V

C55 1-126-964-11 ELECT 10uF 20% 50V
TM1 1-537-238-21 TERMINAL BOARD (ANTENNA) C56 1-126-964-11 ELECT 10uF 20% 50V
C57 1-164-159-21 CERAMIC 0.1uF 50V F
< VIBRATOR > C58 1-162-306-11 CERAMIC 10000PF 30% 16V
X21 1-760-549-11 VIBRATOR, CRYSTAL (4.5MHz) C59 1-164-159-21 CERAMIC 0.1uF 50V F
X41 1-760-220-11 FILTER, CERAMIC (10.7MHz) C61 1-164-159-21 CERAMIC 0.1uF 50V F
X42 1-527-981-00 FILTER, CERAMIC (450kHz) C62 1-104-664-11 ELECT 47uF 20% 16V
X43 1-577-075-11 OSCILLATOR, CERAMIC (19kHz) C63 1-164-159-21 CERAMIC 0.1uF 50V F
C64 1-124-902-00 ELECT 0.47uF 20% 50V
**************************************************************
C65 1-124-903-11 ELECT 1.0uF 20% 50V
* A-4303-537-A TCB BOARD, COMPLETE (TH) C66 1-124-903-11 ELECT 1.0uF 20% 50V
************************ C67 1-126-964-11 ELECT 10uF 20% 50V
C68 1-162-306-11 CERAMIC 10000PF 30% 16V
< CAPACITOR > C69 1-162-306-11 CERAMIC 10000PF 30% 16V
C1 1-162-294-31 CERAMIC 0.001uF 10% 50V C70 1-162-306-11 CERAMIC 10000PF 30% 16V
C2 1-104-664-11 ELECT 47uF 20% 16V C71 1-162-306-11 CERAMIC 10000PF 30% 16V
C3 1-164-159-21 CERAMIC 0.1uF 50V C73 1-162-306-11 CERAMIC 10000PF 30% 16V
— 95 —
TCB
C74 1-126-964-11 ELECT 10uF 20% 50V R12 1-249-411-11 CARBON 330 5% 1/4W
R13 1-249-411-11 CARBON 330 5% 1/4W
< FILTER > R14 1-247-863-91 CARBON 22K 5% 1/4W
R15 1-249-429-11 CARBON 10K 5% 1/4W
CF1 1-567-389-11 FILTER, CERAMIC R16 1-249-437-11 CARBON 47K 5% 1/4W
CF2 1-567-389-11 FILTER, CERAMIC
R19 1-249-399-11 CARBON 33 5% 1/4W F
< CONNECTOR > R21 1-247-807-31 CARBON 100 5% 1/4W
R22 1-249-425-11 CARBON 4.7K 5% 1/4W F
* CN1 1-568-832-11 SOCKET, CONNECTOR 13P R23 1-249-425-11 CARBON 4.7K 5% 1/4W F
R24 1-249-425-11 CARBON 4.7K 5% 1/4W F
< DIODE >
R25 1-247-807-31 CARBON 100 5% 1/4W
D1 8-719-933-33 DIODE HZS6A1L R26 1-249-411-11 CARBON 330 5% 1/4W
D2 8-719-987-63 DIODE 1N4148M R27 1-249-425-11 CARBON 4.7K 5% 1/4W F
R28 1-249-423-11 CARBON 3.3K 5% 1/4W F
< FRONTEND > R29 1-249-417-11 CARBON 1.0K 5% 1/4W F
FE1 1-233-533-11 ENCAPSULATED COMPONENT R30 1-249-417-11 CARBON 1.0K 5% 1/4W F

FE2 1-239-260-11 ENCAPSULATED COMPONENT R31 1-249-417-11 CARBON 1.0K 5% 1/4W F
R32 1-249-417-11 CARBON 1.0K 5% 1/4W F
< IC > R33 1-247-807-31 CARBON 100 5% 1/4W
R34 1-249-429-11 CARBON 10K 5% 1/4W
IC1 8-759-288-54 IC LC72130
IC2 8-759-176-03 IC LA1835 R35 1-249-429-11 CARBON 10K 5% 1/4W
R36 1-249-437-11 CARBON 47K 5% 1/4W
< IFT > R37 1-249-417-11 CARBON 1.0K 5% 1/4W F
R41 1-249-429-11 CARBON 10K 5% 1/4W
IFT41 1-409-636-11 TRANSFORMER, IF (CERAMIC FILTER) R43 1-249-423-11 CARBON 3.3K 5% 1/4W
< COIL > R44 1-249-423-11 CARBON 3.3K 5% 1/4W

R46 1-249-442-11 CARBON 510 5% 1/4W
L41 1-410-119-11 MICRO INDUCTOR (EL TYPE) 1mH R47 1-249-399-11 CARBON 33 5% 1/4W F
R48 1-249-423-11 CARBON 3.3K 5% 1/4W F
< FILTER > R49 1-249-393-11 CARBON 10 5% 1/4W F
R52 1-249-429-11 CARBON 10K 5% 1/4W
< TRANSISTOR > R53 1-249-425-11 CARBON 4.7K 5% 1/4W F
R54 1-249-425-11 CARBON 4.7K 5% 1/4W F
Q1 8-729-230-99 TRANSISTOR 2SC2669O-Y
Q2 8-729-230-99 TRANSISTOR 2SC2669O-Y R99 1-249-399-11 CARBON 33 5% 1/4W F
Q5 8-729-422-57 TRANSISTOR UN4111 < VARIABLE RESISTOR >
< RESISTOR > RV41 1-238-600-11 RES, ADJ, CARBON 10K

R1 1-249-401-11 CARBON 47 5% 1/4W F
R2 1-249-411-11 CARBON 330 5% 1/4W < TERMINAL >
R3 1-249-411-11 CARBON 330 5% 1/4W
R5 1-249-411-11 CARBON 330 5% 1/4W TM1 1-537-238-21 TERMINAL BOARD (ANTENNA)
R6 1-247-863-91 CARBON 22K 5% 1/4W
< VIBRATOR >
R7 1-249-411-11 CARBON 330 5% 1/4W
R8 1-249-411-11 CARBON 330 5% 1/4W X21 1-567-713-11 VIBRATOR, CRYSTAL (4.5MHz)
R9 1-247-863-91 CARBON 22K 5% 1/4W X41 1-577-075-11 OSCILLATOR, CERAMIC (456kHz)
R10 1-249-411-11 CARBON 330 5% 1/4W X42 1-760-220-11 FILTER, CERAMIC (10.7MHz)
R11 1-247-863-91 CARBON 22K 5% 1/4W X43 1-527-981-00 FILTER, CERAMIC (450kHz)
**************************************************************
— 96 —
TRANSFORMER
* 1-659-332-11 TRANSFORMER BOARD FL501 1-517-489-11 INDICATOR TUBE, FLUORESCENT

******************* HP101 1-500-093-11 HEAD, MAGNETIC (PLAYBACK)
HRPE101 1-500-094-11 HEAD, MAGNETIC (REC/PB/ERASE)
< CONNECTOR > M1 X-3371-223-1 MOTOR ASSY (CAPSTAN)
M2 A-2004-410-A MOTOR ASSY (TRIGGER)
* CN1600 1-564-525-11 PLUG, CONNECTOR 10P
CN1601 1-564-321-00 PIN, CONNECTOR 2P M101 X-4917-523-4 MOTOR ASSY (SPINDLE)
M102 X-4917-504-1 MOTOR ASSY (SLED)
< FUSE > M903 A-4604-363-A MOTOR (L) ASSY (LOADING)
S101 1-572-085-11 SWITCH, LEAF (LIMIT)
! F1603 1-532-503-31 FUSE,TIME-LAG (1.6A 250V) ! T1601 1-429-438-11 TRANSFORMER, POWER (AEP,UK,G,IT,EE)
(E,JE,EA,HK,SP,TW,IA)
! T1601 1-429-465-11 TRANSFORMER, POWER
< FUSE HOLDER > (E,JE,EA,HK,MY,SP,TW,IA,TH)
FH1603 1-533-223-11 HOLDER, FUSE (E,JE,EA,HK,SP,TW,IA) **************************************************************

FH1604 1-533-223-11 HOLDER, FUSE (E,JE,EA,HK,SP,TW,IA)
ACCESSORIES & PACKING MATERIALS
< TRANSFORMER > *********************************
! T1601 1-429-438-11 TRANSFORMER,POWER (AEP,UK,G,IT,EE) * 4-981-032-01 CUSHION (FRONT)

! T1601 1-429-465-11 TRANSFORMER,POWER * 4-981-033-01 CUSHION (REAR)
(E,JE,EA,HK,MY,SP,TW,IA,TH)
**************************************************************
< SWITCH >
*************
! VS1601 1-572-675-11 SWITCH, POWER VOLTAGE CHANGE HARDWARE LIST
(VOLTAGE SELECTOR)(E,JE,EA,HK,SP,TW,IA) *************
************************************************************** #1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S

#2 7-682-548-04 SCREW +BVTT 3X8 (S)
MISCELLANEOUS #3 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3
************* #4 7-621-775-10 SCREW +B 2.6X4
#5 7-621-255-15 SCREW +P 2X3
4 1-751-086-11 WIRE (FLAT TYPE)(13 CORE)(TH)
4 1-773-012-11 WIRE (FLAT TYPE)(15 CORE)(EXCEPT TH) #6 7-685-131-19 SCREW +BTP 2.6X4 TYPE2 N-S
6 1-769-946-11 WIRE (FLAT TYPE)(11 CORE) #7 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S
7 1-769-940-11 WIRE (FLAT TYPE)(11 CORE) #8 7-623-921-01 RING, RETAINING, CAPSTAN
8 1-773-158-11 WIRE (FLAT TYPE)(21 CORE) #9 7-621-775-00 SCREW +B 2.6X3
#10 7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S
9 1-776-166-11 WIRE (FLAT TYPE)(19 CORE)
52 1-537-770-21 TERMINAL BOARD, GROUND #11 7-621-770-67 SCREW +BVTT 2.6X6 (S)
! 58 1-569-007-11 ADAPTER, CONVERSION 2P (E,JE)
! 58 1-569-008-11 ADAPTER, CONVERSION 2P (EA,SP,TW,IA)
! 58 1-770-019-11 ADAPTOR, CONVERSION PLUGJ(HK)
203 1-452-719-11 MAGNET ASSY

! 301 8-848-367-11 OPTICAL PICK-UP KSS-213BA/F-NP
302 1-769-069-11 WIRE (FLAT TYPE)(16 CORE)
!CNP1601 1-575-651-11 CORD, POWER (EXCEPT UK,E,JE,TH)
! CNP1601 1-575-653-11 CORD, POWER (E,JE)
!CNP1601 1-751-326-31 CORD, POWER (TH)

! CNP1601 1-751-520-21 CORD, POWER (UK)
! F1601 1-532-504-31 FUSE, TIME LAG (4.0A 250V)
! F1602 1-532-504-31 FUSE, TIME LAG (4.0A 250V)
! F1603 1-532-503-31 FUSE, TIME LAG (1.6 A 250V)
(E,JE,EA,HK,SP,TW,IA)

specified.
— 97 —
HCD-H551
English
Sony Corporation 96C0972-1
Printed in Japan
Consumer A&V Products Company © 1996. 3
9-960-534-11 Home A&V Products Div. Published by Home A&V Products Div.
Quality Engineering Dept.
— 98 —

Service Manual: HCD-H551

Uploaded by

Document Informationclick to expand document information

Document Informationclick to expand document information

Copyright:

Available Formats

Service Manual: HCD-H551

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Service Manual: HCD-H551

Uploaded by

Copyright:

Available Formats

HCD-H551

SERVICE MANUAL AEP Model

HCD-H551 is the tuner, deck, CD and

COMPACT DISC DECK RECEIVER

Tape player section

Flexible Circuit Board Repairing

Laser component in this product is capable of emitting radiation

SAFETY-RELATED COMPONENT WARNING !!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED

Section Title Page Section Title Page

SECTION 1. SERVICING NOTE ................................ 5 SECTION 7. EXPLODED VIEWS

(AEP, UK, German, Italian, East European

(E, Saudi Arabia, Hong Kong, Malaysia,

1 VIDEO IN jacks (22)

1 Remove the connectors

5 Remove the claws

3-2. TC MECHANISM DECK

6 TC mechanism deck 5 Three screws

2 Remove the claws

1 Push the EJECT button.

*Note: It will be easy to remove if you push

3-5. CD MECHANISM DECK

3 Remove the CD mechanism

Playback Level Adjustment (Deck A, Deck B)

4. After the adjustments, apply suitable locking compound to the

3. Mode: Playback 3. Mode: Playback

main board main board

Adjustment Location: MD board Adjustment Location: MAIN board

Note: As a front-end (FE1) is difficult to repair if faulty, replace it

AM Tuned Level Adjustment

Adjustment Location: TCB board

FM RF stereo signal FE1

Procedure: RV41 IC2 TM1

Adjustment Location: TCB board FE1

Procedure: D1, CV2, T2

Set frequency Adjustment

• Repeat the procedures is each adjustment several times, and the

1.Connect oscilloscope to test point TP (RF) on BD board.

level: 1.3 ± 0.3 Vp-p

oscilloscope [BD BOARD] — Component Side —

level: 300 ± 100 mVp-p [MAIN BOARD] — Conductor Side —

6. Remove the lead wire connected in step 1.

Focus/Tracking Gain Adjustment (RV102, RV103)

This gain has a margin, so even if it is slightly off.

PANEL board MAIN board

POWER AMP board

Note: pA is including in MD board.

LEAF SWITCH board

• IC501 GRAPHIC CONTROL (ASD042)

Pin No. Pin Name I/O Function

7-1. CASE SECTION

1 4-978-836-01 PANEL, LOADING * 5 A-4303-518-A TCB BOARD (E,EA,HK,MY,SP,TW)

108 FL501 113

111 3-354-957-01 JOINT (LOCK LEVER)

157 X-4946-707-1 BUTTON (TC-PLAY) ASSY

* 207 4-960-839-01 CAM

The components identified by