Page 1/8

Safety data sheet

according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

SECTION 1: Identification of the substance/mixture and of the company/

undertaking
· 1.1 Product identifier
· Trade name: MANNOL 7715 Longlife 504/507
· UFI: ACCP-90NG-400G-VJ5X
· 1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
· Application of the substance / the mixture Lubricant
· 1.3 Details of the supplier of the safety data sheet
· Manufacturer/Supplier:
UAB "SCT Lubricants"
Silutes Pl. 119
LIT-95112 KLAIPEDA
LITHUANIA
renata@sct.lt
· Further information obtainable from: Product safety department.
· 1.4 Emergency telephone number:
Members of the public seeking specific information on poisons should contact:
In England and Wales: NHS 111 - dial 111
In Scotland: NHS 24 - dial 111

SECTION 2: Hazards identification

· 2.1 Classification of the substance or mixture
· Classification according to Regulation (EC) No 1272/2008
The product is not classified, according to the CLP regulation.
· 2.2 Label elements
· Labelling according to Regulation (EC) No 1272/2008 Void
· Hazard pictograms Void
· Signal word Void
· Hazard statements Void
· Precautionary statements
P102 Keep out of reach of children.
P273 Avoid release to the environment.
P280 Wear protective gloves/protective clothing/eye protection/face protection/hearing protection.
P391 Collect spillage.
P501 Dispose of contents/container in accordance with local/regional/national/international regulations.
· 2.3 Other hazards
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.

SECTION 3: Composition/information on ingredients

· 3.2 Mixtures
· Description: Mixture of substances listed below with nonhazardous additions.
· Dangerous components: Void
(Contd. on page 2)
IE

56.0.13
 Page 2/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 1)
· Not dangerous substances
CAS: 64742-54-7 A complex combination of hydrocarbons obtained by treating a <47.0%
EINECS: 265-157-1 petroleum fraction with hydrogen in the presence of a catalyst.
CAS: 74869-22-0 Lubricating oils <44.0%
EINECS: 278-012-2
CAS: 31261-08-2 Alkyl acrylate - alkyl methacrylate copolymer <6.0%
EC number: 833-063-5
CAS: 122-62-3 bis(2-ethylhexyl) sebacate 1.0%
EINECS: 204-558-8
EC number: 701-251-5 Phenol, paraalkylation products with C10-15 branched olefins (C12 <1.0%
rich) derived from propene oligomerization, carbonates, calcium
salts, overbased, sulfurized, including distillates (petroleum),
hydrotreated, solvent-refined, solvent-dewaxed, or catalytic dewaxed,
light or heavy paraffinic C15-C50
Aquatic Chronic 4, H413
CAS: 4259-15-8 2-ethylhexyl zinc dithiophosphate <0.5%
EINECS: 224-235-5 Eye Dam. 1, H318; Aquatic Chronic 2, H411
CAS: 84605-29-8 Salt of zincditio acid <0.5%
EINECS: 283-392-8 Eye Dam. 1, H318; Aquatic Chronic 2, H411; Skin Irrit. 2, H315
· Additional information: For the wording of the listed hazard phrases refer to section 16.

SECTION 4: First aid measures

· 4.1 Description of first aid measures
· General information: No special measures required.
· After inhalation: Supply fresh air; consult doctor in case of complaints.
· After skin contact: Generally the product does not irritate the skin.
· After eye contact: Rinse opened eye for several minutes under running water.
· After swallowing: If symptoms persist consult doctor.
· 4.2 Most important symptoms and effects, both acute and delayed
No further relevant information available.
· 4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.

SECTION 5: Firefighting measures

· 5.1 Extinguishing media
· Suitable extinguishing agents:
CO2. Do not use water.
Use fire extinguishing methods suitable to surrounding conditions.
Foam
Fire-extinguishing powder
Sand
· For safety reasons unsuitable extinguishing agents: Water
· 5.2 Special hazards arising from the substance or mixture No further relevant information available.
· 5.3 Advice for firefighters
· Protective equipment: No special measures required.
(Contd. on page 3)
IE

56.0.13
 Page 3/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 2)
· Additional information
Dispose of fire debris and contaminated fire fighting water in accordance with official regulations.

SECTION 6: Accidental release measures

· 6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation
Particular danger of slipping on leaked/spilled product.
Wear protective clothing.
· 6.2 Environmental precautions:
Do not allow product to reach sewage system or any water course.
Inform respective authorities in case of seepage into water course or sewage system.
Do not allow to enter sewers/ surface or ground water.
· 6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Dispose contaminated material as waste according to item 13.
· 6.4 Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.

SECTION 7: Handling and storage

· 7.1 Precautions for safe handling No special measures required.
· Information about fire - and explosion protection: No special measures required.
· 7.2 Conditions for safe storage, including any incompatibilities
· Storage:
· Requirements to be met by storerooms and receptacles: No special requirements.
· Information about storage in one common storage facility: Not required.
· Further information about storage conditions: None.
· 7.3 Specific end use(s) No further relevant information available.

SECTION 8: Exposure controls/personal protection

· 8.1 Control parameters
· Ingredients with limit values that require monitoring at the workplace:
The product does not contain any relevant quantities of materials with critical values that have to be
monitored at the workplace.
· Additional information: The lists valid during the making were used as basis.
· 8.2 Exposure controls
· Appropriate engineering controls No further data; see item 7.
· Individual protection measures, such as personal protective equipment
· General protective and hygienic measures:
The usual precautionary measures are to be adhered to when handling chemicals.
· Respiratory protection: Not required.
(Contd. on page 4)
IE

56.0.13
 Page 4/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 3)
· Hand protection

Protective gloves

The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Due to missing tests no recommendation to the glove material can be given for the product/ the
preparation/ the chemical mixture.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the
degradation
· Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of
quality and varies from manufacturer to manufacturer. As the product is a preparation of several
substances, the resistance of the glove material can not be calculated in advance and has therefore to
be checked prior to the application.
· Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has
to be observed.
· Eye/face protection Goggles recommended during refilling

* SECTION 9: Physical and chemical properties

· 9.1 Information on basic physical and chemical properties
· General Information
· Physical state Fluid
· Colour: Yellow-brown
· Odour: Specific type
· Odour threshold: Not determined.
· Melting point/freezing point: -42 °C
· Boiling point or initial boiling point and boiling
range >350 °C
· Flammability Not applicable.
· Lower and upper explosion limit
· Lower: Not determined.
· Upper: Not determined.
· Flash point: >216 °C
· Decomposition temperature: Not determined.
· pH Not determined.
· Viscosity:
· Kinematic viscosity at 40 °C >65 mm²/s
· Dynamic: Not determined.
· Solubility
· water: Not miscible or difficult to mix.
· Partition coefficient n-octanol/water (log value) Not determined.
· Vapour pressure: Not determined.
· Density and/or relative density
· Density at 20 °C: 0.85 g/cm³
· Relative density Not determined.
· Bulk density: 850 kg/m³
(Contd. on page 5)
IE

56.0.13
 Page 5/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 4)

· Vapour density Not determined.

· 9.2 Other information
· Appearance:
· Form: Liquid
· Important information on protection of health
and environment, and on safety.
· Ignition temperature: Product is not selfigniting.
· Explosive properties: Product does not present an explosion hazard.
· Solvent content:
· VOC (EC) 0.00 %
· Solids content: 0.0 %
· Change in condition
· Evaporation rate Not determined.
· Information with regard to physical hazard
classes
· Explosives Void
· Flammable gases Void
· Aerosols Void
· Oxidising gases Void
· Gases under pressure Void
· Flammable liquids Void
· Flammable solids Void
· Self-reactive substances and mixtures Void
· Pyrophoric liquids Void
· Pyrophoric solids Void
· Self-heating substances and mixtures Void
· Substances and mixtures, which emit
flammable gases in contact with water Void
· Oxidising liquids Void
· Oxidising solids Void
· Organic peroxides Void
· Corrosive to metals Void
· Desensitised explosives Void

SECTION 10: Stability and reactivity

· 10.1 Reactivity No further relevant information available.
· 10.2 Chemical stability
· Thermal decomposition / conditions to be avoided:
No decomposition if used according to specifications.
· 10.3 Possibility of hazardous reactions No dangerous reactions known.
· 10.4 Conditions to avoid No further relevant information available.
· 10.5 Incompatible materials: No further relevant information available.
· 10.6 Hazardous decomposition products:
Carbon monoxide
Aldehyde
Poisonous gases/vapours
(Contd. on page 6)
IE

56.0.13
 Page 6/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 5)
Carbon dioxide

* SECTION 11: Toxicological information

· 11.1 Information on hazard classes as defined in Regulation (EC) No 1272/2008
· Acute toxicity Based on available data, the classification criteria are not met.
· Skin corrosion/irritation Based on available data, the classification criteria are not met.
· Serious eye damage/irritation Based on available data, the classification criteria are not met.
· Respiratory or skin sensitisation Based on available data, the classification criteria are not met.
· Germ cell mutagenicity Based on available data, the classification criteria are not met.
· Carcinogenicity Based on available data, the classification criteria are not met.
· Reproductive toxicity Based on available data, the classification criteria are not met.
· STOT-single exposure Based on available data, the classification criteria are not met.
· STOT-repeated exposure Based on available data, the classification criteria are not met.
· Aspiration hazard Based on available data, the classification criteria are not met.
· 11.2 Information on other hazards
· Endocrine disrupting properties
None of the ingredients is listed.

* SECTION 12: Ecological information

· 12.1 Toxicity
· Aquatic toxicity: No further relevant information available.
· 12.2 Persistence and degradability No further relevant information available.
· 12.3 Bioaccumulative potential No further relevant information available.
· 12.4 Mobility in soil No further relevant information available.
· 12.5 Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
· 12.6 Endocrine disrupting properties
The product does not contain substances with endocrine disrupting properties.
· 12.7 Other adverse effects
· Additional ecological information:
· General notes:
Water hazard class 1 (German Regulation) (Self-assessment): slightly hazardous for water
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage
system.

SECTION 13: Disposal considerations

· 13.1 Waste treatment methods
· Recommendation Smaller quantities can be disposed of with household waste.
· Uncleaned packaging:
· Recommendation: Disposal must be made according to official regulations.
IE
(Contd. on page 7)

56.0.13
 Page 7/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 6)

SECTION 14: Transport information

· 14.1 UN number or ID number
· ADR, ADN, IMDG, IATA not regulated
· 14.2 UN proper shipping name
· ADR, ADN, IMDG, IATA not regulated
· 14.3 Transport hazard class(es)
· ADR, ADN, IMDG, IATA
· Class not regulated
· 14.4 Packing group
· ADR, IMDG, IATA not regulated
· 14.5 Environmental hazards: Not applicable.
· 14.6 Special precautions for user Not applicable.
· 14.7 Maritime transport in bulk according to
IMO instruments Not applicable.
· UN "Model Regulation": not regulated

SECTION 15: Regulatory information

· 15.1 Safety, health and environmental regulations/legislation specific for the substance or
mixture
· Directive 2012/18/EU
· Named dangerous substances - ANNEX I None of the ingredients is listed.
· DIRECTIVE 2011/65/EU on the restriction of the use of certain hazardous substances in
electrical and electronic equipment – Annex II
None of the ingredients is listed.
· REGULATION (EU) 2019/1148
· Annex I - RESTRICTED EXPLOSIVES PRECURSORS (Upper limit value for the purpose of
licensing under Article 5(3))
None of the ingredients is listed.
· Annex II - REPORTABLE EXPLOSIVES PRECURSORS
None of the ingredients is listed.
· Regulation (EC) No 273/2004 on drug precursors
None of the ingredients is listed.
· Regulation (EC) No 111/2005 laying down rules for the monitoring of trade between the
Community and third countries in drug precursors
None of the ingredients is listed.
· 15.2 Chemical safety assessment: A Chemical Safety Assessment has not been carried out.
IE
(Contd. on page 8)

56.0.13
 Page 8/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2023 Version number 1 Revision: 13.03.2023

Trade name: MANNOL 7715 Longlife 504/507

(Contd. of page 7)

SECTION 16: Other information

This information is based on our present knowledge. However, this shall not constitute a guarantee for
any specific product features and shall not establish a legally valid contractual relationship.
· Relevant phrases
H315 Causes skin irritation.
H318 Causes serious eye damage.
H411 Toxic to aquatic life with long lasting effects.
H413 May cause long lasting harmful effects to aquatic life.
· Classification according to Regulation (EC) No 1272/2008
The classification of the mixture is generally based on the calculation method using substance data
according to Regulation (EC) No 1272/2008.
· Department issuing SDS: Product safety department.
· Contact: Mrs. Zubaite
· Date of previous version: 12.08.2022
· Abbreviations and acronyms:
ADR: Accord relatif au transport international des marchandises dangereuses par route (European Agreement Concerning the
International Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classification and Labelling of Chemicals
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
VOC: Volatile Organic Compounds (USA, EU)
PBT: Persistent, Bioaccumulative and Toxic
vPvB: very Persistent and very Bioaccumulative
· * Data compared to the previous version altered.
IE

56.0.13