Solid State Fermentation

A Bacillus subtilis isolate was shown to be able to produce extracellular protease in solid-state fermentations (SSF) using soy cake as culture medium. A significant effect of inoculum concentration and physiological age on protease production was observed. Maximum activities were obtained for inocula consisting of exponentially growing cells at inoculum concentrations in the range of 0.7–2.0 mg g−1. A comparative

... of the C source has been pointed out in several recent optimization studies ... pre treatment of wheat straw used as the inducing substrate for xylanase production by T ... Organism Substrate Cultivation conditions Xylanase Cellulase Activity", Productb, Assay' FPase't, CMCa", IU ml IU ...

District heating networks are commonly addressed in the literature as one of the most effective solutions for decreasing the greenhouse gas emissions from the building sector. These systems require high investments which are returned through the heat sales. Due to the changed climate conditions and building renovation policies, heat demand in the future could decrease, prolonging the investment return period. The main scope of this paper is to assess the feasibility of using the heat demand – outdoor temperature function for heat demand forecast. The district of Alvalade, located in Lisbon (Portugal), was used as a case study. The district is consisted of 665 buildings that vary in both construction period and typology. Three weather scenarios (low, medium, high) and three district renovation scenarios were developed (shallow, intermediate, deep). To estimate the error, obtained heat demand values were compared with results from a dynamic heat demand model, previously developed and validated by the authors. The results showed that when only weather change is considered, the margin of error could be acceptable for some applications (the error in annual demand was lower than 20% for all weather scenarios considered). However, after introducing renovation scenarios, the error value increased up to 59.5% (depending on the weather and renovation scenarios combination considered). The value of slope coefficient increased on average within the range of 3.8% up to 8% per decade, that corresponds to the decrease in the number of heating hours of 22-139h during the heating season (depending on the combination of weather and renovation scenarios considered). On the other hand, function intercept increased for 7.8-12.7% per decade (depending on the coupled scenarios). The values suggested could be used to modify the function parameters for the scenarios considered, and improve the accuracy of heat demand estimations. Abstract This study aims to examine the nonsterilized fermentation conditions for coproduction of pectinases and lipase enzymes using several fruit wastes as an energy source. Thermophilic fungal strain, Penicillium expansum CMI 39671 was used as a fermenting strain. The effect of process conditions including; nitrogen sources, pH, temperature, time and moisture contents, on the production of both enzymes were studied. The highest activities of pectinase and lipase (2817, 1870 U/g dry substrate) enzymes were found with orange peel feedstock, whereas the lowest activities of 1662 U/g and 1266 U/g were found with banana peel and papaya peel feedstocks respectively. Overall, pectinase showed higher enzymatic activities than lipase enzymes, both having similar increasing and decreasing trends, at all studied conditions. The optimum process conditions of peptone as a nitrogen source, pH 7, 40°C, 5 days and 70% moisture contents, were found to show highest enzymatic activities for both enzymes. The orange peel feedstock showed no significant difference in both enzymes' activities at sterilized and nonnotarized process conditions. Pectinase and lipase enzymes showed (13791 U/g) and (8114 U/g) for sterilized and (14091 U/g) and (8324 U/g) for nonnotarized process conditions respectively. In addition, the fungal strains also produce bacteriocin-like compounds that could inhibit microbial growth. These findings will help to design and develop robust, cost-effective and less energy intensive enzyme production processes and consequently an efficient fruit waste to energy system through open fermentation. Abstract This study aims to examine the nonsterilized fermentation conditions for coproduction of pectinases and lipase enzymes using several fruit wastes as an energy source. Thermophilic fungal strain, Penicillium expansum CMI 39671 was used as a fermenting strain. The effect of process conditions including; nitrogen sources, pH, temperature, time and moisture contents, on the production of both enzymes were studied. The highest activities of pectinase and lipase (2817, 1870 U/g dry substrate) enzymes were found with orange peel feedstock, whereas the lowest activities of 1662 U/g and 1266 U/g were found with banana peel and papaya peel feedstocks respectively. Overall, pectinase showed higher enzymatic activities than lipase enzymes, both having similar increasing and decreasing trends, at all studied conditions. The optimum process conditions of peptone as a nitrogen source, pH 7, 40°C, 5 days and 70% moisture contents, were found to show highest enzymatic activities for both enzymes. The orange peel feedstock showed no significant difference in both enzymes' activities at sterilized and nonnotarized process conditions. Pectinase and lipase enzymes showed (13791 U/g) and (8114 U/g) for sterilized and (14091 U/g) and (8324 U/g) for nonnotarized process conditions respectively. In addition, the fungal strains also produce bacteriocin-like compounds that could inhibit microbial growth. These findings will help to design and develop robust, cost-effective and less energy intensive enzyme production processes and consequently an efficient fruit waste to energy system through open fermentation.