ORDER NO.

AD0203062C2

Service Manual Tuner

ST-HD560E
Colour

(N)............. Gold Type

System

SC-HD560:

Tuner; ST-HD560, Amplifier; SE-HD560,

CD Player; SL-HD560, Cassette Deck; RS-HD560,

Speakers; SB-HD560 (Made in Spain.)

Specifications
IPre-amplifier section ■Timer section
Input sensitivity/impedance: Clock: Quarts - lock type
EXTIN; 300 mV/15k£2 Function: Play timer (every day), Rec timer (every day),
Sleep timer (120 min, 30min internals)

ITuner section
FM frequency range: 87.50 - 108.00 MHz ■General

(0.05 MHz steps) Dimensions (WxHxD): 210x76.3x251 mm

FM antenna terminal(s) 75 £2 (unbalanced) Mass: 1.1 kg

AM frequency range: 522 - 1629 kHz (9 kHz steps)

520 - 1630 kHz (10 kHz steps) Notes:
Specifications are subject to change without notice.
Mass and dimensions are approximate.

A WARNING
This service information is designed for experienced repair technicians only and is not designed for use by the general public.
It does not contain warnings or cautions to advise non-technical individuals of potential dangers in attempting to service a product.
Products powered by electricity should be serviced or repaired only by experienced professional technicians. Any attempt to service
or repair the product or products dealt with in this service information by anyone else could result in serious injury or death.

CONTENTS
Page Page

1 Note....................................................................................................... 2 9 Schematic Diagram............................................................................7

2 Before Repair...................................................................................... 2 10 Printed Circuit Board Diagram......................................................11
3 Location of Controls..........................................................................2 11 Block Diagram...................................................................................13
4 Operation Checks and Component Replacement Procedures3 12 Wiring Connection Diagram.......................................................... 15
5 To Supply Power Source..................................................................3 13 Terminal Function of ICs................................................................ 16
6 Self-Diagnostic Function.................................................................. 4 14 Replacement Parts List...................................................................17
7 Type Illustration of ICs, Transistors and Diodes........................5 15 Cabinet Parts Location................................................................... 20
8 Schematic Diagram Notes................................................................5

© 2002 Matsushita Electric Industrial Co., Ltd. All

rights reserved. Unauthorized copying and
distribution is a violation of law.
ST-HD560E

1 Note 2 Before Repair

This equipment (ST-HD560), which is a component of the
1. Because of unque interconnecting cables, when a
system, is supplied with power from the Amplifier (SE-HD560).
component requires service, send or bring in the entire When repairing this equipment or checking operation of the
system.
system, be sure to connect to the amplifier with it.
2. Refer to the service manual for Model No. SE-HD560
Power supply and operation check in the state of it as a single
(Order No. AD0203061C2) for information on
equipment is impracticable.
Accessories and Packaging.

3 Location of Controls

® Display panel
The display also shows information for the cassette deck, CD
player, and amplifier.
(2) Play timer/record timer button and indicator
(© PLAY/® REC)
(3) Clock/timer button (CLOCK/TIMER)
@ Set button (SET)
(5) Tuning/time adjust buttons
(TUNE/TIME ADJUST V, A)
@ Tuning mode button (TUNE MODE)
® RDS button (RDS)
@ Band select button (FM/AM)

2
 |ST-HD560e]

4 Operation Checks and Component Replacement

Procedures
• This section describes procedures for checking the
4.2. Checking for the main P.C.B.
operation of the major printed circuit boards and
replacing the main components. • Follow the (Step 1) - (Step 3) of item 4.1.

• For reassembly after operation checks or replacement,

reverse the respective procedures. Special reassembly
(Step 1)
procedures are described only when required.

4.1. Checking for the FL P.C.B.

(Step 3)
Remove the cabinet.

(Step 3) ©x2
Release the 2 claws, and then (Step 2)
remove the main P.C.B. and ' v '
rear panel.

• Check the main P.C.B. as shown below.

• Check the FL P.C.B. as shown below.

5 To Supply Power Source

This unit is designed to operate on power supplied from system connected.
When a component requires service, use the system connections to supply power source.
For system connections, refer to Fig. 5-1.

Fig. 5-1.

3
|ST-HD560E]

6 Self-Diagnostic Function
This unit is equipped with a self-diagnostic function which, in
6.3. Display contents
the event of a malfunction, automatically displays a code
indicating the nature of the malfunction. 6.3.1. U70 CD/U70 TAPE
Use this self-diagnostic function when servicing the unit. (displayed automatically)
6.1. To display the malfunction • Problem or condition

code A bus-line communications error has occurred as a result of

the flat cables being inserted incorrectly, thus preventing
U70 CD: Automatically displays on the tuner when the system from operating.
U70 TAPE: a malfunction occurs. Refer to Fig. 6-1. - If U70 is displayed on the tuner, the CD Player or
F61: Automatically displays on the tuner when Cassette deck cannot be operated by remote control.
a malfunction occurs. Refer to Fig. 6-1.
• Correction Procedure

1.To check for correct insertion of the flat cables.

- Insert each connectors until you hear a click.
- Insert the flat cables at the back of the unit in the
order indicated. Refer to Fig. 6-2.

Make sure the white side of the cable is on your right

side. Refer to Fig. 6-3.

Fig. 6-1.

White side
6.2. To return to the normal
display
1. For U70 CD/U70 TAPE Fig. 6-3.

• Press an any operation button on the tuner. 2. Breakage of the flat cables. (Check and replace.)
•To re-display the code, switch the power off (POWER 3. If the problem is not corrected by items 1 and 2 above,
STANDBY button), and then switch power back on this indicates a faulty IC.
again. ST-HD560:
2. For F61 IC601 (C2BBGF000308)
• If F61 is displayed, the power will automatically be SL-HD560:
switched off.
IC201 (C2BBFD000340)
• F61 will be displayed for 3 seconds, and then the clock
RS-HD560:
will be displayed.
IC701 (C2BBED000031)
• To re-display the code, switch the power on. F61 will be
re-displayed, and then after 3 seconds the clock will be Check these ICs and replace.
displayed and the power will automatically switch off.
6.3.2. F61
• Problem or condition

When the power switch is switched on, it automatically

switches back off, making it impossible to switch power on.
• Correction procedure

Faulty the Amplifier (SE-HD560) output IC (IC101). (When

a DC voltage is applied to speaker terminals.)

4
 |ST-HD560e]

7 Type Illustration of ICs, Transistors and Diodes

BU4052BCF-E2 16IPN C2BBGF000308 2SB1417PQTA
C1BB00000527 16PIN 2SD2137PQTA 2SD2144STA
C1BB00000528 20PIN DTA114ESTP
NJM4558MTE1 8PIN DTA114TSTP
DTC114ESTP
DTC143XSTP

2SA1309ATA 2SD1819ATX 2SC3940AQSTA 2SD2374PQAU 2SB621AQRSTA MA111TX

2SC3311ATA UN5214TX 1SS380TE-17

MA719TA MA165TA MA8062MTX RL1N4003N02

MA29WATA MA8051MTX
MA4056HTA
MA4062HTA
MA4082LTA
MA4091MTA

LNJ201LPQJA

8 Schematic Diagram Notes

• This schematic diagram may be modified at any time noise (resistors), etc. are used.
with the development of new technology. When replacing any of components, be sure to use only
Notes: manufacturer’s specified parts shown in the parts list.
S601: Tuning/time adjust up switch • The supply part number is described alone in the
(TUNE/TIME ADJUST A ) replacement parts list.
S602: Tuning/time adjust down switch • Caution!
(TUNETIME ADJUST V )
IC and LSI are sensitive to static electricity.
S603: Play timer/record timer switch
( ® PLAY/ ® REC) Secondary trouble can be prevented by taking care during
S604: Clock/timer switch (CLOCK/TIMER) repair.
S605: Set switch (SET) Cover the parts boxes made of plastics with aluminum foil.
S606: Tuning mode switch (TUNE MODE) Ground the soldering iron.
S607: RDS switch (RDS)
Put a conductive mat on the work table.
S608: Band select switch(FM/AM)
Do not touch the legs of IC or LSI with the fingers directly.
• Indicated voltage values are the standard values for the unit
• Voltage and signal line
measured by the DC electronic circuit tester (high-
impedance) with the chassis taken as standard. Therefore, : Positive voltage line
there may exist some errors in the voltage values, : Negative voltage line
depending on theinternalimpedance of the DC circuit tester.
: FM signal line
No mark : FM : FM OSC signal line
() : AM
: AM signal line
• Important safety notice:
: AM OSC signal line
Components identified by A mark have special
: FM/AM signal line
characteristics important for safety.
Furthermore, special parts which have purposes of fire­
retardant (resistors), high-quality sound (capacitors), low-

5
ST-HD560E

6
 ST-HD560E

9 Schematic Diagram
SCHEMATIC DIAGRAM-1 NOTE:
The number which noted at the connectors on the schematic diagram as
"SCHEMATIC DIAGRAM-1" or "SCHEMATIC DIAGRAM-2"
FL CIRCUIT indicates the schematic diagram serial number located on the left corner in the schematic diagram. OPERATION CIRCUIT :POSITIVE VOLTAGE LINE NEGATIVE VOLTAGE LINE

FL601 (RSL0309-F) Z601

RCDGP1U26XD
(REMOTE SENSOR)
FL DISPLAY

OUT Vdd GND R602 R603 R604 R605 R606 R607 R608
820 1K 1.2K 1.5K 1.8K 2.2K 3.3K
D601
LNJ201LPQJA
C609
0.1

0629
6.3V47

CP603

CN603
POO/

P01/ FLDO
P02/FLD10

P30 / FLD24

P32 / FLD26
FLD8

P33/ FLD27

P35/ FLD29
P36/ FLD30

P40/ FLD32

P42/ FLD34

P44/ FLD36
P45Z FLD37
P34/ FLD28
P11/FLD17
P07/FLD15

P14/FLD20

P16/FLD22
P17/FLD23

P31/FLD25

P41/FLD33

P43/ FLD35
P13/FLD19
P12/FLD18
P04/FLD12
P05/FLD13
P06/FLD14

P10/FLD16
P03/ FLD11

P37/ FLD31
P15/FLD21
R633
P46/ 120
P27/ FLD7 FLD38
P26/ FLD6 P47/ FLD39
P25/ FLD5 P50/ FLD40
R640 R659
P24/ FLD4 P51/FLD41 Q602 4.1V 1K 330
P23/ FLD3 P52/ FLD42 2SD1819ATX
P22/ FLD2 P53/ FLD43 LED DRIVE
P21/FLD1 P54/ FLD44
P20/ FLDO P55/ FLD45
Vee P56/ FLD46
IC601
PB6/SIN1 P57/ FLD47
C2BBGF000308
PB5/ SOUT1 SYSTEM CONTROL/ P60/ FLD48
PB4/SCLK11 FL DRIVE P61/ FLD49
PB3/SSTB1 P62/ FLD50
PB2/ SBUSY1 FM/AM FM/AM P63/ FLD51
PB1/ SRDY1 P64/RXD
PB0/SCLK12/DA P65/TXD
AVss P66/ SCLK21
VREF P67/ SRDY2
AN7 P70/ INTO
P93/ SRDY3

P91/SOUT3

P76/T3OUT
P75/T1OUT
P92/ SCLK3

AN6 P71/INT1
P90/ SIN3

P77/ INT4

P73/ INT3
XC OUT
RESET
CNVss

XOUT
XC IN

INT2
P72/
XIN'
ANO
AN5
AN4
AN3
AN2
AN1

P97
P96

P94

P80

P74
P95

P81

Vss

Vcc

R658
1K

D614
MA111TX

Q601
UN5214TX
RESET
OV

X602
(4.19MHz)

RJ723
OQ

ST-HD560(E) FL,OPERATION CIRCUIT DIAGRAM

ST-HD560E

SCHEMATIC DIAGRAM-2
MAIN CIRCUIT :POSITIVE VOLTAGE LINE NEGATIVE VOLTAGE LINE :FM/AM SIGNAL LINE

R422 0418
100 50V0.22

R502
0Q
C426
100P
R436
47K
R418 C416
100 50V0.22

MA165TA
D404
MA165TA
50V0.47
IC405 R468

0.1
D402

C438
3300P

C412

R456
C410
0.022
C414
100

0.1

100
C422
NJM4558MTE1 AAV
R464 C44O
BUFFER AMP 100 50V0.1

C428
33P

R446
R444
R438

R442
1.2K
2.7K

10K
18K

C436
330P

R462
100K
4.3V 3.7V 1 f 3.7V 4.3V U4.2V
C441

R460
C424 R434 R432 C456 C430

4.7K
5 100P 10K 100 16V10 0.1 C432 0.1
100P

VREF,
IN
DAT

SIM IN
SIM OUT
CLK

BASS
OUT

TRE
DGND

R430
100K
C434 R458
100P 10K -8.7V OV OV OV
IC402 8 6
C1BB00000528
ELECTRONIC VOLUME Vss Vee INH Vss Vee INH

SIM OUT
IC403 IC404 IC406

SIM IN
AG N D

NJM4558MTE1
DVdd

BASS

AVdd
OUT

BU4052BCF-E2 BU4052BCF-E2
TRE
CS

BUFFER AMP

IN
SWITCHING(VGCA) SIGNAL SELECTOR
Ji
h5.1V 5.1V 4.3V ।, 3.7V j 13.7V 4.3V m4.2V

O CM Vdd B Vdd
R423

O 2!^
10K

’TO--- 9 [12J
OO ,11
R421 C417 C423 R433 R431 C455
100 50V0.22 100P 10K 100 16V10 4.9V 5.2V OV 0V nOV 4.9V

R450

R449
100

100
C433 R457

R467

R465
R435

C425

100

100
100P
47K
100P 10K
6.3V100

C421

R443

R445
C4O8

R441

1.2K
2.7K
R416

10K
R415
4.7K

4.7K

33P

50V0.1
R424

C439
1K C431
100P

R463
100
C419

C407
R420

MA165TA
1.5K

0.1

0.1

D401

R437
18K
R417 C415

100K
330P
C435

R461
100 50V0.22

4.9V

C420

C427

C429
R495

R490
1.2K
0.1

0.1
0.1
CN302 1M Q404
DTA114ESTP

R489
1.2K
R488 SWITCHING(VGCA)
OV
0.7V 4.7K 1.4V 1.5V
Q405,406 Q406
R411 R452 R262
100 10K 10K 2SC3311ATA
SWITCHING R487
0V 4.7K
(VGCA)
6.3V100

0.7V H B
C256

Q405
C254

R261 AAV
0.1

10K

R497
1M
R254 FM/AM
10K
2.6V
P-P
R252

R253

R255
R251

10K
100

100
100

F=4.332MHz

(0V) (5.2V) G E F
0.6V 2.8V 5.1V 5.2V ’f 2.5V

C B D A
V dd D
DATA

RST

X IN
MODE
RDY

CLK

VssD

R471
IC251 R427 100 100
C1BB00000527
RDS DECODER
R426

R472
FL OUT
100

MPX IN

R469

R470
22K

22K
XOUT
VREF

TEST

100
V ddA

VssA

C IN

CN251 CN201
CN301

2.6V i i 2.5V 5.2V 2.6V 2.5V 2.7V

EXT IN TERMINAL
C255 CONNECTOR CIRCUIT CIRCUIT
16V10

R257
C251

560P X251
100

(4.332MHz)
CP251 CP201
FM/AM
47P
C258

2.6V
P-P J 5.7 V >
C253
330P
R256
100 Q252 Q251
R303 F=4.332MHz
HF AAV 2SC3940AQSTA 2SC3311ATA
10K REGULATOR R207
REGULATOR JK201
D 10K
15.4V 7.3V 15.7V 14.8V
Lch
0303
R306
C252
R301

0.047
10K

22K

C261
0.047

100P
C264

C203
0.1

C266
0.047
R302

R305

R209
R260

100P
C205
D302 2SC3311ATA

4.7K
10K
10K

MA4082LTA 1K
R259 C263 R212
MA165TA INTERFACE 220 0.047 10
15.5V
EXTIN
MA165TA

E
D301

C204
100P
R258

R210
R310

C206
100P
16V100
G

4.7K
47K

0251

C265
R308 1K R208
0.9V 4.7K 0.6V 10K
0.6V

■
Rchi

25V 100
C262
R307

R309
4.7K
10K

0302 7.3V
2.8V R304 2SC3311ATA 14.8V
Q301 1.2V 33$ INTERFACE
DTC143XSTP
INTERFACE CN253

F
CL
DO&ST

Lch IN

Rch IN
DI

DET

T.GND
CE

+B(2)

+B(1)
$D

To TUNER UNIT on SCHEMATIC DIAGRAM-4/11,12-A ST-HD560(E) MAIN,CONN ECTOR, EXT IN TERMINAL CIRCUIT DIAGRAM
13 14 15 16 17 18 19 20 21 23 24

8
SCHEMATIC DIAGRAM-3
MAIN CIRCUIT :POSITIVE VOLTAGE LINE :NEGATIVE VOLTAGE LINE FM/AM SIGNAL LINE

JK302
+B(13V)
CD REQ
M.GND
CS
+B(5V)
D.GND
CLK
DATA
DECK REQ To CD PLAYER
(SL-HD560) &
SYNC
CASSETTE DECK
LINE IN Rch (RS-HD560)
LINE IN Lch
NC
REC OUT Rch
REC OUT Lch
CD Rch IN
A.GND
CD Lch IN
NC

JK301
Lch OUT
A.GND
Rch OUT
MUTE
POWER
+B(13V)
LED CONT
CT
D.GND
-B(-13V) To AMPLIFIER
+B(16V) (SE-HD560)
+B(12V)
KEY SE
JOG A
JOG B
HPDET
-B(-24V)
FL1
FL2
Q313 Q307 SYNC
2SC3940AQSTA 2SD2137PQTA
REGULATOR REGULATOR R320
4.7
10V100
0323

0.047

0.047
0309
0321

R317
1K

25V 100
0314
MA4056HTA

D307
25V100

25V47
0307
0305
16V10
D315

0322

D307.308 0313
MA4091MTA 0.1
25V47
0308

D308

MA165TA
25V100

25V100
0306

D321

0315

Q308
2SB1417PQTA
R318
0.047
0310

1K

REGULATOR R319
4.7

Q308
16V10
0452

Q407,408
R504
1K

2SD2144STA
MUTING
0453
50V1
R506
100K

R507
1K
Q407 Q304 Q306
2SB621AQRSTA
R505

2SD2374PQAU
1M

R508 POWER SUPPLY D303 REGULATOR

1K RL1N4003N02
Q408
6.3V 100

6.3V1000

Q409
0.047
0304
0301

R312

R314
0302
330

680

DTA114TSTP
MA29WATA

MUTING CONT. R486

D320

2.2K
MA4062HTA
16V100
R311
1K

0303

D304
10 U H
L302

R321 R322 Q311

100 100
2SA1309ATA
SWITCHING(SYNC)
C316 0317
1 0.1
Q305
D310 D312 DTC114ESTP
R313

R324
1K

MA719TA MA719TA POWER SUPPLY 100K

CONT. E301
R323
10K

D309 D311
MA719TA MA719TA R325 Q312
1K
DTC114ESTP
0.047
0318

SWITCHING
(SYNC)

ST-HD560(E) MAIN CIRCUIT DIAGRAM

9
SCHEMATIC DIAGRAM-4
:FM/AM SIGNAL LINE
Z101 TUNER UNIT(RAN0005EM-2) :POSITIVE VOLTAGE LINE :FM SIGNAL LINE :AM SIGNAL LINE :FM OSC SIGNAL UNE :AM OSC SIGNAL LINE

2SC2059
FM MIXER
2SK360
RFAMP

2SC2413 2SC2413
FM ANT FMIFAMP FMIFAMP DTA114
(75Q) POWER SUPPLY
(FM:ON)

2SK360
FM OSC
2SC2413
BUFFER AMP

LA1833MN
FM/AM IF AMP,
AM ANT DET/AM OSC.MIX/FM MPX
EXT

LOOP

AM RF IN

PILOT IN

MPX IN
AM CSC OUT

AM OUT

DET OUT

PILOT OUT

Rch OUT

Lch OUT
AM OSC

AFC

AGC
AM MIX OUT
FM IF IN

AM IF IN

FM DET

MONO
FM/AM
STRQ
REG

GND

Vcc
ST
SD
2SC2712
SWITCHING
VDD

FM IN

AM IN

IF IN
A OUT

I02
PD
Vss
XOUT

AIN

LC72131M
PLL FREQUENCY
SYNTHESIZER
X IN

bo7

B04
B02

B03
CL

DO
CE

ioT
DI

CL
DO&ST

Lch OUT

DET
Rch OUT
CE

SD

T.GND
DI

+B(2)

+B(1)
To Q CONNECTOR CIRCUIT(CN253)
on SCHEMATIC DI AG RAM-2/19,20-A
ST-HD560(E) TUNER CIRCUIT DIAGRAM
 |ST-HD560E

10 Printed Circuit Board Diagram

Note: This printed circuit board diagram may be modified at any time with the development of new technology.

H
FL RC.B. OPERATION P.C.B.

MAIN P.C.B.
To CD PLAYER &
EXT IN TERMINAL RC.B. -24V TO
AMPLIFIER
A.GND
CASSETTE DECK

| -13V
D.GND

+12V

+16V

CT
+13V

CONNECTOR P.C.B.
D

(REP3298A-M)

(REP3299A-S)
(REP3299A-S)

(REP3298A-M)

ST-HD560(E) FL, OPERATION, EXT IN TERMINAL, CONNECTOR, MAIN P.C.B.

11
IST-HD560E

12
11 Block Diagram

Z101 TUNER UNIT (RAN0005EM-2)

BU4052BCF-E2

NJM4558MTE1
RFAMP FM IFT AM AM
MIXER ANT OSC
COIL COIL +B(13V) BUFFER
FM/AM IF AMP, AMP.
FM IF DET/AM OSC, CD REQ
BUFFER AMP MIX/FM MPX
FMOSC (LA1833MN) M.GND
AMP

CS

+B(5V)

D.GND INTERFACE
SW CONT.
CLK

DATA INTERFACE

To CD PLAYER DECK REQ

(SL-HD560) &
DECODER CASSETTE DECK
ALC AM (RS-HD560) SYNC
AM AM AGC
OSC RF BLOCK DIAGRAM
MIX
BUFEER AMP UNE IN Rch

PHASE STEREO PILOT LINE IN Lch

DET SWITCH CANCEL
NC
LEVEL
DET AM/FM REC OUT Rch
IF
S- BUFFER
CURVE REC OUT Lch
FM IF
FM TUNING CD Rch IN
DET DRIVE
A.GND

CD Lch IN

NC

c1bSh2P527
RDS DECODER

PHASE DET REFERENCE

CHARGE PUMP DIVIDER

PLL CLOCK
REFERENCE RECOVERY
SWALLOW COUNTER (57kHz) (1187.5kHz)
1/6,1/17 4BIT VOLTAGE

PLL FREQUENCY 57kHz DATA

ANTIALIASING BPF SMOOTHING
SYNTHESIZER FILTER DECODER
FILTER (SCF)
(LC72131M)

CLK(4.332MHz)
UNIVERSAL RDS-ID
COUNTER DATA SHIFT TEST DETECT/
REGISTER LATCH RAM
Power OSC/DIVIDER
ON
RESET
Power
supply
(FM:ON

ST-HD560(E) BLOCK DIAGRAM

13
 C1BB00000528
NOTE FM SIGNAL LINE
ELECTRONIC VOLUME FM OSC SIGNAL LINE
AM SIGNAL LINE
AM OSC SIGNAL LINE
FM/AM SIGNAL LINE
indicates pin No. Right channel.

NJM4558MTE1
JK301

Lch OUT

A.GND
BU4052BCF-E2
Rch OUT
SWITCHING(VGCA)
MUTE

POWER

CONTROL +B(13V)
LOGC
LED CONT

CT

D.GND
To AMPLIFIER
-B(-13V) BLOCK
DIAGRAM
SW CONT. +B(16V)
SWITCHING
(VGCA) +B(12V)

KEY SE
SWITCHING
(VGCA) JOG A

JOG B

HPDET

-B(-24V)

FL1
To FL DISPLAY
FL2

SYNC

ANO
X IN
P80
P66

P67

P70

P74

P76

P77
AN7

AN4

AN5

AN6
X OUT
P75

VEE
AN2
XC OUT
XC IN
P81

AN1

P03~07,P11~17,
C2BBGF000308

SYSTEM CONTROL / FL DRIVE

P00-02,
P30-35

P20-27

CNVss
RESET

VREF
AVss
AN3
PB6
PB2
PB5

PB4

PB3

P73
P96

P72
P93

PB1
P94

P90
P95

P92

P71
P97

P91

Vss

Vcc
FL DISPLAY
Z601 FL601
(REMOTE SENSOR) KEY
SWITCH
(8601^608)

ST-HD560(E) BLOCK DIAGRAM

14
 |ST-HD560e]

12 Wiring Connection Diagram

To CD PLAYER&
CASSETTE DECK | To AMPLIFIER]

15
|ST-HD560e]

13 Terminal Function of ICs

13.1. IC601 (C2BBGF000308): Pin
No.
Terminal
Name
I/O Function

System Control/FL Drive 45 P53/

FLD43
Pin Terminal I/O Function I I - Not used, connected to GND
No. Name P40/
1 AN5 O Muting signal output 56 FLD32
2 AN4 I Headphone connection detect signal input 57 P37/ - Not used, connected to VREF
FLD31
3 AN3 I Key switch signal input
4 AN2 I Key switch signal input from Amplifier
58 P36/ - Not used, connected to GND
FLD30
5 AN1 I Selector switch signal input from Amplifier
59 P35/
6 ANO I Volume switch signal input from Amplifier FLD29
7 P97 I Tuner signal detection input from Z101 I I o FL segment control signal output
8 P96 O Chip enable signal output for Z101 P03/
9 P95 I Data signal input from Z101 77 FLD11
10 P94 O Clock signal output for Z101 78 P02/
FLD10
11 P93/ I RDS ready signal input from IC251 o
SRDY3
I I FL grid control signal output
P20/
12 P92/ I RDS clock signal input from IC251 88 FLD0
SCLK3 89 I Power supply terminal (Negative)
Vee
13 P91/ O Control data signal output for IC402 90 PB6/ I Communication data signal input
SOUT3 SIN1
14 P90/ I RDS data signal input from IC251 91 PB5/ o Communication data signal output
SIN3 SOUT1
15 P81 O Clock signal output for serial data transfer 92 PB4/ I Communication clock signal input
16 P80 O VGCA switch control signal output SCLK11
17 CNVSS - GND terminal 93 PB3/ o Communication request signal output for
18 RESET I Reset signal input SSTB1 CD '
19 XC OUT o Oscillator connected terminal (F=32.7 kHz) 94 PB2/ I Communication chip select signal input
20 XC IN SBUSY1
21 Vss - GND terminal 95 PB1/ o Communication request signal output for
22 X IN I SRDY1 Deck
Oscillator connected terminal (F=4.19 MHz)
96 PB0/ Not used, connected to GND
23 X OUT o SCLK12/
24 Vcc I Power supply terminal DA
25 P77/ I Power failure detect signal input 97 AVSS - GND terminal
INT4
98 VREF I Reference voltage input
26 P76/ o Muting signal output
99 AN7 o LED (VGCA) control signal output
T3OUT
27 P75/ - Not used, connected to VREF
100 AN6 o Power supply control signal output
T1OUT
28 P74 o VGCA switch control signal output
29 P73/ o CR timer terminal for clock backup
INT3
30 P72/ I Remote control signal input
INT2
31 P71/ o LED drive signal output
INT1
32 P70/ o Select signal output for IC406
INTO
33 P67/ o Select signal output for IC406
SRDY2
34 P66/ o Select signal output for IC406
SCLK21
35 P65/ - Not used, connected to GND
TXD
36 P64/ - Not used, connected to VREF
RXD
37 P63/ - GND terminal
FLD51
38 P62/ I/O Data signal input/output
FLD50
39 P61/ o Chip select signal output
FLD49
40 P60/ o Clock signal output
FLD48
41 P57/
FLD47
I I - Not used, connected to GND
P54/
44 FLD44

16
 |ST-HD560e]

14 Replacement Parts List

Notes: Ref. Part No. Part Name & Pcs Remarks
No. Description
• Important safety notice: C323 ECA1APX101B 10V 100U 1
Components identified by A mark have special C407 ECBT1H104ZF5 50V 0.1U 1 F1E1H104A001
C408 ECA0JAKI01XB 6.3V 100U 1
characteristics important for safety.
C409,10 ECQB1H223JF3 50V 0.022U 2
Furthermore, special parts which have purposes of fire­ C411,12 ECA1HAKR47XB 50V 0.47U 2
retardant (resistors), high-quality sound (capacitors), C413,14 ECBT1C332KR5 16V 3300P 2 ECBT1C332KR3
low-noise (resistors), etc. are used. C415-18 ECA1HAKR22XB 50V 0.22U 4
C419,20 ECBT1H104ZF5 50V 0.1U 2 F1E1H104A001
When replacing any of components, be sure to use only C421,22 ECBT1H330J5 50V 33P 2 F1D1H330A006
manufacture’s specified parts shown in the parts list. C423-26 ECBA1H101KB5 50V 100P 4
C427-30 ECBT1H104ZF5 50V 0.1U 4 F1E1H104A001
• The marking [RTL] indicates that the Retention Time is
C431-34 ECBA1H101KB5 50V 100P 4
limited for this item. After the discontinuation of this C435,36 ECBT1H331KB3 50V 330P 2
assembly in production, it will no longer be available. C437,38 ECBT1H104ZF5 50V 0.1U 2 F1E1H104A001
C439,40 ECA1HAK0R1XB 50V 0.1U 2
• All parts are supplied by MESA.
C441 ECBT1H104ZF5 50V 0.1U 1 F1E1H104A001
Ref. Part No. Part Name & Pcs Remarks C443-48 ECBA1H101KB5 50V 100P 6
No. Description C452 ECA1CAK100XB 16V 10U 1
C453 ECA1HAK010XI 50V 1U 1
1 RHD30082-K1 SCREW 4 C455,56 ECA1CAK100XB 2
16V 10U
2 RKM0413A-N CABINET 1 C601 ECJ2VF1H104Z 50V 0.1U 1
3 XTB3+8JFZ SCREW 1 C609,10 ECJ2VF1H104Z 50V 0.1U 2
4 REZ1379 FFC(23P) 1 C612 ECJ2VF1H104Z 50V 0.1U 1
5 RKA0114-K FOOT 4 C614 ECUV1H102KBN 50V 1000P 1 ECJ2VB1H102K
5-1 RKA0083-K CUSHION 4 F2A0J470A014
C616 RCE0JKA470BG 6.3V 47U 1
6 REZ1359 FFC(19P) 1 C617 RCE1HKA3R3BG 50V 3.3U 1 F2A1H3R3A015
7 RGG0189G-S FRONT PANEL 1 C618 ECUV1H180JCN 50V 18P ECJ2VC1H180J
1
8 RAN0005EM-2 TUNER PACK(Z101) 1 C619 ECJ2VF1H104Z 50V 0.1U 1
9 RGP0841-S SUB PANEL 1 C620 50V 18P ECJ2VC1H180J
ECUV1H180JCN 1
10 RGU1935-S BUTTON, BAND 1 C621,22 ECJ2VF1H104Z 50V 0.1U 2
11 RGU1939-S BUTTON,TIMER 1 C623 F2A0J102A130 6.3V 1000U 1
12 RKW0629-R FL WINDOW 1 C624 ECA1CAK100XB 16V 10U 1
13 XTBS26+8J SCREW 9 ECUV1H102KBN ECJ2VB1H102K
C625 50V 1000P 1
14 XTBS3+8JFZ1 SCREW 9 C626,27 ECJ2VF1H104Z 50V 0.1U 2
15 XTB3+12JFZ SCREW 3 C628 ECJ2VC1H101J 50V 100P 1
16 XTB3+5JFZ SCREW 4 C629 RCE0JKA470BG 6.3V 47U F2A0J470A014
1
17 RGK1326-M SIDE PANEL(L) 1 C649 ECJ2VF1H104Z 50V 0.1U 1
18 RGK1327-M SIDE PANEL (R) 1
19 XYN3+F8 SCREW 1 CN2 01 RJT100W04 CONNECTOR(4P) 1
20 RGK1330-S SIDE ORNAMENT(L) 1 RJT100W11
CN2 51 CONNECTOR(IIP) 1 K1KA11A00093
21 RGK1331-S SIDE ORNAMENT(R) 1 RJT100W11
CN2 53 CONNECTOR(IIP) 1 K1KA11A00093
22 RGL0529-Q INDICATOR,TIMER 1 CN3 01 RJS1A6823 K1MN23A00009
CONNECTOR(23P) 1
23 SHE170-2 P.C.B. SUPPORT 4 CN3 02 RJS1A6819 K1MN19A00013
CONNECTOR(19P) 1
CN601 RJS1A6223-1 CONNECTOR(23P) 1 K1MN23C00001
C203-06 ECBA1H101KB5 50V 100P 4 CN602 RJS1A6219-1 K1MN19C00001
CONNECTOR(19P) 1
C251 ECA1CAK100XB 16V 10U 1 CN603 RJT066H05A CONNECTOR(5P) 1 K1KA05B00073
C252 ECBT1H104ZF5 50V 0.1U 1 F1E1H104A001
C253 ECBT1H331KB3 50V 330P 1 CP201 RJU100W04 CONNECTOR(4P) 1
C254 ECAOJAKI01XB 6.3V 100U 1 RJU100W11
CP251 CONNECTOR(IIP) 1 K1KB11A00020
C255 ECBT1H561KB3 50V 560P 1 CP603 RJU066H05 CONNECTOR(5P) 1 K1KB05C00003
C256 ECBT1H104ZF5 50V 0.1U 1 F1E1H104A001
C257,58 ECBT1H470J3 50V 47P 2 D251 MA4082LTA DIODE 1 MAZ40820LF
C261 ECBT1H473KB5 50V 0.047U 1 F1D1H473A012 D301,02 MA165 DIODE MA2C165
2
C262 ECA1EAM101XB 25V 100U 1 RL1N4003N02 DIODE 1 B0AAMM000009
D303
C263,64 ECBT1H473KB5 50V 0.047U 2 F1D1H473A012 D304 MA4062H DIODE 1 MAZ40620H
C265 ECA1CAK101XB 16V 100U 1 D307,08 MA4091MTA DIODE 2 MAZ40910MF
C266 ECBT1H473KB5 50V 0.047U 1 F1D1H473A012 MA719TA DIODE 4 MA2C71900A
D309-12
C301 ECAOJAKI01XB 6.3V 100U 1 MA4056H DIODE
D315 1 MAZ40560H
C302 ECAOJAMI02XB 6.3V 1000U 1 D320 MA29W-A DIODE MA2C029WA
1
C303 ECA1CAK101XB 16V 100U 1 D321 MA165 DIODE MA2C165
1
C304 ECBT1H473KB5 50V 0.047U 1 F1D1H473A012 D401-04 MA165 DIODE 4 MA2C165
C305,06 ECA1EPX101B 25V 100U 2 D601 LNJ201LPQJA LED 1
C307,08 ECA1EPX470B 25V 47U 2 D609 MA2J11100L DIODE 1
C309,10 ECBT1H473KB5 50V 0.047U 2 F1D1H473A012 DIODE MAZ80510M
D610 MA8051M 1
C313 ECBT1H104ZF5 50V 0.1U 1 F1E1H104A001 D611 MA2J11100L DIODE 1
C314,15 ECA1EAM101XB 25V 100U 2 D612,13 1SS380TE-17 DIODE 2
C316 ECBT1C105ZF5 16V 1U 1 F1E1C1050001 D614 MA2J11100L DIODE 1
C317 ECBT1H104ZF5 50V 0.1U 1 F1E1H104A001 MA8062M DIODE MAZ80620ML
D615 1
C318 ECBT1H473KB5 50V 0.047U 1 F1D1H473A012 D622 MA2J11100L DIODE 1
C321 ECBT1H473KB5 50V 0.047U 1 F1D1H473A012
C322 ECA1CAK100XB 16V 10U 1

17
|ST-HD560e]

Ref. Part No. Part Name & Pcs Remarks Ref. Part No. Part Name & Pcs Remarks
No. Description No. Description
FL601 RSL0309-F FL 1 R423 ERDS2FJ103 1/4W 10K 1
R424 ERDS2FJ102 1/4W IK 1
IC251 C1BB00000527 IC 1 R425-27 ERDS2FJ101 1/4W 100 3
IC402 C1BB00000528 IC 1 R429,30 ERDS2FJ104 1/4W 100K 2
IC403 NJM4558MTE1 IC 1 C0ABBB000109 R431,32 ERDS2FJ101 1/4W 100 2
IC404 BU4052BCF-E2 IC 1 C0JBAR000002 R433,34 ERDS2FJ103 1/4W 10K 2
IC405 NJM4558MTE1 IC 1 C0ABBB000109 R435,36 ERDS2FJ473 1/4W 47K 2
IC406 BU4052BCF-E2 IC 1 C0JBAR000002 R437,38 ERDS2TJ183 1/4W 18K 2
IC601 C2BBGF000308 IC 1 R441,42 ERDS2FJ103 1/4W 10K 2
R443,44 ERDS2TJ272T 1/4W 2.7K 2
JK201 SJF3069-8N JACK,EXT IN/OUT 1 K2HA102B0039 R445,46 ERDS2FJ122 1/4W 1.2K 2
JK301 RJT065K20 SYSTEM 1 K1FA220B0006 R449,50 ERDS2FJ101 1/4W 100 2
CONNECTOR(2OP) R452 ERDS2FJ103 1/4W 10K 1
JK302 RJT065K19 SYSTEM 1 K1FA219B0001 R455,56 ERDS2FJ101 1/4W 100 2
CONNECTOR(19P) 1/4W 10K 2
R457,58 ERDS2FJ103
R459,60 ERDS2FJ472 1/4W 4.7K 2
L301,02 RLQA100JT-Y COIL 2 G0C100JA0023
R461,62 ERDS2FJ104 1/4W 100K 2
L609 RLBN300AV-W COIL 1 J0JHC0000027 R463-65 ERDS2FJ101 1/4W 100 3
R467,68 ERDS2FJ101 1/4W 100 2
PCB1 REP3298A-M MAIN P.C.B. ASS'Y 1 [RTL]
R469,70 ERDS2FJ223 1/4W 22K 2
PCB2 REP3299A-S PANEL P.C.B. ASS'Y 1 [RTL] R471,72 ERDS2FJ101 1/4W 100 2
R473,74 ERDS2FJ103 1/4W 10K 2
Q251 2SC3311ATA TRANSISTOR 1 2SC3311A0A
R475,76 ERDS2FJ472 1/4W 4.7K 2
Q252 2SC3940AQSTA TRANSISTOR 1 2SC3940ARA
R477-80 ERDS2FJ103 1/4W 10K 4
Q301 DTC143XSTP TRANSISTOR 1 B1GACFGH0002
R481,82 ERDS2FJ102 1/4W IK 2
Q302,03 2SC3311ATA TRANSISTOR 2 2SC3311A0A
R483,84 ERDS2FJ332 1/4W 3.3K 2
Q304 2SB621A-R TRANSISTOR 1 2SB0621AH
R485,86 ERDS2FJ222 1/4W 2.2K 2
Q305 DTC114ESTP TRANSISTOR 1 B1GACFJJ0007
R487,88 ERDS2FJ472 1/4W 4.7K 2
Q306 2SD2374PQAU TRANSISTOR 1 2SD23740J1AU 1/4W 1.2K 2
R489,90 ERDS2FJ122
Q307 2SD2137PQTA TRANSISTOR 1 2SD21370PA
R495 ERDS2TJ105T 1/4W IM 1
Q308 2SB1417PQTA TRANSISTOR 1 2SB14170JA
R497 ERDS2TJ105T 1/4W IM 1
Q311 2SA1309ATA TRANSISTOR 1 2SA1309AWA
R501,02 ERDS2T0T 1/4W 0 2
Q312 DTC114ESTP TRANSISTOR 1 B1GACFJJ0007
R503,04 ERDS2FJ102 1/4W IK 2
Q313 2SC3940AQSTA TRANSISTOR 1 2SC3940ARA
R505 ERDS2TJ105T 1/4W IM 1
Q404 DTA114ESTP TRANSISTOR 1 B1GCCFJJ0008
R506 ERDS2FJ104 1/4W 100K 1
Q405,06 2SC3311ATA TRANSISTOR 2 2SC3311A0A
R507,08 ERDS2FJ102 1/4W IK 2
Q407,08 2SD2144S TRANSISTOR 2 B1AAGC000006 ERJ6GEYJ221V 1/10W 220
R601 1
Q409 DTA114ESTP TRANSISTOR 1 B1GCCFJA0002
R602 ERJ6GEYJ821V 1/10W 820 1
Q601 UN5214TX TRANSISTOR 1 UNR521400L
R603 ERJ6GEYJ102V 1/10W IK 1
Q602 2SD1819A0L TRANSISTOR 1 R604 ERJ6GEYJ122V 1/10W 1.2K 1
R605 ERJ6GEYJ152V 1/10W 1.5K 1 D0GD152JA003
R207,08 ERDS2FJ103 1/4W 10K 2
R606 ERJ6GEYJ182V 1/10W 1.8K 1
R209,10 ERDS2FJ472 1/4W 4.7K 2
R607 ERJ6GEYJ222V 1/10W 2.2K 1
R212 ERDS2FJ100 1/4W 10 1
R608 ERJ6GEYJ332V 1/10W 3.3K 1
R251-53 ERDS2FJ101 1/4W 100 3 R609-14 ERJ6GEYJ331V 1/10W 330 6
R254,55 ERDS2FJ103 1/4W 10K 2 R616,17 ERJ6GEYJ331V 1/10W 330 2
R256,57 ERDS2FJ101 1/4W 100 2
R618-20 ERJ6GEYJ103V 1/10W 10K 3
R258 ERDS2FJ102 1/4W IK 1 R621 ERJ6GEYJ332V 1/10W 3.3K 1
R259 ERDS2FJ221 1/4W 220 1 R622-24 ERJ6GEYJ103V 1/10W 10K 3
R260 ERDS2FJ102 1/4W IK 1
R625 ERJ6GEYJ101V 1/10W 100 1
R261,62 ERDS2FJ103 1/4W 10K 2
R626-32 ERJ6GEYJ331V 1/10W 330 7
R301-03 ERDS2FJ103 1/4W 10K 3 R633 ERJ6GEYJ121V 1/10W 120 1 D0GD121JA003
R304 ERDS2FJ331 1/4W 330 1
R634-39 ERJ6GEYJ331V 1/10W 330 6
R305 ERDS2FJ103 1/4W 10K 1
R640 ERJ6GEYJ102V 1/10W IK 1
R306 ERDS2FJ223 1/4W 22K 1 R641 ERJ6GEYJ103V 1/10W 10K 1
R307 ERDS2FJ103 1/4W 10K 1
R642,43 ERJ6GEYJ331V 1/10W 330 2
R308,09 ERDS2FJ472 1/4W 4.7K 2 R644 ERJ6GEYJ101V 1/10W 100 1
R310 ERDS2FJ473 1/4W 47K 1
R645 ERJ6GEYJ102V 1/10W IK 1
R311 ERDS2FJ102 1/4W IK 1
R646 ERJ6GEYJ103V 1/10W 10K 1
R312 ERDS2FJ331 1/4W 330 1
R647 ERJ6GEYJ104V 1/10W 100K 1
R313 ERDS2FJ102 1/4W IK 1
R648 ERJ6GEYJ102V 1/10W IK 1
R314 ERDS2FJ681 1/4W 680 1
R649 ERJ6GEY0R00V 1/10W 0 1
R317,18 ERDS2FJ102 1/4W IK 2
R650 ERJ6GEYJ103V 1/10W 10K 1
R319,20 ERD2FCJ4R7 1/4W 4.7 2 R651 ERJ6GEYJ102V 1/10W IK 1
R321,22 ERDS2FJ101 1/4W 100 2
R652 ERJ6GEYJ331V 1/10W 330 1
R323 ERDS2FJ103 1/4W 10K 1
R653 ERJ6GEYJ223V 1/10W 22K 1 D0GD223JA003
R324 ERDS2FJ104 1/4W 100K 1
R654 ERJ6GEYJ331V 1/10W 330 1
R325,26 ERDS2FJ102 1/4W IK 2
R655 ERJ6GEYJ223V 1/10W 22K 1 D0GD223JA003
R411 ERDS2FJ101 1/4W 100 1
R656 ERJ6GEYJ331V 1/10W 330 1
R415,16 ERDS2FJ472 1/4W 4.7K 2
R657 ERJ6GEYG105 1/10W IM 1
R417,18 ERDS2FJ101 1/4W 100 2
R658 ERJ6GEYJ102V 1/10W IK 1
R42 0 ERDS2FJ152 1/4W 1.5K 1 R659 ERJ6GEYJ331V 1/10W 330 1
R421,22 ERDS2FJ101 1/4W 100 2
R660 ERJ6GEYJ101V 1/10W 100 1

18
 ST-HD560E

Ref. Part No. Part Name & Pcs Remarks

No. Description
R661-63 ERJ6GEYJ331V 1/10W 330 3
R664 ERJ6GEYJ472V 1/10W 4.7K 1 D0GD472JA012
R665 ERJ6GEYJ101V 1/10W 100 1
R666,67 ERJ6GEYJ331V 1/10W 330 2
R668 ERJ6GEYJ223V 1/10W 22K 1 D0GD223JA003
R669 ERJ6GEYJ101V 1/10W 100 1
R670,71 ERJ6GEYJ151V 1/10W 150 2
R672 ERJ6GEYJ103V 1/10W 10K 1
R674 ERJ6GEYJ103V 1/10W 10K 1
R675 ERJ6GEYJ101V 1/10W 100 1
R676 ERJ6GEYJ223V 1/10W 22K 1 D0GD223JA003
R677-80 ERJ6GEYJ103V 1/10W 10K 4
R681 ERJ6GEYJ106V 1/10W IM 1
R682,83 ERJ6GEYF473 1/10W 47K 2

RJ721- ERJ8GEY0R00V CHIP JUMPER 4 D0YFR0000002

24

S601-08 EVQ11G05R SW,PUSH 8

X251 RSXC4M33S02T OSCILLATOR 1 H0H433400001

X601 RSXD32K7S05 OSCILLATOR 1 H0A327200029
X602 H2B419400005 OSCILLATOR 1

Z601 RCDGP1U26XD REMOTE SENSOR 1 B3RAD0000010

19
ST-HD560E

15 Cabinet Parts Location

Notes : • We do not supply those items of parts marked *.

•This "PCBT is a combination PCB.
•This "PCB2" is a combination PCB.

20 H020400000TN/AM