RENR7893-07

June 2010
Harness And Wire Electrical Schematic Symbols
Symbols

Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Marine Multi-Station Control System Sender: A component that is used with a temperature or pressure gauge. The sender

Electrical System
measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The
C9A1-UP (Engine) J2K1-UP (Engine) 9PW1-UP (Engine) electromagnet can open or close the switch part of the relay.
M7A1-UP (Engine) 3JK1-UP (Engine) CLX1-UP (Engine)
REA1-UP (Engine) 6MK1-UP (Engine) C7X1-UP (Engine) Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
RLA1-UP (Engine) 9WK1-UP (Engine) JKX1-UP (Engine) can open or close a valve or move a piece of metal that can do work.
C7B1-UP (Engine) NFL1-UP (Engine) RNX1-UP (Engine) Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
C9B1-UP (Engine) K1M1-UP (Engine) STX1-UP (Engine) activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
RXB1-UP (Engine) CSN1-UP (Engine) X9X1-UP (Engine) that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
WKB1-UP (Engine) CYN1-UP (Engine) Z9X1-UP (Engine)
RNC1-UP (Engine) GEN1-UP (Engine) RNY1-UP (Engine) Harness and Wire Symbols
C7D1-UP (Engine) T2P1-UP (Engine) X9Y1-UP (Engine) Deutsch connector: Typical representation Sure-Seal connector: Typical representation
1 1
RND1-UP (Engine) 9HP1-UP (Engine) C1Z1-UP (Engine) 2
of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins. 2
of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.
PLE1-UP (Engine) RNR1-UP (Engine) C3Z1-UP (Engine)
Harness Identification Letter(s):
RNE1-UP (Engine) 2XR1-UP (Engine) C7Z1-UP (Engine) Wire, Cable, or Harness Assembly Identification:
Includes Harness Identification Letters and Harness
(A, B, C, ..., AA, AB, AC, ...)

9ZF1-UP (Engine) 9WR1-UP (Engine) RNZ1-UP (Engine) Connector Serialization Codes Harness Connector Serialization Code: The "C" stands
for "Connector" and the number indicates which

M7G1-UP (Engine) GES1-UP (Engine) Part Number for

AG-C4 L-C12
connector in the harness. (C1, C2, C3, .....)
Part Number For
C-C4 AG-C3 Connector Plug
8RG1-UP (Engine) 3GS1-UP (Engine) 130-6795 130-6795 111-7898 3E-5179 Connector Recepticle

CKH1-UP (Engine) 9KS1-UP (Engine) 325-AG135 PK-14 1 5A

Pin Socket
C1J1-UP (Engine) KJT1-UP (Engine) Receptacle
Pin or Socket
Fuse
9X-1123 (5 Amps)
1ZJ1-UP (Engine) SLT1-UP (Engine) Single Wire
Connector
Number
Component
CYK1-UP (Engine) T3T1-UP (Engine) Plug Part Number
Harness identification code: 2 200-L32 BK-14
This example indicates wire
135 in harness "AG".
Typical Single Engine Installation Ground
Connection
Circuit Identification
Number Wire Color Wire Gauge

© 2010 Caterpillar Printed in U.S.A.

All Rights Reserved

30 Page, (Dimensions: 39 inches x 28 inches)

RENR7893-07
 MASTER STATION WITH BACKUP SHAFT SPEED SENSOR ELECTRONIC TROLL PROCESSOR
226-3424 256-4883
155-2267
7X-6222
STATION LOCKOUT SHAFT SPEED GN A GN-20 SHAFT SPEED SIGNAL RETURN BK-20 12 SIGNAL RETURN STARTER INTERLOCK 1
SWITCH SIGNAL RETURN BK B BK-20 SIGNAL RETURN (-)BATTERY BK-20 11 (-)BATTERY
3E-3364 155-2269 2
248-7494 SENSOR POWER(+) RD C RD-20 SENSOR POWER(+) BATTERY(+) RD-20 10
155-2252 1 RD-18 3
INTEGRATED CONTROL HEAD TROLL ENABLED RD-20 9 TROLL ENABLED 8T-8736
219-8022 1 2 BK-18 226-0417 4
SENSOR POWER(+) RD-20 8 SENSOR POWER(+)
220-2313 2 5
220-2315 7
3 LOCKOUT SWITCH BK-18 6
6
4 LOCKOUT BATTERY(+) RD-18 226-0417 7 D
SHAFT SPEED GN-20 5 SHAFT SPEED
CAN DATA LOOP 8
5
VALVE 2 (-) GN-20 4 VALVE 2 (-) E C
6 CAN DATA LOOP DKBU-18 9
TROLL VALVE VALVE 1 (+) WH-20 3 VALVE 1 (+)
CAN DATA (+) YL-18 10
7 155-2272 2 F A B
8 CAN DATA (-) GN-18 (-)BATTERY 11
9 CAN SHIELD BARE
226-0363 226-0363 VALVE 1 (+) 1 WH-20 VALVE 1 (+) ON JUMPER SIGNAL WH-20 1 12 EXPANSION G
J
VALVE 2 (-) 2 GN-20 VALVE 2 (-)
10 STATION LOCKOUT
BATTERY (+)
OR-14
RD-14 RD-14
155-2273
(+)BATTERY
(-)BATTERY 3 BK-20 (-)BATTERY RD-14 12 (+)BATTERY
13
14
INTERFACE H
11 1
TROLL ENABLED 4 RD-20 TROLL ENABLED BK-14 11 (-)BATTERY
12 BATTERY (-) BK-14 BK-14 (-)BATTERY 2 15
BARE 10 J1939 SHIELD TRIP CLEAR SWITCH 16
OR-14 STATION LOCKOUT 3
STATION LOCKOUT 226-0366 9
BARE CAN SHIELD 4 17
SWITCH 226-3414 8
3E-3364 155-2269 GN-18 CAN DATA (-) 5 18
248-7494 7
155-2252 1 RD-18 YL-18 CAN DATA (+) 6 155-2273 19
BACKUP PANEL YL-18 6 J1939 (+)
219-8023 1 2 BK-18 1 (+)BATTERY RD-14 20 103-0213
2 (-)BATTERY BK-14 GN-18 5 J1939 (-)
2 21
225-6107 225-6107 4
3 LOCKOUT SWITCH BK-18 3 STATION LOCKOUT OR-14 22
4 CAN SHIELD BARE OR-14 3 TROLL ENABLE 23
4 LOCKOUT BATTERY(+) RD-18
2 1 2 3 4 5 6 7 8 9 10 11 12 13 14
5 5 CAN DATA (-) GN-18 24 15 16 17 18 19 20 21 22 23 24 25 26 27 28
155-2273 6 CAN DATA (+) YL-18 1
6 29 30 31 32 33 34 35 36 37 38 39 40 41 42
RD-14 (+)BATTERY 1 160-7689
7 CAN DATA (+) YL-18 43 44 45 46 47 48 49 50 51 52 53 54 55 56
BK-14 (-)BATTERY 2 GY-18 SLOW VESSEL MODE 1
8 CAN DATA (-) GN-18 57 58 59 60 61 62 63 64 65 66 67 68 69 70

9 CAN SHIELD BARE OR-14 STATION LOCKOUT 3 2

226-0366 225-6107
10 STATION LOCKOUT OR-14 BARE CAN SHIELD 4 BK-18 START RELAY RETURN 3
(+)BATTERY RD-14 GN-18 CAN DATA (-) 5 4
11 CABLE TEE

RD-14
BK-14
OR-14
BARE
GN-18
YL-18
(-)BATTERY BK-14 YL-18 CAN DATA (+) 6 221-9506 YL-18 ATA DATA LINK (+) 5
12
6
7
OR-18 BACKUP ECM ACTIVE 8

ENABLE
SHIELD
155-2252

(+)BATTERY
(-)BATTERY
9

(-)
(+)
155-2273 YL-18 TRIP CLEAR SWITCH 10 KEY A

155-2273
RD-14 (+)BATTERY BU-18 ATA DATA LINK (-) 11

TROLL
1

J1939
J1939
J1939
BK-14 (-)BATTERY 2 RD-14 (+)BATTERY ECM(ECM BREAKER) 12
OR-14 (+)BATTERY SWITCHED 3 RD-14 (+)BATTERY ECM(ECM BREAKER) 13
225-6112 14
MARINE POWER DISPLAY BARE J1939 SHIELD 4 12 11 10 9 8 7

1
2
3
4
5
6
212-6188 GN-18 J1939 (-) 5 CABLE TEE 15
155-2252 YL-18 J1939 (+) 6 155-2273 221-9506 BR-18 STARTER INTERLOCK SWITCH 16
CONFIGURATION 1 1 1 (+)BATTERY RD-14 17
CONFIGURATION 2 2 2 (-)BATTERY BK-14 WH-18 BACKUP ECM READY 18
225-6107 225-6107
CONFIGURATION RTN 3 DK/BU-18 3 (+)BATTERY SWITCHED OR-14 GY-18 LOW COOLANT LEVEL LAMP 19 1 2 3 4 5 6

EXTERNAL ALARM 4 4 J1939 SHIELD BARE WH-18 LOAD FEEDBACK SIGNAL 20

BUS NEGATIVE 5 5 J1939 (-) GN-18 OR-18 GENERAL ALARM DRIVER 21
155-2273 6 J1939 (+) YL-18 22
BUS POSITIVE 6
RD-14 (+)BATTERY 1 RD-14 (+)BATTERY ECM(ECM BREAKER) 23
J1939 (+) 7 J1939 (+) YL-18
BK-14 (-)BATTERY 2 PK-18 SECONDARY THROTTLE (PWM) 24
J1939 (-) 8 J1939 (-) GN-18
OR-14 (+)BATTERY SWITCHED 3 155-2253
J1939 SHIELD 9 J1939 SHIELD BARE BR-18 PRIMARY THROTTLE (PWM) 25
225-6112 225-6107
BARE J1939 SHIELD 4

1
2
3
4
5
6

1
2
3
4
5
6
MPD ENABLE 10 (+)BATTERY SWITCHED OR-14 26
225-6107

155-2273
11 (+)BATTERY RD-14 GN-18 J1939 (-) 5 27 KEY B
POSITIVE BATTERY CABLE TEE

J1939 SHIELD
(+)BATTERY
(-)BATTERY
TROLL ENABLE

J1939 (-)
J1939 (+)
(-)BATTERY BK-14 YL-18 J1939 (+) 6 221-9506 28
NEGATIVE BATTERY 12
29

120
30
31 12 11 10 9 8 7

J1939 SHIELD
(+)BATTERY
(-)BATTERY
TROLL ENABLE

J1939 (-)
J1939 (+)
TERMINATION BK-18 MULTI-STATION CONTROL SYSTEM RETURN 32
225-6116
RESISTOR BR-18 TROLL ENABLE (ETP) 33
208-0432 34
ENGINE

RD-14
BK-14
OR-14
BARE
GN-18
YL-18
35
8T-8736 1 2 3 4 5 6

A (+)BATTERY SWITCHED RD-18 155-2264

36
37
ELECTRONIC CONTROL MODULE
KEYSWITCH / ALARM PANEL
1 KEYSWITCH OR-18 INTERFACE

155-2273
B (-)BATTERY BK-18 217-3865 BK-14 (-)BATTERY ECM 38

RD-14
BK-14
OR-14
BARE
GN-18
YL-18
225-6118 2 BK-14 (-)BATTERY ECM
C 39
D CAT DATA LINK (+) OR-18 3 REMOTE START BR-18 YL-18 SYNC SWITCH INPUT 2 40
SERVICE TOOL (+)BATTERY RD-14
E CAT DATA LINK (-) GN-18 4 BARE-18 J1939 (SHIELD) 41 155-2254
CONNECTOR 226-0361 226-0361

1
2
3
4
5
6
3E-3382
F 5 DIAGNOSTIC INDICATOR WH-18 225-6107 GY-18 42
G 6 WARNING INDICATOR GN-18 YL-18 43 KEY C
H 7 REMOTE SHUTDOWN BU-18 BU-18 103-0213 9X-4391 44
8 (-)BATTERY BK-14 BK-14 101-RD 1 (+)BATTERY ECM(ECM BREAKER) RD-14 45
J
YL-18 PCP ALARM 229-BK 2 (-)BATTERY ECM BK-14 46

PCP ALARM
229-BK 3 (-)BATTERY ECM BK-14 BK-14 (-)BATTERY ECM 47 MARINE 12 11 10 9 8 7

M972-PK 4 SECONDARY THROTTLE (PWM) PK-18 J1939 (-) 48

REMOTE ENGINE
SHUTDOWN SWITCH 2
3E-3364
DKBU-18
+ - 1
155-2269
RD-18 101-RD 5 (+)BATTERY ECM(ECM BREAKER) RD-14 PK-14 REMOTE START 49 JUNCTION
945-BR CAT DATA LINK (-) BR-18 BU-18 DIAGNOSTIC LAMP 50
BOX
OPEN TO RUN 1 BK-18 2 BK-18 6
NOTE B
944-OR 7 CAT DATA LINK (+) OR-18 GY-18 HIGH COOLANT TEMPERATURE LAMP 51
1 2 3 4 5 6

225-6122
101-RD 8 (+)BATTERY ECM(ECM BREAKER) RD-14 BU-18 MAINTENANCE CLEAR 52
229-BK 9 (-)BATTERY ECM BK-14 BR-18 SYNC SWITCH INPUT 1 53
225-6118 M971-BR 10 PRIMARY THROTTLE (PWM) BR-18 OR-18 CAT DATA LINK (+) 54
C212-BK 11 MULTI-STATION CONTROL SYSTEM RETURN BK-18 55
F427-PK 12 HOUR METER (+) PK-18 56
L464-BR 13 HOUR METER (-) BR-18 57 160-7689
450-YL 14 TACHOMETER (+) YL-18 J1939 (+) 58
451-BR 15 TACHOMETER (-) BR-18 VT-14 REMOTE ENGINE SHUTDOWN SWITCH 59
A234-BK 16 J1939 (SHIELD) BARE-18 BR-18 WARNING INDICATOR 60
K900-YL 17 J1939 (+) YL-18 GY-18 LOW OIL PRESSURE INDICATOR 61
CONTROL STATION #1 WITH BACKUP K990-GN 18 J1939 (-) GY-18 YL-18 MAINTENANCE INDICATOR 62
STATION LOCKOUT
L460-YL 19 TRIP CLEAR SWITCH YL-18 PK-18 HOUR METER (+) 63
SWITCH
248-7494 3E-3364 155-2269 L463-GY 20 LOW COOLANT LEVEL LAMP GY-18 BR-18 HOUR METER (-) 64
155-2273
155-2252 1 RD-18 F401-GY 21 HIGH COOLANT TEMPERATURE LAMP GY-18 BR-18 TACHOMETER (-) 65
INTEGRATED CONTROL HEAD RD-14 (+)BATTERY 1 225-6116
1 2 BK-18 TO ENGINE ECM F424-YL 22 MAINTENANCE INDICATOR YL-18 YL-18 TACHOMETER (+) 66
219-8022 BK-14 (-)BATTERY 2
220-2313 2 F400-GY 23 LOW OIL PRESSURE LAMP GY-18 VT-18 TROLLING MODE 67
220-2315 OR-14 STATION LOCKOUT 3
3 LOCKOUT SWITCH BK-18 226-0366 F429-BU 24 DIAGNOSTIC LAMP BU-18 BR-18 CAT DATA LINK (-) 68
LOCKOUT BATTERY(+) RD-18 BARE CAN SHIELD 4
4 F473-YL 25 WARNING LAMP BR-18 BR-14 KEYSWITCH 69
GN-18 CAN DATA (-) 5
5 F889-WH 26 LOAD FEEDBACK SIGNAL WH-18 70
YL-18 CAN DATA (+) 6 155-2273
6 H417-OR 27 BACKUP ECM ACTIVE OR-18
1 (+)BATTERY RD-14
7 CAN DATA (+) YL-18 H419-WH 28 BACKUP ECM READY WH-18 155-2273
2 (-)BATTERY BK-14
8 CAN DATA (-) GN-18 225-6107 225-6107 391-PK 29 REMOTE START PK-14 RD-14 (+)BATTERY 1
3 STATION LOCKOUT OR-14
9 CAN SHIELD BARE J906-BR 30 KEYSWITCH BR-14 BK-14 (-)BATTERY 2 3E-3364 3E-3382
226-0366 4 CAN SHIELD BARE
10 STATION LOCKOUT OR-14
5 CAN DATA (-) GN-18 E794-YL 31 ATA DATA LINK (+) YL-18
225-6107 225-6107
OR-14 (+)BATTERY SWITCHED 3 CAN
11 (+)BATTERY RD-14 BARE J1939 SHIELD 4
12 (-)BATTERY BK-14 RD-14
155-2273
(+)BATTERY 1
6 CAN DATA (+) YL-18 E793-BU 32
33
ATA DATA LINK (-) BU-18
GN-18 J1939 (-) 5
INTERFACE
6 1
BK-14 (-)BATTERY 2 M973-BR 34 SYNC SWITCH INPUT 1 BR-18 YL-18 J1939 (+) 6
M974-YL 35 SYNC SWITCH INPUT 2 YL-18 1 2
OR-14 STATION LOCKOUT 3 5 2
225-6107 G966-PU 36 REMOTE ENGINE SHUTDOWN SWITCH VT-14 155-2252
BARE CAN SHIELD 4 4 3
GN-18 CAN DATA (-) 5 F425-PU 37 TROLLING MODE VT-18 BU-18 WARNING LAMP 1
CABLE TEE
YL-18 CAN DATA (+) 6 R819-GY 38 SLOW VESSEL MODE GY-18 BR-18 DIAGNOSTIC LAMP 2
221-9506
F426-BU 39 MAINTENANCE CLEAR BU-18 WH-18 LOW OIL PRESSURE LAMP 3
STATION LOCKOUT
SWITCH 40 GN-18 HIGH COOLANT TEMPERATURE LAMP 4
248-7494 3E-3364 155-2269 X994-BR 41 STARTER INTERLOCK SWITCH BR-18 OR-18 MAINTENANCE INDICATOR LAMP 5
155-2273
BACKUP PANEL
1 RD-18
RD-14 (+)BATTERY 1
C214-BK 42 START RELAY RETURN BK-18
225-6102 YL-18 MAINTENANCE CLEAR SWITCH 6 CUSTOM 155-2264 155-2269
1 2 BK-18 GY-18 HOUR METER(-)
219-8023
2
BK-14 (-)BATTERY 2
X416-OR
K883-BR
43
44
GENERAL ALARM DRIVER
TROLL ENABLE (ETP)
OR-18
BR-18 VT-18 HOUR METER(+)
7
8
PANEL INTERFACE
OR-14 STATION LOCKOUT 3
3 LOCKOUT SWITCH BK-18 226-0366 45 RD/GN-18 TACHOMETER(-) 9
LOCKOUT BATTERY(+) RD-18 BARE CAN SHIELD 4
4 46 PK-18 TACHOMETER(+) 10
1 8
GN-18 CAN DATA (-) 5
5 47 TN-18 BATTERY(-) 11
2 7
YL-18 CAN DATA (+) 6 155-2273 2 1
3 6
6 48 RD-18 KEYSWITCH 12
1 (+)BATTERY RD-14 4 5
7 CAN DATA (+) YL-18 49
2 (-)BATTERY BK-14
8 CAN DATA (-) GN-18 225-6107 225-6107 50 155-2252
3 STATION LOCKOUT OR-14
9 CAN SHIELD BARE 51 DBU-18 BATTERY (-) DBU-18 1
226-0366 4 CAN SHIELD BARE
10 STATION LOCKOUT OR-14 52 GN-18 ENABLE GN-18 2
5 CAN DATA (-) GN-18
11 (+)BATTERY RD-14 155-2273 53 OR-18 SYNC SWITCH INPUT 2 OR-18 3
6 CAN DATA (+) YL-18
12 (-)BATTERY BK-14 226-0367
RD-14 (+)BATTERY 1 54 CUSTOM PANEL BREAKOUT 4
226-3422 155-2273 155-2267
BK-14 (-)BATTERY 2 55 BARE SHIELD BARE 5
OR-14 STATION LOCKOUT 3 56
155-2252 RD-18 PRIMARY THROTTLE PWM 6 THROTTLE
225-6107 WARNING LAMP 1 BU-18 BARE SHIELD
BARE
GN-18
CAN SHIELD
CAN DATA (-)
4
5
57
58 DIAGNOSTIC LAMP 2 BR-18 WH-18 SECONDARY THROTTLE PWM
7
8
INTERFACE
CABLE TEE
YL-18 CAN DATA (+) 6 59 LOW OIL PRESSURE LAMP 3 WH-18 BU-18 SVM 9
1 6
B
221-9506 A
60 HIGH COOLANT TEMPERATURE LAMP 4 GN-18 RD-18 10 2 5

MARINE POWER DISPLAY 61 MAINTENANCE INDICATOR LAMP 5 OR-18 WH-18 11 3 4

212-6188 225-6102
62 MAINTENANCE CLEAR SWITCH 6 YL-18 BU-18 12 C
155-2273
155-2252 63 HOUR METER(-) 7 GY-18
RD-14 (+)BATTERY 1
CONFIGURATION 1 1 64 HOUR METER(+) 8 VT-18 155-2264
BK-14 (-)BATTERY 2
CONFIGURATION 2 2 65 TACHOMETER(-) 9 RD/GN-18 OR-18 KEYSWITCH 1
OR-14 (+)BATTERY SWITCHED 3
CONFIGURATION RTN 3 DK/BU-18 225-6112 66 TACHOMETER(+) 10 PK-18 YL-18 PCP ALARM 2
BARE J1939 SHIELD 4
EXTERNAL ALARM 4 67 BATTERY(-) 11 TN-18 BU-18 BU-18 REMOTE SHUTDOWN 3 155-2272
GN-18 J1939 (-) 5
BUS NEGATIVE 5
YL-18 J1939 (+) 6 155-2273 68 KEYSWITCH 12 RD-18
226-0361
BR-18 REMOTE START 4 KEYSWITCH/ALARM
BUS POSITIVE 6 WH-18 DIAGNOSTIC INDICATOR
J1939 (+) 7 J1939 (+) YL-18
1 (+)BATTERY
(-)BATTERY
RD-14
BK-14
69
70 GN-18 WARNING INDICATOR
5
6
PANEL INTERFACE
2
30 Page, (Dimensions: 39 inches x 28 inches)

J1939 (-) 8
9
J1939 (-)
J1939 SHIELD
GN-18
BARE
3 (+)BATTERY SWITCHED OR-14
225-6107 225-6107 BK-14 BK-18 (-)BATTERY 7 SYNC PANEL CAT DATA LINK PCP POWER 1 4
J1939 SHIELD RD-14 (+)BATTERY 8
MPD ENABLE 10 (+)BATTERY SWITCHED OR-14
225-6112 4
5
J1939 SHIELD
J1939 (-)
BARE
GN-18
226-0361 NEGATIVE POSITIVE INTERFACE INTERFACE INTERFACE 2 3
POSITIVE BATTERY 11 (+)BATTERY RD-14 155-2273 6 J1939 (+) YL-18
BATTERY

10
11
12
NEGATIVE BATTERY 12 (-)BATTERY BK-14 3E-3364

1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8
9
10
11
12
RD-14 (+)BATTERY 1 REMOTE ENGINE CONNECTION

1
2
3
4
5
6
7
8
9
DKBU-18 2

155-2264

155-2254
BK-14 (-)BATTERY 2 OPEN TO RUN SHUTDOWN SWITCH
BK-18 1

(+)BATTERY SWITCHED

CAT DATA LINK (+)

CAT DATA LINK (-)

(-)BATTERY
OR-14 (+)BATTERY SWITCHED 3 NOTE B
225-6107 NOTE A

PORT (+)BATTERY SWITCHED

STARBOARD (+)BATTERY SWITCHED

EXTERNAL ALARM COMMON

EXTERNAL ALARM NORMALLY CLOSED
(-)BATTERY
(+)BATTERY1 PRIMARY
(+)BATTERY2 PRIMARY
(+)BATTERY2 SECONDARY
(+)BATTERY1 SECONDARY
(-)BATTERY
BARE J1939 SHIELD 4
GN-18 J1939 (-) 5 CUSTOMER INSTALLED
CABLE TEE
YL-18 J1939 (+) 6 221-9506

BATTERY REVERSE ISOLATOR

225-6118
BATTERY BATTERY
TERMINATION

RD-18

OR-18
GN-18

BK-18
RENR7893-07

RESISTOR
225-6107 208-0432
1 12V or 24V 12V or 24V
2
3
4 120

225-6118
5
155-2273 6
RD-14 (+)BATTERY 1

CONTROL STATION WITH BACKUP (END) BK-14

OR-14
(-)BATTERY
(+)BATTERY SWITCHED
2
3
225-6118

225-6107 225-6107

RD-18

GN-18

OR-18
BK-18
BK-14
RD-14
GN-14
BU-14
WH-14
BR-14
BARE CAN DATA SHIELD 4
GN-18 CAN DATA (-) 5 155-2264 THIS SCHEMATIC IS FOR THE MULTI-STATION CONTROL SYSTEM
STATION LOCKOUT YL-18 CAN DATA (+) 6 155-2273 RD-14 (+)BATTERY 1 (TYPICAL SINGLE ENGINE INSTALLATION)
SWITCH 1 (+)BATTERY RD-14 BK-14 (-)BATTERY 2

226-0369
3E-3364 155-2269
248-7494 155-2273 2 (-)BATTERY BK-14 YL-18 CAN DATA (+) 3 NOTE A: NOT USED WHEN A PCP IS INSTALLED.
INTEGRATED CONTROL HEAD
1
155-2252 1
2
RD-18
BK-18
RD-14 (+)BATTERY 1 3 STATION LOCKOUT OR-14 226-0365 GN-18 CAN DATA (-) 4 BACKUP CONNECT JUMPER FOR 24V SYSTEM VOLTAGE NOTE B: THIS CONNECTION MAY BE USED WITH THE ENGINE SHUTDOWN
219-8022 BARE CAN SHIELD
220-2313 2
BK-14
OR-14
(-)BATTERY
STATION LOCKOUT
2
3
4
5
CAN SHIELD
CAN DATA (-)
BARE
GN-18
5
6
STATION REMOVE JUMPER FOR 12V SYSTEM VOLTAGE
CIRCUIT OF THE FIRE SUPPRESSION SYSTEM FOR THE VESSEL.
220-2315 3 LOCKOUT SWITCH BK-18 CABLE TEE
226-0366
BARE CAN SHIELD 4 221-9506 6 CAN DATA (+) YL-18 7
4 LOCKOUT BATTERY(+) RD-18
GN-18 CAN DATA (-) 5 OR-14 STATION LOCKOUT 8 155-2254
5
YL-18 CAN DATA (+) 6 155-2273 1 PORT (+)BATTERY SWITCHED RD-18
6
1 (+)BATTERY RD-14 155-2264 2 SELECT RETURN DKBU-18
7 CAN DATA (+) YL-18
2 (-)BATTERY BK-14 RD-14 BATTERY (+) 1 3 STARBOARD (+)BATTERY SWITCHED GN-18
8 CAN DATA (-) GN-18 225-6107
3 STATION LOCKOUT OR-14 BK-14 BATTERY (-) 2 4 24V SYSTEM SELECT
POWERTRAIN
9 CAN SHIELD BARE 226-0363 226-0363
226-0366 TERMINATION 4 CAN SHIELD BARE YL-18 CAN DATA (+) 3 5 EXTERNAL ALARM COMMON OR-18
10 STATION LOCKOUT OR-14
RESISTOR 5 CAN DATA (-) GN-18 GN-18 CAN DATA (-) 4 MASTER POWER 6 EXTERNAL ALARM NORMALLY CLOSED BK-18
226-0369

CONTROL
11 (+)BATTERY RD-14 208-0432 6 CAN DATA (+) YL-18
12 (-)BATTERY BK-14
1
BARE CAN SHIELD
CAN DATA LOOP
5
6
STATION 7
8
(-)BATTERY
(+)BATTERY1 PRIMARY
BK-14
RD-14
2
3
DKBU-18 CAN DATA LOOP 7 PROCESSOR 9 (+)BATTERY2 PRIMARY GN-14 Control / Item Description
OR-14 STATION LOCKOUT 8 10 (+)BATTERY2 SECONDARY BU-14
120 4
5
219-8020 11 (+)BATTERY1 SECONDARY WH-14 207-4496 SYNC PANEL
CABLE TEE 155-2264 12 (-)BATTERY BR-14
6
208-0432 J1939/CAN TERMINATION RESISTOR
221-9506 155-2273 RD-14 (+)BATTERY 1
STATION LOCKOUT 1 (+)BATTERY RD-14 BK-14 (-)BATTERY 2 267-8623 MARINE POWER DISPLAY (MPD)
SWITCH 2 (-)BATTERY BK-14 YL-18 CAN DATA (+) 3 217-3865 KEYSWITCH / ALARM
155-2252
248-7494 3E-3364 155-2269
1 RD-18
155-2273 3 STATION LOCKOUT OR-14 226-0365 GN-18 CAN DATA (-) 4 CONTROL 219-8020 POWERTRAIN CONTROL PROCESSOR (PCP)
BACKUP PANEL
219-8023 1 2 BK-18
RD-14
BK-14
(+)BATTERY
(-)BATTERY
1
2
4
5
CAN SHIELD
CAN DATA (-)
BARE
GN-18
BARE CAN SHIELD 5
6
STATION 219-8021 CONTROL STATION PROCESSOR (CSP)
2
OR-14 STATION LOCKOUT 155-2273
3 LOCKOUT SWITCH BK-18 226-0366
BARE CAN SHIELD
3
4 RD-14 (+)BATTERY 1
6 CAN DATA (+) YL-18
OR-14 STATION LOCKOUT
7
8
PORT PORT STARBOARD STARBOARD 219-8022 INTEGRATED CONTROL HEAD (ICH) chrome
4 LOCKOUT BATTERY(+) RD-18
5
GN-18 CAN DATA (-) 5 BK-14 (-)BATTERY 2 TRANSMISSION ECM/ETP ECM/ETP TRANSMISSION 219-8023 BACKUP PANEL (BS)
YL-18 CAN DATA (+) 6 155-2273 OR-14 (+)BATTERY SWITCHED 3
6 225-6107 225-6107 256-4883 ELECTRONIC TROLL PROCESSOR (ETP)

10
11
12

10
11
12
1 (+)BATTERY RD-14 BARE CAN DATA SHIELD 4 TERMINATION

1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
7 CAN DATA (+) YL-18 220-2313 INTEGRATED CONTROL HEAD (ICH) black
2 (-)BATTERY BK-14 GN-18 CAN DATA (-) 5 RESISTOR

155-2264

155-2252
8 CAN DATA (-) GN-18 225-6107 208-0432
3 STATION LOCKOUT OR-14 YL-18 CAN DATA (+) 6 220-2315 INTEGRATED CONTROL HEAD (ICH) gold
9 CAN SHIELD BARE 1

(+)V FORWARD

(+)V REVERSE
(-)V REVERSE

(-)V FORWARD
226-0366 TERMINATION 4 CAN SHIELD BARE

NOT USED
NOT USED
10 STATION LOCKOUT OR-14
RESISTOR 2
221-9506 J1939/CAN TEE
5 CAN DATA (-) GN-18
11 (+)BATTERY RD-14 208-0432 6 CAN DATA (+) YL-18 3 221-9507 BUTTON PANEL (BP) chrome
12 (-)BATTERY BK-14
1 4

J1939 SHIELD
ENABLE

PRIMARY THROTTLE PWM

SYNC SWITCH INPUT 2
SECONDARY THROTTLE PWM
SVM

J1939 (+)
J1939 (-)
120 SLIM LINE CONTROL HEAD - RIGHT SLANT HANDLE
2 CABLE TEE 5
3 221-9506 6 223-8200 THROTTLE clear
120 4 223-8201 GEAR clear
5
CABLE TEE 223-8204 DUAL clear
6 221-9506

RD-18

OR-18
GN-18
WH-18
BU-18
BK-18
FORWARD
SOLENOID (+)V FORWARD
223-8205 THROTTLE black
MARINE POWER DISPLAY
212-6188 (-)V FORWARD 223-8206 GEAR black
155-2273 (+)V REVERSE
155-2252

226-0371
RD-14 (+)BATTERY 1
223-8208 DUAL black
CONFIGURATION 1 1 REVERSE (-)V REVERSE
BK-14 (-)BATTERY 2 SOLENOID SLIM LINE CONTROL HEAD - STRAIGHT HANDLE
CONFIGURATION 2 2

GN-18

RD-18
OR-18
WH-18
BU-18

YL-18
GN-18
BARE
OR-14 (+)BATTERY SWITCHED 3 223-8211 THROTTLE clear
CONFIGURATION RTN 3 DK/BU-18 225-6112
BARE J1939 SHIELD 4
EXTERNAL ALARM 4
GN-18 J1939 (-) 5 223-8213 GEAR clear
BUS NEGATIVE 5
YL-18 J1939 (+) 6 155-2273
BUS POSITIVE 6 223-8214 DUAL clear
1 (+)BATTERY RD-14
J1939 (+) 7 J1939 (+) YL-18 223-8216 THROTTLE black
2 (-)BATTERY BK-14
226-0371

J1939 (-) 8 J1939 (-) GN-18 225-6107

3 (+)BATTERY SWITCHED OR-14 226-0367 226-0367 223-8218 GEAR black
J1939 SHIELD 9 J1939 SHIELD BARE
225-6112 TERMINATION 4 J1939 SHIELD BARE
MPD ENABLE 10 (+)BATTERY SWITCHED OR-14 RESISTOR J1939 (-) 155-2273 223-8219 DUAL black
5 GN-18
POSITIVE BATTERY 11 (+)BATTERY RD-14 208-0432 1 SLIM LINE CONTROL HEAD - LEFT SLANT HANDLE
6 J1939 (+) YL-18 3E-3382 155-2273
NEGATIVE BATTERY 12 (-)BATTERY BK-14 2
1
(+)V FORWARD 1 (+)V FORWARD RD-18 223-8220 THROTTLE clear
2 3
(+)V REVERSE 2 (+)V REVERSE OR-18 J1939 SHIELD BARE 223-8221 GEAR clear
3 4
(-)V REVERSE 3 (-)V REVERSE GN-18 226-0367
4 5 J1939 (-) GN-18
120 4 NOT USED WH-18 155-2273
223-8222 DUAL clear
5 6 J1939 (+) YL-18
CABLE TEE 5 NOT USED BU-18 RD-14 (+)BATTERY 223-8223 THROTTLE black
6 1
221-9506 (-)V FORWARD (-)V FORWARD BK-18
6 BK-14 (-)BATTERY 2
225-6107 225-6107
223-8224 GEAR black
OR-14 (+)BATTERY SWITCHED 3
BARE J1939 SHIELD 4 223-8225 DUAL black
GN-18 J1939 (-) 5
YL-18 J1939 (+) 6 155-2273
1 (+)BATTERY RD-14 224-9873 BUTTON PANEL (BP) black
2 (-)BATTERY BK-14 224-9874 BUTTON PANEL (BP) gold
3 (+)BATTERY SWITCHED OR-14
225-6107 225-6122 MARINE JUNCTION BOX (MJB) - SINGLE ENGINE
4 J1939 SHIELD BARE
CABLE TEE 5 J1939 (-) GN-18 226-3422 CUSTOM PANEL BREAKOUT
221-9506 6 J1939 (+) YL-18 226-3424 SHAFT SPEED SENSOR
229-3689 SIDE MOUNT CONTROL HEAD - DUAL - LEFT HANDLE
229-3690 SIDE MOUNT CONTROL HEAD - DUAL - RIGHT HANDLE

TYPICAL CONTROL STATION CONFIGURATION Harness Chg Description

THE MAXIMUM NUMBER OF MASTER STATIONS IS 1.
THE MAXIMUM NUMBER OF CONTROL STATIONS IS 7. 225-6102 00 MJB TO CUSTOM PANEL
Control Station #7 with Backup(End) Control Station #6 with Backup Control Station #5 with Backup Control Station #4 with Backup Control Station #3 with Backup Control Station #2 with Backup Control Station #1 with Backup Master Station with Backup WIRE COLOR
225-6107 03 TEE TO TEE
225-6112 02 TEE TO MPD
ABBREVIATIONS 225-6116 02 ECM TO MJB
CSP Backup MPD CSP Backup MPD CSP Backup MPD CSP Backup MPD CSP Backup MPD CSP Backup MPD CSP Backup MPD CSP Backup MPD
ICH ICH ICH ICH ICH ICH ICH ICH BK BLACK 225-6118 03 CDL TO MJB
BR BROWN
225-6120 02 MJB TO SYNC PANEL see other side
226-0361 02 MJB TO KEYSWITCH
BU BLUE
226-0363 02 PCP TO MS, CS, BS
Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE Cable TEE GN GREEN 226-0365 00 TEE TO PCP
GY GRAY 226-0366 01 TEE TO BS, CSP, ICH
226-0367 04 PCP TO MJB AND TEE
OR ORANGE
120 120 120 226-0369 02 MJB TO PCP PWR
KEY CDL PK PINK
Alarm 226-0371 03 PCP TO GEAR
PU PURPLE 226-0411 02 BP TO CSP see other side
RD RED 226-0417 01 ETP TO SENSOR AND VALVE
226-3414 00 TEE TO ETP
VT VIOLET
226-3415 02 TPS TO MJB - SINGLE ENGINE see other side
MARINE JUNCTION BOX WH WHITE 226-3419 02 THROTTLE/GEAR "Y" HARNESS see other side
POWERTRAIN CONTROL PROCESSOR YL YELLOW