TM 610
TM 610
TM 610
Contents
General ...............................................................................................................................2
Radio Overview..................................................................................................................3
Software Specifications.....................................................................................................7
Circuit Description...........................................................................................................10
Exploded View.................................................................................................................. 82
Packing ............................................................................................................................. 85
Specifications.................................................................................................................109
1
TM-610 Service Manual
General
Manual Scope
This manual is intended for use by experienced technicians familiar with similar types of communication equipment. It
contains all service information required for the equipment and is current as of the publication date.
z For vehicles equipped with electronic anti-skid braking systems, electronic ignition systems or electronic fuel injection
systems, interferences may occur during the radio transmission. If the foregoing electronic equipments are installed
on your vehicle, please contact your dealer for further assistance to make sure that the radio transmission will not
interfere with these equipments.
z For radio installation in vehicles fueled by LP gas with LP gas container within interior of the vehicles, the following
precautions are recommended for personal safety.
① Any space containing radio equipment shall be isolated by a seal from the space in which the LP gas container
and its fittings are located.
② Remote (outside) fitting connections shall be used.
③ Good ventilation is required for the container space.
z Do not mount the mobile radio overhead or on a sidewall unless you take special precautions.
z If the mobile radio is not properly installed, road shock could bump the radio loose, and the falling radio could, in
some circumstances, cause serious injury to the driver or a passenger. In case of vehicle accidents, even when
properly installed, the radio could break loose and become a dangerous projectile.
2
TM-610 Service Manual
Radio Overview
Front Panel View
3
TM-610 Service Manual
① 15 Pin Connector (for external expansion)
② External Speaker Jack
Used to connect an external speaker with a 3.5 mm plug. Refer to Test Cable for Speaker Output in Tuning Description for
details.
③ Power Inlet
Use HYT-authorized DC power cord to inlet 13.6 V DC power.
④ Antenna Connector
Used to connect an external antenna.
Microphone
LED Indicator
Indicator Description
LCD Display
4
TM-610 Service Manual
Indicator Description
1. Display zone / channel number.
2. Display channel label
3. Display DTMF digit
4. Display channel Frequency
5. Display menu, setting items, etc.
1. Monitor status activated by pressing the Monitor key, and the channel
is initialized to Monitor Squelch.
2. Monitor status activated by a call or decoding, i.e., auto reset mode.
3. Monitor status activated by Force Monitor.
4. Carrier squelch mode under Rx Squelch.
5. Monitor status with authorization request.
5
TM-610 Service Manual
6
TM-610 Service Manual
Software Specifications
Radio Modes
1. Frame of Radio Modes
Note: When power-on password is enabled, you must input the correct password before you can enter User Mode.
You can input password through the keypad and press [#] to clear.
7
TM-610 Service Manual
3. Error Information and Measures in User Mode
The radio self-checks when power on. If no error is detected, the radio enters conventional mode. While the radio will
sound alert once any error is checked.
Error information and measures:
No. Error Information LCD Display Measures
1 Stun status Stun Re-program.
Turn the radio on while holding down [P4] to enter Firmware Version Display Mode, the firmware version will be displayed
on the LCD.
Release [P4] to enter User Mode.
5. PC Programming Mode
Connect the radio with a PC by programming cable. If data is written to the radio from PC, it can be programmed into the
EEPROM. Data programming is accessible by programming software.
When data is written to the radio from PC, “PROGRAM”appears on the LCD. LED glows green when data is written to the
radio and red when data is read from the radio. Radio will restart automatically when programming is completed.
Note: Cloning is available only when both radios are in the same mode.
8
TM-610 Service Manual
(2) Select the item with [Up]/[Down] keys. Press [P4] to enter the selected sub-item.
(3) Press [P4] to enter the sub-item and tune the data with [Up]/[Down] keys. Then press [P4] to save the data and
enter the next sub-item. Press [P1] to go back to the previous item without saving the data.
(1) Press [P2] to turn the radio on. The radio enters Model Set Mode. The frequency band appears on the LCD.
(2) Press [Up]/[Down] to choose right frequency band.
(3) Press [P4 ] to confirm. LED glows orange and ”WAIT”appears on the LCD; then the radio enters User Mode after
reset.
Notes:
1. Once [P4] key is pressed to set the new model, the previously stored channel data (frequency, CTCSS/CDCSS,
channel function settings) will be cleared, and part of functions also change. Therefore, do not make this operation unless
it’
s necessary.
2. Initialization Data Table and frequency range (FL: lowest frequency- FH: highest frequency -FC: center frequency) of
different models are shown in the following table.
TM600V: 136-174MHz
TM600U1: 400-470MHz
TM600U2: 450-500MHz
TM600U3: 470-520MHz
TM600U4: 350-400MHz
TM600U5: 440-470MHz
TM600U6 (for Taiwan only): 480-526MHz
TM600U7: 330-350MHz
9
TM-610 Service Manual
CH 1 2 3 4 5 6 7 8
CH CH 1 CH 2 CH 3 CH 4 CH 5 CH 6 CH 7 CH 8
Circuit Description
1. Frequency Configuration
The receiver utilizes double conversion superheterodyne. The first IF is 49.95MHz and the second is 450KHz. The first
local oscillator signal is supplied by the PLL circuit; and the second (50.4MHz) is generated from the frequency tripling of
TCXO (16.8MHz). The PLL circuit generates the frequencies required for transmission. (See figure 1).
Frequency Range VHF: 136MHz - 174MHz
UHF: 400MHz - 470MHz 450MHz - 500MHz
470MHz - 520MHz 350MHz - 400MHz
440MHz - 470MHz 480MHz - 526MHz
330MHz - 350MHz
2. Receiver Circuit
2.3 IF Amplifier
The first IF signal is amplified by Q113 and then enters IC102 (TA31136FN), where the signal is mixed again with the
10
TM-610 Service Manual
second local oscillator signal (50.4MHz) to become a 450KHz second IF signal. The second IF signal is then fed through a
ceramic filter (N: CF202; W: CF203) to eliminate unwanted signals. The resulting signal then is detected by IC102 and
output from Pin 9 as audio signals.
3.3 APC
The APC circuit stabilizes the output power at a predetermined level. D101 and D102 transform the signal from the
detector to DC voltage, which is then compared with the reference voltage from CPU in IC104 to output a DC voltage. The
DC voltage controls the output power by controlling the grid of IC101.
11
TM-610 Service Manual
4. PLL Circuit
The frequencies of receiving the first local oscillator signal and transmitting signal are generated by the PLL circuit. The
PLL circuit consists of Tx frequency oscillator (Q701), Rx frequency oscillator (Q702), buffer amplifier (Q703), RF amplifier
(Q102), PLL IC (IC801), LPF and Tx/Rx VCO control switch (Q704, Q706).
In transmit mode, IC120 transmits the frequency data to PLL IC. Q704 is turned on to activate Tx VCO. The output signal
is amplified by Q703 and Q102, and then divided by PLL IC into 2.5KHz, 5KHz or 6.25KHz signals. The divided signal is
compared with the 2.5KHz, 5KHz or 6.25KHz reference signal from a 16.8MHz crystal oscillator (2.5 PPM frequency
stability) in the phase comparator. The frequency control voltage output from the phase comparator is sent to Tx VCO after
passing through LPF (Q802, Q803). In the meantime, the modulation signal (Tx) is passed to Tx VCO for frequency
modulation.
The working principle in receive mode is similar to that in transmit mode.
Figure 3
5. Control Circuit
The control circuit is composed of CPU, reset IC and power supply control circuit.
5.1 CPU
IC502 (CPU) operates at 9.8304MHz. CPU controls the data transmission among E2PROM (IC501), Rx circuit, Tx circuit,
control circuit, display circuit and peripheral circuits.
12
TM-610 Service Manual
5.2 Power Supply
+B supplies power for the radio. D135 and D137 are over-voltage protection diodes. Power-on/off can be controlled via
the software.
13
TM-610 Service Manual
Semiconductor Data
1. Positive Voltage Regulator: TA7805F (POWER unit IC602) and TA7808S (POWER unit 601).
2. EEPROM: AT24C256N10SI2.7 (CPU unit IC501)
2.1 Pin Function
Pin No. Name I/O Function
1~3 A0~A2 I Address input
4 GND GND
5 SDA I/O Serial data
6 SCL Serial clock input
7 TEST Test
8 VCC +5V.
3. Audio Processor: AK2346 (AFPwr Unit IC404)
3.1 Pin Function
Pin No. Name I/O Function
1 AGNDIN I Analog ground input
2 AGND O Analog ground output
3 TxIN I Tx audio signal input
4 TxINO O TxA1 feedback output
5 LIMLV I Limit level tuning
6 EXTLIMIN I External signal input pin for pre-limiter circuit.
7 MOD O Modulated Tx signal output
8 VSS GND.
9 TCLK O Clock output pin for MSK transmission data.
10 TDATA I MSK transmission data input
Delay data is latched with the TCLK rising edge.
11 DI/O I/O Serial data input and output
Memory setting data during inputting; MSK receiving signal during outputting
12 RDF/FC O MSK signal output of receiving flag and frame detection signal
13 SCLK I I/O clock input of serial data
14 DIR I Serial data I/O control
15 XOUT I Crystal oscillator input
16 XIN I/O Crystal oscillator input and output
17 VDD Positive power supply
18 EXPOUT O Output signal after audio processing
19 RxAFIN I Rx audio signal input
20 RxAF O Rx audio signal output
21 RxLPFO O Rx LPF output
22 RxINO O RxA1 feedback output
23 RxIN I Demodulated Rx signal input
24 TEST I Test register control input
4. Audio Power Amplifier: TDA7297D (AFPwr unit IC511)
Pin Function
14
TM-610 Service Manual
Pin No. Name I/O Function
1 PW GND Power ground 1
2 OUT1+ O Output 1+
3 N.C
4 N.C
5 OUT1- O Output 1-
6 VCC I Supply voltage
7 IN1 I Input 1
8 MUT I Operation switch
9 STAND-BY I Operation switch
10 PW GND Power ground 2
11 PW GND Power ground 3
12 N.C
13 SGND Signal ground
14 IN2 I Input 2
15 VCC I Supply voltage
16 OUT2- O Output 2-
17 N.C
18 N.C
19 OUT2+ O Output 2+
20 PW GND Power ground
5. LCD Driver: PCF8576DH (Display unit IC501)
Pin No. Name I/O Function
1 N.C.
2~7 S34~S39 O Output LCD.
8~9 N.C.
2
10 SDA I/O Input/output I C bus serial data
11 SCL O Output I2 C bus clock
12 SYNC I N.C.
13 CLK I/O N.C.
14 VDD Power supply
15 OSC I Internal quartz crystal oscillator enable input
16~18 A0~A2 I Address line
2
19 SA0 I I C bus sub-address bit 0
20 Vss GND
21 VLCD N.C
22~24 N.C.
25~28 BP0~BP3 O LCD base panel output
29~32 S0~S4 O Output LCD
33 N.C. .
34~47 S5~S18 O Output LCD
48 N.C.
49、50 S19、S20 O Output LCD
51~64 S21~S34 O Output LCD
15
TM-610 Service Manual
6. Amplifier: TA75W558FU (AFPr unit IC404), TC75W51FU (AFPr unit IC402, AFPr unit IC405, AFPr unit IC403),
TA75S01F (RF unit IC1037), TA75W01FU (RF unit IC404).
7. IF Detector: TA31136FN (RF unit IC102).
8. Dual D-type trigger: TC4013BF (AFPwr unit IC512).
9. RF PLL Frequency Synthesizer: MB15A02 (PLL unit IC801).
10. CPU: SCM M3062LFGPGP (CPU unit IC502)
10.1 Pin Function
16
TM-610 Service Manual
36 P60 AUX2 I/O AUX2— — optional circuit board port 2 (input)
37 P57 RDY I Pull Up
38 P56 NC Not used (left open)
17
TM-610 Service Manual
81 P05 TYPE I TM-610/TM-610 Selection input,H: TM-610; L: TM-610
82 P04 NC I Left open
83 P03 P4 I P4 input,ON: L (external pull-up resistor)
84 P02 P3 I P3 input,ON: L (external pull-up resistor)
85 P01 P2 I P2 input,ON: L (external pull-up resistor)
86 P00 P1 I P1 input,ON: L (external pull-up resistor)
87 AN7 Not used (left open)
88 AN6 Volume I Volume Tuning input
89 AN5 DTMF soft decode preserve
90 AN4 DTMF soft decode preserve
91 AN3 Temperature I Temperature data input
92 AN2 RSSI I RSSI input
93 AN1 SQL I SQL analog input
94 AVss AVss GND
Component Description
1. Tx-Rx Unit
18
TM-610 Service Manual
19
TM-610 Service Manual
20
TM-610 Service Manual
21
TM-610 Service Manual
22
TM-610 Service Manual
23
TM-610 Service Manual
24
TM-610 Service Manual
25
TM-610 Service Manual
26
TM-610 Service Manual
27
TM-610 Service Manual
28
TM-610 Service Manual
29
TM-610 Service Manual
30
TM-610 Service Manual
31
TM-610 Service Manual
32
TM-610 Service Manual
33
TM-610 Service Manual
34
TM-610 Service Manual
35
TM-610 Service Manual
Tx-Rx Unit (VHF)
No. Material No. Description Qty. Ref. No. Print No.
1 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 C404 B5E
2 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R106 T2B
3 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R419 B5E
4 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R448 B5F
5 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R451 B5F
6 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R455 B5E
7 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R457 B5C
8 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R481 T4B
9 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R483 B4B
10 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R484 B4B
11 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R485 T4F
12 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R510 T4C
13 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R513 T4C
14 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R518 T5E
15 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R520 T5E
16 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R521 T5E
17 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R522 T5E
18 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R577 T4E
19 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R580 T4E
20 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R584 T4E
21 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R590 T5F
22 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R591 T5F
23 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R595 T4E
24 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R598 T4E
25 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R599 T4E
26 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R600 T5F
27 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R605 B2F
28 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R608 T5F
29 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R611 T4C
30 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R615 T4E
31 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R616 T4E
32 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R618 T4E
33 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R620 T5F
34 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R625 T5F
35 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R626 T4E
36 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R627 T4C
37 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R629 T5D
38 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R823 T3D
39 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R824 T3D
40 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R825 T3D
41 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R146 T2D
42 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R168 B3D
43 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R173 B3D
44 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R174 B3D
36
TM-610 Service Manual
37
TM-610 Service Manual
38
TM-610 Service Manual
39
TM-610 Service Manual
40
TM-610 Service Manual
41
TM-610 Service Manual
42
TM-610 Service Manual
43
TM-610 Service Manual
44
TM-610 Service Manual
45
TM-610 Service Manual
46
TM-610 Service Manual
47
TM-610 Service Manual
48
TM-610 Service Manual
49
TM-610 Service Manual
50
TM-610 Service Manual
51
TM-610 Service Manual
52
TM-610 Service Manual
53
TM-610 Service Manual
54
TM-610 Service Manual
55
TM-610 Service Manual
56
TM-610 Service Manual
Display Unit
No. Material No. Description Qty. Ref. No.
1 3001060000000 Chip resistor 0603 0Ω J 1/10W 1 R344
2 3001061010000 Chip resistor 0603 100Ω J 1/1 1 R341
3 3001061030000 Chip resistor 0603 10KΩ D 1/1 1 R304
4 3001061040000 Chip resistor 0603 100KΩ D 1/ 1 R319
5 3001061210000 Chip resistor 0603 120Ω J 1/1 1 R311
6 3001061830000 Chip resistor 0603 18KΩ D 1/1 1 R308
7 3001061830000 Chip resistor 0603 18KΩ D 1/1 1 R313
8 3001062700000 Chip resistor 0603 27Ω J 1/10 1 R306
9 3001063310010 Chip resistor 0603 330Ω J 1/1 1 R301
10 3001063920000 Chip resistor 0603 3.9KΩ J 1/ 1 R307
11 3101064710000 Chip capacitor 0603 470PF K 50 1 C301
12 3101064710000 Chip capacitor 0603 470PF K 50 1 C302
13 3307110000000 LED KP-1608SECK (RoHS) 1 LED302
14 3307110000000 LED KP-1608SECK (RoHS) 1 LED303
15 3307110000000 LED KP-1608SECK (RoHS) 1 LED304
16 3307110000000 LED KP-1608SECK (RoHS) 1 LED306
17 3307110000000 LED KP-1608SECK (RoHS) 1 LED307
18 3307110000000 LED KP-1608SECK (RoHS) 1 LED308
19 3307110000000 LED KP-1608SECK (RoHS) 1 LED309
20 3307110000000 LED KP-1608SECK (RoHS) 1 LED310
21 3307110000000 LED KP-1608SECK (RoHS) 1 LED311
22 3399010600000 Diode HSB123TR-E 1 D303
23 3399010600000 Diode HSB123TR-E 1 Q305
24 3399010600000 Diode HSB123TR-E 1 Q306
25 3403002000000 Transistor 2SB1132FD5T100R 1 Q302
26 3403008000010 Transistor DTC114EE(TL) 1 Q301
27 3403008000010 Transistor DTC114EE(TL) 1 Q303
28 3403008000010 Transistor DTC114EE(TL) 1 Q304
29 3609023000020 LCD Drive PCF8576DH/ 1 IC301
30 5207032000000 FFC/FPC Connector 52559-327 1 J302
31 3213306221010 Multi-layer chip inductor 0603 0.22uH 1 L301
32 3213306221010 Multi-layer chip inductor 0603 0.22uH 1 L302
33 3001050000000 Chip resistor 0402 0Ω J 1/16W 1 R320
34 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R321
35 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R340
36 3001051010000 Chip resistor 0402 100Ω J 1/1 1 R342
37 3001051520000 Chip resistor 0402 1.5KΩ J 1/ 1 R315
38 3001051520000 Chip resistor 0402 1.5KΩ J 1/ 1 R316
39 3221506601000 Chip ferrite bead 0603 600Ω±25 1 L303
40 3001051210000 Chip resistor 0402 120Ω J 1/1 1 R310
41 3307110200000 LED KPB-3025SUR 1 LED
42 410M6101000H0 TM-610 Front panel PCB FR4 1.2T/2L/4P H 1
43 3101051030020 Chip capacitor 0402 0.01UF K 2 1 C304
57
TM-610 Service Manual
Tuning Description
1. Key Functions
1.1 Front Panel View
⑤ Speaker
⑥ Power Switch
58
TM-610 Service Manual
2.2 Enter Panel Tuning Mode
Press [P1] key to turn on the radio and enter tuning mode. Items of the tuning mode are shown as follows:
No Dealer Mode
1 Tx high power
2 Tx low power
3 Max. Frequency Deviation
4 CDCSS balance
5 CTCSS Frequency Deviation
6 CDCSS Frequency Deviation
7 DTMF Frequency Deviation
8 MSK Frequency Deviation
9 Single Tone Frequency Deviation
10 Rx Sensitivity
11 Squelch on level
12 Squelch off level
13 RSSI high power
14 RSSI low power
Note: The tuning items display as the description in Section “2.3”.
2.3. Tuning Items and Display
Setting Items and Display
Wideband/
Setting Items Main LCD Frequency Sub-LCD Description
Narrowband
Certer _C *** No signalling
TXHIGH High power Wideband Low _L *** No signalling
High _H *** No signalling
TX Power
Center _C *** No signalling
TX LOW Low power Wideband Low _L *** No signalling
High _H *** No signalling
Center _C *** No signalling
Wideband Low _L *** No signalling
High _H *** No signalling
Max Deviation MAX.DEV Medium band Center M_C *** No signalling
Center N_C *** No signalling
Narrow band Low N_L *** No signalling
High N_H *** No signalling
Center _C *** CDCSS:023N
Wideband Low _L *** CDCSS:023N
High _H *** CDCSS:023N
Medium band Center M_C *** CDCSS:023N
CDCSS Balance CDCSS.BAL
Center N_C *** CDCSS:023N
Low N_L *** CDCSS:023N
Narrow band
CDCSS:023N
High N_H ***
59
TM-610 Service Manual
Ceter _C *** CTCSS: 67.0Hz
Wideband Low _L *** CTCSS: 67.0Hz
High _H *** CTCSS: 67.0Hz
CTC.DEV_L Medium band Ceter M_C *** CTCSS: 67.0Hz
Ceter N_C *** CTCSS: 67.0Hz
Narrow band Low N_L *** CTCSS: 67.0Hz
High N_H *** CTCSS: 67.0Hz
Ceter _C *** CTCSS:151.4Hz
Wideband Low _L *** CTCSS:151.4Hz
High _H *** CTCSS:151.4Hz
CTCSS.Deviation CTC.DEV_M Medium band Ceter M_C *** CTCSS:151.4Hz
Ceter N_C *** CTCSS:151.4Hz
Narrow band Low N_L *** CTCSS:151.4Hz
High N_H *** CTCSS:151.4Hz
Ceter _C *** CTCSS:254.1Hz
Wideband Low _L *** CTCSS:254.1Hz
High _H *** CTCSS:254.1Hz
CTC.DEV_H Medium band Ceter M_C *** CTCSS:254.1Hz
Ceter N_C *** CTCSS:254.1Hz
Narrow band Low N_L *** CTCSS:254.1Hz
High N_H *** CTCSS:254.1Hz
Ceter _C *** CDCSS: 023N
Wideband Low _L *** CDCSS: 023N
High _H *** CDCSS: 023N
CDCSS.Deviation CDCSS.DEV Medium band Ceter M_C *** CDCSS: 023N
Ceter N_C *** CDCSS: 023N
Narrow band Low N_L *** CDCSS: 023N
High N_H *** CDCSS: 023N
Ceter _C *** DTMF: 9
Low _L *** DTMF: 9
Wideband
High _H *** DTMF: 9
Medium band Ceter M_C *** DTMF: 9
DTMF Deviation DTMF.DEV
Ceter N_C *** DTMF: 9
Narrow band Low N_L *** DTMF: 9
High N_H*** DTMF: 9
Ceter _C *** 0XAAA…
Wideband Low _L *** 0XAAA…
High _H *** 0XAAA…
MSK Deviation MSK.DEV Medium band Ceter M_C *** 0XAAA…
Ceter N_C *** 0XAAA…
Narrow band Low N_L*** 0XAAA…
High N_H*** 0XAAA…
60
TM-610 Service Manual
Center _C *** 1KHz
Wideband Low _L *** 1KHz
High _H *** 1KHz
Single Tone
TONE DEV Medium Center M_C *** 1KHz
Deviation
Center N_C *** 1KHz
Narrowband Low N_L*** 1KHz
High N_H *** 1KHz
No signalling,
- Low
_L *** SQL off
No signalling,
- Low-center
_LC *** SQL off
No signalling,
Rx Sensitivity SENSITVI - Center
_C *** SQL off
No signalling,
- Center-high
_HC *** SQL off
No signalling,
- High
_H *** SQL off
Center _C *** No signalling
SQL 9 Wideband Low _L *** No signalling
High _H *** No signalling
OPENSQL9 SQL 9 Medium Center M_C *** No signalling
Center N_C *** No signalling
SQL 9 Narrowband Low N_L *** No signalling
High N_H *** No signalling
SQL Open
Center _C *** No signalling
SQL 3 Wideband Low _L *** No signalling
High _H *** No signalling
OPENSQL3 SQL 3 Medium Center M_C *** No signalling
Center N_C *** No signalling
SQL 3 Narrowband Low N_L *** No signalling
High N_H *** No signalling
Center _C *** No signalling
SQL 9 Wideband Low _L *** No signalling
High _H *** No signalling
CLOS.SQL9 SQL 9 Medium Center M_C *** No signalling
Center N_C *** No signalling
SQL 9 Narrowband Low N_L *** No signalling
SQL Close
High N_H *** No signalling
Center _C *** No signalling
SQL 3 Wideband
Low _L *** No signalling
CLOS.SQL3
High _H ***
No signalling
61
TM-610 Service Manual
Center N_C *** No signalling
Low N_L *** No signalling
SQL 3 Narrowband
High N_H *** No signalling
Center _C *** No signalling
Wide band Low _L *** No signalling
High _H *** No signalling
RSSI High Power RSSIHIGH Medium Center M_C *** No signalling
Center N_C *** No signalling
Narrow band Low N_L *** No signalling
High N_H *** No signalling
Center _C *** No signalling
Wide band Low _L *** No signalling
High _H *** No signalling
RSSI Low Power RSSI LOW Medium Center M_C *** No signalling
Center N_C *** No signalling
Narrow band Low N_L *** No signalling
High N_H *** No signalling
2.4.Flow Chart
62
TM-610 Service Manual
[ U p ]/[D o w n ] [U p ]/[D ow n ]
[P 4 ] [P 4 ]
Tu ning
M o de, C D C S S de viatio n C D C SS d evia tion (C enter) o pen S que lch o pen S qu elch ( C e nte r)
Pre ss [P 1 ] [P 4 ] [P 4 ]
[P 4 ]
TX po w er T X h igh po w er ( C enter ) C D C S S devia tion ( L ow) o pen Squ elch ( L ow)
[P 4 ] [P 4 ] [P 4 ]
T X high pow e r ( L ow ) C D C SS de viation( H igh) o pe n Squ elch( H igh)
[P 4 ] [P 4 ] [P 4 ]
T X hig h pow er ( H ig h) C D CS S d eviatio n (m idd le Ce nter ) ope n Sq uelch ( m idd le
C en ter )
[ P4 ] [P 4 ]
[P 4 ]
T X lo w pow e r (C enter ) C DC SS de via tion (n arrow Ce nter)
op en Sq ue lch ( na rrow
[P 4 ] [P 4 ] C en ter )
T X low p ow e r ( L ow ) CD C SS d evia tio n( na rro w Lo w) [P 4 ]
[P 4 ] [P 4 ] ope n Sq uelc h( narro w Low)
T X low p ow e r ( H ig h) C DC SS de via tion (na rro w H ig h) [P 4 ]
[P 4] op en S que lch ( narro w H igh)
[U p ]/[D ow n ]
[P 4 ] [ U p ]/[D o w n ] [ P4 ]
D T M F de viation D TM F de viation ( C e nte r) [P 4 ]
[P 4 ] C los e Squ elch C lose S que lch ( C e nte r)
D TM F de viation ( L ow) [P 4 ]
[P 4 ] C lose S que lch ( Low)
[U p ]/[ D o w n] [P 4 ]
D TM F d evia tion ( high ) [P 4 ]
[P 4 ]
[P 4 ] C los e Squ elch ( H igh )
M ax. de viatio n M a x. de viation ( C en ter )
DT M F de via tion( m id dle C en te r) [P 4 ]
[P 4 ]
[P 4 ] C lose S qu elch ( m iddle
M a x. de viation ( Low ) C en ter )
D TM F d eviatio n(na rro w C en ter)
[P 4 ] [P 4 ]
[P 4 ]
M a x. dev iation (H igh ) C lose S que lch ( n arrow
D TM F d eviatio n( n arrow Lo w) C en ter )
[P 4 ]
[P 4 ] [P 4 ]
M a x. d evia tion ( M idd le
C e nte r) D T M F d evia tio n( na rro w H ig h) C lo se Sq ue lch ( na rrow L ow )
[P 4 ] [U p ]/[ D o w n] [P 4] [P 4 ]
M a x. d evia tion( narro w [ P4 ] C lose S que lch ( n arrow
C e nte r) H ig h)
M SK d evia tion M S K dev iation( C e nte r)
[P 4 ] [ P4 ]
[U p ]/[D ow n ]
[P 4 ]
M a x. de viatio n (na rrow Lo w ) [ P4 ]
M S K dev iation( Low )
H igh R S SI H igh R S SI ( C e nte r)
[P 4 ] [P 4 ]
[P 4 ]
M SK de viatio n( h igh)
M ax. de viatio n( na rrow H ig h) H igh R SSI ( L ow )
[P 4 ]
[ U p ]/[D o w n ] [ P4 ] [P 4 ]
M SK de via tion (m idd le Ce nter )
[ P4 ] H igh R SSI ( H ig h)
[P 4 ]
C D C S S Bala nce C D C SS B alan ce (C e nte r) [P 4 ]
M S K de viation (na rro w C en te r)
[P 4 ] H ig h R SS I ( m id dle C e nte r)
[P 4 ]
C D C S S Ba lanc e( Low) [P 4 ]
M SK de via tion( n arrow L ow )
[P 4 ] H ig h R SS I( na rrow C en ter )
[P 4 ]
C D C SS B ala nce( H ig h) [P 4 ]
M S K d eviatio n (na rro w H igh)
[P 4 ] H ig h R SS I (n arro w L ow )
[P 4]
C D C SS B alan ce (m id dle [ U p ]/[D o w n ] [P 4 ]
C en ter ) [ P4 ]
Sin gle to ne H ig h R SS I ( narro w H igh)
[P 4 ] Ton e de viatio n( C e nte r)
d eviation [ P4 ]
C D C SS Ba lan ce( n arrow [P 4 ] [U p ]/[D ow n ]
C en ter ) [ P4 ]
To ne d evia tion (L ow )
[P 4 ] Lo w R S SI H igh R S SI ( C e nte r)
C D C SS Ba lan ce( n arrow [P 4 ]
Lo w ) [P 4 ]
To ne d eviation ( high )
[P 4 ] H igh R SSI ( L ow )
[P 4 ]
C D C SS Ba lan ce( n arrow [P 4 ]
H igh ) To ne de via tion ( m id dle Ce nte r)
H igh R SSI ( H ig h)
[U p ]/[ D o w n] [P 4 ] [P 4 ]
[P 4 ]
[P 4 ] T on e d eviatio n(na rro w C e nter)
H ig h R SS I ( m id dle C e nte r)
C TC S S dev iatio n C T C S S de viatio n (C en ter ) [P 4 ]
[P 4 ]
[P 4 ] To ne de via tion ( na rro w L ow)
H ig h R SS I( na rrow C en ter )
C T C S S de viatio n (Lo w ) [P 4 ]
[P 4 ]
[P 4 ] T on e d evia tio n(n arrow H ig h)
H ig h R SS I (n arro w L ow )
C T C S S de viatio n ( H igh ) [ U p ]/[D o w n ] [P 4]
[P 4 ]
[P 4 ] [P 4 ]
H ig h R SS I ( narro w H igh)
C T C SS de viation (m id dle R x S ens itivity R x Se nsitivity ( Lo w )
C e nte r) [ P4 ]
[P 4 ]
[P 4 ]
R x S ens itivity (L C )
C T C S S de viatio n ( na rrow
C e nte r) [P 4 ]
[P 4 ] R x Se nsitiv ity ( C e nte r)
C T C S S de viatio n ( na rrow [P 4 ]
L ow )
R x S ens itivity ( H C )
[P 4 ]
[P 4 ]
C T C S S de viatio n ( na rrow
H ig h ) R x S en sitivity ( H ig h)
[ P4 ] [P 4]
63
TM-610 Service Manual
Standard Signal Generator Frequency VHF: 136-174 MHz; UHF: 400-470 MHz 450-500 MHz
(SSG) Modulation 470-520 MHz 350-400 MHz 440-470 MHz
Output power Frequency modulation and external modulation
0.1uV to 1mV above
Power Meter Input Impedance 50Ω
Operation Frequency VHF: 136-174 MHz; UHF: 400-470 MHz 450-500 MHz
Measurement Capability 470-520 MHz 350-400 MHz 440-470 MHz
About 25W (high power)/5W (low power)
Tuning Meter Frequency Range VHF: 136-174 MHz; UHF: 400-470 MHz 450-500 MHz
470-520 MHz 350-400 MHz 440-470 MHz
Digital Voltmeter (DVM) Measuring Range 1 to 20V DC
Accuracy High input impedance for minimum circuit loading
Oscilloscope DC to 30MHz AC
DUMMY
To Audio VIVM
SP
Distortion
Meter SP
64
TM-610 Service Manual
3.2 Test Cable for Microphone Input
HOOK
To AG
MIC
Audio VTVM
MICG PTT
END
CUT
8 PIN
1:CM 5:PTT/TXD
2:HOOK/RX 6:GND
D3.MIC 7:PSB
4:ME 8:MBL
Instrument:
Radio Communication Test Set 1 set
Spectrum Analyzer 1 set
20A/30V Power Supply 1 set
Digital Voltmeter 1 set
Power Meter 1 set
Signal Cable (with dummy load) 1 piece
65
TM-610 Service Manual
2. Initialization
It is necessary to set the frequency and initialize the radio before tuning because there is no wanted information in
EEPROM when the radio is manufactured.
z Turn on the radio while holding down P2, and then release them to enter frequency initiliazation. Observe the
display and select an item through the Up/Down arrow keys. The display may show the following items:
“0” (TM-610V)
“1” (TM-610U1)
“2” (TM-610U2)
“3” (TM-610U3)
“4” (TM-610U4)
“5” (TM-610U5)
“6” (TM-610U6, for Taiwan only)
“7” (TM-610U7)
Then press the [P4] again to save data. See the Model table below.
z LED on the front panel stops flashing, indicating that the initialization is completed.
3. Tuning
Some items can be tuned in the conventional mode and the others can be tuned manually.
z Turn on the radio to enter the conventional mode.
z Turn off the radio. And then turn the radio back on while holding down P1. The radio enters manual tuning mode. The
channel number is displayed on LCD.
z Frequency Table (The following table shows all the available frequency points.)
66
TM-610 Service Manual
VCO
1.Power supply:
1. Power Supply Note:
DC 13.6V
1. The radio can only be installed in negative grounding electrical system.
Reverse polarity will cause the cable fuse to get blown. Check the vehicle
ground polarity before installation to avoid wasted time and effort.
2. If the DC power is controlled by the vehicle ignition switch, then the power on
procedure is controlled by the input control pulse signal of the car ignitor.
6.1V±0.1V TM-610U1
5.0V±0.1V TM-610U2
TM-610U3
5.1V±0.1V TM-610U4
2.VCO Lock Voltage 1.CH: TX HI
Digital Voltmeter CV TC701 TM-610U6
(Tx )
TM-610U5
4.0V±0.1V
TM-610U7
6.0V±0.1V TM-610V
2.CH: TX LO Check >1.0V
TM-610U1
TM-610V
6.0V±0.1V TM-610U3
TM-610U4
3.VCO Lock Voltage 1.CH: RX HI TM-610U6
Digital Voltmeter CV TC702
(Rx) TM-610U5
4.0V±0.1V
TM-610U7
6.5V±0.1V TM-610U2
Measurement Tuning
Item Condition Specification/Remarks
Test
Terminal Part Method
Instrument
Radio
4.TX Not enter tuning item, Tune channel
Communication ANT VR801 Error<50Hz
Frequency but switch to CH2 frequency
Test Se
67
TM-610 Service Manual
tune High/Low power. VHF high PO=5±0.5W
power, and I≤4.0A
unnecessary for
UHF.
11. Each CH corresponds Radio Adjust value Adjust deviation to: “_C, “_L”, and “_H”
Communication ANT
CDCSS to a specific TX freq; Test Set through 0.75KHz±0.10KHz correspond to wide
68
TM-610 Service Manual
Deviation enter the item Filter: UP/DOWN (W) band; “M_C.”
“CDCSS_DEV" and <20HZ-300Hz keys, then 0.60KHz±0.10KHz corresponds to medium
press P4 to enter “_C”, AF: OFF press [P4] to (M) band; “N_C.”, “N_L”,
“_L”, “_H”, “M_C”
, save setting s 0.37KHz±0.05KHz and “N_H”correspond
“N_C”, “N_L”, “N_H”. and move to the (N) to narrow band of
next item. Hi/Center/Low freq.
Adjust value “_C, “_L”, and “_H”
Each CH corresponds
through correspond to wide
to a specific TX freq; Radio
UP/DOWN band; “M_C.”
enter the item Communication 3.0KHz±0.1KHz (W)
12. DTMF Test Set keys, then corresponds to medium
“DTMF .DEV" and Filter: ANT 2.4KHz±0.1KHz (M)
Deviation press [P4] to band; “N_C.”, “N_L”,
press P4 to enter “_C”, 300Hz--3KHz 1.5KHz±0.1KHz (N)
AF: OFF save settings and “N_H”correspond
“_L”, “_H”, “M_C” ,
and move to the to narrow band of
“N_C”, “N_L”, “N_H”.
next item. Hi/Center/Low freq.
Adjust value “_C, “_L”, and “_H”
Each CH corresponds
through correspond to wide
to a specific TX freq; Radio
UP/DOWN band; “M_C.”
enter the item Communication 3.0KHz±0.1KHz (W)
Test Set keys, then corresponds to medium
13. MSK “MSK.DEV" and press Filter: ANT 2.4KHz±0.1KHz (M)
press [P4] to band; “N_C.”, “N_L”,
P4 to enter “_C”, “_L”, 300Hz--3KHz 1.5KHz±0.1KHz (N)
AF: OFF save se ttings and “N_H”correspond
“_H”, “M_C”, “N_C”,
and move to the to narrow band of
“N_L”, “N_H”.
next item. Hi/Center/Low freq.
Adjust value “_C, “_L”, and “_H”
Each CH corresponds
through Adjust deviation to: correspond to wide
to a specific TX freq; Radio
14. Single UP/DOWN 3.0KHz±0.10KHz band; “M_C.”
enter the item “TONE Communication
tone Test Set keys, then (W) corresponds to medium
DEV" and press P4 to Filter: ANT
(2-tone / press [P4] to 2.4KHz±0.10KHz band; “N_C.”, “N_L”,
enter “_C”, “_L”, “_H”, 300Hz-3KHz
5-tone) AF: OFF save se ttings (M) and “N_H”correspond
“M_C”, “N_C”, “N_L”,
and move to the1.5KHz±0.1KHz (N) to narrow band of
“N_H”.
next item. Hi/Center/Low freq.
Radio
Communication
Test Set
1. Each CH Filter:
15. FM S/N≥45 (W)
corresponds to a 0.3-3KHz ANT Check
Noise AF:1KHz S/N≥40 (N)
specific TX freq.
7.5mV,
DEV: 3KHz
69
TM-610 Service Manual
Receiver
UHF waveform:
Radio
Communication
Test Set
Frequency: RX Center;
SSG Output: Check Max.
17. Max. tune to CH1(C); ANT
-47dBm K301 volume:
volume corresponds to a specific SP Jack
MOD: 1KHz 4.3 V-5.4V
freq.
DEV: ±3KHz(W)
±1.5KHz(N)
Filter: 0.3-3.0KHz
Radio
1. Frequency: RX Center; Communication
tune to CH1(C) manually. Test Set Wide/Narrow
SSG Output: switch (Turn on
-118dBm the radio while
ANT holding down [P1] SINAD:
70
TM-610 Service Manual
Radio
Enter in turn the items No need to
Communication
“OPEN SQL9”(Level 9 tune software Press [P4]
Test Set
on), “OPEN SQL3”(Level setting at twice to
19. SQL SSG Output:
3 on); then press [P4] to squelch Level read/write
Open -114dBm (Level 9)
enter items “_C.”, “_L”, 3&9; Just press squelch level
“_H”, “M_C”, “N_C”, “N_L”,SSG Output: [P4] twice to from/into CPU.
“N_H”. -120dBm (Level 3) ANT Adjust software save.
SP Jack settings
Enter in turn the items Radio No need to
“OPEN SQL9”(Level 9 Communication tune software Press [P4]
on), “OPEN SQL3”(Level Test Set setting at twice to
20. SQL
3 on); then press [P4] to SSG Output: squelch Level read/write
Close
enter items “_C.”, “_L”, -116dBm (Level 9) 3&9; Just press squelch level
“_H”, “M_C”, “N_C”, “N_L”,SSG Output: [P4] twice to from/into CPU.
“N_H”. -122dBm (Level 3) save.
21. Radio
DIS≤5%
Distortion Communication
ANT Filter:
1. CH: RX Center Test Set Check
SP Jack 0.3-3.0KHz S/N≥45 (W)
22.S/N SSG Output:
S/N≥40 (N)
-47dBm
Note: The radio must be covered with aluminum chassis during tuning of sensitivity, transmit power, signalling waveform,
frequency deviation, carrier frequency error, Rx squelch. Connect an RF power meter to the antenna connector during
transmission. Connect a SINAD meter with 16ohm load to the external SP Jack.
Terminal Function
1. Display Unit
71
TM-610 Service Manual
6 MICDAT Serial data output for keypad MIC.
7 NC NC
8 ME MIC ground
9 MIC MIC signal output.
10 GND Ground
11 VO Audio input after tuning by k301
12 PSW Power switch control signal output
13 RxD2 Serial data output
14 TxD2 Serial data input
15 VI Audio output after tuning by k301
16 TYPE Model select(H:TM-610; L:TM-610)
17 P4 SW position signal output 4
18 P3 SW position signal output 3
19 P2 SW position signal output 2
20 P1 SW position signal output 1
21 SLED Scan indicator
22 PLED Low power indicator
23 RLED Transmit indicator control
24 GLED Receive indicator control
25 LED1 Channel display control
26 LED7 Channel display control
27 LED0 Channel display control
28 LED2 Channel display control
29 LED5 Channel display control
30 LED3 Channel display control
31 LED6 Channel display control
32 LED4 Channel display control
2. Tx-Rx Unit
72
TM-610 Service Manual
13 RxD2 Serial data output
14 TxD2 Serial data input
15 VI Audio input after tuning by k301
16 TYPE Model select (H:TM-610; L:TM-610)
17 P4 SW position signal output 4
18 P3 SW position signal output 3
19 P2 SW position signal output 2
20 P1 SW position signal output 1
21 SLED Scan indicator
22 PLED Low power indicator
23 RLED Transmit indicator control
24 GLED Receive indicator control
25 LED1 Channel display control
26 LED7 Channel display control
27 LED0 Channel display control
28 LED2 Channel display control
29 LED5 Channel display control
30 LED3 Channel display control
31 LED6 Channel display control
32 LED4 Channel display control
J504 (to Speaker)
1 SP1 BTL input for external speaker output.
2 SP2 BTL input for external speaker output.
J503 of Previous Version (to Repeater)
1 TxD1 Serial data input
2 RxD1 Serial data output
3 MIC2 External MIC signal output.
4 ME MIC ground
5 AF-OUT Filtered audio output.
6 TI Filtered CTCSS/CDCSS output.
7 PA1 MIC signal output
8 PA2 MIC signal output
9 E GND
10 IGN Ignition sensor input
11 SB Power input after power switch (13.6V+15%)
12 AUX1 Programmable auxiliary port
13 AUX2 Programmable auxiliary port
14 AUX4 Programmable auxiliary port
15 AUX5 Programmable auxiliary port
J503 of New Version (to Repeater)
1 TxD2 Serial port transmitting and reading
2 RxD2 Serial port writing
3 MIC2 External MIC input
73
TM-610 Service Manual
4 ME External MIC ground
AF_O Receive audio output (300-3KHz, de-emphasized) (default)
5
DI Modulation input of digital signal (selectable)
PA1 Signal output of SPEAKER1 (default)
6
RSSI Field detect of received signal (selectable)
PA2 Signal output of SPEAKER2 (default)
7
PCO RF power control (selectable)
8 AUX1 Expansion functions (AUX1 to AUX 4): 1. External PTT; 2. Data Transmission
9 AUX2 PTT; 3. Speaker Mute; 4. External Monitor; 5. ▲ key; 6. ▼ key 7. External
10 AUX3 Hook; 8. Emergency Call; 9. MIC Mute; 10. Receive Carrier; 11. Receive Tone;
11 AUX4 12. Digital Modulation Input
74
TM-610 Service Manual
75
TM-610 Service Manual
76
TM-610 Service Manual
77
TM-610 Service Manual
78
TM-610 Service Manual
1. Turn off the radio. Disconnect the power cord and screw out the antenna connector.
2. Remove the top cover.
3. Loosen the 8 screws locking the shielding and pedestal of the aluminum chassis. Then remove the shielding,
disconnect FFC and speaker cable which bind front panel PCB and main unit PCB.
4. Loosen the two screws shown in the following figure, and detach the front panel from the main unit.
79
TM-610 Service Manual
5. Pull out the volume control knob. Screw out the copper nut from the potentiometer tuning volume. Then loosen the four
screws fixing the front case and remove the front panel.
6. Use an electric iron and screwdriver to separate the antenna connector, power cord, external board and waterproof ring
on this board.
7. Loosen the screws fixing the main unit PCB and PA module.
80
TM-610 Service Manual
Assembly
2. Tighten the four tuning screws (each with one shrapnel and one shim).
3. Plug the connector (microphone) into the jack (microphone). If the microphone is not in use, hang it on the bracket .
81
TM-610 Service Manual
Exploded View
1
2
6
7
8
9
10
47
11
46 12
45
44
43
42
41
40 13
39 14
38 15
37 16
36 17
35 18
34
33 19
32 20
31
21
22
30 29 28 27 26 25 24 23
82
TM-610 Service Manual
83
TM-610 Service Manual
41 4310020000000 Rotary switch 1
42 PCB (front panel) 1
43 7400201000000 Baffle 2
44 4210100000400 32pin signal cable 1
45 PCB (radio unit) 1
46 7102606020000 Self-tapping screw ST2.6*6.0mm 5
47 6100143000000 Waterproof ring (radio unit) 1
Remarks: Parts that are not marked with material number can vary according to changes of their corresponding power
and frequencies.
84
TM-610 Service Manual
Packing
85
TM-610 VHF PCB View (Main Board Unit)
Top Layer
86
TM-610 VHF PCB View (Main Board Unit)
Bottom Layer
87
TM-610 UHF PCB View (VCO Unit)
88
TM-610 UHF PCB View (Main Board Unit)
Top Layer
89
TM-610 UHF PCB View (Main Board Unit)
Bottom Layer
90
TM-610 PCB View (Display Unit)
Top Layer
91
TM-610 PCB View (Display Unit)
Bottom Layer
92
1 2 3 4 5 6 7 8
D
TM-610 UHF/VHF Block Diagram
TM610原理框图 D
LE
Data
CLK UL
Q802,Q803 ANT
PLL IC
+B +B LPF IC 801 SW Drive AMP Drive AMP final AMP 8T TX/RX SW
D801 ATT
8C 5V D105 LPF
Q702 Q110 Q109 IC101
50ohm 50ohm D104
IC601 8V RX DET
Protect Q512 AVR Q801 VCO LPF IC802 8T 8T IC104 D101
D515 SW 8V Filter 8C 16.8MHz DC
SW SW OSC1 AMP D102
Protect AVR 5V Q706 Q705 MB DET
D516 IC602 AVR AMP 8T PCO
IC8033.3V ST Q704
Protect SW IGN SW SW Q102 8T RF AMP
8T
D517 IC512 Q603 BPF BPF BPF
Q111
8TC TX VCO Q703 Q101 D115 LPF
C PSW SBC SW Q701 SW C
8R
Q601 OSC1 MD Buff AMP Buff AMP 8R
16.8MHz 8C 8R Mixer D107 D110 D108
50.4MHz Q112 D109 D120
BPF IF AMP
Q107 IF BPF
Q113
49.95M CV
8R FM IC
QUAD IC102 8R
CD201
IC501 IC301 AF 450KHz
E2PROM SW IF BPF SW
TXD/RXD
AMP 5C IF BPF
PTT
2T/5T OUT3
SDA TCLK,TDATA AMP RXLPFO Q511
DTMF OUT4
DI/O,RDF/FD Filter MIC out
SCL 5C DIR,SCLK MSK IC404
CPU VDD TI Filter SP Mute SB APCO
3.6864MHz
PLL IC
TI
B B
X402 RXIN
LED301 MIC in IC403
TXD/RXD LED306--311 D302--D304 IC406
J302 LED*6 LED*3 S301--S307
PF*7 2T/5T EXPOUT
Q304 Q303
SW SW IC405
TO CPU
SW SW MIC 1 AMP
5C Q301 LCD--BL Q302
BEAT X102 APC W/N RSSI
SHIFT BEEP T/R CH Encode 2T/5T,DTMF
9.8304MHz MUTE SBC
8TC IGN PTT
8RC PSW
A
93 A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
5C
AF_O
R437 220K
R440
R436 33k C447 VO
C450 15K
DET
1u R625
47P Voltage level is 680-685mV
1
R480 0 C468
NC R485 NC R486
R434 Q406
R481 IC402 22k
1
BEEP 18k MIC
-
0 2sk1824 R455 0 1u
TC75W51FU
+
R488
0.1u C467 NC
+ -
R401 R402 R403
DT/2T 1uF
8
C448 C444
R435
10k C449
18k
10k C403 R482 4.7u/6.3v 1u
4.7k 1uF
C402 C443 R439
8
R404 33k
C401 R405 R433 C446 C445 1k
0.01u 4700p 15k 1000p
47k 33k NC 470p R441
C405 22k
0.1UF
PA
NC R438 100k
C404
R408 R409
15k 22k R406 R407 R442 R443
CTC_OUT 0 Q405
330K 2.7K R479 22K 91K
2SK1824
C410 C409 C419 C439 R444 1u
0.015u 0.018u R454 68K
47k 330p C437
C411 0.82U
R410
8
2SC4617 C438 1u
0.1u C440
DI C406 C442
15K Q401 R453
4.7U/6.3V 0.1UF C420 470pF 1k R445
R412
+ -
1000p
R424 R425
C441
C408 C407 0.47u 22k
R411 0.1UF 220 10k 0
C IC405 C
MOD
390k R413
+
TC75W51FU
1U NC
R484 R483
-
C416 C421 R428 C422
0 0K
2200p 560p 27k 0.47u
R414 ME
C436
1
1u R449 R447 0.027U R446
100k
R422 10k 4.7k 150k
R426
PA R423 R427
10k
C418 100k
Q402 330k 10k C417 C435
1u
C424 47p
DTC114EE IC401 4.7u/6.3v R448
C423
R456
C415 AK2346 0
68k
33p
1 24 R452
C412 AGNDIN TEST R457
R420 R421 22K
1U AGND RXIN C425 0
51k 27k 33p R451 0
TXIN RXINO R429
R418 R419 C414
TXINO RXLPFO 150p 56k
18k 0 1uF
LIMLV RXAF
EXTLIMIN RXAFIN R450
C426 0.027u C434
MOD EXPOUT 56k R430 10k D402
C413
C432 47p 1u
TCLK XIN C427
R415 R416 C430 Q404 470p
3.6864MHz
TDATA XOUT 22p RB706F-40
27k 18K R431 0.1u 2SC4116(Y)
DI/O DIR C466
12 13
RDF/FD SCLK 390K MIC2
X402
C428 C429
NC 15u/6.3v R487
R417 NC
6.8k Q403 22p
2SK1824
NCON R432 33k +8V
C431
C903
R458
0.01u D401
AFCK R462 R461 22k
NC MA742
82k 390k
AFDT
C460
1k 0.068u
IC403 180k
2700p
R471 C451 IC404 C454
R467
AFDIR
100k
1 8 12k 220P 1 8 0.012u
R477 R473
AFSCLK 10k 1M C458
R475
150k
R474 - + 1000p - +
2T/5T 8.2k
+ - R470 R469 R468 + - R460
R472
4.7u/6.3v
TI 10k 10k 4.7k 100k 180k
0.01u
C456
R465 R464
C457
AFMute 15k 10k
TC75W51FU C462 TA75W558FU C455
R478
MicMu C465 C464 1000p 2200p
150k
0.01u 4.7u/6.3v C463 C461
0.1u 0.01u
A A
94
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
Q521
R573 2SK1824
PA
4.7K
C537
0.1u
BS
R575
VI
0
R624 C531
Q511 0 1000P
BEEP/ALT C511
R571 R572 2SK1824 Q512 D516 D515
BEEP 22ZR-10D
DSM3MA1
4.7K 47K 2 3
2SA1641(S.T)
C E B+
0.1u
0.1U C532 R570 C526
B
R543 C530 0 D517 1000P
SPMute C533 R551 R568
4.7K C534 1000P 4.7K 1000P 1SS355 C527
R544 R545 47U/25V 1K 470U/25V
1
C512 47K 47K DTA114EE
0.01u Q519
R569
13.55V C529
0 C528
C EXTSP C513 C514 R552 1000P 0.1U C
J511 2 1u 1u 470 0.5W D518
1 C515 C516 02DZ15(X.Y) Q520
3
0 DTA114EE DTC114EE
1800p 1800p Q513 C525 Q518
DTC114EE 0.1U
R564
10
1
2
3
4
5
6
7
8
9
0
R553 6.22V D511 1 14
0 R554 Q1 Vdd
C536 1SS355
STAND-BY
PW GND
PW GND
OUT1+
IN1
MUT
OUT1-
N.C
N.C
VCC
PW GND
OUT2-
ON:0.02V
SGNG
OFF:13.2V
N.C
N.C
N.C
C521 C520
D512
02DZ18(X.Y)
0.1U 0.1U Q515 Q516
C519 C518 DTC114EE R561
PSW
B 47K B
R558
R549 R548 10K
10 10 DTA114EE
1710B
10U/6.3V->1U/6.3V 1K
D514
PA2
0.22U 1SS355
R550 R559
APCO 100K
R574
Q517
NC
47K
DTC114EE
A
95 A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
D
TM-610 TM-600V
VHF Schematic
车载台(B Diagram
版) CPU(CPU
电路Unit) D
SDATA
SDATA
AFDIR
AFDIR
RSSI
RSSI
Type
Type
CSN
CSN
AUX2
AUX2
AUX6
AUX6
AUX3
CP523 AUX3
AUX5
AUX5
AUX4
AUX4
PSW
1K*2 PSW
Apc/Sen
Apc/Sen
SDATA DT/2T
DT/2T
CSN 2T/5T
2T/5T
AFDIO
L501 AFDIO
AFSCLK
5C AFSCLK
PA
601S TXD3 PA
CP505 1K*2 NCON
RXD3 NCON
RXD2 AFRDF
AFRDF
DGND TXD2 SBC
SBC
R511 AUX2 CTC_OUT
CTC_OUT
5.1K SPMute
SPMute
AUX4 CTC_PLL
CTC_PLL
AFDT
AFDT
NCON AFCK
AFCK
MicMu RXD2
RXD2
WCON TXD2
TXD2
SHIFT TXD1
TXD1
CP501
RXD1
1K*2
RXD1
CP521
R503
CP502
MICDAT MICDAT
MICDAT
5.1K
SHIFT
SHIFT
CP520 1K 1K*2 WCON
WCON
R502
1K*2 CP504 MicMu
R611
R628 R627 MicMu
1K RXD1/HOOK RXD1 RLED
0 RLED
R501 TXD1/PTT TXD1 GLED
42 1K*2
0 GLED
35 1K*2
C 100 AUX1 C
AUX1
0 R513 LCDBL/LED0
LCDBL/LED0
2627
AFDIR SHIFT LCDCE/LED1
LCDCE/LED1
50
49
48
47
46
45
44
43
41
40
39
38
37
36
34
33
32
31
30
29
28
1k R504 LCDCL/LED2
LCDCL/LED2
LCDCI/LED3
P42/A18
P43/A19
P56/ALE
P61/CLK0
P62/RxD0
P65/CLK1
P66/RxD1
P71/RxD2
P72/CLK2
P44/CS0
P45/CS1
P46/CS2
P47/CS3
P52/RD
P63/TxD0
P67/TxD1
P70/TxD2
P54/HLDA
P55/HOLD
P60/CTS0
P64/CTS1
P51/WRH
P53/BCLK
P57/RDY
P50/WRL
R515 LCDCI/LED3
UP/LED4
LED4
10K DOWN/LED5
LED5
LED6
CP518 1K*2 51 25 LED6
LED7 AFCK LED7
P41/A17 P73/CTS2 LED7
LED6 52 24 CP506 1K*2 AFDT PLL_DT
53 P40/A16 P74/TA2out 23 PLL_DT
DOWN/LED5 Q501 PLL_CK
CP517 1K*2 54 P37A15 P75/TA2in 22 PLL_CK
UP/LED4 CTC_PLL DTC114EE SLED
CP516 P36/A14 P76/TA3out SLED
LCDCI/LED3 55 21 1K R505 SPMute PLED
1K*2 56 P35/A13 P77/TA3in 20 PLED
LCDCL/LED2 CTC_OUT C501 15p 8RC
57 P34/A12 P80/TA4out 19 8RC
2
LCDCE/LED1 1K R506 SBC APCO
CP519 1K*2 P33/A11 P81/TA4in APCO
LCDBL/LED0 58 P32/A10 P82/INT0
18 1k R632 AUX1 8TC
8TC
RLED C507 59 17 1K R612 X501 T/R
12
60 P31/A9 P83/INT1 16 9.8304MHz T/R
0.1U AFRDF PLL_UL
ACC P84/INT2 UL
GLED 61 P30/A8
30622M4
P85/NMI
15 PLL_LE
PLL_LE
62 14 R507 5.1K C502 AFMute
1
63 VSS VCC 13 AFMute
27P P4
P27/A7 IC502 XIN P4
64 P26/A6 VSS
12 DGND C503 P3
P3
65 11 680 DGND P2
66 P25/A5 XOUT 10 P2
DGND RESET R510 27P P1
CP515 67 P24/A4 RESET 9 P1
PLL_DT Volume
P23/A3 P86/Xcout Volume
PLL_CK 68 8 CP508 1K*2 PA C538 C539 TEMP
69 P22/A2 P87/Xcin 7 TEMP
SLED SQL
1K*2 70 P21/A1 CNVSS 6 1000p 0.1u L502 SQL
PLED R508 TI
P20/A0 BYTE 601S TI
8RC 71 5 5.1k AFSCLK
72 P17/INT5 P90/TB0in 4
0
8TC CP509 1K*2 AFDIO
73 P16/INT4 P91/TB1 3
T/R 2T/5T
P15/INT3 P92/TB2in
74 2 DT/2T 32
GND
75 P14/D12 P93/DA0 1 Apc/Sen J504 31
P13/D11 P94/DA1
R523 47K R512 2 30
99 P96/ANX1
100P95/ANX0
AT24C256N10SI2.7
98 P97/ADtrg
10k R509
87 P107/AN7
88 P106/AN6
92 P102/AN2
93 P101/AN1
95 P100/AN0 SP2 SP1
89 P105/IN5
90 P104/IN4
91 P103/IN3
5
6
7
8
CP510 1K*2 0 1 29
76 P12/D10
77 P11/D9
78 P10/D8
79 P07/D7
80 P06/D6
81 P05/D5
82 P04/D4
83 P03/D3
84 P02/D2
85 P01/D1
86 P00/D0
SP1 SP2
97 AVCC
94 AVSS
96 VREF 28
R524 47K AF JACK COM 27 J501
GND SDA
TEST
VCC
SCL
AF_O
PA1
DET
26
PA2
TI
DI
25 32PIN
IC501
B DGND 24 B
I\G\N
CP513 PWR
R622
R607
0.1u DGND 22
R621
D501 PLED
21
R521
R600
R522
R606
R608
MA2S111 SLED
RSSI
PCO
20
BS
4
3
2
1
601S
P1
5C
RESET 19
0
P2
0
DGND 0 NC NC 0 18
P3
NC R590
NC R592
17
R591
0 0 0
L505
P4
R516 33K 16
1K*2
0 R620
15
1K*2
R514 NC VI
TXD1/PTT14
AUX4
AUX3
AUX2
AUX1
TXD1
TXD2
RXD2
R519
MIC2
CP524 100K C504 RXD1/HOOK
13
ME
R609
R610
RXD1
1K*2
CP512
PSW
11
VO
1K 1K 10
Q503 Q502 9
2SK1824 MIC
8
CP514
DTC114EE ME
IGN 7
E200 TXD
6
MICDAT
IGN
5
FP101
E200 RXD
4
15
BS
1
R518 0.01u 0.5A 3
PLL_UL
PLL_LE
C506
AFMute
GND
0 FP102
AUX3
TEMP
APCO
RSSI
Type
PSW
1
SQL
IGN
AUX4
AUX3
AUX2
AUX1
TXD2
ING
SB
PA2
PA1
DET
RXD2
AF_O
E
ME
MIC2
5C
P4
P3
P2
P1
TI
0.5A
0
J503
96
A A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
TM-610 TM-600V
VHF Schematic
车载台(B版 Diagram
) PLL电路(PLL Unit)
D D
IC803
XC62FP3302P
L803 R808
2 3
5C Vin Vout
GND
601S 22
L801
601S
TP803 VR801
1
C810 C811 68K C830
R803 4.7u/6.3v R832
1000p DI
10 C806 IC802 16.8M 2.2k
4.7u/6.3 1000p C807 L802 R807 4.7u/6.3v
C804 3 4 180K
RF Xout VC
0.56u
1000p C825
C805 R804 2 1 R828 R829 R830
1000p Ognd MB CTC_PLL
R801 10K 56 22K 15K
100K C826 C827 4.7u/6.3v
C802 C803 3P NC R806 R827
C809
1000p 0.1u 100K 120K C823 C824
1000p 0.018u 0.015u
R802 1K
1
MA2S111 C808
C C801 D801 R805 C
0.1u 5.6K
GND
LD
Do
Vp
XIN
XOUT
FIN
Vcc
1000p
16.8M
IC801 R831
T801 MB15A02 C812 601S T802
C828
1000P R809 4.7U/16V
CLOCK
470
DATA
FOUT
R820
NC
100K R821
FC
LE
R
R810 R817
P
R819
R826 1K 1.5K 1.5k 0
UL D802 5.6K CV
9
10
11
12
13
14
15
16
R825 1K HZU5ALL R811
PLL_CK 22K R818
C816
R824 1K 2.7K
PLL_DT 0.1u/35v
Q802 C814
R823 1K R816 0.047u/35V
PLL_LE 2SA1832(GR) 2.7k
C822 C821 C820
C813 C815
1000p 1000p 1000p 5P 1u/16V
Q803
R812 2SC4738(GR)
0
R813
18K
B R814 R815 B
10K 0
Evco
8C
Q801
2SC4116 C
2 3
C E
R822 B B E
C818 D803 4.7K C817
1000p MA2S111 1000p 2SA1832
2SC4738
1
C819
10u/16v
A A
97
1 2 3 4 5 6 7 8
1 2 3 4
8C
IC602
TA7805F
1 3
Vin Vout 5C
GND
IC601
TA7808S C603 C604
2
3 1 4.7u/10v 0.01U
C BS Vin Vout C
GND
C601
4.7u/16v C602
0.1U
2
Q601
2SB1132
8R
Q602
DTC114EE
R601 R602 C605
47k 4.7k 1000P
B 8RC B
Q603
8T
2SB1132 Q604
DTC114EE
R603 R604
47K 2.2k
C607
10u/16v C606
0.01U
R605
8TC
0
C608
1u/16v
A A
98
1 2 3 4
1 2 3 4 5 6 7 8
B+
15K
POUT
C236
VGG
VDD
RA30H1317M
PIN
1000p
ANTENNA
L131
L132
C106 C104 C102
4P 8P NC
C218 C220 R195
12P 22
8C L129 D104 L104
601S C223 C235 C232 L130 UMX9401F L103 L102
8C C234 5T 5T 5T 5T
D Q109 1000P D
R174 2SC3357 0.1U
100 C219 R196 1000P 1000P C108
C212 R194 47U/25V 1000P
C202 39P 4P C107 C105 C103 C101 L101
0.1u Q110 270 270 C231 C230 10P 22P 18P 10P 11T
C205 C206 R183 C207 2SC3357 R188 R192 18P 27P 112nH
1000P 27P 33 1000P L127
33N 2.2K L128 470 L133 C109
C203 68N 6T 0.3P(B)
1000P C213 R190
TP104 L122 18P 2K
R175 R177 R191 R201
82N 330 D115 R182
18K C204 3 L125 L126 R184 R185 18 120 0.5W C110
15P 3 R193
2 56N 56N 180 2.2K R186 R189 C215 C221 C111 0.3P(B)
2 180 C211 22 0.5W D118 D101
1 D116 10K 1000P C222 0.5P(B)
1 1SS355 1000P MA3J742
R187 C210 C229
UDZ175.1B
22
C200 1000p Q101 DAN235E 47 1000P 10U/16V 0.1u C226 C227 C228 1000P
2SC5108(Y) C216 C217 1000P 0.01U 0.01U
OSC 1000P C112
C208 1000P R109
R179 1000P C113 0.5P(B)
47K D102
4.7K
1000P MA3J742
C201
R176 1000P R181 D117
R178 100 R101
10K 47K
330 IC104 D103
R180 100k R105 R103 R102
C209 C214 R108 100KR104
1000P 1000P MA3J742 C224 330K + - 1SS355 47K 47K
8T
C182 L119 R172 0.047u C115 C114
R170 100N 220 + - 100K 1000P
R168 C191 1000P
R167 1000P C187 C188
100 68K
33 10K C185 3P 3P 8 1 R106
VR101
TA75W01FU 0
1000P
L120 L121 R10710K
15P
C183 Q102 39N 39N C118
2SC5108 C225
L105 5T L106 56nH
C186 C189 C190 R203 R110
1000P
1000P 56 0 C116 9p
R171 15P 27P 15P 1000P TH102 R113 22P C119 1p
C R169 4.7k 8.2K-NC C117 C
C196 C198 2P(B) 15K-NC
47 C184 R173 Q108 D105 15P
C237 R111 UMX9401F
100 DTC114EE-NC 10K C120 D107
1000P R112
0.22u 100K
RF L123 L124 27P
1SV279
R118
NC 39N R114 1M
C195 8C C122 C121
NC C197 C193 C194 220-NC PCO 2P
1000P
5C 18P 18P 1000P L107
56nH
C241 C123
WCON 1u/16V C240
R161 CF203 R159 IC103 0.01u 1000P TC101 6P
22K 450KHz-E 22K R117 1 5
Apc/Sen +V R119
220
C168 R148 C238 2 1M C124
100K 1000P 27P D108
0.1u L112 3 4
D114 D113 180N C199
5R 1000P TA75S01F 1M 1SV279
R120
8R
CF202 R116 R115 C125 C127
DAN222 450KHz-G DAN222 C154 100K 100K C246 C140 L108
1.5p
R163 2.2u/10V C239 R131 R130 56nH
R160 0.01u 1000P 1M 1M C126 1000P
4.7K 0.1u 1000p
4.7K
C167 R162 R158 C165 C128
R143 L136
22K 22K 3p
0.1u 0.1u 180 T101 TP103 601S
R157 D112 R129
10 UDZ175.1B C142 47
4.7u/6.3v L135
L134 C129 D109
NCON 601S
10U
R140
C136 C135
C169 XF200 L113 39P 1SV279
C152 49.95MHZ C148 0 R128 1000p 0.1u C130
560nH
0.1u R142 4 1 R141 L109 1K
B B
56nH 1000p
330 330
C163 C164 C243 R145 0.01u 0.01u Q112
4
C170 220p 0.01u 1K C151 C149 L114 C141
5
6
3
2
0.01u NC 2.4P 3SK318
C150 560nH 1000p C137
10u/6.3V R132 L110 R127 0 R126
C162 C153 3 R123 R121
R144
4
R155 C174 13P 2 0 82nH 0 180K 180K
R156
3.9K 560K 47K 1.5P Q111
0.1u NC 33p R139 R138 C138 3
1
39p C134 3SK318
C171220p 33 4.7K 2
Q113 C144
R137 C145 L111 33p 1P C245
1000p
8
1
C146 C139 56nH
C147 1.5P
R154 1000P 1SV279 D110 R124
VCC
FILO
MIXO
OSCO
DEC
IFI
FILI
OSCI
R136 R133
E200 RX_INT
NDET
NREC
C173
MIXI
RSSI
IFO
3.3K
16
C179
0.1u
99
1 2 3 4 5 6 7 8
1 2 3 4
NC
D704 R704 1K R712
3
Q701 33
2SK508NV(K52) C726 L710 R715 C721
D
L701 1SV282 C702 C704 1000P 100N 330 1000P
D703 2
G
S
C723
0.75P
3.3U
1SV282
C703
C706
C705
220P 220P C709 R713
15P
C C
35.5N
R703
D701
D702
L703
9P
L702
220K
3.3U
C722
1
NC
10K
R701
C701 100 15P 1000P
1SV278
TC701 C707 1P Q703
D705
6P 9P 2SC5108(Y)
3.3U
L704
1000P C708
R702 1000P R714
390
0
OSC
R719 C725 C724
68K 47p R718 NC R717 MOD MOD
22K
10U 10V
R716 Evco
2
C710 R705
100K CV
1K
C
C716 1 R711
C720 B T/R
L708
1000P
2.7U
4.7K
E
1SV282 1000P 1000P
L705 D708 R706 Q704 R710
B C715 15P B
2.7U 2SC4116 4.7K
3
100 R709
1SV282 C711 C717 10K
D709 L707 35.5N 1P
2
R708
C712
47P
0.1U 4.7K
1SV282
1SV282
C713
L709
C714
2.7U
C
R707
D706
D707
L706
1 R720
2.7U
C719
15P 15P 220 4.7K
TC702
Q706
1000P
1000P
E
C718
6P
Q705
DTC114EE
Q702 2SC4116
3
2SK508NV(K52)
A A
100
1 2 3 4
B
C
A
D
1
1
1
3
1
3
Q306
Q305
HSB321
HSB321
2
2
R345 R346
15K
1.2K
VI 2
VO
1
CM
100 R321 2
H00K/RXD
3 3 1
MIC
4
ME
0 R320 5 4 5
PTT/TXD
J301
6
2
2
100
100 R344 GND
R341
0.5A FP102 7
BS
L301
8
MBL k301
1k R340
0.5A
FP101
0.22u
R343
NC
5c
0
330
R301
1
5C
J302
L302 0.22u
2
32PIN
GND
3
4 BS
5
6 MICDAT
S307
LED309
LED306
1
8 ME
S306
S305
S304
S303
S302
S301
9 MIC
3
3
10 GND
1
11 VO
2
LED310
LED307
12 PSW
13 RXD2
ON/OFF
P4
P3
P1
UP
P22
14 TXD2
DOWN
15 VI
16 Type R319
LED311
LED308
17 P4 100K
18 P3
19 P2
20 P1
21 SLED
22 PLED
23 RLED
24 GLED
Q301
25 LCDCE/LED1
26 LED7
TM-610 UHF/VHF
27 LCDBL/LED0
DTC114EE
28 LCDCL/LED2
10K
4
4
R304
29 DOWN/LED5
30 LCDCI/LED3
31 LED6
32 UP/LED4
GND
0
LED304
10K
R342
27
101
C301
TM-610 UHF/VHF
2SB1132
470P
LED303
LED302
470P
R306 C302
Q302
3.9K
R307
Schematic
18K
D303
R308
470P
C304
HSB123
5
5
Q303
red
DTC114EE
R310
120
1 2
5c
原理图
3 4
120
green
R311
5C
LED
LED301
Q304
DTC114EE
18K
R313
Diagram
S601
L303
1.5K
LCD301
R315
38 C1
37 C2
S01 1
S01
C1
S02 2
6
6
S02
S03 3
1.5K
C2 LO
R316
S03
S04 4
(显示单元)
S04
S05 5
S05
S06 6
S06
S07 7
S07
S08 8
S08
S09 9
S09
S10 10
S10
S11 11
S11
S12 12
S12
TM-610 UHF/VHF 原理图 (显示单元)
S13 13
S13
S14 14
S14
S15 15
S15
S16 16
S16
S17 17
S17
S18 18
A
16
15
14
13
12
11
10
S18
9
8
7
6
5
4
3
2
1
S19 19
(Display Unit)
S19
S20 20
S20
17 64 S34 S21 21
V
A1 S33 S21
A0
7
7
n.c.
n.c.
n.c.
S39
S38
S37
S36
S35
S34
18 63 S33 S22 22
SCL
OSC
CLK
SDA
A2 S32 S22
VDD
SYNC
19 62 S32 S23 23
SA0 S31 S23
20 61 S31 S24 24
VSS S30 S24
21 60 S30 S25 25
SCN
C2 27 54 S24 S31 31
BP1 S23 S31
C4 28 53 S23 S32 32
BP3 S22 S32
S01 29 52 S22 S33 33
S0 S21 S33
S02 30 51 S21 S34 34
C4
C3
S1 S20 S34
S03 31 50 S20
S2 S19
S04 32 49 S19
n.c.
n.c.
S10
S11
S12
S13
S14
S15
S16
S17
S4
S5
S6
S7
S8
S9
S3 S18
C4 35
C3 36
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
8
8
S05
S06
S07
S08
S09
S10
S11
S12
S13
S14
S15
S16
S17
S18
B
C
A
D
1 2 3 4 5 6 7 8
R440
R436 33k C447 VO
C450 R625 20k
DET
1u 0
47P
1
C468
R480 R481 R485 0 1u R486
R434 Q406
NC 0 IC402 NC
1
BEEP 18k MIC
-
2sk1824 R455
TC75W51FU
+
0 R488
0.1u NC
+ -
R401 R402 R403 C444
DT/2T
8
C448
R435
10k C467 C449
18k
10k C403 4.7u/6.3v 1u
4.7k 1uF 1uF
C402 C443 R439
8
C401 R404 C445
R405 R482 R433 C446 1k
0.01u 4700p 15k 1000p
47k 56k 33k NC 470p R441
C405 22k
0.1UF
C404
PA
R438 33k
R408 R409 0
15k 22k R406 R407 R442 R443
CTC_OUT Q405
330K 2.7K R479 22k 91K
NC 2SK1824
C410 C409 C419 C439 R444
0.015u 0.018u R454 68K
47k 330p C437
C411 0.68U 1u
R410
8
2SC4617 C438 1u
0.1u C440
DI C406 C442
15K Q401 R453
4.7U/6.3V 0.1UF C420 470pF 1k R445
R412
+ -
1000p
R424 R425
C441
C408 C407 0.47u 22k
R411 0.1UF 220 10k 0 IC405
MOD
68K R413
+
R483 R484 TC75W51FU
1U 56K
NC 0
此处特殊接地
-
C416 C421 R428 C422
C 2200p 560p 10k 0.47u C
R414 ME
C436
1
1u R449 R447 0.027u R446
6.8K
R422 10k 4.7k 150k
R426
PA R423 R427
10k
C418 100k
Q402 330k 10k C417 C435
1u
C424 47p
DTC114EE IC401 4.7u/6.3v R448
C423
R456
C415 AK2346 0
68k
33p
1 24 R452
C412 AGNDIN TEST R457
R420 R421 22K
1U AGND RXIN C425 0
51k 27k 33p R451 0
TXIN RXINO R429
R418 R419 C414
TXINO RXLPFO 150p 56k
10k 0 1uF
LIMLV RXAF
EXTLIMIN RXAFIN R450
C426 0.027u C434
MOD EXPOUT 56k R430 10k D402
C413
C432 47p 1u
TCLK XIN C427
R415 R416 C430 Q404 470p
3.6864MHz
TDATA XOUT 22p RB706F-40->NC
NC 8.2K R431 0.1u 2SC4116(Y)
DI/O DIR C466
12 13
RDF/FD SCLK 390k MIC2
X402
C428 C429
NC 15u/6.3v R487
R417 NC
6.8k Q403 22p
2SK1824
NCON R432 33k 8C
C903 NC
R458
0.01u C431 D401
AFCK R462 R461 22k
MA742
82k 180k
AFDT
C460
1k 0.068u
IC403 180k
2700p
R471 C451 IC404 C454
R467
AFDIR
100k
1 8 12k 180p 1 8 0.012u
R477 R473
B AFSCLK 10k 1M C458 B
R475
150k
R474 - + 1000p - +
2T/5T 8.2k
+ - R470 R469 R468 + - R460
R472
4.7u/6.3v
TI 10k 10k 4.7k 100k 180k
0.01u
C456
R465 R464
C457
AFMute 15k 10k
TC75W51FU C462 TA75W558FU C455
R478
MicMu C465 C464 1000p 2200p
150k
0.01u 4.7u/6.3v C463 C461
0.1u 180P
A 102 A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
Q521
R573 2SK1824
PA
4.7K
C537
0.1u
BS
R575
VI
0
R624 C531
Q511 0 1000P
BEEP/ALT C511
R571 R572 2SK1824 Q512 D516 D515
BEEP 22ZR-10D
DSM3MA1
4.7K 47K 2 3
2SA1641(S.T)
C E B+
0.1u
0.1U C532 R570 C526
B
R543 C530 0 D517 1000P
SPMute C533 R551 R568
4.7K C534 1000P 4.7K 1000P 1SS355 C527
R544 R545 47U/25V 1K 470U/25V
1
C512 47K 47K DTA114EE
0.01u Q519
C R569 C
13.55V C529
0 C528
EXTSP C513 C514 R552 1000P 0.1U
J511 1u 1u 470 0.5W D518
C515 C516 02DZ15(X.Y) Q520
DTA114EE DTC114EE
0.01u 0.01u Q513 C525 Q518
DTC114EE 0.1U
R564
10
1
2
3
4
5
6
7
8
9
0
R553
0 6.22V R554
D511 1
Q1 Vdd
14
C536 1SS355
STAND-BY
PW GND
PW GND
IN1
MUT
OUT1+
N.C
N.C
OUT1-
VCC
PW GND
OUT2-
ON:0.02V
SGNG
OFF:13.2V
N.C
N.C
N.C
C521 C520
D512
02DZ18(X.Y)
0.1U 0.1U Q515 Q516
C519 C518 DTC114EE R561
B PSW B
47K
R558
R549 R548 10K
10 10 DTA114EE
写频软件选中后,高电平开机、低电平关机。
C522 D513
PA1 R560
C517
IGN
1u/16v 1K
PA2
0.22U 1SS355
R550 R559
APCO 100K
47K Q517 1710B
R574 DTC114EE D514
NC
103
A A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
CP501
RXD1
1K*2
RXD1
CP521
CP502
MICDAT MICDAT
MICDAT
5.1K
1K R503
SHIFT
SHIFT
CP520 1K*2 WCON
WCON
R502
1K*2 CP504 MicMu
30 R611
RXD1/HOOK MicMu
1K RXD1 RLED
38 R628
RLED
TXD1/PTT TXD1 GLED
42 1K*2
GLED
35 1K*2
0 R501 100 AUX1
R513 0 AUX1
0 R627 LCDBL/LED0
LCDBL/LED0
AFDIR SHIFT LCDCE/LED1
50
49
48
47
46
45
44
43
41
40
39
37
36
34
33
32
31
29
28
27
26
LCDCE/LED1
C 1k R504 LCDCL/LED2 C
LCDCL/LED2
LCDCI/LED3
P42/A18
P43/A19
P56/ALE
P61/CLK0
P62/RxD0
P65/CLK1
P66/RxD1
P71/RxD2
P72/CLK2
P44/CS0
P45/CS1
P46/CS2
P47/CS3
P52/RD
P63/TxD0
P67/TxD1
P70/TxD2
P54/HLDA
P55/HOLD
P60/CTS0
P64/CTS1
P51/WRH
P53/BCLK
P57/RDY
P50/WRL
LCDCI/LED3
10K R515 UP/LED4
LED4
DOWN/LED5
LED5
LED6
LED7
CP518 1K*2 51P41/A17 25 AFCK LED7
LED6
LED6 52P40/A16 P73/CTS2 24 CP506 1K*2 AFDT PLL_DT
LED7
DOWN/LED5 53P37A15 P74/TA2out 23 Q501 PLL_CK
PLL_DT
UP/LED4
CP517 1K*2 54P36/A14 P75/TA2in 22 CTC_PLL DTC114EE SLED
PLL_CK
LCDCI/LED3
CP516 55P35/A13 P76/TA3out 21 SPMute PLED
SLED
LCDCL/LED2
1K*2 56P34/A12 P77/TA3in 20 1K R505
CTC_OUT C501 15p 8RC
PLED
57P33/A11 P80/TA4out 19 8RC
2
LCDCE/LED1 SBC APCO
LCDBL/LED0
CP519 1K*2 58P32/A10 P81/TA4in 18 1K R506
AUX1 8TC
APCO
RLED C507 59P31/A9 P82/INT0 17 R632 1K
X501 T/R
8TC
60ACC 16 1K R612
12
P83/INT1 9.8304MHz T/R
0.1U AFRDF PLL_UL
GLED 61P30/A8 30622M4
P84/INT2 15 PLL_LE
UL
62VSS P85/NMI 14 R507 5.1K C502 AFMute
PLL_LE
63P27/A7 13
1
VCC AFMute
27P P4
64P26/A6 IC502 XIN 12 P3
P4
65 VSS 11 DGND 0 DGND P2
P3
DGND 66P25/A5 XOUT 10 RESET P1
P2
PLL_DT
CP515 67P24/A4 RESET 9 R510
C503 27P Volume
P1
PLL_CK 68P22/A2
P23/A3 P86/Xcout 8 CP508 1K*2 PA TEMP
Volume
SLED 69 P87/Xcin 7 C538 C539 SQL
TEMP
PLED
1K*2 70P21/A1 CNVSS 6 R508
L502
TI
SQL
8RC 71P20/A0 BYTE 5 5.1k AFSCLK 1000P 0.1u 601S TI
72P16/INT4
P17/INT5 P90/TB0in 4
此电阻烧录时才贴上
0
8TC CP509 1K*2 AFDIO
T/R 73P15/INT3 P91/TB1 3 2T/5T
74P14/D12 P92/TB2in 2 DT/2T J504 32
75P13/D11 1
GND
P93/DA0
Apc/Sen 2 31
P94/DA1 SP2 SP1
R512
R523 47K 1 30
P96/ANX1
P95/ANX0
AT24C256N10SI2.7
99P97/ADtrg
88P107/AN7
P106/AN6
93P101/AN1
P102/AN2
96P100/AN0
SP1 SP2
AF_O
89P105/IN5
91P104/IN4
92P103/IN3
PA1
DET
5
6
7
8
CP510 1K*2 0 29
76P12/D10
PA2
TI
77P11/D9
78P10/D8
80P07/D7
81P06/D6
82P05/D5
83P04/D4
84P03/D3
85P01/D1
P02/D2
87P00/D0
98AVCC
DI
95AVSS
97VREF
R509 AF JACK COM 28
R524 47K 10k 27 J501
100
GND SDA
TEST
VCC
SCL
26
79
86
90
94
I\G\N
R622
R607
PWR
25 32PIN
R621
IC501
DGND 24
R600
R606
R608
RSSI
PCO
C505 L503 601S 23
A2
A1
A0
BS
5C
0.1u DGND 22
0
D501 PLED
0
0 NC NC
CP513
0 21
R520
R521
B B
R522
MA2S111 SLED
0 R590
NC R592
20
R591
4
3
2
1
601S
P1
RESET 19
P2
0 R620
DGND 18
NC P3
0 0 0 17
AUX4
AUX3
AUX2
AUX1
L505
P4
TXD2
RXD2
MIC2
R516 33K 16
ME
R517 47K Type
601S
15
1K*2
R514 VI
TXD1/PTT
1K*2 CP512
14
R609
R610
47K 0.1U 12
L504
PSW
1K 1K CP524 11
VO
1K*2 10
Q503 Q502 9
2SK1824 MIC
8
CP514
DTC114EE ME
IGN 7
15
MBL
1
6
MICDAT
5
IGN
4
AUX5
AUX4
AUX3
TXD2
IGN
SB
RSSI
DET
RXD2
AF_O
E
DI
PCO
ME
MIC2
R518 0.01u 3
PLL_UL
PLL_LE
C506
AFMute
GND
0
AUX3
TEMP
APCO
RSSI
Type
PSW
1
SQL
IGN
P4
P3
P2
P1
TI
J503
FP101
0
BS
0.5A
FP102
5C
0.5A
104
A A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
TM-600/610 U (3组5音)PLL电路
IC803
XC62FP3302P
L803 R808
2 3
5C Vin Vout
GND
601S 22
L801
601S
TP803 VR801
1
68K
C810 C811 C831
R803 4.7u/6.3v R832
1000p DI
22 C806 IC802 16.8M 2.2k
4.7u/6.3 1000p C807 L802 R807 4.7u/6.3v
C804 3 4 180K
RF Xout VC
1.2K
1000p C825
C805 R804 2 1 R828 R829 R830
1000p Ognd MB CTC_PLL
R801 10K 33K 22K 15K
C 100K C826 C827 4.7u/6.3v C
C802 C803 10p 10p R806 R827
C809
470p 0.1u 100K 120K C823 C824
1000p 0.018u 0.015u
R802 1K
1
MA2S111
C801 D801
0.1u C808
R805 2.2K
GND
LD
Do
Vp
XOUT
XIN
FIN
Vcc
1000p
L804 16.8M
IC801
601S
T801 MB15A02 C812
C830 C829
C828
T802
4.7U/16V
470P R809 1000p 0.1U
CLOCK
0
DATA
FOUT
R820
NC
FC 100K R821
LE
R
R810 R817
P
R819
R826 1K 1K 1.5k 10K
UL D802 10K CV
9
10
11
12
13
14
15
16
R825 1K HZU5ALL R811
PLL_CK 22K R818
C816
R824 1K 1.2K
PLL_DT 0.1U/35V
Q802 C814
R823 1K R816 0.047u/35V
PLL_LE 2SA1832(GR) 1K
C822 C821 C820
B C813 C815 B
470p 470p 470p 3P 3.3u/16V
Q803
R812 2SC4738(GR)
0
R813
22K
R814 R815
10K 0
Evco
8C
Q801
2SC5343E C
R822
C818 D803 4.7K C817 B E
470p MA2S111 470p
2SA1832
2SC4738
C819
10u/16v
A A
105
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
D
TM-610 UHF Schematic
TM-600/610 U(3Diagram (Power
组5音)POWER 电路 Unit) D
8C
IC602
TA7805F
1 3
Vin Vout 5C
GND
C IC601 C
TA7808S C603 C604
2
3 1 4.7u/10v 0.01U
BS Vin Vout
GND
C601
4.7u/16v C602
0.1U
2 Q601
2SB1132
8R
Q602
DTC114EE
R601 R602 C605
47k 4.7k 1000P
8RC
Q603
8T
2SB1132 Q604
B DTC114EE B
R603 R604
47K 2.2k
C607
10u/16v C606
0.01U
R605
8TC
0
C608
1u/16v
A 106 A
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8 9 10 11 12
TH101
Temp
IC101
发射电路
B+
15K C236
POUT
VGG
VDD
RA30H4452M
PIN
1000p
L131
L132
ANTENNA
L104 NC
C104 C102
1P 1P
C218 C220 R195
5.6
C
6P L129 D104
601S C223 C235 C232 L130 MA4P1250 L103 L102
C234 2T 3T 3T
4P Q109 1000P
C
B 2SC3357 0.1U
B C219 R196 470P 470P C108 C105 C106 C103
C212 47U/25V C107
E
R194 470P
C
2P C101 C100 L101
Q110 820 820 C231 C230 NC 2P NC 5P 11T
2SC3357 R188 R192 3P 5P C109 2P 112nH
E
L127
C
B 10N 1.2K L128 470 L133 NC
TX B 6T 0.5P(B)
10N
E
C213 R190
68P 47
R191 R201 C111
E
18 120 0.5W
3
R185 R193 C110
2.2K R186 R189 C215 C221 0.5P(B) 0.5P(B)
C211 22 0.5W D118 D101
D116 10K 470P C222
3
1SS355 470P MA3J742
R187 C210 22 C229
UDZ175.1B
1
18 470P 0.1U/16V 0.1u C226 C227 C228 470P
C216 C217 470P 0.01U 0.01U
3
C208 470P 470P C112
1
R109 C113 2P(B)
470P
D102
1.5K
3
470P MA3J742
1
R181 D117
1K R101
TXSW 220K 22K
IC104 D103
1
R180 100k R105 R103 R102
C209 C214 R108
470P 470P MA3J742 C224 330K + - R104 1SS355 47K 22K
8T
0.047U C115 C114
+ - 100K VR101 470P
22K 470P
8 1 R106
C TA75W01FU 0 C
R107
C118
C225 100K L105 3T L106 15nH
R110
1000P
0 C116 11p NC C119
TH102 R113 2P C117
C198 8.2K-NC
C196 1P C199 15K-NC C182 3p
0.5P Q108 D105 1P D120
Lo C237 R111 MA4P1250 R128
DTC114EE-NC 15K
4p R112 C120
L123 10K NC NC
18N L138 0.22u HVC376B
0.75p
C248
18N 470P C121 L107
R114 8.2nH
C195
6P C197 C194 NC 8C PCO
C123
5R 10P 10P L124
22N 470P TC101
C241 6P
WCON C192 1u/16V C240
R161 CF203 R159 470p IC103 0.01u R119
22K 450KHz-E 22K R117 1 5
Apc/Sen +V 1M
220 D108
C168 R148 C238 2 5.6p C124
100K 1000P 1M
0.1u 3 4 R120 HVC376B
D114 D113
TA75S01F
8R 5R C127
R115 1.5p
CF202 R116 C125 L108
DAN222 450KHz-G DAN222 C154 100K 100K C239 C140 R118 C249
8.2nH
R163 R131 1M R130
R160 C250 0.01u 470P 1M 470P 1M C126 470P
4.7K 0.1u 2.2u/10v 470p
4.7K
C167 R162 R158 C165 C128
R143 R127 L135
22K 22K 3p
0.1u 0.1u 180 22 T101 TP103 601S
R157 D112 R129
10 UDZ175.1B C247 15 C129 D109
4.7u/6.3v L137
L134
NCON 601S
10U R140
1K C135 C136 5.6p HVC376B
C169 XF200 L113
C152 49.95MHZ C148 330nH L109 0.1U 470p C130
0.1u R142 4 1 R141 22N R204
NC 470p
100->470 470
C163 C164 C243 R145 0.01u 0.01u Q112
4
C170 220p 0.01u 1K C151 C149 L114 C141
5
6
3
2
0.01u 4p NC 3SK318
C150 560n(PN:03265610) 470p C245 C137 C122
10u/6.3V L139 R126 0
C162 C153 3 R123 R121
R144
4
R155 C174 15p 2 39nH+ 180k 180k
R156 12P
C246
10K 470K 47K NC 18P 1.5P C134 Q111
0.1u NC 33p R139 R138 C138 L110 3
1
B 3SK318 B
C171220p 33 4.7K 5.6P 8.2nH 2
Q113 C144 5.6P
R137 C145 L111
0.1u 470P
8
1
C146 C139 8.2nH
C147 D111 6P 8.2nH 12P 470P
4P NC
R154 470P TC102 C133
FILI
OSCI
DEC
HVC376B
FILO
IFI
OSCO
MIXO
VCC
QUAD
R136 R133
NREC
NDET
C173
MIXI
RSSI
IFO
20p C160
AF
3.3K
16
C179
0.1u
107
A A
1 2 3 4 5 6 7 8 9 10 11 12
1 2 3 4 5 6 7 8
D D
8C
8C
D704
1SV282 R174
100
L711 C704 R704 33 R712 C202
1U 3.6P 33 0.1U
D703 Q701 C726 L710 R715 C721 C205 C206 R183 C207
C L703 470P 220 470P 470P 10P 33 470P C
L701 NC C702 2SK508NV(K52) 18N
120P 18N TX
3 1 C203
D S 1000P
1U C703 C723
1SV282
G
D701
D702
47 3 R184
TC701 2.4P 3P 0.5P Q703 15P 2 15N 15N
2 2 180 180
6P D705 2SC5108(Y) 1
L704 1
1SV278 1U
C708 C200 Q101 DAN235E
R702 470P 2SC5108(Y)
330 C755
C724 470P 470P R179
R718 R717 MOD MOD
47K
100K 15K C201
10U 10V R167 R176 1000P
Evco R178
2
R716 10K
R705 33 220 TXSW
C710 100K
CV
470P 220
C
1 R711
C716 B T/R Lo
L708
C720 4.7K
E
1U
3
1U R709 10K 18 10K 470P
C185 2P 2P
1SV282 C717 RF
C711 2SK508NV(K52) 8P
D709 68P L707 18N 0.5P
L120 L121
R708 4.7K
C712 C183 Q102 15N 15N
L706 10P C714 L709 470P 2SC5108
D706 D707 1U C713 Q702 5P 1U R707 R720 R203
1SV282 NC 6P 270 C718 4.7K C719 C186 C189 C190 56
TC702 Q706 R171 6P 10P 6P
6P 470P Q705 470P DTC114EE R169 4.7K
2SC4116 47 C184 R173
150
470P
GND
B B
A A
108
1 2 3 4 5 6 7 8
TM-610 Service Manual
Specifications
General
Standby 0.2A
Current
Receive ≤2A
Drain
Transmit ≤8A(High Power); ≤5A(Low Power)
Weight 1.0kg
Receiver
Selectivity 75dB/70dB/65dB
FM Noise ≥45dB(25KHz/20KHz)/40dB(12.5KHz)
Transmitter
Spurious and Harmonics -36dBm (frequency below 1GHz); -30dBm (frequency above 1GHz)
FM Noise ≥45dB(25KHz/20KHz)/40dB(12.5KHz)
All Specifications are tested according to TIA/EIA-603, and subject to change without notice due to continuous
development.
86
109
TM-610 Service Manual
HYT endeavors to achieve the accuracy and completeness of this manual, but no warranty of accuracy or reliability is
given. All the specifications and design are subject to change without prior notice due to continuous technology
development. Changes which may occur after publication are highlighted by Revision History contained in Service
Manual.
No part of this manual may be copied, reproduced, translated, stored in a retrieval system, distributed, or transmitted in
any form or by any means, electronic or mechanical, for any purpose without the express written permission of HYT.
87