Service: Manual
Service: Manual
Chassis Model
MJ15AS* 510N
MJ15BS* 510T
MJ17AS* 710N
MJ17BS* 710T
MJ19AS* 910N
MJ19BS* 910T
SERVICE Manual
TFT-LCD MONITOR CONTENTS
1. Precautions
2. Product Specifications
5. Troubleshooting
8. Block Diagram
9. Wiring Diagram
Pivot Stand
1-1-1 Warnings
1. For continued safety, do not attempt to modify the
(READING SHOULD
circuit board. NOT BE ABOVE 0.5mA)
Before returning the monitor to the user, perform the Figure 1-1. Leakage Current Test Circuit
following safety checks:
1. Inspect each lead dress to make certain that the 4. With the unit completely reassembled, plug the AC
leads are not pinched or that hardware is not line cord directly into a 120V AC outlet. With the
lodged between the chassis and other metal parts in unit’s AC switch first in the ON position and then
the monitor. OFF, measure the current between a known earth
2. Inspect all protective devices such as nonmetallic ground (metal water pipe, conduit, etc.) and all
control knobs, insulating materials, cabinet backs, exposed metal parts, including: metal cabinets,
adjustment and compartment covers or shields, screwheads and control shafts. The current
isolation resistor-capacitor networks, mechanical measured should not exceed 0.5 milliamp. Reverse
insulators, etc. the power-plug prongs in the AC outlet and repeat
3. Leakage Current Hot Check (Figure 1-1): the test.
WARNING:
Do not use an isolation transformer during this test. 1-1-4 Product Safety Notices
Use a leakage current tester or a metering system Some electrical and mechanical parts have special
that complies with American National Standards safety-related characteristics which are often not
Institute (ANSI C101.1, Leakage Current for evident from visual inspection. The protection they give
Appliances), and Underwriters Laboratories (UL may not be obtained by replacing them with
Publication UL1410, 59.7). components rated for higher voltage, wattage, etc. Parts
that have special safety characteristics are identified by
! on schematics and parts lists. A substitute
replacement that does not have the same safety
characteristics as the recommended replacement part
might create shock, fire and/or other hazards. Product
safety is under review continuously and new
instructions are issued whenever appropriate.
MJ15AS*/MJ17AS*/MJ19AS*/ 1-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
1 Precautions
1. Immediately before handling any semiconductor 6. Do not remove a replacement ESD from its
components or assemblies, drain the electrostatic protective package until you are ready to install it.
charge from your body by touching a known earth Most replacement ESDs are packaged with leads
ground. Alternatively, wear a discharging wrist- that are electrically shorted together by conductive
strap device. To avoid a shock hazard, be sure to foam, aluminum foil or other conductive materials.
remove the wrist strap before applying power to 7. Immediately before removing the protective
the monitor. material from the leads of a replacement ESD,
2. After removing an ESD-equipped assembly, place it touch the protective material to the chassis or
on a conductive surface such as aluminum foil to circuit assembly into which the device will be
prevent accumulation of an electrostatic charge. installed.
3. Do not use freon-propelled chemicals. These can Caution: Be sure no power is applied to the
generate electrical charges sufficient to damage chassis or circuit and observe all
ESDs. other safety precautions.
4. Use only a grounded-tip soldering iron to solder or
desolder ESDs. 8. Minimize body motions when handling
unpackaged replacement ESDs. Motions such as
5. Use only an anti-static solder removal device. Some brushing clothes together, or lifting your foot from
solder removal devices not classified as “anti-static” a carpeted floor can generate enough static
can generate electrical charges sufficient to damage electricity to damage an ESD.
ESDs.
1-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
2 Product Specifications
2-1 MJ15AS*/MJ15BS*/MJ17AS*/MJ17BS* Specifications
Description
Item
MJ15AS*/MJ15BS* MJ17AS*/MJ17BS*
LCD Panel TFT-LCD panel, RGB vertical stripe, normally black transmissive, TFT-LCD panel, RGB vertical stripe, normally black transmissive,
15-Inch viewable, 0.297 (H) x 0.297 (V) mm pixel pitch 17-Inch viewable, 0.264 (H) x 0.264 (V) mm pixel pitch
Scanning Frequency Horizontal : 31 kHz ~ 61 kHz (Automatic) Horizontal : 30 kHz ~ 81 kHz (Automatic)
Vertical : 50 Hz ~ 75 Hz Vertical : 56 Hz ~ 75 Hz
Active Display
Horizontal/Vertical 304.1 mm / 228.1 mm 338 ± 3 mm / 270 ± 3 mm
AC power voltage & Frequency AC 90 ~ 264 Volts, 60/50 Hz ± 12V / 3A AC 90 ~ 264 Volts, 60/50 Hz ± 3 Hz
Set (W x D x H) 13.3 x 2.2 x 10.7 Inches (338.0 x 56.3 x 272.0 mm) State of stand disassembled 14.6 x 2.4 x 12.4 Inches (370.0 x 60.3 x 316.0 mm) State of stand disassembled
13.3 x 6.9 x 13.3 Inches (338.0 x 175.0 x 337.0 mm) State of stand installed 14.6 x 6.9 x 15 Inches (370.0 x 175.0 x 381.0 mm) State of stand installed
Package 15.3 x 4.9 x 15.1 Inches (388 x 125 x 383 mm) 17.9 x 5.6 x 17.2 Inches (455 x 141 x 437 mm)
Weight (Set/Package) 3.1 kg (6.8 lbs) / 4.25 kg (9.4 lbs) 4.5 kg (9.9 lbs) / 6.15 kg (13.6 lbs)
Dimensions Pivot Stand
Set (W x D x H) - 14.6 x 2.4 x 12.4 Inches (370.0 x 60.3 x 316.0 mm) State of stand disassembled
14.6 x 7.5 x 16.0 Inches (370.0 x 190.9 x 406.8 mm) State of stand installed
Package 20.0 x 10.1 x 16.0 Inches (508 x 256 x 407 mm)
Weight (Set/Package) - 6.25 kg (13.8 lbs) / 7.95 kg (17.5 lbs)
MJ15AS*/MJ17AS*/MJ19AS*/ 2-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
2 Product Specifications
Item Description
LCD Panel TFT-LCD panel, RGB vertical stripe, normally black transmissive,
19-Inch viewable, 0.297 (H) x 0.297 (V) mm pixel pitch
Active Display
Horizontal/Vertical 376.32 mm ± 3 mm / 301.056 mm ± 3 mm
Set (W x D x H) 16.4 x 2.4 x 13.8 Inches (416.6 x 60.2 x 349.4 mm) State of stand disassembled 16.4 x 2.4 x 13.8 Inches (416.6 x 60.2 x 349.4 mm) State of stand disassembled
16.4 x 7.7 x 16.7 Inches (416.6 x 195.7 x 424.6 mm) State of stand installed 16.4 x 7.5 x 16.7 Inches (416.6 x 190.9 x 423.4 mm) State of stand installed
Package 20.0 x 5.9 x 19.4 Inches (509 x 150 x 494 mm) 21.1 x 9.4 x 17.4 Inches (535 x 238 x 443 mm)
Weight (Set/Package) 5.85 kg (12.9 lbs) / 7.8 kg (17.2 lbs) 7.30 kg (16.1 lbs) / 9.1 kg (20.1 lbs)
Environmental Considerations Operating Temperature : 50°F ~ 104°F (10°C ~ 40°C)
Operating Humidity : 10 % ~ 80 %
Storage Temperature : -13°F ~ 113°F (-25°C ~ 45°C)
Storage Humidity : 5 % ~ 95 %
2-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
2 Product Specifications
Sync
Type 24P DVI-D
Pin No.
1 Rx2- 13 No Connection
2 Rx2+ 14 +5V_M
3 GND 15 Self Raster
4 No Connection 16 +5V_M
5 No Connection 17 Rx0-
6 DDC Clock (SCL) 18 Rx0+
7 DDC Data (SDA) 19 NC
8 NC 20 No Connection
9 Rx1- 21 No Connection
10 Rx1+ 22 NC
11 NC 23 RxC+
12 No Connection 24 RxC-
MJ15AS*/MJ17AS*/MJ19AS*/ 2-3
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
2 Product Specifications
This section of the service manual describes the timing that the computer industry recognizes as standard
for computer-generated video signals.
fH (kHz) 31.469 31.469 37.500 37.879 46.875 48.363 60.023 63.981 79.975
A µsec 31.777 31.778 26.667 26.400 21.333 20.677 16.660 11.852 12.504
B µsec 3.813 3.813 2.032 3.200 1.616 2.092 1.219 1.037 1.067
C µsec 1.589 1.589 3.810 2.200 3.232 2.462 2.235 2.296 1.837
D µsec 26.058 26.058 20.317 20.000 16.162 15.754 13.003 9.259 9.481
E µsec 0.318 0.318 0.508 0.000 0.323 0.369 0.203 0.000 0.119
fV (Hz) 70.087 59.940 75.000 60.317 75.000 60.004 75.029 60.020 75.025
O msec 14.268 16.683 13.333 16.579 13.333 16.666 13.328 16.005 13.329
P msec 0.064 0.064 0.080 0.106 0.064 0.124 0.050 0.047 0.038
Q msec 0.858 0.794 0.427 0.607 0.448 0.600 0.466 0.594 0.475
R msec 13.155 15.761 12.800 15.840 12.800 15.880 12.795 15.630 12.804
S msec 0.191 0.064 0.027 0.0261 0.021 0.062 0.017 0.016 0.013
Clock
Freq. 28.322 26.175 31.500 40.000 49.500 75.000 78.750 108.000 135.000
(MHz)
Polarity
H.Sync Negative Negative Negative Positive Positive Negative Positive Positive Positive
V.Sync Positive Negative Negative Positive Positive Negative Positive Positive Positive
Remark Separate Separate Separate Separate Separate Separate Separate Separate Separate
Sync-on-Green
Sync
Sync Sync
Sync Vertical
Green
BB PP
Horizontal
AA O O P Q R S
B O
A : Line time total B : Horizontal sync width O : Frame time total P : Vertical sync width
2-4 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
3 Disassembly and Reassembly
This section of the service manual describes the disassembly and reassembly procedures for the
MJ15AS*/MJ17AS*/MJ19AS*/MJ15BS*/MJ17BS*/MJ19BS* TFT-LCD monitors.
WARNING: This monitor contains electrostatically sensitive devices. Use caution when handling
these components.
3-1 Disassembly
Cautions:1. Disconnect the monitor from the power source before disassembly.
2. Follow these directions carefully; never use any metal instrument except provided jig to
separate the cabinet.
3. R/Cover opening jig : BH81-00001A
MJ15AS*/MJ17AS*/MJ19AS*/ 3-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
3 Disassembly and Reassembly
3-2 Reassembly
3-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
4 Alignments and Adjustments
This section of the service manual explains how to use the RS232 JIG.
This function is needed for AD board change and program memory (IC110) change.
Figure 1.
❇ Note : Please be sure to read the following instructions for details on service function.
MJ15AS*/MJ17AS*/MJ19AS*/ 4-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
4 Alignments and Adjustments
Panel Information
Softward Version
Checksum
Figure 3.
4-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
4 Alignments and Adjustments
Figure 4.
Figure 5, 6.
MJ15AS*/MJ17AS*/MJ19AS*/ 4-3
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
4 Alignments and Adjustments
Memo
4-4 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
5 Troubleshooting
Yes
Yes
Yes
Yes
MJ15AS*/MJ17AS*/MJ19AS*/ 5-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
5 Troubleshooting
Yes
Yes
Yes
5-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
5 Troubleshooting
No
1 X400 oscillate properly? Replace or check related circuit.
Yes
Yes
Yes
Yes
Yes
Yes
MJ15AS*/MJ17AS*/MJ19AS*/ 5-3
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
5 Troubleshooting
WAVEFORMS
1 2
5-4 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
5 Troubleshooting
No
1 X400 oscillate properly? Replace or check related circuit.
Yes
Is there R, G, B input at No
4 5 6 Check input part.
R110, R112, R114, R111,
R113 and R115?
Yes
Is there waveform No
7 Check input part.
at R11, R117?
Yes
Yes
Yes
MJ15AS*/MJ17AS*/MJ19AS*/ 5-5
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
5 Troubleshooting
WAVEFORMS
1 2
3 4
5 6
5-6 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
6 Exploded View and Parts List
❈ You can search for updated part codes through ITSELF web site.
URL : http://itself. sec. samsung.co.kr
6-1 MJ15AS*
MJ15AS*/MJ17AS*/MJ19AS*/ 6-1
MJ15BS*/MJ17BS*/MJ19BS*
6-2 MJ15BS*
6-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
6-3 MJ17AS*
MJ15AS*/MJ17AS*/MJ19AS*/ 6-3
MJ15BS*/MJ17BS*/MJ19BS*
6-4 MJ17BS*
6-4 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
6-5 MJ19AS*
MJ15AS*/MJ17AS*/MJ19AS*/ 6-5
MJ15BS*/MJ17BS*/MJ19BS*
6-6 MJ19BS*
6-6 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
0 MJ15AS
1 E27-MJ15AS - 1 SEC,LTM150XO-L01 -
3 BN94-00527D - ASSY PCB MAIN MJ15AS SNA
4 0204-002420 CIS3 SOLVENT 1M-1000,C3H70H,96,-,- SNA
4 0204-002426 CIS4 FLUX DF-201TVS,MIX,0.820,FLUX13%,14KG,- SNA
4 3701-001219 CN101 CONNECTOR-DSUB 15P,3R,FEMALE,ANGLE,AUF SA
4 3711-004712 CN600 CONNECTOR-HEADER BOX,9P,1R,2mm,STRAIGHT,SN SA
4 6003-000117 IP/PCB+BRKT/PCB SCREW-TAPTITE BH,+,B,M3,L6,ZPC(YEL),SWRCH18A SNA
4 6003-000117 M/PCB+BRKT/PCB SCREW-TAPTITE BH,+,B,M3,L6,ZPC(YEL),SWRCH18A SNA
4 BN97-00354K MICOM ASSY MICOM GS17VS SA
5 0903-001347 IC200 IC-MICROCONTROLLER NT68F63GL,8Bit,PLCC,44P,653MIL,12MHz,ST,-,PLASTIC,5.000000V,-,-0to+70C,256B,-,-, SNA
5 BN82-00114L CIS A/S MICOM GS17VS SNA
4 BN97-00358T - ASSY SMD MJ15AS SNA
5 3301-000314 BD100 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD101 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD102 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD103 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD104 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD105 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 2703-001334 BD106 INDUCTOR-SMD 1.5uH,10%,2012 SA
5 3301-000314 BD200 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD201 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 2203-005005 C100 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C101 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C102 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C103 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C104 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C105 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-000257 C106 C-CER,CHIP 10nF,10%,50V,X7R,TP,1608 SA
5 2203-005005 C110 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C112 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C114 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-000236 C116 C-CER,CHIP 0.1NF,5%,50V,C0G,TP,1608 SA
5 2203-000998 C117 C-CER,CHIP 0.047NF,5%,50V,C0G,TP,1608 SA
5 2203-005005 C200 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005437 C201 C-CER,CHIP 10000nF,+80-20%,10V,Y5V,TP,3216 SA
5 2203-005005 C203 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005437 C205 C-CER,CHIP 10000nF,+80-20%,10V,Y5V,TP,3216 SA
5 2203-005065 C206 C-CER,CHIP 1000nF,+80-20%,10V,Y5V,-,1608 SA
5 2203-000257 C221 C-CER,CHIP 10nF,10%,50V,X7R,TP,1608 SA
5 2203-000257 C222 C-CER,CHIP 10nF,10%,50V,X7R,TP,1608 SA
5 2203-000189 C224 C-CER,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, SA
5 2203-005005 C400 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2402-001042 C401 C-AL,SMD 100uF,20%,16V,GP,TP,6.6x6.6x5.4mm SA
5 2203-005005 C402 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C403 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C404 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C405 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C406 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C407 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C408 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C409 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C410 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C411 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C412 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C413 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C414 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C415 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-000426 C416 C-CER,CHIP 0.018NF,5%,50V,C0G,TP,1608 SA
5 2203-000257 C417 C-CER,CHIP 10nF,10%,50V,X7R,TP,1608 SA
5 2203-000426 C418 C-CER,CHIP 0.018NF,5%,50V,C0G,TP,1608 SA
5 2203-005005 C419 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C420 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C421 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2402-000108 C422 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4 SA
MJ15AS*/MJ17AS*/MJ19AS*/ 7-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
7-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
MJ15AS*/MJ17AS*/MJ19AS*/ 7-3
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
0 MJ17ASAB
1 E23-MJ17ASAB - 1 SEC,LTM170EU-L11 -
3 BN94-00527C - ASSY PCB MAIN MJ17AS SNA
4 0204-002420 CIS3 SOLVENT 1M-1000,C3H70H,96,-,- SNA
4 0204-002426 CIS4 FLUX DF-201TVS,MIX,0.820,FLUX13%,14KG,- SNA
4 3701-001219 CN101 CONNECTOR-DSUB 15P,3R,FEMALE,ANGLE,AUF SA
7-4 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
MJ15AS*/MJ17AS*/MJ19AS*/ 7-5
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
7-6 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
MJ15AS*/MJ17AS*/MJ19AS*/ 7-7
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
0 MJ19ASAB/XSH
1 E10-MJ19ASAB/XSH - 1 LTM190E1-L02 -
3 BN94-00516T - ASSY PCB MAIN-E10/E17 GS19VS/MJ19AS SNA
4 0204-002420 CIS3 SOLVENT 1M-1000,C3H70H,96,-,- SNA
4 0204-002426 CIS4 FLUX DF-201TVS,MIX,0.820,FLUX13%,14KG,- SNA
4 BN63-00995A CIS8 GASKET GY17MS,CONDUCTIVE FAB,4MM,15MM,100MM,GRAY,32K,71TSSK-15-4-100-13 SNA
4 3701-001219 CN101 CONNECTOR-DSUB 15P,3R,FEMALE,ANGLE,AUF SA
4 3711-004712 CN600 CONNECTOR-HEADER BOX,9P,1R,2mm,STRAIGHT,SN SA
4 6003-000117 IP/PCB+BRKT/PCB SCREW-TAPTITE BH,+,B,M3,L6,ZPC(YEL),SWRCH18A SNA
4 6003-000117 M/PCB+BRKT/PCB SCREW-TAPTITE BH,+,B,M3,L6,ZPC(YEL),SWRCH18A SNA
4 BN97-00354K MICOM ASSY MICOM GS17VS SA
5 0903-001347 IC200 IC-MICROCONTROLLER NT68F63GL,8Bit,PLCC,44P,653MIL,12MHz,ST,-,PLASTIC,5.000000V,-,-0to+70C,256B,-,-, SNA
5 BN82-00114L CIS A/S MICOM GS17VS SNA
4 BN97-00358G - ASSY SMD GS17VS/17VT/GS19VT SNA
5 3301-000314 BD100 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD101 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD102 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD103 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD104 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD105 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 2703-001334 BD106 INDUCTOR-SMD 1.5uH,10%,2012 SA
5 3301-000314 BD200 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 3301-000314 BD201 BEAD-SMD 120ohm,1.6x0.8x0.8mm,150mA,,,,40000ohm SNA
5 2203-005005 C100 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C101 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C102 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C103 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C104 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C105 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-000257 C106 C-CER,CHIP 10nF,10%,50V,X7R,TP,1608 SA
5 2203-005005 C110 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
5 2203-005005 C112 C-CER,CHIP 100nF,10%,16V,X7R,TP,1608 SA
7-8 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
MJ15AS*/MJ17AS*/MJ19AS*/ 7-9
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
7-10 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
MJ15AS*/MJ17AS*/MJ19AS*/ 7-11
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
7 Electrical Parts List
* Refer to Chapter 6 Exploded View and Parts List for All Models Different Mechanically Part List.
7-12 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
8 Block Diagram
8-1 MJ15AS*/MJ17AS*/MJ19AS* ANALOG Block Diagram
C
D
P
A
N
E
L
L
IM A GE SCA L ER/ L V DS
(SE7889)
M ICOM
A DC/
12MHz
+ 0~ 3.3
(ON)+ 5V
IP BOARD
IN V ERT ER
+ 13V
+ 13V
+ 5V
+ 5V
R
G
B
H- sy nc
V - sy nc
M
S
S
P
MJ15AS*/MJ17AS*/MJ19AS*/ 8-1
MJ15BS*/MJ17BS*/MJ19BS*
Downloaded from www.Manualslib.com manuals search engine
8-2
8 Block Diagrams
(PC)DIGIT AL
RX2+ RX2- RX1+ RX1- RX0+ RX0- RXC+ RXC-
R
G
S + 0~ 3.3
(ON)+ 5V
M ICOM
IP BOARD
IN V ERT ER
MJ15BS*/MJ17BS*/MJ19BS*
MJ15AS*/MJ17AS*/MJ19AS*/
10 PCB Layout
10-1 MJ15AS* ANALOG PCB
MJ15AS*/MJ17AS*/MJ19AS*/ 10-1
MJ15BS*/MJ17BS*/MJ19BS*
IC
IC101 IC-EEPROM 15.8 23.6
IC105 DIODE-TVS 55.0 14.0
IC106 DIODE-TVS 110.7 12.9
IC107 DIODE-TVS 11.0 9.6
IC200 IC-MICROCONTROLLER 96.6 30.9
IC201 IC-EEPROM 95.2 8.5
IC400 IC-LCD CONTROLLER 56.0 46.9
IC600 FET-SILICON 27.5 55.8
IC601 IC-DUAL VOLTAGE REGULATOR 17.4 35.5
IC602 IC-VOLTAGE REGULATOR 12.8 56.1
TRANSISTOR
10-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
MJ15AS*/MJ17AS*/MJ19AS*/ 10-3
MJ15BS*/MJ17BS*/MJ19BS*
IC
IC101 IC-EEPROM 15.8 23.6
IC105 DIODE-TVS 55.0 14.0
IC106 DIODE-TVS 110.7 12.9
IC107 DIODE-TVS 11.0 9.6
IC200 IC-MICROCONTROLLER 96.6 30.9
IC201 IC-EEPROM 95.2 8.5
IC400 IC-LCD CONTROLLER 56.0 46.9
IC600 FET-SILICON 27.5 55.8
IC601 IC-DUAL VOLTAGE REGULATOR 17.4 35.5
TRANSISTOR
Q100 TR-SMALL SIGNAL 7.0 21.1
10-4 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
MJ15AS*/MJ17AS*/MJ19AS*/
+5V
+5V
GND
GND
GND
+14V
+14V
BL_EN
ADJ_BL
RX2-
RX2+
GND
CN102
NC
NC
DDC_SCL
CN600
DDC_SDA
NC
RX1-
RX1+
GND
NC
NC
CN400
GND
RxE3-
RXC+ GND
RXC- RxEC+
RxEC-
GND
RxE2+
RxE2-
GND
RED_IN
RxE1+
GREEM_IN
BLUE_IN RxE1-
CN101
GND
GND
RxE0+
GND
RxE0-
R_GND
RxO3+
G_GND
RxO3-
B_GND
RxOC+
NC
RxOC-
CHK_DSUB
GND
GND RxO2+
SDA_DDC
RxO2-
HSYNC_IN
RxO1+
VSYNC_IN RxO1-
SCL_DDC RxO0+
RxO0-
+5v
+5v
+5v
VCC
LED_GRN
NC
CN200
Key 2
Key 1
GND
9-1
9 Wiring Diagram
Memo
9-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*
Vcc_PANEL_IN R200
0
1/16W
15" : +3.3V In
4.7K
4.7K
OEM OPTION
4.7K
RxOC+
RxEC+
RxO0+
RxO1+
RxO2+
RxOC-
RxE2+
RxE3+
RxEC-
RxO0-
RxO1-
RxO2-
RxE2-
RxE3-
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
4.7K
RxO3+
RxE0+
RxE1+
RxO3-
RxE0-
RxE1-
10K
10K
1/16W
GND
GND
GND
GND
GND
GND
NC
1/16W
5V
5V
5V
1/16W
470
R246
C201 C200
100nF
Vcc_PANEL CN400 OEM OPTION 10000nF M/M OPTION
R203
R214
R205
R208
R209
R206
R207
R210
R212
R211
16V
R204
R216
R217
10V
4.7K
MGND2 MGND1
10K
12505WR-30A01
1K
GOYA 2 M/M Only (Option) MO
+5V(17"/19")/+3.3V(15") R213
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
10
11
9
8
7
6
5
4
3
2
1
10K
1/16W
+14V_IN
R202
R600
+14V_AUDIO
R241
R221
R238
10K 470
1/16W R250
0
AUDIO_EN C401 1/16W
M/M OPTION
C600
IC600 100uF AUDIO_EN
1uF R220 4.7K
Q600 10V SUPLECODE M/M OPTION
C400 R400 PANEL_EN
B
HC-49/S-SMD(12MHz,30ppm)
10K
E
2 D1_1 7 4.7K
G1 16V
3 6 MO R218 100 1/16W VSYNC_IN_A
R601 S2 D2
4 D2_1 5
15K G2 HSYNC_IN_A
R215 100 1/16W
X200 CHK_DSUB
C205 CHK_DVI
Q0
C204 10000nF
50V AUDIO_VOL
C601 22pF 10V
R602 C602 MO R245 4.7K R249
100uF MO R248
M/M OPTION
10K 25V 10nF 0
Q1
C603 6 5 4 3 2 1 44 43 42 41 40 24Kohm
1/16W 50V C208 C202 1/16W 1/10W
1uF C207 C206
100nF
V33
HSYNCI
PC4
PC5
VSYNCI
Audio Line(25V Cap)
RSTB
MO
CVV
100nF 1uF
PC0
PC1
PC2
PC3
Reserved 22pF 7 39
GND NC2 25V 25V
8 38
OSCO NC1
PANEL_EN
GOYA 2 M/M Only (Option) +3.3V_MAIN XTL_OUT
9
10
OSCI PC6
37
36 NVRAM_CON
P30 PC7
11 35 DDC_CON
R225 100 12
P31 IC200 PD0
34 BL_EN
WR P34 PD1
R226 100 13 33
PB7
PB6
PB5
PB4
PA7
PA6
PA5
PA4
PA3
PA2
PA1
MST9131B
R231 100
ALE
18 19 20 21 22 23 24 25 26 27 28
R237 100
R233
AD0
+14V_IN +5V_IN 3Kohm
16V
100nF
1/10W
C402
SCL_DDC_D
ADJ_BL R234 100
C403 C405 C406 C404 R243 470 1/16W SDA_DDC_D
LVBCKM
LVBCKP
AVSS_MPLL
GNDP
GNDC
LVACKM
VDDP
VDDC
GNDP
GNDP
GNDP
VDDP
LVACKP
LVB0M
LVB1M
LVB2M
LVB3M
VDDP
LVB0P
LVB1P
LVB2P
LVB3P
LVA0M
LVA1M
LVA2M
LVA3M
LVA0P
LVA1P
LVA2P
LVA3P
1
C416 NC AD1
91 40
To IP Board
TP601 1 18pF NC NC
3 92 39
AD0 AD0 NC
ZD600
5 96 35 MO
AVDD_MPLL RIZ_SCL RD 1 1/16W
6
TP602 1
X400 97
98 AVSS_MPLL
HSYNC0
WRZ_SDA
34
ALE_CS 33
WR
ALE
2
8
7 R247 100 NVRAM_CON
AVDD_PLL
Q1
AVDD_DVI
AVDD_DVI
AVSS_PLL
AVSS_DVI
AVSS_DVI
AVSS_DVI
3
99 32 6
SCL_MCU
VSYNC0
AVSS
SOGIN0
RINOM
7 100 4 5 100
GIN0M
RINOP
31
BIN0M
R223
GIN0P
BIN0P
REFM
AVDD
AVDD
REXT
REFP
AVSS
AVSS
HC-49/S-SMD(12MHz,30ppm)
+3.3V_MAIN +3.3V_MAIN SDA_MCU
CK+
CK-
C418
G+
R+
B+
G-
R-
TP603
B-
8 1
ADJ_BL 18pF R224 100
10
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
11
1
2
3
4
5
6
7
8
9
TP604 50V
9 1
BL_EN +3.3V_MAIN C419
100nF
slcon9p C606 R603 C420
C605 16V
CN600 100
1uF 100nF 100nF
1/16W
10V 16V 16V
MO C421
100nF
16V GOYA 2 M/M Only (Option)
2 A_GND
1
2
N.C.
VC1
OUT1+ 15
16 TP500 1
slcon9p
1
D600 GF1G/17
1 VOUT1
GND
8 C609 C608 AUDIO_VOL 3
N.C.
N.C. 14 TP501 1 2
PGND1
2
VIN GND 7 100uF 100nF R504 51Kohm C502 1uF 4 VI(1) 13
3
C607
3
VIN GND
6
100uF
AMP_R 1/10W 5
VP
OUT1- 12
OUT2-
TP502 1 3
*Drop Voltage* 4 5 R505 51Kohm C503 1uF 6 VI(2) 11
0.8Vmax
GND
VOUT2 16V AMP_L 1/10W 7 SGND N.C. 10
PGND2
TP503 1
4
IC601 8 VC2 9
OUT2+ TP504 1 5
C610 R501 1201-001805
C104 C105 C101 C102 C103 C100 5.1K
100nF R500 R506 TP505 1 6
100nF 100nF 100nF 100nF 100nF 100nF
APL5522KCTR
16V 16V 16V 16V 16V 16V
1/16W
5.1K
24Kohm
1/10W
AMP_R
TP506 1 7
RXC-
RX2-
RX0-
RX1-
10nF
R502 0 A_GND
A_GND
UDZS5.6B-TE-17
1
5.2V ~ 6.0V
FT600 C107
C108 C109 R503 0
A 1
15pF
D100
15pF SOG
15pF
1/10W
1/10W
22ohm 1/10W
22ohm 1/10W
1/10W
1/10W
1/10W
1/10W
B
MO D101
5 MO R106
17"/19" Only(Option) +3.3V_MAIN MO
390ohm MMBD4148SE
6
R108
22ohm
22ohm
22ohm
22ohm
R109 R107
22ohm
22ohm
75ohm
4 75ohm 75ohm
A_GND
B 2
C
3
C110
HSYNC_IN_A
VSYNC_IN_A
IC602
SDA_DDC_A
SCL_DDC_A
CHK_DSUB
100nF
AP1117D-33A D102
1
A
UDZS5.6B-TE-17
3 4 16V
MMBD4148SE
R110
R112
R113
R114
R115
R116
R117
OUT
R111
IN
G+IN_A
R+IN_A
B+IN_A
G-IN_A
R-IN_A
B-IN_A
C111
1 B 2
GND
3
D114
100nF
B 2
C611
C
3
1
C612 16V
A
100uF
RX1+
RX0+
RX0-
RXC+
RXC-
RX2+
RX2-
RX1-
HSYNC_IN_A
VSYNC_IN_A
100uF MO
7
SDA_DDC_D
SCL_DDC_D
D103
A
16V
15" Only(Option) C112
D104 MMBD4148SE
CHK_DVI
100nF
C
B 2
16V
C113 MMBD4148SE VCC_MCU
1
A
100nF
1 B 2
16V
3
C
MO
D105
A
MMBD4148SE
100
75
75
D106
+5V_DDC_D
100
C114
1 B 2
C115
C
3
C119 50V
G-IN_A
B+IN_A
G+IN_A
50V
R+IN_A
50V 50V
B-IN_A
R118
R-IN_A
R119
MO
R120
100nF
R121
MO MO MO CN200
To Function PCB
16V
MO 12507WR-06L
1
TP200
1K
D107 1
TP201
1 B 2
LED_GREEN 1
C
R124
D108
+5V_DDC_D +5V_IN C224 C221
10nF
C222
10nF
1
1 B 2
100nF
3
C123
C
50V 50V
UDZS5.6B-TE-17
25V
C2
C1
C2
C1
A1
A1
100nF MMBD4148SE
3
MO MO
A
16V MO
ZD200
MO D110 D109
UDZS5.6B-TE-17 UDZS5.6B-TE-17
IC107
1
D111MMBD4148SE R125 B A B 2
C2
C1
A1
MMQA5V6T3
3
C125 1K 2 A
1
C3
1 B 2
1/16W
C
100nF
1
C4
C4
3
A2
A2
4
6
1
16V IC106
1
1
7
15K 15K
*Operating Range* 16V 5.32V ~ 5.88 MMQA5V6T3
1 8 1/16W 1/16W
C4
A2
10
MO
4
6
12
13
14
15
11
1
9
2
2 7
C3
5 d_sub15p
C
B 2
4
3
100nF
SDA_DDC_D
16V MMBD4148SE
TP43
U2
1
A
C
3
100nF
TP49
TP48
TP41
10K
TP40
TP39
TP44
16V
1/16W
MO
D115
C
19
14
11
B
17
10
18
12
20
13
21
22
15
23
16
1
7
9
24
25
26
4
DDC_CON
R132
E Q100
2SC2412K-Q 100
CN102
DVI-D SUB
tpcon26p
MJ15AS*/MJ17AS*/MJ19AS*/ 11-1
MJ15BS*/MJ17BS*/MJ19BS*
1 2 3 4
5 6 7
11-2 MJ15AS*/MJ17AS*/MJ19AS*/
MJ15BS*/MJ17BS*/MJ19BS*