XM-444

SERVICE MANUAL AEP Model

UK Model
Ver 1.1 2003. 02
E Model

SPECIFICATIONS

Circuit system OTL (output transformerless) circuit Pulse

power supply
Inputs RCA pin jacks
High level input connector
Input level adjustment range
0.3 – 6 V (RCA pin jacks),
0.6 – 12 V (High level input)
Outputs Speaker terminals
Speaker impedance 2 – 8 Ω (stereo)
4 – 8 Ω (when used as a bridging amplifier)
Maximum outputs
4 Speakers: 80 W × 4 (at 4 Ω)
3 Speakers: 80 W × 2 + 222 W × 1 (at 4 Ω)
2 Speakers: 222 W × 2 (at 4 Ω)
Rated outputs (supply voltage at 14.4 V)
4 Speakers: 35 W × 4 (20 Hz – 20 kHz, 0.04% THD, at 4 Ω)
40 W × 4 (20 Hz – 20 kHz, 0.1% THD, at 2 Ω)
2 Speakers: 80 W × 2 (20 Hz – 20 kHz, 0.1% THD, at 4 Ω)
Frequency response 5 Hz – 80 kHz ( +0–3 dB)
Harmonic distortion 0.005% or less (at 1 kHz, 4 Ω, 10 W)
Low-pass filter 80 Hz, –18 dB/oct
High-pass filter 80 Hz, –12 dB/oct
Power requirements 12 V DC car battery
(negative ground)
Power supply voltage 10.5 – 16 V
Current drain at rated output : 20 A (4 Ω, 35 W × 4)
Remote input : 1.5 mA
Dimensions Approx. 260 × 55 × 180 mm (w/h/d) not incl.
projecting parts and controls
Mass Approx. 2.4 kg not incl. accessories
Supplied accessories Mounting screws (4)
High level input cord (1)
Protection cap (1)

Design and specifications are subject to change without

notice.

STEREO POWER AMPLIFIER

9-873-560-02 Sony Corporation
2003B0400-1 e Vehicle Company
© 2003. 02 Published by Sony Engineering Corporation

1
XM-444

PROTECTOR OPERATION CHECK TABLE OF CONTENTS

Thermal Protect 1. GENERAL

1. Short across TH801 with the power on. Connections ............................................................................. 3
2. Verify that the protector is operated and LD801 illuminates red.
3. Verify that the protector is released and LD801 illuminates green 2. DISASSEMBLY
when the short is removed. 2-1. Bottom Plate ........................................................................ 5
4. Likewise, perform items 1 to 3 for TH802 and TH803. 2-2. Heat Sink ............................................................................. 6
2-3. Amp Board .......................................................................... 6
Over Current Protect
1. Short between the positive and negative sides of the speaker 3. DIAGRAMS
output terminal CN802 with the power on.
3-1. Block Diagram –Front Section– ......................................... 7
(Perform this shorting for each channel on FRONT and REAR.)
3-2. Block Diagram –Rear/Power Section– ............................... 8
2. Verify that the protector is operated and LD801 illuminates red.
3-3. Schematic Diagram –Amp Section– ................................... 9
3. Verify that the protector is not released and LD801 remains red
3-4. Schematic Diagram –Power Section– ............................... 10
even when the short is removed.
3-5. Printed Wiring Board ........................................................ 11
4. Verify that the protector is released and LD801 illuminates green
when the power is turned off and then on again.
4. EXPLODED VIEW ........................................................... 12
Offset Protect
1. Short between the +12V terminal of CN801 and the BTL+ or 5. ELECTRICAL PARTS LIST ......................................... 13
BTL– of the speaker output terminal CN802.
(Short between +12V terminal and BTL+ and between +12V
terminal and BTL–.)
2. Verify that the protector is operated and LD801 illuminates red.
3. Verify that the protector is not released and LD801 remains red
even when the short is removed.
4. Verify that the protector is released and LD801 illuminates green
when the power is turned off and then on again.

Chassis Short Protect

1. Short between the +12V terminal of CN801 and the chassis with
the power on.
2. Verify that the pilot lamp PL801 goes on.
3. Verify that PL801 goes off when the short is removed.

Notes on Chip Component Replacement

• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be dam-
aged by heat.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE

WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.

2
 XM-444
SECTION 1
GENERAL This section is extracted
from instruction manual.

3
XM-444

4
 XM-444
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.

SET

2-1. BOTTOM PLATE

(Page 5)

2-2. HEAT SINK

(Page 6)

2-3. AMP BOARD

(Page 6)

Note : Follow the disassembly procedure in the numerical order given.

2-1. BOTTOM PLATE

1 BTP 3x6
3 bottom plate
2 BTP 3x6

5
XM-444

2-2. HEAT SINK

1 BVTP 3x8

3 BVTP 3x8
2 BVTP 3x8

4 AMP board

5 heat sink

2-3. AMP BOARD

2 rear panel

1 BVTP 3x8

4 front panel

5 AMP board

3 BVTP 3x8

6
 XM-444
SECTION 3
DIAGRAMS
3-1. BLOCK DIAGRAM — FRONT SECTION —

PRE AMP
HPF
IC801 (1/2) GAIN CONTROL
-1 IC802 (1/2)
-1 AMP CN802 (1/2)
2 IC803 (1/2)
L (BTL) 1 5 7 SPEAKER
OUT
3 5 DIFFERENTIAL (FRONT)
7 SWITCH DRIVE AMP DRIVE AMP POWER AMP
Q101 AMP Q104 Q108 Q110
6 Q102
S801-1
HPF L
(80Hz) VR801-1
(FRONT) LEVEL BIAS
CNJ801 (1/2) Q106,107
ON (FRONT)
INPUT
(FRONT) OFF
OVERLOAD
DIFFERENTIAL DRIVE AMP DRIVE AMP POWER AMP DET
AMP Q105 Q109 Q111 Q112
Q103

PRE AMP
IC801 (2/2) HPF BTL
-2 IC802 (2/2) GAIN CONTROL
-2 AMP
R 5
7 3 1 IC803 (2/2)
6 3 DIFFERENTIAL
B
1 SWITCH DRIVE AMP DRIVE AMP POWER AMP
Q201 AMP Q204 Q208 Q210 (Page 8)
2 Q202
S801-2
HPF R
(80Hz) VR801-2
CNJ802 (1/2)
(FRONT) LEVEL BIAS
HI LEVEL L R Q206,207
ON (FRONT)

OFF
DIFFERENTIAL DRIVE AMP DRIVE AMP POWER AMP OVERLOAD
AMP Q205 Q209 Q211 DET
Q203 Q212
C
(Page 8)
A
• Signal path (Page 8)

: AUDIO (FRONT)

7 7
XM-444

3-2. BLOCK DIAGRAM — REAR/POWER SECTION —

PRE AMP
LPF
IC804 (1/2) GAIN CONTROL
-3 -3 IC805 (1/2) CN802 (2/2)
AMP
L (BTL) 2 IC806 (1/2) SPEAKER
1 5 7 OUT
3 5 SWITCH DIFFERENTIAL DRIVE AMP DRIVE AMP POWER AMP (REAR)
7 AMP
6 Q301 Q304 Q308 Q310
Q302
S802-1
LPF
(80Hz) L
VR802-1
(REAR) BIAS
LEVEL
CNJ801 (2/2) ON Q306,307
(REAR)
INPUT
OFF
(REAR) OVERLOAD
DIFFERENTIAL DRIVE AMP DRIVE AMP POWER AMP DET
AMP Q305 Q309 Q311 Q312
Q303
(Page 7)

PRE AMP
LPF
B BTL
IC804 (2/2) GAIN CONTROL
-4 IC805 (2/2)
-4 AMP
R 5 IC806 (2/2) OFFSET
7 3 1 DET
6 3 SWITCH DIFFERENTIAL DRIVE AMP DRIVE AMP POWER AMP Q852,853
1 AMP
2 Q401 Q404 Q408 Q410
Q402
S802-2
LPF R
(80Hz)
CNJ802 (2/2) (REAR)
VR802-2 C BIAS
LEVEL
HI LEVEL L R ON (Page 7) Q406,407
(REAR)
OFF
MUTE
Q851 DIFFERENTIAL OVERLOAD
DRIVE AMP DRIVE AMP POWER AMP
AMP Q405 Q409 Q411 DET
Q403 Q412

B+ 15V REG
(14.8V) Q905,D905
PROTECTOR
DC DET
Q802 A
4 IC851 2 (Page 7)
B- -15V REG
(-14.8V) Q906,D906
F901
DC-DC CONVERTER CN801
40A
RECT TRANSFORMER B+
D903,904 T901 INVERTER DRIVER 12 SWITCH +12V
9 Q902
Q903 Q907
1
LD801
B+ POWER/
(23.5V) ERROR 2
PROTECTOR
POWER
LED ON/OFF
INVERTER DRIVER 10 Q901
Q904 Q908 3 DRIVE
B- Q803
(-23.5V) REM
15
ERROR GND
16
THERMAL
13 14 Q801

DC-DC CONVERTER
IC901
TH801 TH802 TH803
• Signal path
: AUDIO (REAR)
D804

D802

8 8
 XM-444

3-3. SCHEMATIC DIAGRAM — AMP SECTION — • Refer to page 12 for Common Note on Schematic Diagrams.

R116 D101 R118

R114
Q104 Q108
R133
Q102
C104 C113 R124 Q110
C857 Q112
R126 R129
C112 C114 R122 Q107
Q101 R131
R103 R119 R130
C101 C109 C115
R101 R106 Q106 R128

R123 R125
R113 R120 C116
C103 IC803 (1/2) R112
C102 R102 C107 C108
C111 R132 R127 R135
IC802 (1/2) Q103
IC801 (1/2) Q111
Q105
C861 R138 R139 Q109
S801 R115 R117
R862 C862 C105 R104 VR801 D102 R121
R861

C110 R110
R107 R108 R109 R111
C119 C120
R136

R207 R208 R209 R210 R211

C210 R218
C205 R204 R216 D201
C201 R214
R201 Q204 Q208 R233
IC801 (2/2) Q202
IC802 (2/2) C213 R224 Q210
C207 C208 C211 R213 Q212
C203 IC803 (2/2) R226 R229
Q201 C212 C214 R222 Q207
R231 R219
C202 R202 R206 C209 R230
C215 R228
R203 Q206
R223 R225
R220 C216
C858
CNJ801 CNJ802 R212
R238 R239 C204 R232 R227 R235
Q203
C117
C118
C217
C218

Q211
Q205
C219 C220
R137 R215 R217 Q209
D202 R221
R237
R236
CN802
R337

R316 R318
R437 R314 D301
C320 C319 Q304 Q308
Q302 R333
C304 C313 R324 Q310
C317
C318
C417
C418

R339 R338 C859 Q312

R326 R329
Q301 C312 C314 R322 Q307
R331 R319
C301 R303 R330
R863 C863 C307 C309 C315 R328
R301 R305 Q306
R323 R325
R320 C316
IC806 (1/2) R312 R313
C303 R306 R307
C306 C311 R332 R327 R335
IC805 (1/2) Q303
IC804 (1/2) Q311
C302 R302 Q305
S802 R315 R317 Q309
C420 C419 C305 R304 C310 R310 VR802 D302 R321
C308 R308 R309 R311
R864 C864 R439 R438 R336

C408 R408 R409 R410 R411

C410 R418
C405 R404 R416 D401
C401 R414
R401 Q404 Q408 R433
IC804 (2/2) C406 Q402
IC805 (2/2) C413 R424 Q410
R406 R407 C411 R413 Q412
C403 IC806 (2/2) R426 R429
Q401 C412 C414 R422 Q407
R431 R419
C402 R402 C407 R405 C409 C415 R430
R403 Q406 R428
C860
R423 R425
R420 C416
R412
C404 R432 R427 R435
Q403 Q411
Q405

R415 R417 Q409

D402 R421

R436

(Page 10)

9 9
XM-444

3-4. SCHEMATIC DIAGRAM — POWER SECTION — • Refer to page 12 for IC Block Diagram and Common Note on Schematic Diagrams.

(Page 9)

R855

Q905
T901 C914 R929
R851 D903
R919 Q907
Q851 Q903
C907 C919
R852 R916 R921 R927
R915 C913
C911 D905 C917
R923 R924 L951
IC851
R853 D852
R925 R926 C908 C915 D906 C918 R858
R917 C912
R918 R922 R928 C920 C852
D851 R856
Q904
C851 R854 R920 Q908 C910 C853 C854
D904
C916 R930
Q906 R857
Q853 D805

Q852

IC B/D
TH802 D806
Q902

R914 D804 TH801 C804

TH803 R809 R812 LD801
C801 R801
R905 D801
R811
R810
F901 Q901 R906 R865 Q802
CN801 L901
R802
R907 IC901
D803 D802

C901 R904 D902

C904 R813
R901 R902 C909

R814
C802

R805
R806
R909
R803 C903 R807
C902 R903 R913
R910
C906

D901 Q801 R815 R912 C905 C803 Q803

R911 R808 R859

C805 R961 C959
PL801
R804

• Waveform
1V/DIV, 5µsec/DIV
1
3.4Vp-p

15µsec

IC901 5

10 10
 XM-444

3-5. PRINTED WIRING BOARD • Refer to page 12 for Semiconductor Location and Common Note on Printed Wiring Boards.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

CN802
SPEAKER OUT AMP BOARD Q410 Q411 Q310 Q311
(REAR) (FRONT)
JW46

C316
S802

JW41
R336

R410
S802 LPF(80Hz)

JW43
B E C B Q406 E C B E C B Q306 E C B
4 1 -2 -1 (REAR)

C411
JW44
JW45

JR9
-2

JW154
ON

R335
R426 B C E R427 R326 B C E R327 IC806

R411
R311
C859
R136

JW155
R323

R322
R423 R310 5 C311
L TH803 JW47 8 OFF

C116
R424 R324 -1

R430 Q412

JW40
R408

R429 B C E
JW48

R433
Q407 JW49 C406

ECB

ECB
JW118 VR802

R422
R135
JW50 Q307 C309
BTL JW51 R321 C408 C409 LEVEL

JW42
JW119

R406
R409

C407
R405
VR802

D302
R315
JW120 JW52 R407 (REAR)

R308
Q305 Q303 C410
R425 C315 4 1
JW121 R421 C313

R305
R436 C307 C310
C416

JW122 C314 R314 IC805 CNJ802

R415
C Q403 R437

R318
R428 Q405 R328 R317

R307
R306
R325 HI LEVEL

R309
Q304

R237 R337
JW123 Q302 5 8
Q404 C413 D402 R

R331

C217 C317 C417

C218 C318 C418
R332
C414 R414 Q309 C419 C306

JW39
(REAR)
R435

JW27
Q408

JW26
Q409 R417 Q308 R316 C308 C320
C319 C420
R236

JW54

JW124
L
JW153

R418
R JW156 Q402 JR4 C312 C219

R431
R432

R320
R419
R420
JW55

R304
C305
D301 R303 R338

R319
JW125 C220

JW35
R235 C216

C853 R416 R413 R313 R

JW126 C415 JW56 C304

R137
Q301
R301

D401

ECB
C119

R339
R329 (FRONT)

C405 R403 C303

JW117

JW38
JW53
JW57 4 1 C120 L

JW36
JW127

JW37

JW34
C854 C412 R330

D806 D805

JR3
R859 Q853 ECB

R412

C118
C117
JW58 IC804 R302 JW21

R312
ECB
JW128

R404 R438
R401 R439
Q312 Q401
IC851 D803 E C B C301
R858
C852

JW116 8 R402
D JW129 5
JW152

D852

JW22
JW23
JW32

R853
R333

C864
C860
JW150

Q852 JW115

C403
C404
JW130 R851

R854
R812

JW131 JW20 (REAR)

JR8

D906 JW59 C302 R864

R856
R857

JW114 R852 -3 -4

JW25
JW24
C803 JW132 C401 C402
JW149 JW151 JW113 L (BTL) R
JW133 C919

R855
JW60
R807
BCE
Q803

JW33 C920
Q851

C851
JW148 C802 C918

JW29
JW112

C863
JW61

R863
JW110

JW28
C959
C906 JR7
R803

R808

JW62
JW63
LD801 JW134

D851
CNJ801

C105
R R815 JW111 JR1 R103 R138
JW109 R930 R961 C861
R813

R104
POWER/ INPUT

JW64
C804 JW106 C104
R811

JW65

R139
D801 R101

JR2
D804

C917
R910
R911

R912
R909
C909

PROTECTOR JW108

C103
R804

R202 R102
JW105
R809

D905
JW135
R801

R861
4
C801

Q906 1
C904

(FRONT)

C858
R810 JW107 JW104 JW66 JW19
G

JW14
IC801 -1 -2
R802
E Q802 JW147 C101

R203
R239
R238
C903 JW103 JW72 Q905 L (BTL) R
JW31

JR6
JR5
LD801 8 1 JW99 5 8

JW15 C857
Q801 JW146

JW17
JW16
R806
R805

IC901 JW102 JW73 JW30 JW18 C102

D802 JW67
9 16 R913 R929

R204
R201
C203
C204
C205
JW145

JW101 JW74 Q201 C201 C202

JW144

C905 JW68

R212
F901 R112

JW13
R914 JW75 ECB
40A C R920 JW100
R917

JW76
R915

JW69 C862
R906
R907

E Q902
JW136

B
C911 ECB

JW79
R862

JW12
R814 R918 JW77 C212 C112 JW11

JW82
JW70

JW81
R919 Q101 JW10 S801 S801
JW78

JW80
R905 C913 C916 JW71 -2 -1 HPF(80Hz)

C211
JR10
JW137 R922 D202 R213 R113 -2
R865
D902

R211
R111
(FRONT)
R902
R903

D102
Q901

R921

JW9
R115 D101
F R215 D201 ON

R221

R132
R131
R232
R210 1 C111

R231
CN801

JW3
R916 C115 4 -1
Q203 R233 Q103
JW142
JW143

R121
C215
L901

JW8
JW7
R120
R119
R220
R219
R904 OFF
Q205 R214 R114
Q908 Q907

IC803
ECB ECB

Q212
R229 E C B
D901

C214 R217 C114 R117 VR801

REM C914 C915 VR801

JW83
Q105 C113 5 LEVEL
JW138

JW4
8

R116
C213 R108

R216
R218
Q109

R230
Q208 Q202 Q108 Q102 R110
Q209 C109 (FRONT)
JW139

R208

R209
JW84

JW6

C210
JW5
C901 T901 R923 R225 JW90 R125 R118
JW140 L951 JW91 Q104 R129 R109
Q204

R130

C209
C912

DC-DC CONVERTER

R207
R925 R228 B C E Q112 JW2
+12V R901 TRANSFORMER JW96 R128
JW141 JW88 JW85 C110

C208
C207
G
R924
R927

JW87

BCE
C902

JW95

BCE
C910 JW92 Q207 JW89 Q107 JW86

JW1
C907 JW94 R133 4 1
R206
JW93 R224 R124 C107

R122
IC802

R222
C908

R106
TH801

TH802 R223 R123 C108

5 8
GND E C B R226 R127 E C B R126
R926 R928 R227 R107
PL801
G D S G D S K A K A K A B C E Q206 B C E B C E Q106 B C E
C805

H Q904 Q903 D904 D903 Q211 Q210 Q111 Q110 1-684-682- 11

11 11
XM-444
SECTION 4
EXPLODED VIEW
• Semiconductor Location NOTE:
THIS NOTE IS COMMON FOR PRINTED WIRING
• The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by
Ref. No. Location Ref. No. Location BOARDS AND SCHEMATIC DIAGRAMS.
number in the exploded views are not supplied. Example : mark 0 or dotted line with mark.
D101 F-12 Q203 F-9 (In addition to this, the necessary note is
printed in each block.) • Items marked “*” are not stocked since KNOB, BALANCE (WHITE) ... (RED) 0 are critical for safety.
D102 F-11 Q204 G-9 they are seldom required for routine service. R R Replace only with part number
D201 F-10 Q205 F-9 Some delay should be anticipated Parts Color Cabinet’s Color
for schematic diagram: specified.
D202 F-9 Q206 H-8
• All capacitors are in µF unless otherwise noted. pF: µµF when ordering these items. • Accessories are given in the last of this parts list.
D301 C-10 Q207 G-8
D302 C-11 Q208 F-8 50 WV or less are not indicated except for electrolytics
D401 D-7 Q209 F-8 and tantalums.
D402 C-8 Q210 H-9 • All resistors are in Ω and 1/4 W or less unless otherwise
D801 E-3 Q211 H-8 specified.
D802 E-6 Q212 F-10 • 2 : nonflammable resistor.
D803 D-3 Q301 D-10
D804 E-4 Q302 C-10 Note: The components identified by mark 0 or dotted line
D805 D-5 Q303 C-10 with mark 0 are critical for safety.
D806 D-5 Q304 C-10 Replace only with part number specified.
D851 D-9 Q305 C-10 • A : B+ Line.
D852 D-9 Q306 B-9
• B : B– Line.
D901 F-3 Q307 C-9
• Power voltage is dc 14.4V and fed with regulated dc power
D902 F-4 Q308 C-9
supply from +12V and REM terminals.
D903 H-7 Q309 C-9
• Voltage is dc with respect to ground under no-signal
4
D904 H-6 Q310 B-9 5 6
D905 E-10 Q311 B-10 condition.
D906 D-10 Q312 D-9 • Voltages are taken with a VOM (Input impedance 10 MΩ).
Q401 D-10 Voltage variations may be noted due to normal produc-
IC801 E-12 Q402 C-8 tion tolerances.
IC802 G-13 Q403 C-8 • Waveforms are taken with a oscilloscope.
10 10
IC803 F-12 Q404 C-7 Voltage variations may be noted due to normal produc-
IC804 D-11 Q405 C-7 tion tolerances. 12
IC805 C-11 Q406 B-7 • Circled numbers refer to waveforms.
IC806 B-12 Q407 B-7 • Signal path.
IC851 D-3 Q408 C-6 F : AUDIO 3
IC901 E-4 Q409 C-7 8
Q410 B-6 for printed wiring boards:
LD801 E-3 Q411 B-7 • X : parts extracted from the component side.
Q412 B-6 • : Pattern from the side which enables seeing.
Q101 F-11 Q801 E-3
11 12 9
Q102 F-11 Q802 E-3
Q103 F-11 Q803 D-2
Q104 G-11 Q851 D-10
Q105 F-11 Q852 D-4 6
Q106 H-11 Q853 D-4 F901
Q107 G-10 Q901 F-3
Q108 F-11 Q902 E-4
Q109 F-10 Q903 H-5
Q110 H-11 Q904 H-4 2 6
Q111 H-10 Q905 E-10
11
11
Q112 G-12 Q906 E-10
Q201 E-9 Q907 F-6
Q202 F-9 Q908 G-6 1
• IC Block Diagram 6
6

IC901 µPC494GS-T1

16 15 14 13 12 11 10 9
7

ERROR REF. REG.

7
0.1V
OSC
ERROR

1 2 3 4 5 6 7 8

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
1 3-240-650-01 PLATE, BOTTOM 7 7-685-545-14 SCREW +BTP 3X6 TYPE2 N-S
2 3-238-669-01 PANEL, FRONT 8 3-240-642-01 HEAT SINK (SUB 2CH)
3 3-238-668-01 HEAT SINK (CHINESE MADE) 9 3-240-651-01 HEAT SINK (SUB 4CH)
3 3-238-668-11 HEAT SINK (JAPAN MADE) 10 3-225-184-01 SCREW (+PS.TT.3X6)
4 3-238-670-01 PANEL, REAR 11 3-225-183-01 SCREW (+PSW.TT.3XL)

5 A-3274-222-A AMP BOARD, COMPLETE 12 3-912-432-01 SCREW (+–B)

6 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 0 F901 1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) 40A

12 12
 XM-444
SECTION 5
ELECTRICAL PARTS LIST AMP
NOTE:
• Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by
the parts list may be different from the they are seldom required for routine service. mark 0 or dotted line with mark.
parts specified in the diagrams or the Some delay should be anticipated 0 are critical for safety.
components used on the set. when ordering these items. Replace only with part number
• RESISTORS • SEMICONDUCTORS specified.
All resistors are in ohms. In each case, u : µ, for example:
METAL:Metal-film resistor. uA.. : µA.. uPA.. : µPA.. When indicating parts by reference
METAL OXIDE: Metal oxide-film resistor. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. number, please include the board.
F:nonflammable • CAPACITORS
uF : µF
• COILS
uH : µH

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
A-3274-222-A AMP BOARD, COMPLETE C217 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
********************* C218 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C219 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
1-537-479-11 TERMINAL C220 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
3-225-183-01 SCREW (+PSW.TT.3XL) C301 1-126-963-11 ELECT 4.7uF 20% 50V
3-225-184-01 SCREW (+PS.TT.3X6)
3-240-642-01 HEAT SINK (SUB 2CH) C302 1-126-963-11 ELECT 4.7uF 20% 50V
3-240-651-01 HEAT SINK (SUB 4CH) C303 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C304 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
3-912-432-01 SCREW (+–B) C305 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C306 1-126-963-11 ELECT 4.7uF 20% 50V
< CAPACITOR >
C307 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C101 1-126-963-11 ELECT 4.7uF 20% 50V C308 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C102 1-126-963-11 ELECT 4.7uF 20% 50V C309 1-128-551-11 ELECT 22uF 20% 25V
C103 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C310 1-128-551-11 ELECT 22uF 20% 25V
C104 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C311 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C105 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C312 1-126-933-11 ELECT 100uF 20% 16V
C107 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C313 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C108 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C314 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C109 1-128-551-11 ELECT 22uF 20% 25V C315 1-126-960-11 ELECT 1uF 20% 50V
C110 1-128-551-11 ELECT 22uF 20% 25V C316 1-136-161-00 FILM 0.047uF 5% 50V
C111 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C317 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C112 1-126-933-11 ELECT 100uF 20% 16V C318 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C113 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C319 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C114 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C320 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C115 1-126-960-11 ELECT 1uF 20% 50V C401 1-126-963-11 ELECT 4.7uF 20% 50V
C116 1-136-161-00 FILM 0.047uF 5% 50V
C402 1-126-963-11 ELECT 4.7uF 20% 50V
C117 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C403 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C118 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C404 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C119 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C405 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C120 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C406 1-126-963-11 ELECT 4.7uF 20% 50V
C201 1-126-963-11 ELECT 4.7uF 20% 50V
C407 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C202 1-126-963-11 ELECT 4.7uF 20% 50V C408 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C203 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C409 1-128-551-11 ELECT 22uF 20% 25V
C204 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C410 1-128-551-11 ELECT 22uF 20% 25V
C205 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C411 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C207 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C412 1-126-933-11 ELECT 100uF 20% 16V
C208 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C413 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C209 1-128-551-11 ELECT 22uF 20% 25V C414 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C210 1-128-551-11 ELECT 22uF 20% 25V C415 1-126-960-11 ELECT 1uF 20% 50V
C211 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C416 1-136-161-00 FILM 0.047uF 5% 50V
C212 1-126-933-11 ELECT 100uF 20% 16V
C417 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C213 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C418 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C214 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C419 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C215 1-126-960-11 ELECT 1uF 20% 50V C420 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C216 1-136-161-00 FILM 0.047uF 5% 50V C801 1-163-021-00 CERAMIC CHIP 0.01uF 10% 50V

13
XM-444
AMP

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
C802 1-128-551-11 ELECT 22uF 20% 25V < DIODE >
C803 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
C804 1-128-551-11 ELECT 22uF 20% 25V D101 8-719-801-78 DIODE 1SS184
C805 1-164-156-11 CERAMIC CHIP 0.1uF 25V D102 8-719-801-78 DIODE 1SS184
C851 1-128-551-11 ELECT 22uF 20% 25V D201 8-719-801-78 DIODE 1SS184
D202 8-719-801-78 DIODE 1SS184
C852 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V D301 8-719-801-78 DIODE 1SS184
C853 1-128-551-11 ELECT 22uF 20% 25V
C854 1-128-551-11 ELECT 22uF 20% 25V D302 8-719-801-78 DIODE 1SS184
C857 1-164-156-11 CERAMIC CHIP 0.1uF 25V D401 8-719-801-78 DIODE 1SS184
C858 1-164-156-11 CERAMIC CHIP 0.1uF 25V D402 8-719-801-78 DIODE 1SS184
D801 8-719-801-78 DIODE 1SS184
C859 1-164-156-11 CERAMIC CHIP 0.1uF 25V D802 8-719-801-78 DIODE 1SS184
C860 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C861 1-126-934-11 ELECT 220uF 20% 16V D803 8-719-801-78 DIODE 1SS184
C862 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V D804 8-719-801-78 DIODE 1SS184
C863 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V D805 8-719-801-78 DIODE 1SS184
D806 8-719-820-05 DIODE 1SS181
C864 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V D851 8-719-025-34 DIODE 02CZ6.8-TE85L
C901 1-137-194-81 FILM 0.47uF 5% 50V
C902 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V D852 8-719-801-78 DIODE 1SS184
C903 1-126-947-11 ELECT 47uF 20% 16V D901 8-719-025-50 DIODE 02CZ16-TE85L
C904 1-128-551-11 ELECT 22uF 20% 25V D902 8-719-025-34 DIODE 02CZ6.8-TE85L
D903 6-500-209-01 DIODE FCH08A15
C905 1-126-933-11 ELECT 100uF 20% 16V D904 6-500-210-01 DIODE FRH08A15
C906 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C907 1-136-161-00 FILM 0.047uF 5% 50V D905 8-719-025-49 DIODE 02CZ15-TE85L
C908 1-131-731-11 ELECT 2200uF 20% 16V D906 8-719-025-49 DIODE 02CZ15-TE85L
C909 1-163-021-00 CERAMIC CHIP 0.01uF 10% 50V
< FUSE >
C910 1-131-731-11 ELECT 2200uF 20% 16V
C911 1-136-165-00 FILM 0.1uF 5% 50V 0 F901 1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) 40A
C912 1-136-165-00 FILM 0.1uF 5% 50V
C913 1-165-949-11 ELECT 1500uF 35V < IC >
C914 1-165-949-11 ELECT 1500uF 35V
IC801 8-759-710-28 IC NJM4565M-A
C915 1-165-949-11 ELECT 1500uF 35V IC802 8-759-710-28 IC NJM4565M-A
C916 1-165-949-11 ELECT 1500uF 35V IC803 8-759-710-28 IC NJM4565M-A
C917 1-126-963-11 ELECT 4.7uF 20% 50V IC804 8-759-710-28 IC NJM4565M-A
C918 1-126-963-11 ELECT 4.7uF 20% 50V IC805 8-759-710-28 IC NJM4565M-A
C919 1-126-933-11 ELECT 100uF 20% 16V
IC806 8-759-710-28 IC NJM4565M-A
C920 1-126-933-11 ELECT 100uF 20% 16V IC901 8-759-144-88 IC uPC494GS
C959 1-164-156-11 CERAMIC CHIP 0.1uF 25V
< PHOTO COUPLER >
< TERMINAL BOARD >
IC851 8-719-156-72 PHOTO COUPLER PS2501-1-K
CN801 1-537-477-11 TERMINAL BOARD (3P) (REM,+12V,GND)
CN802 1-694-902-11 TERMINAL BOARD (8P) (SPEAKER OUT < JUMPER RESISTOR >
(FRONT/REAR))
JR1 1-216-864-11 METAL CHIP 0 5% 1/16W
< JACK > JR2 1-216-296-11 SHORT 0
JR3 1-216-864-11 METAL CHIP 0 5% 1/16W
CNJ801 1-779-078-21 JACK, PIN 4P (INPUT (FRONT/REAR)) JR4 1-216-864-11 METAL CHIP 0 5% 1/16W
JR5 1-216-864-11 METAL CHIP 0 5% 1/16W
< CONNECTOR >
JR6 1-216-864-11 METAL CHIP 0 5% 1/16W
CNJ802 1-580-283-11 PIN, CONNECTOR (PC BOARD) 8P (HI LEVEL JR7 1-216-864-11 METAL CHIP 0 5% 1/16W
(INPUT (FRONT/REAR))) JR8 1-216-296-11 SHORT 0
JR9 1-216-296-11 SHORT 0
JR10 1-216-296-11 SHORT 0

The components identified by

mark 0 or dotted line with mark.
0 are critical for safety.
Replace only with part number
specified.

14
 XM-444
AMP

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
< COIL > Q405 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q406 8-729-902-11 TRANSISTOR 2SC2021-Q
L901 1-411-756-11 COIL, CHOKE Q407 8-729-230-46 TRANSISTOR 2SA1162-YG
L951 1-410-396-41 INDUCTOR, FERRITE BEAD 0.45uH Q408 8-729-020-80 TRANSISTOR 2SC2235-O/Y(TPE6)
Q409 8-729-232-32 TRANSISTOR 2SA965
< DIODE >
Q410 8-729-024-79 TRANSISTOR 2SC5100-P
LD801 8-719-076-62 LED GL5ED60 (POWER/PROTECTOR) Q411 8-729-024-76 TRANSISTOR 2SA1908-P
Q412 8-729-230-49 TRANSISTOR 2SC2712-YG
< PILOT LAMP > Q801 8-729-049-77 TRANSISTOR HN1B01F-GR(T5LSONY)
Q802 8-729-049-77 TRANSISTOR HN1B01F-GR(T5LSONY)
PL801 1-517-156-11 LAMP, PILOT
Q803 8-729-027-43 TRANSISTOR DTC114EKA-T146
< TRANSISTOR > Q851 8-729-049-77 TRANSISTOR HN1B01F-GR(T5LSONY)
Q852 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q101 8-729-202-38 TRANSISTOR 2SC3326N-A Q853 8-729-049-77 TRANSISTOR HN1B01F-GR(T5LSONY)
Q102 8-729-014-86 TRANSISTOR 2SC4207-YGR-TE85L Q901 8-729-049-77 TRANSISTOR HN1B01F-GR(T5LSONY)
Q103 8-729-232-66 TRANSISTOR 2SA1618-Y
Q104 8-729-140-82 TRANSISTOR 2SA988-PAFAEA Q902 8-729-106-60 TRANSISTOR 2SB1115A
Q105 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA Q903 8-729-053-05 FET FKV550T
Q904 8-729-053-05 FET FKV550T
Q106 8-729-902-11 TRANSISTOR 2SC2021-Q Q905 8-729-207-82 TRANSISTOR 2SC3421-Y
Q107 8-729-230-46 TRANSISTOR 2SA1162-YG Q906 8-729-207-89 TRANSISTOR 2SA1358-Y
Q108 8-729-020-80 TRANSISTOR 2SC2235-O/Y(TPE6)
Q109 8-729-232-32 TRANSISTOR 2SA965 Q907 8-729-230-49 TRANSISTOR 2SC2712-YG
Q110 8-729-024-79 TRANSISTOR 2SC5100-P Q908 8-729-230-49 TRANSISTOR 2SC2712-YG

Q111 8-729-024-76 TRANSISTOR 2SA1908-P < RESISTOR >

Q112 8-729-230-49 TRANSISTOR 2SC2712-YG
Q201 8-729-202-38 TRANSISTOR 2SC3326N-A R101 1-216-837-11 METAL CHIP 22K 5% 1/16W
Q202 8-729-014-86 TRANSISTOR 2SC4207-YGR-TE85L R102 1-216-837-11 METAL CHIP 22K 5% 1/16W
Q203 8-729-232-66 TRANSISTOR 2SA1618-Y R103 1-218-867-11 RES-CHIP 6.8K 5% 1/10W
R104 1-218-867-11 RES-CHIP 6.8K 5% 1/10W
Q204 8-729-140-82 TRANSISTOR 2SA988-PAFAEA R106 1-216-843-11 METAL CHIP 68K 5% 1/16W
Q205 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q206 8-729-902-11 TRANSISTOR 2SC2021-Q R107 1-218-332-11 RES-CHIP 130K 5% 1/10W
Q207 8-729-230-46 TRANSISTOR 2SA1162-YG R108 1-216-841-11 METAL CHIP 47K 5% 1/16W
Q208 8-729-020-80 TRANSISTOR 2SC2235-O/Y(TPE6) R109 1-216-841-11 METAL CHIP 47K 5% 1/16W
R110 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
Q209 8-729-232-32 TRANSISTOR 2SA965 R111 1-218-482-11 RES-CHIP 430 5% 1/10W
Q210 8-729-024-79 TRANSISTOR 2SC5100-P
Q211 8-729-024-76 TRANSISTOR 2SA1908-P R112 1-216-222-00 RES-CHIP 10K 5% 1/8W
Q212 8-729-230-49 TRANSISTOR 2SC2712-YG R113 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
Q301 8-729-202-38 TRANSISTOR 2SC3326N-A R114 1-216-839-11 METAL CHIP 33K 5% 1/16W
R115 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
Q302 8-729-014-86 TRANSISTOR 2SC4207-YGR-TE85L R116 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
Q303 8-729-232-66 TRANSISTOR 2SA1618-Y
Q304 8-729-140-82 TRANSISTOR 2SA988-PAFAEA R117 1-216-839-11 METAL CHIP 33K 5% 1/16W
Q305 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA R118 1-216-809-11 METAL CHIP 100 5% 1/16W
Q306 8-729-902-11 TRANSISTOR 2SC2021-Q R119 1-216-845-11 METAL CHIP 100K 5% 1/16W
R120 1-216-845-11 METAL CHIP 100K 5% 1/16W
Q307 8-729-230-46 TRANSISTOR 2SA1162-YG R121 1-216-174-00 RES-CHIP 100 5% 1/8W
Q308 8-729-020-80 TRANSISTOR 2SC2235-O/Y(TPE6)
Q309 8-729-232-32 TRANSISTOR 2SA965 R122 1-216-820-11 METAL CHIP 820 5% 1/16W
Q310 8-729-024-79 TRANSISTOR 2SC5100-P R123 1-216-814-11 METAL CHIP 270 5% 1/16W
Q311 8-729-024-76 TRANSISTOR 2SA1908-P R124 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R125 1-216-182-00 RES-CHIP 220 5% 1/8W
Q312 8-729-230-49 TRANSISTOR 2SC2712-YG R126 1-216-150-00 RES-CHIP 10 5% 1/8W
Q401 8-729-202-38 TRANSISTOR 2SC3326N-A
Q402 8-729-014-86 TRANSISTOR 2SC4207-YGR-TE85L R127 1-216-150-00 RES-CHIP 10 5% 1/8W
Q403 8-729-232-66 TRANSISTOR 2SA1618-Y R128 1-205-991-11 METAL 0.1X2 10% 5W
Q404 8-729-140-82 TRANSISTOR 2SA988-PAFAEA R129 1-216-821-11 METAL CHIP 1K 5% 1/16W
R130 1-216-821-11 METAL CHIP 1K 5% 1/16W

15
XM-444
AMP

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R131 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R309 1-216-841-11 METAL CHIP 47K 5% 1/16W
R132 1-216-222-00 RES-CHIP 10K 5% 1/8W R310 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R133 1-216-833-11 METAL CHIP 10K 5% 1/16W R311 1-218-482-11 RES-CHIP 430 5% 1/10W
R135 1-215-857-31 METAL OXIDE 10 5% 1W F R312 1-216-222-00 RES-CHIP 10K 5% 1/8W
R136 1-216-853-11 METAL CHIP 470K 5% 1/16W R313 1-216-829-11 METAL CHIP 4.7K 5% 1/16W

R137 1-216-206-00 RES-CHIP 2.2K 5% 1/8W R314 1-216-839-11 METAL CHIP 33K 5% 1/16W
R138 1-216-841-11 METAL CHIP 47K 5% 1/16W R315 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R139 1-216-841-11 METAL CHIP 47K 5% 1/16W R316 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R201 1-216-837-11 METAL CHIP 22K 5% 1/16W R317 1-216-839-11 METAL CHIP 33K 5% 1/16W
R202 1-216-837-11 METAL CHIP 22K 5% 1/16W R318 1-216-174-00 RES-CHIP 100 5% 1/8W

R203 1-218-867-11 RES-CHIP 6.8K 5% 1/10W R319 1-216-845-11 METAL CHIP 100K 5% 1/16W
R204 1-218-867-11 RES-CHIP 6.8K 5% 1/10W R320 1-216-845-11 METAL CHIP 100K 5% 1/16W
R206 1-216-843-11 METAL CHIP 68K 5% 1/16W R321 1-216-809-11 METAL CHIP 100 5% 1/16W
R207 1-218-332-11 RES-CHIP 130K 5% 1/10W R322 1-216-820-11 METAL CHIP 820 5% 1/16W
R208 1-216-841-11 METAL CHIP 47K 5% 1/16W R323 1-216-814-11 METAL CHIP 270 5% 1/16W

R209 1-216-841-11 METAL CHIP 47K 5% 1/16W R324 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R210 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R325 1-216-182-00 RES-CHIP 220 5% 1/8W
R211 1-218-482-11 RES-CHIP 430 5% 1/10W R326 1-216-150-00 RES-CHIP 10 5% 1/8W
R212 1-216-222-00 RES-CHIP 10K 5% 1/8W R327 1-216-150-00 RES-CHIP 10 5% 1/8W
R213 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R328 1-205-991-11 METAL 0.1X2 10% 5W

R214 1-216-839-11 METAL CHIP 33K 5% 1/16W R329 1-216-821-11 METAL CHIP 1K 5% 1/16W
R215 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R330 1-216-821-11 METAL CHIP 1K 5% 1/16W
R216 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R331 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R217 1-216-839-11 METAL CHIP 33K 5% 1/16W R332 1-216-222-00 RES-CHIP 10K 5% 1/8W
R218 1-216-809-11 METAL CHIP 100 5% 1/16W R333 1-216-222-00 RES-CHIP 10K 5% 1/8W

R219 1-216-845-11 METAL CHIP 100K 5% 1/16W R335 1-215-857-31 METAL OXIDE 10 5% 1W F
R220 1-216-845-11 METAL CHIP 100K 5% 1/16W R336 1-216-853-11 METAL CHIP 470K 5% 1/16W
R221 1-216-174-00 RES-CHIP 100 5% 1/8W R337 1-216-206-00 RES-CHIP 2.2K 5% 1/8W
R222 1-216-820-11 METAL CHIP 820 5% 1/16W R338 1-216-841-11 METAL CHIP 47K 5% 1/16W
R223 1-216-814-11 METAL CHIP 270 5% 1/16W R339 1-216-841-11 METAL CHIP 47K 5% 1/16W

R224 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R401 1-216-837-11 METAL CHIP 22K 5% 1/16W
R225 1-216-182-00 RES-CHIP 220 5% 1/8W R402 1-216-837-11 METAL CHIP 22K 5% 1/16W
R226 1-216-150-00 RES-CHIP 10 5% 1/8W R403 1-218-867-11 RES-CHIP 6.8K 5% 1/10W
R227 1-216-150-00 RES-CHIP 10 5% 1/8W R404 1-218-867-11 RES-CHIP 6.8K 5% 1/10W
R228 1-205-991-11 METAL 0.1X2 10% 5W R405 1-216-816-11 METAL CHIP 390 5% 1/16W

R229 1-216-821-11 METAL CHIP 1K 5% 1/16W R406 1-216-841-11 METAL CHIP 47K 5% 1/16W
R230 1-216-821-11 METAL CHIP 1K 5% 1/16W R407 1-216-841-11 METAL CHIP 47K 5% 1/16W
R231 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R408 1-216-841-11 METAL CHIP 47K 5% 1/16W
R232 1-216-222-00 RES-CHIP 10K 5% 1/8W R409 1-216-841-11 METAL CHIP 47K 5% 1/16W
R233 1-216-833-11 METAL CHIP 10K 5% 1/16W R410 1-216-829-11 METAL CHIP 4.7K 5% 1/16W

R235 1-215-857-31 METAL OXIDE 10 5% 1W F R411 1-218-482-11 RES-CHIP 430 5% 1/10W

R236 1-216-853-11 METAL CHIP 470K 5% 1/16W R412 1-216-222-00 RES-CHIP 10K 5% 1/8W
R237 1-216-206-00 RES-CHIP 2.2K 5% 1/8W R413 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R238 1-216-841-11 METAL CHIP 47K 5% 1/16W R414 1-216-839-11 METAL CHIP 33K 5% 1/16W
R239 1-216-841-11 METAL CHIP 47K 5% 1/16W R415 1-216-823-11 METAL CHIP 1.5K 5% 1/16W

R301 1-216-837-11 METAL CHIP 22K 5% 1/16W R416 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R302 1-216-837-11 METAL CHIP 22K 5% 1/16W R417 1-216-839-11 METAL CHIP 33K 5% 1/16W
R303 1-218-867-11 RES-CHIP 6.8K 5% 1/10W R418 1-216-174-00 RES-CHIP 100 5% 1/8W
R304 1-218-867-11 RES-CHIP 6.8K 5% 1/10W R419 1-216-845-11 METAL CHIP 100K 5% 1/16W
R305 1-216-816-11 METAL CHIP 390 5% 1/16W R420 1-216-845-11 METAL CHIP 100K 5% 1/16W

R306 1-216-841-11 METAL CHIP 47K 5% 1/16W R421 1-216-809-11 METAL CHIP 100 5% 1/16W
R307 1-216-841-11 METAL CHIP 47K 5% 1/16W R422 1-216-820-11 METAL CHIP 820 5% 1/16W
R308 1-216-841-11 METAL CHIP 47K 5% 1/16W R423 1-216-814-11 METAL CHIP 270 5% 1/16W

16
 XM-444
Ver 1.1
AMP
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
R424 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R911 1-216-835-11 METAL CHIP 15K 5% 1/16W
R425 1-216-182-00 RES-CHIP 220 5% 1/8W R912 1-216-833-11 METAL CHIP 10K 5% 1/16W
R426 1-216-150-00 RES-CHIP 10 5% 1/8W R913 1-216-853-11 METAL CHIP 470K 5% 1/16W
R427 1-216-150-00 RES-CHIP 10 5% 1/8W R914 1-216-833-11 METAL CHIP 10K 5% 1/16W
R428 1-205-991-11 METAL 0.1X2 10% 5W R915 1-216-190-00 RES-CHIP 470 5% 1/8W

R429 1-216-821-11 METAL CHIP 1K 5% 1/16W R916 1-216-821-11 METAL CHIP 1K 5% 1/16W
R430 1-216-821-11 METAL CHIP 1K 5% 1/16W R917 1-216-190-00 RES-CHIP 470 5% 1/8W
R431 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R918 1-216-821-11 METAL CHIP 1K 5% 1/16W
R432 1-216-222-00 RES-CHIP 10K 5% 1/8W R919 1-216-166-00 RES-CHIP 47 5% 1/8W
R433 1-216-833-11 METAL CHIP 10K 5% 1/16W R920 1-216-166-00 RES-CHIP 47 5% 1/8W

R435 1-215-857-31 METAL OXIDE 10 5% 1W F R921 1-216-821-11 METAL CHIP 1K 5% 1/16W

R436 1-216-853-11 METAL CHIP 470K 5% 1/16W R922 1-216-821-11 METAL CHIP 1K 5% 1/16W
R437 1-216-206-00 RES-CHIP 2.2K 5% 1/8W R923 1-216-186-00 RES-CHIP 330 5% 1/8W
R438 1-216-841-11 METAL CHIP 47K 5% 1/16W R924 1-216-190-00 RES-CHIP 470 5% 1/8W
R439 1-216-841-11 METAL CHIP 47K 5% 1/16W R925 1-216-186-00 RES-CHIP 330 5% 1/8W

R801 1-216-833-11 METAL CHIP 10K 5% 1/16W R926 1-216-190-00 RES-CHIP 470 5% 1/8W
R802 1-216-833-11 METAL CHIP 10K 5% 1/16W R927 1-216-166-00 RES-CHIP 47 5% 1/8W
R803 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R928 1-216-166-00 RES-CHIP 47 5% 1/8W
R804 1-216-837-11 METAL CHIP 22K 5% 1/16W R929 1-216-206-00 RES-CHIP 2.2K 5% 1/8W
R805 1-216-821-11 METAL CHIP 1K 5% 1/16W R930 1-216-206-00 RES-CHIP 2.2K 5% 1/8W

R806 1-216-821-11 METAL CHIP 1K 5% 1/16W R961 1-216-206-00 RES-CHIP 2.2K 5% 1/8W
R807 1-216-833-11 METAL CHIP 10K 5% 1/16W
R808 1-216-833-11 METAL CHIP 10K 5% 1/16W < SWITCH >
R809 1-216-833-11 METAL CHIP 10K 5% 1/16W
R810 1-216-829-11 METAL CHIP 4.7K 5% 1/16W S801 1-771-271-11 SWITCH, SLIDE (HPF(80Hz) (FRONT))
S802 1-771-271-11 SWITCH, SLIDE (LPF(80Hz) (REAR))
R811 1-216-206-00 RES-CHIP 2.2K 5% 1/8W
R812 1-216-206-00 RES-CHIP 2.2K 5% 1/8W < TRANSFORMER >
R813 1-216-202-00 RES-CHIP 1.5K 5% 1/8W
R814 1-216-820-11 METAL CHIP 820 5% 1/16W T901 1-437-744-11 TRANSFORMER, DC-DC CONVERTER
R815 1-216-821-11 METAL CHIP 1K 5% 1/16W
< THERMISTOR >
R851 1-216-222-00 RES-CHIP 10K 5% 1/8W
R852 1-216-821-11 METAL CHIP 1K 5% 1/16W TH801 1-808-877-11 THERMISTOR 20K
R853 1-216-845-11 METAL CHIP 100K 5% 1/16W TH802 1-808-877-11 THERMISTOR 20K
R854 1-216-837-11 METAL CHIP 22K 5% 1/16W TH803 1-808-877-11 THERMISTOR 20K
R855 1-216-286-00 RES-CHIP 4.7M 5% 1/8W
< VARIABLE RESISTOR >
R856 1-216-833-11 METAL CHIP 10K 5% 1/16W
R857 1-216-833-11 METAL CHIP 10K 5% 1/16W VR801 1-225-459-11 RES, VAR, CARBON 10KX2 (LEVEL (FRONT))
R858 1-216-857-11 METAL CHIP 1M 5% 1/16W VR802 1-225-459-11 RES, VAR, CARBON 10KX2 (LEVEL (REAR))
R859 1-216-841-11 METAL CHIP 47K 5% 1/16W *************************************************************
R861 1-216-214-00 RES-CHIP 4.7K 5% 1/8W
ACCESSORIES
R862 1-216-198-00 RES-CHIP 1K 5% 1/8W ************
R863 1-216-198-00 RES-CHIP 1K 5% 1/8W
R864 1-216-198-00 RES-CHIP 1K 5% 1/8W 3-240-580-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
R865 1-216-829-11 METAL CHIP 4.7K 5% 1/16W TRADITIONAL CHINESE)
R901 1-216-222-00 RES-CHIP 10K 5% 1/8W 3-240-580-21 MANUAL, INSTRUCTION (FRENCH,GERMAN,
ITALIAN) (AEP,UK)
R902 1-216-833-11 METAL CHIP 10K 5% 1/16W 3-240-580-31 MANUAL, INSTRUCTION (DUTCH,RUSSIAN,
R903 1-216-833-11 METAL CHIP 10K 5% 1/16W SWEDISH) (AEP,UK)
R904 1-216-190-00 RES-CHIP 470 5% 1/8W 3-240-580-41 MANUAL, INSTRUCTION (PORTUGUESE,POLISH,
R905 1-216-829-11 METAL CHIP 4.7K 5% 1/16W GREEK) (AEP,UK)
R906 1-216-190-00 RES-CHIP 470 5% 1/8W *************************************************************

R907 1-216-190-00 RES-CHIP 470 5% 1/8W

R909 1-216-849-11 METAL CHIP 220K 5% 1/16W
R910 1-216-836-11 METAL CHIP 18K 5% 1/16W

17
XM-444

Ref. No. Part No. Description Remark

PARTS FOR INSTALLATION AND CONNECTIONS
***************************************

51 3-367-410-01 SCREW (DIA.5X15), TAPPING

52 1-823-952-11 CORD, CONNECTION 8P (0.2m)
53 3-013-264-01 COVER, 3P TERMINAL BOARD

51 52 53

φ5 x 15
(x 4) 0.2 m

18
 XM-444

MEMO

19
XM-444

REVISION HISTORY

Clicking the version allows you to jump to the revised page.

Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.

Ver. Date Description of Revision

1.0 2002. 02 New
1.1 2003. 02 Part number correction of S801, 802. (SPM-03002)

20