Safety Data Sheet

Washmatic DM-1522
Version：V1.0.0.1
Creation Date：2015/11/19
Revision Date：2015/11/19

*Prepared according to UN GHS (the 5th revised edition)

1 Identification of the chemical and supplier

| Product identifier
Product Name Washmatic DM-1522
Cat No. 132700
Synonyms -
CAS No. 9003-01-4
EC No. 202-415-4
Molecular Formula (C3H4O2)n

| Relevant identified uses of the substance or mixture and uses advised against
Relevant identified uses Please consult manufacturer.
Uses advised against Please consult manufacturer.

| Details of the supplier of the Safety Data Sheet

Name of the company Dymatic Chemicals, Inc.
Address of the
Haiwei Section, Ronggui, Shunde, Foshan, Guangdong, China
company
Post code 528303
Telephone number 0757-28399088
Fax number 0757-28396930
E-mail address dengdh@dymatic.com

| Emergency phone number

Emergency phone
0757-29262922
number

2 Hazards identification
| Hazard classification according to GHS
Hazard classification
Not applicable
according to GHS

| Label elements

Hazard pictograms Not applicable

Signal word Not applicable

| Hazard statements
1/8
Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

Hazard statements Not applicable

| Precautionary statements

 Prevention
Prevention Not applicable

 Response
Response Not applicable

 Storage
Storage Not applicable

 Disposal
Disposal Not applicable

| Hazard description
 Physical and chemical hazards
No information available

 Health hazards
The product is not thought to produce either adverse health effects or irritation
Inhaled
of the respiratory tract following discomfort.
Accidental ingestion of the product may be harmful to the health of the
Ingestion
individual.
Entry into the blood-stream, through, for example, cuts, abrasions or lesions,
Skin Contact
may produce systemic injury with harmful effects.
This product may cause temporary discomf ort following direct contact with the
Eye
eye.

 Environmental hazards
Please refer to 12th chapter of SDS.

3 Composition/information on ingredients

Component Cas No. EC No. Concentration (weight percent, %)

2-Propenoic acid,
9003-01-4 202-415-4 Commercial secrets
homopolymer

4 First aid measures

| Description of first aid measures
Immediate medic al attention is required. Show this safety data sheet (SDS) to
General advice
the doctor in attendance.
Rinse thoroughly with plenty of water for at least 15 minutes and consult a
Eye contact
physician if fell uncomfortable.
Take off contaminated clothing and shoes immediately. Wash off with plenty of
Skin contact
water for at least 15 minutes and consult a physician if fell uncomfortable.
Ingestion Do not induc e vomiting. Never give anything by mouth to an unconscious
2/8
Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

person. Call a physician or Poison Control Center immediately.

Move victim into fresh air. If breathing is difficult, give oxygen. Do not use
Inhalation mouth to mouth resusc itation if victim ingested or inhaled the substance. If not
breathing, give artificial respiration and consult a physician immediately.
Ensure that medical personnel are aware of the substance involved. Take
Protecting of first-aiders
precautions to protect themselves and prevent spread of contamination.

| Most important symptoms and effects, both acute and delayed

Substance accumulation, in the human body, may occur and may cause some concern following
1
repeated or long-term occupational exposure.

| Indication of any immediate medical attention and special treatment needed

1 Treat symptomatically.
2 Symptoms may be delayed.

5 Firefighting measures
| Extinguishing media
Suitable extinguishing
dry chemical, carbon dioxide, water spray,alcohol-resistant foam.
media
Unsuitable exting uishing
Do not use a solid water stream as it may scatter or spread fire.
media

| Specific hazards arising from the substance or mixture

1 Containers may explode when heated.
2 Fire exposed containers may vent contents through pressure relief valves .
3 May expansion or decompose explosively when heated or involved in fire.

| Advice for firefighters

As in any fire, wear self-contained breathing apparatus （MSHA/NIOSH approved or equivalent)and
1
full protective gear.
2 Fight fire from a safe distance, with adequate cover.
3 Prevent fire extinguishing water from contaminating surface water or the ground water system.

6 Accidental release measures

| Personal precautions, protective equipment and emergency procedures
1 Ensure adequate ventilation. Remove all sources of ignition.
2 Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak.
3 Use personal protective equipment. Avoid breathing vapours, mist, gas or dust.

| Environmental precautions
1 Prevent further leakage or spillage if safe to do so.
2 Discharge into the environment must be avoided.

| Methods and materials for containment and cleaning up

Absorb spilled material in dry sand or inert absorbent. In case of large amount of spillage, contain a
1
spill by bunding.
Adhered or collected material should be promptly disposed of, in accordance with appropriate laws
2
and regulations.
3 Remove all sources of ignition. Use spark-proof tools and explosion-proof equipment.

7 Handling and storage 3/8

Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

| Precautions for handling

1 Handling is performed in a well ventilated place.
2 Wear suitable protective equipment.
3 Avoid contact with skin and eyes.
4 Keep away from heat/sparks/open flames/ hot surfaces.
5 Take precautionary measures against static discharges.

| Precautions for storage

1 Keep containers tightly closed .
2 Keep containers in a dry, cool and well-ventilated place.
3 Keep away from heat/sparks/open flames/ hot surfaces.
4 Store away from incompatible materials and foodstuff containers.

8 Exposure controls/personal protection

| Control parameters

 Occupational Exposure limit values

Occupational Exposure limit
No information available
values

 Biological limit values

Biological limit values No information available

 Monitoring methods
EN 14042 Workplace atmospheres. Guide for the application and use of procedures for the assessment
1
of exposure to chemical and biological agents.
2 GBZ/T 160.1~GBZ/ T 160.81-2004 Determination of tox ic substanc es in workplace air（Series standard）.

| Engineering controls
1 Ensure adequate ventilation, especially in confined areas.
2 Ensure that eyewash stations and safety showers are close to the workstation location.
3 Use explosion-proof electrical/ventilating/lighting/equipment.
4 Set up emergency exit and necessary risk-elimination area.

| Personal protection equipment

General requirement

Eye protection Tightly fitting safety goggles (approved by EN 166(EU) or NIOSH (US).
Wear protective gloves（such as butyl rubber）, passing the tests according to
Hand protection
EN 374(EU),US F739 or AS/NZS 2161.1 standard.
If exposure limits are exceeded or if irritation or other symptoms are
Respirator y protection experienced, use a full-face respirat or with multi-purpose combination (US ) or
type AXBEK (EN 14387) respirator cartridges.
Skin and body protection Wear fire/flame resistant/retardant clothing and antistatic boots.

9 Physical and chemical properties

4/8
Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

| Physical and chemical properties

Appearance Colorless or yellowish transparent liquid
Odor light
Odor threshold No information available
pH 8.0~10.0（1% aqueous solution）
Melting point/freezing
No information available
point(℃)
Initial boiling point and
>35
boiling range(℃)
Flash point(Closed
No information available
cup,℃)
Evaporation rate No information available
Flammability(solid, gas) Not applicable
Upper/lower explosive
Upper limit：No information available；Lower limit：No information available
limits[%(v/v)]
Vapor pressure(kPa) No information available
Vapor density(Air＝1) No information available
Relative
1.1-1.2
density(Water=1)
Solubility(mg/L) Miscible with water
n-octanol/water
No information available
partition coefficient
Auto-ignition
No information available
temperature(℃)
Decomposition
No information available
temperature(℃)
Viscosity(mm 2 /s) No information available

10 Stability and reactivity

| Stability and reactivity
Contact with incompatible substances can cause decomposition or other
Reactivity
chemical reactions.
Chemical stability Stable under proper operation and storage conditions.
Possibility of hazardous
No information available
reactions
Conditions to avoid Incompatible materials, heat, flame and spark.
Incompatible materials No information available
Hazardous Under normal conditions of storage and use, hazardous decomposition
decomposition products products should not be produced.

11 Toxicological information
| Acute toxicity
Component Cas No. LD50 (oral) LD50 (dermal) LC50 (inhalation)-4h

No
2-Propenoic acid, No information
homopolymer 9003-01-4 6880mg/kg(Rat) information
available
available

5/8
Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

| Carcinogenicity
ID Cas No. Component IARC NTP

1 9003-01-4 2-Propenoic acid, homopolymer Category 3 Not Listed

| Others
2-Propenoic acid, homopolymer(Component)
Skin corrosion/irritation No information available
Serious eye
No information available
damage/irritation
Skin sensitization No information available
Respirator y sensitization No information available
Reproductive toxicity No information available
STOT-single exposure No information available
STOT-repeated exposure No information available
Aspiration hazard No information available
Germ cell mutagenicity No information available
Reproductive toxicity No information available

12 Ecological information
| Acute aquatic toxicity
Component Cas No. Fish Crustaceans Algae

2-Propenoic acid, LC50：>20mg/L No information

homopolymer 9003-01-4 No information available
(96h) available

| Chronic aquatic toxicity

Chronic aquatic toxicity No information available

| Others
Persistence and
No information available
degradability
Bioaccumulative
No information available
potential
Mobility in soil No information available
Results of PBT and vPvB 2-Propenoic acid, homopolymer does not meet the criteria for PBT and vPvB
assessment according to Regulation (EC) No 1907/2006, annex XIII.

13 Disposal considerations
| Disposal considerations
Waste chemicals If medical advice is needed, have product container or label at hand.
Contaminated Containers may still present chemical hazard when empty. Keep away from hot
packaging and ignition source of fire. Return to supplier for recycling if possible.
Disposal
Refer to section 13.1and 13.2.
recommendations

14 Transport information
6/8
Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

| Label

Label Not applicable

| IMDG-CODE
IMDG-CODE NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS

| ICAO/IATA-DG
ICAO/IATA-DG NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS

| UN-ADR
UN-ADR NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS

15 Regulatory information
| International chemical inventory
Component EINECS TSCA DSL IECSC NZIoC PICCS KECI AICS
2-Propenoic
Not Not
acid, Listed Listed Listed Listed Listed Listed
Listed Listed
homopolymer
【EINECS】 European Inventor y of Existing Commercial Chemical Substances
【TSCA】 United States Toxic Substances Control Act Inventor y
【DSL】 Canadian Domestic Substances List
【IECSC】 China Inventor y of Existing Chemical Substances
【NZIoC】 New Zealand Inventor y of Chemicals
【PICCS】 Philippines Inventor y of Chemicals and Chemical Substances
【KECI】 Existing and Evaluated Chemical Substances
【AICS】 Australia Inventor y of Chemical Substances

16 Others
| Information on revision
Creation Date 2015/11/19
Revision Date 2015/11/19
Reason for revision -

| Reference

[1]IPCS:The International Chemical Safety Cards (ICSC) ,website: http://www.ilo.org/dyn/icsc/showcard.home.

[2]IARC，website: http://www.iarc.fr/.
[3]OECD: The Global Portal to Information on Chemical Substances, website:
http://www.echemportal.org/echemportal/index?pageID=0&request_locale=en.

[4]CAMEO Chemicals, website: http://cameochemicals.noaa.gov/search/simple.

[5]NLM:ChemIDplus, website: http://chem.sis.nlm.nih.gov/chemidplus/chemidlite.jsp.
[6]EPA: Integrated Risk Information System, website: http://cfpub.epa.gov/iris/.
[7]U.S. Department of Transportation:ERG, website: http://www.phmsa.dot.gov/hazmat/library/erg.
[8]Germany GESTIS-database on hazard substance, website: http://gestis-en.itrust.de/.

7/8
Washmatic DM-1522 Version：V1.0.0.1 Revision Date：2015/11/19

| Abbreviations and acronyms

CAS –Chemi cal Abstracts Servi ce CMR - Ca rci nogens, mutagens or substances toxic to reproduction

PC-STEL- Short term exposure limit PC-TWA - Ti me Weighted Average

DNEL - Deri ved No Effect Level IARC - International Agency for Research on Ca ncer

RPE - Res piratory Protective Equipment PNEC –Predi cted No Effect Concentration

LC50 - Letha l Concentration 50% LD 50 - Letha l Dose 50%

NOEC -No Obs erved Effect Concentration EC50 - Effecti ve Concentration 50%

PBT - Pers i stent, Bioaccumulative, Toxic POW - Pa rti ti on coefficient Octa nol:Water

BCF - Bi oconcentration factor (BCF) vPvB - very Pers i stent, very Bi oaccumulative

IMDG-International Ma ritime Dangerous Goods ICAO/IATA-Interna tional Ci vil Avia tion Organiza tion/Interna tional Ai r
Tra ns portation Association

UN-The United Nations ACGIH-Ameri can Conference of Governmental Industrial Hygienists

NFPA-Na ti onal Fi re Protection Association OECD-Orga nization for Economic Co-operation a nd Development

| Disclaimer

This Safety Data Sheet (SDS) was prepared according to UN G HS (the 5th revised edition). The data included
was derived from international authoritative database and provided by the enterprise. Other inf ormation was
based on the present state of our knowledge. We try to ensure the correctness of all information. However,
due to the diversity of information sourc es and the limitations of our knowledge, this document is only for
user’s reference. Users should make their independent judgment of suitability of t his information f or their
particular purposes. We do not assume responsibility for loss, damage or ex pense arising out of or in any way
connected with the handling, storage, use or disposal of the product.

8/8