Safety Data Sheet

SECTION 1 PRODUCT AND COMPANY IDENTIFICATION

Cat ® ELC (Extended Life Coolant) Extender

Product Use: Corrosion Inhibitor for cooling systems
Product Number(s): 226279
Company Identification
Chevron Products Company
Global Lubricants
6001 Bollinger Canyon Rd.
San Ramon, CA 94583
United States of America
www.chevronlubricants.com

Transportation Emergency Response

CHEMTREC: (800) 424-9300 or (703) 527-3887
Health Emergency
Chevron Emergency Information Center: Located in the USA. International collect calls accepted. (800)
231-0623 or (510) 231-0623
email : lubemsds@chevron.com

SECTION 2 HAZARDS IDENTIFICATION

CLASSIFICATION: Target organ toxicant (single exposure): Category 1. Eye irritation: Category 2A.
Skin irritation: Category 2. Acute aquatic toxicant: Category 2.

Signal Word: Danger

Health Hazards: Causes skin irritation. Causes serious eye irritation.

Environmental Hazards: Toxic to aquatic life.

(Blood/Blood Forming Organs).

PRECAUTIONARY STATEMENTS:
Prevention: Do not breathe dust/fume/gas/mist/vapours/spray. Wear protective gloves/protective
clothing/eye protection/face protection. Do not eat, drink or smoke when using this product. Wash
thoroughly after handling. Avoid release to the environment.
Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. IF ON
SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention.
_____________________________________________________________________
Revision Number: %%revision_number%% 1 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
Take off contaminated clothing and wash it before reuse. IF exposed: Call a poison center or
doctor/physician. Specific treatment (see Notes to Physician on this label).
Storage: Store locked up.
Disposal: Dispose of contents/container in accordance with applicable
local/regional/national/international regulations.

HAZARDS NOT OTHERWISE CLASSIFIED: Not Applicable

SECTION 3 COMPOSITION/ INFORMATION ON INGREDIENTS

COMPONENTS CAS NUMBER AMOUNT

Sodium tolyltriazole 64665-57-2 1 - 3 %weight
Sodium Nitrite 7632-00-0 1 - 3 %weight

SECTION 4 FIRST AID MEASURES

Description of first aid measures

Eye: Flush eyes with water immediately while holding the eyelids open. Remove contact lenses, if worn,
after initial flushing, and continue flushing for at least 15 minutes. Get immediate medical attention.
Skin: Wash skin with water immediately and remove contaminated clothing and shoes. Get medical
attention if any symptoms develop. To remove the material from skin, use soap and water. Discard
contaminated clothing and shoes or thoroughly clean before reuse.
Ingestion: If swallowed, get medical attention. Do not induce vomiting. Never give anything by mouth
to an unconscious person.
Inhalation: No specific first aid measures are required. If exposed to excessive levels of material in the
air, move the exposed person to fresh air. Get medical attention if coughing or respiratory discomfort
occurs.

Most important symptoms and effects, both acute and delayed

IMMEDIATE HEALTH EFFECTS
Eye: Contact with the eyes causes severe irritation. Symptoms may include pain, tearing, reddening,
swelling and impaired vision.
Skin: Contact with the skin causes irritation. Contact with the skin is not expected to cause an allergic
skin response. Symptoms may include pain, itching, discoloration, swelling, and blistering.
Ingestion: May be irritating to mouth, throat, and stomach. Symptoms may include pain, nausea,
vomiting, and diarrhea.
Inhalation: Not expected to be harmful if inhaled.

DELAYED OR OTHER HEALTH EFFECTS:

Target Organs: Contains material that may cause damage to the following organ(s) if swallowed
based on animal data:Blood/Blood Forming Organs Risk depends on duration and level of exposure.
See Section 11 for additional information.

Indication of any immediate medical attention and special treatment needed Not Applicable

SECTION 5 FIRE FIGHTING MEASURES

EXTINGUISHING MEDIA: Use water fog, foam, dry chemical or carbon dioxide (CO2) to extinguish
flames.

_____________________________________________________________________
Revision Number: %%revision_number%% 2 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
PROTECTION OF FIRE FIGHTERS:
Fire Fighting Instructions: This material will burn although it is not easily ignited. See Section 7 for
proper handling and storage. For fires involving this material, do not enter any enclosed or confined fire
space without proper protective equipment, including self-contained breathing apparatus.
Combustion Products: Highly dependent on combustion conditions. A complex mixture of airborne
solids, liquids, and gases including carbon monoxide, carbon dioxide, and unidentified organic
compounds will be evolved when this material undergoes combustion. Combustion may form oxides
of: Nitrogen, Sodium.

SECTION 6 ACCIDENTAL RELEASE MEASURES

Protective Measures: Eliminate all sources of ignition in vicinity of spilled material.

Spill Management: Stop the source of the release if you can do it without risk. Contain release to
prevent further contamination of soil, surface water or groundwater. Clean up spill as soon as possible,
observing precautions in Exposure Controls/Personal Protection. Use appropriate techniques such as
applying non-combustible absorbent materials or pumping. Where feasible and appropriate, remove
contaminated soil. Place contaminated materials in disposable containers and dispose of in a manner
consistent with applicable regulations.
Reporting: Report spills to local authorities and/or the U.S. Coast Guard's National Response Center at
(800) 424-8802 as appropriate or required.

SECTION 7 HANDLING AND STORAGE

General Handling Information: Avoid contaminating soil or releasing this material into sewage and
drainage systems and bodies of water.
Precautionary Measures: Do not get in eyes, on skin, or on clothing. Do not get in eyes. Do not taste
or swallow. Wash thoroughly after handling. Keep out of the reach of children.
Static Hazard: Electrostatic charge may accumulate and create a hazardous condition when handling
this material. To minimize this hazard, bonding and grounding may be necessary but may not, by
themselves, be sufficient. Review all operations which have the potential of generating and accumulating
an electrostatic charge and/or a flammable atmosphere (including tank and container filling, splash filling,
tank cleaning, sampling, gauging, switch loading, filtering, mixing, agitation, and vacuum truck operations)
and use appropriate mitigating procedures.
Container Warnings: Container is not designed to contain pressure. Do not use pressure to empty
container or it may rupture with explosive force. Empty containers retain product residue (solid, liquid,
and/or vapor) and can be dangerous. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose
such containers to heat, flame, sparks, static electricity, or other sources of ignition. They may explode
and cause injury or death. Empty containers should be completely drained, properly closed, and
promptly returned to a drum reconditioner or disposed of properly.

SECTION 8 EXPOSURE CONTROLS/PERSONAL PROTECTION

GENERAL CONSIDERATIONS:
Consider the potential hazards of this material (see Section 3), applicable exposure limits, job activities,
and other substances in the work place when designing engineering controls and selecting personal
protective equipment. If engineering controls or work practices are not adequate to prevent exposure to
harmful levels of this material, the personal protective equipment listed below is recommended. The
user should read and understand all instructions and limitations supplied with the equipment since
protection is usually provided for a limited time or under certain circumstances.

ENGINEERING CONTROLS:
Use in a well-ventilated area.
_____________________________________________________________________
Revision Number: %%revision_number%% 3 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
PERSONAL PROTECTIVE EQUIPMENT
Eye/Face Protection: Wear protective equipment to prevent eye contact. Selection of protective
equipment may include safety glasses, chemical goggles, face shields, or a combination depending on
the work operations conducted.
Skin Protection: Wear protective clothing to prevent skin contact. Selection of protective clothing may
include gloves, apron, boots, and complete facial protection depending on operations conducted.
Suggested materials for protective gloves include: Natural rubber, Nitrile Rubber.
Respiratory Protection: No respiratory protection is normally required.

Use a positive pressure air-supplying respirator in circumstances where air-purifying respirators may not
provide adequate protection.

Occupational Exposure Limits:

Component Agency TWA STEL Ceiling Notation

Sodium tolyltriazole Not Applicable -- -- -- --
Sodium Nitrite Not Applicable -- -- -- --
No applicable occupational exposure limits exist for this material or its components.

SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES

Attention: the data below are typical values and do not constitute a specification.

Color: Red
Physical State: Liquid
Odor: Faint or Mild
Odor Threshold: No data available
pH: 11
Vapor Pressure: <0.01 mmHg @ 20 °C (68 °F)
Vapor Density (Air = 1): >1
Initial Boiling Point: No data available
Solubility: Completely Soluble
Freezing Point: No data available
Melting Point: No data available
Specific Gravity: 1.06 @ 15.6°C (60.1°F) / 15.6°C (60.1°F)
Viscosity: No data available
Evaporation Rate: No data available
Decomposition temperature: No data available
Octanol/Water Partition Coefficient: No data available

FLAMMABLE PROPERTIES:
Flammability (solid, gas): No Data Available

Flashpoint: Not Applicable

Autoignition: No data available
Flammability (Explosive) Limits (% by volume in air): Lower: Not Applicable Upper: Not
Applicable

SECTION 10 STABILITY AND REACTIVITY

Reactivity: May react with strong acids or strong oxidizing agents, such as chlorates, nitrates,
peroxides, etc.
_____________________________________________________________________
Revision Number: %%revision_number%% 4 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
Chemical Stability: This material is considered stable under normal ambient and anticipated storage
and handling conditions of temperature and pressure.
Incompatibility With Other Materials: May form cancer-causing nitrosamines when mixed with
secondary amines.
Hazardous Decomposition Products: None known (None expected)
Hazardous Polymerization: Hazardous polymerization will not occur.

SECTION 11 TOXICOLOGICAL INFORMATION

Information on toxicological effects

Serious Eye Damage/Irritation: The eye irritation hazard is based on an evaluation of the data for the
components.
Skin Corrosion/Irritation: The skin irritation hazard is based on evaluation of data for product
components.
Skin Sensitization: The skin sensitization hazard is based on evaluation of data for product
components.
Acute Dermal Toxicity: The acute dermal toxicity hazard is based on evaluation of data for product
components.
Acute Oral Toxicity: The acute oral toxicity hazard is based on evaluation of data for product
components.
Acute Inhalation Toxicity: The acute inhalation toxicity hazard is based on evaluation of data for product
components.
Acute Toxicity Estimate: Not Determined

Germ Cell Mutagenicity: The hazard evaluation is based on data for components or a similar material.

Carcinogenicity: The hazard evaluation is based on data for components or a similar material.

Reproductive Toxicity: The hazard evaluation is based on data for components or a similar material.

Specific Target Organ Toxicity - Single Exposure: The hazard evaluation is based on data for
components or a similar material.

Specific Target Organ Toxicity - Repeated Exposure: The hazard evaluation is based on data for
components or a similar material.

ADDITIONAL TOXICOLOGY INFORMATION:

Nitrite salts can cause methemoglobin to form in the blood, resulting in a fall in blood pressure, cyanosis,
coma and possibly death. Infants are particularly susceptible to nitrite toxicity. Rats chronically exposed to
sodium nitrite in drinking water had pathological changes in heart and lung tissue.

SECTION 12 ECOLOGICAL INFORMATION

ECOTOXICITY
This material is expected to be toxic to aquatic organisms.
The product has not been tested. The statement has been derived from the properties of the individual
components.

_____________________________________________________________________
Revision Number: %%revision_number%% 5 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
MOBILITY
No data available.

PERSISTENCE AND DEGRADABILITY

This material is expected to be readily biodegradable. The biodegradability of this material is based on an
evaluation of data for the components or a similar material.
The product has not been tested. The statement has been derived from the properties of the individual
components.

POTENTIAL TO BIOACCUMULATE
Bioconcentration Factor: No data available.
Octanol/Water Partition Coefficient: No data available

SECTION 13 DISPOSAL CONSIDERATIONS

Use material for its intended purpose or recycle if possible. This material, if it must be discarded, may
meet the criteria of a hazardous waste as defined by international, country, or local laws and regulations.

SECTION 14 TRANSPORT INFORMATION

The description shown may not apply to all shipping situations. Consult 49CFR, or appropriate
Dangerous Goods Regulations, for additional description requirements (e.g., technical name) and
mode-specific or quantity-specific shipping requirements.

DOT Shipping Description: NOT REGULATED AS A HAZARDOUS MATERIAL UNDER 49 CFR

IMO/IMDG Shipping Description: NOT REGULATED AS DANGEROUS GOODS FOR TRANSPORT

UNDER THE IMDG CODE

ICAO/IATA Shipping Description: NOT REGULATED AS DANGEROUS GOODS FOR TRANSPORT

UNDER ICAO

Transport in bulk according to Annex II of MARPOL 73/78 and the IBC code:
Not applicable

SECTION 15 REGULATORY INFORMATION

EPCRA 311/312 CATEGORIES: 1. Immediate (Acute) Health Effects: YES

2. Delayed (Chronic) Health Effects: NO
3. Fire Hazard: NO
4. Sudden Release of Pressure Hazard: NO
5. Reactivity Hazard: NO

REGULATORY LISTS SEARCHED:

01-1=IARC Group 1 03=EPCRA 313
01-2A=IARC Group 2A 04=CA Proposition 65
01-2B=IARC Group 2B 05=MA RTK
02=NTP Carcinogen 06=NJ RTK
07=PA RTK

_____________________________________________________________________
Revision Number: %%revision_number%% 6 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
Sodium Nitrite 03, 05, 06, 07

CERCLA REPORTABLE QUANTITIES(RQ)/EPCRA 302 THRESHOLD PLANNING

QUANTITIES(TPQ):
Component Component RQ Component TPQ Product RQ
Sodium Nitrite 100 lbs None 3367 lbs

CHEMICAL INVENTORIES:
All components comply with the following chemical inventory requirements: AICS (Australia), DSL
(Canada), EINECS (European Union), ENCS (Japan), IECSC (China), KECI (Korea), PICCS
(Philippines), TSCA (United States).
Under the New Jersey Right-to-Know Act L. 1983 Chapter 315 N.J.S.A. 34:5A-1 et. seq., the product is to
be identified as follows: Refer to components listed in Section 3.

SECTION 16 OTHER INFORMATION

NFPA RATINGS: Health: 2 Flammability: 0 Reactivity: 0

HMIS RATINGS: Health: 2 Flammability: 0 Reactivity: 0

(0-Least, 1-Slight, 2-Moderate, 3-High, 4-Extreme, PPE:- Personal Protection Equipment Index
recommendation, *- Chronic Effect Indicator). These values are obtained using the guidelines or
published evaluations prepared by the National Fire Protection Association (NFPA) or the National Paint
and Coating Association (for HMIS ratings).

LABEL RECOMMENDATION:
Label Category : ANTIFREEZE/COOLANT 12 - AFC12

REVISION STATEMENT: This revision updates the following sections of this Safety Data Sheet: 1-16
Revision Date: APRIL 29, 2015

ABBREVIATIONS THAT MAY HAVE BEEN USED IN THIS DOCUMENT:

TLV - Threshold Limit Value TWA - Time Weighted Average
STEL - Short-term Exposure Limit PEL - Permissible Exposure Limit
GHS - Globally Harmonized System CAS - Chemical Abstract Service Number
ACGIH - American Conference of IMO/IMDG - International Maritime Dangerous
Governmental Industrial Hygienists Goods Code
API - American Petroleum Institute SDS - Safety Data Sheet
HMIS - Hazardous Materials Information NFPA - National Fire Protection Association (USA)
System
DOT - Department of Transportation (USA) NTP - National Toxicology Program (USA)
IARC - International Agency for Research on OSHA - Occupational Safety and Health
Cancer Administration
NCEL - New Chemical Exposure Limit EPA - Environmental Protection Agency
SCBA - Self-Contained Breathing Apparatus

Prepared according to the 29 CFR 1910.1200 (2012) by Chevron Energy Technology Company, 6001
Bollinger Canyon Road San Ramon, CA 94583.

_____________________________________________________________________
Revision Number: %%revision_number%% 7 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575
The above information is based on the data of which we are aware and is believed to be correct
as of the date hereof. Since this information may be applied under conditions beyond our
control and with which we may be unfamiliar and since data made available subsequent to the
date hereof may suggest modifications of the information, we do not assume any responsibility
for the results of its use. This information is furnished upon condition that the person
receiving it shall make his own determination of the suitability of the material for his particular
purpose.

_____________________________________________________________________
Revision Number: %%revision_number%% 8 of 8 Cat ® ELC (Extended Life Coolant)
Revision Date: APRIL 29, 2015 Extender
SDS : 10575